2002 Ford Explorer Complaint Log

CPSC# I11A0238A. 2002 FORD EXPLORER. STUDS FOR VEHICLE REAR RIGHT TIRE COMPLETELY SNAP IN HALF. *LN

AT A STOP, BEGAN ACCELERATING TO ENTER HIGHWAY, ACCELERATOR PEDAL BECAME STUCK AND CAR CONTINUED TO ACCELERATE UP TO 90 MPH AT FULL THROTTLE BEFORE I SHUT VEHICLE OFF AND PUT IT IN NEUTRAL. HAS HAPPENED ON SEVERAL OCCASIONS, ALL EXACTLY THE SAME. VEHICLE ACCELERATES AT FULL THROTTLE AND HAS TO BE SHUT OFF BEFORE AN ACCIDENT OCCURS. ONLY WAY TO CORRECT PROBLEM IS TO EXIT VEHICLE AND PUSH GAS PEDAL SEVERAL TIMES; START VEHICLE AND SEE IF ENGINE IS STILL AT FULL THROTTLE.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE OVERDRIVE WARNING LIGHT ILLUMINATED AS THE VEHICLE BEGAN TO LOOSE POWER. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TR

I WAS DRIVING IN TOWN WHEN I ACCELERATED FROM A STOP LIGHT AND THE TRANSMISSION WOULD NOT ENGAGE INTO 3RD GEAR. THE ENGINE REVVED HIGHLY AND THEN SUDDENLY THE TRANSMISSION KICKED INTO GEAR WITH A SUDDEN JOLT FORWARD. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPLACEMENT OF THE REAR WHEEL BEARINGS WHEN THE MECHANIC NOTICED THAT THE DRIVER AND PASSENGER SIDE REAR COIL SPRINGS WERE FRACTURED AND WOULD HAVE NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

I RECENTLY HAD THE DEALER INSTALL 2 NEW REAR WHEEL BEARINGS (2ND TIME IN 2 YEARS) AND WAS TOLD THAT BOTH REAR SPRINGS ARE BROKEN. I WAS TOLD THAT THE BROKEN PIECES CAN COME OUT WHILE DRIVING AND PUNCTURE THE TIRE. I DID AN INTERNET SEARCH AND FOUND OVER 100 COMPLAINTS OF THE SAME BROKEN SPRINGS ON OTHER EXPLORERS. *TR

[XXX] GOT BEHIND THE WHEEL OF HER 2002 FORD EXPLORER, INTENDING TO PICK UP HER SON FROM SCHOOL. WHEN SHE TRIED TO SHIFT THE CAR INTO REVERSE, SHE SAYS THE ENTIRE GEAR SELECTOR BROKE OFF AND FELL IN HER LAP. IT TURNS OUT SHE'S NOT ALONE. TEAM 4 INVESTIGATOR JIM PARSONS REPORTED THAT THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION HAS BEEN INVESTIGATING SIMILAR COMPLAINTS AROUND THE COUNTRY -- SOME OF WHICH INVOLVED VEHICLES SLIPPING INTO GEAR AND CRASHING -- FOR MORE THAN TWO YEARS. NHTSA'S OFFICE OF DEFECTS INVESTIGATION SAYS IT HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVED THEY HAD SHIFTED THE SUVS INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES. EARLIER THIS YEAR, NHTSA UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS FOR 2002-2005 FORD EXPLORERS AND MERCURY MOUNTAINEERS. [XXX] SAYS FORD TOLD HER SHE WOULD NEED TO REPLACE HER ENTIRE STEERING COLUMN TO FIX THE BROKEN GEAR SELECTOR AT A COST OF MORE THAN $1,500. INSTEAD, SHE WORKED WITH HER LOCAL MECHANIC TO FIND AN AFTER-MARKET REPLACEMENT PART THAT RETAILS FOR $30. SO FAR, FORD MOTOR COMPANY HAS NOT ISSUED A RECALL ON THE GEAR SELECTOR. MORE INFORMATION: NHTSA WEBSITE DETAILS ON EXPLORER INVESTIGATION (TYPE IN ACTION NUMBER EA09013) READ MORE: HTTP://WWW.WTAE.COM/NEWS/29353127/DETAIL.HTML#IXZZ1ZYUBPJEG INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE THE CONTACT SHIFTED INTO REVERSE THE GEAR SHIFT LEVER COMPLETELY DISENGAGED FROM THE HOUSING AREA. THE VEHICLE WAS TOWED TO THE DEALER AND CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.

