2004 BMW 3 Series Complaint Log

The contact owns a 2004 BMW 330CI. The contact stated that after starting the vehicle and shifting to the reverse position, the engine began to rev very high, and the vehicle suddenly experienced unintended acceleration and drove reverse into the side of the home. During the incident the vehicle the destroyed. No injuries were reported and no police report was taken. The vehicle was later towed to the local mechanic but the cause of the failure was not determined and no repairs were performed. The manufacturer and local dealer were not contacted regarding the failure. The failure mileage was 10,000.

I cannot use put my windows up/down, cannot open the trunk, cannot use interior lights, cannot unlock my gas lid. Due to a broke. Electronic part called the GM5

Unknown

The contact owns a 2004 BMW 325 CI. The contact stated that while driving at an undisclosed speed, the driver's side rear turn signal light became inoperable while attempting to make a turn. There was no warning light illuminated. The contact stated that the rear turn signal light failed to function properly. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear tail lamp functions had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 250,000.

Window rolled down, but never went back up. Happened on multiple windows of my vehicle. Has been a common problem among these cars, caused me to fail inspection.

While backing out of a short driveway and placed t to drive, the vehicle revved and started speeding out of control with brakes applied. The vehicle sideswiped a neighbors vehicle before crashing head on into a tree causing it to stop. I had jerked up the emergency brake and ripped the key out of the ignition. The replaced airbags did not deploy.

This car has factory HID Xenon projector headlights. Over time the reflector bowls burned and melted from the heat of the light bulbs, causing some wire insulation to melt, and a brown film to cover all surfaces inside the headlight assembly. The brown coating makes the headlights dangerously dim. From various online searches, it appears this is a common failing of these headlights. BMW has not recalled these headlights, and replacements nearly exceed the value of the car.

The contact owned a 2004 BMW 325i. The contact received notification of NHTSA Campaign Number: 20V018000 (Air Bags) and requested to be removed from the recall distribution list as she no longer own the vehicle. The local dealer and manufacturer were not contacted.

The contact’s girlfriend owns a 2004 BMW 325XI. The contact received notification of NHTSA campaign number: 20V018000 (Air Bags). The contact’s girlfriend took the vehicle to the local dealer for the recall repair. After the vehicle was repaired and the vehicle was retrieved, the air bag warning light was illuminated. The driver took the vehicle back to the local dealer for the warning light. The mechanic inspected the vehicle and informed the contact that the battery cable needed to be replaced. The contact was concerned that the failure was related to the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 89,000.

2004 BMW 325i. Inquiry on behalf of the constituent, in regards to getting assistance with his BMW. THE CONSUMER STATED THE EMISSIONS SYSTEM FAILED. MULTIPLE REPAIR ATTEMPTS WERE MADE. THE DMTL PUMP WAS REPLACED. THE CONSUMER REQUESTED TO BE REIMBURSED FOR REPAIRS.

Two hours after I got to work one of my coworkers came running in the backroom, And told me my car was on fire.

The contact owned a 2004 BMW 325XI. The contact stated while driving 45 mph, the vehicle was struck by another vehicle on the passenger’s side causing the passenger’s side mirror to detach from the vehicle. The contact loss control of the vehicle and crashed into the median. The vehicle rolled and then came to a complete stop. The contact stated that the air bags failed to deploy. Additionally, the dashboard collapsed and the rear-view mirror detached from the windshield. The vehicle was towed from the scene of the crash. The contact received injuries to the chest, ribs, neck, and breast for which medical assistance was sought. A police report was filed. The contact stated that the driver's frontal air bag was previously replaced under NHTSA Campaign Number: 15V318000 (Air Bags). The vehicle was destroyed. The manufacturer was not contacted or notified of the failure. The approximate failure mileage was 100,000.

