2001 Ford Explorer Complaint Log

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 03V281000 (SEATS). THE CONTACT STATED THAT HER SON NOTICED THAT THE FRONT DRIVER'S SEAT WAS HARD TO RECLINE UP AND DOWN. THE VEHICLE WAS TAKEN THREE TIMES TO SHAKER'S FAMILY FORD LINCOLN (831 STRAITS TURNPIKE, WATERTOWN, CT 06795) FOR THE RECALL. ON THE FIRST DEALER VISIT, THE MECHANIC WAS UNABLE TO REMOVE THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT. ON THE SECOND VISIT, THE DEALER WAS ABLE TO REMOVE THE UPPER BOLT AND INSTALLED A NEW BOLT HOWEVER, THE CONTACT BELIEVED THAT THE DEALER DAMAGED THE SEAT IN THE PROCESS OF INSTALLING THE NEW BOLT. THE CONTACT STATED THAT THE SEAT NO LONGER RECLINED AND NEEDED THE MIDDLE ROW SEATS TO KEEP IT UPRIGHT. ON THE THIRD VISIT, THE CONTACT WAS INFORMED THAT THE SEAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DECLINED TO OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 143,800.

TL* THE CONTACT OWNED A 2001 FORD EXPLORER. WHILE DRIVING, A BURNING ODOR WAS PRESENT AND THE AIR BAG DEPLOYED WITHOUT WARNING OR AN IMPACT. THERE WERE NO INJURIES. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT NOTICED FLAMES UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CONTACT WAS NOT AWARE IF A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A RESIDENCE AND DEEMED DESTROYED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE LEAKED ANTI-FREEZE AND TRANSMISSION FLUID. THERE WAS ALSO RUST UNDERNEATH THE VEHICLE AND A HOLE IN THE RUNNING BOARDS, WHICH ALMOST CAUSED THEM TO DETACH. THE CONTACT CLAIMED THAT THE GROUND COULD BE SEEN THROUGH THE HOLE. THE VEHICLE ALSO PRODUCED THICK SMOKE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 170,000.

SMOKE COMING FROM STEERING... CAN FEEL A CHANGE IN ENGINE WHILE DRIVING, FEELS LIKE A ROUGH RIDE, AND OVERDRIVE STARTS TO FLASH.

THE VEHICLE ROLLED OVER ON ITS SIDE ON DRY PAVEMENT ON THE FWY AT THE POSTED SPEED LIMIT IN GOOD WEATHER CONDITIONS. NO OTHER VEHICLE WAS INVOLVED, THE CAR SKIDED WHEN I ATTEMPTED TO CHANGE LANES. I WENT INTO A SKID AND THE CAR TURNED ON ITS SIDE.

I HAVE A GREAT 2001 FORD EXPLORER BUT IT STARTED LEAKING FROM THE ROOF AND THE LEAK SOURCE CAN NOT BE FOUND. THERE WAS NO DAMAGE, JUST SOMETHING CHANGED. THERE IS NOW MOLD ALL OVER THE INTERIOR AND ITS POSING A GREAT HEALTH RISK TO MYSELF AND ANY OCCUPANTS. I WOULD LIKE THE PROBLEM FIXED BY FORD.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 35 MPH, THE FRONT PASSENGER WHEEL SEIZED AND CAUSED THE CONTACT TO HEAD TOWARDS ONCOMING TRAFFIC. THERE WAS NO CRASH INVOLVED. THE VEHICLE WAS NOT ABLE TO BE DRIVEN AND WAS TOWED. IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE WHEEL BEARING DISINTEGRATED. THE VEHICLE WAS REPAIRED AND THE WHEEL BEARING WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,600.

SWITCHED INTO 4 WHEEL DRIVE LOW WITHOUT A COMMAND WHILE DRIVING AROUND 30 MPH ON A DRY LEVEL PAVED ROAD.

