2017 Ford Escape Complaint Log

I am writing to formally express my deep dissatisfaction and concern regarding a serious mechanical failure in my 2017 Ford Escape, which has associated with safety issues. The issue began with a check engine light accompanied by a diagnostic trouble code indicating a misfire in cylinder 2. Upon further inspection, it was determined that coolant was leaking into the engine — a problem that ultimately led to catastrophic engine failure. Searched online and found it is common issue for this type of car but we did get notice and no warranty coverage offered to address it. The fact that this is a widely reported problem suggests a potential manufacturing or design defect that Ford has failed to proactively acknowledge or address. This issue also caused a big safety issue to the customer.

The contact owns a 2017 Ford Escape. The contact stated that when the vehicle was started, the check engine warning light illuminated, and the vehicle was shaking slightly. The vehicle was taken to the dealer and was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 85,000.

2017 Ford Escape with 2.0L EcoBoost engine. Experienced rough engine/shutter and check engine light (MIL) came on. Code scanner found P0302 for PCM. Took to dealership and they found coolant intrusion into cylinder requiring a full engine replacement. They quoted almost $10,000 to fix. This is a know design flaw/defect with this engine and Ford has reworked design at least twice to address. Unfortunately, they left existing owners with ticking time bombs in the form of a likely expense repair or early demise to the vehicle.

The contact owns a 2017 Ford Escape. The contact stated that while his wife was driving 30 MPH, there was an abnormal vibrating sound coming from the engine compartment. The contact stated that the check engine warning light was illuminated. The contact stated that a dealer was contacted. The vehicle was taken to a dealer where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 73,786.

The contact owns a 2017 Ford Escape. The contact stated that the check engine warning light had been illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure but no assistance was provided. The failure mileage was 65,000.

1.5 engine failure due to coolant intrusion into the cylinder.

Our engine has quit working due to the much publicized coolant intrusion issue by Ford and the Escape model vehicle. I called Ford customer service and they would do nothing to help with the expensive engine repair left but what is being called on the internet as a faulty design. It appears to be quite well known and quite common and they addressed it somewhat with the 1.5 liter Escapes but ours is a 2.0 engine and it is happening a lot with that engine too.

I was driving on the interstate when all of a sudden I lost all power, the car started shaking violently, it started leaking and burning oil. I brought it to my local shop and they confirmed that cylinder 3 had a catastrophic failure and it can no longer create any pressure. There were no warning signs. This just happened randomly driving down the interstate.

Coolant intrusion ruined block. Overheated on interstate. My family and I had to wait on side of interstate for many hours in 100 degree weather with nothing to drink. We were sunburnt and dehydrated by the time we got to a motel that evening. Vehicle was towed to Pep Boys. Had to pay for a motel room for 3 days waiting on a diagnosis from them. Finally they informed me of the devastating news so I had to rent a U-Haul and car dolly to tow it back home since we were 300 miles away when this happened. There was a warning light that came on about 5 seconds before car shut off. It is available for inspection at this time.

The contact owns a 2017 Ford Escape. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that there was coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 87,000.

I have a 2017 Ford Escape. Have owned the car for 4 months and it's already experiencing transmission issues i.e. hesitation, slipping etc. Took it the repair shop and found other issues (turbocharger, thermostat, water pump). They claimed they didn't see anything wrong with the transmission. Car ran well for a couple of weeks and then I got transmission fault warning. It wouldn't engage and I couldn't get it in gear. Undrivable. I sat on the side of the road for four hours waiting for a tow. Mechanic says it's either a full transmission problem or the brushing cable.

The contact owns a 2017 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The contact used a diagnostic scanner to retrieve DTC: P0302 (cylinder #2 misfire). The contact replaced the spark plugs and the ignition coils; however, the check engine warning light remained illuminated. The contact stated that while starting the vehicle, there was white smoke coming from the exhaust pipes. The contact stated that after further inspection, the contact became aware that the coolant reservoir was almost empty. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 68,000.

Apparently coolant leaked into the engine causing engine failure. No warning! No fix except to replace the engine for $9,500.

My check engine light came on and the mechanic said it was spark plugs. I had it fixed and then it came on a week later and they said they didn’t know what it was. A week later all my panel was flashing telling me to pull over immediately. I almost got in an accident while trying to pull over in the emergency of the warning. The dealer said it’s a coolant leak in the engine and a fault of Ford’s eco boost engine and nothing at all that is my fault. Now they want $7,100 to fix it and Ford knows they caused the issue in their cars. I don’t know why I should pay for the engine replacement when Ford knows it’s their fault.

The contact owns a 2017 Ford Escape. The contact stated that upon starting the vehicle and shifting into drive(D), the vehicle failed to move as intended. The contact stated that the "Service Transmission Now" message was displayed. The check engine warning light was illuminated. The vehicle was not taken to the dealer or independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 129,000.

