2016 Ford Explorer Complaint Log

WHENEVER PUTTING THE VEHICLE INTO REVERSE THERE WILL BE A LOUD POP AND WILL SLAM INTO GEAR. SIMILARLY WILL HAPPEN WHEN SHIFTED INTO DRIVE. THEN WHEN CHANGING GEARS FROM SECOND TO THIRD THE VEHICLE WILL HESITATE SWITCHING GEARS AND THE RPM WILL GO INTO THE 5000 RPM. WILL HAPPEN USUALLY WHEN SHIFTING AGAIN INTO A HIGHER GEAR. USUALLY CAN DRIVE AROUND FIVE TO TEN MILES AND WILL SORT ITSELF OUT. HOWEVER IF YOU ARE ENTERING TRAFFIC ESPECIALLY A BUSY ROAD SYSTEM THIS MAY NOT ALLOW YOU TO ACCELERATE TO A SAFE SPEED SINCE THE GEARS NOT SHIFTING WILL CAUSE THE VEHICLE TO STALL AND NOT ACCELERATE.

I STARTED HEARING A GRINDING NOISE WHEN TURNING THE VEHICLE IN EITHER DIRECTION IN REVERSE LAST WEEK. I TOOK A LITTLE TRIP ON DEC. 5 2020, GOING UP TO THE MOUNTAINS. IT GOT WORSE WHILE STEERING MY VEHICLE ON A MOUNTAIN ROAD. I MADE AN APPOINTMENT ON DECEMBER 7 TO THE LOCAL DEALER. MY WIFE WAS DRIVING AT 50 MPH WHEN THE STEERING STARTED TO LOCK UP AND ALMOST CAUSED A COLLISION.THAT'S WHEN WE DECIDED IT IS A SAFETY ISSUE TO DRIVE THIS VEHICLE SO WE TOOK IT TO THE DEALER ASAP AND WAS HANDED A REPAIR COST OF 2620.00 TO REPAIR STEERING GEAR ASSEMBLY . THE VEHICLE HAD ONLY 47,700 MILES ON MY 2016 FORD EXPLORE XLT. IT IS NOW AT THE LOCAL FORD DEALER ON DECEMBER 9, 2020 AWAITING COMPLETION OF REPAIR AS VEHICLE IS NOT DRIVE-ABLE UNTIL REPAIRED. MY WIFE WAS ON THE HIGHWAY DRIVING WHEN SHE ENCOUNTERED ERRATIC BEHAVIOR FROM THE STEERING WHEEL GOING 50MPH. MY PARTS TOTAL FOR REPAIR IS 1,840.44 WITH LABOR TOTAL IS 2,620.00 WITH PARTS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED BEAU TOWNSEND FORD (1020 W. NATIONAL RD, VANDALIA, OH 45377, (937) 898-5841) TO SCHEDULE AN APPOINTMENT AND THE DEALER CONTACTED THE CONTACT BACK TO INFORMED HIM THAT THERE WERE NO PARTS AVAILABLE FOR THE RECALL REPAIR. THE CONTACT CONTACTED THE MANUFACTURER BUT THERE WAS NO RESPONSE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

I RECEIVED A RECALL NOTICE FROM FORD ON THURSDAY. EVERYTIME I CALL TO MAKE A SERVICE APPOINT, I TOLD RECALL COMPUTERS ARE DOWN.

48K MILES PLATINUM EDITION , STEERING WHEEL BEGAN STICKING. RECENTLY STARTED PULLING HARD TO THE RIGHT AT TIMES. HAD IT LOOKED AT AND IT LOOKS LIKE AS WITH MANY MANY OTHERS LIKE IT, THE THE RACK AND PINION NEEDS TO REPLACED. FORD SHOULD BE FORCED TO RECALL THE CARS AND FIX THE PROBLEM. THERE ARE LITERALLY HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. WHEN IS THE NHTSA GOING TO STEP UP AND DO SOMETHING? AFTER PEOPLE START DYING?