DRIVING AROUND 30 MPH ON A FLAT STRAIGHT PAVED ROAD WHEN IT SUDDENLY SHIFTED INTO 4 WHEEL LOW.

TL* THE CONTACT OWNED A 2001 FORD EXPLORER. WHILE DRIVING 55 MPH, THE CONTACT STEERED TO THE RIGHT AND THE VEHICLE SKIDDED AND CRASHED INTO A GUARDRAIL. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED FOUR BROKEN RIBS AND BACK INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. UPDATED 10/19/16*LJ

THE S.U.V LEAKS WATER IN CAUSING ISSUES I HAD TO REPLACE THE BRAIN AND FUSE BOX NOW MINEXPENSIVE HAS A DRAINAGE OF ITS BATTREY AND THE LIGHT DONE GO OFF I REPLACED THE BATTREY AN ALTNATOR.AN AS WELL.FORD SHOULD FIX IT THY HE TO MANY ISSUES LIKE THIS.PARKED IN DRIVE WAY.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS OR WHILE PARKED, THE DRIVER SIDE TURN SIGNAL FAILED TO ILLUMINATE INSIDE AND OUTSIDE THE VEHICLE. ALSO, THE BRAKE LIGHTS FAILED TO ILLUMINATE. WHEN THE STEERING COLUMN WAS TILTED TO THE UPPER POSITION, THE INTERIOR AND EXTERIOR TURN SIGNAL LIGHTS AND THE BRAKE LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 35 MPH, THE CONTACT HEARD A LOUD THUMP COMING FROM THE REAR HATCH WINDOW. UPON FURTHER INVESTIGATION, THE REAR HATCH WINDOW WAS LOOSE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000. ....UPDATED 07/05/16 *BF UPDATED 07/13/16.*JB

MAIN PROBLEM AT THE MOMENT IS A CLICKING, KNOCKING NOISE THAT SOUNDS LIKE IS COMING FROM UNDERNEATH TRUCK IN THE MIDDLE. YOU CAN FEEL TRUCK SHAKE/VIBRATE WHEN YOU HEAR THE NOISE. PREVIOUS PROBLEMS LUG BOLTS CAME LOOSE AND ALMOST CAUSE TIRE TO FALL OFF. OTHER PROBLEM TRUCK STARTED OFF SOUNDING LIKE THE BRAKE PADS WERE GOING THEN THE TRUCK STARTED MAKING A HORRIBLE GRINDING NOISE . FELT LIKE THE ENGINE WAS GOING TO FALL OUT. ENDED UP BEING FRONT PASSENGER SIDE TIRE. RIM HAD STATTERED.

WAS MAKING A RIGHT HAND TURN FROM A CITY STREET INTO MY COMMUNITY AND ABOUT 90 DEGREES INTO THE TURN THE STEERING LOCKED UP AND I WAS HEADED FOR THE MEDIAN. I STOPPED WITH THE BRAKES AND LOOKED DOWN AT THE DASH AND THE BATTERY PICTURE WAS RED WHICH HELPED ME TO REALIZE THE CAR HAD TURNED OFF. I PUT THE CAR IN PARK AND THEN STARTED IT UP AND THE PROBLEM WAS GONE.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 25 MPH, THE VEHICLE SHOOK VIOLENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 119,699.