The TAKATA airbags were replaced April 8, 2021, by Reeds Import, Tampa FL. Please save a tree and stop sending recall notices. Thank you. Mark

THIS CAR WAS SOLD TO US UNDER FALSE STATEMENTS,WIPER DISPENSER DOES NOT WORK ,KEY FOB DOES NOT WORK,NO TITLE ,THE CAR HESITATES AND VIBRATES,OIL LEAK,ODOMETER ON CARFAX SAYS 86000 ACTUALLY 111,402.WE WRWE TOLD IT WAS EXCELLENT CONDITION .THE CAR IS NOT. BOUGHT IT 3/10 21 7:00PM , CALLED 3/11 8;00 AM ASK FOR REFUND.THOUGHT WE HAD A 3 DAY GRACE PERIOD. THE DEALER LAUGHED NO. WE ARE SENIORS CITIZEN I GUESS HE THOUGHT HE HAD US. CREST AUTO WHOLESALERS OF S W FLORIDA. CRAIG WALLACE. WELL DRIVING IT STARTED TO VIBRATE. AND HUM? COULD NOT DECLINE GOOD. COULD NOT CLEAN WIND SHIELD.IT VIBRATES WHEN STATIONARY.DIDN'T KNOW UNTIL I STARTED DRIVING IT. THOUGHT IT WAS BECAUSE CAR COLD? BAD OIL LEAK. AND TIRES NEED BALANCED THOUGHT THAT WAS IT BUT NO.WHAT CAN WE DO OUT $4,500. FOR A CAR THAT'S NOT EXCELLENT IT SAYS ON CAR FAX.THIS HAPPENS ON STREET AND EXPRESS. HELP NOT A SAFE CAR.

AFTER RECALLED AIR BAGS REPLACED, ABOUT 6 MONTHS LATER NEW AIR BAG SENSOR LIGHT CAME ON AND DIAGNOSED AS PASSENGER SEAT AIR BAG SENSOR MAT NEEDS TO BE REPLACED. JUST RANDOMLY THE LIGHT CAME ON AND STAYED ON. I SEE THIS HAS BEEN A PROBLEM IN BMWS AND THERE WAS AN EXTENDED WARRANTY FOR OTHER MODELS. THIS SHOULD BE A RECALL AS IT IS A SAFETY ISSUE AS BAGS WILL NOT DEPLOY.

THE GROUND WIRE ON MY BREAK LIGHT HAS BURNED THROUGH THE 8 PIN CONNECTOR NOT ONLY IS THIS LIMITING MY ABILITY TO WARN OTHER DRIVERS IT IS A MAJOR FIRE HAZARD THIS WAS DISCOVERED DURING A RECALL SERVICE AT THE LOCAL DEALERSHIP I DO NOT BELIEVE. THE PROPER STEPS HAVE BEEN TAKEN TO REMEDY THIS PROBLEM AND IF THIS CAN NOT BE RESOLVED INFORMALLY I WOULD LIKE TO PURSUE FORMAL LITIGATION AGAINST ALL PARTIES INVOLVED AND FOR DISCOVERY PURPOSE ALL RELATED CORRESPONDENCE, VIDEO, AND RECORDED EVIDENCE SHOULD BE PRESERVED. CURRENTLY THE BREAK LIGHT IS NOT WORKING AND THERE ARE DEFECTIVE AND HAZARDOUS AIRBAGS.

i was driving about 35mph and hit a pot hole in the road. that caused my passenger front, passenger side door, and passenger aide door top to deploy.

