2005 Chevrolet Corvette Engine Problems

I left my driveway and got two miles up the road and with no warning lights or anything dashboard went dark and suddenly car put itself into assesory mode and car just stopped while driving. I was probably going 15 mph and luckily no one was behind me. The dash said to "shift into park" so I did then I started by pushing start button and it started right up with no problem. I can't get anyone to service vehicle because they said it is not reading any code from check engine light ect. So all I can do is hope it doesn't do this again. Scary.

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. WHILE DRIVING AT ANY SPEED AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE OVER 5 MPH. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE MESSAGES "LOSS OF POWER" AND "TRACTION CONTROL SYSTEM" WERE DISPLAYED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 6,000.

MY 2005 C6 WAS STUCK IN PARK, FAULTY SOLENOID IT WILL NOT ENGAGE DOG EAR TO ALLOW YOU SHIFT OUT OF PARK, LEAVES YOU STRANDED, DEALER WANTS $800 TO REPLACE ENTIRE SHIFTER SINCE THE SOLENOID IS RIVETED TO. THERE ARE MANY C6 OWNERS DEALING WITH SAME ISSUE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT AFTER DRIVING TWO MILES THE SERVICE TRACTION SYSTEM AND REDUCE POWER WARNING MESSAGES ILLUMINATED. THE VEHICLE LOST ALL POWER AND STALLED. THE CONTACT STATED THAT THE VEHICLE WOULD RESTART AFTER TEN MINUTES. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT INSPECTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 10,500. *TR

DRIVING AT 1-35 MPH ENGINE AND ELECTRICAL WILL SHUT OFF, ALL LIGHTS AND ENGINE SHUTS OFF. PUT CAR IN PARK, ENGINE STARTS RIGHT AWAY. IN 2014 GM RECALL OF 2005 COBALT AND PONTIAC FOR SAME PROBLEM, IT WAS SAID THAT SIX PEOPLE DIED. I HAVE THE SAME PROBLEM. THIS ALMOST HAPPENED TO ME. I AM AFRAID TO DRIVE THE CAR. CALLED GM AND TALKED TO A SPECIALIST NAMED SCOTT AT 1-866-790-5600 EXT. 31087 . I WAS ASKED TO TAKE THE CAR BACK TO THE DEALERSHIP, SO THEY WILL LOOK AT IT FOR THE 3RD TIME. THIS HAS BEEN GOING ON SINCE MAY 08, 2013 -- ALMOST 1 YEAR. PLEASE HELP ME BEFORE SOMETHING HAPPENS TO ME OR MY FAMILY. THE CAR IS AT JACK SCHMITT CHEVROLET, 127 REGENCY PARK DRIVE; O'FALLON IL 62269 (618) 628-2500 WWW.JACKSCHMITT.COM. *TR

UPON TAKING MY CAR IN FOR AN OIL CHANGE IT WAS DISCOVERED BY THE TECHNICIAN THAT THE BOLT HOLDING THE HARMONIC BALANCER IN PLACE HAD BACKED ITSELF OUT. THIS ALLOWED THE HARMONIC BALANCER TO DO EXCESSIVE DAMAGE TO SEVERAL ENGINE COMPONENTS INCLUDING THE OIL PAN. ACCORDING TO TECHNICIAN FIRE COULD HAVE ENSUED OR CAR COULD'VE SUFFERED A SEVERE LOSS OF TRACTION FROM THE SUBSTANTIAL OIL LEAK. GENERAL MOTORS HAS ISSUED A "TECHNICAL SERVICE BULLETIN" OUTLINING REPAIR PROCEDURES TO BE PERFORMED AT A LOCAL DEALERSHIP AT NO COST TO CUSTOMERS WITH CARS IN A SPECIFIC VIN SERIES. AFTER LOOKING UP THE TSB MY CAR IS NOT IN SAID VIN SERIES EVEN THOUGH PROBLEM IS EXACTLY AS DESCRIBED IN TSB. *TR