ON DRIVING MY TRUCK IT SLOWED DOWN ALMOST TO A STOP THEN MOVED BUT CONTINUED TO PUTTER AND SLOW DOWN--I GOT SCARED AND GOT IT IN MY DRIVEWAY AND CALLED AA TO TOW TO MY SERVICE MECHANIC--THE MECHANIC HAD IT FOR 2 DAYS AND COULD FIND NOTHING WRONG WITH IT---I TOLD HIM I FELT IT WAS IN THE GEARSHIFT AUTOMATIC AS WHEN I PUT IT IN P IT LUNGES FORWARD AND I HAVE TO PUT MY FOOT ON THE BRAKE AGAIN--ALSO WHEN I HAVE IT IN D THE GEARSHIFT DOES NOT STAY IN THE MIDDLE, AS IT ALWAYS DID. HE SAID IT MIGHT BE WATER IN THE GAS, WHICH I SAID NO TO. I KNOW MY VEHICLE AS I HAD IT FROM DAY ONE AND IT DID NOT DRIVE LIKE THAT. IT HAS ONLY 110,000 MILES ON IT AND I TOOK GOOD CARE OF IT FOR UPKEEP AND NOW THAT I AM RETIRED AND AGE 70, MONEY TO REPAIR DOES NOT COME EASY WITH SMALL PENSION AND SOCIAL SECURITY.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING AT APPROXIMATELY 5 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL WITH FORCE AND THE PASSENGER SEAT INDEPENDENTLY FOLDED FORWARD AND THEN BACKWARDS. THE SEAT WOULD NO LONGER HOLD ITS UPRIGHT POSITION AND HAD TO BE PROPPED UP BY FOLDING DOWN THE REAR SEAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WELD ON THE BACK OF THE SEAT HAD FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V281000 (SEATS). THE APPROXIMATE FAILURE MILEAGE WAS 66,500. UPDATED 04/04/16*LJ A BOLT WAS REPLACED IN THE SEAT BACK. UPDATED 04/05/16.*JB

I WAS SITTING IN A RESTAURANT DRIVE THRU WHEN THE CAR TURNED OFF. I TURNED THE CAR BACK ON & INCHED A BIT FORWARD IN LINE. MOMENTS AFTER THAT WHILE IN DRIVE, BUT NOT MOVING, I HEARD A LOUD POP. AFTER THAT, I SAW FLAMES SHOOTING TOWARDS THE FRONT WINDSHIELD COMING FROM UNDER THE HOOD ON MY SIDE. I PUT THE CAR IN PARK, TURNED OFF THE CAR AND TOOK THE KEY OUT OF THE IGNITION AND FLED. THE RESTAURANT WORKERS CAME TO MY AID AND PUT THE FIRE OUT BEFORE IT SPREAD. WHEN I WENT BACK TO SAY THANK YOU, THEY TOLD ME THAT THEY HEARD A SECOND POP BEFORE THEY PUT OUT THE FIRE. I HAVE REPORTED THIS TO FORD HEADQUARTERS. THEY CHECKED MY VIN AND TOLD ME THAT THE VEHICLE WAS UNDER RECALL FOR A DEFECT THAT CAUSES FIRES. I TOOK THE CAR TO A FORD DEALERSHIP A COUPLE MONTHS PRIOR TO THIS INCIDENT AND THEY DID NOT TELL ME ANYTHING ABOUT A RECALL ON THE CAR. ALSO, THE CAR OIL WAS LAST CHANGED 3/5/2015 AND WAS BELOW THE MILEAGE FOR ANOTHER OIL CHANGE, SO I AM SO CONFUSED AS TO WHY THIS HAPPENED. *TR

THE FORD EXPLORER 2001 XLS 4.0L REAR WHEEL DRIVE TRANSMISSION IS DEFECTIVE IN SLIP 4 TO 5 GEAR IN 75000 MILES. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING, THE FRONT DRIVER SIDE SEAT BELT WOULD SUDDENLY UNLOCK. IN ADDITION, THE DRIVER SIDE AND PASSENGER SIDE FRONT SEATS WOULD MOVE FORWARD WHEN MAKING A SUDDEN STOP AND THE PASSENGER SIDE DOOR AND HATCH DOOR WOULD NOT OPEN. THE VEHICLE WAS NOT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 166,694.

AIR BAG LIGHT ON SINCE I PURCHASED THE VEHICLE FROM A PRIVATE PARTY IN 2014.

