2007 Ford Expedition Complaint Log

THE RUBBER VALVE STEMS ON THE TIRES CRACKED RESULTING IN LOSS OF TIRE PRESSURE. *TR

NHTSA SAID THAT THERE IS NOT A SAFTY CONCERN THAT THE VALVE STEMS ON CERTIN FORD CARS ARE SPLITTING. THEY HAVE CLOSED THE INVESTIGATION APRIL 9, 2009. THAT'S GREAT, EXCEPT THAT ON APRIL 11, 2009 ONE OF OUR VALVE STEMS BLOW OUT WHILE WE WERE DRIVING ON A MOUNTAIN HIGHWAY. THERE WAS NO WARNING AND THE TIRE SHREDDED. 2 18 WHEELERS HAD TO DO ALL KINDS OF MOVES TO AVOID HITTING US. THE ONE NEARLY DID. THE TIRE WAS COMPLETELY SHREDDED AND WE COULD HARDLY GET FAR ENOUGH OFF THE HIGHWAY TO PUT ON THE SPARE. WITH THREE SMALL KIDS IN THE CAR, IT WAS VERY SCARY. THE ON APRIL 25TH, 2009, IT HAPPENED TO THE OTHER FRONT TIRE WHILE WE WERE ON A TRIP. WHEN INSPECTING THE TWO BACK VALVES, THEY WERE BARLEY HOLDING ON. WE WERE IN THE MIDDLE OF NOWHERE AND NOTHING WAS OPENED FOR HELP. *TR

I HAVE EXPERIENCE 3 VALVE STEM FAILURES ON CONTINENTAL CONTITRAC TR TIRES; MODEL P265/70R17 113S ON A 2007 FORD EXPEDITION . THE VALVE STEMS APPARENTLY ARE THE CHINESE MODEL TR-414 STEMS THAT HAVE BEEN DISCUSSED IN SEVERAL AUTOMOTIVE NEWSPAPER COLUMNS. TODAY (6/9/09) I RECEIVED A LETTER FROM FORD MOTOR COMPANY NOTIFYING VEHICLE OWNERS ABOUT THIS PROBLEM. THE FORD REPRESENTATIVE SAID SINCE THIS IS NOT A RECALL, THERE IS NO PROVISION FOR MONETARY REIMBURSEMENT TO VEHICLE OWNERS WHO HAVE HAD THE VALVE STEMS REPLACED. I BELIEVE THIS IS A SAFETY ISSUE AND NHTSA SHOULD CONSIDER A MANDATED RECALL FOR ALL TIRES USING THESE POORLY MGF. VALVE STEMS. MY STEM LEAKAGE PROBLEMS HAVE OCCURRED ON APRIL 9, APRIL 23 AND JUNE 9, 2009. I HAVE ROTATED MY TIRES EVERY 3000 MILES AND THEY HAVE APPROX. 21620 MILES WEAR. FORTUNATELY I HAVE A TIRE PRESSURE MONITORING SYSTEM THAT ALERTED ME TO THE PROBLEMS BEFORE THE TIRES WENT COMPLETELY FLAT OR BEFORE I WAS STRANDED ON THE HIGHWAY. *TR

WE HAVE BEEN HAVING SPORADIC ISSUES WITH A GRATING/GRINDING/SCRAPING NOISE AND A BUCKING/JERKING WITH OUR 35,00MILE 2007 FORD EXPEDITION EL. NO ONE SEEMS TO BE ABLE TO PINPOINT THE PROBLEM (DEALERSHIP, OF COURSE). I'M SURE AT 36,001 MILES THEY'LL FIGURE IT(WARRANTY UP). HELP. I WORRY ABOUT THE SAFETY OF MY THREE CHILDREN, AS WELL AS THE EXPENSE OF FIXING IT. WHEN IT OCCURS LONGTERM (20+ SECONDS) , TAPPING THE BRAKES SEEMS TO RELEASE THE NOISE/HANG UP. YOU CAN ALSO FEEL IT IN THE PEDALS/FLOOR WHEN IT HAPPENS. WHEN THE CAR BUCKS(NOT ALWAYS OCCURRING WITH THE NOISE)- IT REALLY BUCKS. I HAVE PULLED OVER EVERY TIME TO CHECK THAT I HAVEN'T BLOWN A TIRE BECAUSE I KNOW I DIDN'T HIT A POTHOLE OR ROAD DEBRIS AND JUST TO BE SAFE. IT IS TERRIFYING. *TR

