2006 Ford F-150 Powertrain & Transmission Problems

while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?

Rotted and bent frame realized after purchase on February 22 at nj car and driver (Cadillacs Plus) for $3500.00 Continues to stall and feels like it’s going to crack in two. Stalled a few times while driving and had to put it in neutral to start back up

The shift cable for the automatic transmission was routed next to the exhaust manifold on the engine. The shift cable gets hot and burns into from the heat off the exhaust manifold. I purchased the 2006 Ford F150 used. I had mechanic replace one shift cable with a new shift cable. The new shift cable burned into has I was backing in my driveway. I did research on the internet for trucks in that year range and it included other trucks 2007 and 2008 F150 having the same issue. You can find a ton of utube videos . ShowIng mechanics finding solutions to prevent the shift cables from burning into. I contacted Ford motor company about it. Ford wanted me to take the truck to a dealership and let them diagnosed the problem. The dealership wanted me to pay them a 150 dollars to look at it. I was not going to pay them for something that I already knew the answer too. So it is a manufacturing flaw with the way Ford put the shift cable on 2006 F150 and other F150's in that year range. I hope you research the issue and get back to me soon. Sincerely Yours [XXX] Ph [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

MY 2006 FORD F 150 HAS 125,000 MILES. I WENT TO PUT MY TRUCK IN REVERSE TO BACK UP OUT OF MY DRIVEWAY AND IT MADE A NOISE. APPARENTLY REVERS BAND IN THE TRANSMISSION WENT. I NO LONGER CAN PUT MY VEHICLE IN REVERSE TO BACK UP. VERY FRUSTRATED BECAUSE THE VEHICLE IS VERY WELL MAINTAINED AND IT BROKE FOR NO REASON.

I WAS PULLING IN MY DRIVEWAY I BACK OUT TO BACK IN BACK IN TO UNLOAD MY FOURWHEELER AN THE TRUCK WOULDN'T MOVE, I TAPPED THE FUEL A COUPLE TIMES AN SOUND LIKE THE TRANSMISSION WENT OUT, I JUST BOUGHT THE TRUCK IN FEBRUARY

THE MECHANIC SAID I NEED TO REPLACE MY TRANSMISSION, IT IS AN AUTOMATIC 4.6L MOTOR AND DOES NOT GET 4RD OR 4TH GEAR. MY VEHICLE WAS IN MOTION AND WHEN IT REACHED 40MPH IT WOULD NOT GO I HAD TO SWITCH TO 2ND GEAR.

TRANSMISSION HAS A DELAY SHIFTING OR KIND OF GET STOCK THE TRANSMISSION WAS REPLACED AT 80000 MILES AND DOING IT AGAIN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION CHANGED FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 3/4/15*CN THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS A FAULTY SOLENOID. UPDATED 10/15/2015 *JS

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

MY TRUCK WAS NOT INVOLVED IN AN ACCIDENT. I HAVE 74,000 MILES ON MY TRUCK AND THE TRANSMISSION IS STARTING TO SLIP. WITH THIS LOW MILEAGE THIS SHOULD NOT BE HAPPENING. *TR

WENT TO BACK UP AND NO REVERSE. *TR

TRANSMISSION SHIFT CABLE OUTER SHEATH WAS MELTED ON EXHAUST SYSTEM. CABLE HAD UNKNOWINGLY COME LOOSE OF A RETAINING CLIP AND WAS THEN ALLOWED TO CONTACT HOT EXHAUST MANIFOLD. MELTED THE OUTER PLASTIC OF SHIFT CABLE CAUSING THE SHIFT SELECTOR TO BECOME INOPERABLE. SHIFT SELECTOR COULD BE PLACED IN PARK BUT TRANSMISSION WOULD NOT BE IN PARK; IF I HAD NOT REALIZED THERE WAS A PROBLEM I COULD HAVE BELIEVED THE TRANSMISSION WAS IN PARK WHEN IT WAS NOT AND THE TRUCK COULD HAVE ROLLED FREELY. TRUCK IS A WELL MAINTAINED 2006 FORD F150 CREW CAB 4X4 WITH THE COLUMN SHIFTER. *TT

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE DRIFTED BACKWARD AND CRASHED INTO ANOTHER VEHICLE. THE CRASH CAUSED NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 96,500.

TRANSMISSION JUMPS IN HIGH GEAR WHEN OVERDRIVE IS ACTIVE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE HAVING THE TIRES CHANGED THE MECHANIC NOTICED THAT THE REAR COVER ON THE DIFFERENTIAL WAS COVERED WITH RUST AND CAUSED A LEAK. THE VEHICLE WAS REPAIRED FOR THE REAR COVER AND OIL WAS ADDED FOR LUBRICATION. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 102,000. UPDATED 07/08/11 *BF UPDATED 09/16/11

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR

GLAZE ON REAR END CLUTCH CAUSING TRUCK TO DRIVE INCORRECTLY...CONTACTED COMPANY AND THEY HAD A POSSIBLE RESOLUTION THAT DIDN'T WORK....WORRIED THAT THE REAR END WILL LOCK UP WHEN DRIVING CAUSING A WRECK!! *TR