2007 Chevrolet Corvette Electrical System Problems

UPON STARTING THE SHIFT LEVER FOR THE AUTOMATIC TRANSMISSION CANNOT BE MOVED OUT OF PARK. CAR DIED ONCE IN A HIGHWAY AND COULD NOT BE MOVED OFF THE STREET. THIS ISSUE IS RECURING, WHENEVER THE VEHICLE IS FIRST STARTED. INTERMITTENT NO SHIFT OUT OF PARK ISSUE.

THE LAST 2 DAYS WHEN I DRIVE AT NIGHT THE HEADLIGHTS (LOW BEAMS) SHUT OFF. I SWITCH TO THE HIGH BEAMS AND THEY WORK. THIS HAS HAPPENED IN THE DARK AND IS DANGEROUS BECAUSE IT HAPPENS ABOUT 30 OR 40 MINUTES AFTER DRIVING THE CAR. I LET THE CAR SIT FOR 4 OR 5 HOURS AND THEN COME BACK AND THEY START WORKING. IT IS THE UNDERHOOD BUSSED ELECTRICAL CENTER (UBEC) HOUSING I SUSPECT.

ELECTRICAL CONTACTS IN FUEL SENDING SENSOR (LOCATED INSIDE GAS TANK) GET COVERED WITH SULFITE. AND DO NOT TRANSMIT FUEL LEFT IN GAS TANK.. MAKES NO DIFFERENCE IF CAR IS STATIONERY, IN MOTION, OR ON HIGHWAY. GAS GAGE READS ZERO.. CHEVROLET CHANGED THEIR TRANSMITTER THE FOLLOWING MODEL YEAR.. BUT MOST 2007 MODELS AND PRIOR YEARS (2005,06 AND 07 ARE AFFECTED.

CAR GOES INTO DEFERRED ENGINE POWER. REPLACED THROTTLE BODY 3 TIMES. THE CAR STARTS TO VIBRATE AND THEN SHUTS DOWN. THIS IS DANGEROUS FOR THE DRIVER AND COULD GET KILLED. WE HAVE CHECKED ENGINE LEAKS, SENSORS, ETC. THE CAR WILL DRIVE OKEY FOR A LITTLE WHILE AND THEN ENGINE LIGHT GOES ON AND THEN STARTS TO VIBRATE AND SHUTS DOWN AND STOPS. I HAVE TO WAIT A LITTLE WHILE, SOMETIMES IT WILL START UP AND SOMETIMES WILL NOT. I CANNOT DRIVE LONG DISTANCES OR AT NIGHT FOR FEAR THE CAR WILL JUST STOP. THIS IS DANGEROUS. I DO NOT KNOW WHAT TO DO. BROUGHT TO THE DEALER AND THEY JUST SAY, GET A NEW VETTE, THEY DO NOT TAKE THIS PROBLEM SERIOUSLY. NOR DO THEIR TECHNICIANS KNOW HOW TO WORK ON A VETTE. THEY HAVE HAD THE DIRECTIONS ON HOW TO TAKE CARE OF THE PROBLEM IN A NOTEBOOK. ONE TECH LEFT HIS NOTES IN MY CAR. IF A DOCTOR HAD TO TAKE OUT HIS NOTES TO SEE HOW TO DO A SURGERY, I WOULDN'T GO TO HIM. WOULD YOU? '

ENGINE LIGHT GOES ON AND GOES INTO DEFERRED ENGINE POWER. HAVE REPLACED THROTTLE BODY TWICE. CAR RUN GREAT AND THEN THE ENGINE LIGHT WILL GO ON AND WHEN I START THE CAR IT STARTS TO VIOLENTLY VIBRATE. I TURN OFF. SIT FOR ABOUT 10 MINUTES AND THEN TRY TO START AGAIN. SOMETIMES IT WORKS AND SOMETIMES NOT. DEFERRED ENGINE POWER IS DANGEROUS. SENSORS HAVE BEEN RESET. THIS IS AN ONGOING PROBLEM BEEN TO THE DEALER AND THEY ARE PRICE GOUGING. PROBLEM HAS BEEN GOING ON FOR SEVERAL MONTHS.

