2004 Chevrolet Tahoe Complaint Log

TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT NOTICED BRAKE FLUID LEAKING FROM THE VEHICLE ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE TWO BOTTOM BRAKE LINES WERE WORN AND HAD SPLIT SIMULTANEOUSLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 113,000. UPDATED 06/17/11*LJ UPDATED 2/03/2012 *LN *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 75 MPH SHE HEARD A CLICKING NOISE FOLLOWED BY THE ILLUMINATION OF THE ANTI-LOCK BRAKE AND FUEL GAUGE WARNING LIGHTS ON THE INSTRUMENT PANEL. MOMENTS LATER THE VEHICLE STALLED. UPON RESTART THE VEHICLE OPERATED AS NORMAL. THE FAILURE RECURRED APPROXIMATELY TWENTY TIMES WITHIN A TWO WEEK PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT PLANNED ON TAKING THE VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE FAILURE DIAGNOSED. THE CONTACT ALSO EXPRESSED CONCERN OF NHTSA CAMPAIGN ID NUMBERS: 04V045000 (FUEL SYSTEM, GASOLINE), 04V045000 (SERVICE BRAKES, HYDRAULIC) AND 07E106000 (WHEELS: CAP/COVER/HUB, WHICH HE BELIEVED COULD HAVE POSSIBLY CONTRIBUTED TO THE FAILURE. THE VIN WAS NOT INCLUDED IN ANY OF THE RECALLS AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

WHILE DRIVING VEHICLE WITH AIR CONDITIONER ON, EXTREME HEAT STARTED TO BLOW OUT OF DRIVERS SIDE VENTS, WHILE COLD AIR CONTINUED TO BLOW OUT OF PASSENGER SIDE. THIS PROBLEM HAPPENS EVERYTIME THE VEHICLE IS IN OPERATION. *TR

WHILE COMING TO A SLOW STOP OF 5 TO 10MPH, THE ABS KICKS IN.AFFECTED PART IS THE FRONT BEARING AND ABS SENSOR, CAUSED BY RUST BUILD UP IN THE UNIT. *JS

2004 CHEVY TAHOE SPEEDOMETER IS DEFECTIVE AND READS INACCURATELY BY AT LEAST 15 TO 20 MPH. DOES NOT RETURN TO ZERO WHEN STOP, EVEN AFTER VEHICLE POWER IS TURNED OFF. BEGINS WORKING AGAIN AND WILL SOON THEREAFTER MALFUNCTION AS JUST DESCRIBED. THIS IS INACCURATELY CALCULATING MILEAGE, AND, WHEN I SPOKE WITH SERVICE PERSONNEL AT HUFFINES CHEVROLET, Q CHEVROLET AND CLASSIC CHEVROLET (ALL IN THE DALLAS/FORT WORTH AREA), ALL ACKNOWLEDGED THIS AS A KNOWN PROBLEM THAT GM WILL NOT FIX AFTER 80K MILES. ALTHOUGH I'M INUNDATED WITH JUNK EMAIL FROM GM, THEY NEVER, EVER PROVIDED ME WITH ANY INDICATION THAT THIS WAS AN ISSUE. NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) SHOULD NEVER, NEVER ALLOW THIS TO OCCUR. PLEASE INSIST THAT GM PROVIDE FULL REPLACEMENT, INCLUDING ALL PARTS AND LABOR, FOR SUCH A SERIOUS AND KNOWN SAFETY DEFECT.

TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STARTED THE IGNITION AND EXITED THE VEHICLE. A FEW MOMENTS LATER, SMOKE BEGAN TO EMIT THROUGH THE WINDOWS AND FLAMES ERUPTED FROM THE DASHBOARD ON THE PASSENGER'S SIDE, WHICH BURNED A HOLE IN THE WINDSHIELD GLASS. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE AND THE VEHICLE WAS DESTROYED BEYOND REPAIR. THE FAILURE WAS CONTRIBUTED TO A FAULTY HEATER BLOWER. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT WHO INFORMED THE CONTACT THAT THERE WERE NO RECALLS RELATED TO THE DEFECT. THE MANUFACTURER HAD HOWEVER, ISSUED A CUSTOMER SATISFACTION CAMPAIGN PERTAINING TO THE HEATER BLOWER. THE APPROXIMATE FAILURE MILEAGE WAS 101,000. UPDATED 06/26/12 *BF

SIGMA STAMPEDE RADIALS FOR MY 04 TAHOE WERE PURCHASED IN FEB. 2009 WHEN MY TRUCK HAD 86,000 MILES. THE TIRES WERE SUPPOSED TO HAVE A 65,000 MILE WARRANTY. AT 133,00 MILES, THE FRONT RIGHT TIRE CAME APART ON THE INTERIOR SIDE WALL ALL THE WAY AROUND WITH 1 SEPARATION ON EXTERIOR SIDE WALL. NO INJURY OR DAMAGE OCCURRED BECAUSE I ALWAYS DRIVE SLOWLY AND WAS ON CITY STREET AT TIME. INSPECTION OF OTHER 3 TIRES SHOWS MANY SLITS/CRACKS ON EXTERIOR SIDEWALLS OF 2 OF 3 TIRES. SELLER HAS DONE SOME COMPENSATION. HOWEVER, I THINK THE TIRE NEEDS TO BE RECALLED. THE SITUATION OF THE TIRE COMING APART COULD BE VERY SERIOUS AT HIGH SPEED. *TR