Coolant intrusion into cylinders causing engine misfires, spikes in engine temperature, and issues with car starting. The check engine light came on as I started the car, and the engine shuddered as if misfiring. As I was driving the vehicle to get the issue checked out, the vehicle’s extreme temperature warning went off, instructing me to pull over and shut the vehicle off immediately. The coolant reservoir was found to be empty. After replacing the coolant, the car had difficulty starting. After finally getting the vehicle to start, I got it to a service center where it was diagnosed with a blown head gasket and coolant was present in the engine oil. I was informed that the vehicle WAS NOT safe to drive and needed a complete engine replacement.

My Ford Escape has had coolant leak into engine block, causing damage to cylinders and cylinder misfires, detailed in this service bulletin: [XXX] . The car has been checked by my mechanic, who confirms the problem. Dealership acknowledges that this problem is real and has had many customers who have had to replace motors because of it but says there has been no recall or extended warranty in respect to this design flaw and declines to resolve the problem at Ford's cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Check engine light on, running rough on startup. Diagnosed as Coolant Intrusion in Cylinder No. 2 as result of engine warpage.

The contact's wife owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the engine was idling rough. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the engine needed to be replaced due to coolant intrusion into cylinder #2. The dealer related the failure to Technical Service Bulletin: 22-2229 (Coolant in Cylinders, White Exhaust Smoke And/ Or Illuminated MIL); however, the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 44,800.

The contact owns a 2017 Ford Escape. The contact stated while driving 30 MPH, the vehicle jerked and vibrated abnormally, and started to decelerate unintendedly. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer and was diagnosed with coolant intrusion in cylinder #4, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 58,000.

Vehicles transmission, with no warning indicator lights, or any indication whatsoever, failed on me at a busy intersection and nearly caused me and others to be in a possibly fatal accident. It's my knowledge that Ford knowingly produced this 6F35 transmission with a flawed design and with poor engineering. There should be a recall to prevent a possible fatality.

05/03/2025 - My Escape has the 1.5L 4-cylinder engine failed at 118763 miles. Local Ford Dealership installed new Short Block. 09/11/2025 - Engine failed at 122742. Local Ford Dealership installed new Short Block.

The contact owns a 2017 Ford Escape. The contact stated that while his daughter was driving at an undisclosed speed, the check engine warning light illuminated. Additionally, white smoke was coming from the exhaust pipe, and the engine overheated while driving. The vehicle was taken back to the used car dealer, where the vehicle was purchased, and the spark plugs, ignition coils, and oxygen sensor were replaced, but the failure persisted. The vehicle was taken to an independent mechanic, who related the failure to Technical Service Bulletin: 19-2346 (Coolant in Cylinders, White Exhaust Smoke And/or Illuminated MIL); however, the vehicle was not covered under the TSB. The contact was informed that the engine needed to be replaced. The dealer was made aware of the failure but confirmed that the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 91,000.

The Check Engine light was going on and off. I took it into a repair shop and they told me there was a coolant leak in the engine and a full engine repair needs to be done. After looking this up, I came to realize this is a very common issue with the make and model and ford refuses to pay for it.

After having head gasket replaced a year ago. Coolant leaked again into cylynder 3 causing white smoke to come out of exhaust. Ford Dealer looked at car and said the engine was designed wrong... engine needed to be replaced. the headgasket replacement cost 3,000 and now new engine is 7,000

Ford knows about a manufacturing flaw on their engine. I have a coolant leak that caused white smoke to come out of my exhaust while I warm up my car in the garage. I immediately had a mechanic look at it and was told my car is not drivable until I have a head gasket replacement. I am an avid backpacker, and could have been stranded in the middle of nowhere without cell service for a flaw they know about and should remediate.

I have been noticing radiator fluid loss the past few months along with a recent engine light coming on so I took my Ford Escape to Vanderhyde Ford Dealership in Cedar Springs Michigan and they were going to do a leak check on the cylinders to see if antifreeze was leaking but they were only able to get 3 of the 4 spark plug out of engine block. They said they didn't want to break the spark plug off inside the block. I asked what would cause the spark plug to corrode and they said it's possible my #1 cylinder is leaking antifreeze and corroding the aluminum intake manifold and the steel spark plugs. So, I took car back home and let engine cool and I was able to get spark plug out. I now have appointment 7/23/2025 to have cylinders checked for leaks. Updates coming if leak in cylinders is confirmed.

