2005 Ford Five Hundred Complaint Log

GALVANIC CORROSION, WHERE HOOD LATCH BAR ATTACHES TO HOOD, IS EATING AWAY THE HOOD METAL. CONNECTION WILL EVENTUALLY FAIL ALLOWING HOOD TO BLOW OPEN WHILE DRIVING. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE HESITATED WHILE DRIVING UPHILL AT 40 MPH . THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION BUT A CLEAR DIAGNOSIS WAS NOT GIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

CAR DRIVES ON ITS OWN! IF I DO NOT HAVE FOOT ON GAS ON BREAK IT WILL CONTINUE TO MOVE. SAID FAILSAFE MODE THEN CHECK ENGINE LIGHT ILLUMINATED, DASH BOARD SAID CHECK ENGINE CHECK TRANSMISSION THEN THE LIGHT WENT OUT THE FOLLOWING DAY. NOW DRIVING BACK TO NORMAL. I TOOK TO AUTO ZONE THE DAY IT WENT HAYWIRE & THEY ADVISED ME ITS A POSSIBLE RECALL SEVERAL PPL SAID THE SAME ISSUE WITH THEIR FORD.

REPLACED LOW BEAM HEADLAMP ON DRIVER SIDE, NOTED ELECTRICAL BURN MARKS ON ONE TERMINAL. REPLACEMENT BULB DID NOT WORK, HAD TO WIGGLE TO GET IT TO WORK. QUIT WORKING DAILY WITHOUT WIGGLING WHOLE LIGHTING SOCKET , TOOK APART NOTICED THAT THE SOCKET HOUSING WAS BRITTLE AND CRACKED WITH BURN MARK ON METAL FEMALE LEAD. TWO TO THREE WEEKS LATER PASSENGER LOW BEAM HEADLIGHT WOULD NOT WORK, WIGGLED PASSENGER SIDE LIGHT, CAME BACK ON. SOMETIMES BOTH LIGHT WOULD GO OUT AT SAME TIME. PROBLEM KEPT OCCURRING THROUGH AUGUST. FOUND THIS HAS OCCURRED ON OTHER FORD FIVE HUNDREDS DUE TO SOCKETS OVERHEATING. CHECKED PASSENGER SOCKET AND COMPARED TO DRIVER SIDE AND BOTH SOCKETS AND LIGHT BULBS LOOK IDENTICAL IN DAMAGE. BURNED/MELTED PLASTIC ON BULB BASE AND CRACKED BURNED SOCKETS. REPLACED BOTH SIDE BULBS AND SOCKETS LAST WEEKEND, BOTH LIGHTS WORKED FOR THREE DAYS BEFORE APPARENTLY FUSED THE SOCKET WITH THE BULB ON THE DRIVER SIDE. GUESSING THE PASSENGER SIDE WILL DO THE SAME WITHIN NEXT MONTH LIKE IT DID BEFORE.

A THROTTLE BODY WARRANTY REPAIR WAS DONE ON THIS PART ON 1-26-13. ON 6-6-13 VEHICLE LOST THE ABILITY TO GO FORWARD AS I DROVE TO WORK. PUT CAR IN REVERSE AND GOT IT OFF THE ROAD. WRENCH LIGHT CAME ON AND ATTEMPTED TO DRIVE AND CAR STILL DID NOT RESPOND. AFTER A FEW MINUTES OF STAYING IN PARK I PUT THE CAR IN DRIVE AND IT DID MOVE WITHOUT A PROBLEM. GOT AN APPOINTMENT AT FORD DEALERSHIP TO GET THE PROBLEM FIXED. WAS TOLD AFTER CAR WAS PUT ON DIAGNOSTIC TEST THAT THE THROTTLE BODY WAS STICKING, AND NEEDED REPLACED.. SERVICE ADVISOR ATTEMPTED TO GET BODY REPAIRED UNDER LAST RECALL BUT WAS UNSUCCESSFUL . I THEN APPLIED FOR THE FORD SERVICE CREDIT CARD AND PUT THE REPAIR ON IT.. I THINK REPAIR OF PART SHOULD OF BEEN COVERED UNDER RECALL.. IF THIS ISN'T REGARDED AS A SAFETY ISSUE, PLEASE DIRECT ME TO THE THE CORRECT PLACE. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE VEHICLE STALLED WITHOUT WARNING AND SHIFTED INTO REVERSED INDEPENDENTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 49,000. *TR