THERE IS AN SRS AIRBAG WARNING LIGHT ON THE DASHBOARD THAT USED TO INTERMITTENTLY DISPLAY. NOW IT IS ON CONSISTENTLY WHEN THE VEHICLE IS DRIVEN. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. DIRECTLY FROM SITE: HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER TSB 16-0001 AIR BAG WARNING LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B141B AND/OR B141C THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. FORD DEALERSHIP CLAIMS THAT THIS IS NOT WARRANTY FAILURE. BUT SOUNDS LIKE AN ELECTRICAL AND SAFETY ISSUE TO ME...WHICH SHOULD BE COVERED UNDER WARRANTY. THE TRUTH TO THE MATTER IS...FORD DOES NOT CARE THAT A POTENTIALLY HIGH RISK PROBLEM HAS BEEN IDENTIFIED AS A FAILURE ON THE COMPANY'S END BUT THEY DON'T CARE ENOUGH TO DO ANYTHING ABOUT IT. WELL..OTHER THAN CHARGE THE CUSTOMER CLOSE TO $1000 OUT OF POCKET TO FIX FOR A POOR DESIGN ON FORD'S END. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND THE LIVES OF ALL PASSENGERS IN JEOPARDY!

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE WATER PUMP LEAKED FLUID WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO STEVENS FORD OF MILFORD (717 BRIDGEPORT AVE, MILFORD, CT 06460) WHERE SHE WAS INFORMED THAT THE VEHICLE NEEDED A NEW WATER PUMP. THE CONTACT DECLINED THE REPAIR. THE CONTACT THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE SHE HAD THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

The contact owns a 2016 Ford Explorer. The contact stated that after a rainy day, while entering the vehicle, she noticed water on the front passenger’s side floor. The contact took the vehicle to the local dealer, where it was diagnosed with needing the windshield to be sealed. The vehicle was repaired but a year later she experienced the failure again. The manufacturer had been informed of the failure. The failure mileage was approximately 52,000.

UPON STARTING MY CAR FOR THE THIRD TIME THAT DAY MY AIR BAG LIGHT CAME ON AND DOES NOT GO OFF. I ALSO HAVE A PROBLEM WITH IT OCCASIONALLY NOT REGISTERING MY DRIVERS SEATBELT AS BUCKLED OR UNBUCKLED.

S AIR BAG LIGHT IS ON, CHECK AND ADVISE SRS AIRBAG LIGHT IS ON. MANUFACTURER AND DEALERSHIP ARE AWARE OF THE ISSUE AND HAVE A TSB FOR THE ISSUE BUT ARE NOT COVERING UNDER VEHICLE WARRANTY OR RECALL. INSTEAD THEY ARE CHARGING FOR TROUBLE SHOOTING TO LOOK UP THE CODE AND THEN OFFERING TO LOOK INTO REPLACING PARTS TO GET THE SYSTEM WORKING AGAIN UNDER THE ALREADY ISSUED TSB FOR THE FAULTY SAFETY SYSTEM. THIS IS THE DESCRIPTION PROVIDED: VERIFIED CONCERN. RAN EEC TEST, FOUND B141C STORED IN RCM, SECOND ROW INFLATOR CONTROL SEAT BELTS. RAN OASIS, TSB 16-0001 APPLIES HOWEVER NOT COVERED UNDER ACTIVE CONTRACTS CPO POWERTRAIN.

