2019 Chevrolet Silverado Complaint Log

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while reversing, the rearview camera displayed a blue image with the message "Service Rear Vision System". The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

Engine oil cooler lines leaking. Known issue with 2019 Silverados. Needing replacement before engine failure occurs.

The vehicle began knocking on the freeway and experienced a loss of power. It caused warning lights for the Electronic Traction Control and parking break system to light up.

On [XXX] I was driving in Beloit WI. Luckily I was in town and only doing 30-35mph and not another mile because I was headed for the interstate and we all would have died, because all of the sudden my parking brake locked on, my check engine light, ABS light, traction control light all came on and gray smoke just started pouring out my exhaust. Had it towed to my usual mechanic, it had 38 different codes on it, he worked on it for 8 hours and said it needed to go to a dealership. Towed it to a dealership, lifter on cylinder 5 went out and I was told "Yes camshaft is destroyed on that cylinder.. just need one. But tech would pull engine out and pull apart… or replace engine as does not include the fact that oil pump the timing chain the timing chain tensioner, the rod bearing the main bearings, and most importantly the camshaft bearings are still gonna be old and original to your engine. If you replaced just a camshaft. So later on down the road, something there could fail and more than likely the oil pump but again it’s just more money and more what else but if you are going to commit to that then you probably should commit to timing, chain, and oil pump, and everything else in which case now you start adding all the prices of that components in with labor on top of it, and an engine in my opinion would probably be better" and the engine comes with 100k mile warranty. So there's that. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that during cold starts, there was an abnormal sound like a loud pop, and the "Service Engine" warning light illuminated. The contact was able to drive the vehicle to a local dealer. The contact stated that there was a misfire coming from the engine, but the vehicle had not stalled. The dealer diagnosed the vehicle and determined that a valve had failed and damaged the camshaft. The vehicle was repaired. The contact researched online and related the failure to TSB: 19-NA-291. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 79,000.

On 6/4/2025 while driving my truck, I noticed smoke coming out of vents of the front passenger side of vehicle. I got out of truck and went to open passenger door to investigate and the engine ignited. A neighbor called 911 and the local fire department responded. I contacted my insurance company. They had the truck towed so their investigators could examine it. The cause was classified as indeterminate and the truck was declared a total loss. The truck had approximately 51,000 miles at the time of the incident and was well maintained, with new tires and no known mechanical issues or warning lights prior to the fire. The fire occurred while driving on a road seven miles from my home.

The contact owned a 2019 Chevrolet Silverado 1500. The contact stated while driving at approximately 55 MPH, there was an abnormal rattling sound coming from the engine compartment. The contact stated that the vehicle was losing motive power. The contact stated no warning light was illuminated. The contact pulled over and turned off the vehicle; however, when the vehicle was restarted, the vehicle failed to exceed 10 MPH while driving to an independent mechanic. The mechanic diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 120,000.

Truck goes into limp mode several times… fuses pop when it does..it does it when I drive or hit any slight bump

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to an independent mechanic, who informed the contact that similar vehicles were known for excessive oil consumption. The contact was adding oil every 500 - 1,000 miles driven, because the message "Engine Oil Low - Add Oil" would be displayed on the instrument panel. The contact was later alerted by a friend that, upon leaving his residence, oil from the vehicle had leaked out onto the driveway. The vehicle was taken to another independent mechanic, who discovered that a line in the engine oil cooler was leaking oil from a detached crimp joint. Upon investigation, the contact discovered Customer Satisfaction Program: N212326940; for the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in the CSP. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was repaired. The failure mileage was approximately 105,000.

Since I have owned this vehicle I have experienced erratic shifting, primarily when driving in traffic, and when the vehicle is downshifting to 1st or 2nd gear. It has occasionally occurred when traveling on the highway during an upshift, but this is rare. I have also experienced lurching when stopped, or creeping forward in anticipation of a turn. I can occur at any time, and under any type of conditions, hot or cold. It also has a tendency to shift harshly when shifting from park to reverse or from reverse to drive. I have expressed my concerns with my dealer, and it appears they are aware of the problem, and have told me that GM is also aware of the issue, but they dismiss it by way of saying it is normal. I have had the transmission fluid changed at the regular interval, but this has not cured the problem. Finally, GM is well aware of this issue, and is subject to class action lawsuit regarding these transmissions, and other owners have stated that they too have experienced this shifting issue. My concern is that this will eventually lead to a failure of the transmission and the drive components i.e., drive shaft, pinon gear, differential housing, anything connected to the transmission. If this failure occurs at highway speeds, a possible loss of control and crash could occur.