MY TIRE FAILED ON MY 2007 FORD EXPEDITION EL MILEAGE 18000, TIRES ARE THE ORIGINAL/FACTORY INSTALLED PIRELLI SCORPION P255/70R18. THE TIRE WENT FLAT AT FREEWAY SPEED AND THE SIDEWALL IS NOW DAMAGED BEYOND REPAIR. UNDER FURTHER INVESTIGATION I FIND THAT THE TIRE DOES NOT HAVE ANY PUNCTURE AND IT IS A CRACKED VALVE STEM THAT IS CAUSING THE LEAK. EVEN WITH THE SIDEWALL DAMAGE THE TIRE TAKES AIR AND THE ONLY LEAK IS COMING FROM THE LEAKING VALVE STEAM. THE FORD DEALER WILL BE REPLACING THE TIRE AT MY COST. I FEEL THIS IS A MANUFACTURER ISSUE AND KNOW THERE IS A RECALL ON THESE AND FORD SHOULD BE REPLACING THE TIRE FOR FREE AND CHECKING ALL OTHER VALVES ON THE VEHICLE. I SPOKE WITH CLAY AT TECH INTERNATIONAL AND HE EXPLAINED THAT FORD HAS NOT RECALLED THESE TIRES BUT TECH INTERNATIONAL HAS RECALLED "AFTER MARKET" TIRE REPLACEMENTS. FORD NEEDS TO TAKE IMMEDIATE ACTION ON THIS TO PREVENT ANY FUTURE FAILURES THAT COULD LEAD TO SERIOUS ACCIDENTS. LUCKILY MY FAILURE DID NOT CAUSE AN ACCIDENT BECAUSE IT WAS A REAR TIRE AND I WAS ABLE TO PULL OVER THE VEHICLE, PREVENTING AN ACCIDENT BUT I DID BEGIN TO LOOSE CONTROL. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING BETWEEN 10-15 MPH ON NORMAL CONDITIONS, THE CONTACT HEARD A LOUD GRINDING NOISE WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE FAILED TO STOP. AFTER SEVERAL ATTEMPTS, THE VEHICLE FINALLY CAME TO A COMPLETE STOP. IMMEDIATELY, THE VEHICLE WAS PARKED IN THE CONTACT'S DRIVEWAY. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE RECURRED, BUT COULD NOT BE DUPLICATED BY THE DEALER AGAIN. THE VEHICLE HAS CURRENTLY BEEN AT THE AUTHORIZED DEALER FOR OVER A WEEK AND IS UNDER INVESTIGATION BY THE ENGINEERS. THE CONTACT REFUSES TO DRIVE THE VEHICLE UNTIL THE CAUSE OF THE FAILURE HAS BEEN DETERMINED AND REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 14,000.

WHILE DRIVING ON DRY PAVEMENT AT APPROXIMATELY 25-35 MPH THE TRACTION CONTROL LIGHT WILL START TO ILLUMINATE RANDOMLY. EVENTUALLY STAYING ON CONSTANTLY. PUSHING THE TRACTION CONTROL BUTTON WILL NOT TURN OFF THE LIGHT. TURNING OFF THE CAR AND STARTING IT AGAIN WILL MAKE IT GO AWAY. ONE TIME WHEN THIS HAPPENED THE ABS BRAKES ENGAGED AND THE BRAKES HAD SIGNIFICANTLY REDUCED STOPPING POWER. I TOOK IT STRAIGHT TO THE DEALER AND THEY DID NOT SEE ANY ERROR CODES IN THE SYSTEM. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE BRAKES FAILED TO OPERATE PROPERLY WHILE DRIVING 30 MPH. THE VEHICLE DID NOT SLOW DOWN WHEN THE BRAKE PEDAL WAS DEPRESSED. SHE HAD TO TAP THE PEDAL FOR APPROXIMATELY 40 SECONDS IN ORDER TO STOP THE VEHICLE. SO FAR, THE FAILURE HAS ONLY OCCURRED ONCE. THE CONTACT FEELS THAT THIS IS A SAFETY ISSUE BECAUSE A SERIOUS CRASH COULD OCCUR. THE CURRENT AND FAILURE MILEAGES WERE 28,436.

TIRES IN MY 2007 FORD EXPEDITION REGULARLY LOSE AIR. LOCAL TIRE SHOP DIDN'T LOCATE LEAK IN TIRE. TIRES WEARING UNEVENLY OVER TIME AND NOW MUST REPLACE ALL FOUR AFTER 30K MILES. UPON REMOVING TIRE AND TIRE SHOP INSPECTING, THEY NOTICED CRACKS IN VALVE STEMS. BOUGHT FOUR NEW TIRES. *TR

AIR VALVE STEMS ARE BREAKING ON ALL 4 TIRES, I KEEP LOSING AIR PRESSURE AND FORD SAYS THEY WONT COMPENSATE---I ONLY HAVE 7,000 MI. *TR

HEARD A HISSING NOISE WHEN I GOT IN MY CAR THIS MORNING. NOTICED A VALVE STEM WAS CRACKED ON BACK TIRE (DRIVERS SIDE). WENT DIRECTLY TO TIRE COMPANY.. HAD TO STOP NUMEROUS TIMES ON THE WAY TO PUT AIR IN THE TIRE BECAUSE THE CRACK WAS GETTING BIGGER. WHEN I ARRIVED AT THE TIRE COMPANY, THE VALVE SNAPPED AND THE TIRE WENT FLAT IN A MATTER OF SECONDS. THE TIRE COMPANY EXAMINED MY VEHICLE AND STATED THAT 2 OTHER VALVES WERE CRACKED. I HAD TO REPLACE 3 VALVE STEMS TODAY. *TR

WAS DRIVING MY 2007 FORD EXPEDITION ON HIGHWAY WHEN LOW TIRE PRESSURE LIGHT CAME ON. EXITED HGWY @ NEXT EXIT & CHECKED ALL TIRES & ADDED AIR TO LEFT FRONT TIRE WHICH WAS LOW & PROCEEDED ON TO AIRPORT APPROX. 10-15 MINS AWAY. AFTER DRIVING APPROX. 10 MINS AFTER STOPPING I WAS FIGHTING TRUCK PULLING LEFT ON INTERSTATE. WHEN I ARRIVED CURBSIDE AT THE AIRPORT, I EXITED THE VEHICLE TO FIND THAT THE LEFT FRONT TIRE WAS ALMOST COMPLETELY FLAT & WAS SEPARATING READY TO HAVE A BLOW OUT. THE TIRE WAS CHANGED OUT FOR THE SPARE & UPON ARRIVING BACK HOME, MY HUSBAND & I INSPECTED THE TIRE FOR ANY FOREIGN OBJECT IN TREAD ONLY TO FIND NONE & THEN TOLD MY HUSBAND OF THE NEWS STORY ABOUT FAULTY VALVE STEMS BUT NO RECALL ISSUED. SO WITH THE BAD TIRE FULL OF AIR LAYING IN DRIVEWAY HE TOUCHED THE VALVE & THE AIR STARTED RUSHING OUT. WE HAVE THE ISSUE WITH THE VALVE STEM THAT YOU ARE INVESTIGATING. WE DO NOT KNOW IF ANY OF THE REMAINING TIRES ARE OK OR NOT AS THE TRUCK IS TO BE TAKEN TO FORD TOMORROW. WE DO NOT FEEL WE SHOULD HAVE TO BUY ANY TIRES AS I DID WHAT I WAS SUPPOSE TO DO & THE STEM FAILED CAUSING ME TO RUIN A GOOD TIRE AND WILL HAVE TO HAVE NOT 1 BUT 2 NEW TIRES. PLEASE HELP US CONSUMERS FIGHT FOR ALL THE MONEY WE SPEND TRYING TO BUY AMERICAN & SUPPORT OUR COUNTRY WITH HARD EARNED MONEY. SOMEONE COULD DIE AS A RESULT OF THEIR PIG HEADEDNESS. *TR