2004 CHEVY TAHOE WITH CASTECH HEADS HAS A HISTORY OF RUNNING HOT OR OVERHEATING WITH LITTLE WARNING. IN THE COOLER MONTHS, WILL FAIL TO HEAT THE INTERIOR OF THE VEHICLE WITHOUT WARNING. CAN LEAVE DRIVERS AND PASSENGERS (LIKELY CHILDREN) WITHOUT TRANSPORTATION IN A HARSH ENVIRONMENT. *TR

I HAVE A 2004 CHEVROLET TAHOE WITH 68,863 MILES. THE SPEEDOMETER STARTING READING 20 MILES AN HOUR YESTERDAY WHEN PARKED. WHEN DRIVING THE SPEEDOMETER IS ERRATIC AND READS APPROXIMATELY 20-30 MILES AN HOUR FASTER THAN I BELIEVE I AM TRAVELING. I HAVE RESEARCHED AND FOUND MANY REPORTS OF THIS PROBLEM. THIS IS A SEVERE SAFETY ISSUE AND THIS DEFECT IS A PROBLEM THE MANUFACTURER SHOULD REPAIR AT NO CHARGE. RECALL THIS VEHICLE. *TR

2004 TAHOE: SPEEDOMETER READS CRAZY DURING LONG TRIP. HAVE READ ABOUT THIS ISSUE AND NOW IT HAS HAPPENED TO MY TAHOE. IT'S NOW A PERMANENT ISSUE AND I RELY ON MY GPS DEVICE TO MONITOR MY SPEED. I'M WAITING FOR THE OTHER CLUSTER INSTRUMENTS TO FAIL AND THEN I WILL HAVE TO REPLACE THE PARTS ON ALL. IT'S PATHETIC THAT GM WILL NOT RECALL THIS AS A SERIOUS SAFETY ISSUE. IT'S NOT LIKE YOU CAN DRIVE WITHOUT THIS GAUGE - WILL GM PAY MY TICKETS? *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 10 MPH AND APPROACHING A STOP SIGN, THE CONTACT NOTICED THAT FRONT DRIVER SIDE TIRE WAS FLAT. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE CONTACT STATED THAT THE SPARE TIRE MOUNT WOULD NOT UNLOCK AND RELEASE THE TIRE. THE VEHICLE WAS TOWED TO THE RESIDENCE WHERE THE CONTACT PURPOSELY HAD TO FRACTURE A MECHANISM IN ORDER TO DETACH THE SPARE TIRE FROM THE CABLE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,000.

THE GM 5.3L BUILT BETWEEN 2002 AND 2006 USING CASTEK CORPORATION ENGINE HEADS WERE INCORRECTLY BUILT PER GM AND CASTEK. THE HEADS LEAK ENGINE COOLANT INTO THE COMBUSTION CHAMBERS AND BURNS OFF CAUSING THE ENGINE TO OVERHEAT. GM HAS ISSUED A TECHNICAL BULLETIN REGARDING THIS ISSUE AND REQUESTS THE HEADS BE CHANGED OUT BUT AT THE CLIENTS EXPENSE. WITH THE LOSS OF COOLANT AND INEVITABLE ENGINE DAMAGE THIS IS A SAFETY HAZARD AND SHOULD BE A RECALL AND REPLACED AT GM COST. TECHNICAL BULLETIN 06-06-01-019B ISSUED 6/12/2007.

COOLANT LOSS WITHOUT SIGNS OF LEAK. LOSS OF OIL WITH NO SIGNS OF LEAK. LIFTERS CHATTERING ON COLD START. PUFF OF WHITE SMOKE ON START-UP. LOSS OF OIL PRESSURE. DEFECTIVE CYLINDER HEADS MADE BY CASTECH. *TR

ABS LIGHT CAME ON ALONG WITH A LOUD HUM AND RATTLING FROM FRONT TIRE AREA. HAD TO GET THE HUB ASSEMBLY REPLACE. THIS HAPPENED AROUND 90,000 MILES WITH THE FRONT PASSENGER SIDE TIRE, AND AROUND 130,000 MILES WITH THE FRONT DRIVER SIDE TIRE. BOTH MECHANICS I BROUGHT IT TO SAID THIS WAS A COMMON PROBLEM FOR MY TYPE OF VEHICLE. THEY ALSO MENTIONED THAT WHEN THIS OCCURS THE ENTIRE WHEEL COULD FALL OFF AND RESULT IN A MAJOR ACCIDENT IF TRAVELING AT HIGH SPEEDS. *KB

2004 CHEVY TAHOE SPEEDOMETER STICKS AT VARIOUS SPEED LEVELS AND INTERMITTENTLY WILL NOT RETURN TO ZERO WHEN THE VEHICLE IS NOT IN MOTION. SPEEDOMETER CAN STICK AT EXCESSIVE SPEEDS INDICATED ON THE CLUSTER, THIS HAD INTERMITTENTLY EFFECTED THE CRUISE CONTROL OPERATION. THIS WAS A KNOWN ISSUE BY GM, NO RECALL WAS PROVIDED. MY VEHICLE IS OVER 80,000 (82,500) MILES. ISSUE STARTED WITH MY VEHICLE AT ABOUT 78K, BUT WAS NOT BROUGHT IN BY ME TO GM BECAUSE THERE WAS NOT AN ANNOUNCED RECALL. GM DECIDED TO REPLACE THE CLUSTERS FOR CUSTOMERS WHO HAD THE DEFECT OCCUR BETWEEN 70 AND 80K, WITH A CHARGE FOR THE LABOR, NOT THE PART. GIVEN THE FACT THIS IS A SAFETY ISSUE (SPEED INDICATION AND INTERMITTENT CRUISE CONTROL, GM SHOULD PROVIDE FULL REPLACEMENT, PARTS AND LABOR. *TR

