There are 17 owner-reported lighting complaints for the 2002 Dodge Grand Caravanin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
WHEN THE LOW BEAMS ARE ON ONE HEADLIGHT IS OUT AND WHEN THE HIGH BEAMS ARE ON THE OTHER HEADLIGHT IS OUT. I HAD IT FIXED TWICE BY TWO DIFFERENT SHOPS UNTIL I FOUND THAT THE PROBLEM IS THE FRONT COMPUTER MODULE. THE FIX IS A NEW FRONT MODULE WHICH IS AROUND $550.00 (PART IS 450/LABOR 100). MY COMPLAINT IS THAT IT IS A SAFETY ISSUE AND VERY EXPENSIVE TO FIX, ALSO IT TOOK QUITE SOME TIME TO FIGURE OUT EXACTLY WHAT NEEDED TO BE FIXED, DURING THAT TIME I DIDN'T FEEL SAFE IN THE VEHICLE DRIVING AT NIGHT. I BELIEVE THERE SHOULD BE A RECALL ON THIS MODULE AS I HAVE SEEN MANY OTHER PEOPLE WHO HAVE HAD THE SAME PROBLEM. *TR
TL* THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HEADLIGHTS MALFUNCTIONED WHILE DRIVING 25 MPH AND ONLY THE PASSENGER SIDE HEADLIGHT WAS OPERABLE. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 89,500.
TL*THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE CONTACT STATED THE DRIVER SIDE LOW-BEAM AND PASSENGER SIDE HIGH BEAM HEADLIGHTS WOULD NOT OPERATE. THE CONTACT REPLACED THE HEADLIGHT BULBS AND THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE MULTI-FUNCTION SWITCH WAS REPLACED. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08E039000 (EXTERIOR LIGHTING: HEADLIGHTS). THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE DEALER TO VERIFY WHETHER THE VIN WAS INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE VIN WAS UNAVAILABLE.
MY VAN IS A 2002 AND IT HAS THE DRIVERS SIDE LIGHT OUT WHILE THE PASSENGER STAYS ON. WHEN I PULL THE HIGH BEAM SWITCH THE PASSENGER SIDE GOES OUT AND THE DRIVERS SIDE COMES ON. MY BAD LIGHT CHANGES SIDES AS I CLICK THE DIMMER SWITCH. I HAVE REPLACED THE DIMMER SWITCH, AND BOTH HEADLIGHTS AND THAT DID NOT FIX THE ISSUE. IF YOU HOLD IN THE DIMMER SWITCH WHEN THE LIGHTS ARE ON BRIGHT, BOTH THE BRIGHT LIGHT ON ONE SIDE AND THE DIM LIGHT ON THE OTHER SIDE ARE ON. *TR
WHEN THE IGNITION IS FIRST TURNED ON, THE DAYLIGHT LIGHTS COME ON THE DRIVER SIDE ONLY, THE PASSENGER LIGHT IS OFF. WHEN THE HEADLIGHTS ARE TURNED ON THE PASSENGER SIDE TURNS ON ONLY, THE DRIVER SIDE IS OFF. WHEN HIGH BEAMS ARE TURNED ON THE DRIVER SIDE COMES ON ONLY, AND THE PASSENGER SIDE IS OFF. VERIFIED THE BULBS THEY'RE ALL OK.? *TR
HEADLIGHT MALFUNCTION. DRL ONE ON ONE OFF, HEADLIGHTS OPPOSITE ON/OFF, HI-BEAMS OPPOSITE ON/OFF. REPLACED FCM, WORKED OK FOR A FEW WEEKS, BUT IS MALFUNCTIONING AGAIN. *TR
