2006 Dodge Grand Caravan Complaint Log

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point it smelled like the vehicle was on fire. I have had several calipers and rotors replaced, numerous brake pads and not all of these repairs has been done by the same garage. I read complaints from others about the manufacturers brake system is too small for this style vehicle. They have experienced the same problems I have had. I bought this vehicle in 2015 and I have 155,000 miles on it. I have had to replace a water pump and spark plugs and wires, regular oil changes, etc. The only real problem I have had has been the brakes. I have spent almost $3,500 on brakes alone. I would think the braking system could be a very hazardous situation in the traffic of today. Please help me and others who are experiencing this problem with the braking systems on the 2006 Dodge Grand Caravans. Thank you.

The contact owns a 2006 Dodge Grand Caravan. The contact stated that on several occasions, the air bag warning light illuminated for two minutes and then disappeared. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 146,032.

The headlights and taillights come on randomly throughout the day and night while the car is parked and off. The warning dings for accidentally leaving your lights on happens every time you open the doors even though the lights are off. This has been going on since we got the vehicle.

LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF WHENEVER I TURN A CORNER LEFT OR RIGHT OF HIT A BUMP.

SLIDING DOOR LOCK ACTUATOR FROZE UP.THIS RENDERSTHE SLIDING DOOR COMPLETELY INOPERABLE.IF THAT DOOR WAS NEEDED FOREGRESS,IT WOULDNT BE AVAILABLE!!

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD NOISES COMING FROM THE STEERING COLUMN. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE VIN WAS INCLUDED IN AN UNKNOWN RECALL; HOWEVER, NO RECALL WAS FOUND. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000.

DRIVER SIDE SLIDING DOOR IS LOCKED AND CAN'T BE UNLOCKED MANUALLY OR WITH FOB OR OVERHEAD BUTTON. VERY WORRIED ABOUT PASSENGERS NOT BEING ABLE TO EXIT DURING AN EMERGENCY. *DT CONSUMER STATED SHE WILL TAKE IT TO HER LOCAL DODGE DEALER.*JB

DRIVER SIDE SLIDING DOOR STUCK IN LOCKED POSITION. UNABLE TO UNLOCK USING DOOR LOCK SWITCH, UPPER CONSOLE DOOR SWITCH, KEY FOB OR MANUALLY. PASSENGER STUCK AND HAD TO CRAWL OUT DIFFERENT DOOR.

AIR BAG SENSOR LIGHT KEEPS COMING ON, STAYS ON, THEN GOES OFF, THEN BACK ON WHILE DRIVING.

SLIDING DOOR LOCK ACTUATOR FROZE UP. THIS RENDERS THE SLIDING DOOR COMPLETELY INOPERABLE. IF THAT DOOR WAS NEEDED FOREGRESS, IT WOULDN'T BE AVAILABLE.

2006 DODGE CARAVANS HAVE A DUMMY SPARE TIRE LOCATED NEAR THE GAS TANK SUBJECT TO ALL WEATHER CONDITIONS AND THEY BECOME DRY ROTTED AND CAN EXPLODE.THERE IS NO PROTECTION COVER THAT PREVIOUS DODGE CARS HAD. I HAD ONE BLOW AS I WAS ABOUT TO USE IT ON THE VAN. I SINCERELY NO ONE HAS ONE BLOW WHILE MOUNTED NEAR THE GAS TANK. *TR