GEAR SHIFT BROKE OFF IN MY HANDS. *TR

THE TRANSMISSION HAS A 5 SECOND DELAY WHEN GOING INTO REVERSE OR DRIVE. THE CAR TRANSMISSION JERKS FORWARD SUDDENLY AND RANDOMLY SHIFTS INTO A HIGHER OR LOWER GEAR WHILE DRIVING. THERE IS A LOUD GRINDING NOISE WHILE THE CAR IS RUNNING AND WHILE THE GEARS ARE SHIFTING. *TT

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT AFTER LOOSING CONTROL OF THE VEHICLE AND CRASHING INTO A POLE, NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED AND THE DRIVER SUSTAINED MINOR CONTUSIONS. THE PASSENGER SUFFERED A BROKEN ARM. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT WAS DRIVING 50 MPH UPHILL WHEN THE VEHICLE BEGAN TO STALL. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND WAS UNABLE TO SHIFT INTO PARK. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WOULD NEED REPLACING. THE CONTACT CALLED THE MANUFACTURER AND WAS TOLD THAT A POSSIBLE BRAKE FLUID LEAK CAUSED THE TRANSMISSION TO MALFUNCTION. THE CONTACT DID NOT HAVE THE TRANSMISSION REPLACED. THE FAILURE MILEAGE WAS 129,000.

TRANSMISSION FAILURE. *TR

IN THE EVENING, I WAS ABOUT HALF AN HOUR FROM HOME WHEN I PULLED UP TO A GAS PUMP AT A STATION AND ATTEMPTED TO PUT THE VEHICLE INTO PARK. I DID NOT DO ANYTHING DIFFERENT THAN NORMAL. THE STEERING GEAR SHIFT BROKE OFF INTO MY HAND. IT WAS ATTACHED BY A WIRE. I COULD NOT TELL WHAT HAPPENED EXCEPT THAT IT WAS BROKEN OFF THE STEERING COLUMN. THE SERVICE DEPARTMENT OF THE DEALERSHIP WAS CLOSED BUT THE RECEPTIONIST SAID THAT THE VEHICLE COULD BE LEFT AT THE SERVICE DEPARTMENT LOT OVERNIGHT AND THEY WOULD TAKE A LOOK AT IT THE NEXT DAY. I DROVE TO THE DEALERSHIP HOLDING THE PIECE IN MY RIGHT HAND AS I DID NOT KNOW WHAT WOULD HAPPEN IF IT BECAME UNATTACHED FROM THAT WIRE. I FELT SCARED THAT SOMETHING WAS GOING TO HAPPEN SUCH AS A FIRE, TURN COMPLETELY OFF IN TRAFFIC, ETC. I DIDN'T KNOW WHAT WAS GOING TO HAPPEN NEXT. I GOT TO THE DEALERSHIP, SET THE EMERGENCY BRAKE AND TURNED OFF THE IGNITION. I COULDN'T GET THE KEY OUT OF THE IGNITION. I HAD NO CHOICE BUT TO LEAVE MY VEHICLE THERE WITH KEY IN THE IGNITION. I EMPTIED AS MUCH OF MY STUFF FROM THE CAR AS I COULD AS I WAS WORRIED THAT THERE COULD BE SOME TYPE OF CRIMINAL ACTIVITY OVERNIGHT. THANKFULLY, IT WAS THERE THE NEXT MORNING BUT UNFORTUNATELY THE COST OF REPAIR IS OVER $1,500. THE SERVICE ADVISOR SAID THE ONLY WAY TO FIX THIS IS TO REPLACE THE ENTIRE STEERING COLUMN. THIS IS ALL OUT OF POCKET COSTS. I AM THANKFUL THAT THE DEALERSHIP DOES PROVIDE FREE LOANERS AND THAT THIS HAPPENED IN A PLACE WHERE I COULD EXIT THE LOCATION AND MAKE IT TO THE DEALERSHIP. THE COST TO REPAIR, THE STRESS THAT THIS CAUSED, THE FACT THAT THIS IS A KNOWN DEFECTIVE PART, AND THE POSSIBILITY OF THIS HAPPENING AGAIN ARE ALL NOT GOOD. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT SHE WAS UNABLE TO SHIFT THE VEHICLE INTO REVERSE. THE DEALER INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE TRANSMISSION. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 131,000.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE MOVING THE GEAR SHIFTER FROM PARK TO REVERSE, THE GEAR SHIFTER FRACTURED AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS STATED THE STEERING COLUMN HAD TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

THE TRANSMISSION IS JUNK. FORD KNOWS THIS. REBUILDING OR REPLACING THE TRANSMISSION IS INEVITABLE...AND NOT JUST ONCE, BECAUSE THERE ARE KNOWN DESIGN AND MANUFACTURING ISSUES THAT WILL ONLY CAUSE THE FAILURES TO REPEAT THEMSELVES. UNLESS THESE FAILURES ARE DEALT WITH, THERE ARE MANY PEOPLE ON THE ROADS WHO ARE AT THE MERCY OF LUCK THAT THE CAR THEY ARE DRIVING OR THE CARS THAT OTHERS ARE DRIVING NEAR THEM WONT STOP DEAD, STOPPING THEM DEAD. HOW IS THIS KNOWN PROBLEM NOT A PUBLIC SAFETY ISSUE? HAVE YOU COUNTED THE NUMBER OF FORD EXPLORERS ON THE ROAD?? ITS SCARY. *TR