2007 FORD EXPEDITION VALVE STEM ON CAR HAD A LEAK. TIRE IS RUINED AS WHILE SHE WAS DRIVING THE AIR LEAKED OUT OF THE TIRE CAUSING IT TO GO LOW AND THE SIDEWALL BEING DAMAGED. *TR

ON SEPTEMBER 4, 2008, I EXPERIENCED A LOW TIRE PRESSURE SENSOR WARNING ON MY 2007 FORD EXPEDITION (VEHICLE WAS PURCHASED NEW;ALL TIRES ON THE VEHICLE WERE THE ORIGINAL FACTORY INSTALLED TIRES.) I CHECKED ALL TIRES AND DID NOT SEE AN IMMEDIATE LOSS OF TIRE PRESSURE AND SINCE I WAS IN A RURAL AREA AT THE TIME I FELT THAT IT WAS IN MY BEST INTEREST TO GET TO A MORE POPULATED AREA WHERE I COULD HAVE THE TIRES CHECKED. THE TIRE QUICKLY LOST ALL AIR PRESSURE AND WENT FLAT CAUSING ME TO TAKE AN EVASIVE MOVE TO GET OFF THE ROAD. THE TIRE WAS CHANGED AND I TOOK THE FAILED TIRE INTO FUTURE FORD OF ROSEVILLE WHERE I PURCHASED MY VEHICLE. THE TIRE HAD TO BE REPLACED. THERE WAS NO EVIDENCE OF A PUNCTURE OR REASON FOR THE TIRE TO FAIL. NO COMPENSATION FROM THE DEALER WAS OFFERED. ON OCTOBER 16, 2008, THE LOW TIRE SENSOR LIGHT AGAIN ACTIVATED. AFTER CHECKING ALL TIRES I FOUND THAT ONE OF THE TIRE VALUES WAS SPLIT AND LEAKING (HISSING). I WAS ABLE TO TAKE THE VEHICLE TO A LOCAL TIRE COMPANY TO HAVE IT REPAIRED. UPON INSPECTION OF THE OTHER TIRE VALUES WE FOUND THAT ALL THE VALUES (EXCEPT FOR THE NEW TIRE THAT HAD BEEN INSTALLED) WERE ALL SPLIT AND WOULD EVENTUALLY START TO LEAK. I HAD ALL THE VALUES REPLACED ON ALL THE TIRES. AT THE TIME THE TIRE COMPANY, LES SCHWAB, INFORMED ME THAT THERE HAVE BEEN SOME REPORTED ISSUES WITH LEAKING TIRE VALVES ON SOME FORD VEHICLES. I DID SOME RESEARCH AND FOUND THAT CONSUMER REPORTS IS RECOMMENDING THAT ALL 2007 FORD VEHICLE TIRE VALVES BE INSPECTED AND REPLACED IF FOUND TO BE CRACKED. ON 10/17/08, I REPORTED THIS TO FUTURE FORD OF ROSEVILLE AND THEY WERE UNAWARE OF ANY TYPE OF TIRE VALVE FAILURES. SEEMS THAT CAR DEALERS SHOULD BE CHECKING FOR THIS PROBLEM ON DILL VALVES. LES SCHWAB WAS ABLE TO RECOVER 2 OF THE CRACKED VALVES FROM MY EXPEDITION. ALL ARE TR414 VALVES WHICH APPEAR TO BE UNDER INVESTIGATION FOR FAILURE AND POSSIBLE SAFETY ISSUES. MY COST FOR THIS PROBLEM IS NOW $250.00. *TR

ON 7-21-08 MY FRONT PASS. TIRE WENT FLAT AND HAD TO BE REPLACED. THE VALVE STEM WAS LEAKING. FORD REPLACED THE TIRE UNDER MY WARRANTY. ON 10-02-08 MY REAR DRIVERS SIDE TIRE WENT FLAT DUE TO THE VALVE STEM LEAKING, ONLY THE VALVE STEM HAD TO REPLACED, BUT FORD WOULD NOT FIX IT UNDER MY WARRANTY, THE REPAIR COST WAS $21.00. ON 10-06-08 MY REAR PASS. TIRE WAS LOW AND THE CAUSE WAS AGAIN A LEAKING VALVE STEM. SINCE FORD STATED THAT THIS WAS NOT UNDER MY WARRANTY I WENT TO ALLEN TIRE AND HAD ALL FOUR VALVE STEMS REPLACED AT A COST OF $101.65. *TR

