2004 Chevrolet Colorado Complaint Log

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT WATER CONTINUOUSLY LEAKED ONTO THE FRONT DRIVER SIDE FLOOR. THE DEALER STATED THAT THERE WAS A LEAK BEHIND THE FIREWALL OF THE BRAKE PEDAL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000...UPDATED 09/30/14 *BF

THE AIR BAG LIGHT WOULD NOT GO OFF. THE POWER WINDOW ON THE DRIVERS SIDE REAR WOULD NOT OPERATE FROM THE DRIVERS DOOR MASTER SWITCH PANEL.THE PASSENGER SIDE MIRROR STOPPED WORKING. THE AIRBAG LIGHT REMAINS ON, THE INOPERATIVE POWER REAR WINDOW CONTINUES TO BE OPERATIONAL BUT ONLY FROM THE REAR DOOR SWITCH AND CONTINUES TO BE NON RESPONSIVE TO THE DRIVERS DOOR MASTER PANEL. THE ALL THE POWER WINDOWS CEASED TO FUNCTION AND I FOUND A BLOWN FUSE WHICH WHEN REPLACED ALLOWED THE THREE WORKING WINDOWS TO RESUME OPERATION. I HAD A CERTIFIED MECHANIC TROUBLESHOOT THE AIRBAG SYSTEM WITH A COMPUTER PROGRAM. HE TOLD ME THE AIRBAG SYSTEM WOULD NOT RESET DUE TO A FAULT WITH THE DRIVERS SIDE DOOR AIRBAG LOCATED IN THE "A" PILLAR. AS THERE ARE ALREADY RECALLS ON GM PICKUP TRUCK DRIVER SIDE MASTER WINDOW,MIRROR SWITCH AND THESE ABOVE STATED FAILURES THE RISK OF SAFETY MAY HAVE TO BE INVESTIGATED AND A RECALL EXPANDED. *TR

THE IGNITION WILL NOT START AT FIRST. IT TAKES MULTIPLE TIMES IN ORDER TO GET THE ENGINE TO TURN OVER. ONCE THE IGNITION DOES CAUSE THE ENGINE TO TURN OVER, THE VEHICLE WILL SUDDENLY LOSE POWER WHILE DRIVING AS THE VEHICLE SHUTS ITSELF OFF (AS IF THE IGNITION HAS BEEN TURNED OFF ALTHOUGH IT HAS NOT BEEN). THIS HAS HAPPENED ON MULTIPLE OCCASIONS IN THE COURSE OF NORMAL DRIVING ACTIVITIES, SEVERAL TIMES WHILE CROSSING BUSY INTERSECTIONS WHICH LUCKILY HAS NOT RESULTED IN ANY CRASHES TO DATE, BUT MAY VERY WELL RESULT IN A POTENTIALLY FATAL ONE SHOULD IT CONTINUE TO OCCUR. ENGINE HAS BEEN TESTED AND ALL SYSTEMS CHECK OUT, EXCEPT FOR THE IGNITION SWITCH WHICH -WILL- HAVE TO BE REPLACED. *TR

I PUT KEY INTO ON POSITION AND AIRBAG DEPLOYED AND HIT ME IN FACE. MY FACE WAS RED & SWOLLEN ON RIGHT SIDE WHERE I WAS HIT BY BAG. MY TRUCK NOT MOVING WAS PARKED MY SEATBELT WAS OUT SIDE I WAS GETTING IT ON WHEN BAG DEPLOYED. GM IS GIVING ME A HARD TIME! I KEEP GETTING 1800 CUSTOMER SERVICE NUMBERS THEY GAVE ME A PAC # BUT THEY HAVE NOT FOLLOWED UP WITH ME OR DEALER. I BOUGHT THE TRUCK IT HAD 101,000 ON IT HAS 176,000 ON IT NOW. GM ONLY AGREED TO TAKE CARE OF IT AFTER I TOLD THEM I WAS IN VEHICLE WHEN THE BAG DEPLOYED. STILL WAITING FOR MY TRUCK TO BE FIXED. DEALER TOLD ME THE COMPUTER IS FRIED SO IT NEEDS BAG AND COMPUTER THEN MAYBE THEY CAN FIND OUT WHY IT BLEW. COST IS $1500-2000 TO FIX THEY SAID IT MAY DO IT AGAIN. SO I LEFT WAITING AND WONDERING WHAT NEXT? LUCKILY I HAD STOPPED FOR WORK SUPPLIES ON MY WAY HOME, AND DID NOT DRIVE STRAIGHT HOME! OTHERWISE, I WOULD HAVE BEEN IN A WRECK! AFTER IT HAPPENED, I WONDERED WHY CAB FILLED WITH POWDER. I CALLED DEALER! THEY COULD NOT BELIEVE THIS, SO I DROVE THE TRUCK TO THEM. THEY CUT BAG OFF WHEEL AND TAPED HORN COVER ON. I RETURNED IT TO THEM TO FIX. THE USED CAR DEALER TURNED IT OVER TO A GM DEALER BY THEM AND THERE IT SITS? WAITING FOR GM TO CALL AND GIVE GM DEALERSHIP THE GO AHEAD TO FIX!, AND FOR GM TO CALL ME AND GIVE ME A REASON FOR ALL OF THIS! *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

HEATER FAN DOES NOT WORK. IT IS WINTERTIME AND I HAVE TWO CHILDREN AGES 4 1/2 YEARS AND 9 MONTHS. FAULTY WIRING FOR THE FAN. *TR