WHEN AIR CONDITIONER IS RUNNING, AIR COMING FROM DRIVER'S SIDE VENTS BECOME EXTREMELY HOT WHILE PASSENGER'S SIDE REMAINS COOL. I CANNOT DETERMINE ANY SPECIFIC CONDITIONS THAT MADE THIS OCCUR. IT SEEMS TO BE TOTALLY RANDOM. THE HOT AIR IS NOT WARM AIR OR PRETTY HOT AIR, IT IS EXTREMELY HOT, HOTTER THAN A HAIR DRYER PRODUCES AT ITS HOTTEST. I REPORT THIS BECAUSE IT IS OBVIOUSLY A SAFETY HAZARD AND, JUDGING FROM COMPLAINTS SHOWING ON INTERNET BLOGS, IT IS FAIRLY COMMON. APPARENTLY CHEVROLET IS ADMITTING NO RESPONSIBILITY FOR THIS FAILURE, EVEN DENYING THAT IT IS A COMMON PROBLEM.

TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT THE BRAKE PEDAL WOULD DEPRESS TO THE FLOOR WHENEVER THE BRAKES WERE ENGAGED AND IT WOULD TAKE REPEATED HEAVY PRESSURE TO STOP THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. AN AUTHORIZED DEALER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 04V045000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 70,000.

THE ENGINE CYLINDER HEADS FOR THE 5.3L GM MOTORS BUILT BY CASTECH LEAK COOLANT INTO THE ENGINE CAUSING ENGINE OVERHEAT AND INTERNAL ENGINE FAILURES. GM HAS ISSUED A TECHNICAL BULLETIN #060601019B TO ADDRESS THE ISSUE AND DIAGNOSE THE ISSUE. GM WILL NOT OFFER CUSTOMERS ANY FINANCIAL HELP IN THE REPLACEMENT OF THE DEFECTIVE PARTS. THIS ISSUE EFFECTS THE SAFETY OF THE VEHICLE AND THE SAFETY OF THE PERSONS IN AND AROUND THE VEHICLE. THE FOULED ENGINE OIL CAUSES THE LIFTERS TO FAIL, THE OIL PRESSURE TO DROP AND THE ENGINE TO LOCK UP DUE TO LACK OF LUBRICATION BY THE FOULED OIL AND THE DRIVER HAS NO WAY OF KNOWING THIS IS HAPPENING AS THERE IS NO EXTERNAL INDICATORS. *TR

MY 2004 CHEVROLET TAHOE HAS A PROBLEM WITH THE SPEEDOMETER NOT GIVING ACCURATE READINGS. IT WILL JUMP FROM 0 TO 120 MPH AND STICK SOMEWHERE IN BETWEEN OR GIVE A FALSE MPH READING OR JUST GO TO ZERO AND REGISTER NOTHING. THE PROBLEM SEEMS PREVALENT WITH ALL TAHOES. GM NEEDS TO HAVE A RECALL AND FIX THIS DANGEROUS SITUATION INSTEAD OF CHARGING EVERYBODY $500-$900 WHEN THEY KNOW THEY HAVE A SERIOUS DEFECT. THIS PROBLEM HAS BEEN ONGOING NOW FOR THE LAST 2 YEARS. *TR

2004 CHEVY TAHOE (108K MILES) SPEEDOMETER WAS STUCK AT 70 MPH, THEN SLOWLY DECREASED DOWN TO ZERO. OVER THE NEXT 3 WEEKS IT BECAME MORE SPORADIC AND NOW IT ONLY READS "0" ALL THE TIME. MECHANIC WANTED TO CHARGE ME $350 TO REPLACE THE ENTIRE INSTRUMENT CLUSTER. THIS IS A KNOWN DEFECT AND CHEVY SHOULD TAKE RESPONSIBILITY FOR IT. *TR