THE SLIDING CAR ICON DISPLAYS QUITE OFTEN, ALWAYS ON DRY PAVEMENT. USUALLY FOR A SHORT TIME DURING THAT TIME THE BRAKES DO NOT OPERATE PROPERLY. THEY ACT AS THOUGH THE ABS HAVE ENGAGED THEMSELVES AND MAKE IT ALMOST IMPOSSIBLE TO STOP. IT HAS HAPPENED OVER 10 TIMES TO ME IN THE 15 MONTHS THAT I HAVE OWNED THE TRUCK. THE DEALER CHECKED THE PROBLEM AND REPORTED THAT THERE WAS NOTHING WRONG. *TR

HAVE A 2007 FORD EXPEDITION AND HAD TO REPLACE ONE TIRE BECAUSE OF FLAT ON THE HIGHWAY THAT RUINED THE TIRE. I'VE HAD TWO MORE FLATS THAT RESULTED IN TIRE DAMAGE AND HAVE TO REPLACE THEM WHEN I GET THE MONEY. WE COULD NOT FIND THE PROBLEM OF THE FIRST TIRE, UNTIL A FRIEND OF MINE TOLD ME ABOUT FORD HAVING PROBLEMS WITH VALVE STEMS. CALLED FORD AND DEALERSHIPS WHERE I BOUGHT VEHICLE AND THEY DO NOT WANT TO HELP ME AT ALL . TIRES HAVE LESS THAN 10,000 MILES ON THEM. IM GOING TO BE OUT OVER 600.00 DOLLARS FOR THERE MISTAKE. IM GOING AHEAD AND REPLACING THE OTHER TIRE AND STEM FOR ME AND MY FAMILY SAFETY. PLEASE HELP WITH THIS PROBLEM. *TR

MY FORD 07 EXPEDITION HAS A ONGOING PROBLEM W/ A TIRE LOSING AIR. FORD HAS LOOKED AT IT 3 TIMES AND THE 3RD TIME SAY THEY FIXED IT WITH A PATCH ON A SMALL HOLE. THE TIRE STILL LEAKS AIR AND THE AIR SENSOR GOES OFF EVERY 4-5 DAYS. *TR

I HAVE A 2007 FORD EXPEDITION THAT HAS HAD FOUR (4) VALVE STEMS GO BAD. ONE CAUSED THE AIR TO DEFLATE SO QUICKLY THE TIRE WAS RUINED. WHEN TALKING TO FORD DEALERS, ONE THAT REPLACED THE TIRE AND ONE THAT SOLD THE EXPEDITION, BOTH SAID IT WAS BAD LUCK AND NOTHING COULD BE DONE. HAD IT NOT BEEN FOR THE TIRE SENSOR SYSTEM, I WOULD HAVE RUINED THE RIM AS WELL AS THE TIRE. THE CAR DID NOT VIBRATE OR PULL TO THE SIDE OR ANY OTHER PROBLEMS, IT KEPT RUNNING AS IF NOTHING WAS WRONG UNTIL THE SENSOR KICKED IN AND BY THEN IT WAS TOO LATE, THE RIM CUT INTO THE SIDEWALL OF THE TIRE. THE REPAIR CENTER CONFIRMED IT WAS A BAD VALVE. SADLY, WHEN THEY REPLACED THE TIRE, THEY USED THE SAME TYPE OF STEM AND IT LEAKED AS WELL. I HAD TO GO TO THIRD PARTIES TO REPLACE THE OTHER VALVE STEMS THAT WERE DEFECTIVE. CALLING MY LOCAL DEALER AGAIN ABOUT IT, THEY STILL MAINTAIN NOTHING CAN BE DONE ABOUT THIS. *TR

TIRE PRESSURE LIGHT ON. DEALER FOUND CRACKS IN TIRE STEMS ON AL FOUR AND REPLACED. *TR

WE HAVE A 2007 FORD EXPEDITION WITH A REMOTE ELECTRIC START INSTALLED IN THE TRUCK. WHEN YOU REMOTE START THE VEHICLE THEN GET INTO THE VEHICLE WITH THE KEYS OUT OF THE IGNITION YOU ARE ABLE TO PUT YOUR FOOT ON THE BRAKE PEDAL AND MOVE THE GEAR SHIFT TO ANY POSITION........... THIS HAS BEEN WITNESSED BY THE FORD DEALER WHO WAS SHOCKED, BUT HAS TOLD ME ITS WORKING THE WAY IT WAS DESIGNED........... IF YOU TEST THIS,,,,,,, REMOTE START THE VEHICLE THEN SIT IN THE DRIVERS SEAT, PUT YOUR FOOT ON THE PEDAL AND MOVE THE SHIFTER. THE CAR WILL SHUT OFF AS ITS SUPPOSE TO AND ONCE THE ENGINE DIES THE SHIFTER WILL NOT MOVE. ITS JUST FOR THE SPLIT OF 3 TO 10 SECONDS IT TAKES FOR THE ENGINE TO STOP THAT SHIFTER IS FREE TO MOVE ..........IF A CHILD IS TO ENTER THE VEHICLE AND PUT THEIR FOOT ON THE PEDAL THEY WILL HAVE THAT AMOUNT OF TIME TO MOVE THE SHIFTER AND ONCE YOU MOVE THE SHIFTER THAT CAR IS FREE TO ROLL AT ANYTIME AND THE SHIFTER CAN STILL MOVE .............................................................. THE PROBLEM AS I SEE IT. IF I REMOTE START THE VEHICLE AND A CHILD CLIMBS INTO THE VEHICLE AND PRETENDS TO DRIVE PUTS HIS FOOT ON THE BRAKE AND MOVES THE SHIFTER, THE CAR IS GOING TO ROLL AND IT NEVER HAD THE KEYS IN THE IGNITION..................... I PARK ON A HILL AND THIS GOOD EASILY KILL SOMEONE IF THE VEHICLE ROLLS...................THE FIX WOULD BE NOT ALLOW THE GEAR SHIFT TO MOVE OUT OF PARK WITH OUT THE KEYS IN THE IGNITION. I WAS ADVISED BY FORD NOT TO REMOTE START MY VEHICLE WITH THE DOORS UNLOCKED AND THAT'S FINE FOR ME, BUT FOR THE REST OF THE DRIVERS OF THESE TRUCKS WHO KNOWS. I HAVE BEEN TOLD THIS MUST HAVE BEEN MISSED BY FORD. THE IGNITION NEEDS TO SEE THE KEY BEFORE IT RELEASES THE SHIFTER. JUST MY THOUGHTS. THANK YOU. *TR

