2006 BMW 5 Series Engine Problems

The contact owns a 2006 BMW 530I. The contact received notification of the NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available. The contact stated that on multiple occasions while the vehicle was idling, the vehicle lunged forward with the check engine warning light intermittently illuminated. The contact stated that a certified mechanic inspected the vehicle and determined that an O2 sensor, coil, and other unknown failures were affected by the recall. Additionally, the contact stated that she had to add a quart of oil every 400 miles. The contact also noticed a burning odor throughout the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 156,000.

The contact owns a 2006 BMW 530I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 BMW 530XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer had not been made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2006 BMW 530XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

2006 BMW 5 SERIES. CONSUMER WITES SEEKING REIMBURSEMENT FOR VEHICLE REPAIRS RELATED TO SAFTEY RECALL 22V-119.

The contact owns a 2006 BMW 530i. The contact stated while driving approximately 35 MPH, the vehicle was smoking and came to a complete stop. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the residence and then to a local dealer. The dealer diagnosed the vehicle with engine and transmission failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The failure mileage was unknown.

The contact owns a 2006 BMW 530i. The contact received notification of NHTSA Campaign Number: 19V273000 (Engine and Engine Cooling) and 22V119000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that air bag and seat belt warning lights were illuminated. the contact took the vehicle to the dealer and was informed that air bag and seat belt needed to be repaired. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage 100,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 525I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated while driving approximately 30 MPH, she noticed the odor of burning plastic. The contact stated that the check radiator light was illuminated. The contact stated that she drove the vehicle to a dealer. The dealer diagnosed that the failure was with the PCV valve and replaced the PCV valve. The vehicle was repaired; however, the contact was billed by the dealer for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 235,641. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

The contact owns a 2006 BMW 530i. The contact stated while driving approximately 15 MPH, the vehicle started smoking from the engine and steering wheel. There was no fire in the vehicle. The check engine light illuminated on the instrument panel. The contact pulled over safely to the side of the road. The vehicle was cooled down and then was driven to an independent mechanic who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.

The contact owns a 2006 BMW 530i. The contact stated upon taking the vehicle to an independent mechanic to be serviced, he was informed that the VIN was included in NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle had experienced excessive oil consumption. The manufacturer was not made aware of the failure. The low engine oil pressure warning light was illuminated. The failure mileage was approximately 8,000. VIN tool confirms parts not available.

My serpentine belt broke causing my car to shut down. Apparently only BMW’s have a terrible design that the belt gets sucked into the engine and then the engine is gone. No other cars have this design. There are thousands of this model vehicle that are dead cars being sold online. This seems to be a problem

The contact owns a 2006 BMW 525XI. The contact stated that the vehicle was overheating while driving. The coolant temperature warning light was illuminated. The vehicle was taken to an independent mechanic where the thermostat and radiator were replaced; however, the failure persisted. The vehicle was taken back to an independent mechanic where it was diagnosed that the computer needed to be replaced. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 19V273000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000. VIN tool confirms parts not available.

The engine overheated on January 27, 2022 and a warning appeared on the dash to pull over and turn off the engine. It was then towed to a repair facility, where it was determined that overheating caused the failure of radiater hoses, loss of coolant, and other damages. Repairs cost $2574.56 on January 29, 2022. When I contacted BMW and the dealer, I was told that did not want to hear about it until they have determined what remedy was available for the recall, and they told me they would noot listen to any complaints about damages until then.

The contact owns a 2006 BMW 530i. The contact stated upon coming to a complete stop, the vehicle would shudder significantly. Additionally, the contact stated that the engine was misfiring while driving. The transmission warning light and another unknown warning light illuminated. The contact stated that upon parking the vehicle in the driveway, he smelled a strong burning plastic odor. The contact turned off the vehicle. The vehicle was not diagnosed or repaired. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 217,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 530i. The contact stated while driving at approximately 65 MPH, the contact observed an unspecified "yellow" warning light on the dash and heard a small explosion sound issue from the engine compartment. The contact stated that smoke began to come out from under the hood. The contact turned the vehicle off and set the transmission to "neutral" coasted off the roadway onto the left shoulder and stopped. The vehicle was on fire in the engine compartment. The contact extinguished the flames with a fire extinguisher. The contact had the vehicle towed to his residence. The contact had not taken the vehicle to a dealer or an independent mechanic. The contact received a recall letter and related the failure to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

The contact owns a 2006 BMW 525i. The contact stated while driving 60-65 MPH, the vehicle started to overheat. The coolant temperature warning light was illuminated. The contact veered to the side of the road and added coolant in the vehicle. The contact then continued to drive. The contact stated that the failure reoccurred while driving. The contact stated that he replaced the thermostat himself. However, the failure persisted and the vehicle failed to start. The vehicle was towed to the residence. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 135,000. VIN tool confirms parts not available.

THERE IS FUEL LEAKING FROM THE MAIN FUEL LINE TO THE FUEL RAIL. EXTREMELY DANGEROUS UPON RESEARCH I HAVE FOUND THAT THIS IS A COMMON PROBLEM WITH MY MODEL WHICH EXPLAINS WHY BMW'S CATCH FIRE. DOES SOMEONE HAVE TO DIE BEFORE THEY FIX THIS PROBLEM?

BROKEN HEAD BOLTS AT 85K MILES IN NORMAL USE

MY CAR HAS BEEN LEAKING ENGINE OIL FOR ABOUT THREE MONTHS. AFTER I HAD IT CHECKED, I WAS TOLD THAT ONE BOLT ON THE ENGINE WAS BROKEN. I FOUND THAT THE SAME PROBLEM HAPPENED COMMON. I THINK BMW SHOULD SOLVE THIS PROBLEM THROUGH RECALL, BECAUSE THIS PROBLEM IS A MANUFACTURE DEFECT.

DURING A BMW SPONSORED VEHICLE INSPECTION I WAS INFORMED THAT ONE OF MY VALVE COVER BOLTS WAS BROKEN AND OIL WAS LEADING ON THE ENGINE (FIRE HAZARD). THE BMW MECHANIC STATED THIS WAS A COMMON PROBLEM WITH THE 530 SERIES AS THE MANUFACTURED USED ALUMINUM BOLTS TO REDUCE WEIGHT ON THE VEHICLE. THE ALUMINUM BOLTS SNAP/BREAK DUE TO HEAT. THIS IS A POSSIBLE FIRE HAZARD AND THE ALUMINUM VALVE COVER BOLTS SHOULD BE RECALLED AND REPLACED BY BMW.