Sliding rear window leaks in 3 spots. Leak poses the safety risk of mold growth inside the vehicle along with the potential of water getting inside of electrical components and air bag device compartments. The problem was reproduced and confirmed at the dealership, to which the plastic seal at the top of the rear window was confirmed to have failed in 3 locations. Dealership recommended replacing the entire back window and assembly with what they believe to be the same window assembly that failed. The only inspection completed on the vehicle to date has been the dealership GM certified technicians. Musty smell after rain and observed staining on the headliner is when the issue was first identified.

In March of 2025, my engine started knocking and had low power. I took it to a local mechanic and he said it was the classic 6.2L rod knock. I took it to the dealer in Decorah Iowa and they agreed that it was the rod knock from the recall. Since it was not covered under the recall, I had to pay almost $10,000 to have it replaced. It took over 4 months to get an engine and then it was finally replaced.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while idling, the vehicle made an abnormal ticking sound, and several unknown warning lights were illuminated. The contact was able to pull to the shoulder of the roadway. The vehicle was towed to an independent mechanic to be diagnosed, but no diagnostic trouble codes were retrieved, and the cause of the failure could not be determined. The mechanic advised the contact to tow the vehicle to a dealer. The vehicle was then towed to a dealer, where the vehicle was diagnosed with defective engine lifters and a defective camshaft. The contact related the failure to NHTSA Action Number: PE25001(Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall, and a case was filed. The manufacturer agreed to partially cover the cost of the repair. The vehicle was repaired. The manufacturer also referred the contact to the NHTSA Hotline to file a vehicle safety complaint. The failure mileage was approximately 63,000.

The truck is a 2019 Chevy silverado 1500 with a 5.3L V8. I have had 2 engine failures since I got this truck. Related to collapsed lifters causing bearing damage and camshaft damage. The first time this happened was around 98k miles. The failure happened while merging onto I95 and matching the highway speed to merge. I believe It is a dangerous defect because when this happened to me while merging the whole truck violently jolted and shook and lost engine power in the middle of the highway. The jolt was violent enough I suspected I got rear ended for a second after regaining control. The second incident happened about a week ago. This time the rebuilt engine failed the same way as before (bearings, lifters and camshaft) but without the dramatic jolt. The rebuilt engine only lasted 12k miles or so. This time the Camshaft is so bent they cannot remove it from the engine and have to replace the whole engine. The engine may be available for inspection but it is currently at a Chevy dealership while they wait for a new engine. Before these failures there was zero warning of the impending issue. Zero warning lights or messages of any kind. Warning lights and messages only appeared after the engine destroyed itself. I also have maintenance records that show routine maintenance was well accounted for.

Driving at 65 MPH engine began so shudder and immediately shut down.

While exiting the highway from 70MPH my truck quit running on the exit ramp as I approached the end of the ramp. The truck would not restart and blocked traffic until I was able to get a tow truck. After the truck was towed back to my home I was able to scan the truck and found P129F code reporting (Fuel Pump Driver Control Module Fuel Pump Speed Signal Incorrect) (see attached report). Only after purchasing a Fuel Pump Driver Control Module from the dealer (P/N) 13565641 (replacement for the original 13531875 P/N) and installing it would the truck start. This was a real safety concern as other driver were also exiting the highway at speed while my truck was blocking a lane. The fuel pump control modules should be designed in "fail safe" way to allow the fuel pump to continue even if it isn't running at the most optimal level.

Key keeps getting stuck when I put it in park and turn off truck! It’s off and on park but it won’t release the key! This happens every day!