THE REAR POWER LIFT GATE ON MY 2006 DODGE GRAND CARAVAN DOES NOT STAY OPEN WHEN LOADING OR UNLOADING ITEMS BUT KEEPS CONTINUALLY CLOSING HARD AUTOMATICALLY WHEN NEEDING TO HAVE IT STAY OPEN TO ALLOW FOR LOADING OR UNLOADING. THIS HAPPEN WHETHER ONE TRIES TO OPEN THE DOOR USING THE HANDLE MANUALLY OR AUTOMATICALLY WITH THE KEY FOB. THIS HAS HAPPENED OVER THE LAST 3 OR 4 YEARS ESPECIALLY DURING WINTER BUT NOT CONFINED TO WINTER ONLY. MY GRANDSON AND MYSELF ALMOST GOT CAUGHT MORE THAN ONCE AND INJURED IN ITS UNEXPECTED DOWNWARD FREE-FALL. THIS IS VERY DANGEROUS TO ANYONE TRYING TO ACCESS THE BACK PORTION OF THE VAN AS THE HEAVY LIFT GATES CLOSES ON THEM TRAPPING THEM AND CAUSING POTENTIAL SERIOUS INJURY. THIS HAPPENS WHEN VEHICLE IS STATIONARY AND IN THE GARAGE OR STATIONARY IN A SHOPPING PARKING LOT WHEN LOADING GROCERIES OR OTHER PURCHASES. OR WHEN PUTTING THE REAR SEATS UP OR DOWN TO UTILIZE BACK PORTION OF VAN. SOMEONE CANNOT HOLD THE LIFT GATE OPEN WHEN ANOTHER IS TRYING TO ACCESS THE BACK OF THE VAN AS THE LIFT GATE FALLS HARD AND CANNOT BE STOPPED. THERE ARE CURRENTLY 93,360 MILES DRIVEN.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS TRANSPORTED TO THE HOSPITAL, BUT THERE WERE NO INJURIES OR MEDICAL ATTENTION NEEDED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THERE WAS AN OIL LEAK IN THE ENGINE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

WHEN DRIVING IN RAINY CONDITIONS (NOTE: WET ROAD, NOT HIGH WATER), POWER STEERING FAILED AND VAN WAS UNCONTROLABLE. THIS HAS HAPPENED 2X IN THE PAST YEAR. DEALERSHIP SAYS THIS IS A COMMON ISSUE WITH THIS MODEL, AS WATER CAN GET TO THE POWER STEERING BELT. THEY OFFERED NO SOLUTION. I NEARLY RAN INTO A DITCH AS I WAS UNABLE TO STEER. THANKFULLY I WAS ABLE TO STOP THE CAR WITHOUT CAUSING AN ACCIDENT, BUT THIS WAS A DANGEROUS SITUATION. BOTH TIMES THIS HAPPENED I WAS DRIVING ON A CITY STREET IN RAINY CONDITIONS.

I'VE TAKEN THE VEHICLE TO PEPBOYS TWICE BECAUSE ALTHOUGH THE GAS GAUGE WAS WORKING, THE VEHICLE WOULD CLICK THE GAS NOZZLE OFF AND WOULD NOT ACCEPT FUELING. PEPBOYS REPLACED THE IN-TANK PUMP AS A REMEDY TWICE. DODGE/CHRYSLER SAID IT WAS THE BREATHER TUBE. WHO'S RIGHT?

INTERMITTENT TURN SIGNAL OPERATION PROBLEM. RIGHT SIGNAL TURNS ON WHEN ATTEMPTING TO SIGNAL LEFT, HAVE TO THEN SWITCH TO RIGHT AND BACK TO GET LEFT TO TURN ON. HAPPENS WHILE IN OPERATION AND IN MOTION, CHECKED OUT FINE WHEN PARKED.

EVERY TIME I FILL UP THE THE VAN DIES OR RUNS POORLY FOR A FEW MINUTES. I IS ALWAY IN TRAFFIC WHEN IT DIES. I FILL UP AND PULL OUT INTO THE ROAD AND IT DIES. STARTS BACK AT ONCE BUT IT IS VERY DANGEROUS

I TURNED INTO A DRIVE WAY AND THE CAR LOST CONTROL. BREAKS LOCKED AND I WOULDN'T STOP

I WENT IN FOR MY INSPECTION STICKER FOR MY 2006 DODGE GRAND CARAVAN, IT FAILED DUE TO THE AIRBAG LIGHT BEING ON. THERE ARE KNOWN ISSUES WITH THE AIRBAG SENSOR, BUT MINES NOT COVERED UNDER THE RECALL, BUT ITS THE SAME ISSUE.