2007 FORD EXPEDITION MILEAGE ~34,000 I HAVE TAKEN MY 2007 FORD EXPEDITION INTO THE SHOP NOW ON 3 SEPARATE OCCASIONS FOR THE SAME ISSUE. THE FIRST AND SECOND TIME THE PROBLEM WAS LISTED AT UN-FOUND, AND THE 3RD TIME IT WAS IN THE SHOW THEY STATED THAT THEY WERE AWARE OF AN ISSUE BUT THERE IS CURRENTLY NO FIRE AVAILABLE. THE ISSUE: *WHEN SLOWING DOWN TO A STOP, THE VEHICLE SEEMS TO STAY IN A HIGHER GEAR AND THEN DOWNSHIFTS HARD, AND COMES TO A STOP. *WHILE ACCELERATING FROM A STOP THE VEHICLE SEEMS TO HESITATE VERY BADLY, THEN TAKE OFF. THIS HAS BEEN PARTICULARLY SCARY WHEN PULLING OUT INTO TRAFFIC BECAUSE YOU NEVER KNOW WHEN IT'S GOING TO "CATCH" AND TAKE OFF. I HAVE BASICALLY STARTED TO LEAVE MYSELF 10X THE ROOM NEEDED TO PULL OUT TO AVOID AN INJURY. *AT 35 MILES PER HOUR, WHEN THE ACCELERATOR IS DEPRESSED TO SPEED UP A CLUNKING NOISE IS HEARD, AND THE VEHICLE HESITATES THEN DECIDES TO MOVE. IT IS ALMOST AS IF THE ACCELERATOR IS NOT TELLING THE TRUCK TO GO! *THIS VEHICLE HAS BEEN A VERY GOOD VEHICLE, BUT FORD HAS BEEN COVERING THIS ISSUE UP FOR MANY MONTHS NOW! THIS IS GOING TO END UP KILLING SOMEONE ONE DAY IF IT IS NOT FIXED! WRITTEN BY A CORPORATE SAFETY SPECIALIST. *TR

2007 FORD EXPEDITION, FROM AUGUST 2008 TO OCTOBER 2008, ON FOUR DIFFERENT OCCASIONS EACH A DIFFERENT TIRE, LOW TIRE PRESSURE INDICATOR CAME ON. SPARE TIRE WAS PUT ON, FLAT TIRE TAKEN TO FORD DEALER, VALVE STEM REPLACED. *TR

ON AUGUST 2, 2008 WE HAD RAPID AIR LOSS IN OUR LEFT REAR TIRE. I GOT IT TO A TIRE PLACE AND THE VALVE WAS BROKEN. THEY SAID THEY NEVER SEEN A VALVE BREAK ON A NEW VEHICLE. A 2007 FORD EXPEDITION. I WAS LUCKY FOR THE AIR PRESSURE WARNING SYSTEM. I WAS ON THE FREEWAY. AFTER SEEING ALL THE TALK ABOUT VALVE PROBLEMS I AM NOW WORRIED ABOUT MY OTHER TIRES. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THE VEHICLE WOULD EXHIBIT SUDDEN ACCELERATION SPORADICALLY. THE VEHICLE HAD BEEN TAKEN TO THE DEALER NUMEROUS TIMES SINCE JULY 2008. THE THROTTLE BODY WAS REPLACED BUT THE FAILURE PERSISTED. THE DEALER CONTINUED TO INSPECT THE VEHICLE BUT WAS UNABLE TO DETERMINE A FAILURE WITHIN THE VEHICLE. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT AFFECTED BY A FAILURE. THE FAILURE MILEAGE WAS 17,538 AND THE CURRENT MILEAGE WAS 77,335.

SHORTLY AFTER BUYING THE VEHICLE AUG. 23, 2007 WE STARTED HAVING PROBLEMS WITH THE SUNROOF RATTLING. IN SEPT. 2007 THEY REPLACED THE SUNROOF. SINCE REPLACING THE SUNROOF IT HAS BEEN BACK 3 MORE TIME WITH RATTLING PROBLEMS. THE PROBLEM CAN NOT BE FIXED AND IT CONTINUES TO EXIST. WE HAVE CONTACTED FORD MOTOR CO. ABOUT THE PROBLEM AND AT THIS TIME THEY WANT ANOTHER CHANCE TO FIX IT. WE HAVE CONTACTED THE WASHINGTON STATE ATTNY. GENERAL AND HAVE STARTED THE PROCESS TO HAVE THIS VEHICLE DEEMED A "LEMON". AFTER FOR ATTEMPTS TO REPAIR THE SUNROOF THE PROBLEMS CONTINUES AND THEN THERE ARE OTHER PROBLEMS WITH THIS EXPEDITION. *TR

DRIVING MY WIFE NOTICED THE TIRE PRESSURE LIGHT COME ON. ONCE SHE WAS ABLE TO GET OVER SHE NOTICED THAT AIR WAS LEAKING FROM THE TIRE VALVE. UPON FURTHER INSPECTION, WE NOTICED THAT ALL THE VALVES WERE CRACKED AND DEFECTIVE. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE'S ALARM SOUNDED, WHICH INDICATED THAT THE TIRE PRESSURE WAS LOW. HE PLACED AIR IN THE TIRES, BUT THE TIRE PRESSURE DID NOT INCREASE. HE TOOK THE VEHICLE TO THE DEALER AND THEY DISCOVERED THAT THE TIRE VALVE STEMS (TR414) WERE ALSO DEFECTIVE. THE VALVE STEMS WERE REPLACED. THE MANUFACTURER STATED THAT THEY WOULD REIMBURSE THE CONTACT FOR THE REPLACEMENT COSTS. THE CURRENT AND FAILURE MILEAGES WERE 183,000.

