2000 Ford Explorer Engine Problems

See attached document for complaint.

The contact owns a 2000 Ford Explorer. The contact stated while driving approximately 30 MPH, the vehicle stalled. The contact stated that there were several unknown warning lights illuminated. The contact stated that the failure was intermittent. The contact had not taken the vehicle to the local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 153,000.

2000 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO RECALL STATES ENGINE RUNNING WITHOUT IGNITION KEY COULD START A FIRE. CONSUMER STATES THOUGHT DEALERSHIP REPAIRED RECALL PROBLEMS. VEHICLE EXPLODED SEVEN MINUTES AFTER CONSUMER EXISTS VEHICLE. *SMD

SUDDEN ACCELERATION FROM STOP IN PARKING LOT.

TIMING CHAIN RATTLES. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPLORER SPORT. THE CONTACT STATED THAT WHILE STARTING THE IGNITION, THE ENGINE WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE FOUR 02 OXYGEN SENSORS WERE REPLACED. AFTER THE REPAIR THE FAILURE PERSISTED BUT THE VEHICLE WAS NOT FURTHER SERVICED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 169,000.

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT STATED THAT SHE PARKED THE VEHICLE AND AS SHE PROCEEDED TO WALK AWAY, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT STATED THAT THE FIRE ORIGINATED FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 173,000.

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT WAS DRIVING 35 MPH WHEN SMOKE EMITTED FROM THE REAR END OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS DESTROYED. THE POLICE AND THE FIRE DEPARTMENT WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 179,000.

SPARKPLUG SUPER-HEATED AND MELTED LONGITUDINALLY DESTROYING THE OUTERMOST SPARKPLUG THREADS (7 THROUGH THE SEATING SURFACE OF THE SPARK PLUG). INNER MOST THREADS, THE ONES DEEPEST INTO THE HEAD WERE NOT DAMAGED. A SECOND PLUG WAS INSTALLED ALONG WITH A NEW SPARK PLUG WIRE AND WITHIN 20 MILES, THE SPARKPLUG WAS AGAIN MELTED BEYOND SALVAGE AND THE NEW WIRE BURNED UP. DUE TO THE DESTRUCTION OF THE SPARKPLUG, IT WAS ABLE TO BE REMOVED WITHOUT TOOLS AS THERE WERE NO THREADS REMAINING IN THE CYLINDER HEAD. FORTUNATELY THE FIRE DAMAGE (LIKELY FROM THE SPARK OF THE PLUG) WAS LIMITED ONLY TO DAMAGING THE SPARKPLUG AND THE SPARK PLUG WIRE LABLED #3. *TT

THE 2000 FORD EXPLORER SUV BEGAN TO SLOW DOWN AS THE ENGINE RPMS INCREASED. AFTER PULLING OVER AND TURNING THE IGNITION OFF, WE NOTICED SMOKE COMING FROM THE HOOD. UNDERNEATH THE CAR, FLAMES WERE DRIPPING DOWN FROM THE TRANSMISSION. WE USED A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES ON THE GROUND, AND ATTEMPTED TO OPEN THE HOOD. AFTER THE HOOD WAS OPENED, LARGE FLAMES WERE OBSERVED IN THE ENGINE COMPARTMENT. THE FIRE EXTINGUISHER WAS USED UNTIL EMPTY AND HAD LITTLE IMPACT. THE CAR BEGAN TO BURN QUICKLY AND THE FLAMES SPREAD FROM FRONT TO BACK. THE EMERGENCY SERVICES ARRIVED, EXTINGUISHED THE FIRE AND COLLECTED WITNESS STATEMENTS. NO ONE WAS HURT IN THE INCIDENT AND THE FRAME WAS TOWED VIA AAA TO A NEARBY AUTOMOTIVE SHOP. *KB