I RECENTLY TOOK MY CAR IN FOR AN INSPECTION STICKER, BUT IT FAILED DUE TO THE AIR BAG SENSOR LIGHT BEING ON. I LOOKED UNDER THE RECALLS AND THEIR IS A RECALL FOR THIS ISSUE FOR THE YEAR AND MAKE OF MY CAR, BUT WHEN I SEARCH THE VIN NUMBER IT CLAIMS THAT MY CARE IS NOT INCLUDED IN THE RECALL. CAN THIS BE LOOKED INTO SO THAT MY CARE CAM BE INCLUDED AND I CAN GET THE ISSUES FIXED. I HAD MY INSPECTION DONE ON 3/2/18.

CAR AIRBAG LIGHT CAME ON AT ABOUT 68,000 MILES ONCE AND THEN AT 78,000 IT CAME ON AND STAYS ON ALL THE TIME. THIS IS MY SECOND 2006 DODGE GRAND CARAVAN AND THAT ONE DID THE SAME THING. HAD TO GET RID OF IT BECAUSE OF RUST AT 192,000 MILES. WHENEVER I START UP AND DRIVE, IT IS CONSTANTLY ON NOW. NEVER GOES OUT.

VEHICLE OFTEN STALLS SHORTLY AFTER REFUELING. CAN BE VERY DANGEROUS IF PULL OUT INTO TRAFFIC. HAS HAPPENED AT LEAST A DOZEN TIMES. DOES NOT HAPPEN WITH EVERY FILL-UP, BUT IS BECOMING MORE FREQUENT.

EVERY TIME IT RAINS OR I TAKE MY CAR TO THE CAR WASH THE AIRBAG LIGHT COMES ON. AFTER A DAY OR TWO IT GOES OFF. I TOOK IT TO A MECHANIC WHO TOLD ME THAT MY VAN HAD STORED CODES FOR ' NO RIGHT FRONT SIDE IMPACT SENSOR COMMUNICATION ' AND 'RIGHT FRONT IMPACT SENSOR INTERNAL 1'. IN RESEARCHING THIS ISSUE I DISCOVERED RECALL #10V008000 WHICH COVERS 2005 AND 2006 GRAND CARAVANS AND PRETTY MUCH DESCRIBES EXACTLY WHAT IS HAPPENING TO MY VAN. HOWEVER, WHEN I CONTACTED DODGE I WAS TOLD THAT MY PARTICULAR VIN NUMBER IS NOT COVERED UNDER THE CURRENT RECALL. I FIND IT VERY STRANGE THAT MY VAN FITS ALL OF THE PARAMETERS FOR THE RECALL BUT IS EXCLUDED.

I HAD SUSPENSION WORK COMPLETED ON MY VEHICLE (INNER/OUTER TIE RODS, RACK AND PINION AND CONTROL ARMS REPLACED BY A SHOP) AFTER DRIVING BACK TO TEXAS I NOTICED BOTH FRONT TIRES WERE EXTREMELY WORN AND WAS CLOSE TO A BLOW OUT. I CONTACTED THE SHOP ABOUT IT AND THEY REFUSED TO WORK WITH ME. AFTER TAKING MY VEHICLE TO A LOCAL REPAIR SHOP THE MECHANIC STATED THAT THE ALIGNMENT APPEARED TO NOT HAVE BEEN DONE AND THAT THE SPECS WAS OFF THE CHARTS. THE MECHANIC CONTACTED THE SHOP THAT MADE THE INITIAL REPAIRS AND THEY DENIED NOT COMPLETING AN ALIGNMENT. I'VE HAD THIS VEHICLE FOR OVER 11 YEARS AND MY TIRES HAVE NEVER WORN THIS FAST AND IT DIDN'T HAPPEN UNTIL THIS REPAIR SHOP DID THE SUSPENSION WORK ON MY VEHICLE. THE SHOP NEEDS TO BE INVESTIGATED FOR UNSAFE MAINTENANCE PRACTICES. THEIR MAINTENANCE AND LACK OF SAFETY STANDARDS PUT THE SAFETY OF MY FAMILY IN JEOPARDY, AND THEY'RE STILL IN DENIAL OF ANY WRONG DOING NOR ARE THEY WILLING TO PROVIDE ME SPECS OF THE ALIGNMENT THEY SAID THEY DID. PHOTOS ARE ATTACHED.