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. WHILE DRIVING VARIOUS SPEEDS, THE TRACTION CONTROL SYSTEM WARNING INDICATOR AND OTHER WARNING INDICATORS ON THE INSTRUMENT PANEL FLASHED. THE VEHICLE LOST POWER AND DECELERATED. THE FAILURE WOULD CORRECT ITSELF AFTER SEVERAL MINUTES AND THE VEHICLE WOULD OPERATE NORMALLY. THE VEHICLE WAS TAKEN TO ROYAL CHEVROLET (4502 W BROAD ST, RICHMOND, VA 23230 (804) 441-9393) WHERE IT WAS DIAGNOSED WITH A FAULTY WHEEL SPEED TRACTION DETECTOR THAT NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 68,100.

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE HEADLIGHTS SUDDENLY SHUT OFF WITHOUT WARNING. IN ORDER TO TURN THE HEADLIGHTS BACK ON, THE CONTACT HAD TO CAP THE FUSE BOX. THE DEALER STATED THAT THE WIRING SHORTAGE WAS UNDER THE FUSE BOX AND THE VEHICLE NEEDED TO BE REWIRED IN ORDER TO PREVENT THE SHORTAGE. ALSO, THE FUSE BOX NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THE VEHICLE HAD ALREADY RECEIVED A RECALL REPAIR REGARDING THE HEADLIGHTS. THE CONTACT STATED THAT THE FAILURE RECURRED EVEN AFTER RECEIVING THE REPAIR. THE RECALL DETAILS WERE UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

DEALERS REFUSE TO REPAIR VEHICLE STATING THE EXTENDED SPECIAL COVERAGE HAS EXPIRED. AIRBAG LIGHT WILL NOT SHUT OFF DUE TO WIRE HARNESS PROBLEM AND GM KNOWS ABOUT THE PROBLEM. I TRIED TO GET THE CAR REPAIRED BUT LOCAL DEALER DID NOT HAVE THE PARTS. AND THE COVERAGE EXPIRED. . I RECEIVE THE NOTICE IN MAY 2016. MY CAR MET THE MILEAGE STANDARD, LESS THAN 120 K MILES AND WITHIN 10 YEARS OF OWNERSHIP.

MY 2007 CORVETTE 2D CONVERTIBLE LOCKS YOU IN THE CAR. YOU COULD GET STUCK IN THE CAR AND SUFFOCATE TO DEATH. THE WINDOWS AND DOORS WILL NOT OPEN, CAR IS NOT RECOGNIZING THE FOB, YOU ARE TOTALLY STUCK. RESORT TO EMERGENCY RELEASE ON FLOOR BESIDE THE SEAT. LOTS OF PEOPLE DON'T KNOW IT'S THERE! LIKE A PASSENGER SITTING IN THE CAR WHILE YOU GO TO DO AN ERRAND. THEY COULD "BURN UP" OVERHEATED AND STUCK! GM KNOWS THAT THEY HAVE A PROBLEM AS THEY SENT ME A LETTER ADVISING ME ABOUT THE EMERGENCY RELEASE! BUT THEY REFUSE TO FIX IT CLAIMING THEY DON'T HAVE A PROBLEM!. ...UPDATED 02/23/16 *BF

REAR PARKING LIGHTS

MY LOW BEAM HEADLIGHTS (LEFT/RIGHT) HAVE INTERMITTENT OUTAGES AFTER THE CAR WARMS UP. THE LOW BEAMS FAIL WITHOUT WARNING LEAVING IT DIFFICULT TO SEE THE VEHICLE AND OPERATE THE VEHICLE DURING EVENING, DUSK AND NIGHT DRIVING. *TR