When I was driving home the message center said low oil pressure shut engine off and I did then noticed that the oil cooler line blew apart from the crimp piece and sprayed oil all over the road and on my passenger side front tire and rotor and luckily it was raining because I feel it could have caught on fire from the oil hitting the hot rotor

I was driving down the road and I got a warning to "Turn off vehicle immediately no oil pressure". There is a GM customer satisfaction program number N212326940 that addresses the same issue I had for the same year (2019 Chevy Silverado) but when the dealership pulled up the VIN it did not show up. I then called the ( GM) number on the bottom of that bulletin and they said the same thing the dealership said. They then told me to contact NHTSA because you are the ones that issues that, and see how to get my vehicle added.

I was driving down the road and my oil lines from my engine to my oil cooler exploded and oil went everywhere. I turned off the truck immediately. I started looking around and there is a Bulletin (N192220080) addressing this issue with my make model and year vehicle but my VIN was not included. I called GM and they said since this was issued by NHTSA they have to be the ones to update the bulletin or issue a new one if this is happening on more vehicles.

There’s a plastic clip inside the control lever control that is cheaply made, multiple trucks affected. Have pictures to share

Started truck Lights came on and warnings popped up on 5/13/2025 Service ESC Service Trailer Brake System Engine Power Reduced ABS Light Started truck lights came on and warnings popped up on 7/10/2025 Service ESC Service Trailer Brake System Engine Power Reduced ABS light

The Wheel Bearing Bolts came loose and began to fall out. One rubbed against the clamp for the axle boot. The driver was alerted to an issue due to a whining noise from the wheel. Unclear if this noise came from the wheel bearing failing due to misalignment caused by added stress on the single remaining bolt or the rubbing of one of the bolts against the axle. Visual inspection showed one of the bolts had almost completely fallen out. Car was towed to a repair shop and wheel bearings and bolts were replaced.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the camshaft and cylinder #7 connecting rod, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 100,000. The VIN was not available.

I was driving on I85 North north of Atlanta merging off of I285 East in the second to the left hand lane when a light came on the dash saying "low oil pressure". I looked at the oil pressure gauge and it was at zero and there was black smoke from the back of the vehicle from oil hitting the exhaust. There was absolutely no indication of any issue at any time. I was able to coast into the emergency lane and get it shut off. Had I not been able to get pulled off the side of the road, it could have been disastrous as the vehicle had no power and I could have easily lost control and caused a multi vehicle accident. I had the vehicle towed to the closest Chevy dealership and have been informed that the oil cooler line completely separated and will cost $1,400.00 to repair. After receiving the diagnosis, I did a quick Google search and found that this is a fairly common issue, specifically with 2019 5.3L Chevy Silverados and should be, in my opinion, a safety recall.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle shuddered and stalled with black smoke coming from the exhaust. The check engine warning light was illuminated. The vehicle was towed to a local independent dealer, where it was diagnosed and determined that the engine needed to be replaced. The local dealer was contacted; however, the vehicle was not diagnosed because to the VIN was not under recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 153,000.

Oil coolant line detached from the crimp. GM customer satisfaction program N212326940 is exactly what has happened and GM states it is not associated to my VIN so they can't (won't) do anything about it, even though the bulletin clearly indicates 2019 Silverado 1500 (new model). This occured as I was on the interstate. I pulled over as soon as the warning came up telling me to turn the vehicle off. I had to wait on the side of the interstate for several hours for a tow to a local mechanic shop. The mechanic diagnosed the issue and took photos and described the issue in writing. Prior to the incident there was no vehicle warning light that there was an issue, nor did I receive a letter warning of the issue. This catastrophic failure of the coolant line ejected oil, coating the undercarriage and passenger running board. The program bulletin states: Condition: Certain 2019 model year Chevrolet Silverado 1500 (New Model) and GMC Sierra 1500 (New Model) vehicles, may have a condition in which the engine oil cooler (EOC) lines may leak and detach from the crimp joints. Exposure to cold temperature may also aggravate this condition. If the EOC lines leak, there may be an oil leak on the ground and if the EOC lines detach while operating the vehicle, there will be an immediate decrease in oil pressure. This will coincide with a warning on the driver information center display (“Oil Pressure Low Turn Vehicle Off”), along with warning chimes. If the customer continues to operate the vehicle, a loss of propulsion is possible. Correction: Dealers are to replace the engine oil cooler lines, oil, oil filter and refill the coolant.