TL* THE CONTACT OWNS A 2004 BMW 325CI. THE CONTACT STATED THAT UPON MAKING A RIGHT TURN AND A STOP, HE NOTICED THAT HIS RIGHT TURN SIGNAL HAD FLASHED ERRATICALLY UPON ACTIVATION. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HIM THAT THERE WAS A RECALL ON HIS VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 11V438000 (EXTERIOR LIGHTING). THE CONTACT CALLED CHAPMAN BMW CHANDLER (7455 W ORCHID LN, CHANDLER, AZ 85226) WHERE HE MADE AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED UNDER THE RECALL. THE DEALER CALLED BACK AND INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER THEN REFERRED HIM TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

I WAS DRIVING BY MYSELF ON THE FREEWAY AND A RUBBLE THE SIZE OF A BASKETBALL WAS ROLLING TOWARDS MY PATH. I DO NOT KNOW IF IT FELL FROM A CONSTRUCTION VEHICLE OR IT ALREADY HIT ANOTHER CAR AND THAT THE RUBBLE JUST RICOCHET TOWARDS ME. ANYWAY I WAS GOING 65 MILES PER HOUR AND WAS IN THE MIDDLE LANE AND THERE WERE CARS ON BOTH SIDES AND A CAR NOT TOO FAR OFF BEHIND. I NEVER HAD THE CHANCE TO AVOID THE RUBBLE SO I JUST BRACED MYSELF AND HOPE THAT THE RUBBLE WOULD GET PAST ME. UNFORTUNATELY, IT HIT MY LEFT SIDE AND ELEVATED MY CAR AROUND 2 TO 3 FEET FROM THE GROUND AND FLATTENED MY TWO LEFT TIRES. THE AIRBAG ON THE FRONT PASSENGER SIDE DEPLOYED, THE ONE ON THE DOOR AND THE ONE ON THE UPPER ROOF PANEL. NONE OF THE DRIVER SIDE AIRBAGS DEPLOYED. I JUST HAD A LITTLE WHIPLASH FROM THE IMPACT BUT I WAS FINE. I CONTACTED MY INSURANCE AND UPON INSPECTION THEY CONSIDERED MY VEHICLE A TOTAL LOSS DUE TO THE DAMAGES. I ALSO CONTACTED BMW AND HAVE YET TO NOTIFY ME OF WHY THE DRIVER SIDE AIRBAG DID NOT DEPLOY ON WHERE THE IMPACT OCCURRED. THEY DID A RECALL SERVICE ON MY VEHICLE AROUND MARCH 2020 FOR THE AIRBAG. AFTER THE SERVICE THERE WERE NO AIRBAG LIGHTS OR ANY WARNINGS ON THE DASHBOARD. IN THE EVENT OF THE ACCIDENT, MY VEHICLE WENT TO AN SOS MODE WHICH SLOWED DOWN THE VEHICLE AND AUTOMATICALLY TURNED ON THE HAZARD LIGHTS. I WAS ABLE TO PULL TO THE RIGHT SHOULDER OF THE FREEWAY AND HAD IT TOWED. HOPEFULLY THE CAR MANUFACTURER COULD SEND NOTICE TO OWNERS OF THIS CAR MODEL THAT COULD HAVE THE SAME ISSUE WITH AIRBAGS ON THE SIDE OF IMPACT NOT DEPLOYING.

RIGHT FRONT LOW BEAM HEADLAMP CUTS OUT INTERMITTENTLY AND EVENTUALLY STOPS WORKING DUE TO CRACKED WIRING INSIDE THE ADJUSTABLE HEADLAMP UNIT. FOR AWHILE, MY HEADLIGHT WOULD STOP WORKING WHILE MAKING A RIGHT TURN BUT THEN TURN BACK ON WHEN STRAIGHTENED OUT. AFTER TWO RIGHT TURNS, THE HEADLIGHT WOULD CEASE TO TURN BACK ON. NOW (AFTER SEVERAL WEEKS OF THIS HAPPENING) THE HEADLIGHT DOES NOT FUNCTION AT ALL, AND I CAN SEE BROKEN WIRING IF I LOOK INSIDE THE HEADLIGHT UNIT CAUSING THE ISSUE.