I TOOK MY VEHICLE IN FOR AN AIRBAG LIGHT AND WAS TOLD THAT THE WIRE ASSEMBLY LOCATED UNDER THE REAR SEAT WAS DAMAGED/FAULTY. THIS SEEMS TO BE A VERY COMMON ISSUE (SEE LINKS BELOW) THAT REQUIRED ME TO REPLACE THE WIRING AND WAS NOT COVERED UNDER WARRANTY BUT IS A SAFETY ITEM THAT IS WELL DOCUMENTED BY OTHERS IN ONLINE FORUMS. HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER?FBCLID=IWAR1IAMT7GHXQIAJF_Q3ETH7XLFE011S14V7P3JBMQQF1BY4XP1GP55U5F-E HTTPS://WWW.CARPROBLEMZOO.COM/FORD/EXPLORER/AIR-BAG-LIGHT-ON-PROBLEMS.PHP?FBCLID=IWAR32W-NNT2R2ESUV-5JM3H5ULS1FW4OQUHGPXWVRW5DLBBVOTZ4ED5OR69M

WHEN ACCELERATING AN ODOR LIKE BURNT HAIR OR ELECTRICAL ENTERS THE CABIN. FORD DID PERFORM RECALL WORK BUT THE ODOR STILL ENTERS THE CABIN.

MY WATER PUMP HAS GONE OUT AND APPARENTLY THIS HAS NOT BEEN THE ONLY ONE.

MY AIRBAGS LIGHT IS ON AND NONE WILL DEPLOY IN THE EVENT OF AN ACCIDENT AND IS NOT COVERED BY ANY WARRANTY. UNACCEPTABLE AND VERY DANGEROUS MANY OWNERS ARE REPORTING THIS ISSUE. HTTPS://WWW-ODI.NHTSA.DOT.GOV/VEHICLECOMPLAINT/

2016 Ford Explorer 3.5 Liter (non-turbo) front wheel drive, automatic, 44k miles. Loss of power, vehicle jerked and stayed in one gear. We limped the car home and let it cool down. After the car cooled down, we went on small test drive and confirmed it was shifting erratically. We took the car to the dealer and they confirmed a component in the transmission had failed, disabling the vehicle. Over $3,000 worth of transmission repairs were made under warranty.

ON SEVERAL OCCASIONS WHEN I GO TO START THE VEHICLE I GET A MESSAGE ON THE LEFT SIDE OF THE DASH CLUSTER THAT SAYS " STEERING ASSIST FAULT FAILURE, SEEK SERVICE." THE VEHICLE WON'T START. AFTER I KEEP PRESSING THE START BUTTON IF WILL START. I CARRIED IT TO THE DEALER ( PARADISE FORD IN COCOA, FL) AND THEY SAID THERE WERE NO CODES IN THE SYSTEM BUT DID SAY THERE WERE A LOT OF PROBLEMS WITH THE STEERING FAILURE ON THAT MODEL AND WOULD COST AROUND $2,500.00 TO REPAIR OUT OF MY POCKET. THE VEHICLE ONLY HAS A LITTLE OVER 5,000 MILES ON IT AS OF 11/29/20.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE 2, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC 1A H 0716. THE CONTACT BECAME AWARE OF TREAD SEPARATION ON ALL FOUR TIRES. THE CONTACT STATED THAT THE FAILURE WAS MORE SEVERE ON THE TWO FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE TIRES REPLACED. THE CONTACT ALSO STATED THAT THE TIRES FAILED TO MAINTAIN THE PROPER TIRE PRESSURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,132.

WHEN BACKING OUT OF MY DRIVEWAY AND TURNING SLOWLY THERE IS A POPING NOISE AND MY STEERING WHEEL LOCKED UP MULTIPLE TIMES. BEFORE THIS I SPENT 1000 BUCKS TO GET THE WIRING HARNESS FOR AIR BAGS REPLACED. NONE OF THEM WORK FORD WOULD NOT COVER IT BECAUSE THERE IS NOT A RECALL.

RANDOMLY ONE OF THE CAPTAIN CHAIRS SEAT BELTS NO LONGER BUCKLES. IT'S A AIRBAG SEATBELT WITH A DIFFERENT TYPE OF LATCH. WE HAVE NUMEROUS PROBLEMS WITH THESE TYPE OF BUCKLES SINCE WE BOUGH THE VEHICLE. THEY HAD TO REPLACE THE WHOLE HOUSING UNIT ON THE OTHER SIDE WITHIN THE FIRST 6 MONTHS BECAUSE IT JUST FELL APART.