THIS IS TO REPORT A FIRE IN A 2000 FORD EXPLORER: ON FRIDAY, 25 NOV 11, 5 ADULTS (MY HUSBAND, 2 SONS, DAUGHTER-IN LAW, AND MYSELF) AND 2 DOGS, LEFT BETHLEHEM PA FOR OUR FAMILY CHRISTMAS TRIP IN OUR 2000 FORD EXPLORER, PULLING A UTILITY TRAILER. THE INTENT OF THE TRIP WAS TO START AT A CHRISTMAS TREE FARM, CUT DOWN 3 CHRISTMAS TREES, HAUL THEM IN THE TRAILER AND CONTINUE WITH SEVERAL OTHER CHRISTMAS RELATED TRADITIONAL STOPS. MY HUSBAND, DROVE APPROXIMATELY 45 MINUTES NORTH TO BISSELS CHRISTMAS TREE HILL IN LEHIGHTON, PA. HE DID NOT USE CRUISE CONTROL BECAUSE WE WERE PULLING THE TRAILER. THE TRIP WAS FINE WITH ABSOLUTELY NO INDICATIONS THAT ANYTHING WAS WRONG WITH THE VEHICLE. IT ALSO HAD NOT HAD ANY SERVICE DONE TO IT RECENTLY (A QUESTION FREQUENTLY ASKED TO US). HE PARKED THE VEHICLE ALONG AN EMBANKMENT AT THE TREE FARM AND WE ALL WERE IN VARIOUS STAGES OF GETTING OUT OF THE CAR WITH THE DOGS WHEN SOMEONE NEARBY YELLED TO US THAT OUR CAR WAS ON FIRE. SHE REPEATED IT AS WE LOOKED TO SEE WHO SHE WAS ADDRESSING. WE LOOKED AT OUR CAR AND SAW THAT UNDER IT, FIRE BALLS WERE HITTING THE GROUND FROM WHAT APPEARED TO BE THE CENTER OF THE ENGINE. MY HUSBAND ATTEMPTED TO OPEN THE HOOD AND SMOKE WAS IMMEDIATELY POURING OUT OF THE ENGINE. WE ALL QUICKLY GOT AWAY FROM THE VEHICLE. MY ONE SON IMMEDIATELY CALLED 911 AND MY OTHER SON RAN NEARBY TO TRY AND FIND A FIRE EXTINGUISHER. THE SMOKE QUICKLY TURNED INTO A FULL BLOWN FIRE. THE COMPLETE FRONT OF THE VEHICLE, ALONG WITH THE EMBANKMENT NEARBY, WAS ABLAZE. THE MAHONING VALLEY POLICE CAME, THEN THE FIRE CAPTAINS, THEN 2 FULL FIRE TRUCKS FROM LEHIGHTON AND MAHONING VALLEY FIRE DEPARTMENTS. THEY QUICKLY EXTINGUISHED EVERYTHING, ALONG WITH THE VEHICLE WE LOST MY PURSE, JACKETS, AND OTHER MISCELLANEOUS VALUABLES THAT WERE ON THE FLOOR OF THE FRONT SEAT AND IN THE GLOVE COMPARTMENT. *TR

MY FORD EXPLORER CAUGHT ON FIRE. ALL I SAW WAS CLOUD OF SMOKE. THEN PEOPLE STARTED YELLING AND BLOWING THEIR HORN AT ME, THE UNBELIEVABLE, THAT MY CAR WAS ON FIRE. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPLORER . THE CONTACT STATES THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. SHE THEN PULLED OVER AND TURNED THE VEHICLE OFF. SHE THEN RESTARTED THE VEHICLE AND DROVE DIRECTLY TO THE DEALER. THE TECHNICIAN ADVISED HER THAT THE FAILURE OCCURRED FROM A CRACK IN THE CYLINDER HEAD OF THE ENGINE. THE VEHICLE WAS REPAIRED UNDER OWNERS EXPENSE. WHEN IT WAS AT THE DEALER SHIP THEY TOOK THE VEHICLE APART WITHOUT THE DRIVERS PERMISSION. THE DRIVER CALLED AN INVESTIGATOR FROM THE BUREAU OF AUTOMOTIVE REPAIR. IT WAS DETERMINED THAT THEY USED A DEFECTIVE ENGINE FOR THE 2000 FORD MODELS AND FOUND OUT AFTER A YEAR AND THAT'S WHY THE Y DISCONTINUED USING THAT SPECIFIC ENGINE. THE FAILURE MILEAGE WAS 93104 AND THE CURRENT MILEAGE WAS 93300.