THE INTERIOR WIRES OF THE BMW E46 HEADLIGHT ASSEMBLIES HAVE INSULATION MATERIAL THAT READILY BREAKS OFF OF THE WIRE, CAUSING THE BEAR WIRE CONDUCTOR TO BE VISIBLE. THIS RESULTS IN A FAILURE OF THE HEADLIGHTS AS THE WIRES CONDUCTORS ARE ALLOWED TO TOUCH. THIS IS ALSO A POSSIBLE SOURCE OF A VEHICLE FIRE.

I CALLED MY DEALER LAST YEAR TO SCHEDULE TO FIX MY RECALL ON MY CAR. UNFORTUNATELY I DID NOT WENT TO MY APPOINTMENT. NOW ONE OF THE BAGS EXPLODED, AND I CALLED THE DELEGAR AGAIN TO DO MY RECALL, BUT TO MY SURPRISE THE HAVE MY CAR IN RECORDS AS REPAIR!! AND I TOLD THE THAT NEVER HAPPENED. THEY PROMISED TO CHECK AND CALL ME BACK AND HAS NOT HAPPENED EITHER. THIS IS THE BMW SAN ANTONIO TEXAS DELEGAR. I BELIEVE THIS IS FRAUD! I WANT TO HAVE THE RECALL DONE AND I WANT TO MAKE SURE THEY DON'T GO AWAY WITH IT. I DON'T HAVE ANY DOCUMENTATION TO UPLOAD ABOUT IT BECAUSE IT DOESN'T EXIST. NEVERTHELESS I DO HAVE A PICTURE THAT SHOWS THE AIRBAG THAT EXPLODED IS FROM 2003, AS THE REST OF THEM. I FEEL SO ANGRY AND DISAPPOINTED. MY NAME IS [XXX], OWNER OF THE 2004 BMW 325CI INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

THE REFLECTOR BOWL ON THE HEADLIGHTS BURNS, CREATING A SEVERELY DECREASED OUTPUT. THIS IS AN ISSUE KNOWN BY MANY PEOPLE IN THE BMW COMMUNITY. HTTPS://WWW.BIMMERFEST.COM/THREADS/E46-ZKW-REFLECTOR-RECALL-OPEN-NHTSA-INVESTIGATION.552978/

2004 BMW 325CI. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG SAFETY RECALL. *LD *JS

CHEAP PLASTIC USED IN HEADLIGHT PROJECTORS MELT DUE TO HEAT FROM OEM XENON BULBS. THIS POSES A FIRE SAFETY HAZARD AS WELL AS LOW AND EVENTUALLY NO LIGHT ONTO THE ROAD.

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW 325I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V018000 (AIR BAGS). THE CONTACT CALLED TWO BMW DEALERS, INCLUDING THE BMW OF MONTEREY DEALER, LOCATED AT (1 GEARY PLZ, SEASIDE, CA 93955) AND IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

WHEN TRAVELING AT 60 MPH ON A RESTRICTED HIGHWAY OUR SUNROOF EXPLODED. THERE WERE NO SURROUNDING VEHICLES OR ANY EVIDENCE OF PROJECTILES THAT WOULD HAVE EXPLAINED THE EXPLOSION. WEATHER CONDITIONS WERE CLEAR, DRY, AND ABOVE FREEZING.

TL* THE CONTACT OWNED A 2004 BMW 325I. THE CONTACT STATED THAT WHILE PARKED AT A FUELING STATION AND WHEN EXITING THE STORE NOTICED SMOKE EXITING THE TRUNK OF THE VEHICLE. THE CONTACT USED THE KEY FOB TO OPEN THE TRUNK OF THE VEHICLE AND SAW THAT TRUNK WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT AND POLICE DEPARTMENT WERE CALLED FOR ASSISTANCE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE AND POLICE REPORT WERE FILED. THE FIRE DEPARTMENT STATED THAT THE FIRE WAS NOT DUE TO OPERATOR INVOLVEMENT AND WAS CAUSED BY AN ELECTRICAL FAILURE. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS TOWED TO A TOW YARD. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER WHICH STATED THAT THE FAILURE WAS POSSIBLY DUE TO RODENT INTRUSION IN THE VEHICLE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. *LN *DL

CAR CAUGHT FIRE WITHIN 5 MINUTES OF DRIVING IT. MY FRONT END WAS SERVERLY DAMAGED IN THE FIRE. IT WAS TOTALED.