THE AIR BAG LIGHT GOES ON AND OFF PERIODICALLY, BOTH WHILE DRIVING AND STOPPED, TYPICALLY AFTER A RAIN STORM.

RUSTING BODY PANELS CAN RESULT IN SEVERE SAFETY ISSUES IN NEAR FUTURE, EVEN WITH GREAT CARE, SOME VEHICLES ARE PRONE TO THE RUSTING BODY PANELS. THE 4TH GENERATION (GRAND) CARAVAN ISN'T THE EXCEPTION WHICH HAD EXCESSIVELY AGGRESSIVE RUST FORMING ON THE BODY PANELS. MY GRAND CARAVAN CURRENTLY HAS JUST OVER 65000 MILES WITH RUST FORMING ON MAJOR PANELS. I PERSONALLY TOOK OVERLY ATTENTION TO THE VEHICLE MAINTAINING AND CARING BY WAXING AND WASHING THE VEHICLE THE PROPER WAY, YET THE VEHICLE IS PILING WITH MORE AND MORE RUST EACH WEEK. ON THE ROAD, I HAVEN'T GOT TO SEE THE DODGE CARAVAN THAT HAS NO RUST WHAT SO EVER. THEREFORE, THE RUSTING HAS TO BE THE MOST CONCERNING ISSUE FOR THE CARAVAN OWNERS.

*TAKATA RECALLS" MY SLIDING SIDE DOORS ON BOTH SIDES SCRATCHES THE SIDES OF MY VAN ON THE EXTERIOR.

WE PURCHASED VAN NEW FROM DODGE DEALER IN SEPTEMBER OF 2006. ABOUT 5 MONTHS AGO MY WIFE (NORMALLY DRIVES) STALLED PULLING TOWARD AN INTERSECTION SHORTLY AFTER SHE DROVE FROM FILLING THE GAS TANK. THE VAN RUNS FINE OTHERWISE AND NOW HAS ABOUT 112K MILES. THIS HAPPENED TO HER A FEW MORE TIMES (VERY STRESSFUL LOSING POWER STEERING AND BRAKES). THEREFORE, ONE FILL-UP TO CHECK IT I DROVE THE CAR AND IT DID THE SAME A COUPLE MINUTES AFTER FILL-UP DRIVING 1/4 MILE SLOWLY IN NEARBY HOME DEPOT PARKING LOT (AFRAID I WOULD HIT SOMEONE TRYING TO TURN (SIMILAR CONDITIONS AS MY WIFE HAD). THE VAN WILL RESTART AFTER TRYING A COUPLE OF TIMES AND THEN RUN FINE FOR THE REST OF THE TANK. WE HAVE BEEN FORCED TO STOP FILLING THE TANK ABOVE 3/4, AN INCONVENIENCE TO PLAN FOR BUT SEEMS TO ELIMINATE THAT PROBLEM; BUT I AM NOT SURE HOW MUCH LONGER THAT WILL WORK. IN DOING RESEARCH I UNDERSTAND OTHER DODGE VAN OWNERS IN THAT YEAR RANGE HAVE HAD THIS PROBLEM. APPARENTLY, DUE TO THE DESIGN OF THE VALVE THAT IS FAILING THE ENTIRE GAS TANK MUST ALSO BE REPLACED WHICH IS VERY COSTLY. I FEEL THAT CHRYSLER USED A VERY POOR DESIGN OR PART WHERE IF ONLY THE VALVE FAILS THAT THE ENTIRE GAS TANK MUST BE REPLACED. THE VAN RUNS FINE, WE LIKE THE VAN AND WERE PLANNING TO DRIVE IT MANY MORE MILES BUT AT THIS POINT THE COSTLY REPAIR INVOLVED IS A GOOD PORTION OF THE VEHICLE VALUE. I THINK THAT CHRYSLER SHOULD HELP US IN REPAIRING THIS ISSUE. IT IS OBVIOUSLY A SAFETY ISSUE WHEN DRIVING THE CAR, AND A DESIGN FLAW IN MY OPINION IN THAT FAILURE OF A SMALL COMPONENT REQUIRES THE WHOLE GAS TANK SYSTEM TO BE REPLACED. PLEASE LET US KNOW CHRYSLER'S POSITION ON THIS ISSUE. WE REALIZE THAT THE VEHICLE IS OUT OF CHRYSLER'S WARRANTY BUT FEEL THIS IS SOMETHING THAT SHOULD HAVE BEEN RECTIFIED WHEN THE ISSUE BECAME KNOWN A NUMBER OF YEARS AGO. THANKS IN ADVANCE