I TOOK MY CAR TO ASTORIA FORD LATE LAST YEAR, BECAUSE IT WAS STALLING AND LOSING POWER. THE CHARGED ME ALMOST $1,000.00 AND THE PROBLEM PERSISTS. THE O/D ON OFF LIGHT WILL STOP AND START. WHEN IT COMES ON WHICH JUST STARTED TODAY, THE CAR IN ANY GEAR WHILE ONLY GO FORWARD. IN REVERSE AND NEUTRAL, ONLY FORWARD. AS A POLICE OFFICER THIS IS VERY DANGEROUS, AND I CANNOT DRIVE THE VEHICLE. MANY HAVE SUBMITTED COMPLAINTS ABOUT THIS TO FORD, THEY CALL IT A PHANTOM PROBLEM. I HOPE THIS PHANTOM PROBLEM DOES NOT OCCUR IN FRONT OF A DAY CARE. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT WHILE REVERSING INTO A PARKING SPACE, THE VEHICLE LUNGED FORWARD WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 26,500.

FORD EXPLORERS MANUFACTURED IN 2001 WERE EQUIPPED WITH DEFECTIVE ENGINEERED BODY TO FRAME BUSHINGS WHICH HAVE COMPLETELY DETERIORATE AND JUST AS EASILY CRUMBLED IN YOUR HAND, NOW, BUT BEGIN DETERIORATING ONLY A FEW SHORT YEARS FROM WHEN NEW. FORD STOPPED USING THIS STYLE MANUFACTURED MOUNT BUSHINGS AFTER THESE FEW MANUFACTURING YEARS BECAUSE THEY KNEW THEY WERE DEFECTIVE. I'VE SPOKEN TO MANY EXPLORER OWNERS WHO HAVE THIS EXACT SAME PROBLEM , AND THOSE I ASK TO LOOK UNDER THEIR VEHICLES, WHICH ARE NOT A VISIBLE DEFECT UNLESS UNDER THE CAR AND HANDS-ON INSPECTION, ALSO FOUND THIS PROBLEM. MY VEHICLE IS IN LIKE-NEW CONDITION OTHERWISE AND HAS ALWAYS BEEN GARAGED IN THE STATE OF FLORIDA. THESE BODY TO MOUNT BUSHINGS, WHEN DETERIORATED CAUSE SERIOUS SAFETY PROBLEMS TO EXPLORER DRIVERS AND ALL OTHERS DRIVING IN OTHER VEHICLES, DUE TO UNEXPECTED SWAYING AND OR BOUNCING POSSIBLY CAUSING THE VEHICLE TO CRASH AND CAUSE SERIOUS INJURY TO ANYONE DRIVING NEAR THE EXPLORERS. I BELIEVE, AND AM SURE, THAT THE MATERIAL MIX OF THE RUBBER/SILICONE BUSHINGS WAS COMPROMISED DURING MANUFACTURING AND THESE VEHICLES SHOULD IMMEDIATELY RECALLED TO REPLACE THESE BUSHINGS WHICH SHOULD LAST THE LIFETIME OF THE VEHICLE. CARS 40 PLUS YEARS OLD HAVE BODY TO FRAME BUSHINGS STILL IN GOOD CONDITION. FOR THESE BUSHINGS TO START DETERIORATING AFTER ONLY A FEW YEARS AND BEING COMPLETELY USELESS AT THIS AGE AND CONDITION OF VEHICLE IS UNHEARD OF. NOW IS THE TIME TO MAKE SURE ALL EXPLORER SPORT OWNERS IN THE 2001 PLUS OR MINUS VICINITY BE NOTIFIED BY FORD OF THIS DEFECT. PLEASE LOOK UNDER ANY EXPLORER SPORT MADE IN 2001 , AND YOU CAN CONFIRM MY FINDINGS. ALSO, HAVE A PRIVATE ENGINEER TEST THE BUSHING RUBBER/SILICONE MATERIALS USED IN THIS YEAR RANGE, AND I ASSURE YOU THEY WILL BACK MY CLAIM. *TR