PASSENGER SIDE HEADLIGHT ASSEMBLY WIRES BREAK AND CAUSE THE HEADLIGHT TO STOP EMITTING LIGHT OR OTHERWISE WORKING. REPEATED ATTEMPTS TO REPAIR THE WIRING HARNESS EVENTUALLY FAIL. THIS OCCURS WITH MERE NORMAL USE OF THE CAR AND PASSAGE OF TIME. THE HEADLIGHT ASSEMBLY AND BULB ARE STILL INTACT, BUT SIMPLY RECEIVE NO POWER DUE TO THE BROKEN WIRES. THE ASSEMBLY CAN FAIL AT ANY TIME, WHETHER STATIONARY, IN MOTION, OR ON BACK ROADS OR HIGHWAYS. WHEN THIS ISSUE IS GOOGLED ON THIS PARTICULAR CAR, A 2004'2006 BMW 3 SERIES E46 COUPE WITH BI-XENON ADAPTIVE HEADLIGHTS, MANY MANY USERS REPORT THE SAME ISSUE. NO MATTER THE CONDITION, LOCATION, AND SERVICE HISTORY OF THE CAR, THE HEADLIGHT ASSEMBLY ON THE PASSENGER SIDE WILL ALWAYS STOP WORKING SIMPLY BECAUSE OF THE WIRING. SEE: HTTPS://FORUM.E46FANATICS.COM/SHOWTHREAD.PHP?T=1073501 IF REPAIRED ENOUGH TIMES, THE ASSEMBLY BECOMES UNREPAIRABLE, AT WHICH POINT THE USER IS STUCK DRIVING WITHOUT A HEADLIGHT, A DANGEROUS SITUATION TO BE IN. ORDERING AN INCREDIBLY COSTLY $1500 PART TO REPLACE IT IS NOT ONLY COSTLY, BUT WILL EVENTUALLY RESULT IN THE SAME CRITICAL ISSUE RE-APPEARING BECAUSE THE DESIGN IS INHERENTLY DEFECTIVE. THIS IS A SERIOUS SAFETY ISSUE. OTHER COSTS INCLUDE MECHANICS WHO INSIST TO CUSTOMERS THAT THE ISSUE IS BOTH WIRING AND THE BULB TOO, CAUSING UNSUSPECTING USERS TO BE CHARGED EXTRA FOR REPLACEMENT BULBS AND THE ASSOCIATED LABOR AS WELL. FIRST OCCURRENCE ON MY CAR WAS APRIL 2019, SECOND WAS OCTOBER 2019, AND THIRD WAS FEBRUARY 2020 AT WHICH POINT THE PART WAS DEEMED UNREPAIRABLE. 2004'2006 BMW 325CI AND BMW 330CI WITH ADAPTIVE BI-XENON HID HEADLIGHTS

TL* THE CONTACT OWNS A 2004 BMW 325I. THE CONTACT STATED THAT THE HEADLIGHTS FAILED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE HEADLIGHT HOUSING MATERIAL WAS DETERIORATED AND PREVENTED THE HEADLIGHTS FROM PROVIDING ADEQUATE ILLUMINATION. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 140,000.

MY LEFT REVERSE/TAIL LIGHT DOES NOT WORK. I HAVE REPLACED THE BULB AND ASSEMBLY AND ALSO HAVE FOUND ONLINE THAT THERE WERE RECALLS FOR THIS SPECIFIC ISSUE.