THE AUTOMATIC GEAR SHIFTER HAS A RUBBER MAT UNDER THE METAL PLATE WITH THE PRNDL GEARS LISTED. IT IS DIFFICULT TO SHIFT OUT OF P AND THEN THEN YOU REACH R AND D THE MAT HAS BUNCHED UP SO MUCH THAT THE METAL PLATE TELLING YOU WHAT GEAR YOU'RE IN POPS OFF. THIS IS AN EXTREME HAZARD, AS I BACK INTO THE ROAD AND THEN TO PUT IT IN D, NOT KNOWING WHERE D IS BECAUSE THE PLATE POPS OFF, I COULD BE HIT. I ALSO HAVE A 2008 FORD TAURUS EXPERIENCING THE SAME PROBLEM. I CALLED FORD AND THEY ACTED AS IF THERE WERE NO PREVIOUS ISSUES. THIS IS CERTAINLY NOT TRUE. THIS WILL CAUSE AN ACCIDENT OR FATALITY. *TR

DRIVING DOWN THE INTERSTATE AND THE INSTRUMENT CLUSTER STOPPED WORKING. THE SPEEDOMETER, TACOMETER, FUEL GAUGE, TURN SIGNAL INDICATOR AS WELL AS THE REST OF THE DIGITAL INSTURMENTS QUITE WORKING. I PULLED OVER AND CHECKED AND MY OUTSIDE LIGHTS AND RADIO WORKED. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO ACCELERATE AND BOTH THE FAIL SAFE ENGINE MODE AND THE WRENCH WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS STOPPED AND RESTARTED, AS IT OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 168,400. UPDATED 08/15/13*LJ

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT RECEIVED A SERVICE NOTICE FROM THE MANUFACTURER ABOUT A THROTTLE BODY REMEDY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND ROUTINE SERVICE. THE THROTTLE BODY WAS CLEANED BUT THE CONTACT STATED THAT THE VEHICLE BEGAN TO IDLE AT VARIOUS SPEEDS. THE CHECK ENGINE LAMP ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 51,000. UPDATED 01/07/2014*LJ THE CONSUMER STATED THE DURING THE TEST DRIVING THE VEHICLE IT WENT INTO FAIL SAFE MODE. THE TECH RESET THE LIGHT AND RETURNED THE VEHICLE. N THE WAY HOME THE VEHICLE WENT INTO FAIL SAFE MODE AGAIN ALMOST CAUSING AN ACCIDENT. UPDATED 01/22/2014 *JS

APPROXIMATELY TWO MONTHS AFTER SERVICE PERFORMED UNDER NHTSA CAMPAIGN PE11018 THE VEHICLE BEGAN TO ACCELERATE IRREGULARLY AND THEN IT PLACED ITSELF INTO "FAIL SAFE" MODE AND ILLUMINATED THE CHECK ENGINE LIGHT. VEHICLE WAS RETURNED TO THE FORD DEALER THAT PERFORMED THE SERVICE AND THEY DETERMINED THAT THE ELECTRIC THROTTLE CONTROL WAS AT FAULT BUT WAS NOT ASSOCIATED WITH THE SERVICE THEY PERFORMED ON THE SAME COMPONENT JUST WEEKS EARLIER. DEALER CONTACTED FORD MOTOR CO AND THEY ALSO CLAIMED THE TWO WERE NOT RELATED REGARDLESS OF THE SIMILAR CLAIMS FOUND ONLINE. *TR