Exhaust leaks into cab under moderate to heavy acceleration with windows closed it is even worse when accelerating with the windows open

POWER STEERING LOCKED UP , WELL ITS ELECTRIC STEERING .AND THE WARRING LIGHTS CAME ON TERRAIN ASSIST AND HILL ASSIST DISABLED, SERVICE ADVANCE TRAC ,STEERING LOSS , I WAS TRAVELING ON THE FREEWAY DOING ABOUT 70 MILES AN HOUR WHEN THIS HAPPED I ALMOST LOSS CONTROL OF THE VEHICLE . THERE ARE SO MANY COMPLAINTS ABOUT THIS PROBLEM WITH THE FORD EXPLORE STEERING ISSUSE .

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT REMAINED ILLUMINATED ON THE INSTRUMENTAL PANEL. THE CONTACT TOOK THE VEHICLE TO KOONS FORD OF ANNAPOLIS (2540 RIVA ROAD, ANNAPOLIS, MD 21401, (410-224-2100) TO HAVE A DIAGNOSTIC TEST PERFORMED. THE CONTACT WAS INFORMED THAT THE AIR BAGS ELECTRICAL CONNECTOR LOCATED UNDERNEATH THE DRIVER'S FRONT SEAT WAS CORRODED AND NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT OF MANUFACTURER COMMUNICATIONS NUMBER: 16-0001 AND PROVIDED AN ESTIMATE FOR THE COST OF THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

EL RACK AN PINON YA FUE REMPLAZADO. ENTIENDO QUE ES MUY PREMATURO PARA REMPLARLO. ES UN FALLA DE FABRICA. TRANSLATION: "THE RACK AND PINION WAS REPLACED. TO MY UNDERSTANDING IS TOO PREMATURE TO BE REPLACED. IT SEEMS LIKE IS A MANUGACTURING DEFECT"

WHILE DRIVING 52MPH, CRUISE CONTROL SET, CLEAR WEATHER, RURAL ROAD, TRAVELING STRAIGHT - NO INCLINE OR DOWNHILL...THE VEHICLE SUDDENLY DOWNSHIFTED TO 2ND OR 1ST GEAR - THUS DECELERATING RAPIDLY. AFTER A MOMENT, IT WENT BACK TO BEING ABLE TO ACCELERATE AND MAINTAIN NORMALLY. 2016 EXPLORER SPORT WITH 44K MILES...I'VE HAD IT FOR ABOUT A MONTH.

WITHIN 10 DAYS OF BUYING IT BRAND NEW I'VE HAD ELECTRICAL PROBLEMS. REPLACED BACK UP SCREEN WITHIN THOSE 10 DAYS EVEN THOUGH THEY DIDN'T FIND ANYTHING WRONG. STILL CONTINUES. MULTIPLE ISSUES WITH THE POWER TRAIN. NOW I'VE BEEN OUT OF A CAR FOR 2 WEEKS BECAUSE I MIGHT NEED A NEW TRANSMISSION AT 65,000 NO LONGER UNDER WARRANTY. HOW CAN I PAY $38,000 AND IT GOES BAD INSTANTLY? NO HELP FROM FORD OR DEALER. MY GEARS ARE STALLING AND NOT SHIFTING CORRECTLY OR PICKING UP SPEED. I DRIVE LIKE AN OLD LADY AND TAKE CARE OF THIS CAR LIKE IT'S BRAND NEW. I WILL NEVER BUY A FORD AGAIN AND WILL TELL ANYONE WHO WILL LISTEN NOT TO DO THE SAME.

