2005 Ford F-150 Powertrain & Transmission Problems

customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of this of which they bought a frame repair kit (Pre-cut over frame c-channel steel) to weld onto the frame to support a longer lifespan. The truck is now safe for the roadway.

The contact owns a 2005 Ford F-150. The contact stated that while parking the vehicle, the vehicle rolled backwards. The contact shifted the gear shifter into park and turned off the vehicle; however, the vehicle rolled backwards again. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact stated that upon inspecting under the hood, the contact became aware that the shifter cable had melted. The contact purchased a new shifter cable and replaced the shifter cable. The vehicle was started and driven to the residence. In addition, the contact stated that the failure had occurred at night, which was dangerous for being on the side of the road. The contact stated that the shifter cable had melted again within 12 hours. The contact stated that the failure was the result of a design flaw. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 260,000.

I don't even have 150,000 miles on this thing. I get it serviced regularly. I've used the 4x4 when needed, as I live in the Sierra Nv Mountains area. I don't overdo it, I don't abuse it. One day with "ZERO" Clues or indications my truck popped out of drive into neutral ON ITS OWN I put it back into drive. Then as I tried to accelerate NOTHING, I got a code/msg saying faulty transmission, my O/D kept turning off and on. I pushed it to the side if the road. I eventually got reverse back, 1st gear, but that's it. And NOBODY KNOWS WHAT IS WRONG WITH IT. Its Automatically you need a transmission. [XXX]!! You go online and this is happening to TONS of people. Are you saying WE ALL NEED NEW TRANSMISSIONS?? Kinda odd same trucks, same issues on the same part. What's the common denominator here ford??? Your [XXX] transmissions. Figure it out!!! My truck is paid off and I can't even drive the [XXX]. I'm walking because of a [XXX] transmission, on top of paying over 20,000 you want me to dish out another 3grand for your [XXX]?? Nah... Figure it the [XXX] out. Take care of your customers as you should!!! Integrity is doing the right thing when no one is looking. Come on Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Issues with transmission/ over drive snap ring vehicle only has 145,000 miles. This truck has many complaints and many failures and flaws that need fixed.

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

ME ENTER HOY QUE MI TRUCK TENA VARIOS RECALL Y NO HE RECIBIDO AVISO, GRACIAS POR SU ATENCION.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED, WHICH CAUSED THE TRANSMISSION LINE TO BECOME DEFECTIVE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION LINE WAS REPLACED. THE CONTACT WAS INFORMED BY THE MECHANIC THAT, DUE TO THE CORROSION, OTHER PARTS OF THE VEHICLE COULD BECOME DEFECTIVE. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

TRANSMISSION CLUNKS. TRUCK STALLS IN TRAFFIC BECAUSE OF THROTTLE BODY PROBLEMS. IT HAS BEEN AN ON GOING PROBLEM OVER THE PAST SEVERAL YEARS.

MY 2005 F150 HAS AN ELECTRONIC SWITCH TO ENGAGE THE 4 WHEEL DRIVE. IT HAS STOPPED WORKING ALL TOGETHER. I'VE RESEARCHED THE PROBLEM AND HAVE DISCOVERED THAT THIS IS A COMMON PROBLEM FOR THIS MODEL FROM 2004 ON UP. I NEARLY CRASHED WHILE DRIVING AFTER A SNOW STORM DUE TO THE 4 WHEEL DRIVE BEING INACTIVE.