THE REAR HINGES GAVE WAY, AND THE BACK HALF GLASS EXPLODED. *TR

I HAVE A 2002 FORD EXPLORE WITH 47,000 MILES. WAS TOLD BOTH REAR SPRINGS WERE BROKE DURING VEHICLE INSPECTION. DON'T KNOW WHEN THEY BROKE. DAILY DRIVER ONLY, NO TOWING. SHOULD NOT HAPPEN AT 47,000 MILES SHOULD HAVE A RECALL WITH ALL THE COMPLAINTS WITH SPRINGS. *TR

#3 CYCLINDER PLUB BLEW. HAD TOWED TO DEALER. DEALER SAID THEY COULD FIX EASILY BY INSTALLING A HELIX COIL ADAPTER & COULD HAVE CAR READY NEXT DAY. DEALER CALLS BACK AND SAYS THEY FIXED IT BUT IT WAS REALLY RUNNING BAD AND THAT THEY WOULD NOT RECOMMEND DRIVING IT. I ASKED WHAT THE SOLUTION WAS AND THEY SAID THEY COULD PULL THE HEAD AND REFINISH IT BUT THAT THEY WOULD NOT RECOMMEND DOING SUCH. I ASKED ABOUT A JASPER AND THEY SAID THEY WOULD NOT RECOMMEND AS JASPER HAS A POOR WARRANTY (12 MONTHS+LIMITED MILEAGE & NO LABOR) WHILE A NEW FORD ENGINE WOULD HAVE 3 YEARS, NO MILEAGE LIMIT & BE WARRANTED FOR BOTH LABOR AND PARTS. AS I NEEDED THE VEHICLE - AS IT IS I HAD TO RENT A VEHICLE. AFTER GETTING THE VEHICLE BACK AND TALKING WITH SEVERAL OTHER FORD DEALERS - IT WOULD SEEM THAT THERE IS A STRONG POSSIBILITY THAT THE FORD DEALER INSTALLING THE HELIX COIL MAY HAVE DROPPED DEBRIS INTO THE ENGINE - AS NONE OF THE OTHER DEALERS SAID THEY HAVE EVER HAD TO REPLACE AN ENGINE FOR A BLOWN SPARK PLUG. PS: THE PLUGS WERE THE ORIGINALS FROM THE FACTORY. I HAVE TRIED TO WORK WITH THE DEALER TO GET SOME SORT OF REDUCTION IN WHAT I HAD TO PAY BUT THEY HAVE BEEN LESS THAN INTERESTED IN TALKING WITH ME. SO AM TRYING FIGURE OUT WHAT MY NEXT STEP SHOULD BE. ALL ADVISE WOULD BE APPRECIATED AS APPARENTLY THE PLUG BLOWING PROBLEM IS COMMON! THIS IS A SERIOUS SAFETY HAZARD - THERE COULD HAVE BEEN A FIRE. *KB

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 55 MPH SHE NOTICED SMOKING IN THE REAR OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO STATED THERE WAS A MINOR DEFECT IN THE TRANSMISSION. THE MECHANIC REPAIRED THE DEFECT AND WITHIN TWO WEEKS THE TRANSMISSION FAILED. THE CONTACT TOWED THE VEHICLE TO HER HOME AND NOTIFIED THE MANUFACTURER REGARDING THE TRANSMISSION FAILURE. THE MANUFACTURER STATED THERE WAS NOTHING THEY COULD SINCE THERE WERE NO RELATED RECALLS. THE CONTACT STATED IF THE TRANSMISSION FAILED WHILE DRIVING ON THE HIGHWAY, A CRASH COULD OCCUR. THE FAILURE MILEAGE WAS 150,000.

2002 FORD EXPLORER HAD ALL COIL SPRINGS BROKEN AND SOME MAY HAVE BEEN FOR QUITE SOME TIME. THIS IS A COMMON PROBLEM THAT FORD WILL NOT ACKNOWLEDGE. I PULLED INTO MY DRIVEWAY AND I HEARD SOMETHING CLUNK IN THE BACK AND SURE ENOUGH IT WAS COMPLETELY CRACKED. TOOK IT INTO GET REPAIRED ALONG WITH STRUTS AND BALL BEARING PLATE. TOTAL COST FOR THE FAILURE OF THESE SPRINGS = $1750! *TR

