2004 Chevrolet Malibu Steering Problems

Electric Power Steering has failed on my car. Warning shows up saying power steering. Live in a snowy deer populated area impossible to turn wheel in these situations to avoid a collision. There was no actual accident that occured but there more than likely could be.

The steering system gets extremely sensitive towards highway speeds to where a slight touch of the steering wheel could cause the car to move a significant amount no warning lamps or messages

The contact owns a 2004 Chevrolet Malibu. The contact stated that the power steering failure message was displayed on the instrument panel. The vehicle was taken to an independent mechanic where it was diagnosed however, there was no DTC code retrieved for the power steering failure. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to costs. The contact linked the failure to NHTSA Campaign Number: 14V153000 (Steering) however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.

The contact's friend owns a 2004 Chevrolet Malibu. The contact stated that while his friend was driving at various speeds, the vehicle experienced a loss of power steering assist. The oil and theft warning lights were illuminated. The Service Power Steering message was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

On multiple occasions driving at slow speeds and parallel parking, the steering wheel locked and I was unable to turn the car. This has occurred numerous times and I am very concerned about my safety as this is extremely hazardous. I am aware that this, power steering failure, is a known issue. Please advise.

My 16 yr old was driving to school when the power steering stopped working. The vehicle was around 151,850 miles. The vehicle steering light came on, the vehicle was still drivable but was very difficult to turn. I’ve taken it to a GM verified dealership to get repaired. The recall that was on the vehicle shows completed 05/2014. The vehicle has never been repaired and I have pictures of the original parts that were replaced in case you need to verify part numbers and prove it has never been repaired. I would really like to be reimbursed as this was a recall that my vehicle was never repaired for.

The contact owns a 2004 Chevrolet Malibu. The contact stated while reversing the power steering failed without warning. The vehicle was taken to the dealer and they stated the steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and they stated that the vehicle was not under warranty. The failure mileage 139,000.

1. A known about the recall for the power steering to go out. This was repaired as a recall a in 2014. It was replaced at no charge. In the last year the same thing happened again. I was charged over $1400 for repair at the dealership. Why was this not covered as well. Same part. Same problem a second time. ? 2. Also, cruise control has gone out over a year ago. No one told me there was a recall. I did not get it fixed due to cost.

Driving along the power steering goes out. You have to pull over, turn engine off and on and ok until the next time. This was a recall that was fixed in 2014. It’s happening again. Happens everywhere. Slowly out to parking lot to highway speeds and everywhere in between. Exactly same when it happened in 2014. Recall 14116

The contact owns a 2004 Chevrolet Malibu. The contact stated while driving 50 MPH, the vehicle experienced a loss of power steering assist. The contact related the failure to NHTSA Campaign Number: 14E044000 (Steering) however, the VIN was not included. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

The contact owns a 2004 Chevrolet Malibu Maxx. The contact stated while driving approximately 30 MPH, the vehicle lost power steering functionality. The power steering warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed with power steering failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 117,000.

In March of 2015 recall for steering shift was done. The car is loosing power again when you are turning a corner it has happened several times. A powere steering code was on. A local shop looked at it and cleared it.

The 2004 Chevy Malibu Maxx equipped with Electric Power Steering experienced a sudden loss of power steering assist. The power steering loss made it extremely difficult to control the direction of the car and can cause crash. The problem has been confirmed by the dealer after a $185 inspection to just read a code. The problem has been covered by recall Bulletin No. 14116. However, the recall DID NOT fix the problem and the exact problem showed up. Mike Maroone Chevrolet North and GM stated "when the recall is done it's done", although the problem was still there. A message was displayed on the Driver Information Center and a chime sounds to inform the driver. The Bulletin is https://static.nhtsa.gov/odi/rcl/2014/RCRIT-14V153-6084.pdf. There is also news on GM's website. https://media.gm.com/media/us/en/gm/home.detail.html/content/Pages/news/us/en/2014/mar/0331-power-steering.html

EPS went out, warning message for steering on message board. Cannot steer very easily. Have not taken to dealer due to not wanting to operate unnecessarily