Coolant leaking unknown source

The contact owns a 2017 Ford Escape. The contact stated that while driving at various speeds, there was a misfire coming from the engine intermittently while depressing the accelerator pedal. The failure persisted and the check engine warning light illuminated. The vehicle was taken to the dealer on two separate occasions. On the first occasion, the check engine warning light was reset but the failure returned. On the second occasion, the spark plugs were replaced; however, the check engine warning light returned a month later. The vehicle was then taken to an independent mechanic who discovered coolant intrusion into cylinder #3, resulting in engine failure. The manufacturer was notified of the failure and the contact was provided a case number. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

ABS light and traction light is on then hill assist information comes on then the 4 wheel drive disabled comes on then for minutes later comes back on and says abled. It’s been going on for sometime now but now when I am driving it seems like it just shuts off and then starts again and at times it goes very quick. It is very dangerous. I only have 45000 miles on it.

The contact owns a 2017 Ford Escape. The contact stated that while driving approximately 40 MPH, the check engine warning light illuminated. The contact pulled over and parked in a safe location. The vehicle was towed to the dealer to be diagnosed. The vehicle was diagnosed with coolant intrusion in cylinders #2 and #4. The dealer stated that there was metal inside the cylinder head and pistons. The dealer determined that the long block needed to be replaced. The vehicle was not repaired. The manufacturer opened a case for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 45,000.

Automatic transmission failure burnt smell started coming from the engine compartment but didn't see anything because the engine air filter was on the way but after removing it there was a leak coming from the top of the transmission vehicle only has 129,598 miles and I was in the highway when I notice vehicle deaccelarating and had to pull over almost cause a. Accident because I was in the middle lane Problem has not been addressed by dealer or independent service center No inspection done to the vehicle yet No warning lights until too late which is burnt transmission fluid and transmission in top of transmission

The contact owns a 2017 Ford Escape. The contact stated that while driving 40 MPH, the message to pull over at the earliest safe warning light illuminated. The contact immediately drove the vehicle to the dealer. The contact was informed that there was coolant was leaking into the engine and engine needed to be replaced. The vehicle was not repaired. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 79,000.

Bad engine design flaw causes the cylinder sleeve to become unattached and it rises up , damages the head gasket and ruins the engine. There have been multiple repairs of this year engine in escapes in our area. A very well known defect.

While driving, the transmission shuddered and jerked. I took the car to my garage, where it was diagnosed as needing a new transmission. At the time it had 98,258 miles. The transmission was replaced on 9/1/2023. In September, 2024, the transmission fault message and the check engine light came on. I took the car to Duval Ford where the transmission was rebuilt under warranty. Mileage at that time was 118,754. It took the dealer 3 weeks to get the car back to me. Two weeks ago, again the transmission fault message and the check engine light came on. (Mileage 128,952) Currently I am waiting for a loaner car from Coggin Ford so they can repair the transmission. I have been only driving short distances because I am afraid the transmission will suddenly stop working and I will have an accident or be stranded. I might add that in my 60+ years of driving this is the first time I have ever had transmission problems.

I own a 2017 Ford Escape equipped with the 2.0L EcoBoost engine. I am experiencing a known issue related to engine coolant intrusion into the cylinders, which has been reported by many owners and acknowledged by Ford through Customer Satisfaction Program 21N12. This issue involves coolant leaking internally into the combustion chamber—usually due to a flawed cylinder head casting—which can cause engine misfires, white exhaust smoke, rough idling, overheating, or complete engine failure. In my case, a coolant pressure test was performed, and it confirmed that the cooling system is losing pressure, which is consistent with internal coolant leakage into the engine. Despite this, Ford has declined to cover the repair under the 21N12 program, stating that my vehicle is not eligible by VIN, even though it is the correct model year and engine. I believe this constitutes a safety issue, as the engine could fail at highway speeds without warning, and Ford has failed to provide adequate support for vehicles that clearly exhibit the documented failure pattern. I am requesting the NHTSA investigate this issue further, including why certain 2017 Escapes with the affected 2.0L EcoBoost engine are being excluded from coverage despite confirmed symptoms.

Morning of April 25, 2025 heard unusual engine sound on 2017 Ford Escape, Eco Boost Engine. Evening - check engine light came on. Next morning took to dealer. "Diagnostics: retrieved code P0303, cylinder 3 misfire, pressure test cooling system, cylinder #3 has coolant intrusion, recommend engine assembly." Had we not paid attention to the issue immediately, the engine could have simply stopped running at some point while on the road. 10-11K to replace engine on 8 yr old car with 97K miles on it. Just like that no second car in the family, worthless without an engine, great financial loss and stress. Should be driving it for another 90K miles! Vehicle at home and cannot drive it, sell it, trade it. The 2017 Ford Escape has manufacturing defects (to include the paint)!

coolant leak into two pistons which in past ford escapes could cause the engine to overheat and potentially catch fire. was checked at the ford dealer on 04/24/2025

The contact owns a 2017 Ford Escape. The contact stated while driving at various speeds, the vehicle made an abnormal sound. The check engine warning light was illuminated. The contact stated that a mechanic inspected the vehicle and used a scanner to scan the vehicle. The mechanic informed the contact that there was coolant intrusion into the engine due to the head gasket coolant leak. The vehicle was not repaired. The dealer was contacted and informed the contact that the VIN was not under recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 54,500.