I HAVE A 2002 FORD EXPLORER THAT HAS 120,000 MILES ON IT. I WAS RECENTLY DRIVING BACK HOME FROM A TRIP IN SAN FRANCISCO, CALIFORNIA TO SACRAMENTO, CALIFORNIA. TWO DAYS AFTER HAVING MY CAR FULLY SERVICED AND MY OVER DRIVE LIGHT CAME ON AND AS SOON AS THAT HAPPENED MY CAR STARTED TELLING ME I NEED TO GET MY TRANSMISSION CHECKED. I SAT THERE THINKING TO MYSELF HOW CAN THIS BE HAPPENING I JUST SPENT 800 DOLLARS TO HAVE ALL OF MY FLUIDS FLUSHED, BRAKES CHECKED, EVERYTHING. I TOOK MY CAR BACK TO THE AUTO REPAIR STORE AND THEY TOLD ME I NEEDED A NEW TRANSMISSION AND AFTER LABOR IT WOULD BE AROUND 5000 (I THINK I WAS QUOTED THAT PRICE BECAUSE I'M A YOUNG FEMALE, I WAS LOOKING ONLINE AND MOST PEOPLE WERE QUOTED AROUND 3000). I'M A FULL TIME COLLEGE STUDENT PAYING FOR MY CLASSES WITH STUDENT LOANS AND GRANTS. I DON'T HAVE A FEW THOUSAND DOLLARS SITTING AROUND AT MY DISPOSAL TO FIX MY CAR. I ALSO CAN'T HAVE MY CAR IN THE SHOP FOR A LONG PERIOD OF TIME DUE TO THE FACT IF I MISS MORE THAN 3 CLASSES MOST OF MY PROFESSORS WILL DROP ME. I HAVE RESEARCHED THIS ISSUE AND MANY OTHER CONSUMERS NOT JUST MYSELF HAVE HAD THIS INCIDENT HAPPEN TO THEM, I BELIEVE FORD IS IN THE WRONG FOR HAVING FAULTY MANUFACTURING, THEY HAVE MADE IT SO ANY TRANSMISSION WORK HAS TO BE DONE BY THE DEALER, YOU CAN'T EVEN CHECK YOUR OWN TRANSMISSION FLUID. I FEEL AS IF FORD NEEDS TO ISSUE A RECALL ON THEIR TRANSMISSIONS OR OFFER SOME KIND OF HELP TO PAY FOR THESE UNACCEPTABLE INCIDENTS. *TR

2002 FORD EXPLORER LF SEATBELT BUCKLE PRETENSIONER BAD. AIRBAG LIGHT CONTINUED TO ILLUMINATE AFTER TWO REPLACEMENTS OF OVER 300.00 EA. SAFETY ISSUE? *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING 55 MPH THE ACCELERATOR PEDAL WOULD NOT DISENGAGE. THE DRIVER ATTEMPTED TO PULL THE ACCELERATOR PEDAL UP WITH HER FOOT BUT WAS UNSUCCESSFUL BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE SLOWED DOWN. THE DRIVER WAS ABLE TO MANEUVER THE VEHICLE OFF OF THE ROAD AND CRASHED INTO A FEW SMALL TREES IN A WOODED AREA. THE DRIVER PREVIOUSLY SUFFERED FROM SPINAL INJURIES AND EXPERIENCED BACK AND HIP PAIN. THE DRIVER WAS TREATED BY A DOCTOR FOR THE INJURIES. A POLICE REPORT WAS FILED. THE INSURANCE COMPANY HAD THE VEHICLE TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 09/21/11*LJ UPDATED 10/05/11