EVERYDAY NOW WHEN I TRY TO START THE TRUCK IT TURNS OVER BUT WILL NOT START, WAIT 15 MINUTES THEN IT WILL START. TODAY WHEN I TRIED IT THE FIRST TIME IT TURNED OVER BUT WOULD NOT START SO WHEN I TURNED IT OFF AT THE KEY IT STOPPED THEN TRIED TO START AGAIN ON ITS OWN FOR ABOUT 8 TO 10 SECS. THE STARTER TURNED THE ENGINE OVER WITHOUT TOUCHING THE IGNITION SWITCH IT THEN STOPPED FOR ABOUT 3 OR 4 SECS THEN TRIED TO START ON ITS OWN AGAIN WITHOUT TOUCHING THE KEY, IT DID THIS START SEQUENCE 3 TIMES IN A ROW. THE GM PASSLOCK SYSTEM IS TERRIBLY DEFECTIVE AS REPORTED BY ALL THE REPORTS ONLINE AND I BELIEVE MY PROBLEMS ARE A RESULT OF THIS SYSTEM. *TR

THE VEHICLE WAS PARKED AND STARTED UP DUE TO THE SNOW/ICE TO MELT THE WINDSHIELD. THE FAN WOULD ONLY WORK ON THE HIGH SETTING WHICH IS "4". I REPLACED THE RESISTOR AS IT WAS BURNT. IT WORKED OK FOR A WEEK AND THEN BURNT OUT AGAIN. IF I JIGGLE THE WIRES IT WILL SOMETIMES WORK ON 1, 2 OR 3 SETTING BUT NOT FOR VERY LONG. I HAVE REPLACED 3-4 RESISTORS AND I'M TIRED OF REPLACING THEM. SEEMS TO ME THAT THIS SHOULD BE A RECALL AS TENS OF THOUSANDS IF NOT HUNDREDS OF THOUSANDS OF CHEVROLET COLORADOS HAVE HAD THIS PROBLEM. JUST DO AN INTERNET SEARCH AND FIND THE THOUSANDS OF REPORTS YET GM IS NOT DOING ANYTHING ABOUT IT. ALSO, ONE TIME WHILE DRIVING THE FAN QUIT AND THE ENTIRE DASH LIGHTS WENT OUT INCLUDING THE SPEEDOMETER, RPM GAUGE AND FUEL/BATTERY GAUGES. *TR

TRUCK LEFT ROAD HIT EMBANKMENT THEN ROLLED. AIR BAG DID NOT DEPLOY. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE EMERGENCY BRAKE FAILED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS TOLD THE RATCHETING MECHANISM WAS BROKEN ON THE INSIDE OF THE VEHICLE AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,000 AND THE CURRENT MILEAGE WAS 64,000. THE CONSUMER STATED A REPRESENTATIVE FROM FORD ADVISED THE VEHICLE NEEDED A PARKING BRAKE CONTROLLER. GM OFFERED TO COVER 20% OF THE COST OF REPAIRS AT A GM GM DEALERSHIP. THE CONSUMER FELT THIS WAS AN INADEQUATE AMOUNT. UPDATED 1/2/2013 *JS

ABS FAULT LIGHT WENT ON. TURNED OFF ENGINE, RESTART, LIGHT OFF. GOES ON AND OFF RANDOMLY. *TR

2004 CHEVROLET COLORADO. CONSUMER WRITES IN REGARDS TO A DEFECTIVE IGNITION SWITCH. *SMD THE CONSUMER STATED, HE PAID TO HAVE HIS IGNITION SWITCH REPLACED, AND IS SEEKING REIMBURSEMENT. HE STATED THERE WERE TIMES, WHEN THE VEHICLE WOULD NOT START, AND IT WOULD TAKE ANYWHERE FROM 20-30 MINUTES. OVER SEVERAL YEARS, HE TOOK THE VEHICLE TO THE DEALER, EXPLAINING THE PROBLEMS, WITH TRYING TO START THE VEHICLE. EACH TIME HE WAS TOLD BY THE SERVICE MANAGER, THE PROBLEM COULD NOT BE DIAGNOSE. EVENTUALLY, HE TOOK THE VEHICLE TO A REPAIR SHOP, AND THE PROBLEM WAS FINALLY DIAGNOSED AND THE IGNITION SWITCH WAS REPLACED. HE NO LONGER EXPERIENCED STARTING PROBLEMS. HOWEVER, IN SEPTEMBER 2013, HE DECIDED TO TRADE THE VEHICLE. *JB

VEHICLE KEEPS STALLING AT IDLE OR AS YOU ARE SLOWING TO STOP AT TRAFFIC LIGHTS, DRIVE THRU'S... ACTS AS IF IT ISN'T CHARGING PROPERLY. HAVE REPLACED BATTERY, PLUGS, BELT TENSIONER, DRIVE BELTS. THIS IS DANGEROUS!!! I ALMOST GOT HIT AGAIN IN MORGANTOWN! BRAKE LIGHTS, HEAD & TAIL LIGHTS KEEP GOING OUT AS WELL!!! MY HUSBAND RECENTLY DIAGNOSED WITH CANCER. I AM HAVING TO DRIVE HIM BACK & FORTH TO WVU HOSPITAL IN THE COLORADO. IT IS DANGEROUS HAVING TO DRIVE THIS THING LIKE THIS! TALKING TO OTHER COLORADO OWNERS EXPERIENCING SAME/SIMILAR PROBLEMS! TRUCK DOES GREAT ON HIGHWAY, EXCEPT FOR LIGHTS GOING OFF & ON. PLEASE HELP!!! TRUCK NOW HAS ABOUT 119,000 MILES. *TR