WHILE I WAS DRIVING I STARTED TO GET A STRONG SMELL OF ROTTEN EGGS/SULFUR THAT FILLED THE CABIN. IT GOT SO STRONG THAT I HAD TO ROLL DOWN THE WINDOWS TO AIR IT OUT AND IT STARTED TO GIVE ME A HEADACHE. IT HAPPENED AGAIN WHILE DRIVING BACK TO MY HOME THAT SAME DAY. THE SMELL GOT SO STRONG IT STARTED TO MAKE ME DIZZY, NAUSEOUS AND GAVE ME A HEADACHE.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was repaired; however, the failure reoccurred 4 years later. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown. The VIN was not available.

AIRBAG WARNING LIGHT ILLUMINATED ON VEHICLE. CHECKED ALL WIRES UNDER THE SEAT AND NONE ARE LOOSE OR DAMAGED. SEARCHED TOPIC ONLINE AND APPEARS TO BE A KNOWN ISSUE. FORD ISSUED A SERVICE BULLETIN FOR THE REPAIRS BUT WILL NOT COVER UNDER WARRANTY OR ISSUE RECALL. THIS IS A SAFETY ISSUE AS THE AIRBAGS WILL NOT DEPLOY WHEN THIS LIGHT IS ILLUMINATED.

THE STEERING WHEEL LOCKED WHILE WE WERE DRIVING IN THE CAR. WE TURNED LEFT INTO THE GROCERY STORE AND THEN BACK RIGHT TO ENTER A PARKING SPOT AND THE STEERING LOCKED AND WE ALMOST RAN INTO A PARKED CAR. LUCKILY WE SLAMMED ON THE BRAKES IN TIME TO AVOID AN ACCIDENT. WE HAD TO CRANK THE STEERING WHEEL ALL THE WAY TO THE RIGHT TO ALLOW IT TO "RELEASE" AND GIVE US SOME STEERING BACK...BUT AFTER THAT THE STEERING NOW CLICKS WHILE YOU TURN LEFT OR RIGHT BADLY. WE TOOK IT INTO OUR DEALER...THEY SAID IT IS THE STEERING GEAR MOTOR. THE CAR WAS IN THE SAME DEALERSHIP 1 WEEK PRIOR TO THIS GETTING AN OIL CHANGE AND NO SIGNS OF MALFUNCTION OR WEAR/TEAR...WITHOUT WARNING THE STEERING LOCKED UP ON US...VERY FRIGHTENING...OUR CAR IS 4 YEARS OLD AND ONLY HAS 16,000 MILES ON IT. AND THEY CANNOT EXPLAIN EXACTLY WHY IT HAPPENED. SO I AM UNSURE OF IF/WHEN IT HAPPENS AGAIN.

The drivers side windshield trim panel came off of the car while driving down a highway at 55mph. Luckily, there were no other cars on the highway and no further damage or injury occurred.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED INSIDE HIS GARAGE WHEN HE STARTED TO SMELL A HEAVY EXHAUST ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DORSCH FORD LINCOLN KIA (2641 EATON RD, GREEN BAY, WI 54311, (920) 469-3000) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED COST ME $3,000 TO FIX BY CONSUMER'S MECHANIC. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.*DT*JB

TWO SEPARATE FAILURE WITHIN A FOUR DAY TIME SPAN. COMPANY SOLD ME THE VEHIXAL SAID IT WAS A TIE ROD AND FIXED THE RIGHT PASSENGER REAR WHEEL. THE VEHICAL WAS REAL EASED TO ME TODAY WITH THE UNDERSTANDING THAT THE REAR SUSPENSION WAS FULLY REPAIRED. I HAD A HIGH SPEED ACCIDENT AFTER THE LEFT REAR TIR ROD BROKE AT A SPEED OF 80 MPH. DUE TO THE SUSPENSION BREAKAGE, THE CAR WENT OFF THE INTERSTATE AT HIGH SPEED. THE REAR END SUSPENSION HAD COMPLETE FAILURE AND THE AUTO DEALERSHIP RELEASED THE VEHICLE TO ME WITH THE FULL WITH ASSURANCE THE ISSUE WAS FIXED. THIS WAS A VERY SERIOUS INCIDENT WITH A POTENTIAL DEADLY OUTCOME.