OK. THIS CAR WAS BROUGHT IN ON 2/12/19 TO THE BMW DEALER IN APPLETON, WI. AFTER THAT BMW HAS CALLED ME 3 TIMES CLAIMING HE WASN'T FIXED. THEY WERE GOING TO CALL THE DEALER. NOW I HAVE REC'D A LETTER FROM THE DMV STATING IT WASN'T FIXED. I FAXED THE INVOICE DATES 2/12/19 TO BMW TODAY. I GIVE UP. THE CONTACT IS PETE KEMPEN 1-877-983-7473. SOMEONE NEEDS TO FIGURE OUT WHAT IS WRONG.

CAR SITTING IN DRIVEWAY OF PRIMARY RESIDENCE FOR SEVERAL DAYS AFTER REPEATED HEAVY RAINS AND HURRICANES AND SPONTANEOUSLY CAUGHT FIRE. FIRE WAS SELF EXTINGUISHED BUT STARTED IN DASH ON LEFT SIDE OF STEERING WHEEL CENTERED ON THE HEAD-LIGHT CONTROL MODULE.

SUBFRAME

THERE IS A MANUFACTURING DEFECT IN ZKW XENON PROJECTOR BOWLS USED IN E46 BMW CARS. MY HEADLIGHTS HAVE BECOME SO DIM THAT I CONSTANTLY RUN FOG LIGHTS AT NIGHT TO BE ABLE TO SEE. DRIVING AT NIGHT, ESPECIALLY IN THE RAIN, IS VERY DANGEROUS FOR ME AND OTHER DRIVERS. ZKW PROJECTOR BOWLS ARE MADE OF PLASTIC, WHICH ARE UNABLE TO STAND UP TO THE HEAT OF XENON BULBS. OVER TIME, THEY HAVE BECOME BROWN AND CRACKED AND DO NOT REFLECT LIGHT ON TO THE ROAD. AL XENON PROJECTOR BOWLS, ALSO USED IN E46 BMWS, DO NOT HAVE THIS ISSUE. ZKW SEEMS TO HAVE REALIZED THAT THEIR PLASTIC BOWLS ARE NOT SUFFICIENT. THE ZKW PROJECTOR BOWLS FOR E90 BMWS ARE MADE OF METAL AND DO NOT HAVE THIS ISSUE. THERE IS NO AFFORDABLE AND SUFFICIENT OEM REPAIR FOR THIS ISSUE. BMW ONLY SELLS WHOLE HEADLIGHT ASSEMBLIES, NOT JUST THE PROJECTOR BOWLS, WHICH RUN HUNDREDS OF DOLLARS EACH. EVEN THEN, REPLACING WITH ZKW LIGHTS WOULD EVENTUALLY CAUSE THE SAME ISSUE BECAUSE OF THE INSUFFICIENT DESIGN OF THE PLASTIC BOWLS. THE COMMUNITY IS WELL AWARE OF THIS ISSUE. THE ONLY REMEDIES ARE REPLACE ENTIRE ASSEMBLIES OR RETROFITING THE HEADLIGHTS WITH AFTERMARKET PARTS. HEADLIGHTS ARE CRITICAL TO DRIVER SAFETY AND SHOULD NOT BE THIS COSTLY TO KEEP WORKING. THESE HAVE FAILED PRIOR TO THE LIFE OF THE VEHICLE (MINE IS AT 138K). THIS THREAD GOES INTO DETAIL FOR MANY PEOPLE WITH THIS SAME ISSUE: HTTP://WWW.ZHPMAFIA.COM/FORUMS/SHOWTHREAD.PHP?3598-THE-ZKW-BURNT-BOWLS-THREAD THERE SHOULD BE A RECALL FOR THIS DANGEROUS ISSUE CAUSED BY NEGLECTFUL MANUFACTURING OF THESE HEADLIGHTS. THE ATTACHED PICTURE SHOWS THE DAMAGE OF MY HEADLIGHTS.