THIS COMPLAINT IS IN REGARDS TO THE 2002-2005 FORD EXPLORER/MERCURY MOUNTAINEER MODELS (4 DOORS). I OWN A 2002 FORD EXPLORER 4 DOOR XLS WITH 150,000 MILES. RECENTLY MY VEHICLE BECAME VERY DANGEROUS TO DRIVE. WHEN I ACCELERATE AND THEN RELEASE THE PEDAL THE VEHICLE WOULD "PUSH" TO ONE SIDE OR ANOTHER. ALSO GOING AROUND CURVES I WOULD GET A "DEATH WOBBLE" WHERE THE VEHICLE WOULD "PUSH" FROM SIDE TO SIDE IN ALMOST A SWINGING MOTION AND WHEN YOU ATTEMPT TO CORRECT IT, IT CONTINUES TO SWING EXCESSIVELY BACK AND FORTH. TONIGHT I WENT TO CHECK MY WHEEL BEARINGS THINKING THIS WAS THE PROBLEM, AND I FOUND 3 OUT OF THE 4 COIL SPRINGS ON THE STRUTS WERE BROKEN. BOTH REAR COILS WERE SHATTERED (EASIEST WAY TO DESCRIBE IT) AT THE TOP OF THE SPRING. I COULD LITERALLY PULL PIECES OF COIL SPRING OUT OF THE COIL. THE FRONT RIGHT SPRING WAS ALSO CRACKED ALL THE WAY THROUGH, NEAR THE BOTTOM OF THE COIL. I HAVE SPENT ALOT OF TIME WORKING ON CARS AND I HAVE NEVER SEE 3 COIL SPRINGS FAIL AT THE SAME TIME ESPECIALLY SINCE THEY ARE LESS THAN 10 YEARS OLD!!! I ALSO DID A GOOGLE SEARCH AND READ WHERE OTHER OWNERS HAVE HAD SPRING FAILURES AS LOW AS 75,000 MILES!! PLEASE LOOK INTO THIS ISSUE THERE ARE SO MANY OF THESE ON THE ROAD. I WORK IN LAW ENFORCEMENT AND THIS I FEEL IS A SIGNIFICANT SAFETY RISK AFTER EXPERIENCING THE LOSS OF CONTROL YOU HAVE WHEN DRIVING THE VEHICLE IN THIS CONDITION. IF THIS WOULD HAVE HAPPENED IN THE ILLINOIS WINTER WITH ICE ON THE ROADS IT COULD HAVE BEEN DISASTROUS. I WILL BE REPLACING THE ENTIRE STRUT/COIL SPRING ASSEMBLY SING THE REAR SPRINGS HAVE COLLAPSED IN SUCH A WAY THAT THE SPRING IS RUBBING ON THE STRUT BODIES. ONE OF THE ISSUES IS, WITH EXCEPTION OF THE HANDLING CHARACTERISTICS, THE VEHICLE SITS LEVEL AND CLOSE TO ITS NORMAL RIDE HEIGHT AND ITS IS VERY DIFFICULT TO TELL 3 SPRINGS ARE BROKEN. I WILL BE TAKING PICTURES TO DOCUMENT THIS FAILURE AND I WILL BE WILLING TO PROVIDE THIS TO YOU. I MAY ALSO SAVE THE OLD PARTS IF YOU WOULD LIKE. *TR

WAS DRIVING HOME FROM GETTING GROCERIES AND THE CAR FAILED TO ACCELERATE. WAS AT A INTERSECTION SO IT WAS A UNPLEASANT SITUATION AS THEIR WAS ONCOMING CARS. PULLED THE CAR OVER AND SHUT OFF.. CHECKED FOR TRANSMISSION FLUID.. THERE WAS NONE. STARTED CAR AND IT WOULD ONLY DRIVE ABOUT 15 MPH THE REMAINDER OF THE TRIP. THE OVERDRIVE CONTROL ON THE TRANSMISSION HAD FAILED. 2200 REPAIR.. CHECKED THE RECALLS AND THERE CURRENTLY IS NOT ONE EVEN THOUGH THIS SPECIFIC TRANSMISSION HAS THOUSANDS OF COMPLAINS (NOT OVER EXAGGERATING) THIS IS A DANGEROUS SITUATIONS CONSIDERING I COULD HAVE BEEN ON THE INTERSTATE OR A ON RAMP. THIS VEHICLE IS SITTING IN MY GARAGE AWAITING A RECALL OF WHEN MY FAMILY GETS THE FINANCIAL STABILITY TO REPAIR IT IN A NON FORD DEALERSHIP/REPAIR SHOP. THIS SUV GETS REGULAR FLUID FILLS/CHANGES AT THE CORRECT INTERVALS WITH DOCUMENTATION.. THIS TRANSMISSION IS "SEALED" WHICH MEANS IT CANNOT BE CHECKED FOR FLUID LOSS OR BAD FLUID. "BAD ENGINEERING" WHICH SHOULD REQUIRE A REPAIR AT FORDS EXPENSE. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT UPON SHIFTING THE VEHICLE INTO REVERSE, THE GEAR SHIFTER SEPARATED FROM THE STEERING COLUMN. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 183,000.

2002 FORD EXPLORER-TRANSMISSION FAILURE-130,000 MILES-JULY 12, 2011 TRANSMISSION REBUILT AT 119,000 MILES ON JAN. 13, 2010 BY A LOCAL FORD DEALER- BOTH FAILURES CONSISTED OF THE TRANSMISSION SLIPPING IN AND OUT OF GEAR DURING NORMAL DRIVING. IN HEAVY TRAFFIC THIS IS A VERY DANGEROUS SITUATION. THE VEHICLE SUDDENLY LOSES SPEED AND PASSENGERS ARE SUBJECT TO REAR END IMPACT OR SUDDEN SURGES OF SPEED WHEN THE TRANSMISSION SLIPS BACK INTO GEAR, CAUSING A POSSIBLE REAR END IMPACT WITH ANOTHER VEHICLE. IN ADDITION, THE TRANSMISSION STICKS IN ONE GEAR AND WILL NOT SHIFT. FORD MOTOR COMPANY HAS BEEN AWARE OF THE PROBLEMS WITH THIS TYPE OF TRANSMISSION SINCE 2002. MY LOCAL DEALER SAYS THAT FMC FIGURES REVEALED THAT 30% OF VEHICLES EQUIPPED WITH THIS TRANSMISSION EXPERIENCED FAILURE OF SOME TYPE. HOWEVER FMC OFFERED VERY LITTLE RELIEF TO ITS CUSTOMERS. I BELIEVE THAT IT IS TIME FOR AN IMMEDIATE FORCED RECALL OF THIS TRANSMISSION. *KB

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE TIMING CHAIN WAS FRACTURED AND THE ENGINE WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 177,000. THE VIN WAS UNAVAILABLE.