POWER STEERING FAILED COMPLETELY ON MY 2016 FORD EXPLORER WHILE DRIVING. DASHBOARD LIT UP WITH A STEERING ASSIST FAULT, AND THEN HILL ASSIST FAULT. STEERING THE VEHICLE TO SAFETY WAS VERY CHALLEGING. I WAS TURNING AT A LEFT TURN LIGHT AND ALMOST CRASHED INTO ANOTHER VEHICLE BECAUSE I COULD NOT STEER THE CAR. LOOKED IT UP ONLINE AND HAVE FOUND NUMEROUS OTHER ACCOUNTS OF THE SAME ISSUE WITH NO REPSONSE OR RECALL FROM FORD.

I HAD THE REAR TOE LINKS REPLACED DUE TO A SAFETY RECALL DECEMBER 2, 2019. ON 09/27/20, I WAS RETURNING HOME AFTER DROPPING MY KIDS OFF TRAVELING 70 MPH ON A HIGHWAY, WHEN THE RECAL PART I HAD REPLACED LESS THAN A YEAR AGO BREAK. THIS CAUSED ME TO LOSE CONTROL AND HAVE AN ACCIDENT. I NOTIFIED FORD OF THIS 09/28/20 AND I WAS INFORMED THAT THE RECAL WAS COMPLETED, NOTHING THEY COULD DO. I INFORMED THEM THE PART BROKE AT THE WELD WHICH IS A DEFECTIVE PART. AGAIN, I WAS TOLD OT THEIR PROBLEM. THIS HAS CAUSED MY VEHICLE TO TO BE TOWED , DAMAGE TO THE REAR BUMPER AND MYSELF BUYING A NEW PART OUT OF POCKET TO GET VEHICLE ON ROAD AGAIN TO GO TO WORK. THIS IS ALSO ANY OTHER PROBLEMS THAT IT MAY HAVE CAUSED DUE TO STRESS ON VEHICLE, LIKE OTHER TOE LINK, TIRES, BRAKES, OTHER SUSPENSION PARTS. ENCLOSED IS PART AND PART NUMBER THAT WAS THE RECAL PART REPLACED BY A FORD DEALERSHIP AND DAMAGE TO VEHICLE. I WAS LUCKY I DID NOT HIT THE OTHER VEHICLES AROUND ME, HIT HEAD ON WITH CENTER DIVIDER OR GUARDRAIL, ROLL THE VEHICLE OR HAVE SERIOUS INJURY.

MY TIRE VALVE CORRODED AFTER 3 YEARS WITH THE CAR. WHICH CAUSED DAMAGE TO THE TIRE AND THE TIRE PRESSURE SENSOR. THE POWER STEERING WENT AT 67000 MILES. IT STOPPED WORKING COMPLETELY WHILE DRIVING, EXTREMELY SCARY. THE SERVICE DEPARTMENT AT THE DEALERSHIP SAID IT IS JUST SOMETHING THAT HAPPENS. $2400 FIX ON A 4 YEAR OLD CAR WITH 67000 MILES AND COULD HAVE CAUSED AN ACCIDENT.

