BMW · 5 Series · 2005
5
Recalls
192
Complaints
-
Not Rated
The 2005 BMW 5 Series has 5 recalls and 192 owner-reported complaints on file with NHTSA. Most reported issue: air bags (60 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2005 BMW 5 Series page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is air bags with 60 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
Remedy Status
Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Remedy Status
BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Remedy Status
BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Remedy Status
DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Remedy Status
DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.
The tail-lights have gone out creating safty issue and number of warning lights to come up on the dashboard. Dealership stated that the wiring harness around ground wire has melted. They stated that this is same issue that is mentioned under NHTSA Campaign Number: 13V407000. Th...
Preview excerpt
The contact owns a 2005 BMW 545I. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the contact became aware of a ball of white smoke coming from the exhaust. The contact stated that whenever the accelerator pedal was depressed, th...
Preview excerpt
I am encountering persistent issues with my 2005 BMW 525i. Despite having replaced several critical components, including the ignition coils, spark plugs, mass air flow sensor, and throttle body sensors, the vehicle continues to experience performance problems, specifically faili...
Preview excerpt
The wiring inside of the headlights has dried up and fallen off, leaving bare electrical wire. The resulting was both of the headlights became non operational at night. To replace the headlights in the car with all the factory features is about 3200.00 for parts alone. I know of ...
Preview excerpt
At approxamitately 1:20pm on July 13, after being parked for a little over an hour I was told that my car was burning. 911 was called immediately and the owner of the establishment went outside and called to the firemen at the station on the other side of the street. Their resp...
Preview excerpt
DRIVING APPROXIMATELY 50 MPH AN ACCIDENT OCCURRED WHERE THERE WAS OIL IN ROAD. MY CAR LOST CONTROL AND VEERED INTO A GUARD RAIL ON THE HIGHWAY. MY CAR WAS SUBSEQUENTLY TOTALED AND NONE OF MY AIR BAGS DEPLOYED IN THE CRASH.
I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMI...
Preview excerpt
GOOD EVENING ALL, SINCE 2011 I HAVE HAD ISSUES WITH THE I DRIVE SYSTEM. JUST RECENTLY, THE SYSTEM STOPPED WORKING. AFTER ATTEMPTING TO RESOLVE THE ISSUE WITH BMW OF ONTARIO, THEY DECLINED TO COVER THE VEHICLE'S I DRIVE COMPUTER MODULE. FINALLY, THE COMPUTER STOPPED WORKING AND I...
Preview excerpt
GOOD EVENING ALL, EVERY TIME I FILL UP THE GAS IN THE VEHICLE, THERE IS A STRONG SMELL INSIDE THE CAB. THIS BEGAN OCCURRING ABOUT 4 YEARS AGO BUT HAS CONTINUED THOUGHT MY TIME WITH THE VEHICLE. CURRENTLY, I CANNOT FILL THE TANK AT MORE THAN . IF I DO FILL UP THE VEHICLE TO MORE ...
Preview excerpt
AS I UNDERSTAND A VEHICLE FOR PASSENGER SIDE AIRBAG IN PASSENGER SIDE FREE STREAM HAS BEEN DEALT WITH ALREADY I JUST RECEIVED THIS VEHICLE SEVERAL MONTHS AGO SO IT IS NEW TO ME AND I HAVE THE SAME ERRORS AS WHICH A RECALL HAS BEEN ISSUED FOR MY CAR 2005 545 I BMW. AS I HAVE READ ...
Preview excerpt
Showing 10 recent complaints from 192 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2005 BMW models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2005 BMW 5 Series has 5 recalls recorded by NHTSA.
NHTSA has received 192 owner-reported complaints for the 2005 BMW 5 Series.
NHTSA has not published a safety rating for the 2005 BMW 5 Series.
The most commonly reported complaint categories for the 2005 BMW 5 Series are air bags (60 reports), air bags,seat belts (19 reports), power train (15 reports).
Yes. NHTSA has 5 recalls on record for the 2005 BMW 5 Series. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.