SPARK PLUG CLOSEST TO DRIVER DOES NOT SEAT AND COMES OUT. NOT A FULL BLOW OUT OF IT, BUT THE PLUG FEELS REAL LOOSE. I TRIED NEW PLUG BUT IT STILL FEELS LOOSE. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, ANOTHER DRIVER INFORMED THE CONTACT THAT THERE WERE FLAMES UNDERNEATH THE VEHICLE. SHE PULLED OVER ONTO THE SIDE OF THE ROAD AND NOTICED FLAMES UNDERNEATH THE VEHICLE AND THE HOOD. THE CONTACT QUICKLY REMOVED HER CHILDREN AND CHILD SEAT FROM THE VEHICLE. IN A MATTER OF SECONDS, THE HOOD BURST INTO FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE JUNKYARD. THE INSURANCE COMPANY WILL NOT INVESTIGATE THE FAILURE BECAUSE THE VEHICLE DID NOT HAVE COMPLETE COVERAGE. THE MIAMI MIDWAY POLICE DEPARTMENT FILED REPORT NUMBER PPOC9A02C02188. THE CURRENT AND FAILURE MILEAGES WERE 96,000.

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE MECHANIC FOUND ANTIFREEZE IN THE OIL. NEW OIL WAS PLACED IN THE VEHICLE AND, ONCE IT WAS RESTARTED, ANTIFREEZE WAS FOUND IN THE OIL AGAIN. THE CONTACT CALLED THE MANUFACTURER FOR ASSISTANCE AND THEY STATED THAT THERE WAS NO RECALL ON THE HEAD GASKET. THEY FURTHER STATED THAT THE FAILURE WAS DUE TO A BLOWN HEAD GASKET OR A FAILED HEAD BOLT. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 110,000.

AT 166,000 HEAD GASKET BLEW PLUS THERE WERE OTHER ENGINE PROBLEMS. REPLACED WITH ANOTHER ENGINE. NOW TRANSMISSION IS GOING OUT. IT WILL GO INTO REVERSE FINE BUT WILL GO INTO DRIVE WITH PROBLEMS. IF VEHICLE IS COLD IT WILL GO INTO DRIVE FASTER THAN WHEN IT IS WARMED UP. AT WARM TEMP IT MAY TAKE SEVERAL TRIES OF SHIFTING FROM PARK BACK TO DRIVE OR WAITING SEVERAL MINUTES FOR IT TO DROP INTO DRIVE AFTER SHIFTING OUT OF PARK. HAVE ONLY OWNED THIS VEHICLE LESS THAN 2 YEARS. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHEN THE VEHICLE IS STARTED, THE ENGINE MAKES A LOUD RATTLING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DISCOVERED THAT THE TIMING BELT WAS OFFLINE. THE DEALER INFORMED THE CONTACT THAT THEY WERE CONDUCTING A FREE REPAIR FOR THIS FAILURE; HOWEVER, THE TIME HAD ALREADY EXPIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NO LONGER HONORING THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 06/17/08. *LJ UPDATED 06/17/08

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE FUEL LINE RUSTED AND DEVELOPED TINY PIN HOLES AND CRACKS. THE ENGINE LIGHT ILLUMINATED ALSO. THE CONTACT WAS INFORMED THAT THE COST WOULD BE BETWEEN $400 AND $500 TO REMOVE THE TANK. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 34,200 AND FAILURE MILEAGE WAS 34,100.

VEHICLE STARTED RUNNING VERY ROUGH IN DRIVE BUT OK IN PARK AND SMELL OF FUEL OR EXHAUST WAS IN CABIN. TOOK VEHICLE TO DEALERSHIP IMMEDIATELY. DEALERSHIP SAID VALVE WAS BURNED OUT AND THIS ONLY HAPPENS IF VEHICLE HAS OVERHEATED. THIS VEHICLE HAS NEVER OVERHEATED AND EVEN ACKNOWLEDGED A FULL AND CLEAN COOLANT LEVEL PRESENT. DEALERSHIP WANTS $1,800 TO FIX ENGINE WHICH ONLY HAS 68,000 MILES ON IT. *TR