THE VEHICLE FAN CONTROL FAILS TO FUNCTION ON SETTINGS 1, 2, OR 3. SETTING 4 FUNCTIONS PROPERLY. THE CONNECTOR PLUG AT THE FAN HOUSING AND WIRING HARNESS SHOWS SIGNS OF CHARRING. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE RECALL REMEDY WAS PERFORMED TWO YEARS AGO UNDER NHTSA CAMPAIGN ID NUMBER: 09V310000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CONTACT STATED THAT FOR THE FIRST TIME SINCE THE REMEDY WAS PERFORMED, THE BRAKE WARNING LIGHT ILLUMINATED UPON STARTING THE ENGINE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND THEY STATED THAT THE RECALL EXPIRED. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 143,000.

PERIODIC ABS SYSTEM FAILURE OCCURRING WHILE DRIVING AND APPLYING THE BRAKES. HAS BEEN A FAILURE FOR FOUR YEARS MADE EFFORTS TO REMEDY THE PROBLEM BY CALLING THEM AND NO SATISFACTION. I'VE ASKED OTHER COLORADO OWNERS AND THEY SAID THEY HAVE THIS PROBLEM IN THE 05, 06.. I HIT INTO A SCHOOL BUS. *TR

CHEVROLET HAS A KNOWN IGNITION SYSTEM DEFECT SINCE MARCH 2009. MY 2004 CHEVROLET COLORADO INTERMITTENTLY DOES NOT START AND THEN STARTS ON THE SECOND TRY. CHEVROLET'S DOCUMENT: "#PIP4575B: INTERMITTENT CLICK NO CRANK OR BRIEF CRANK NO CRANK WITH DTCS - POSSIBLE CRANK SENSOR - KEYWORDS BQMI - (MAR 11, 2009)" EXPLAINS THE DEFECT. I TOOK MY COLORADO IN FOR SERVICE ON 04-05-12 BECAUSE IT WAS NOT STARTING AT ALL. THEY ADVISED ME THE IGNITION CYLINDER WAS "NOT READING THE KEY" PROPERLY. THEY REPLACED THE IGNITION CYLINDER AND REPROGRAMMED A NEW KEY. THIS REPAIR DID NOT CORRECT THE INTERMITTENT NO CRANK PROBLEM BUT DID BRING THE PROBLEM BACK TO THE STATE WHERE IT WOULD START ON THE SECOND ATTEMPT FOLLOWING A NO CRANK OCCURRENCE. I AM CONVINCED THE INITIAL IGNITION DEFECT WAS THE EVENTUAL CAUSE OF THE COMPLETE FAILURE OF THE IGNITION TO START THE VEHICLE. I BELIEVE THIS COULD BE A SAFETY ISSUE ON THE VEHICLES AFFECTED BY THE INTERMITTENT NO CRANK PROBLEM. IF ONE OF THESE VEHICLES STALLED OUT, THE POSSIBILITY THE VEHICLE COULD FAIL TO START IMMEDIATELY, COULD CAUSE AN ACCIDENT. EVEN THOUGH CHEVROLET CLAIMED THE PROBLEM WAS UNDER INVESTIGATION, THERE HAS BEEN NO NOTIFICATION OF ANY FIX FOR THE PROBLEM THAT I KNOW OF. I WOULD ALSO NOTE THAT CHEVROLET IS CHARGING CUSTOMERS FOR DIAGNOSTIC TESTING AND IGNITION CYLINDER REPLACEMENT EVEN THOUGH THEY HAVE KNOW OF THIS DEFECT SINCE 2009. HOWEVER, REPLACING THE IGNITION CYLINDER AND REPROGRAMMING A NEW KEY IS NOT CORRECTING THE ORIGINAL "NO CRANK" IGNITION DEFECT. *TR

MY ABS FAULT LIGHT IS COMING ON AND THE BRAKES ARE GRINDING AS THOUGH I AM SLIDING ACROSS AN ICY ROAD. I JUST PUT ON NEW BRAKE PADS AT A DEALERSHIP IN MARCH AND NO ONE MENTIONED THAT I HAD A PROBLEM. FROM WHAT I HEARD THE PROBLEM CAN BE PULLING THE ABS PLUG OR SPENDING THOUSANDS AT A DISHONEST DEALERSHIP. IT IS VERY DANGEROUS AND I HAVE READ ON FORUMS THAT THIS ABS FAULT ISSUE IS A WIDE SPREAD SERIOUS ONE. I LOVE MY TRUCK AND IT HAS LOT OF MILEAGE BUT THIS WAS GOING TO BE A PROBLEM ON MY CHEVY COLORADO NO MATTER WHAT SO IT SEEMS TO ME THIS SHOULD HAVE BEEN A RECALL. *TR

DASHBOARD LIGHTS NOT ALWAYS COMING ON AT NIGHT ONLY ODOMETER LIGHTS UP.