FOR THE SECOND TIME, THE VEHICLE'S TRANSMISSION FAILED, LEAVING THE VEHICLE COMPLETELY POWERLESS WHILE DRIVING. THE TRANSMISSION ALSO FAILED AT APPROXIMATELY 70,000 MILES IN 2006, AGAIN WHILE DRIVING THE VEHICLE IN TRAFFIC. IN BOTH CASES, I, AS THE DRIVER, WAS NEARLY INVOLVED IN ACCIDENTS WITH OTHER VEHICLES BECAUSE OF THE COMPLETE LOSS OF THE TRANSMISSION POWER TRAIN. THE VEHICLE ALSO GAVE NO WARNING OF THE FAILURE PRIOR TO THESE EVENTS. IT IS MY UNDERSTANDING THAT THIS HAS BEEN A LONG-STANDING DESIGN DEFECT WITH FORD EXPLORERS, WITH A HIGH NUMBER OF VEHICLES FROM THE EARLY 2000S SUFFERING SIMILAR TRANSMISSION FAILURES. THIS IS BOTH DANGEROUS AND, I BELIEVE, A DEFECT THAT COULD CAUSE INJURY AND/OR DEATH.. I ALSO WISH TO ADD THAT THIS VEHICLE, WHICH IS 4 WHEEL DRIVE AND INCLUDES A FACTORY INSTALLED TOWING PACKAGE, HAS ONLY OCCASIONALLY BEEN USED FOR TOWING A BOAT (2X PER YEAR) AND IS SELDOM USED IN ITS 4 WHEEL DRIVE CAPACITY (ONLY ON SNOW COVERED ROADS 2-3 TIMES PER YEAR). THE VEHICLE HAS BEEN WELL MAINTAINED. THE COST OF THE REPAIRS IN EACH CASE WAS OVER $2,000. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ANTI LOCK BRAKING SYSTEM SUDDENLY MALFUNCTIONED AND THE VEHICLE FAILED TO STOP. THE CONATCT HAD TO ENGAGE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE CONTACT INDICATED THAT THE DEFECT OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE DEFECT. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

REAR END OF CAR THUMPED EVERY TIME YOU WOULD GO OVER THE SMALLEST SEPARATION IN THE ROAD AND ALSO ON A BUMPY ROAD. REPLACED REAR END SHOCKS. STILL HAVE THE SAME PROBLEM OF THUMPING. SOME TIMES IT FEELS LIKE I'M GOING TO LOOSE THE REAR END OF THE VEHICLE. I WAS TOLD POSSIBLY NOW THAT BACK BUSHINGS HOLDING THE BODY TO THE FRAME MAY BE DISINTEGRATED. VEHICLE HAS ALWAYS BEEN WELL MAINTAINED AND GARAGED. I HAVE FOUND OUT THAT THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS OCCURRING NOW WITH THIS 2001 MODEL. YOU WOULD THINK THERE WOULD BE A SAFETY RECALL BY FORD TO FIX THESE BUSHING PROBLEMS. *TR

FRAME /BODY MOUNTS, CREAK, SQUAWK CRUNCH , THE NOISE IS MOST NOTICEBLE WHEN TURNING OR HITTING BUMPS. SOME PEPLE ALSO DESCRIBE THE NOISE A HAMMER BEATING UNDER THE VEHICLE, THE CAUSE IS DETERIORATE BODY TO FRAME MOUNT CUSHIONS, THESE CUSHIONS APPER TO HAVE BEEN MADE OF SUBSTANDARD MATERIAL, MUCH LIKE CHINESE VALVE STEMS THAT CAUSE SO MUCH TROUBLE AFTER A FEW YEARS THE BODY MOUNTS DRY ROT , CRUMBLE AND LITERALLY FALL APART, THIS A TERRIBLE, THIS CAN PROVOKED A ACCIDENT.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS UNOCCUPIED, IT BECAME ENGULFED IN FLAMES. THE VEHICLE WAS DESTROYED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