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING 40 MPH, THE CONTACT NOTICED FLAMES COMING FROM THE HOOD OF THE VEHICLE. HE PULLED THE VEHICLE OVER AND IT STALLED AND LOST COMPLETE POWER. THE CONTACT THEN PROCEEDED TO REMOVE ALL THE PASSENGERS, INCLUDING TWO CHILDREN FROM THE REAR SEAT. WITHIN FIVE MINUTES, THE DRIVER'S SIDE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A COLLISION CENTER. AFTER SPEAKING WITH THE MAINTENANCE MANAGER, FORD STATED THAT SINCE THE FIRE ORIGINATED IN THE REAR OF THE VEHICLE, THEY WOULD NOT TAKE RESPONSIBILITY FOR THE FIRE. THE FIRE REPORT CLEARLY STATED THAT THE FLAMES ORIGINATED FROM THE HOOD OF THE VEHICLE. THE VEHICLE IS CURRENTLY AT THE COLLISION CENTER. THE CURRENT AND FAILURE MILEAGES WERE 12,000.

VEHICLE OFTEN FAILS TO MOVE WHEN ON AN INCLINE, E.G., PULLING BOAT OUT OF WATER ON LAUNCH RAMP; BACKING VEHICLE UP STEEP DRIVEWAY. WHEN THE ACCELERATOR IS DEPRESSED, ENGINE DOES NOT RESPOND AND VEHICLE WILL NOT MOVE. I HAVE TO TURN ENGINE OFF AND AFTER A FEW SECONDS, TURN IT ON AGAIN BEFORE IT WILL MOVE. I HAVE TAKEN THIS VEHICLE TO THE DEALER TWO OR THREE TIMES (UNKNOWN) AND THEY HAVE BEEN UNABLE TO FIND PROBLEM AND REPAIR. I AM NOW OUT OF WARRANTY AND FORD REFUSES TO HANDLE THIS COMPLAINT. I HAVE WRITTEN TO FORD AND THEY DO NOT CARE TO RESPOND. *TR

WHEN PUTTING THE 2007 FORD EXPEDITION EL INTO REVERSE THE TRANSMISSION WOULD SLAM INTO REVERSE. THIS HAS HAPPENED ON SEVERAL OCCASIONS. WHEN TAKEN TO THE DEALER THEY COULDN'T DUPLICATE THE CONCERN AND THEN CHECKED FOR UPDATES. THE ECM HAS THE MOST CORRECT UPDATES. *TR

ENGINES LUGS ON TAKE OFF, WE WERE AT THE FREEWAY SEVERAL TIMES AND THE VEHICLE WOULD HESITATE BEFORE MOVING. THIS HAS HAPPENED SEVERAL TIMES OVER THE LAST 9 MONTHS TOOK VEHICLE IN AND THEY COULD NOT FIND A PROBLEM. THEY SAID THE ECM HAS THE MOST CURRENT UPDATES. THE VEHICLE HAS ONLY BEEN DRIVEN A FEW TIMES SINCE AUG. 13TH, 2008. WE ARE CURRENTLY ALSO HAVE PROBLEMS WITH THE SUNROOF, WAITING ON FORD MOTOR CO. REGARDING THAT ISSUE. *TR

ELECTRONIC REAR HATCH MAKE AN AWFUL NOISE WHEN OPENING AND CLOSING. IT HAS BEEN TO THE DEALER TWICE FOR REPAIR. THEY CAN NOT FIGURE OUT WHAT THE PROBLEM IS. THE NOISE IS NOT CONSISTENT, WILL COME AND GO. THEY DID INDICATE THAT THE MOTOR IS LOUD. THE NOISE STILL CONTINUES TO EXIST. *TR

INTENSITY OF THE LIGHTING SUPPLIED TO THE ELECTRONIC MESSAGE CENTER (WHICH DISPLAYS MILEAGE, ODOMETER, REMAINING FUEL MILEAGE, FUEL ECONOMY, COMPASS, ETC.) IS PROVIDED THROUGH A PHOTO CELL ON THE DASHBOARD. IT IS WIRED INCORRECTLY, SO THAT HIGH INTENSIFY LIGHT (AS IN DAYLIGHT) REDUCES THE AMOUNT OF LIGHT DISPLAYED. THIS IS BACKWARDS. IT MAKES ALL FUNCTIONS OF THE ELECTRONIC MESSAGE CENTER (ODOMETER, ETC.), IMPOSSIBLE TO READ IN NORMAL DAYLIGHT CONDITIONS. LOCAL FORD DEALERSHIP TELLS ME THAT THIS PROBLEM IS COMMON TO A SIGNIFICANT NUMBER OF FORD CARS AND TRUCKS FOR SEVERAL YEARS, INCLUDING AND MORE RECENTLY THAN 2007. A LETTER TO FORD DID NOT PROVIDE ANY SUGGESTIONS FOR REPAIR. IN ORDER TO READ ANYTHING ON THIS DISPLAY IN NORMAL LIGHT, IT IS NECESSARY TO DUCK YOUR HEAD DOWN AND STARE AT IT FOR ABOUT TEN OR MORE SECONDS. IF THIS ACTION HAS NOT YET CAUSED ANY FATALITIES, I CAN'T IMAGINE WHY. UPDATED 10/24/2014 *JS