INTERMITTENT NON WORKING POWER DOOR LOCKS WIPERS HEADLIGHTS AND WINDOWS! THERE ARE HUNDREDS OF THESE INCIDENTS POSTED ONLINE. THERE LOOKS TO BE THOUSANDS OF DOLLARS IN REPAIRS WITH NO SOLUTION! *KB

AIR BAG WARNING LIGHT WAS LIT ON MY 2004 CHEVROLET COLORADO EXTENDED CAB WHICH I ASSUME WOULD MAKE THE AIR BAGS INOPERABLE DURING AN ACCIDENT. PROBLEM DETERMINED TO BE A BROKEN WIRE IN THE HARNESS BETWEEN THE CAB AND THE BACK DOOR. *TT

ABS KICK IN WHEN VEHICLE IS COLD IN THE MORNING, THEN DISABLE ALONG WITH AN ABS FAULT LIGHT ON THE INSTRUMENT PANEL, THEN GOES AWAY IN THE AFTERNOON. THE ABS KICKS IN AND THE BRAKE PEDAL WILL NOT GO DOWN. *TR

THE ELECTRIC SYSTEM IS KNOCKING OUT THE BRAKE LIGHT AND CRUISE CONTROL ON ALL 2004 AND UP CHEVROLET COLORADOS. I WAS DRIVING HOME FROM WORK JUST TO BE PULLED OVER BECAUSE THE BRAKE LIGHTS WEREN'T WORKING HE TOLD ME THE GUY BEHIND ME ALMOST NAILED ME BECAUSE OF IT. I DIDN'T KNOW! BUT I DID KNOW OF THE COLORADOS HAVING A BIG PROBLEM WITH THE ELECTRIC SYSTEM KNOCKING OUT THE BRAKE LIGHTS AND CRUISE CONTROL. SO I GOT ON LINE TO SEE JUST HOW BAD IT WAS AND FOUND OUT IT'S NO LAUGHING MATTER ALL MOST EVERY CHEVROLET COLORADO TRUCK HAS THIS PROBLEM. JUST THANK OF COMING TO A STOP FROM 65 MILES AN HOUR AND NOT HAVING BRAKE LIGHTS, I AND SOME PEOPLE ON THE ROAD WITH ME GOT LUCKY TODAY. I CALLED TWO OF MY CLOSEST GM DEALERS TO TRY TO GET IT FIXED TODAY AND ASKED DID THEY KNOW OF A PROBLEM LIKE THIS AND THEY DID BUT GM HAS NO RECALL IT'S AT THE OWNERS EXSPENSE TO GET IT FIXED, WHILE I TOLD THEM BOTH WHAT I FOUND OUT ONLINE. THE ANSWER FROM THEM WAS NO ONE HAS DIED YET. **** THAT'S WHAT IT TAKES TO GET SOME THINGS FIXED NOW DAYS FOR SOME ONE TO DIE BEFORE THE COMPANIES FIX A DEFECTIVE VEHICLE. PLEASE CAN SOMEONE FORCE GM TO FIX THE PROBLEMS WITH THE COLORADO TRUCKS PLEASE HELP OUT US OWNERS OF THESE TRUCKS WE CAN'T KEEP SPENDING MONEY LIKE THIS I ALSO HAVE SPENT HUNDREDS ON OTHER PROBLEMS THROUGH OUT THE SEVEN YEARS I OWNED THE TRUCK. TIMES ARE TIGHT CAN'T JUST GO OUT AND BUY ANOTHER VEHICLE. LOOK ONLINE THESE TRUCKS ARE PRONE FOR TROUBLE AND PEOPLE DON'T KNOW IT UNTIL THEY HAVE BOUGHT THE TRUCK. *KB

SOMETIMES WHEN BRAKING THE ABS WILL COME ON TILL THE VEHICLE STOPS,AND THE ABS WARNING LIGHT COMES ON TILL YOU TURN THE CAR OFF.WHEN THE CAR IS RESTARTED THE WARNING LIGHT IS OFF TILL THE ABS COMES ON AGAIN MOSTLY WHEN COMING TO A SLOW ROLLING STOP,IE.RED LIGHT ,STOP SIGN. I HAVE TALKED TO OTHER OWNERS OF THIS VEHICLE WHO ARE HAVING THE SAME PROBLEM. *TR

I HAVE REPLACED THE MASTER SWITCH THAT CONTROLS THE LOCKS AND WINDOWS ONCE ALREADY. GOT A NEW SWITCH AND IT STILL DOESN'T WORK. I CALLED GM AND THEY SAID THAT THERE WERE NO RECALLS ON MY TRUCK FOR THAT ISSUE. I CAN ONLY LOCK AND UNLOCK THE DRIVER'S SIDE DOOR WITH THE INTERIOR PANEL OR THE REMOTE- THE REST OF THE DOORS DO NOT LOCK/UNLOCK. *KB