HI THIS IS REGARDING A DEFECT IN THE LOCKING SYSTEMS OF PARTICULAR GM TRUCKS AND SUVS THE FACT THAT THE DOOR LOCKS ON MY TAHOE AND OTHER SIMILAR SUVS AND TRUCKS CAN BE PUNCHED IN WITH A SCREWDRIVER AND THAT SIMULATES A KEY. THAT MAKES THESE TYPES OF VEHICLES EASY TARGETS FOR ROBBERY (ESPECIALLY THE THIRD ROW SEATS) WHICH ACCORDING TO THE POLICE OFFICER WHO I FILED THE REPORT WITH IS HAPPENING A LOT WITH THESE VEHICLES. I CONTACTED MY CHEVY SERVICE REP AND HE CONVEYED THE SAME PROBLEM AND THAT DEALERSHIP ACTUALLY OFFERS AN AFTERMARKET BRACKET FOR THESE VEHICLES TO PREVENT THE LOCK FROM BEING PUNCHED IN AT A COST OF $189. HERE IS THE PROBLEM MY TRUCK AND THE OTHERS THAT FALL INTO THIS CATEGORY ESCALADE, TAHOE, SUBURBAN, ETC ARE EXPENSIVE VEHICLES AND SHOULD NOT BE REQUIRED TO PURCHASE AN AFTERMARKET PART (USUALLY AFTER ARE VEHICLES HAVE BEEN BROKEN INTO) FOR A DEFECT IN THE LOCK SYSTEM . I HAVE DONE SOME RESEARCH AND EVERY TIME A THIRD ROW SEAT IS STOLEN IT IS ABOUT A $2500 REPLACEMENT AND USUALLY REQUIRES A CLAIM THROUGH INSURANCE AND THAT LEAVES THEM OUT A LOT OF MONEY BECAUSE OF THIS LOCK DEFECT. I CONTACTED GM AND TO SEE WHAT GM INTENDS TO DO ABOUT THIS SITUATION IF ANYTHING AT ALL GM RESPONDED WITH A SIMPLE CANT HELP YOU NOT OUR PROBLEM. I AM OUT ABOUT $600 WHICH INCLUDES ME REPLACING MY DOOR HANDLE WITHOUT THE KEY ENTRY AS I SEE THIS BEING THE ONLY WAY TO DETER FURTHER BREAK-INS AND WHAT WAS STOLEN FROM MY TRUCK AND I KNOW THERE ARE MANY OTHERS THAT ARE IN THE SAME SITUATION. I FEEL THAT THIS IS SOMETHING THAT GM NEEDS TO ACKNOWLEDGE AND ADDRESS THE SITUATION AS IT IS COSTING CUSTOMERS AND INSURANCE COMPANIES TONS OF MONEY BECAUSE GM WILL NOT CHANGE THIS DOOR LOCK. THE OFFICE SAID THIS HAS BEEN A GROWING PROBLEM AS CRIMINALS LEARN HOW EASY IT IS TO BREAK IN THESE VEHICLES WITH A SCREWDRIVER AND OUR ALARM, SECURITY DEVICES WILL NOT ACTIVATE AND IF MY LOCAL DEALERSHIP HAS TO OFFER AN AFTERMARKET BRACKET TO TRY TO FIX IT THERE IS A PROBLEM. PLEASE LOOK INTO IT! *TR

THE ALL SEASON GRABBER TIRE TREAD TOR APART AS DRIVING ON THE HIGH WAY THE TIRE IS HERE STILL BUT THE TREAD OF THE TIRE IS NOT THE TIRE NUMBERS IS : DOT # A3723MN 0103 P265/70R16 ALL SEASON AW. *TR

1) NORMAL DRIVING, SOME HIGHWAY OF NOT MORE THEN 3 HRS IN ONE DIRECTION AND AROUND TOWN. 2-3) EL DORADO ZTR 265/70/16 - TIRE SEPARATION OF 2 OF 4 BOUGHT. A 3RD IS ON ITS WAY TO THE SAME PROBLEM. AVOIDED A CRASH BY ONLY A FEW MILES AS WHEEL VIBRATION WAS EXTREME. I HAD PURCHASED THE TIRES FROM "WHEEL CITY" IN CORONA CA. AND THEY WOULD NOT FIX THE PROBLEM. I DID CONTACT SOMEONE AT EL DORADO IN PENNSYLVANIA WHO CONNECTED ME WITH A "COOPER" TIRE DEALER IN CALIF. TO PRO-RATE MY DEFECTIVE TIRES. 2 OF 4, ALTHOUGH 4 WERE DESIRED, WERE REPLACED. DOT # TIRE 3: UT72 EMD 0607 G9L1 TIRE 4: UT72 EMD 0607 G09L. *TR

THIS VEHICLE HAS HAD NUMEROUS, FREQUENT, AND PERSISTENT ELECTRICAL PROBLEMS. THE APPROXIMATE DATE GIVEN WAS WITH THE AIR CONDITIONING WHERE IT BLEW ONLY HOT AIR. TWO "REPAIRS" AT THE DEALER AND TWO SUBSEQUENT REPAIRS FINALLY REVEALED ELECTRICAL PROBLEMS. THE REAL SAFETY ISSUES THAT CONTINUE ARE WITH THE INSTRUMENT PANEL THAT HAS AT TIMES AFFECTED THE SPEEDOMETER, TACHOMETER (CONTINUOUS PROBLEM), OIL PRESSURE GAUGE (CONTINUOUS PROBLEM), AND NO DASH LIGHTS AT NIGHT. COMPUTER ANALYSES AND RESETS HAVE NOT SOLVED THE PROBLEM. MANY OTHER PEOPLE HAVE HAD THE SAME ISSUE, AS EVIDENCED BY TESTIMONIALS ON FORUMS AND COMPLAINTS. THE DANGER IN THIS IS LIGHTS GOING OUT TO A BLANK DASH AT NIGHT, ENGINE PROBLEMS THAT COULD RESULT FROM THE LACK OF A FUNCTIONING OIL GAUGE, AND INACCURATE OR NO SPEED READINGS. SHOULD BE A RECALL FOR THE CONTROL PANEL SYSTEM AT THE LEAST. THANK YOU. *TR

SPEEDOMETER DOES NOT INDICATE CORRECT SPEED. SPEEDOMETER DOES NOT RETURN TO ZERO MPH WHEN VEHICLE STOPPED. SPEEDOMETER IS INTERMITTENT. *TR

TRANSMISSION HAD TO BE REPLACED AND I PAID FOR HALF, GM GOODWILL PAID FOR HALF. WHEN YOU PAY OVER $42,000 FOR A VEHICLE IT SHOULD LAST MORE THAN 50,000 MILES! *TR

CONSUMING OIL AND WATER - NEEDING 1-2 QUARTS OF OIL AND 1 GALLON WATER/COOLANT PER 900 MILES. NO LEAKS, NO DRIPPING, NO SPOTS ON GARAGE FLOOR. AT START UP, THERE IS A LARGE CLOUD OF BLUE/WHITE SMOKE FROM EXHAUST. SOMETIMES THERE IS A VERY LOUD TAPPING IN THE ENGINE UNTIL WELL AFTER REACHING NORMAL TEMPERATURE. OIL AND WATER IS BEING CONSUMED INTERNALLY - DUE TO CRACK IN CYLINDER HEAD WHICH IS A KNOWN ISSUE WITH CERTAIN ENGINE BLOCKS. *TR

