Ford · F-150 · 2005
14
Recalls
1,120
Complaints
-
Not Rated
The 2005 Ford F-150 has 14 recalls and 1,120 owner-reported complaints on file with NHTSA. Most reported issue: visibility (240 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
Remedy Status
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
Remedy Status
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Remedy Status
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
Remedy Status
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Remedy Status
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
Remedy Status
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Remedy Status
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Remedy Status
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and discovered that the engine compartment was on fire. The Home Depot employees came out to the vehicle and extinguished the fire with a fire extinguisher. The Fire Department and Police Department were contacted; however, the contact was unsure if a report was filed for either department. The orgin of the fire was not confirmed however, the fire department informed that timing was critical because any longer the fire would have caused an explosion. No warning lights were illuminated. The vehicle was towed back to the residence, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 360,000.
customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of this of which they bought a frame repair kit (Pre-cut over frame c-channel steel) to weld onto the frame to support a longer lifespan. The truck is now safe for the roadway.
While changing the spark plugs 7 of the eight broke off in the engine block, the threaded section came out but the ceramic bottom portion is what broke. I find that this is somewhat common because Auto Zone rents a spark plug extractor specifically for this. My safety isn’t at risk. Problem not reported to a dealership yet. No inspection yet. The check engine light was on
The contact owns a 2005 Ford F-150. The contact stated that while parking the vehicle, the vehicle rolled backwards. The contact shifted the gear shifter into park and turned off the vehicle; however, the vehicle rolled backwards again. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact stated that upon inspecting under the hood, the contact became aware that the shifter cable had melted. The contact purchased a new shifter cable and replaced the shifter cable. The vehicle was started and driven to the residence. In addition, the contact stated that the failure had occurred at night, which was dangerous for being on the side of the road. The contact stated that the shifter cable had melted again within 12 hours. The contact stated that the failure was the result of a design flaw. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 260,000.
Odometer Fraud. The contact purchased a 2005 Ford F-150. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,180 and at the time of registration, it was discovered that the mileage was 216,350.
This is an extended cab - 4 door - the rear doors are half doors with a a handle allowing entry and exit to and from the rear passenger seats. (It is not a crew cab 4 door). The doors LOCKED and the handles failed with a child in the rear seat. THe doors cannot be opened. The child and his mother had to climb over the center console to exit the vehicle. THe vehicle is at a mechanic who states no part are available to repair this faulty and unsafe door mechanism. Both rear doors are LOCKED. QUalified mechanic estimates the cost to rig a fix, in absence of any left door mechanism parts will be near or over $500.00. THe mechanic reports that the control cables from the handles to the door latch stretched and failed. If there had been a collision or engine fire, rear seated passengers would be trapped inside the vehicle. THIS NEEDS TO BE ADDRESSED and REPAIRED BY FORD.
I don't even have 150,000 miles on this thing. I get it serviced regularly. I've used the 4x4 when needed, as I live in the Sierra Nv Mountains area. I don't overdo it, I don't abuse it. One day with "ZERO" Clues or indications my truck popped out of drive into neutral ON ITS OWN I put it back into drive. Then as I tried to accelerate NOTHING, I got a code/msg saying faulty transmission, my O/D kept turning off and on. I pushed it to the side if the road. I eventually got reverse back, 1st gear, but that's it. And NOBODY KNOWS WHAT IS WRONG WITH IT. Its Automatically you need a transmission. [XXX]!! You go online and this is happening to TONS of people. Are you saying WE ALL NEED NEW TRANSMISSIONS?? Kinda odd same trucks, same issues on the same part. What's the common denominator here ford??? Your [XXX] transmissions. Figure it out!!! My truck is paid off and I can't even drive the [XXX]. I'm walking because of a [XXX] transmission, on top of paying over 20,000 you want me to dish out another 3grand for your [XXX]?? Nah... Figure it the [XXX] out. Take care of your customers as you should!!! Integrity is doing the right thing when no one is looking. Come on Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My airbag light is on and the dealership says I have no active recalls but when I ask about recall number 11V-107 no one can confirm the when and where for this recall. I would like it repaired at no cost and the criteria of this recall number.