I HAVE A 2002 FORD EXPLORER XLT, MY TRANSMISSION JUST RECENTLY WENT OUT. IT HAS ABOUT 142,000 MILES. I TOOK IT TO A TRANSMISSION SPECIALIST, TO GET IT FIXED, THEY TOOK IT APART, AND TOLD ME IT WAS COSTING $3,786.60 TO GET IT FIXED/REBUILT! AS OF RIGHT NOW MY TRUCK IS STILL IN THE SHOP, IT HAS BEEN THERE FOR 2 WEEKS NOW. THERE IS NO WAY CAN AFFORD TO PAY THAT, I"M JUST A STUDENT. I DID SOME RESEARCH ONLINE AND IT TURNS OUT THAT THERE IS THOUSANDS OF PEOPLE WITH THE SAME PROBLEM; TRANSMISSIONS GO OUT AND THE MAJORITY ON THE 2002 MODEL. THEY REBUILD THE TRANSMISSION, ONLY FOR IT TO GO OUT AGAIN. SOME PEOPLE HAVE REPLACED/REBUILT THEIR TRANSMISSIONS 4 OR 5 TIMES. I ALSO READ THAT THESE TRUCKS CAN STOP AT ANY MOMENT; ANYWHERE. THIS IS VERY DANGEROUS, ESPECIALLY IF ON THE FREEWAY. I DON'T SEE WHY FORD, DIDN'T RECALL THIS TRUCK OR THIS TRANSMISSION. THEY NEED TO TAKE RESPONSIBILITY AND FIX THE PROBLEM. I HAVE NO IDEA, WHAT I AM GOING TO DO TO GET MY TRUCK FIXED.. OR MAYBE EVEN REPLACED. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE WOULD NOT ACCELERATE MORE THAN 20 MPH, AND THE OVER DRIVE WARNING LIGHT REMAINED ILLUMINATED. DUE TO THE TYPE OF WARNING LIGHT, THE VEHICLE WOULD NOT SHIFT INTO GEAR, CAUSING THE TRANSMISSION TO FAIL. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS OR WARRANTIES, AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 68,000.

I OWN A 2002 XPLORER, RECENTLY THE O.D LIGHT BEGAN BLINKING AND THE TRUCK STARTED JERKING VIOLENTLY. I DID SOME RESEARCH AND FOUND OUT THERE ARE THOUSANDS OF PEOPLE WITH THE SAME TRANSMISSION PROBLEM.I HAVE AN EIGHT YEAR OLD WHO WAS IN THE TRUCK WITH ME AT THE TIME.THIS IS A MAJOR SAFETY ISSUE WITH FORD AND SHOULD DEFINATELY BE LOOKED INTO. *TT

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK THE VEHICLE, SHE NOTICED SMOKE AND FLAMES COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND THE ORIGIN OF THE FIRE WAS UNKNOWN. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE FAILURE WAS LOCATED AT THE MASTER CYLINDER. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED AND A CLAIM WAS FILED. THE CONTACT WAS AWAITING FURTHER INSTRUCTION BY THE MANUFACTURER. THE FAILURE MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE DEALER MADE FOUR ATTEMPTS TO DUPLICATE THE FAILURE BY REPLACING THE DRIVER AND PASSENGER SIDE SEAT BELT PRETENSIONERS HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 165,000 AND THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE. UPDATED 01/10/12*LJ

REAR PANEL HAS CRACK 2 TIMES. WE PAID 600.00$ FOR FIRST REPAIR. 3 MONTHS LATER THE REAR PANEL CRACKED AGAIN. NO CRASH OR ACCIDENT.

REAR CRACKED/CRUMBLING STRUT SPRINGS BOTH SIDES. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE PARKED, THE CONTACT NOTICED FLAMES AROUND THE RADIO CONSOLE AND THE DASHBOARD. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FIRE WAS DETERMINED TO BE A FAILURE WITHIN THE RADIO CONSOLE WIRES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