VEHICLE WAS TAKEN TO CHEVROLET DEALER FOR A SUSPECT SYSTEM RESTRAINT ISSUE WITH INDICATIONS FROM THE AIR BAG DASH LIGHT. FIRST REPAIR WAS DIAGNOSED WITH CODE"C0041". CODE LEAD THE DEALER TO THE DRIVERS SEAT. THE TECHNICIAN REPORTED THE ISSUE TO BE A WIRING PROBLEM UNDER THE SEAT WITH RUBBING OF THE WIRING. AIR BAG LIGHT DID GO OUT FOR A SHORT PERIOD OF TIME AND THEN STARTED TO FLASH BACK ON AND OFF. WITHIN THE PAST TWO MONTHS THE LIGHT HAS STARTED TO STAY LIT ABOUT 90% OF THE TIME. VEHICLE WAS RETURNED TO THE CHEVROLET DEALER, TROUBLE CODE REPORTED THE SAME CODE (C0041), NOW THE DEALER IS INDICATING THE PROBLEM TO BE THE "SEAT AIR BAG MODULE". DEALER WANTS TO SPLIT THE COST OF THE REPAIR 50/50 NOW AFTER AN INITIAL CHARGE OF $275 AGAINST A CURRENT ESTIMATE OF $570. *TR

WHEN I PULL THE DOOR HANDLE OUT TO OPEN THE DOOR IT DOES NOT GO BACK IN. THEREFORE, THE DOOR DOES NOT LATCH CLOSED AND IT FLIES OPEN WHILE DRIVING DOWN THE ROAD. THIS PROBLEM BEGAN WITH THE DRIVER'S DOOR AND IS NOW DOING THE SAME THING ON THE PASSENGER FRONT DOOR (WHICH IS RARELY USED). BETWEEN THE 2 DOORS, THEY HAVE FLOWN OPEN THREE TIMES AT DIFFERENT SPEEDS. THANK GOODNESS THE INDIVIDUALS HAD THEIR SEATBELTS ON AND WERE NOT THROWN FROM THE VEHICLE. I VISITED A CHEVY DEALER AT WHICH TIME THE SERVICE PERSON OILED THE HANDLE. IT DID NOT HELP NOR DID IT CHANGE ANYTHING THIS INDIVIDUAL STATED SEVERAL TIMES "I DO NOT FEEL COMFORTABLE WITH THIS AT ALL" AND TOLD ME TO CONTACT GM FOR ASSISTANCE ON THE REPAIR COSTS. UPON CONTACTING GM CUSTOMER SERVICE AND EXPLAINING THAT THIS IS A HUGE SAFETY ISSUE, I WAS TOLD THEY WOULD DENY MY CLAIM AND ARE UNWILLING TO PAY FOR ANY REPAIRS TO MY VEHICLE BECAUSE IT WAS OUT OF WARRANTY. I AGAIN EXPLAINED THAT THIS DEFECT COULD IN FACT KILL SOMEONE AND THEY DID NOT SEEM TO CARE. I WAS TOLD IT IS MY RESPONSIBILITY TO PAY FOR THE DIAGNOSTIC AND THE REPAIRS. THE FACT THAT THE DOORS DO NOT LATCH SHUT AND FLY OPEN WHILE THE VEHICLE IS MOVING AT ANY SPEED IS EXTREMELY DANGEROUS. I AM IN THE PROCESS OF LOOKING INTO GETTING IT REPAIRED VIA A LOCAL MECHANIC. I DO NOT FEEL SAFE IN THIS VEHICLE AND CERTAINLY DO NOT FEEL SAFE HAVING A PASSENGER WITH ME. I CURRENTLY HIT THE HANDLE BACK IN EVERY SINGLE TIME I ENTER THE VEHICLE. I CANNOT STRESS ENOUGH HOW UNSAFE THIS IS. THANKFULLY THERE HAVE BEEN NO DEATHS OR INJURIES YET. HOPEFULLY NO ONE ELSE THAT OWNS A TAHOE HAS EXPERIENCED ANY. PLEASE HELP BEFORE SOMEONE IS KILLED. THANK YOU SO MUCH. *TR

ON THIS DATE THE SPEEDOMETER AND BATTERY GAUGE BEGAN TO GO HAYWIRE, AT FIRST THEY BEGAN TO JUMP UP SO IT LOOKED LIKE I WAS DRIVING FASTER THEN I WAS DOWN THE INTERSTATE. THE NEXT DAY WHEN I DROVE MY TAHOE THE SPEEDOMETER KEPT GETTING HIGHER AND HAS MAXED OUT OVER 120 MPH, AND THE BATTERY METER WELL OVER 19 VOLTS AND THEY DO NOT MOVE ANYMORE. I NOW HAVE TO RELY ON A PORTABLE GPS IN MY CAR TO ESTIMATE HOW FAST I AM TRAVELING. I SEE THERE WAS A CLASS ACTION LAWSUIT ON THIS, BUT I AM 3,000 MILES OVER THE 80,000 REQUIRED TO GET A REPLACEMENT GAUGE CLUSTER. *TR

