2007 Ford F-150 Powertrain & Transmission Problems

The contact owns a 2007 Ford F-150 The contact stated while driving at an undisclosed speed, the vehicle stalled and jerked. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred, with the check engine warning light illuminated. The vehicle was taken back to the mechanic where it was diagnosed and determined that the spark plugs, and torque converter had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 126,963.

The contact owned a 2007 Ford F-150. The contact stated that when depressing the accelerator pedal while in reverse, the vehicle suddenly accelerated, crossing a field, and crashing into a nearby building, where the vehicle came to a stop. The contact sustained neck injuries, and the front passenger sustained neck injuries as well. The contact did not seek medical attention; however, they intended to do so in the future. The air bags did not deploy. A police report was filed. The rear end of the vehicle was damaged. The vehicle was driven home. The vehicle was taken to Collision Center who diagnosed that the rear of the vehicle needed extensive bodywork and determined the vehicle was totaled. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000. The VIN was not available.

The contact owns a 2007 Ford F-150. The contact stated while making a right turn from a complete stop at 7-10 MPH, the vehicle shuddered significantly. The contact pulled over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the driveline assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 120,000.

The contact's daughter owns a 2013 Ford Focus. The contact stated that the vehicle had failed to shift properly and shuddered. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the clutch assembly needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to another local dealer, #1 Cochran Ford Boardman (7955 Market St., Youngstown, OH 44512); where it was diagnosed and determined that the clutch assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 17,000.

Shifting the automatic transmission from gear to gear with the shifting lever has become extremely difficult. can this be rectified with lubrication at some point? Thankyou

The contact owns a 2007 Ford F-150. The contact stated that while driving at an undisclosed speed, the gear shifter was difficult to shift. The contact stated that the gear shifter was stuck in park(P). There were no warning lights illuminated. The local dealer was not contacted. The vehicle was diagnosed or repaired. The contact stated that the transmission shifter cable was repaired several times by an independent mechanic. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 171,639. The VIN was not available.

TRANSMISSION SLIPPING IN REVERSE.IT THROWS UP THE CODE PO720, WHICH IS THE OUTPUT SHAFT SPEED SENSOR. THE VEHICLE IS INCAPABLE OF TOWING ANYTHING. THIS IS AN ISSUE FOR THIS SPECIFIC TRANSMISSION DATED ALL THE WAY BACK TO 2002.WE BOUGHT THE VEHICLE LESS THAN A YEAR AGO.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN THE GEAR WAS SHIFTED INTO REVERSE, THE VEHICLE WOULD NOT MOVE BACKWARDS. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ROBICHAUX FORD (985-446-3100, LOCATED AT 272 W MAIN ST, THIBODAUX, LA 70301) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS REFERRED TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED.

TRANSMISSION COOLING LINE GOING THROUGH RADIATOR FAILED CAUSING COOLANT TO MIX WITH TRANSMISSION FLUID. RESULTING IN TRANSMISSION FAILURE. TRANSMISSION HAD TO BE ENTIRELY REBUILT AND RADIATOR ALSO HAD TO BE REPLACED. THIS OCCURRED AT HIGHWAY SPEED.

FIRST THE TRANS WENT OUT IN THE MIDDLE OF NO WHERE AT 1130 AT NIGHT WITH MY NEWBORN. THEN THE ENGINE WENT AS I WAS DRIVING TO WORK. WE FOUND OUT IT WAS THE CAM PHASERS WHICH WE HAD TO REPLACE THE ENGINE FOR. WE HAVE DONE $8000 IN REPAIRS AND IT'S NOT RECALLED??

VEHICLE DIFFERENTIAL FAILED AND STARTS ERRATICALLY BUCKING WHILE DRIVING.

DRIVING AND STARTED TO SHAKE, HAS NASTY RATTLE (DEATH RATTLE) THREW CODE P0355. FIXED THE CODE BY INSTALLING NEW WIRES $500.00. FIXED FOR 2 WEEKS THEN STARTED DOING IT AGAIN AND CODE P0355 CAME UP AGAIN. HAS LACK OF POWER AND SHAKES BAD. VERY MUCH A HAZARD TO DRIVE.

I WAS STOPPED AT A TRAFFIC LIGHT, WHEN THE LIGHT TURNED GREEN I GAVE THE TRUCK SOME GAS AND IT STARTED MAKING NOISE AND ACTED AS IF SOMETHING WAS ABOUT READY TO FLY APART AND SEVERLY VIBRATING. I HAD TO STOP AS QUICK AS POSSIBLE WITH CARS BEHIND ME SWERVING TO GET AROUND ME. I HAD TO CALL A TOW SERVICE TO GET MY TRUCK HOME, AFTER INSPECTION OF THE DRIVESHAFT I FOUND THAT THE CARRIER BEARING HAD SLIP OUT OF IT'S HOUSING AND THE DRIVESHAFT WAS BOUNCING AROUND IN THE BEARING BRACKET. I COULD NOT LOCATE A CARRIER BEARING ANYWHERE SO I CALLED THE FORD DEALERSHIP AND WAS TOLD I WOULD HAVE TO BUY AND REPLACE THE ENTIRE DRIVESHAFT. I DID SOME SEARCHES ON THE INTERNET AND FOUND THAT THIS HAS HAPPENED NUMEROUS TIMES. IF YOU INSPECT THE DRIVESHAFTS NOW BEING SOLD FOR REPLACEMENTS YOU WILL FIND THAT THERE HAVE BEEN DESIGN CHANGES MADE BUT FORD WON'T ADMIT THAT THEY HAD A DESIGN FLAW WITH THE ORIGINAL DRIVESHAFT. BY THE WAY, MY 2007 F150 ONLY HAS 32000 MILES ON IT, IT'S NOT A WEAR ISSUE.