THE ADAPTIVE HEADLIGHTS ARE FLICKERING (STATIONARY OR IN MOTION). THIS POINTS TO A FAULTY WIRING ISSUE, ACCORDING TO MANY OTHER OWNERS REPORTING THIS ON INTERNET FORUMS FOR THIS VEHICLE.

TL* THE CONTACT OWNS A 2004 BMW 325I. WHILE DRIVING 15 MPH, THE PASSENGER DOOR SIDE CURTAIN AIR BAG DEPLOYED INDEPENDENTLY AND WITHOUT AN IMPACT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO BMW OF SOUTH ATLANTA (4171 JONESBORO RD, UNION CITY, GA 30291, (678) 228-8373) TO BE REPAIRED. THE DEALER STATED THAT THE AIR BAG UNDERNEATH THE DASHBOARD WAS REPLACED; HOWEVER, THE SIDE CURTAIN AIR BAGS WERE NOT REPLACED. THE CONTACT STATED THAT THE SIDE CURTAIN AIR BAG WAS STILL HANGING OUT FROM THE SIDE CURTAIN AIR BAG HOUSING. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V428000 (AIR BAGS) AND 15V318000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 194,700.

NEW DEFECTIVE BRAKE PADS CAUSED A TRAFFIC ACCIDENT WITH TOTAL LOSS OF THE VEHICLES INVOLVED. BRAKE PADS ARE CONTAMINATED AND EMBEDDED WITH A SLIPPERY SUBSTANCE. PADS ARE FROM PRIME CHOICE AUTO PARTS 42832 STATE ROUTE 12, ALEXANDRIA BAY, NY, 13607-2216 CAN YOU INVESTIGATE AND ANALYZE THE BRAKE PADS IN ORDER TO STOP THE SELLING OF DEFECTIVE AND DANGEROUS BRAKE PADS? I AM ABLE TO SHIP TO YOU A BRAKE PAD SAMPLE. THE VEHICLE WAS IN MOTION, BUT UNABLE TO STOP BEFORE TURNING ON A CITY STREET.

THE STOCK ZKW PROJECTORS HAVE BURNT OUT AND SIGNIFICANTLY REDUCE THE QUALITY OF LIGHT EMANATING FROM THE HEADLIGHTS. IN ORDER TO HAVE ANY TRUE VISIBILITY, I HAVE TO HOLD THE "FLASH-TO-PASS" LIGHTS ON WHILE I'M DRIVING (A MANUAL TRANSMISSION). THIS IS OBVIOUSLY A DANGEROUS SITUATION. THE REPLACEMENT ASSEMBLIES ARE OVER $3,000 FOR THE PAIR. THAT COST CANNOT BE JUSTIFIED. I PURCHASED THE CAR A COUPLE OF MONTHS AGO, BUT I, OF COURSE, DID NOT TEST DRIVE IT AT NIGHT (SINCE IT WAS SUMMER). SO I HAD NO WAY OF KNOWING ABOUT THE DETERIORATED CONDITION OF THE HEADLIGHTS. I CANNOT SAY FOR CERTAIN WHEN THIS HAPPENED, BUT, BASED ON INTERNET SEARCHES, IT APPEARS TO BE A KNOWN ISSUE THAT DATES BACK TO AT LEAST 2011.

THE CAR SEAT WARMER BURNED THROUGH LEATHER AND BURNED THROUGH MY COAT. I MADE COMPLIANT TO BMW AND SPOKE TO MICHAEL PIGONCELLI. BMW REFUSED TO REPAIR THE DEFECT OR TO COMPENSATE ME FOR MY COAT. THE CAR HAS BEEN MAINTAINED. THE SEAT WARMER WILL SEVERELY INJURE ANYONE WHO USES IT IF A HEAVY COAT IS NOT WORN. I WAS TOLD BY THE BMW DEALERSHIP THAT THE SEAT WARMER BURNING THROUGH THE LEATHER AND PEOPLES SKIN/COAT IS COMMON. BMW (NEWMARKET, ONTARIO) TOOK PICTURES OF THE DAMAGE TO THE SEAT AND MY COAT.