Shut down

I am writing to express my concern regarding a serious issue with my 2019 Chevy Silverado. Recently, while driving on the highway, I experienced a sudden loss of power. After diagnosing the issue, I was informed that my engine now requires a full replacement. This comes shortly after I had the camshaft replaced. My truck has only 80,000+ miles on it, which I believe is well below what should be expected for such a major failure. I have maintained the vehicle according to recommended service schedules and was surprised by this issue. Chevy has quoted me approximately $15,000 for the engine replacement, which is an extraordinary expense given the mileage and service history of the vehicle. I am seeking assistance in resolving this matter, as I believe this type of failure should not occur under normal conditions with such low mileage. Please let me know what steps can be taken or if there is any warranty or goodwill support available. Thank you for your time and attention to this matter.

Unexpected loss of power. Issues with bearings caused cam to get damaged leading to required engine replacement.

Truck rev high without much acceleration Clunking noise when accelerating Hard shifting Shuttering

My engine misfired and is now no good. Only 90,000 miles and well maintained.

While driving at highway speeds truck started to shake. Transmission fell out of overdrive almost causing a collision. I only have 80k mileage

I was driving on the highway at a speed of around 65 miles an hour and I heard a loud noise and the truck did a hard jerk and slowed down abruptly I then had to struggle to get over to the shoulder as cars around me were moving at high speeds then I found out that it was the lifters that failed and I started doing research on this problem and it seems to be a problem that a lot of people are having with these trucks as well as transmission issues which I was having before this happened

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving 55 MPH and exiting the freeway, the message "Catastrophic Failure" was displayed. The contact was able to veer to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the engine oil cooler lines had detached from the crimp. The dealer replaced the oil cooler lines, the oil filter, and the oil. Additionally, the dealer performed a computer reset. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered because the VIN was not included in GM Campaign Number: N212326940. The failure mileage was approximately 21,000.

Experienced immediate engine lag then immediate engine shut down. Towed to dealership and engine bearing failure requiring complete engine replacement

Last year the right parking brake was sticking and our service parking brake light kept coming on. We found out that it ate our back right brake so both needed to be replaced. That lasted less than a year. I brought it back to our local mechanic twice and they couldn't figure it out so they referred us to a dealership to run a diagnostic test (which I had to pay $108.00 out of pocket for) I brought it in to the dealership on Friday (4-18-25) to find out that the Brake Control Module needs to be replaced. I noticed that their is a recall for my exact vehicle but my VIN # is not included in the recall. I would like to be included in this recall. This is a very serious issue that deals with everyone's safety. I don't want to have to keep fixing this. I just want my vehicle fixed. Please help

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while the vehicle was parked and turned off, the contact noticed that the engine oil cooler line was leaking fluid on the ground. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related to the failure of the Customer Satisfaction Program: N212326940 (Engine Oil Cooler Lines Detaching from Crimp); however, the vehicle was not included. The manufacturer was made aware of the failure, but informed the contact that the VIN was not included in the Customer Satisfaction Program. The failure mileage was approximately 100,000.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was a burning oil odor detected. Additionally, the contact noticed that engine oil was leaking onto the ground. The vehicle was taken to an independent mechanic, who determined that the engine oil cooler lines were leaking. The mechanic replaced the engine oil cooler lines. The contact related the failure to Customer Satisfaction Program: N212326940 (Engine Oil Cooler Lines Detaching from Crimp); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 50,000.

In 2022 we experienced harsh shifting between gears and had dealership assess and they flushed the transmission. We were told other than that there is no remedy. The problem still persisted occasionally. Recently while driving the EPC light and check engine appeared as well as engine shacking and jerking. We’re broke down on side of busy highway. Getting it back into dealership preliminary testing is that there is engine misfire and transmission. Frustration that GM is in class action lawsuit for transmission issues and that we had it inspected before with being told nothing more can be done. Vehicle is currently in shop being diagnosed for repairs.