The contact owns a 2005 Ford F-150. The contact stated while starting the vehicle, there was an abnormally loud knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 190,000.
Issues with transmission/ over drive snap ring vehicle only has 145,000 miles. This truck has many complaints and many failures and flaws that need fixed.
The DMV has a extended warranty coverage on the fuel injectors .. coming up a recall at DMV. What do I do.
Nothing has happened yet but frame of truck is rusting apart and suspension is going to fall off. This is not just this truck it’s lots of 04-06 f150
Frame on passenger and drive side by transmission, fuel tank, and rear leaf springs are rusted and have no integrity left. No structure integrity if in an accident. If fractures completely, will loose control of vehicle as the bed will contact cab, driveshaft will jamb into transmission, lock up brakes from pinched brake lines, loss of brakes from severed brake lines, lose control and go into on coming traffic or into roadside structures including pedestrians. NOTE: Your system will not let me upload pictures.
No incident FAR SOME REASON MY AIR BAG LIGT STAY ON
My electrical fixtures have failed or blinks off and on, on its own.
The contact owns a 2005 Ford F-150. The contact stated that when he had the vehicle serviced that the independent mechanic informed him that the front and rear frame of the vehicle was rusted and he should not be driving the vehicle. The manufacturer was made aware of the failure but provided no assistance but did inform the contact to contact NHTSA. The failure mileage was approximately 170,000.
The contact owns a 2005 Ford F-150. The contact stated while driving at an undisclosed speed, he smelled an abnormal fuel odor. Additionally, the contact stated that while the accelerator pedal was depressed, the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
The contact owns a 2005 Ford F-150. The contact stated that the bed of the truck was lower than usual. The contact looked underneath the vehicle and became aware of rust underneath the vehicle. The vehicle was taken to an independent mechanic and the mechanic stated that the vehicle was rusted and that the sub frame was cracking and referred the contact to the dealer for assistance. The dealer was contacted, and the dealer stated that the vehicle needed to be inspected. The manufacturer was contacted, and the manufacturer stated that the vehicle was not under recall and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 75,000.
The contact owns a 2005 Ford F-150. The contact stated that the vehicle was taken to an independent mechanic, who informed the contact that the subframe was severely rusted. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 114,000.
Pulled out of driveway and made it 50 feet and whole truck shut down right on the road. Could not make the vehical restart no click or anything dead right where it stopped. Could of caused an accident. Had to have truck taken to a shop they took a week to find out that the electrical fuel system harness had a dead short in it. So no fuel going to the feul injectors or to the key to start the vehical. Still have head lights and breaks and radio. Just no way to restart the vehical. They checked thw wires and after unplugging many wires to the fuel system and retesting it started. Left with the truck a day later the same thing happen but this time i had to jump a curb to avoid an accident and coasted into a parking lot. I got out and wiggled a few of the wires and the truck started back up. I made it back to where i was staying only 2 blocks up the road and it died in the parking lot in a stall. That has been over 3 weeks and cant find the parts to fix it even by talking to ford shops. There not able to get this harness due to they have been discontinued...truck has low miles on it and now i dont know what to DO. This is my daily driver for WORK. This shouldnt of happened with the wires being wrapped even the mechanic who has his own shop but also works for Ford as a mechanic he has seen this before and now having problems getting parts. I hope you can help with this matter. Due to its very disturbing to myself when its in good shape and was taken care of and NOW cant get parts..
Showing 1–20 of 25 complaints
The 2005 Ford F-150 has 14 recalls recorded by NHTSA.
NHTSA has received 1,120 owner-reported complaints for the 2005 Ford F-150.
NHTSA has not published a safety rating for the 2005 Ford F-150.
The most commonly reported complaint categories for the 2005 Ford F-150 are visibility (240 reports), air bags (88 reports), engine and engine cooling (79 reports).
Yes. NHTSA has 14 recalls on record for the 2005 Ford F-150. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.