I HAVE A 2007 CORVETTE AND THE "SERVICE ACTIVE HANDLING SYSTEM" LIGHT COMES ON. I WENT TO THE CHEVROLET DEALER AND HE WAS OF LITTLE HELP. THE CURRENT INVESTIGATION NUMBER IS EA09-002. IS THERE NOW OR WILL THERE BE IN THE FUTURE A RECALL NOTICE ON THIS PROBLEM SINCE IT IS A COMMON PROBLEM AND EVEN A SERVICE BULLETIN ON THE MATTER. *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE HEADLIGHTS SUDDENLY FAILED AND THE HIGH BEAM LIGHTS WERE REQUIRED IN ORDER TO VIEW THE ROADWAY. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT DIAGNOSED THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 63,734. UPDATED 02/06/14*LJ THE DEALER STATED THERE WAS AN INTERNAL UNDERHOOD BUSSED ELECTRICAL CENTER FAILURE.

BOTTOM OF REAR HATCH STRUT / DEFOGGER, DRIVERS SIDE, SHORTED OUT CAUSING A FIRE WHICH TOTALLY DESTROYED THE CAR. *TR

WHILE DRIVING, THE LOW BEAM HEADLIGHTS SUDDENLY WENT OUT. AFTER FURTHER INVESTIGATION, A KNOWN AND DOCUMENTED PROBLEM REGARDING THE FUSE BLOCK UNDER THE HOOD WAS THE CULPRIT. THERE IS A COPPER WIRE WITHIN THE FUSE BLOCK THAT LOSES CONNECTION DUE TO THE HIGH HEAT THAT OCCURS IN THE FUSEBOX CIRCUITRY BUT TO DATE, GM HAS NOT ISSUED A TSB OR RECALL CONCERNING THIS POTENTIALLY DANGEROUS ISSUE. *TR

SERVICE ACTIVE HANDLING/TRACTION CONTROL SYSTEM WARNING CAME ON WHILE DRIVING AVERAGE SPEED (ABOUT 45MPH) GOING STRAIGHT ON A FLAT ROAD. LIGHT WENT OFF AFTER TURNING OFF VEHICLE. CAME BACK ON NUMEROUS TIMES AT DIFFERENT SPEEDS, SOME WHILE BRAKING AT A LIGHT, OTHER TIMES WHILE ACCELERATING. TOOK TO SHOP AND HAD RECOMMENDED FIX OF CLIP ON WIRE BELOW STEERING WHEEL COMPLETED. SHOP TEST DROVE CAR AND COULD NOT DUPLICATE ISSUE. ON WAY HOME, SERVICE LIGHT CAME BACK ON. THIS TIME I NOTICED THE BRAKE LIGHTS ALSO AFFECTED- LIGHTS ON WHILE DRIVING AND OFF WHEN DEPRESSING PEDAL. TOOK BACK TO SHOP WHERE BRAKE LIGHT SWITCH UNDER PEDAL REPLACED AND BCM COMPUTER WAS FLASHED AND REPROGRAMMED (TO AVOID REPLACING). THIS SEEMED TO FIX THE PROBLEM.FOR ABOUT 5 MONTHS. SERVICE TRACTION CONTROL AGAIN CAME ON AND BECAME MORE FREQUENT OVER 2 WEEKS AND BY THE SECOND WEEK THE BRAKE LIGHTS STAYED ON AT ALL TIMES. RETURNED TO SHOP AND HAD TO PAY FOR NEW BCM COMPUTER. HAVE DRIVEN CAR TWICE SINCE THEN WITHOUT ISSUE. FOR OTHER ISSUES ALSO NOTED BY OTHER DRIVERS- HEADLIGHTS HAVE LITTLE CRACKS ALL THROUGH LENSES WHICH CANNOT BE REPLACED, MUST BUY NEW LIGHTS WITH ENTIRE HOUSING WHICH ARE VERY EXPENSIVE AND QUITE LABOR INTENSIVE TO REPLACE. ALSO HEAR LITTLE POPPING NOISES COMING FROM TOP AS NOTED BY RECALL ON FILE. *JS

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE HEADLIGHTS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. GM CUSTOMER SERVICE WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. ...UPDATED 11-01-13 *BF THE CONSUMER STATED THE PROBLEM WAS THE FUSE BLOCK UNDER THE HOOD AND WAS HEAT RELATED, DUE TO POOR DESIGN.