2005 CORVETTE, 45,224 MILES. SQUEAKING NOISE FROM ENGINE ACCESSORY DRIVE BELTS, CLUNKING/ KNOCKING NOISE AT LOWER FRONT OF ENGINE. FOUND CRANKSHAFT BALANCER RETAINING BOLT BACKED OUT, CRANKSHAFT BALANCER MOVING FORWARD. HAD THIS BOLT COME OUT FURTHER, IT WOULD HAVE DAMAGED THE STEERING RACK, ACCESSORY BELTS COMING OFF, LOSS OF POWER STEERING, ELECTRICAL, BRAKING. THIS ISSUE IS KNOWN BY GM/CHEVROLET, TSB 05-06-01-001D. VEHICLE WAS FLAT BED TOWED TO DEALER, THEY DENIED THAT THERE WAS A PROBLEM WITH THE BOLT, IT JUST NEEDED NEW BELTS. AFTER THREATENING THE DEALER & GM WITH A LAWSUIT IF THE PULLEY CAME OFF AND RESULTED IN PROPERTY DAMAGE OR BODILY INJURY, THEY WOULD REPLACE THE PULLEY WITH THE UPGRADED ONE & A NEW BOLT PER THE TSB, BUT AT CUSTOMER EXPENSE. REPAIRS COMPLETED 2/10/2010. THIS VEHICLE WAS WITHIN THE VIN NUMBER RANGE FOR THE TSB, BUT THE DEALER WAS MORE CONCERNED WHERE THE PAPER COPY OF GM TSB 05-06-01-001D CAME FROM- THIS IS PUBLIC INFORMATION. PLEASE- MAKE THIS ISSUE A FORMAL RECALL BEFORE SOMEONE GETS HURT. NHTSA DATABASE SHOWS AT LEAST 6 SIMILAR INCIDENTS, MANY OTHERS HAVE NOT BEEN REPORTED TO NHTSA. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE MAIN PULLEY UNDER THE VEHICLE WAS UNSTABLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT BECAUSE THERE WERE NO ASSOCIATED RECALLS, HE WAS RESPONSIBLE FOR THE COST OF THE REPAIR. THE FAILURE MILEAGE WAS 37,000.

SQUEAKING NOISE FROM ENGINE ACCESSORY DRIVE BELTS, CLUNKING/ KNOCKING NOISE AT LOWER FRONT OF ENGINE. THE CRANK SHIFT BLANCER SPLIT APART MOVING BACK TO THE ENGINE. DAMAGE TO THE TIMING CHAIN COVER AND OIL PAN CAUSING OIL TO LEAK.

PURCHASE A 2005 CORVETTE IN 2008. SHORTLY AFTER AC DIDN'T WORK AFTER WORKING FINE JUST MOMENTS. DROVE CAR FOR A HALF A MILE OR SO AND HEARD A CLUNKING SOUND. PULLED OVER AND RAISED HOOD BUT DIDN'T NOTICE ANYTHING. AC STILL NOT WORKING BUT CAR IS NOT A DAILY DRIVER AND WINTER WAS APPROACHING SO NOT TOO CONCERN. 2009 THIS YEAR DECIDED TO GET AC CHECKED FOR THE SUMMER.....THE AC CLUTCH WAS MISSING. HINDSITE THE CLUNKING SOUND I HEARD A YEAR AGO WAS THE AC CLUTCH FALLING OFF! UNACCEPTABLE FOR ANY CAR. *TR

AFTER ABOUT 2.5 YEARS THE CONVERTIBLE TOP MECHANISM STARTED GETTING NOISY AND THEN REFUSED TO CLOSE ALL THE WAY. THE DEALER REPAIRED IT UNDER WARRANTY WITH A NEW ELECTRIC MOTOR AND A PUMP REPAIR KIT. ABOUT A YEAR LATER THE EXACT SAME THING HAPPENED BUT THE DEALER REFUSED TO REPAIR IT UNDER THE ORIGINAL WARRANTY SAYING THAT IT WAS A DIFFERENT PROBLEM. THIS TIME HE REPLACED ALL THE HYDRAULIC HOSES ON THE LEFT SIDE AND CHARGED ME ABOUT $900.00. I FEEL THAT THE PROBLEM WASN'T PROPERLY REPAIRED THE FIRST TIME. *TR

POTENTIAL LOSS OF COOLANT, ENGINE OVERHEAT, LOSS OF VISIBILITY- INSPECTING UNDER THE HOOD DURING OIL CHANGE, I FOUND THE COOLANT AIR BLEED HOSE RUBBING THROUGH ON THE BOTTOM CORNER OF THE MASS AIR FLOW SENSOR. I TWISTED HOSE AWAY AND PLACED A PLASTIC CONDUIT OVER THE HOSE IN THIS AREA. THIS IS THE SMALL HOSE (8MM ID)LEFT OF THE THROTTLE BODY LEADING FORWARD TO THE COOLANT LINES LEADING TO THE SURGE TANK. HOSE WILL BE REPLACED SOON. *JB