TAKATA RECALL 1. THE KEY FOB, AUTOMATICALLY CONTROLLED REAR DOOR HATCH DOES NOT STAY OPEN WHEN USING THE KEY FOB OR MANUALLY OPENING THE HATCH DOOR. IT HAS CLOSED NEARLY UPON MYSELF - THE OWNER, AND OTHERS - WITHOUT WARNING WHEN STOPPED, MOTOR OFF AND LOADING OR UNLOADING ITEMS. THERE IS NO WAY TO ASSESS WHAT CAUSED THIS AS IT GETS BELOW NORMAL WEAR. SINGLE PARTY USE, NO KIDS. THIS INCIDENCE STARTED 12/12/2016 2. THE FRONT BRAKES MAKE A SCRAPING NOISE AND WOBBLING OF STEERING WHEEL UPON COMING TO A STOP. THIS WAS MENTIONED TO THE DEALER EARLIER THIS YEAR AND BRAKES, PADS AND ROTORS WERE CHECKED AT DEALER, AND IT WAS STATED THAT NOTHING WAS WRONG. NEW BRAKE PADS WERE INSTALLED IN 2013. THE CAR MILEAGE IS 85241 MILES. THE WHEELS HAVE BEEN ROTATED, ALIGNED. THE CAR HAS REGULAR, ROUTINE MAINTAINANCE, THE BRAKES STILL SCRAPES AND WOBBLES THE STEERING WHEEL. THIS HAS BEEN A RECURRING INCIDENCE.

TL* THE CONTACT OWNED A 2006 DODGE GRAND CARAVAN. WHILE THE CONTACT'S DAUGHTER WAS DRIVING 35 MPH, SHE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS DID NOT RETRACT. AS A RESULT, THE CONTACT'S DAUGHTER STRUCK HER HEAD ON THE STEERING WHEEL. A POLICE REPORT WAS FILED. THE DAUGHTER SUSTAINED A HEAD INJURY AND WAS UNCONSCIOUS. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

WAS DRIVING ABOUT 35 MPH AND SLIDING DOOR CAME OPEN WHILE THE CAR WAS IN MOTION AND DOORS WERE LOCKED AND CHILD LOCK WAS ENGAGED ON THAT SIDE. IT HAS ALSO HAPPENED ON THE PASSENGER SIDE AS WELL ON THE INTERSTATE AT HIGHWAY SPEEDS.

UNABLE TO FILL WITH GAS AT SERVICE STATION (EVAPORATIVE SISTEM). THE NOZZLE KEPT SHUTTING OFF EVEN THOUGH THE TANK WAS NEARLY EMPTY.

AFTER FUELING MY 2006 DODGE CARAVAN IT WILL STALL, OR SPUTTER TO ALMOST STALLING THEN REV UP AND ALMOST STALL AGAIN SEVERAL TIMES. AFTER A FEW TIMES OF STALLING AND SPUTTERING IT THEN RUNS FINE. THE PROBLEM IS THAT THIS HAPPENS USUALLY RIGHT AFTER PULLING OUT OF THE GAS STATION, WHICH USUALLY INVOLVES PULLING OUT INTO TRAFFIC. TWO TIMES THIS HAPPENED, BEFORE I KNOW BETTER NOW, IT HAPPENED AFTER PULLING OUT ONTO THE ROAD AND STALLING IN THE MIDDLE OF 4 LANE ROADS. LUCKILY THE FIRST TIME THERE WAS NO TRAFFIC AND THE SECOND TIME I WAS GOING DOWNHILL ON A STRAIGHT ROAD AND WAS ABLE TO COAST UNTIL I GOT THE VAN STARTED. ALTHOUGH I AM AWARE OF THE PROBLEM NOW, THIS COULD BE DANGEROUS. ALSO THIS IS A BUSINESS VEHICLE AND PEOPLE OTHER THAN MYSELF DRIVE THE VEHICLE. MY EMPLOYEES MAY NOT BE ABLE TO REACT TO A STALL IN THE MIDDLE OF A ROAD AS I AM.