AIR BAG TROUBLE COD LIGHT ON THE DASH DRIVING CAR ON STREET AND HIGHWAY

MY VEHICLE HAS A RECALL ON THE AIR BAGS

HEADLIGHTS HAVE LOST BRIGHTNESS AND COVERAGE AND DO NOT ILLIUMINATE THE ROAD PROPERLY. VEHICLE IS EQUIPPED WITH HID XENON LIGHTS PACKAGE AND WHEN NEW WERE EXTREMELY BRIGHT BUT NOW ARE VERY DIM. ORIGINAL EQUIPMENT WITH NO MODIFICATIONS OR ACCIDENTS.

TAKATA RECALL

THE OEM XENON ZKW BRAND LIGHTS HAD COMPLETELY BURNT REFLECTOR BULBS THAT CAUSED LOW LIGHT TO BE EMITTED. THIS DEFECT IS DUE TO PLASTIC BOWLS BEING USED INSTEAD OF METAL OR ANOTHER MATERIAL. THE DAMAGE COULD HAVE CAUSED A FIRE HAZARD OR WORSE. I WAS FORCED TO REPLACE THE LIGHTS AT MY OWN EXPENSE. I HAVE ATTACHED PHOTOS OF THE DAMAGE AND LIGHT OUTPUT TO THIS COMPLAINT. THIS OCCURRED SIMPLY BY HAVING THE HEADLIGHTS ON.

"TAKATA RECALL" I'VE RECEIVED CONFIRMATION MY VEHICLE IS ONE OF THE VEHICLE APART OF THE TAKATA RECALL. I'M A SINGLE FATHER OF A 13 YR OLD SON. KNOWING THE DANGER MY SON HAS BEEN IN ALL OF THIS TIME HAS SHAKEN MY CORE COMFORT ZONE TO DUST. I'M NOW IN THE PROCESS TO CORRECT THIS BAD AIRBAG CURRENTLY IN MY VEHICLE. MY SON'S FUTURE HAS BEEN PLACED IN RUSK AND THAT WILL NOT BE LEFT UNCHECKED BY MEANS AVAILABLE. I WAS HIT WITH MY SON IN THE CAR AND THE BAD AIRBAG DIDN'T DEPLOY, THANK GOD!

CHEAP WIRING WAS USED IN THE HEADLIGHT UNITS FOR SPECIFIC CARS WITH ADAPTIVE BI-XENON HEADLIGHTS. THE WIRING FOR THESE CARS NOW HAS FALLEN APART, AND DISCONNECTS. BMW'S ONLY WAY OF FIXING IT IS TO REPLACE THE ENTIRE HEADLIGHT UNIT, WHICH COSTS AROUND $2000 TO REPLACE A FEW WIRES THAT SHOULD COST LESS THAN $10. THERE ARE MANY CARS ON THE ROAD THAT THIS AFFECTS, WHICH IS A SERIOUS SAFETY CONCERN. CAR OWNERS ARE SOLDERING WIRES BY HAND IN AN ATTEMPT TO FIX IT BUT THERE IS NO LONG TERM SOLUTION.

TAKATA RECALL. RECALL 15V-318 AND 14V-428 ARE RECALLS THAT I CANNOT GET REPAIRED. I HAVE CALLED CUSTOMER RELATIONS TWICE WITHOUT A RESPONSE. I HAVE CALLED WICHITA LUXURY COLLECTIONS 1-316-719-8300 SINCE MAY 2015 AND JULY 2015 AND THEY STILL DO NOT HAVE PARTS. I EXPECT BETTER SERVICE.IF THEY TAKE THIS RECALL SERIOUSLY.

CAR BURNED WHILE PARKED