MY BROTHER SUGGESTED I REPORT THAT THE ENGINE IN MY CAR'S FRONT PULLEY COMES LOOSE AND FALLS OFF CAUSING LOSS OF ELECTRICAL PRODUCTION, A/C, AND WORST OF ALL POWER STEERING--ITS A CORVETTE-DONT KNOW IF IT HAPPENS A LOT TO OTHERS ALSO BUT MAYBE YOU WANT TO LOOK INTO IT-SEEMS TO BE A DANGEROUS SITUATION. *NM

DRIVING NEW 2005 CORVETTE (1486 TOTAL MILES ON CAR) IN SHOPPING DISTRICT AT 35MPH. HEARD "SLAPPING" SOUND FROM UNDER THE HOOD. PULLED OVER AND FOUND THAT ONE OF THE UNDERHOOD ENGINE BELTS WAS SHREDDING. WAS AWARE OF A MANUFACTURERS TECHNICAL SERVICE BULLETIN (05-06-01-001A - FEB 8, 2005), THEREFORE THOUGHT IMMEDIATELY THAT THE PROBLEM THIS TSB ADDRESSES WAS THE PROBLEM. THE OCCURRANCE WAS UNEVENTFULL, AS I WAS DRIVING VERY SLOWLY, HOWEVER IF IT HAD BEEN AT HIGHWAY SPEEDS THIS COULD HAVE RESULTED IN LOSS OF CONTROL AND BROKEN FLUID LINES UNDER THE HOOD. ENGINE WAS DISABLED. CAR WAS FLAT-BEDDED TO LOCAL CHEVROLET DEALER WHERE IT WILL BE REPAIRED.*AK

COMPLAINT RECEIVED VIA E-MAIL. WHILE DRIVING HOME ,THE CRANK BOLT WHICH HOLDS THE ENGINE PULLEY, CAME UNTREATED FROM THE CRANKSHAFT. THIS DISINTEGRATED ALL THREE BELTS, AND I LOST THE POWER STEERING. AT 65 MPH, THIS IS RATHER AN UN-NERVING EXPERIENCE! HAD THIS HAPPENED TO A SMALL WOMAN, SHE MIGHT HAVE LOST CONTROL OF THE VEHICLE IN THE RUSH HOUR TRAFFIC. THERE HAVE BEEN AT LEAST 10 INSTANCES OF THE CRANK BOLT COMING OUT FROM THE ENGINE. *AK

COMPLAINT RECEIVED VIA E-MAIL. MY 3 DAY OLD CORVETTE SHREDDED ITS SERPENTINE BELT, OVERHEATED, AND LOST ITS STEERING. CAR HAD 300 MILES ON IT. FROM WHAT I HAVE BEEN READING ON 'CORVETTE FORUM THIS WAS NOT AN ISOLATED INCIDENT BUT HAS BEEN OCCURRING IN TOO MANY NEW CORVETTES. THIS PROBLEM COULD AFFECT THE OPERATION OF THE VEHICLE AS IT NOT ONLY AFFECTED THE COOLING SYSTEM BUT MORE IMPORTANTLY THE STEERING AND BRAKING. TO MAKE MATTERS WORSE THE REPAIR OF THIS PROBLEM WAS FAILING ON MANY CARS, AND THEY WERE EXPERIENCING IT FOR THE SECOND AND THIRD TIME. *AK. *AK