ENGINE ROUGH IDLE AFTER FUELING AND OCCASIONALLY STALLS ON ROAD

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. WHILE TRYING TO RESTART THE VEHICLE, THE CONTACT NOTICED THAT THE KEY FELL OUT OF THE IGNITION. THE CONTACT REPLACED THE KEY AND WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

I WAS SITTING AT IDLE WARMING UP MY VAN AND AIR BAG LIGHT CAME ON I TRIED CLEARING COMPUTER AND LIGHT JUST CAME BACK ON VEHICLE WAS STATIONARY AND HAS NEVER BEEN IN AN ACCIDENT

UPON REFUELING, THE VEHICLE EXPERIENCES A DELAYED STALL, MEANING THAT THE VEHICLE DOES START WITHOUT HESITATION; HOWEVER, WITHIN A FEW YARDS OF DRIVING, THE VEHICLE STALLS. MORE SPECIFICALLY, IT STALLS UPON BRAKING TO YIELD OR TURN JUST AFTER FUELING. ONCE THE VEHICLE STALLS, IT CAN BE RESTARTED AND THE PROBLEM DOES NOT PRESENT ITSELF AGAIN UNTIL THE NEXT FILL UP. THIS IS A SAFETY ISSUE AS THE VEHICLE MAY STALL IN THE MIDDLE OF ENTERING A BUSY STREET POTENTIALLY CAUSING AN ACCIDENT. THIS GETS PROGRESSIVELY WORSE WITH EACH FILL UP BECAUSE ALTHOUGH THE ENGINE DOES TURN OVER, IT TAKES LONGER TO DO SO EACH TIME AND MAY EVENTUALLY NOT TURN OVER AT ALL. INTERNET RESEARCH AND DIAGNOSTIC FROM A CERTIFIED MECHANIC INDICATE THAT IT IS THE LIQUID SEPARATOR VALVE. FURTHER RESEARCH SHOWS THAT THIS IS A COMMON PROBLEM WITH CHRYSLER MINIVANS. THE VALVE CANNOT BE REPLACED WITHOUT REPLACING THE ENTIRE GAS TANK. THE VALVE CANNOT BE PURCHASED SEPARATELY. BECAUSE THE VALVE IS CONSIDERED AN EMISSIONS PROBLEM AND THE GAS TANK IS NOT, SOME WARRANTY COMPANIES WILL NOT COVER THE REPLACEMENT. THIS PLACES THE CONSUMER AT RISK BECAUSE THE HIGH COST MAY NOT BE FEASIBLE AND THE CONSUMER MAY OPT TO CONTINUE TO DEAL WITH THE VEHICLE STALLING IN LIEU OF REPAIRS. IF THIS IS A COMMON PROBLEM WITH THESE VEHICLES, CHRYSLER SHOULD EITHER RECALL OR ALLOW THE VALVE TO BE PURCHASED SEPARATELY.