Cool ain’t leak causing rust in engine. Ford admitted to me that this has been an issue with this year model and make.

We were informed by a tech that we had a coolant leak. The leak was soo bad that it was causing damage to the engine and seems to be a common issue with fords made around 2017. We are now unfortunately paying for the car although the damage to the engine has left us with a car we cannot drive.

The contact owns a 2017 Ford Escape. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a certified mechanic who diagnosed that there was coolant leaking into the spark plugs. The spark plugs were cleaned. The contact stated that the check engine warning light illuminated again. The contact stated that white smoke was coming from the exhaust pipe and vehicle was sputtering while idling or accelerating. The vehicle was taken to the dealer who diagnosed that there was coolant leaking into the cylinders, and cylinder #3 cylinder was filled with coolant. The dealer confirmed that Customer Satisfaction Program: 19B37 (Engine and Engine Cooling) was previously completed. The dealer diagnosed the vehicle with complete engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 61,000.

The contact owns a 2017 Ford Escape. The contact stated while driving 50 MPH, the vehicle was shaking abnormally. The check engine warning light was blinking. Upon restarting the vehicle, the vehicle was driven to an independent mechanic and was diagnosed with coolant intrusion into the engine. The contact stated that the failure was related to Customer Satisfaction Program: 19B37. The contact called the local dealer and was informed that there was no recall on the VIN for the failure. The manufacturer was contacted and opened a claim and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 101,261.

I have a major engine failure on the 1.5L ecoboost engine. The engine failed away from home (at Costco) and had to arrange a ride home. Towed to the dealer where they diagnosed a coolant intrusion into #3 cylinder which locked the engine. Researched this and found out that this is a known defect. Ford will do nothing to repair this because I fall outside the window of their multiple Technical Service Bulletins. This vehicle has 68111 miles on it and resides at our home in Arizona. We only use it when we Winter there. I received no notices from Ford about this issue. The safety component of this is that we had just returned from a long day trip in the desert and could have been stranded there. This needs to elevated to recall status because there are so many people in my situation. I have a $14,400 quote to fix an otherwise perfect car that is only worth $7800. This is fraud. Ford needs to be held accountable for poor design/manufacturing as well as hiding this problem as long as it could. Fixing this only when there is a failure and you must fall into a certain window is unacceptable.

The contact owns a 2017 Ford Explorer. The contact stated that there was a hard shift in the transmission when accelerating and decelerating. The contact stated that the vehicle was shaking abnormally while being started. The contact stated while driving approximately 10 MPH, there was white smoke coming from the exhaust system. The contact stated that the check engine warning light illuminated and there was a misfire coming from the engine. The vehicle was taken to the dealer to be diagnosed and the contact was informed that there was coolant leaking into the spark plugs, causing the spark plugs to fuse inside the cylinder. The spark plugs were removed, and it was determined that there was coolant inside cylinder #3 and the engine needed to be replaced. The vehicle was taken to the dealer who confirmed the engine failure and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 88,000.

The contact owns a 2017 Ford Escape. The contact stated while driving approximately 65 MPH, there was a misfire from the engine and the engine was overheating. The engine warning light was illuminated. The contact pulled off the highway and observed that the engine temperature gauge was returning to normal. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and replaced the spark plugs and coils. The contact stated that the failure had reoccurred. The contact took the vehicle back to the same mechanic who diagnosed that there was coolant intrusion into the cylinders and that the engine needed to be replaced. The vehicle was not repaired. The contact had been advised by the mechanic that the coolant intrusion into the engine block was a known failure. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 105,000.

The contact's daughter owns a 2017 Ford Escape. The contact stated that the vehicle began to jerk and hesitate while depressing the accelerator pedal. There was no warning light illuminated. Due to the failure, the vehicle was towed to the dealer and the contact was informed that the transmission needed to be replaced. An independent mechanic inspected the vehicle, and the contact was provided the same information as the dealer, with an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and provided the contact with a case number. The failure mileage was approximately 88,000.

The contact owns a 2017 Ford Escape. The contact stated that when the vehicle was started on several occasions, the check warning light illuminated. The vehicle was shifted into reverse(R), and the vehicle shuddered and jerked before the vehicle stalled. The vehicle was restarted each time. The contact stated that while driving on several occasions at various speeds, the vehicle shuddered and jerked, and stalled. The vehicle was taken to an independent mechanic, where it was diagnosed that there was a misfire in cylinder #3 due to coolant leaking into the cylinder. The contact was informed that the head gasket needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was approximately 113,000.

Coolant Intrusion on my 2017 Ford Escape Ecoboost that requires a new engine.

The contact owns a 2017 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated and remained illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 55,000.