WHILE MOVING THE STEERING WHEEL THERE IS A WEIRD CLUNK/POP NOISE AND FEELS A BIT LOOSE. SO THIS IS CONCERNING 66,000 MILES ON MY VEHICLE. ALSO THE FRONT SUSPENSION IS VERY ROUGH AND I HAVE TAKEN VERY GOOD CARE. DEALERSHIP WAS NOT SURE WHAT IT WAS BUT STATED IT WAS SAFE

STEERING WHEEL IS STIFF AND MAKES NOISE WHEN TURNING.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SURGED BETWEEN GEARS AND DECELERATED BEFORE OPERATING AS DESIGNED. THE CONTACT ALSO STATED THAT AFTER THE VEHICLE REVERSED OUT OF THE DRIVEWAY AND SHIFTED INTO DRIVE, AN ABNORMAL CLUNKING NOISE WAS HEARD UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE FAILURES WERE NOTICED DURING A TEST DRIVE PRIOR TO PURCHASING THE VEHICLE HOWEVER, THE TECHNICIAN AT THE GRIECO FORD OF RAYNHAM LOCATED AT 1651 NEW STATE HWY, RAYNHAM, MA, 02767, INFORMED THE CONTACT THAT THERE WAS NO PROBLEM WITH THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED AFTER THE VEHICLE WAS PURCHASED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

WE ARE DRIVING BACK FROM ZION NATIONAL PARK THEN IN THE FREEWAY SUDDENLY I LOST POWER LUCKILY IT WAS ON A DOWN HILL. I WENT ON THE SIDE OF THE ROAD THEN THEN COUPLE I STARTED RIGHT BACK. NOW AM AFRAID DRIVING IT FAR AWAY. FROM TIME TO TIME WHEN UPHILL IT JERK A BIT AND IT FEELS LIKE LOOSING POWER.

TL* THE CONTACT OWNED A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE VEHICLE TAKEN LOCAL DEALER KEVIN'S ROYAL FORD OF COOPERSTOWN (5069 NY-28, COOPERSTOWN, NY 13326:(607) 547-9924) AND HAD THE RECALL COMPLETED. THE CONTACT STATED WHILE DRIVING 45 MPH, WHEN THE VEHICLE'S TOE LINK DETACHED AND CRASHED INTO A GUARD RAIL AND DROVE INTO A DITCH. ALL 5 AIR BAGS DEPLOYED. THE CONTACT DID NOT SUSTAINED ANY INJURIES OR SEEK ANY MEDICATION ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE INSURANCE COMPANY DEEMED THE VEHICLE A LOSS. THE VEHICLE WAS TOWED TO A JUNKYARD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000(SUSPENSION) ON NOVEMBER OF 2020 AFTER THE ACCIDENT. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 42,300. *JS

INITIAL ISSUES WAS AN ISSUES ACCELERATING. WHEN ACCELERATING TO 3000 RPM, THE RPMS WOULD SUDDENLY DROP BACK TO 2 AND THE CAR WOULD LURCH. STARTED EXPERIENCING ISSUES WHEN SLOWLY DECELERATING LIKE GEARS WOULD NOT ENGAGE CORRECTLY. WHEN STARTING THE CAR AND SHIFTING INTO DRIVE, THE CAR LURCHED FORWARD WITH A GRIND AND THE WRENCH DASH LIGHT CAME ON.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE STEERING WHEEL FAILED. THE DRIVER KEPT THE STEERING WHEEL UNDER CONTROL AND MOVE INTO THE SLOW LANE WHILE CONTINUING TO DRIVE. THE CONTACT STATED THAT THE STEERING SYSTEM FAILURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO LEWIS J C FORD (9505 ABERCORN STREET SAVANNAH, GEORGIA, 31406, (912)-210-5677) TO BE DIAGNOSED. THE MECHANIC LOCATED THE FAILURE AT THE STEERING WHEEL RACK AND PINION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.*DT*JB

PER FORD WEBSITE, I WAS TOLD THAT MY SYNC SOFTWARE NEED AN UPGRADE WHEN I TYPED IN THE VIN, THEN I FOLLOW THE INSTRUCTION ON WEBSITE BUT THE PROGRAM I DOWNLOADED MESSED UP MY APIM MODULE ON MY CAR AND RADIO, GPS, AND OTHER FUNCTION AE NOT WORKING. SO I TOOK MY SUV TO THE DEALER AND THEY SAID IT WILL COST ME $1050 TO FIX THE ISSUE.