TIRES ARE DEFECTIVE WITH CUPPING CAUSING VIBRATIONS TIRES LOOK SWOLLEN AND UNEVEN THREADING. WE TOOK THE CAR TO CHECK SUSPENSION SYSTEM AND THEY SAY EVERYTHING IS FINE. I KNOW THAT IT IS THE TIRES. WHICH MAKES THE CAR UNSAFE. I HAVE CHILDREN AND BECAUSE OF THE TIRES BEING UNSAFE I DON'T WANT TO PUT MY FAMILY IN DANGER. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED WHEN THE VEHICLE WAS PARKED IN COLD WEATHER; ICE WOULD FORM INSIDE EACH WINDOW. WHILE DRIVING AT SPEEDS OF 30 MPH AND ENGAGING THE DEFROSTER, ONLY THE FRONT WINDSHIELD WOULD DEFROST BUT NOT THE PASSENGER WINDOWS IN THE VEHICLE. SHE THEN ENGAGED THE INTERIOR HEAT TO NINETY DEGREES IN AN ATTEMPT TO DEFROST THE PASSENGER WINDOWS BUT TO NO AVAIL. THE CONTACT WAS UNABLE TO OPEN THE WINDOWS BECAUSE THEY WERE FROZEN SHUT AND IN ORDER TO DETERMINE WHEN TO CHANGE LANES, THE CONTACT WOULD HAVE TO OPEN THE DRIVER'S DOOR WHILE IN TRANSIT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 7,000 AND THE CURRENT MILEAGE WAS 38,000.

IN THE MORNING WHEN FIRST STARTING OUT DRIVING THE VEHICLE WILL LURCH FORWARD AND THEN SOMETIMES WILL BECOME SLUGGISH, THEN SURGE OF POWER. DEALER COULD NOT DUPLICATE CONCERN, BUT THE FOUND AN UPDATE FOR THE ECM, RE-FLASHED THE ECM AND TEST DROVE, VEHICLE OPERATED AS DESIGNED. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING IN COLD WEATHER ALL SIX OF THE PASSENGER WINDOWS WOULD NOT DEFOG UNLESS THE HEAT WAS TURNED ALL THE WAY UP AND THE AIR VENTS WERE DIRECTED TOWARDS THE WINDOWS. THE CONTACT ALSO STATED THAT THE WINDOWS WOULD FREEZE SHUT AND SHE WAS UNABLE TO OPEN THEM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THERE MIGHT BE AN AIR LEAK. THE DRIVER'S SIDE MIRROR WAS REPLACED YET THE FAILURE PERSISTED WHEN DRIVING IN COLD WEATHER. THE VEHICLE WAS TAKEN BACK TO THE AUTHORIZED DEALER FOUR TIMES, BUT THERE HAD BEEN NO RESOLUTION. THE FAILURE MILEAGE WAS 4,000 AND THE CURRENT MILEAGE WAS 38,000.

ON TWO OCCASIONS IN THE LAST MONTH, THE VEHICLE WHILE IN PARK AND THE KEYS OUT OF THE IGNITION, THE VEHICLE ON ITS OWN ROLLED BACKWARDS AT LEAST 20 FEET. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. THE REAR WINDOW IN THE LIFTGATE SHATTERED AFTER THE VEHICLE HAD JUST BEEN TURNED OFF. THE FAILURE DAMAGED TWO RUBBER FLOORMATS. THE CURRENT MILEAGE WAS 7,611 AND FAILURE MILEAGE WAS 7,530. UPDATED 3/4/08 *CN

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING 67 MPH WITH THE CRUISE CONTROL ACTIVATED, IT FAILED TO DEACTIVATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND THE VEHICLE WOULD NOT STOP. THE CONTACT HAD TO SHUT OFF THE ENGINE IN ORDER TO STOP THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WHEN HE ATTEMPTED TO ACCELERATE FROM A STOP. AS OF NOVEMBER 14, 2007, THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURES. THE FAILURE MILEAGE WAS 11,950 AND CURRENT MILEAGE WAS 12,000. UPDATED 12/12/07

Symptom was low brake pedal or “soft brakes” due to the brake booster pushrod not being turned out to appropriate length requiring to adjust the brake booster pushrod length. In order to correct mechanic has to remove the master brake cylinder and turn out the pushrod 1/2 or 1/4 turn.

SINCE PURCHASING THE VEHICLE IN OCTOBER OF 2006, THE TRANSMISSION SEEMED SLUGGISH AT STOPS WHEN ACCELERATING, I HAVE TAKING THE VEHICLE INTO A FORD DEALERSHIP THREE OR MORE TIMES AND NOW THE TRANSMISSION IS STILL SLUGGISH WHEN MOVING FROM A STOP. I TOOK IT BACK TO A DEALER AND FORD SERVICE SAID THAT A MEMO SAID NOT TO WORK ON MY TRANSMISSION UNTIL THE UPDATE FOR SOFTWARE IS ISSUED SOMETIME IN NOVEMBER. THIS IS AT LEAST A MONTH AWAY AND THE VEHICLE IS NOT SAFE FOR MY WIFE AND FAMILY TO DRIVE IN. I HAVE A FORD REP WHO WE ASKED TO SUPPLY US WITH A RENTAL CAR AND THEY ARE SAYING WE CAN RENT A CAR AND THEY WILL REVIEW IT WHEN THE VEHICLE IS FIXED AND DECIDE IF THEY ARE GOING TO PAY FOR THE RENTAL. THIS IS RIDICULOUS TO BE TREATED THIS WAY BY SUCH A HUGE CORPORATION. *TR