WHILE TRAVELING TO MACON GA ABOUT 11 PM IN THE EVENING, THE LOW BEAM LIGHTS JUST WENT OUT. I TOOK THE VEHICLE TO THE DEALER THE NEXT DAY TO FIGURE OUT WHAT WAS WRONG. THE DEALER STATED THE FIX WOULD BE NEARLY $1,400 TO REMOVE AND REPLACE THE LOW BEAM HEADLIGHTS (REQUIRED REMOVAL OF THE BUMPER). THEY NEVER STATED THERE WERE PROBLEMS WITH THE LIGHTS OR THE LOW BEAM SYSTEM OR IN GENERAL, ASSUMED ANY RESPONSIBILITY WHATSOEVER. VERY DISAPPOINTED TO DATE; SOUNDS LIKE NOT ONLY A SAFETY ISSUE BUT ONE THAT WILL COST ME TO CORRECT. *TR THE CONSUMER STATED GM ACKNOWLEDGED THE ROOT CAUSE AS A DEFECTIVE WIRE IN THE UNDERHOOD BUSSED ELECTRICAL CENTER, YET NO DIRECTIVE HAS BEEN ISSUED TO RECALL THE AFFECTED VEHICLES. UPDATED 01/08/14

USUALLY AFTER INITIAL START AND DURING LOW SPEED DRIVE AND OCCASIONALLY ON HIGHWAY SPEED THE SERVICE ACTIVE HANDLING MESSAGE CAME ON THE DASH. SOMETIMES I COULD STOP, JUST SHUT THE MOTOR OFF AND RESTART IT AND THAT WOULD CLEAR THE MESSAGE. AFTER A FEW DAYS IT BEGAN WARNING MORE FREQUENT AND TOOK LONGER FOR THE MESSAGE TO CORRECT ITSELF. ON 3/26/2013... I HAD THE VEHICLE SERVICED, NEW TIRES AND THE WARNING MESSAGE LOOKED AT BY MY LOCAL CHEVROLET DEALER AND THE FOLLOWING IS WHAT THEY REPORTED AND ASSUMED THE NEEDED REPAIR.: 3/27/2013 44876 CHECKED DTCS FOUND C0710 PERFORMED BULLETIN 06-02-35-002B AND INSTALLED "CLIP" IN STEERING WHEEL POSITION SENSOR AND CLEARED CODES AND TEST DROVE NO FURTHER REPAIR. COST FOR REPAIR WAS $107.63 (CLIP WAS $2.63) I HAVE NOT HAD ANY ISSUE SINCE REPAIR MADE BUT HAVE HEARD OTHERS COMPLAIN ABOUT THIS SAME ISSUE. STEERING TO ME WOULD BE A SAFETY ISSUE AND A $3 CLIP CURED THE PROBLEM... *TR

THE LOW-BEAM HEADLIGHTS ON THE C6 BASE MODEL CORVETTE 2005-2008 WILL STOP WORKING WITH OUT NOTICE WHILE DRIVING AT NIGHT. THIS IS DUE TO A KNOWN ISSUE WITH THE COPPER WIRE CONNECTIONS LOCATED WITHIN THE FUSEBOX. DUE TO DEFECT AND BEING CLOSE TO ENGINE BAY, HEAT CAUSES A BREAK IN THE CIRCUIT WIRE THAT SEPARATES AFTER THE ENGINE BAY HEATS UP (APPROX. 20 MINS OF DRIVING) AND WITHOUT NOTICE, YOUR LIGHTS GO OUT. VERY VERY DANGEROUS WHEN DRIVING ON HIGHWAYS AT SPEED.PLEASE ISSUE A RECALL ON THE FUSEBOX. *TR