O/D OFF LIGHT , TRANSMISSION FAULT ON INFORMATION DISPLAY INTERMITTENT LIGHT AND TONE! TRUCK WOULD NOT START, PCM FAILURE $3500 DOLLARS IN REPAIR, AT FORD DEALER STILL NOT FIXED!

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE FAILED TO FUNCTION PROPERLY AND THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE SPARK PLUGS AN INJECTORS WERE REPLACED, AND AN OIL PRESSURE TEST WAS PROVIDED. THE CONTACT ALSO STATED THAT THE ENGINE MISFIRED AND WAS DIAGNOSED BY MCLARTY FORD (3232 SUMMERHILL RD, TEXARKANA, TX 75503, (903) 792-7121). THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE AND TRANSMISSION NEEDED TO BE REPLACED. THE MECHANIC REBUILT THE TRANSMISSION AND THE STARTER WAS REPLACED. THE MANUFACTURER HAD NOT ISSUED A RECALL, BUT ISSUED EIGHT TSBS FOR THE ENGINE. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION OTHER THAN HAVING THE VEHICLE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 87,402. *TT *TR

EVERY VEHICLE THAT FORD PUT OUT WITH A CAM PHASER IS EXPERIENCING ISSUES WITH THE CAN PHASER. ANY SAE CERTIFIED MECHANIC WILL VERIFY THIS. THIS IS A HORRIBLE DESIGN. WHY HASN'T FORD STEPPED UP TO THE PLATE AND FIXED THIS ISSUE? I BELIEVE THEY ARE TRYING TO BURY IT SO THAT THEY DON'T HAVE TO INCUR THE COST OF FIXING THEIR MISTAKE. DUE TO THIS ISSUE I'VE BEEN STRANDED ON THE HIGHWAY. THE TRUCK LOOSES POWER, WON'T GO INTO GEAR....ETC....THIS HAPPENS AFTER THE CAN PHASER HAS ACTIVATED AND THEN I COME TO A STOP. THEN IT'S MISFIRING STALLING NOT GOING INTO GEAR...YOU NAME IT IT'S AN ISSUE. A COMPUTE READ ON THE OBD2 STAYED THAT I HAD MISSES IN IGNITION COILS 1,3 AND 7 REPLACED THEM THEN THE TEACHING STAYED MISFIRED IS 2,4 AND 5 REPLACED THEM AND ALL THE SAME ISSUES... EVERY MECHANIC I'VE SPOKEN TO SAYS ABSOLUTEY THE PHASES AND THAT THEY HAVE TO PUT A CAM PHASER DELETE KIT IN THESE VEHICLES DO GET RID OF THESE PROBLEMS. WHY HASN'T FORD BEEN HELD RESPONSIBLE FOR SUCH A TERRIBLE DESIGN?

PUT TRUCK IN REVERSE, IT SPED UP AND BRAKES DID NOT WORK. STOPPED BY BACKING INTO A TREE, THEN DROVE FINE. THREE DAYS LATER CAME TO AN INTERSECTION AND WAS UNABLE TO STOP. HIT ANOTHER VEHICLE IN THE INTERSECTION.

WHILE DRIVING AT SPEEDS OF 5 TO 15MPH WHEN THE BRAKE IS ENGAGED THE TRUCKS ENGINE WILL REV AND PULL THE TRUCK FORWARD. THE ONLY WAY TO STOP IS TO PUT IT IN N AND PUMP THE BRAKES, THIS WILL STOP THE ACCELERATION.

FORD 150 PICK UP TRUCK REGULARLY MAINTAINED WITH 70,836 MILES WAS TRAVEL ON CITY STREETS AT SPEED LIMITS WHEN A "POPPING" SOUND WAS HEARD AND TRUCK WOULD NOT TRAVEL OVER 25MPH. NO CABIN LIGHTS, NO INDICATION OF PROBLEM. IMMEDIATELY TOOK TO AUTOMOTIVE CENTER, FOUND NO ERROR OR TROUBLE CODES ON DIAGNOSTIC EQUIPMENT AND ALL FLUID LEVELS WERE FULL AND CLEAN. AUTOMOTIVE CENTER DISCOVERED FAILED TRANSMISSION WITH PIECES OF METAL IN TRANSMISSION COOLER AND LINES DURING TRANSMISSION FLUSH USING FACTORY RECOMMENDED SOLUTION. FACTORY DEFECT OF TRANSMISSION, ENGINEERING DEFECT FOR LACK OF CABIN WARNING LIGHTS AND MAINTENANCE DIAGNOSTIC EQUIPMENT.

THE FAILURES STEM FROM BAD OIL FLOW TO THE TOP END OF THE ENGINE DUE TO A FLAW IN DESIGN. SPECIFICALLY MY CAMSHAFT, CAM PHASER, TIMING COMPONENTS AND LIFTERS ROLLERS HAVE FAILED. THE PROBLEM FIRST SHOWED UP AT 42256 MILES AND HAS SINCE RESURFACED TWICE EVEN AFTER EXPENSIVE REPAIRS. THE WORRISOME PART IS THAT THE WEB IS FILLED WITH THOUSANDS UPON THOUSANDS OF SIMILAR COMPLAINTS ABOUT THIS ENGINE WHICH IS ALSO IN EXPEDITIONS AND CROWN VICTORIAS AND PROBABLY OTHER FORD VEHICLES.