I BOUGHT THIS CAR A YEAR AGO THROUGH RONDUPRATT USED CARS IN JANUARY 2012 CAR SEEMED TO DRAG A LITTLE BUT DIDN'T PAY MUCH ATTENTION TO IS AS SUMMER CAME AROUND TRIED TO USE THE AC IT ONLY BLEW COLD ON THE FREEWAY I JUST THINKING IT NEEDED TO BE SERVICED BUY THE TIME I GOT THE AC CHARGED IT WAS WINTER AGAIN. BUY MARCH OF NEXT YEAR THE CAR STARTED DOING THIS WEIRD SHAKING AT EVERY STOP LIGHT AND EVERY STOP SIGN THE CAR WOULD START TO SHAKE IN APRIL A LETTER COMES IN THE MAIL EXPLAINING THE CAR WAS BEING RECALLED DUE TO THE CARS RPM IDLE SURGING TOOK THE CAR TO FAIRFIELD FORD AN WHEN I GOT THE CAR BACK IT WAS WORSE THEN IT. HAD EVER BEEN SO I DECIDED TO GO PAY RONDUPRATT TO DIAGNOSTIC THE CAR THE SAID WHERE I TOOK THE CAR TO DIDN'T PERFORM THE RECALL AND THE CAR NEEDED AN AC COMPRESSOR AND AN EGR VALVE I HAVE GOTTEN THE EGR VALVE REPLACED AN THE SAME DAY THE CAR WOULDN'T GO IN TO GEAR SO CONFUSED ON WHY THEY ARE ALLOWED TO SELL CARS THAT THEY KNOW ARE EXPERIENCING THESES PROBLEMS AND RANT WILLING TO DO ANYTHING TO FIX THE PROBLEM. *TR

CAR WAS BROUGHT IN FOR THROTTLE RECALL 3/28/13. UPON THE RETURN, THE CAR BEGAN EXPERIENCING ERRATIC SURGES OF RPM/SPEED. GEARS DID NOT SHIFT RIGHT WITH INTERMITTENT ACCELERATION UNTIL VEHICLE SHUT OFF WHILE DRIVING ON HIGHWAY, BARELY ESCAPING ACCIDENT. VEHICLE WOULD NOT START & HAD TO BE BROUGHT BACK TO DEALER. DEALER STATED IT WAS A PRE-EXITING CONDITION DESPITE VEHICLE NOT HAVING ANY PRIOR ISSUES BEFORE RECALL SERVICE. DEALER DIAGNOSED & AGREED TO REPLACE FUEL FILTER. VEHICLE RESTARTED, BUT STILL WITH INTERMITTENT ACCELERATION AND IMPROPER GEAR SHIFT SURGES AT ANY SPEED. ON 4/6/13, WHILE DRIVING ON HIGHWAY VEHICLE EXPERIENCED SEVERAL ENGINE FAILURES, NARROWLY ESCAPING ACCIDENT AGAIN. SHORTLY AFTER WHILE COMPLETELY STOPPED, VEHICLE LUNGED FORWARD HITTING ANOTHER VEHICLE FROM BEHIND, CAUSING SEVERE DAMAGE TO BOTH BUMPERS ALONG WITH ENGINE FAILURE. CAR WAS BROUGHT BACK TO DEALER ONCE AGAIN, AND DEALER REFUSED TO TAKE ACCOUNTABILITY AND RE-SERVICE, STATING IT WAS A PRE-EXISTING CONDITION. UNSERVICED VEHICLE REMAINS UNUSABLE AND CONSIDERED A HAZARD TO DRIVE. VEHICLE SITS IN STADIUM FORD QUALITY AUTO MALL, RUTHERFORD NJ WITH NO RESOLVE FROM FORD DESPITE NUMEROUS COMPLAINTS. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE STOPPED AT A STOP LIGHT, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE ACCELERATE INSTEAD. THE VEHICLE WAS SHIFTED INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS REPAIRED UNDER A MANUFACTURER RECALL FOR THE COMPUTER MODULE BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