ON SAT OCT 1ST 2011 I WAS TRAVELING EAST ON THE INTERSTATE AT ABOUT 75 MPH WHEN ALL OF A SUDDEN IT FELT LIKE I HAD BLOWN A TIRE. THE STEERING BECAME RATHER SLUGGISH AND I PULLED OVER TO THE SIDE OF THE ROAD. I GOT OUT CHECKED ALL THE TIRES AND THEY ALL LOOKED OK, SO I GOT BACK IN THE VEHICLE. MY GRANDSON AND HIS FRIEND WERE IN THE BACK SEAT IT WAS A CREW CAB. I NOTICED THAT THE 4WD INDICATOR ON THE DASH WAS ON BUT I HAD NOT SWITCHED IT FROM 2WD IT HAD DONE IT ON IT'S OWN . I TRIED TO SWITCH IT BACK INTO 2WD BUT UPON MOVING THE VEHICLE IT STILL FELT LIKE IT WAS IN 4WD. I DECIDED TO GET THE VEHICLE OFF THE FREEWAY SO I COULD GO SLOWER AND GET THE VEHICLE HOME, SO I EXITED THE FWY ABOUT A MILE LATER AND GOT ON THE OLD HWY WHERE I COULD GO 35 MPH. MY DAUGHTER WAS BEHIND ME IN HER CAR. ABOUT 5 MILES DOWN THE ROAD MY DAUGHTER STARTS FLASHING HER LIGHTS SO I PULLED OVER AND SHE CAME RUNNING UP AND TOLD ME MY VEHICLE WAS ON FIRE , I ORDERED MY GRANDSON AND HIS FRIEND OUT OF THE TRUCK WE LEFT IMMEDIATELY , AND BACKED OFF ABOUT 200 FEET, YOU COULD SEE SMOKE COMING FROM UNDER THE VEHICLE AND FIRE DRIPPING FROM JUST ABOVE THE TRANSFER CASE BELOW THE FRONT PASSENGERS FLOORBOARD AREA. THE FIRE SPREAD AND THE VEHICLE BECAME FULLY ENGULFED THE TIRE MELTED THE LEATHER INTERIOR WAS COMPLETELY VAPORIZED NEEDLESS TO SAY IT WAS A TOTAL LOSS. MY THEORY IS THAT THE SWITCHING MECHANISM FOR THE TRANSFER CASE IS DEFECTIVE IT SHOULD NOT HAVE SWITCHED ON IT'S OWN AT 75MPH. I ALMOST LOST CONTROL OF THE VEHICLE WHEN IT DID. THAT CAUSED SOME KIND OF DAMAGE INTERNALLY IN THE TRANSFER CASE. WHEN I DROVE THE VEHICLE IT HEATED UP UNTIL IT WAS RED HOT AND CAUGHT THE FUEL FILTER ON FIRE WHICH EVENTUALLY RUPTURED SPREAD THE FIRE AND DESTROYED THE VEHICLE. *TR

ABS TRIGGERED UNEXPECTEDLY, ABS AND TRACTION WARNING LIGHTS CAME ON. NO LOSS OF CONTROL. REPAIRED AT DEALERSHIP 10/14/11 REPLACING RF WHEEL BEARING HUB AND SPEED SENSOR. SUBSEQUENTLY INCIDENT REPEATED ON TWO OCCASIONS, CA. 11/15/11 AND CA. 12/16/11 AFTER STARTING INTO A TURN AT LOW SPEED, PERHAPS WITH SLIGHT BRAKING. NO LOSS OF CONTROL. CHECKED AT DEALERSHIP 2/14/2012 WITH NO CAUSE DETERMINED. LATER SAME DAY, FAILURE OCCURRED AGAIN, WITH SAME SYMPTOMS: LOW SPEED WITH TURN AND PERHAPS SLIGHT BRAKING. NO LOSS OF CONTROL. DIAGNOSIS SUGGESTED FAULTY HUBS AGAIN. RESOLUTION PENDING. *TR

FOR BEING MECHANICALLY INCLINED THIS IS DEFINITELY ONE PROBLEM I CANT FIX. I DID THE PADS AND ROTORS ON MY 2004 CHEVY COLORADO, ALL WENT WELL, NICE AND EASY. LATER THAT WEEK MY ABS LIGHT CAME ON. I HAD MY BREAKS CHECKED AND THE MECHANIC SAID IT WASH SHOWING WHEEL SPEED SENSOR. I BOUGHT THE PART AND REPLACED IT NICE AND EASY AGAIN. THE LIGHT TURNED OFF FOR ABOUT 2 MIN THEN CAME BACK ON. THE NEXT TIME I WENT TO DRIVE MY TRUCK I TURNED IT ON, THE SENSOR WAS OFF THEN THE ABS SYSTEM STARTED ENGAGING ON AND OFF MAKING A WEIRD PUMP SOUND AND MAKING MY BRAKES ENGAGE AND DISENGAGE. THIS HAPPENS FOR ABOUT 20 SEC THEN GOES AWAY AND THE ABS LIGHT COMES BACK ON. I THOUGHT NOTHING WORSE COULD HAPPEN AFTER HAVING THE COMPUTER REPLACED TWICE ON THE TRUCK. THIS IS WORSE. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE RESISTER FOR THE WIRING HARNESS WAS DEFECTIVE AND SMOKE WOULD EMIT FROM THE GLOVE COMPARTMENT. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 103,000. THE VIN WAS UNAVAILABLE.

THE ABS ON MY '04 COLORADO IS ACTIVATING AT LOW OR MEDIUM SPEEDS WITHOUT APPLYING THE BRAKE. IF TRAVELING AT SLOW SPEED, AS IN A PARKING LOT, ABS WILL BE ACTIVATED ALMOST CONSTANTLY. THIS IS VERY ANNOYING AND CAN ACTUALLY BE A SAFETY HAZARD WHEN ATTEMPTING TO COME TO A NORMAL STOP. *TR

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

TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HIM THAT THE 02 SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

MY AIR BAG LIGHT STAYS ON. I THINK IT IS A BROKEN WIRE IN THE REAR DOOR.