DT: THE CONTACT OWNS A 2005 CHEVY CORVETTE. ON NOVEMBER 27 2004 THE VEHICLE WOULD NOT LET THEM GET INTO THE CAR AND THE ALARM WOULD NOT GO OFF. ALSO, THE COMPUTER IN THE CAR WOULD TELL THEM THAT THERE WAS NO TIRE PRESSURE AND THE TIRES WERE ON THE VEHICLE AND THE COMPUTER STATED THERE WAS NO PSI. THEY HAD TO CLIMB INTO THE HATCH TO OPEN THE DOOR BECAUSE THE DOOR WOULD NOT OPEN WITH THE KEY. ON APRIL 5, 2005 THE DEALERSHIP REPLACED THE BATTERY AND IT DID CORRECT THE PROBLEM UNTIL APRIL 12,2005 AT THAT TIME THE VEHICLE WAS TOWED BACK TO THE DEALERSHIP AND THEY STATED BASICALLY IT WAS THE BATTERY AND THE ELECTRICAL SYSTEM SAME TYPE OF PROBLEM AGAIN THIS TIME. APRIL 16, 2005 THE VEHICLE HAD TO BE JUMPED STARTED. ON APRIL 20, 2005 THE VEHICLE WAS TOWED TO THE DEALERSHIP BECAUSE THEY COULD NOT GET INTO THE VEHICLE, THE BATTERY VOLTAGE WAS SHOWING ZERO, AND THE PSI ON THREE TIRES WERE SHOWING THAT THEY DID NOT HAVE TIRES ON THE VEHICLE. ON MAY 23, 2005 WITH ONLY 2700 MILES ON THE VEHICLE WHILE DRIVING DOWN THE HIGHWAY THE SERPENTINE BELT BROKE, IT OVER HEATED, THE ENGINE HAD BLEW AND THE VEHICLE HAD TO BE TOWED. AROUND JULY 3RD OR 4TH WITH LESS THAN 3000 MILES, THE VEHICLE WOULD NOT SHIFT CORRECTLY AND IT WOULD AUTOMATICALLY STOP BECAUSE IT WOULD COME OUT OF CRUISE CONTROL, THE COMPUTER WOULD GIVE THEM STRANGE ERROR MESSAGES. WHEN THEY ARRIVED TO THE DEALERSHIP THAT IS WHEN THE HATCH ON THE BACK HAD CAME OPEN BY IT SELF AND IT HAD HAPPENED TWICE BEFORE THIS BUT THEY THOUGHT THEY HAD MAYBE ACCIDENTALLY OPENED IT. ON JULY 12, 2005 THE VEHICLE WAS PICKED UP FROM THE DEALERSHIP THE PASSENGER DRIVER SIDE WINDOW MOLDING WAS MESSED UP. THE CONTACT TOLD THEM TO KEEP THE VEHICLE UNTIL IT WAS FIXED. THEY HAVE NOTICED NUMEROUS COMPLAINTS ON THE NHTSA WEBSITE WITH THE SAME TYPE OF PROBLEMS. ALSO, ON THE VEHICLE THEY HAVE BEEN UNABLE TO PUT A FULL FUEL TANK OF GASOLINE IN THE VEHICLE SINCE DATE OF PURCHASE. SERVICE INVOICES ARE AVAILABLE IF NEEDED. *NM

(1) PURCHASED CAR 10/23/2004. (2) ON 10/24/2004, LESS THAN 24 HOURS AFTER PURCHASING THE CAR, THE CRANK PULLEY "CAME LOOSE" AND THE CAR THREW ITS SERPENTINE BELT (LEARNED AFTER THE INCIDENT) WHILE DRIVING ON A CROWDED INTERSTATE. THE FIRST INDICATION OF A PROBLEM WAS WHEN THE DRIVER INFORMATION CONSOLE (DIC) DISPLAYED A MALFUNCTION WITH THE VEHICLES CHARGING SYSTEM THAT NEEDED SERVICE. VOLTAGE DISPLAYED ON DIC DROPPED QUICKLY IN .1 VOLT INCREMENTS UNTIL ROUGHLY 11 VOLTS WERE DISPLAYED. THEN, THE CAR BECAME INCREASINGLY UNRESPONSIVE TO DRIVER INPUT FOR STEERING AND THROTTLE. BRAKES FELT "MUSHY" BUT CONTINUED TO RESPOND TO DRIVER INPUT. ALTHOUGH THE DASH DISPLAYED A FRIGHTENING NUMBER OF ERROR MESSAGES AND ALARMS, THE OCCUPANTS HAD NO IDEA WHAT WAS THE MATTER WITH THE VEHICLE. TRYING TO CROSS 5 LANES OF PACKED FREEWAY TRAFFIC TO GET TO A SAFE BREAK DOWN AREA, IN A CAR THAT APPEARS TO HAVE LOST ITS MIND AND IS SPRAYING ANTIFREEZE ALL OVER THE HIGHWAY, COULD HAVE EASILY RESULTED IN INJURY OR DEATH. WE WERE VERY FORTUNATE THAT WE DID NOT CAUSE AN ACCIDENT. 3) VEHICLE WAS "REPAIRED" AT OURISMAN CHEVROLET IN MARLOW HEIGHTS, MD. CRANK PULLEY, BOLT(S), SERPENTINE BELT, AND UNDERHOOD INSULATION (DAMAGED BY FLYING BELT) WERE REPLACED. A FRICTION WASHER WAS ADDED BEHIND THE CRANK PULLEY ON THE ADVICE OF GM TECH SUPPORT. *CAR BROKE DOWN AGAIN WITH THE SAME PROBLEM ON 13 NOVEMBER. CAR IS NOW AT RADLEY CHEVROLET IN FREDERICKSBURG, VA. GM HAS ORDERED THE MOTOR REPLACED AND THE DEALER IS AWAITING PARTS. THIS IS NOT AN ISOLATED FAILURE, THERE ARE OTHER LS2 ENGINES BREAKING DOWN BECAUSE OF THIS CRANK PULLEY PROBLEM.*AK