WHILE ATTEMPTING TO SLOW TO A STOP OR MAKE A TURN, AT APPROXIMATELY 25 MPH, THE TRANSMISSION DOWNSHIFTED HARD. IT DOES NOT DO THIS WHILE SPEEDING UP. I HAVE HAD TWO MECHANICS TELL ME THERE IS NO KNOWN FIX, SHORT OF REPLACING THE TRANSMISSION, AND THERE IS NO INFORMATION AVAILABLE, PARTS BRAKE DOWN, ETC, FOR THEM TO DIAGNOSIS THE PROBLEM. I HAD THE VEHICLE AT A FORD DEALER TO HAVE THE THROTTLE BODY ISSUE FIXED. AT THAT TIME, THE POWER CONTROL MODULE AND THE TRANSMISSION CONTROL MODULE WERE BOTH RE-PROGRAMMED. NO LONG TERM FIX WAS ACHIEVED. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE PAWL LATCH WOULD NOT RETURN TO THE LATCH POSITION WHEN CLOSED. THE CONTACT ALSO MENTIONED THAT ON SEVERAL OCCASIONS THE DOOR WOULD OPEN INDEPENDENTLY WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE DOOR LATCH MECHANISM NEEDED TO BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 153,000. *TR UPDATED 06/18/13*LJ UPDATED 06/21/2013 *JS

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE TRAVELING AT UNKNOWN SPEEDS, THE INSTRUMENT PANEL FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ALL WHEEL DRIVE MALFUNCTIONED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD, POWERED OFF, THEN RESTARTED THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE OXYGEN SENSOR AND DIM MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000.

2005 FORD FIVE HUNDRED. CONSUMER WRITES IN REGARDS TO VEHICLE THROTTLE BODY PROBLEMS. *SMD THE CONSUMER STATED WHILE DRIVING ON THE HIGHWAY ON A COLD AND SNOWY DAY, SHE WAS SUDDENLY FACED WITH THE VEHICLE HAVING NO POWER. SHE WAS ABLE TOG ET OFF THE ROAD, SHUT THE VEHICLE OFF AND RE-STARTED IT. WHEN THE CONSUMER RETURNED TO THE HIGHWAY, SHE DROVE A SHORT DISTANCE, AND THE SAME THING HAPPENED. SHE WAS ABLE TO DRIVE TO THE DEALER AND THEY PERFORMED THE NECESSARY SERVICES AND RECALL. HOWEVER, ONE WEEK LATER, THE SAME THING HAPPENED AGAIN. WITHOUT WARNING, THE VEHICLE HAD NO POWER. THE DEALER REPLACED THE THROTTLE BODY.

REAR UPPER CONTROL ARM SHEARED OFF AT INSIDE BUSHINGS DURING NORMAL DRIVING. WHEEL ASSEMBLY FELL AGAINST FRAME AND SOME LOSS OF CONTROL WAS EXPERIENCED. BOTH SIDES OF CONTROL ARM (FORD PART# 5A804) BROKE OFF FROM FATIGUE. *TR