COULD CAUSE FIRE!!! AC SPEED REGULATOR OF MY 2004 CREW-CAB COLORADO OVERHEATED SO MUCH THAT THE ADAPTER BURNT IN THE INSIDE AND CABLES OVERHEATED TO THE POINT THAT IT COULDN'T BE TOUCHED AND STARTED TO SMOKE. THIS IS LOCATED UNDERNEATH THE GLOVEBOX COMPARTMENT. IF THIS IS LEFT UNATTENDED COULD CAUSE A FIRE INSIDE THE VEHICLE! *TR

DASHBOARD LIGHTS RANDOMLY GO OFF OR FLICKER. THE A/C AND HEATER/DEFROSTER BLOWER STOPS WORKING RANDOMLY OR FOR AN ENTIRE DAY AT A TIME ONLY TO WORK THE NEXT DAY AND THEN QUIT AGAIN. THE A/C HEATING FAN BLOWER DOES NOT WORK ON SPEEDS 1,2, OR 3, ONLY ON SPEED 4. I HAVE HAD THE WIRING HARNESS REPLACED NUMEROUS TIMES ONLY TO HAVE THE PROBLEM CONTINUE AGAIN. THE MECHANICS NEVER CAN SEEM TO FIND THE PROBLEM UNTIL WE GET TO THE HARNESS WHERE THERE IS ALWAYS A BURNED WIRE. THEY REPLACE IT AND JUST LIKE THIS LAST REPLACEMENT, WITHIN THE WEEK THE PROBLEMS RETURNED. *TR

SOME MORNINGS MY 04 COLORADO STALLS OUT AND BOGS DOWN. PUSH THE GAS BOGS DOWN AND GOES NOWHERE. IT DOESN'T MATTER THE TEMP OUTSIDE. IT DOES IT. ITS NOT AN EVERYDAY EVENT. JUST SOME MORNINGS, AND WHEN THE TRUCK HAS BEEN SITTING MORE THAN 8 HOURS. I'VE CHANGED THE FUEL FILTER, PUT LUCAS FUEL TREATMENT. EVERY SMALL REPAIR I'VE DONE. DEALER SAID WHEN IT ACTS UP THEY WILL TRY AND FIX IT. BUT OF COURSE YOU CANT REPLICATE THE PROBLEM FOR THEM TO SEE. WANT TO KNOW WHAT CAN BE CAUSING THIS. I'VE SEEN THERE HAS BEEN ALOT OF INCIDENTS OF ENGINE PROBLEMS. FROM WHAT I'VE READ. SOME OF THESE PROBLEMS WITH OTHER PEOPLES COLORADO'S, ARE HAPPENING TOO. IS THERE ANYTHING THAT CAN BE DONE ABOUT THIS THREW Y'ALL? I HAVE 60,000 MILES ON MY TRUCK I SHOULDN'T BE HAVING PROBLEMS. ANY COST FREE MAINTENANCE FROM GM? *TR

2004 CHEVY COLORADO TURNED ON PARTIALLY TO THE ON POSITION TO START THE VEHICLE AND THE DRIVERS AIRBAG POPPED OUT IN MY FACE AND HIT ME VERY HARD .THIS VEHICLE WAS NOT HIT OR ANYTHING, IT WAS IN A STANDARD PARKING LOT AND WHEN IT POPPED OUT MY HEARING WHEN BLANK OR DEAF LIKE. THE VEHICLE WAS NOT RUNNING AT THE TIME OF THE EXPLOSION. CHEVY THOUGHT MAYBE A MALFUNCTION BUT THEN ADVISED ME TO GO DOWN THE ROAD TO A NEARBY ABRA AUTO BODY WHICH THAT GUY THOUGHT CHEVY MAY BE HIDING A TYPE OF AIRBAG MALFUNCTION RECALL, ANYWAYS CHEVY WOULDN'T ESTIMATE THE PRICE TO BE FIXED AND ABRA SAID I WAS LOOKING AROUND 1300.00 FOR REPAIR.*TR

I NOTICED THAT WHEN USING THE REMOVE ONLY THE DRIVER'S DOOR WOULD LOCK AND UNLOCK. I GO INTO THE TRUCK AND USED THE PANEL AND AGAIN ONLY THE DRIVER'S DOOR WOULD LOCK AND UNLOCK. I PAID OUT OF POCKET TO REPLACE THE SWITCH INSIDE THE TRUCK ON THE DRIVER'S DOOR THAT CONTROLS THE WINDOWS AND THE LOCKING SYSTEM. IT WORKED FOR ABOUT 8 MONTHS AND IT HAS GONE OUT AGAIN. *KB

OWNED THIS 2004 COLORADO EXT.CAB 4X4 SINCE NEW. * AGAIN * BLOWER MOTOR CONTROLLER ON A/C QUIT WORKING ON SPEEDS 1,2,3 STILL WORKS ON "HIGH" 4. THIS IS THE 3RD FAILURE SINCE NEW, AND I'VE HAD TO PAY FOR REPAIRS TWICE ALREADY. ACCORDING TO REPORTS ON INTERNET PROBLEM IS WITH RESISTOR MODULE THAT CONTROLS THE SPEED OF THE BLOWER. SPOKE TO TWO DIFFERENCE GM DEALERS,AND HE ADVISED THAT THE PROBLEM WAS WITH THE MODULE OVERHEATING AND CAUSING THE PLUG TO MELT AND CAUSE THE RESISTOR PACK TO BECOME INOPERABLE. NO WARRANTY ON PART ACCORDING TO GM DEALER. THIS IS A MANUFACTURER DEFECT AND SAFETY HAZARD THAT COULD CAUSE RISK OF FIRE, INJURY OR DEATH. THIS ISSUE NEEDS TO BE COVERED UNDER A RECALL OR SOME PROGRAM TO PROTECT CONSUMERS FROM PAYING TO REPAIR THE SAME DEFECTIVE PART OR SYSTEM OVER AND OVER AGAIN ! *TR

ABS FAULT WARNING LIGHTS UP ON COMPLETELY DRY ROADS CAUSING TEMPORARY LACK OF STOPPING FORCE, ESPICALLY AT SLOW SPEEDS. HAVE HAD NEAR MISS DUE TO THIS FAULT. *TR