I HAVE A 2004 CHEVY TAHOE. MY INSTRUMENT PANEL IS MESSED UP. MY SPEEDOMETER DOES NOT WORK, IT FLUTTERS OR PEGS OUT ALL THE WAY. NOW MY OIL GAUGE IS BOTTOM OUT. IN RESEARCHING THE INTERNET, I SEE THAT THIS IS A COMMON PROBLEM AND THAT CHEVY WILL ONLY FIX IT IF YOU HAVE LESS THAN 70,000 MILES. I HAVE OVER 100,000 MILES ON MY CAR AND I CONSIDER IT A SAFETY HAZARD. 98% OF THE TIME I DO NOT KNOW HOW FAST I AM REALLY GOING. I HEARD THAT A RECALL WILL NOT BE ISSUED BECAUSE IT IS NOT A "SAFETY HAZARD". WELL I DISAGREE, BECAUSE PEOPLE ARE NOT ALWAYS AWARE OF THEIR FUEL LEVEL, HOW FAST/SLOW THEY ARE REALLY DRIVING. *TR

2004 CHEVROLET TAHOE Z71. 69K MILES. DRIVER'S POWER SEAT AND BOTH FRONT SEAT HEATERS FAILED SIMULTANEOUSLY. FOUND BURNED ORANGE WIRE IN CONNECTOR AT REAR OF DRIVER'S SEAT BURNED AND CONNECTOR MELTED AT ORANGE WIRE LOCATION. ALSO SAW AREA ON ORANGE WIRE THAT APPEARED TO BE A LOCATION WHERE WIRE WAS PINCHED BY SEAT ADJUSTER MECHANISM. REPAIR OF WIRE AND RELOCATION OF HARNESS AWAY FROM SEAT MECHANICAL PARTS CURED THE PROBLEM. *TR

I HAVE A 2004 TAHOE WITH LESS THAN 50K MILES ON IT. IT HAS NEVER BEEN WRECKED, DRIVEN SPORADICALLY AS THE MILEAGE WILL ATTEST, AND THE REAR WINDOW GLASS HAS BEEN OPENED LESS THAN HALF DOZEN TIMES SINCE IT WAS PURCHASED NEW. ONE OF THE HINGES HAS BROKEN/SEPARATED FROM THE TOP OF THE LIFT GATE GLASS, MAKING IT DIFFICULT TO CLOSE WHEN IT IS OPENED. I HAVE TAKEN IT TO A LOCAL CHEVY DEALER THAT TOLD ME IT WAS A 'COMMON' HAPPENING ON THIS AND SUBURBAN MODELS. THE 'FIX' IS A FULL GLASS REPLACEMENT TO THE TUNE OF AROUND $1000. ANOTHER OPTION IS A THIRD-PARTY FIX WHICH 'MIGHT' WORK AND INVOLVES REGLUING THE HINGE TO THE WINDOW. I FILED A COMPLAINT WITH CHEVY AND RECEIVED A CALL FROM A REP WHO DISAVOWED ANY KNOWLEDGE OF 'ANY' COMPLAINTS REGARDING THIS ISSUE. HOWEVER, THE SERVICE WRITER AT THE LOCAL DEALERSHIP, AS WELL AS TWO OTHER DEALERSHIP EMPLOYEES (DIFFERENT DEALERS) ALL KNEW OF THE PROBLEM AND THE FIX. THIS IS A SERIOUS DEFECT AND SAFETY ISSUE. IT IS QUITE POSSIBLE THAT THIS COULD CAUSE THE GLASS TO BREAK LOOSE AND FLY OFF WHILE DRIVING, MOST LIKELY CAUSING A SERIOUS ACCIDENT. YET CHEVY REFUSES TO ACKNOWLEDGE THE PROBLEM. THEY WERE NO HELP AT ALL, AND THOUGH I TALKED AT LENGTH TO THEIR REP (WHO COULDN'T EVEN PRONOUNCE TAHOE CORRECTLY) THEY REFUSED TO OFFER ANY HELP AT ALL WITH THE REPAIR, LEAVING ME WITH THE PROBABILITY OF A $1000 REPLACEMENT COST OF A PERFECTLY GOOD REAR GLASS JUST TO FIX A HINGE WHICH IS OBVIOUSLY A DEFECTIVE DESIGN. I HAVE OWNED MORE THAN 20 CHEVYS AND IT HAS ALWAYS BEEN MY VEHICLE OF CHOICE, BUT THEY NEED TO STAND BY THEIR PRODUCT AND FIX WHAT THEY KNOW IS A PROBLEM IN THEIR DESIGN AND THROUGH NO FAULT OF THE OWNER/DRIVER. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT THE REAR LIFTGATE DOOR WOULD NOT UNLOCK. THE CONTACT FIRST NOTICED THE FAILURE NOVEMBER 2009. THE DOOR WOULD OPEN AT TIMES AND BECAME PROGRESSIVELY WORSE TO THE POINT WHERE IT WOULD NOT UNLOCK AT ALL. THE CONTACT CALLED THE DEALERSHIP AND WAS INFORMED THAT THEY WOULD CHARGE TO FEE TO INSPECT THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000. THE CURRENT MILEAGE WAS APPROXIMATELY 120,000.