NOT HAVING PROBLEMS WITH CAR UNTIL AFTER RECALL 12N03. RETURNED 3 DAYS LATER FOR REPAIR. STILL HAVING PROBLEMS. TOOK TO ANOTHER FORD DEALERSHIP. THEY WANT TO REPLACE THE PART THAT WAS RECALLED AND CHARGE ME APPROXIMATELY $800.00. MAIN FORD CUSTOMER SERVICE HAS BEEN CONTACTED NUMEROUS TIMES AND HAVE NOT HEARD BACK FROM THEM WITH ANY INFORMATION CONCERNING MY ISSUE. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY ACCELERATED INDEPENDENTLY AND THERE WAS A SUDDEN INCREASE OF ENGINE RPMS. IN ADDITION, THE VEHICLE WOULD SUDDENLY STALL AND THE FAIL SAFE ENGINE SENSOR INDICATOR ILLUMINATED ON SEVERAL OCCASIONS. THE DEALER CLEANED THE THROTTLE BODY TO REMEDY THE FAILURE, BUT THE FAILURE RECURRED APPROXIMATELY ONE YEAR LATER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES, BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE WAS SHIFTED OUT OF PARK AND THE RPM GAUGE FLUCTUATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE RPM SURGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 101,000. THE VIN WAS UNAVAILABLE. MA 10/25/15 *CN

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH INTO THE GARAGE, THERE WAS AN UNINTENDED INCREASE IN THE ACCELERATION WHICH CAUSED THE VEHICLE TO CRASH INTO THE WALL. THERE WERE NO INJURIES; HOWEVER, THE FRONT BUMPER AND HOOD WERE DAMAGED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE THROTTLE BODY WAS CLEANED AND REPROGRAMMED. THE EXTERIOR BODY DAMAGE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 78,000. ..UPDATED 01/30/13 *BF UPDATED 2/1/2013 *JS

WAS DRIVING MY 2005 FIVE HUNDRED TODAY. I PULLED OFF THE HIGHWAY AND STOPPED AT A RED LIGHT. WHEN THE LIGHT TURNED GREEN I HAD HARDLY ANY POWER. NO POWER STEERING, ALL GAUGES AT HOME AND A MESSAGE SAY "ENGINE FAILSAFE MODE". I TURNED THE CAR OFF AND RESTARTED WITH NO PROBLEMS. I'VE READ ON DIFFERENT SITES WHERE PEOPLE HAVE HAD THIS SAME ISSUE OF THE THROTTLE STICKING OPEN AND THE CAR LUNGING FORWARD OR BACK NEARLY CAUSING A WRECK. *TR

IN AUGUST 2010, I HAD THE CONTINUOUSLY VARIABLE TRANSMISSION REPLACED AT ~98,000 MILES. LUCKILY, IT WAS UNDER WARRANTY. NOW IN OCTOBER 2012, THE SECOND TRANSMISSION AS THE SERVICE MEMBER SAID AT THE FORD DEALERSHIP "THE TRANSMISSION EXPLODED, WE'RE NOT EVEN SURE HOW YOU WERE ABLE TO DRIVE THIS VEHICLE. THIS WAS AT ~146,000 MILES, BUT THERE IS ONLY ~48,000 MILES ON THE TRANSMISSION ITSELF. TWO TRANSMISSIONS HAVE FAILED IN THIS VEHICLE. SEARCHING THE INTERNET I HAVE COME ACROSS SEVERAL INSTANCES OF THE FORD FIVE HUNDREDS CONTINUOUSLY VARIABLE TRANSMISSION FAILING. I CALLED THE FORD CARE LINE TO REPORT IT, BUT THEY CLAIM THEY ARE UNAWARE OF ANY ISSUES. MY CONCERN IS THIS THIRD TRANSMISSION WILL ALSO FAIL AT SOME POINT. *TR