SOMETIMES, ESPECIALLY IN WINTER MONTHS WHEN IT IS COLD OUTSIDE THE DOOR LOCKS WILL STOP WORKING. FOR EXAMPLE, USING THE REMOTE TO LOCK THE DOORS, THEY WON'T LOCK AND THE SECURITY ALARM (HORNS) WILL GO OFF IF YOU OPEN THE CLOSED DOOR BECAUSE THE COMPUTER SYSTEM THINKS THE DOOR IS LOCKED SENDING SECURITY SYSTEM INTO TAMPER MODE. ALSO WHEN SHIFTING TO DRIVE, THE DOORS WILL NOT LOCK AS THEY NORMALLY DO WHEN VEHICLE IS SHIFTED OUT OF PARK. ALSO SOME LIGHTS MAY NOT ILLUMINATE SUCH AS THE LEFT FRONT SIDE MARKER LAMP/TURN SIGNAL. EVENTUALLY THE ELECTRICAL SYSTEM WILL RESET AND THE DOOR LOCKS WILL WORK NORMALLY. IT ISN'T JUST DURING COLD WEATHER THAT THIS HAPPENS BUT IT SEEMS TO HAPPEN MORE OFTEN DURING COLDER WEATHER. GM DEALER REPLACED A COUPLE OF SWITCHES WHEN I BROUGHT MY TRUCK IN WHILE UNDER WARRANTY BUT HAVEN'T BROUGHT IT IN SINCE THE EXPIRATION OF MY WARRANTY AND IT STILL DOES IT ON CERTAIN OCCASIONS. *TR

ABS BRAKE FAILURE. ABS ACTIVATES DURING NORMAL OPERATION OF VEHICLE BREAKING, PEDAL GETS HARD AND OR VIBRATES, BRAKES STILL WORK BUT YOU MUST APPLY VERY HARD FORCE TO PEDAL. VEHICLE IS A 2004 CHEVY COLORADO WITH ONLY 30,000 MILES. THIS HAS BEEN OCCURRING ON AND OFF FOR ABOUT THREE TO FOUR MONTHS. IT APPEARS THAT IT BECOMES WORST DURING WET HUMID WEATHER, AND WHEN TURNING AND BRAKING AT THE SAME TIME. OCCURRENCES HAVE INCREASED IN FREQUENCY FROM A COUPLE OF TIME A WEEK TO SEVERAL TIMES A WEEK. I HAD NOT TAKEN THE VEHICLE INTO MECHANIC TO BE CHECKED YET, BUT WILL SOON. ALSO ABS FAULT LIGHT CAME ON A COUPLE TIMES AND STAYED ON UNTIL VEHICLE WAS SHUT OFF, AND RESTARTED MUCH LATER, AT WHICH TIME THE LIGHT RESET. THIS HAS OCCURRED A COUPLE OF DIFFERENT TIMES DURING THE LAST TWO MONTHS. *TR

BRAKES HAVE STARTED TO MALFUNCTION. BRAKES WILL BE APPLIED AND ABS LIGHT OR TRACTION CONTROL LIGHT ON DASH WILL GO ON. BRAKES WILL FUNCTION BUT SOMETIMES ABS WILL SOUND AT SLOW SPEEDS. OCCURS SPORADICALLY. *TR

DRIVER/OWNER TRAVELLED INTO A PARKING LOT, PARKED WITHOUT INCIDENT AND TURNED THE IGNITION COMPLETELY OFF. WITHIN SECONDS, THE DRIVER STEPPED OUT OF THE VEHICLE, THEN LEANED OVER TO RETRIEVE THE KEY WHICH WAS STILL IN THE IGNITION. AS THE DRIVER REMOVED KEY FROM IGNITION, WITHOUT WARNING, THE DRIVER'S SIDE AIRBAG DEPLOYED, STRIKING HIM IN THE LEFT CHEEK. THE DRIVER SUSTAINED FACIAL BURNS. PARAMEDICS AND FIRE RESPONDED. LATER, HE WAS TAKEN TO AN EMERGENCY ROOM. PRIOR TO THIS INCIDENT, THE VEHICLE OPERATED PROPERLY AND RECEIVED ROUTINE MAINTENANCE WITH DEALER.

THE HVAC BLOWER MOTOR RESISTOR ASSEMBLY MELTED ON THE VEHICLE. THE CURRENT PASSING THROUGH THE UNIT IS SUFFICIENT TO MELT THE CONNECTOR AND DEGRADE THE WIRES TO BRITTLE. I BELIEVE THIS IS A POSSIBLE FIRE HAZARD. A NUMBER OF CO-OWNERS HAVE FOUND THE SAME DEFECT. THE CONNECTION IN QUESTION TERMINAL (C) GOES TO A GROUND DISTRIBUTION BLOCK THAT MIGHT NOT BE SUFFICIENT.

AFTER DRIVING VEHILCE A SHORT DISTANCE FROM THE HOUSE, THE ABS SYSTEM ACTIVATED AS IF ON A SLICK SURFACE AS I BRAKED TO STOP AT STOP SIGN. I EVENTUALLY HAD TO PRESS EXTREMELY HARD ON BRAKE PEDAL TO STOP MY VEHICLE BEFORE STOP SIGN. THE TRUCKS ABS FAULT LIGHT IMMEDIATELY SHOWED UP ON THE DASH ALONG WITH THE ABS LIGHT. DURING SHORT DRIVE TO WORK, THE ABS FAULT MESSAGE CONTINUED TO SHOW. AFTER RESTARTING THE TRUCK AFTER WORK, THE SAME PROCESS OF ABS ACTIVATING AS IF ON SLICK SURFACE AND WARNING MESSAGE SHOWED.