THE SEAT HEATER ON THE DRIVER'S SEAT GETS TOO HOT, MY BROTHER WAS BADLY BURNED ON A ROAD TRIP VERY QUICKLY, INSTANT HUGE BLISTER, HE COULDN'T ADJUST THE HEAT BEING UNFAMILIAR WITH MY TAHOE AND THERE WAS NO WHERE TO PULL OVER SAFELY. *TR

2004 CHEVORLET TAHOE SPEEDOMETER BEGAN TO SHOW THAT THE SPEED WAS TO SLOW THAN I WAS GOING. NOW ITS SHOWING I AM GOING FASTER THAN I AM. TONIGHT MY SPEEDOMETER IS STUCK ON 0 MPH. *TR

THE SPEEDOMETER ON MY 2004 TAHOE DOES NOT GIVE ACCURATE SPEED READINGS. IT SAID I WAS DOING 62 MILES AN HOUR ON THE HIGHWAY AND I STARTED PASSING EVERY CAR ON THE ROAD. I SLOWED DOWN AND THEN IT NEVER GOT ABOVE 15 MILES AN HOUR AND I WAS ON THE HIGHWAY. AFTER SHUTTING OFF THE TAHOE FOR A FEW MINUTES IT WORKED AGAIN. THIS HAPPENS REGULARLY IF I DRIVE THE CAR FOR MORE THAN ABOUT 30 MINUTES AT A TIME. *TR

WOW! I JUST GOT OFF THE PHONE WITH CHEVROLET ABOUT MY SPEEDOMETER NOT WORKING AT ALL. THE REP STATED THIS WAS NOT A RECALL BUT AN EXTENSION OF THE WARRANTY FOR THE CLUSTER IF YOUR VIN# FALLS W/IN A CERTAIN RANGE. MINE FALLS W/IN THE RANGE BUT I'M OVER 80,000 MILES AND I BOUGHT THE CAR USED SO HAD NO IDEA ABOUT THE WTY EXTENSION. THIS MAKES NO SENSE TO ME THE CLUSTER / SPEEDOMETER IS NOT AN ADDED FEATURE OR ACCESSORY, BUT MANDATORY ON ALL VEHICLES. IN OTHER WORDS NO VEHICLES ARE PURCHASED WITH OUT IT. WHY IS THIS NOT A RECALL IT IS A SAFETY ISSUE! THERE WAS A LAWSUIT ON THIS, BUT ONLY EXTENDED THE WARRANTY MILEAGE, WHAT???? IT IS DEFECTIVE NO MATTER WHAT THE MILEAGE, RECALL IT BEFORE SOMEONE IS SERIOUSLY HURT DUE TO AN ACCIDENT. I GUESS UNTIL IT'S RECALLED WE CAN JUST GUESS WHAT SPEED WE ARE GOING, THAT'S LEGAL, RIGHT? HELP ASAP!!!!! *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET TAHOE. WHILE DRIVING 65 MPH THE REAR WINDOW SEPARATED FROM ITS FRAME. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIAN COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 64000.

TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT COOLANT WAS SLOWLY LEAKING INTO THE CYLINDER HEAD, CAUSING THE ENGINE TO OVERHEAT. THE DEALER WAS NOTIFIED OF THE FAILURE WHO ADVISED THAT THE CYLINDER HEAD BE REPLACED. THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THAT THE CONTACT SHOULD TAKE THE VEHICLE TO THE DEALER FOR REPAIRS. THEY OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 105,000.

1. NORMAL DAILY DRIVING 2. THE SPEEDOMETER STOPPED WORKING AS DID THE TACHOMETER, BATTERY GAUGE AND OIL PRESSURE GAUGE. 3. NOTHING WAS DONE. NOT A RECALL NOT UNDER WARRANTY. *TR

MY ANTI-LOCK BRAKES ARE ACTIVATING AT LOW SPEEDS WHEN THERE IS NO APPARENT REASON FOR THEM TO BE DOING SO. *TR

THE HINGE THAT HOLDS THE REAR LIFT GATE WINDOW ONTO THE VEHICLE HAS BROKEN/SEPARATED FROM THE GLASS DUE TO STRESS OR IMPROPER INSTALLATION. THE WINDOW IS IN TACT, BUT THE WINDOW PART OF THE LIFT GATE CANNOT BE OPENED AND CLOSED PROPERLY AND WHEN CLOSED, IT IS NOT SEATED IN THE PROPER POSITION. THIS PART OF THE LIFT GATE HAS PROBABLY BEEN USED ABOUT 5 TIMES IN THE LIFE OF THE TRUCK WHICH NOW HAS ABOUT 53,000 MILES ON IT. I HAVE REPORTED THE PROBLEM TO CHEVROLET WHICH DENIES ANY KNOWLEDGE OF THIS HAPPENING TO OTHER VEHICLES. I AM CONCERNED ABOUT THE POSSIBILITY OF THE WINDOW BREAKING LOOSE ENTIRELY DURING THE TIME THE VEHICLE IS BEING DRIVEN. CHEVROLET'S ONLY OPTION IS TO 'TRY' TO GLUE THE PART BACK ONTO THE WINDOW OR REPLACE THE WINDOW ENTIRELY AT MY COST OF NEARLY $1000. THIS IS NOT ACCEPTABLE AND IN MY OPINION, IS A SERIOUS ACCIDENT WAITING TO HAPPEN. I BELIEVE IT NEEDS TO BE ADDRESSED AS A SAFETY ISSUE AND A RECALL ISSUED TO HAVE THIS TAKEN CARE OF. *TR