THE NAVIGATION SYSTEM HAS BEEN REPLACED 3 TIMES SO FAR WITH OTHER PARTS THAT WERE REUSED BY FORD. THIS VEHICLE HAS BEEN DEADLINED(ME NOT BEING ABLE TO DRIVE IT ABOUT 60DAYS IN THE PAST YEAR. IT HAS BEEN IN THE SHOP NOW FOR A WEEK AND THEY ARE GOING TO TRY TO REPLACE THE ANTENNA ON IT. THEY (FORD)NOT THE DEALERSHIP PUTS THE BLAME ON THE MAKER OF THE UNIT., BUT WITH EACH NEW UNIT COMES OTHER PROBLEMS. NONE OF FORD TECH'S SEND BACK THE SAME RESPONSE. WHAT MY NEXT STEP?? PLEASE HELP IT HAS BEEN IN THE SHOP TO MAY TIMES. THE DEALERSHIP IS GREAT BUT THEY CAN ONLY DO SO MUCH. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING 70 MPH, THE CONTACT ATTEMPTED TO DEPRESS THE BRAKE PEDAL, BUT INSTEAD HE DEPRESSED BOTH THE BRAKE AND ACCELERATOR PEDALS. HE PULLED TO THE SHOULDER OF THE ROAD, BUT THE VEHICLE WOULD NOT DECELERATE. THE DEALER STATED THAT THERE WAS A FAILURE, BUT NO REMEDY. THE CURRENT AND FAILURE MILEAGES WERE 7,000.

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE MAKING A TURN AT 15 MPH, THE SEATS RATTLED. THE TRANSMISSION ALSO EXPERIENCED FAILURE. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE TRANSMISSION WOULD PAUSE AND THEN THE VEHICLE WOULD DRASTICALLY ACCELERATE. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT MILEAGE WAS 11,283 AND FAILURE MILEAGE WAS APPROXIMATELY 8,000. UPDATED 3/4/08 *CN

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DECELERATING AT 5 MPH, THE ENGINE REVVED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, THE CONTACT REAR ENDED ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 1,000.

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE GAUGES ON THE DASHBOARD FAILED TO ILLUMINATE DURING THE DAY. THE DEALER STATED THAT THIS WAS A NORMAL OCCURRENCE. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 420.

WE PURCHASED A 2007 EXPEDITION LIMITED FROM DON CHALMERS FORD IN SANTA FE NEW MEXICO ON JULY 21, 2007. WE HAD THIS SUV FOR LESS THAN 2 WEEKS WHEN THE POWER STEERING AND THE RACK AND PINION FAILED. I WAS BACKING OUT OF A TIGHT PARKING SPACE WHEN I FELT THE SUV SORT OF THUMP. WITHIN 500 FEET, AS I WAS LEAVING THE PARKING LOT, THE POWER STEERING WAS COMPLETELY GONE. AFTER TAKING IT TO THE NEAREST DEALERSHIP, THE SERVICE REPRESENTATIVE SAID THAT THE RACK AND PINION WAS BLOWN. THIS IS OUR 2ND EXPEDITION (WE OWNED A 2001 EDDIE BAUER). I CONVINCED MY HUSBAND TO TRADE IN OUR 2007 TAHOE LTZ FOR THE EXPEDITION LIMITED BECAUSE I MISSED MANY OF THE BASIC FEATURES SUCH AS THE SEATS FOLDING FLAT, THE CONTROLS ON THE STEERING WHEEL, HANDLE ON DRIVERS SIDE. I CANNOT UNDERSTAND HOW A BRAND NEW EXPEDITION CAN HAVE THE POWER STEERING AND RACK AND PINION FAIL WITH LESS THAN 500 MILES AND FROM JUST SIMPLY BACKING OUT OF A TIGHT PARKING SPACE. I THOUGHT THAT THE 20" TIRES HAD SOMETHING TO DO WITH THIS. SOME OF OUR FRIENDS WHO ARE "CAR PEOPLE" SAID THAT THE HOSE TO SUPPORT THE POWER STEERING WAS PROBABLY NOT INSTALLED PROPERLY AND WHEN I MADE THE TIGHT TURN, IT SNAPPED IT OUT OF THE SOCKET. THE SERVICE REP SAID THAT THEY PROBABLY MADE SOME MISTAKES DURING MANUFACTURING THAT CAUSED THE ENTIRE RACK AND PINION TO BE DEFECTIVE. THE FAILURES OCCURRED ON AUGUST 3, 2007, AND THE CAR WAS BROUGHT TO THE DON CHALMERS FORD DEALERSHIP LOCATED IN RIO RANCHO, NEW MEXICO. WE HAVE BEEN GIVEN A LOANER VEHICLE. WE HAVE NOT YET BEEN CONTACTED TO INFORM US OF WHAT THE EXACT PROBLEM IS, OR THE CORRECTIVE ACTION REQUIRED. WE BELIEVE THESE ISSUES ARE UNACCEPTABLE ON A $45K AUTOMOBILE. WE EITHER WANT A REPLACEMENT EXPEDITION OR WE WANT OUR TAHOE BACK.*JB

MY 2007 FORD EXPEDITION EDDIE BAUER EDITION HAS ALWAYS HAD A PULSE ON THE BRAKE YOU COME TO A STOP AND IT WILL STOP AND GO AT FIRST IT WAS NOT BAD NOW IT IS EXTREMELY DANGEROUS. *TR