I HAVE A 2006 GRAND CARAVAN AND LATELY, EVERYTIME I FILL IT UP, IT STALLS OUT ON ME A FEW TIMES. I ALMOST GOT HIT PULLING OUT ONTO A HIGHWAY LAST WEEK.I CALLED THE DEALERSHIP AND HE WAS AWARE OF THE PROBLEM. SAID I SHOULD NOT FILL THE TANK BECAUSE IT WOULD OVERFLOW ON SOME VALVE CAUSING THE STALLING. HE HAD OTHER CUSTOMERS COMPLAIN. MY QUESTION IS, WHY IS THIS NOT FIXED?. I NEED TO FILL MY TANK AS I TRAVEL A LOT. I DON'T WANT TO STOP AND GET GAS OFTEN. AND I SURE DON'T WANT TO GET HIT TRYING TO LEAVE THE GAS STATION. I GOT ONLINE AND LOOKED UP COMPLAINTS. HERE IS JUST ONE LIST I FOUND. HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM WITH THIS BEING A MAJOR PROBLEM WITH SO MANY, I THINK CHRYSLER SHOULD HAVE A RECALL FOR THE SAFETY OF SO MANY PEOPLE. I NEVER HAD A PROBLEM UNTIL RECENTLY SO THIS TELLS ME, SOMETHING IS FAULTY IN THE GAS TANK. AS SOON AS I FILL IT AND DRIVE OFF, IT STALLS, ONCE IT'S DRIVEN A WHILE, IT WORKS FINE. I THINK THE DEALERSHIP IS WRONG TO COVER UP THE REAL PROBLEM.

I AM HAVING A INTERMITTENT ISSUE WITH MY HEADLIGHTS, THEY ARE SHUTING OFF WHILE DRIVING AND ALTHOUGH CRYSLER HAS A LIFETIME WARRANTY ON THE HEAD LIGHT SWITHCH FOR THIS EXACT ISSUE MY VEHICLE VIN IS NOT INCLUDED IN THIS WARRANTY. THIS IS DANGEROUS AND SHOULD BE A RECALL AS PEOPLE COULD BE IN DANGER OF CRASHING IF THIS HAPPENS AND THEY ARE UNABLE TO SEE.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT 30 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FAILURE OCCURRED IMMEDIATELY AFTER THE FUEL TANK WAS FILLED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

SIDE SLIDING DOORS WILL NOT UNLOCK MANUALLY OR ELECTRICALLY. EXTREME SAFETY ISSUE; HAVE ELDERLY PARENTS AND IF ACCIDENT OCCURRED WOULD NOT BE ABLE TO GET THEM OUT! HAVE REPLACED THE ACTUATOR 3 TIMES IN LAST 2 YEARS ON DRIVER SIDE. PASSENGER SIDE HAS BEEN REPLACED TWICE. WHY IS THERE NOT A RECALL ON THESE?

POST REFUELING STALLS. WHILE GOING ON LONG TRIPS, AFTER REFUELING IN THE REST AREAS, THE MINIVAN STALLS WHILE ENTERING THE HIGHWAY CAUSING ME TO PANIC WHILE AVOIDING HIGH SPEED TRAFFIC GOING BY. THIS HAPPEN MANY TIME DURING A TRIP TO FLORIDA FROM INDIANA.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT IT TOOK SEVERAL ATTEMPTS TO START THE IGNITION. THE FAILURE HAS OCCURRED FOR A MONTH. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM). THE PART WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 66,114.

WHILE DRIVING ON BUSY URBAN HIGHWAYS WITH LIMITED OR NO SHOULDER, THE VEHICLE STARTED MAKING CLUNKING NOISES, ORIGINATING FROM THE LEFT SIDE, WHEN DRIVING OVER BUMPS, POTHOLES AND OTHER ROAD IRREGULARITIES. NOT WANTING TO PULL OVER IN AN AREA WITH LIMITED SHOULDER LANES, I CONTINUED DRIVING, BUT THE NOISE BECAME PROGRESSIVELY WORSE OVER A PERIOD OF 50 MILES OR SO, TO THE POINT THAT I WAS ACTIVELY SEEKING A SAFE PLACE TO PULL OVER AND CHECK THE VEHICLE. BEFORE I HAD A (SAFE) OPPORTUNITY TO DO SO, A MUCH LARGER CLUNK WAS HEARD, AND THE VEHICLE INSTANTLY EXPERIENCED GREATLY IMPAIRED DIRECTIONAL CONTROL. I IMMEDIATELY SLOWED, AND WAS ABLE TO BRING THE VEHICLE TO A CONTROLLED STOP ON THE SHOULDER. VISUAL INSPECTION IMMEDIATELY SHOWED THAT THE FRONT DRIVER SIDE WHEEL HAD EXCESSIVE NEGATIVE CAMBER. THE STRUT SHAFT WAS ALSO NO LONGER MATED TO THE STEERING BEARING AT THE TOP OF THE STRUT TOWER, AND WAS RESTING AGAINST THE SIDE OF THE STRUT TOWER. THE TOP SURFACE OF THE STRUT SHAFT HAD AN IRREGULAR, ROUGH FEEL TO IT, SUGGESTIVE OF BRITTLE FAILURE. AFTER LIMPING THE VEHICLE DOWN THE NEAREST OFF-RAMP (APPROXIMATELY 1/2 MILE) AT LOW SPEED (10 MPH) I PARKED HE VEHICLE, AND HAD IT TOWED TO A LOCAL PEP BOYS, WHICH REPLACED BOTH FRONT STRUT ASSEMBLIES.

TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM) EXCEEDED A REASONABLE TIME FOR REPAIR. THE CONTACT RECEIVED A RECALL NOTIFICATION IN JUNE OF 2015; HOWEVER, THE DEALER PLACED THE CONTACT ON A WAITING LIST AND STATED THAT THE PART WAS NOT AVAILABLE FOR REPAIR. THE DEALER DID NOT KNOW WHEN THE PART WOULD BE AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

MY HEADLIGHTS HAVE BEEN TURNING ON BY THEMSELVES WHILE THE SWITCH IS IN THE OFF POSITION.

THIS VEHICLE HAS A STALK ON THE STEERING COLUMN THAT CONTROLS THE WINDSHIELD WASHER, WIPER, AS WELL AS THE VEHICLE BRIGHT LIGHTS, AND THE TURNING SIGNALS. AROUND MAY. 2014 THE WASHER BEGAN WORKING INTERMITTENTLY. SOMETIMES IT WOULD WORK, SOMETIMES NOT. WIGGLING THE STALK WOULD SOMETIMES MAKE IT WORK. BY PULLING THE STALK TOWARD THE DRIVER, THE BRIGHT LIGHTS ARE SUPPOSE TO COME ON TEMPORARILY, UNTIL RELEASED. THEY STOPPED WORKING, ALSO ABOUT MAY, 2014. IT IS STILL WORKING INTERMITTENTLY, BUT NOW THE TURNING SIGNALS ARE ALSO AFFECTED, WORKING INTERMITTENTLY, OR EVEN PUTTING ON THE LEFT TURN SIGNAL, WHEN THE SWITCH IS TURNED FOR A RIGHT TURN, OR RIGHT FOR LEFT. I AM AFRAID THAT THIS SWITCH IS DEFECTIVE, AND CAN CAUSE AN ACCIDENT IF IT DOES NOT WORK RELIABLY.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 141,000.

MY HUSBAND AND I GOT THIS VEHICLE LAST YEAR FROM A BUY HERE PAY HERE PLACE. IT IS ALMOST PAID OFF BUT ALMOST THE ENTIRE TIME HAVEING VAN IT KEEPS DIEING WHILE DRIVEING. WE KEEP ASKING THE DEALER WHY IT IS DOING THIS AND THEY HAVE NO IDEA WHAT IS WRONG. IT IS NOT SAFE TO BE DRIVEING THIS VAN. I HAVE A 6,5,4,1 YEAR OLD AND MY HUSBAND AND SELF IN VAN. WE HAVE ALMOST BEEN IN A CAR ACCIDENT AT LEAST 10 TIMES BECAUSE THE VAN KEEPS DIEING WHILE DRIVEING, PUT IT IN PARK WHENEVER THE VEHICLE STOPS ROLLING UNABLE TO STEER OUT OF THE WAY BECAUSE CAR POWERS OFF AND STOPS RUNNING. SOMEONE PLEASE HELP I DON'T WANT MY FAMILY KILLED OR INJURED BECAUSE THE VAN KEEPS DIEING WHILE DRIVEING AND NO ONE KNOWS WHY