TL*THE CONTACT OWNS A 2004 CHEVROLET COLORADO EQUIPPED WITH COOPER COBRA G/T RADIAL TIRES, TIRE SIZE P255/70/15. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH AND THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THEY INFORMED THAT THE REAR PASSENGER SIDE TIRE TREAD BELT EXHIBITED BUBBLING. THE TIRE WAS REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 06T016000 (TIRES:TREAD/BELT). THE DOT NUMBER WAS NOT INCLUDED IN THE RECALL. RECENTLY, THE FRONT PASSENGER SIDE TIRE TREAD EXHIBITED A SIMILAR DEFECT. THE CONTACT WAS IN THE PROCESS OF REPLACING THE TIRE. THE FAILURE MILEAGE WAS 69,000.

THE IGNITION KEY HAS TWICE NEEDED TO BE REPLACED AS THE KEY ITSELF SEEMS TO LOSE THE ABILITY TO TURN IN THE IGNITION. I ASSUME THAT THE KEY WEARS OUT OVER A PERIOD OF TIME, BUT I HAVE NEVER HAD THIS ISSUE WITH ANY OTHER VEHICLE THAT I HAVE OWNED. I HAVE HAD TO CALL A LOCKSMITH BOTH TIMES AND HAVE A NEW KEY MADE IN ORDER TO START THE VEHICLE. BOTH TIMES I WAS IN A PARKING LOT.

FOR SEVERAL YEARS I HAD PROBLEMS WITH MY ENGINE LIGHT, ABS LIGHT, AND BRAKE LIGHT INTERMITTENTLY COMING ON. WHEN THESE LIGHTS WOULD COME ON, THE ANTILOCK BRAKES WOULD SOMETIMES PREMATURELY ENGAGE, DANGEROUSLY VASTLY INCREASING THE STOPPING DISTANCE. THE VEHICLE WAS REACTING AS IF THE WHEELS WERE LOCKING UP, SO IT WAS PREMATURELY ENGAGING THE ANTILOCK. THIS HAPPENED MOSTLY ON DRY PAVEMENT DURING LIGHT BREAKING. I COULD FEEL AND HEAR THE ANTILOCK PULSING THE PETAL RELEASING THE BRAKE PRESSURE. I COULDN'T GET GOOD BRAKING, EVEN WHEN I PUSHED THE BRAKE PEDAL TO THE FLOOR. I TOOK MY CAR TO A GM AUTHORIZED SERVICE CENTER/DEALERSHIP TO HAVE IT DIAGNOSED AND REPAIRED. DESPITE SEVERAL TRIPS TO THE SERVICE CENTER, REPLACING MANY PARTS AND SPENDING ABOUT $2000, THE PROBLEMS CONTINUED. IT WASN'T UNTIL AFTER I WROTE AN ANGRY LETTER TO THE DEALERSHIP MANAGEMENT THAT THEY REPLACED A VEHICLE SPEED SENSOR WHICH SOLVED THE PROBLEM. IT WAS AGGRAVATING BECAUSE I HAD TO PAY EXTRA FOR ANTILOCK FEATURES WHEN I BOUGHT THE VEHICLE. THE ANTILOCK FEATURE WAS SUPPOSED TO IMPROVE SAFETY, BUT ENDED UP BEING VERY DANGEROUS. IF I WOULD'VE HAD A WRECK BECAUSE OF THE BAD BRAKES, THE GOVERNMENT WOULD HAVE LIKELY HELD ME LIABLE, FOR AN EXPENSIVE AND DANGEROUS PROBLEM THAT THEY HAD CREATED. THE GOVERNMENT HAD PRESSURED THE AUTOMOTIVE INDUSTRY TO INCLUDE EXPENSIVE ANTILOCK BRAKES THAT WERE COMPLICATED, UNRELIABLE AND DANGEROUS. INTERMITTENTLY, IT WOULD TAKE 3 TO 5 TIMES MORE STOPPING DISTANCE THAN LEGACY BRAKES WITHOUT ANTILOCK. CONVENTIONAL LEGACY BRAKES I COULD HAVE FIXED MYSELF. WITH ANTILOCK BRAKES; PROPRIETY DIAGNOSTIC EQUIPMENT WAS REQUIRED, SO I WAS DEPENDENT ON GM AUTHORIZED SERVICE; WHICH WAS VERY EXPENSIVE AND DID A LOUSY JOB. *TR

2004 CHEVY COLORADO ZQ8 HVAC BLOWER HARNESS AND RESISTOR. PART WAS REPLACED AT APPROXIMATELY 15,000 MILES UNDER MFG WARRANTY WITH IDENTICAL PARTS. AGAIN OUT OF WARRANTY WITH NO NEW REVISED PARTS AT 45,000 AND NOW AGAIN AT 77,000 MILES. HARNESS AND RESISTOR FAILURE HAD GOTTEN SO HOT EACH TIME THAT IT HAD MELTED THE HARNESS TO THE RESISTOR. POSSIBLE FIRE HAZARD, WITH SEVERELY BURNT WIRES. LOOKING IT UP ON FORUMS THIS IS COMMON ON ALL GM MODEL COLORADO AND CANYON TRUCKS, GM KNOWS OF THE PROBLEM, BUT REFUSES TO OFFER A REVISED PART OR REAL SOLUTION. *TR