BODY MOUNTS DETERIORATE BEFORE THEIR TIME AND BALL JOINT FAIL. *TR

I WAS DRIVING AND I SAW AND SMELT SMOKE. I IMMEDIATELY COULD TELL WHERE IT WAS COMING FROM BECAUSE I SAW THE SMOKE COMING OUT OF THE HAZARD LIGHT ON TOP OF MY STEERING WHEEL, IT THEN TURNED INTO A FLAME,IT WAS INSIDE OF THE STEERING WHEEL. I PULLED OFF TO THE SIDE OF THE ROAD BECAUSE FORTUNATELY I HAD WATER WITH ME AND I POURED A LITTLE BIT OF WATER ON THE FLAMES THAT WERE COMING OUT OF WHERE THE HAZARD LIGHT IS. THIS HAS HAPPENED 2 TIMES,WITH THE FINAL RESULT BEING 2 FIRES. IT HAPPENED A 3RD TIME WITH JUST SMOKE. I NO LONGER HAVE THE ABILITY TO USE MY WINDSHIELD WIPERS AND SOME OF MY INTERIOR LIGHTS NO LONGER WORK. I DON'T KNOW IF THIS HAS CAUSED OTHER PROBLEMS IE...MY CHECK ENGINE LIGHT BEING ON AS WELL AS MY CRUISE CONTROL WORKING WHEN IT WANTS TO AND OTHER TIMES NOT WORKING AT ALL PLUS THE BUTTONS ON THE INNER SIDE OF THE STEERING WHEEL BEING HOT TO THE TOUCH! I'M TERRIFIED TO DRIVE MY OWN CAR! *TR

AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. I TOOK IT TO THE FORD SHOP AND THEY TOLD ME THAT THEY HAVE FIXED SEVERAL AND THEY GO RIGHT BACK OUT IT WAS A WASTE OF MY TIME.. DOES SOMEONE HAVE TO GET KILLED BEFORE U ALL FIX THIS IF U TRY TO TAKE OFF AND IT SLIPS AND WILL NOT GO U CAN AND WILL GET HIT. *TR

AN ACCIDENT OCCURRED WHEREIN A YOUNG MAN WAS SEVERELY INJURED. HE SURVIVED, BUT HAS A PLATE IN HIS JAW, AND SEVERE SCARRING ON HIS FACE. HIS SISTER WAS ALSO A PASSENGER AND WAS INJURED, BUT LESS SEVERELY. THE RIGHT REAR TIRE APPEARS TO HAVE BLOWN OUT, CAUSING THE CRASH. A WITNESS IMMEDIATELY BEHIND THE CAR AT THE TIME OF THE ACCIDENT STATED: "I NOTICED WHAT LOOKED LIKE ONE OF THE RIGHT SIDE TIRES BEND TO THE SIDE AND SUDDENLY EXPLODE. AT THAT POINT THE DRIVER LOST CONTROL DUE TO THE TIRE EXPLOSION AND SWERVED TO THE CENTER DIVIDER AND CRASHED. INFORMATION ON THE TIRES IS AS FOLLOWS: RADIAL SXT ALL TERRAINS. DOT NUMBER ON THE TIRES WERE XFA 0307 AND THE TIRE SIZE WAS 75/16. ALL TIRES PASSED INSPECTION THREE MONTHS BEFORE, WITH A TREAD OF 6/32. THE OFFICER NOTED THE TREAD SEPARATED FROM THE TIRE. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 45 MPH, THE TRANSMISSION FAILED TO RESPOND WITH AN UNUSUAL WHINING NOISE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CRASHED INTO A TREE AND UPON IMPACT, ALL OF THE AIR BAGS DEPLOYED EXCEPT FOR THE FRONT DRIVER'S SIDE AIR BAG. THE VEHICLE WAS COMPLETELY DESTROYED. THE DRIVER SUSTAINED NECK AND BACK INJURIES. THE VEHICLE WAS NOT TAKEN TO A MECHANIC TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 101,000.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT STATED THAT THE BODY MOUNTS CORRODED WHICH CAUSED THE FRAME TO BECOME DETACHED FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND THE REAR BODY MOUNTS WERE REPLACED. THE FRONT PARTS WERE NOT REPLACED DUE TO THE PARTS BEING UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