Vehicle has been maintained perfectly with full records. 99, 300 miles. Vehicle suddenly lost power at 55 mph, loud noise from the engine compartment. Immediately stopped and had the vehicle towed to the Chevrolet dealership. Diagnosed with DOD failure, required complete engine replacement. Explicitly told by this dealership and four others that I called for comparison price, stated that this is a known weakness, a known “defect” for years. It does seem very criminal to me that neither you nor GM/Chevrolet has not taken action on this known and very public issue. My cost was just over $13,000 +2 weeks rental $900, plus $300 towing.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 50 MPH, the front driver’s side upper control arm detached, causing the brake pads, rotors, and axle to fail. An independent mechanic was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was repaired, and the upper control arm control, brakes pads, and rotors were replaced. The contact stated that the failure had occurred several times. The contact related the failure to NHTSA Campaign Number: 21V718000 (SUSPENSION); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 83,000.

Vehicle wouldn’t accelerate on the freeway and then shuttered and would not shift in the transmission. Was told by a repair man that the transfer clutch failed and the transmission is failed.

Engine misfires, cam and lifters failed suddenly. While driving

This has happened twice now, this vehicle has gone through 2 transmissions and still puzzles me. Hard shifts, sudden jerking and stopping. I’m just throwing money away for something that is unreliable. Both done by certified GM Dealer.

I own a 2023 Chevrolet Silverado 1500 with a 6.2 liter L87 engine that is currently part of class action lawsuits. While driving down the highway with a car full of passengers at around 75-80mph, the vehicle shut down and would not accelerate. Frantically from the left lane, I crossed traffic almost causing an accident multiple times, to the shoulder of the highway. I then called for a tow truck to tow the vehicle as it would not start. The vehicle was towed three hours later, to the dealer (Quirk Chevrolet) and I walked off of the highway with the group of people. We then ubered home. The dealer diagnosed some mechanical issues that they said were the issue and “repaired” the vehicle. I picked the vehicle up three days later. Three weeks after that I was driving down the highway at about the same speed, 75-80mph, and my vehicle shut off again and was unresponsive. I had to then cut across three lanes of traffic frantically again and I coasted off of the highway due to an off ramp being right there and me acting quickly. The vehicle was unable to start for about 20 minutes and when I finally got it started it was making a loud audible knocking noise. I shut it down and called for a tow truck to the same dealer I had it serviced at a few week prior. I got a call the following day stating my vehicle needed an engine replacement and that I was most likely going to have to wait four months or more for it. They stated that they did not have any loaner vehicles available for me due to four other 6.2L engines needing replacement and if they had any available in the coming months, they would all be midsize SUVs. They stated that there was nothing they could due to get me a truck and only a midsize was offered which would not be any time soon anyways. I called three other Chevy dealers in the area and they stated that they all had between 3-5 seized 6.2L engines in the shop. There were no warning signs prior to this happening minus the repairs stated above and maybe a tic

The vehicle was being driven to work when the engine lost power and several warning lights started cycling. The vehicle started shaking badly. The truck had 62,735 miles and was regularly serviced. We took it to Christian Brothers Automotive in Lubbock, TX. where they were able to find that that lifters failed causing $7,000.00 in damage. The shop that made the repairs said it is a common and known issue.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving on the highway at 45 MPH, the vehicle experienced a complete loss of automotive power, and no warning lights were illuminated. The contact immediately proceeded to pull over, and the vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was advised that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 114,000.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the vehicle jerked. Additionally, the transmission shifted abnormally rough, and the check engine warning light was intermittently illuminated. The contact stated that the failure could have pulled the vehicle off the road. The vehicle was taken to Napoli Kia, which was a third-party dealer assigned by the warranty company to be diagnosed. The vehicle was diagnosed with transmission failure. The contact also stated that metal shavings were found in the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact was informed that parts had on back order for over eight months. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 70,000.

Vehicle has been at dealership multiple times for the same issues and the cant figure it out. Constantly p303 codes. On highway doing 65-70 and truck starts to shutter and drop speed swerving down to about 40mph on highway in traffic. Have to pull to shoulder and restart Vehicle.