I WAS RIDING ALONG THE HIGHWAY IN MY 2002 FORD EXPLORER WITH MY TWO KIDS ON VACATION. WE HAD BEEN DRIVING FOR ABOUT 4 HOURS . I WAS USING THE CRUISE CONTROL. I CAME TO A RED LIGHT THEN CONTINUED ON FOR ABOUT 2 MILES THAN ALL OF A SUDDEN THE CHECK TEMP GAUGE CAME ON AND THE GAUGE WAS ALL THE WAY HOT. I WAITED FOR A SAFE PLACE ON THE SIDE OF THE RODE TO PULL OVER. AS SOON AS THE TRUCK WAS PUT IN PARK SMOKE STARTED COMING IN THROUGH THE GLOVE BOX AND THE HOOD. MY SON WHO WAS SITTING IN THE PASSENGER SEAT SAID HIS LEGS FELT HOT. A PASSERBY PULLED OVER AND YELLED GET YOUR STUFF AND GET OUT OF THE TRUCK. WE HAD ENOUGH TIME TO GET WHAT WE COULD AND RUN. THE TRUCK STARTED TO BURN AND ALL WE COULD DO WAS WATCH. WE WERE STRANDED 4 HOURS FROM HOME. LUCKILY FOR US THE GOOD SAMARITANS PROBABLY SAVED OUR LIVES. THE TRUCK WENT FROM HOT TO FULLY INVOLVED IN A MATTER OF A FEW MINUTES. BY THE TIME THE FIRE DEPT. CAME THE TRUCK WAS A TOTAL LOSS. *TR

TRANSMISSION HAS GONE OUT AT 85,300 MILES, MUST HAVE IT REBUILT. *KB

MY VEHICLE SURGES FORWARD WHEN THE BRAKES ARE APPLIED. THIS HAS HAPPENED SEVERAL TIMES THIS MONTH. *TT

MY 2002 FORD EXPLORER (AUTOMATIC TRANSMISSION) WAS PARKED IN MY DRIVEWAY. I ATTEMPTED TO SHIFT OUT OF PARK WHEN THE GEAR SHIFT BROKE OFF IN MY HAND. I NOW HAVE TO PAY $1360 FOR A REPLACEMENT (USED) STEERING COLUMN. AFTER DOING RESEARCH, I HAVE DISCOVERED THAT THIS PROBLEM IS VERY COMMON WITH 2002 FORD EXPLORERS. FORD MOTOR COMPANY SHOULD VOLUNTARILY DO A RECALL, BEFORE A CLASS ACTION LAW SUIT IS BROUGHT AGAINST THEM. *TR

MY GEAR SHIFT BROKE AS I WAS PUTTING INTO GEAR AND IT JUST FELL INTO MY HANDS IT BROKE INTO TWO HALF A PIECE THAT SHOULD NOT BROKE AND AS I WAS GOING SOMEWHERE THE TRUCK JUST STARTING GOING CRAZY THE LIGHTS WAS FLASHING ON AND OFF THE ALARMS WAS GOING OF THE LIGHTS FLASHIN,SOMETIMES IN THE MIDDLE OF THE NIGHT THE ALARM JUST GOES OFF ON IT ON WE SEE ALL THIS HAPPEN AND NO ONE IS BY THE TRUCK NO CATS DOGS NOTHING. *TR

WHEN SHIFTING FROM REVERSE TO PARK THE SHIFT LEVER BROKE OFF IN MY HAND. TO RESEARCH THIS PROBLEM PLEASE LOOK AT WWW.CARCOMPLAINTS.COM AND LOOK UNDER THE 2002 EXPLORER AND UNDER THE SUB HEADING INTERIOR ACCESSORIES PROBLEMS. OF THE 180 COMPLAINTS UNDER THIS SUB HEADING, 126 ARE FOR THE BROKEN SHIFT LEVER PROBLEM AND THESE WERE ALL REPORTED SINCE 2008. PLEASE ISSUE A RECALL FOR THIS SAFETY PROBLEM. THE PROBLEM IS CLEARLY DUE TO FAULTY DESIGN AND FAULTY PARTS. *TR