CPSC#I12A0111A. 2001 FORD EXPLORER. CONSUMER STATED THAT A DAY AFTER SHE BROUGHT THE CAR IT BROKE DOWN. *LN THE CONSUMER STATED THERE WAS A PROBLEM WITH THE ENGINE, AS WELL AS A HOLE IN GAS TANK, WHICH HAD RUSTED OUT, THE BEARINGS NEEDED TO BE REPLACED, THE TIRE WERE DRY ROTTED, AS THEY KEPT GOING FLAT, THE DRIVER'S DOOR DID NOT LOCK, THE REAR DOORS DID NOT OPEN FROM THE INSIDE, THE REAR DRIVER'S DOOR DID NOT OPEN AT ALL, THE OUTSIDE HANDLE WAS BROKE, THE REAR HATCH WOULD NOT CLOSE, AND MOST OF THE TIME IT HAD TO BE SLAMMED SHUT.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT CRASHED INTO A TELEPHONE POLE AND THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO A TOW YARD. THE CONTACT SUSTAINED INJURIES TO THE JAW AND WAS TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE POLICE REPORTED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE 23,000.

VEHICLE WAS IDLING IN DRIVEWAY WITH THE DRIVERS DOOR OPEN. TRANSMISSION WAS IN PARK. TRANSMISSION DROPPED INTO REVERSE, ROLLED BACKWARDS IN DRIVEWAY, CRASHING THROUGH TWO CHAINLINK GATES, THE DOOR WAS TORN BACK AGAINST THE FENDER, I TRIED TO REACH INTO THE TRUCK TO TURN IT OFF, AND WAS PINNED BETWEEN THE TRUCK, AND THE CHAIN LINK FENCE. EXPLORER CURRENTLY IN THE COLLISION SHOP, AND TRANSMISSION WILL BE REPAIRED WHEN THE BODYWORK IS DONE. *TR

TRANSMISSION FAILED WITHOUT WARNING. WOULD NOT CATCH 3RD GEAR AND THEN SOUNDED LIKE A TOOLBOX WAS SCATTERED UNDER THE CAR. CAR SUCCESSIVELY LOST ALL GEARS EXCEPT 1ST. REPAIR COST OVER $2800.00. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE THE VEHICLE WAS STOPPED, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS DESTROYED AS A RESULT OF THE FIRE. THERE WAS NOT A POLICE OR FIRE REPORT FILED. THE DEALER WAS NOT NOTIFIED OF THE FAILURE SINCE THE VEHICLE WAS PURCHASED FROM A PRIVATE SELLER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 150,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE ENGINE EXHIBITED AN ABNORMAL INCREASE IN RPMS. THE VEHICLE THEN ACCELERATED ABNORMALLY AND THE CONTACT WAS INVOLVED IN A CRASH THAT INVOLVED FOUR ADDITIONAL VEHICLES. NO INJURIES WERE REPORTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE SERVO PLUG HAD POPPED OUT OF PLACE AND FRACTURED THE SIDE OF THE TRANSMISSION. THE DEALER ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHEN THE CONTACT ATTEMPTED TO OPEN THE REAR WINDOW THE LIFT GATE FAILED TO OPEN. THE MANUFACTURER STATED THAT THE VIN WASN'T INCLUDED IN RECALL 04V442000 STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS; THEREFORE THEY WILL NOT OFFER ANY ASSISTANCE. THE VEHICLE WILL BE TAKEN TO THE DEALER TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 126,643.