STARTED DRIVING AND RECEIVED A WARNING ON THE SCREEN SAYING "STEERING FAULT SERVICE NOW". LOTS POWER STEERING CONTROL. THANKFULLY WAS AT A LOW SPEED AND COULD STOP SAFELY BEFORE LEAVING OUR NEIGHBORHOOD. PUT VEHICLE IN PARK, POWERED OFF, POWERED BACK ON, AND WAS ABLE TO DRIVE AGAIN. VEHICLE HAS 56K MILES ON IT.

I HAVE A 2016 FORD EXPLORER WITH 94,000 MILES. WE NOTICED THAT THE AC WAS BLOWING HOT AIR SO WE TOOK THE CAR IN FOR A REPAIR ON 9/8/2020. THE DEALERSHIP CALLED US BACK TO INFORM US THAT THE WATER PUMP HAD FAILED WHICH CAUSED ANTIFREEZE TO LEAK INTO AND ON THE AC COMPRESSOR CAUSING IT TO FAIL. WE WERE QUOTED A PRICE OF $2600.00 FOR THE REPAIR THE WATER PUMP. I WAS ALSO TOLD THAT MANY POLICE CRUISERS WITH THE SAME MOTOR ARE HAVING THE SAME ISSUE. FORD RECOMMENDS THAT THE WATER PUMP BE REPLACED AT 150000 MILES' THE MILES ON THE SUV ARE HIGHWAY MILES.

The contact owns a 2016 Ford Explorer. The contact stated that the trim located around the front driver side windshield loosened and detached from the vehicle while driving at highway speeds. The contact took the vehicle to the dealer where they replaced the trim on the front driver side windshield and tightened the trim on the front passenger side windshield. Despite the repair, the contact stated that the trim loosened again on both sides of the windshield. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 60,000.

MY WIFE WAS DRIVING DOWN THE ROAD WHEN THE STEERING QUIT. IT WAS PULLING FROM SIDE TO SIDE AND SHE ALMOST LOST CONTROL. STEERING FAILURE ALARMS WERE CONTINUING TO GO OFF. SHE WAS ABLE TO GET THE VEHICLE OFF THE ROADWAY AND AVOID A CRASH.

WHILE MAKING TURNS EITHER AT SLOW SPEEDS OR AT A COMPLETE STOP, THE STEERING MAKES POPPING SOUNDS. STEERING WHEEL ALSO LOCKS FOR HALF A SECOND. TOOK VEHICLE TO A SHOP AND WAS ADVISED IT WAS THE RACK AND PINION ON THE FRONT RIGHT TIRE AREA. THE VEHICLE IS A 2016 AND HAS 41K MILES. THIS ISSUE BEGAN MANIFESTING APPROXIMATELY TWO WEEKS PRIOR. ESTIMATED COST TO REPAIR IS $2500. ACCORDING TO VEHICLE FORUMS THIS IS A COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED TO THE FORD DEALER IN MY TOWN WHICH IS WAS 2 HOURS AWAY. FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY. COST OF REPAIR IS 2400.00 OF COURSE I HAVE A LIFETIME WARRANTY ON MOST PARTS INCLUDING FUEL PUMP, ENGINE ,TRANSMISSION BUT RACK AND PINION NOT CONSIDERED UNDER THIS WARRANTY. *TR

LOSS OF STEERING WHILE DRIVING. NEARLY CAUSED A 4 CAR COLLISION. STEERING WHEEL LOCKED WHILE DRIVING 57 MPH. WAS BARELY ABLE TO SLOW DOWN AND PULL OFF TO THE SIDE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER AFTER THIS LAST TIME, THE STEERING WHEEL IS PERMANENTLY LOCKED. STEERING LOSS LIGHT CAME ON AFTERWARDS.