YOU NEED TO SERIOUSLY LOOK INTO RECALLING ALL 2002 FORD EXPLORERS FOR POTENTIALLY DANGEROUS WHEEL AND HUB ASSEMBLIES. THIS HAPPENED ON MULTIPLE OCCASIONS. THE FIRST TIME IT HAPPENED, IT HAPPENED IN AUGUST 2008. I JUST MOVED INTO MY DORM, AND I HAD TO GO HOME FOR A LITTLE WHILE. I WAS ON THE PENNSYLVANIA TURNPIKE, AND MY TRUCK BEGAN SWERVING TO THE POINT THAT I HAD NO CONTROL OVER IT, AND I HAD TO PULL OVER. WHEN I GOT OUT, I PULLED THE LUG COVER OFF THE REAR PASSENGER SIDE WHEEL TO FIND THAT FOUR OF THE FIVE LUGS WERE SNAPPED. I HAD TO PAY $400 TO HAVE IT TOWED, AND WHEN IT GOT TO THE GARAGE, THEY FOUND THAT THE WHEEL BEARINGS AND HUB WERE DAMAGED. THE NEXT TIME IT HAPPENED, IT HAPPENED ON THE DRIVER'S SIDE REAR WHEEL, AND, AGAIN, THE LUGS SNAPPED AND THEY FOUND THE HUB AND WHEEL BEARINGS TO BE THE CAUSE OF IT. THIS WAS ABOUT A MONTH AFTER THE FIRST INCIDENT. THE THIRD INCIDENT INVOLVED BOTH FRONT WHEELS, BUT LUCKILY ONLY THE WHEEL BEARINGS AND HUBS WERE DAMAGED AND MY WHEELS STAYED IN PLACE. THIS HAPPENED ABOUT NOVEMBER OF 2010. IN JANUARY OF 2011, THE REAR WENT AGAIN. THIS TIME IT WAS IN THE MIDDLE OF A SNOW STORM, SO I HAD TO WAIT IN THE FREEZING COLD FOR TWO HOURS UNTIL THE TOW TRUCK COULD COME. CURRENTLY, MY VEHICLE IS SITTING IN A GARAGE TO HAVE YET ANOTHER WHEEL BEARING REPLACED BECAUSE IT HAS FAILED. IN TOTAL, IN THE LAST TWO YEARS, THE REAR WHEEL BEARINGS HAVE BEEN REPLACED THREE TIMES EACH AND THE FRONT WHEELS HAVE NOW BEEN REPLACED TWO TIMES EACH. EVERY TIME IT HAPPENS, IT FEELS AS THOUGH YOU ARE DRIVING ON ICE, AND THE VEHICLE EVENTUALLY GETS TO THE POINT WHERE IT CANNOT BE CONTROLLED ANY LONGER. I'VE HAD NUMEROUS INCIDENTS WHERE I'VE BEGAN TO FISHTAIL. EVERY TIME IT GOES TO THE GARAGE, THEY PUT IT ON THE LIFT AND THE WHEELS JUST DANGLE THERE. THE MECHANIC, ONE TIME, KICKED IT AND IT FELL OFF. HE DID THIS TO SHOW HOW CLOSE I WAS TO A MAJOR ACCIDENT. THESE VEHICLES NEED TO BE RECALLED AND EQUIPPED WITH SUPERIOR PARTS. FORD WILL EVENTUALLY KILL SOMEONE. *TR

WHILE MY WIFE WAS BACKING UP IN MY SON'S DRIVEWAY, THE GEAR SHIFT BROKE ON MY 2002 FORD EXPLORER. THE CHARGE TO REPAIR BY A FORD DEALER WAS ROUGHLY $2,000.00 (INCLUDING TOW CHARGES). AFTER DOING RESEARCH ON THIS ISSUE, IT APPARENTLY IS WAY TOO COMMON, HOWEVER FORD REFUSES TO ACKNOWLEDGE RESPONSIBILITY OR ISSUE A RECALL. *TR

MY 2002 FORD EXPLORER'S TRANSMISSION COMPLETELY STOPPED WORKING WHILE STOPPED AT A TRAFFIC LIGHT. THAT IS A MAJOR SAFETY HAZARD AND COULD HAVE CAUSED A MAJOR ACCIDENT. I HAVE READ NUMEROUS COMPLAINTS ABOUT THE TRANSMISSION IN THESE MODEL AND YEAR VEHICLES. THERE NEEDS TO BE SOME RECALL FOR THIS. *TR

UPON TAKING MY 2002 FORD EXPLORER FOR A ROUTINE OIL CHANGE. I WAS INFORMED BY THE FORD DEALER THAT MY LEFT REAR SPRING WAS BROKEN. MY EXPLORER ONLY HAS 26,116 MILES, HOW COULD THE SPRINGS BREAK? I NEVER CARRY ANYTHING HEAVY, USUALLY ONLY ONE PERSON IS IN THE VEHICLE. IV'E BEEN READING ON THE INTERNET AND THERE ARE HUNDREDS OF OTHER PEOPLE WITH THE SAME PROBLEM. WHY HASN'T NHTSA LOOKED IN THIS ISSUE SINCE IT IS A SAFETY PROBLEM? FORD MOTOR CO. KNOWS THIS IS A DEFECT SINCE THEY CHANGED THEIR DESIGN AFTER IT WAS DISCOVERED. CAN NHTSA RE-EXAMINE THIS ISSUE AND ORDER A RECALL BEFORE SOMEONE JETS INJURED. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE ODOMETER BEGAN TO FLASH AND THE VEHICLE BEGAN TO JERK ABNORMALLY. THE VEHICLE WAS TAKEN HOME AND PARKED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 84,000.

THE TRUNK OF MY VEHICLE HAS DEVELOPED A SIZABLE CRACK IN THE REAR PANEL ONLY THROUGH NORMAL USE. I HAVE SEEN THIS ON A NUMBER OF OTHER SIMILAR VEHICLES AND KNOW IT IS NOT ONLY ME WITH THIS PROBLEM. *TR