I was driving to work with my son and sister in the car when the steering wheel suddenly got very tight and started jerking when I attempted to make a left or right turn. I then stopped at a gas station and as soon as I came to a complete stop the vehicle shut off before I could turn it off manually. I then attempted to turn the key on and start the vehicle but it would not turn over, it would only make a clicking sound. I called a friend that was close by to come and assist me so when they arrived I asked them to jump my vehicle off via jumper cables which did get my vehicle's engine to finally start. The car sounded very weak as if it was going to shut off again once we disconnected the jumper cables but it didn't shut off. Nothing was working inside the car or outside meaning I had no radio, no interior lights and nothing on my dash was working. The speedometer wasn't working, the rims Guage wasn't working, the temp Guage wasn't working nor was anything else working on my dash. The turn signals were not working for either side and none of my headlights or taillights were working either. And I still did not safely have control of the steering. The only warning lamp, which didn't appear until my friend jumped my car off, was what looked like a symbol of a vehicle with a symbol of a locked lock in front of it. This failure just happened so I have not taken the car to a certified mechanic to inspect it but the car is available for inspection at any time. I can not afford to put my car in the shop, I work part time at a restaurant in my town and I'm also disabled and I also care for my 8 year old son who is severely autistic so I have no extra money to fix these problems. Please I need help.

The power steering went out while driving. The car was being backed out of the driveway. The car had lights go off when it happened. Once the car was restarted power steering worked again. This problem has only occurred once as far as known. The steering was incredibly hard to move when the issue occurred. It is foreseeable that if issue happens at the wrong time on the freeway it could lead to injury or death of driver, passenger, or others outside the vehicle. If it happens at high speeds during a turn any number of serous damage or injuries could occur. The vehicle was taken to a mechanic who said a dealership would have the equipment properly diagnose the problem. If the mechanic did it himself he would have to replace several parts one a time and it might not be fixed. I will have my son take it to a dealership to look at it. Lights went off during the problem, but it is UNKNOWN which ones lit up. The lights went off, but since significant force had to be used to pull the wheel even slightly the exact lights that went off are unknown.

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT 60 MPH, THE STEERING WHEEL SEIZED NOT ALLOWING THE CONTACT TO HAVE CONTROL OF THE VEHICLE. AS A RESULT, THE VEHICLE RAN INTO A SIDE BEARING. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SOME BACK SORENESS. THE VEHICLE WAS ABLE TO START BACK UP AND THE CONTACT DROVE THE VEHICLE BACK HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 255,450.

Eps goes out. At first only happened when I first started my car but if I restarted it then the issue went away. Problem increased over time & power steering went out while driving. Now it just won’t come back on. Wheel “twitches” or “seizes” on its own. If I put cruise control on the speed increases slightly on its own overtime on its own. It is available for inspection upon request. My safety surely felt at risk & I felt my dogs safety was at risk too. Also any of my passengers safety or anyone else on the road at that time for that matter , had I not been paying 110% attention & noticed the check engine light some on / power steering go out, I could have crashed or someone else could’ve hit me, etc.. Power steering went out while driving quite a few times & I’ve seen numerous complaints for these issues with this same year & model so it has to be a defect not just a personal issue. Have seen comments/reviews all over the internet about these issue , mostly the electric power steering , and even some that say they had replaced their steering column on 3 separate occasions out of pocket with no help resolving this issue from gm or Chevrolet. They first appeared as soon as the power steering went out. No lights prier & no power steering warning on the radio dash thing. (It says when I’m low on washer fluid, or when the power steering goes out, etc.. across my radio)

RECALL # 14E044000, VIN# [XXX]. THE VEHICLE EXHIBITS STEERING ISSUES AS DESCRIBED IN 14E044000 AND DIAGNOSED BY A MECHANIC. BROUGHT VEHICLE TO THE CHEVROLET DEALER AND THEY STATE THERE ARE NO RECALLS BASED ON VIN. HOW TO DETERMINE SPECIFIC VINS THAT ARE IMPACTED? WAS DRVING ON 3/1/21 AND STEERING BECAME ERRATIC. TOOK VEHICLE TO MECHANIC IMMEDIATELY WHERE IT WAS DIAGNOSED. MECHANIC STATED THERE WAS A RECALL AND TO CONTACT CHEVROLET. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

STEERING MECHANISM IS OUT CAN'T CONTROL CAR HAVE TO TURN IT OFF AND ON AND CONTINUES TO GO OUT WHILE DRIVING THE VEHICLE