I HAVE A 2002 DODGE GRAND CARAVAN THAT HAS HAD HEADLIGHT TROUBLES FOR NEARLY TWO YEARS. WHEN YOU TURN THE VAN ON, ONLY THE RIGHT HEADLIGHT TURNS ON. WHEN YOU TURN THE HEADLIGHTS ON, ONLY THE LEFT HEADLIGHT TURNS ON. WHEN YOU TURN THE BRIGHTS ON, ONLY THE RIGHT HEADLIGHT TURNS ON. ALWAYS, ONLY ONE LIGHT AT A TIME. WE HAVE REPLACED ABOUT THREE DIFFERENT SWITCHES AND WE STILL CAN'T SEEM TO FIND THE TROUBLE.(NO, IT ISN'T THE BULB). THIS HAS GONE ON LONG ENOUGH. EVEN THE DEALER CAN'T SEEM TO FIND THE TROUBLE AND IT NEEDS TO BE RECALLED FOR THIS PROBLEM. *TR
THE TAIL LIGHT COVER ON THE PASSENGER REAR BLEW OFF AS I TRAVELED ON A HIGHWAY. THE TAIL LIGHT COVER HAD COME LOOSE. WHEN EXAMINED THE GLUE APPEARED TO HAVE FAILED. I THOUGHT IT WAS STRONG ENOUGH TO HOLD. I WAS WRONG. NOW I HAVE A TAIL LIGHT WITHOUT A LENS SO THE LIGHTS ARE WHITE WHEN I PUT ON MY BRAKES OR TURN SIGNAL. *TR
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS WORKED INTERMITTENTLY. ON TWO OCCASIONS, THE HEADLIGHTS WENT OUT SUDDENLY WITHOUT WARNING. THE DEALERSHIP WAS INFORMED. UPDATED 09/13/06. *JB
SINCE THE PURCHASE OF THIS VEHICLE, I HAVE EXPERIENCED HEAD LIGHT-INTERIOR FLICKERING TO WHICH THE DEALER CANNOT SOLVE. *JB
I HAVE HAD 2 BRIEF HEADLIGHT FAILURES (10 SECONDS OR SO) AND MY HEADLIGHTS OCCASIONALLY FLICKER OR DIM. MY LIGHTSWITCH GETS VERY HOT WHEN THE LIGHTS ARE ON FOR MORE THAN 30 MINUTES.
HEADLIGHTS ON 2002 DODGE GRAND CARAVAN FLICKER. THIS HAPPENS FREQUENTLY. *AK
THE HEADLIGHTS MALFUNCTIONED TWICE IN THE PAST MONTH WHILE ON THE ROAD AT NIGHT. TAKEN TO DEALER FOR TESTING, AND RESULTS SHOWED THAT THE CAUSE WAS UNDETERMINED.*AK
THE HEADLIGHTS TURNED ON AND OFF INTERMITTENTLY, MAKING IT DIFFICULT TO SEE THE ROAD WHEN IT IWAS DARK. CONSUMER INFORMED THE DEALER, BUT THE CAUSE WAS UNDETERMINED.*AK
THE TURN SIGNALS WILL INTERMITTENTLY WORK IN REVERSE. FOR EXAMPLE, IF I ENGAGE THE LEFT TURN SIGNAL, THE RIGHT DASH LIGHT WILL FLASH ALONG WITH THE RIGHT TURN SIGNAL LIGHTS. THIS REVERSE PROCESS ALSO HAPPENS SOMETIMES WHEN I ENGAGE THE RIGHT TURN SIGNAL. *NLM
DRIVING HOME AT NIGHT WHEN THE HEADLIGHTS FLICKERED ON AND OFF. TURNED ON THE HIGH BEAMS IN ORDER TO GET HOME. DEALER REPLACED THE FRONT CONTROL MODULE. *NM
TL*THE CONTACT OWNS A 2002 DODGE GRAND CARAVAN. THE HEADLIGHTS WOULD INTERMITTENTLY TURN OFF AT NIGHT AND TURN BACK ON AFTER 1-2 SECONDS. OCCASIONALLY, THE HEADLIGHTS WOULD NOT ILLUMINATE AGAIN FOR SEVERAL MINUTES. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 40,000. UPDATED 03-0408 *BF
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026