OD LIGHT IS FLASHING AND THE FIRST GEAR SHIFTS REAL HARD. I TOOK IT TO THE FORD SHOP AND THEY TOLD ME THAT THEY HAVE FIXED SEVERAL AND THEY GO RIGHT BACK OUT IT WAS A WASTE OF MY TIME.. DOES SOMEONE HAVE TO GET KILLED BEFORE U ALL FIX THIS IF U TRY TO TAKE OFF AND IT SLIPS AND WILL NOT GO U CAN AND WILL GET HIT. *TR

I HAVE A 2001 FORD EXPLORER AND AT FIRST THE TRUCK WOULD SLIP IN AND OUT OF GEARS SO I TOOK IT TO A CERTIFIED MECHANIC AND WAS TOLD I NEEDED A NEUTRAL SAFETY SWITCH. I HAD THAT REPLACED ABOUT A MONTH AGO. YESTERDAY, I WAS DRIVING AND THE TRUCK SLIPPED OUT OF DRIVE.... AND IT WOULD NOT ACCELERATE. I PULLED OVER AND ATTEMPTED TO RESTART THE VEHICLE AND THE O/D OFF LIGHT STARTED FLASHING. THIS TRUCK IS GOING TO COST ME OVER 2,000 DOLLARS TO FIX AND IT SEEMS AS IF I AM NOT THE ONLY ONE EXPERIENCING THE SAME PROBLEMS. PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER WITH GOODYEAR WRANGLER RT/S TIRES, SIZE P255/70R16. THE CONTACT NOTICED THE REAR PASSENGERS TIRE WAS FLAT AND THE REMAINING THREE TIRES EXHIBITED SIGNS OF DRY ROTTING. THE VEHICLE WAS TOWED TO A LOCAL TIRE SHOP. THE MECHANIC ADVISED THEY WOULD TAKE PARTIAL LIABILITY FOR THREE OF THE FOUR TIRES AND THE FOURTH WOULD BE REPLACED AT THE OWNERS EXPENSE. THE CONTACT BELIEVED THE TIRE MANUFACTURER SHOULD TAKE THE LIABILITY FOR ALL FOUR TIRES. THE DOT NUMBER WAS UNKNOWN. THE TIRE FAILURE MILEAGES WAS 32,985. THE VEHICLE FAILURE AND CURRENT MILEAGES WERE 112,461.

FORD EXPLORER 2001, V8 5.0L ENGINE. THE ORIGINAL MANUFACTURER SPARK PLUGS HAD RUSTED IN THE IRON BLOCK AND METAL RING SEPARATED FROM THE CERAMIC PART WHEN I TRY TO REMOVE THEM. A BROKEN THREADED PART REMAINED IN THE ENGINE BLOCK. IT HAPPENED ON THE FIRST THREE TRIED. ON FIST TWO I WAS ABLE TO USE A REMOVER TO EXTRACT THE LEFT OVER PART, ON THE THIRD ONE, THE THREADER BROKE IN THE HEAD. I HAD TO TAKE THE CAR TO A MECHANIC SHOP, PULL BOTH CYLINDER HEADS OUT AND REPLACE THE REST OF THE SPARK PLUGS. PORTS NEEDED TO HAVE INSERTS INSTALLED. DEFECT IS DUE TO THE DESIGN OF THE SPARK PLUG WITH SHORT THREAD FOLLOWED BY A CYLINDRICAL PART THAT ACCUMULATES MOISTURE AND RUST. *TR

'O/D OFF' LIGHT IF BLINKING, ON AND OFF. WHILE LIGHT IS BLINKING THE CAR SEEMS TO BE SLUGGISH AND DOES NOT RESPOND TO THROTTLE PROPERLY. ROUGH SHIFTS WHILE DRIVING. *TR

AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. *TR