MY CAR SURGES. IT IS MOSTLY AT IDLE SPEED. IT'S DANGEROUS. I WAS AT A DRIVE THROUGH AND A JANITOR WAS SWEEPING. MY CAR SURGED AND I LITERALLY STOOD ON THE BREAKS TO PREVENT RUNNING OVER HIM. AT THE DRIVE THROUGH IT SURGED FORWARD AND I HAD TO STAND ON THE BREAKS TO PREVENT IT FROM RAMMING INTO THE CAR AHEAD. IT OCCURS MORE WHEN AIR CONDITIONING IS RUNNING BUT WILL OCCUR WITHOUT AC ON. I THE LOCAL DEALER REPLACED THE THROTTLE BODY RECENTLY BUT IT STILL SURGES. IT OCCURS WHEN PULLING TO A STOP AT THE LIGHTS OR AT THE DRIVE THROUGH AS YOU SLOWLY MOVE FORWARD. IT HAPPENS WHEN PULLING INTO A PARKING SPOT OR WHEN BACKING UP. I'VE SEEN NEWS ABOUT THE PROBLEM WITH THE FORD ESCAPE. MY FORD 500 IS ALSO AFFECTED AND WEIGHS A WHOLE LOT MORE. IF THIS THING SURGES FORWARD IT COULD DO SOME SERIOUS DAMAGE. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSE THAT THE THROTTLE BODY SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 138,000.

OUT SIDE AIR TEMP WAS APPROX 96 DEGREES SO AC WAS ON . WHILE SHIFTING INTO REVERSE THE VEHICLE LUNGED SO HARD IT WAS UNCONTROLLABLE,AND UNSTOPPABLE, IF SOME ONE HAD STEPPED OUT BEHIND ME THEY WOULD HAVE DIED AS I COULD ONLY STOP REWARD MOVEMENT BY SHIFTING INTO DRIVE. THIS OCCURRED THREE TIMES TRYING TO GET OUT OF A PARKING SPACE AT A CROWDED MALL.THE VEHICLE THEN STALLED. THE LUNGING WAS SO FAST THE BRAKES COULD HARDLY HOLD THE CAR FROM MOVING IN REVERSE. IN CHECKING THERE IS A SERVICE BULLETIN TSB-05-25-13 FROM FORD MOTOR COMPANY ON THIS VERY ISSUE BUT NO RECALL, ALSO MANY INCIDENTS/ACCIDENTS RECORDED IN THIS REGARD. IF I WAS NOT PREPARED ENOUGH DURING THIS INCIDENT IN A CROWDED PARKING LOT SOME ONE WOULD HAVE DIED, THIS MUST BE ADDRESSED B-4 SOMEONE IS RUN OVER. CURRENTLY FORD HAS NO COMMENT. PLEASE CONTACT ME FOR FURTHER DETAILS. *TR

AFTER HAVING TURNED ONTO A 35 MPH STREET, HAVING ONLY REACHED 30MPH, THE RPM'S SHOT UP TO SIX AND THE CAR ACCELERATED TO ALMOST 40 WITHOUT THE GAS PEDDLE HAVING BEEN PRESSED. IF THERE WERE ANOTHER CAR STOPPED OR A PERSON IN FRONT OF US THEY WOULD HAVE BEEN HIT. ANOTHER TIME THE VEHICLE WAS AT A STOP LIGHT AND AGAIN WITH OUT WARNING THE CARS RPM'S SHOT UP TO ABOUT SIX. IF MY FOOT HAD NOT BEEN APPLIED COMPLETELY TO THE BREAKS I WOULD HAVE BEEN IN A BUSY INTERSECTION RESULTING IN THE CAR HAVING BEEN TOTALED, DEATH OF MORE THEN ONE PERSON. THIS IS NOT SAFE. *TR

ON HOT SUMMER DAYS AND ONLY ON HOT SUMMER DAYS WHEN STOPPED AT LIGHT OR STOPPED PERIOD CAR BEGINS TO SURGE FORWARD WHILE HOLDING BRAKE. WENT ASKED FORD WHY IS THIS HAPPENING THEY SAID THEY DON'T KNOW. THAT I SHOULD GET THE THROTTLE BODY AND MASS AIR FLOW SENSOR SERVICED IF NOT DONE ALREADY. I GUESS IT HAD TO BE DONE AT 90K BUT I DID NOT KNOW. WELL I DID WHAT THEY SAID, WENT HOME AND CAR IS NOW IDLING ROUGH WENT BACK AND THEY WANT TO CHARGE ME ANOTHER $90 DOLLARS ONTOP OF THE $105 THEY HAVE ALREADY CHARGED ME FOR THE THROTTLE AND MAFS. I HAVE ALMOST GOTTEN IN NUMEROUS ACCIDENTS BECAUSE OF THIS BUT FORD DOESN'T WANT TO ACKNOWLEDGE THAT THIS IS A PROBLEM WITH THIS CAR. *TR