I WAS DRIVING DOWN ONE OF THE BUSY ROADS IN MANATEE COUNTY, AND THE BACK HATCH GLASS OF MY 2004 CHEVY TAHOE BLEW OFF OF MY CAR. IT WENT AIR BORN AND LANDED IN THE SOUTH BOUND LANE ALMOST ON TOP OF A CAR. IF THE CAR HAD NOT SLAMMED ON ITS BRAKES AND SWERVED, IT COULD HAVE KILLED SOMEONE. I CONTACTED THE DEALERSHIP, AND THE WILL NOT FIX THE PROBLEM. THE HINGES ARE STILL ATTACHED TO MY VEHICLE AND THE INSURANCE COMPANY WANTS A $500 DEDUCTIBLE. I KNOW I HAVE BEEN ONLINE RESEARCHING THIS KIND OF INCIDENT AND I AM NOT THE ONLY PERSON TO HAVE THIS PROBLEM. I FEEL LIKE IT SHOULD BE A RECALL BEFORE SOMEONE GETS KILLED. IT IS NOT NORMAL FOR A 4 YEAR OLD VEHICLE TO HAVE ITS GLASS BLOW OFF. *TR

MY TRUCK IS BLOWING HOT ON DRIVER SIDE AND COLD ON THE PASSENGER SIDE. THERE ARE HUNDREDS OF PEOPLE OUT THEIR WITH THE SAME ISSE. THIS SHOULD BE A RECALL BY GM SEE THIS WEB SITE FOR MORE DETAILS HTTP://AUTOFORUM.CLASSIFIEDS1000.COM/CHEVROLET-SILVERADO_1500_PICKUP/DUAL_AC_BLOWS_COLD_AIR_ON_PASSENGER_BUT_HOT_ON_DRIVER. *TR

2004 CHEVROLET TAHOE. SPEEDOMETER FAILURE AT AROUND 80,000 MILES. I'VE BEEN RUNNING ON THE SPEED INDICATOR OF MY GPS FOR THE LAST 20,000 MILES. SPEEDOMETER FAILURES, DUE TO FAULTY EQUIPMENT, SHOULD BE REPAIRED IN A RECALL BY THE MANUFACTURER. THE "SILENT" RECALL ISSUED IN 2007 NEVER MADE IT TO ME AND IT WAS ONLY FOR CARS UNDER 70,000 MILES. SPEEDOMETERS ARE "SAFETY" EQUIPMENT. THEY SHOULDN'T FAIL AS OFTEN AS THE 2004 MODEL YEAR GENERAL MOTORS VEHICLES ARE FAILING. THERE ARE WAY TOO MANY PEOPLE HAVING TO SPEND FOUR-HUNDRED TO SIX-HUNDRED DOLLARS ON A REPAIR THAT SHOULD BE GENERAL MOTORS RESPONSIBILITY. *TR

I HAVE BEEN SEEING COMMERCIALS ABOUT AIRBAGS NOT DEPLOYING ON CHEVY VEHICLES. MY DAUGHTER WAS KILLED IN MY 04 CHEVY TAHOE WHERE THE AIRBAGS DID NOT DEPLOY. SHE WAS THROWN FROM THE VEHICLE AND ALSO ANOTHER PERSON WAS IN THE CAR AS WELL. AIRBAGS ON THE DRIVERS OR PASSENGERS SIDE DID NOT DEPLOY. THE TRUCK FLIPPED SEVERAL TIMES. THE DRIVERS SEAT ALSO LIFTED UP AND WAS SPLIT IN TO. WE ASKED THE INVESTIGATORS AND OUR INSURANCE COMPANY TO CHECK INTO WHY THE AIRBAGS DID NOT DEPLOY AND THEY SAID IT WAS NORMAL, BUT WE KNEW OTHERWISE. THEY DID NOT TAKE ANY FURTHER ACTION. *TR

SPEEDOMETER REGISTERS 80MPH AT COMPLETE STOP, 120 MPH WITH MOVEMENT. PROBLEM DID OCCUR WITHOUT WARNING. AT THIS TIME NOT REPAIRED BECAUSE I DO NOT HAVE $500. I THINK IT IS A SAFETY ISSUE AND CHEVROLET SHOULD PAY FOR REPAIR EVEN IN MY CAR IS OVER 70,000 MILES (IS 83,000 NOW). I THINK WE ALL WANT TO SAVE AMERICAN CAR INDUSTRY (WITH THE HELP OF TAXPAYERS MONEY), BUT WE NEED TO SEND THE MESSAGE TO THESE PEOPLE THAT THEY SHOULD BE MAKING RELIABLE CARS. PLEASE WE NEED A RECALL FOR THE PROBLEM. I DO WANT TO KEEP BUYING AMERICAN, BUT YOU NEED TO HELP US OUT. *TR

PURCHASED 2004 TAHOE FOR MY SON THINKING IT WAS A RELIABLE VEHICLE. LITTLE DID I KNOW THAT I GOT A LEMON! THE INSTRUMENT PANEL WAS THE FIRST TO GO, ALTHOUGH NOW IT SEEMS TO BE IN THE SUGGESTED MODE, ENGLISH. THEN, THE SPEEDOMETER STARTED ACTING ERRATICALLY, GOING FROM 55 MPH TO 120 MPH IN LIKE SECONDS. I BELIEVE THE VEHICLE HAS ABOUT 105,000....WHAT HAPPENS NOW? I HEAR ITS EXPENSIVE TO FIX AND I DON'T THINK I SHOULD HAVE TO PAY FOR IT. THIS IS A DEFECT AND CLEARLY THERE ARE THOUSANDS OF PEOPLE OUT THERE WITH THE SAME PROBLEM....PLEASE HELP.. *TR

2004 CHEVY TAHOE POWER STEERING FAILURE AND SIMULTANEOUS LOSS OF POWER BRAKES! IT COULD HAVE BEEN A DISASTER IF I HAD BEEN GOING FAST OR IN HEAVY TRAFFIC! *TR