WILL NOT GO IN REVERSE

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE AT A STOP, THE VEHICLE SHOOK AND DID NOT ACCELERATE. IN ADDITION, THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BILL KNIGHT FORD OF STILLWATER (4405 W 6TH AVE, STILLWATER, OK 74074, 405-372-7144) AND THE COMPUTER SYSTEM WAS UPDATED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

MY 2005 FORD F150 TRUCK HAS HAD SO MANY PROBLEMS & SOME REPLACE TWICE & IM OVER IT IM ABOUT TO HAVE A HEART ATTACK NOW IT SOUNDS LIKE MY ACULATOR AGAIN WITH THE SOUND OF METAL SCRAPING ON THE GROUND AND WHEN I SWITCH IT TO 44 THE SOUNDS STOPS .BUT IF ITS NOT IN 44 THE SOUND STAYS AND IT IS LOUD ! I HAVE SPENT SO MUCH GET MY TRUCK FIXED AND WHAT UPSETS ME IS I TAKE CARE OF MY TRUCK CHANGE OIL SPARK PLUGS EVERYTHING SINCE PURCHASED IN 2005 BRAND NEW AND IM OVER IT SOMETHING NEEDS TO DONE WITH ALL THESE PARTS DEFECTED AND IT WILL CONTINUE UNTIL SOMETHING IS DONE.

TRANS FAULT ERROR

NEW TRANS NEEDED, COMMON ON MOST F150. OVERDRIVE LIGHT FLASHES AND WON'T SHIFT OUT OF FIRST GEAR

I NEEDED A NEW TRANSMISSION LAST YEAR. JUST BLEW OUT OF NO WHERE. THIS YEAR ALONE I NEEDED NEW HUBS, ALL8 CYLINDERS HAVE A MISS FIRE MY TRUCK DROPPED FROM 60 TO TEN IN SECONDS SO SCARY

TRUCK WAS BOUGHT AND I REPLACED ALL SPARK PLUGS AND EVEN HAD TO REPLACE A CLINOID BECAUSE WAS TOLD THAT WAS THE PROBLEM. ITS NOT... THERE IS A BALL VALVE IN THE TRANSMISSION THAT KEEPS THE TRUCK FROM BUILDING ENOUGH PRESSURE TO BE ABLE TO SHIFT WHICH THROWS A CODE AND SAYS MISFIRE ON 6 BEEN REPLACED TWICE NOW SO CLEARLY NOT THE PROBLEM. THIS IS A MAJOR ISSUE.. TRUCK FEELS AS IF FIXING TO FIE THEN CHECK ENGINE LIGHT WILL COME ON START FLASHING BUT THROW NO CODES AND YOU CANT SPEED BACK UP BECAUSE IT FEELS LIKE YOUR TRUCK IS ABOUT TO DIE AND YOU DON'T WANT TO BLOW YOUR MOTOR.

MY TRUCK HAS A KNOWN ISSUE WITH THE 5.4L'S CAM PHASERS. THE TRUCK MAKES A VERY LOUD NOISE AND SHAKES. TO REPAIR THIS, IT'S AROUND $3,000 AND ALSO I HAVE A KNOWN ISSUE WITH ALL 8 COILS WHICH HAD TO BE REPLACED FOR $1,200 AND A KNOWN MISFIRE. I DO NOT UNDERSTAND WHY FORD MOTOR IS AWARE OF THE ONGOING ISSUES IN THIS YEAR TRUCK AND HAS NOT DONE ANYTHING ABOUT IT. ALSO IF THE CAM PHASERS ARE NOT REPLACED THE ENGINE WILL BLOW!

TAKATA RECALL AT 80,000 MILES F150 TRANSMISSION WENT OUT. HAD IT REPAIRED NOW IN LESS THAN 12,000 MILES GONE AGAIN.

METAL SCRAPING SOUND FROM REAR END. MECHANIC HAS CHECKED AND SAYS PINION, BEARINGS, RING GEAR HAVE FAILED. LOOKS LIKE ITS A COMMON FAILURE. 9.75 RING GEAR, 3.55 RATIO

REAR END SHAKING WHILE DRIVING DOWN ROAD ABOUT 60MPH. GETTING OFF GAS NOR PUTTING VEHICLE IN NEUTRAL WOULD NOT STOP SHAKING. HAD TO COME TO COMPLETE STOP BEFORE STARTING AGAIN TO MAKE VEHICLE DRIVE PROPERLY.