Chevrolet · Colorado · 2004
3
Recalls
361
Complaints
-
Not Rated
The 2004 Chevrolet Colorado has 3 recalls and 361 owner-reported complaints on file with NHTSA. Most reported issue: electrical system (41 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 Chevrolet Colorado page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is electrical system with 41 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Remedy Status
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Remedy Status
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Remedy Status
DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Tire size 245/45R20 I purchased a set a 4 Cooper Discoverer H/T Plus tires for my truck in 2022. I haven't driven a lot of miles on them due to the fact that I live on the Island of Oahu, in Honolulu, Hawaii and have a lot of thread life left. I noticed that the sidewalls on 2 ...
Preview excerpt
There apparently was fuel dripping onto the starter and soaking the starter so when we went to start the truck. It caught on fire And my truck is a total loss
The frame on my 2004 Chevy Colorado has rusted/rotted to the point that it snapped, causing the bed to rub against the cab. Mechanic said it is not fixable.
Frame rust
Ignition safety module known as pass lock security. This causes my vehicle not to start and give a code and a light on the dash for the Pass Lock security. The vehicle was fine then I went into a store came out and put the key in the ignition, the lights on the dash came on but ...
Preview excerpt
Frame of my vehicle is rotting away causing to fail inspection. Just finding out that Toyota did a recall on one of there pick up models replacing their frame due rotting frames that may be a safety factor if it gets into an accident. Does Chevy Colorado have a recall as such? J...
Preview excerpt
One day, after I turned my truck off, I noticed that my taillights and overhead cargo light remained on. Key was out, truck was off, but the lights stayed on. So for the time being, I disconnected the battery. I brought it to a mechanic, who ran the codes that came back that t...
Preview excerpt
Body Control Module, BCM. Controls everything. Air bag can deploy, breaks can lock up. Mine, the hazards were staying on. Chevy Dealer says they are on National Back Order and GM is canceling those orders after so long placed. “We can get you one from a junk yard for $350 but GM...
Preview excerpt
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be...
Preview excerpt
I was checking on the common rear cab rust and noticed the frame looked rusted through just in front of the rear wheel suspension mount. I took it to my local mechanic (Bob's Repair of Mayer) and they said it was not safe to drive. It is a complete blindside to me and now I have ...
Preview excerpt
Showing 10 recent complaints from 361 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 Chevrolet models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 Chevrolet Colorado has 3 recalls recorded by NHTSA.
NHTSA has received 361 owner-reported complaints for the 2004 Chevrolet Colorado.
NHTSA has not published a safety rating for the 2004 Chevrolet Colorado.
The most commonly reported complaint categories for the 2004 Chevrolet Colorado are electrical system (41 reports), structure (40 reports), service brakes, hydraulic (26 reports).
Yes. NHTSA has 3 recalls on record for the 2004 Chevrolet Colorado. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.