ON HOT DAYS, WHEN BACKING OUT OF PARKING SPACES, THE CAR HAS SOMETIMES "SURGED" MEANING THAT THERE HAS BEEN UNINTENDED ACCELERATION WITHOUT THE ACCELERATOR BEING PRESSED AT ALL. I HAVE HAD TO SUDDENLY AND FIRMLY PUT MY FOOT ON THE BRAKE TO PREVENT THE CAR FROM HITTING OTHER VEHICLES. THIS HAS HAPPENED ON SEVERAL OCCASIONS IN AUGUST OF 2012. I OWN A 2006 FORD FIVE HUNDRED ALSO AND IT HAS HAD THE SAME PROBLEM IN THE SAME CONDITIONS (FILING SEPARATE COMPLAINT). *TR

I HAD PREVIOUSLY HAD PROBLEMS WITH UNINTENDED ACCELERATION WHEN PARKED AND THEN PUTTING THE CAR INTO REVERSE (AUTOMATIC TRANSMISSION). AFTER READING MANY COMPLAINTS ON YOUR SITE IN WHICH CONSUMERS SAID THE THROTTLE BODY HAD BEEN DIAGNOSED AS CAUSING THE PROBLEM, I HAD THE DEALERSHIP REPLACE THE THROTTLE BODY. ( A FEW MONTHS LATER, FORD SENT A LETTER OFFERING TO REPLACE THE THROTTLE BODY). DESPITE HAVING HAD THE DEALERSHIP REPLACE THE THROTTLE BODY, THE CAR CONTINUES TO ACCELERATE FASTER THAN IT SHOULD SOMETIMES WHEN PUT IN REVERSE AND I MUST ALWAYS BE PREPARED TO BRAKE RAPIDLY. IF A DRIVER WAS UNAWARE OF THE PROBLEM OR HAD SLOW REACTION TIME, A CAR OR PERSON IN A PARKING LOT COULD BE HIT. *TR

SO HERE I AM ANOTHER VICTIM OF A FAULTY THROTTLE BODY. THANKS FORD I LOVE WHEN MY CAR TAKES OFF ON ME WITHOUT NOTICE, ESPECIALLY WHEN YOU HAVE KIDS IN THE CAR. HOW MANY OF THESE DO I HAVE TO READ BEFORE ACTION IS TAKEN. DOES IT TAKE A DEATH OR SERIOUS ACCIDENT. COST ME 718 DOLLARS I EXPECT A RECALL SOON AND MY MONEY BACK I WILL NOT QUIT UNTIL THIS IS TAKEN CARE OF. IT'S SAD WHEN YOU GO TO A MECHANIC AND THEY SAY "WOW THERE IS STILL NOT A RECALL ON THIS". OH BY THE WAY IT IS SUCH A COMMON PROBLEM I DIAGNOSED MY OWN CAR ISSUE IN 5 MINUTES BY USING GOOGLE AND TYPING FAILSAFE ENGINE MODE. *TR

THIS HAPPENS FREQUENTLY ALMOST DAILY IN THE SUMMER. BUT ON A HOT DAY (90+) WHEN MOVING FROM A STOPPED POSITION OUT OF A PARKING SPOT OR AROUND A CORNER, WHEN YOU LIGHTLY HAVE THE BRAKE PEDAL DEPRESSED IF YOU TURN THE WHEEL SLIGHTLY (IE BACKING OUT OF A TIGHT PARKING SPACE) THE CAR WILL LUNGE VIOLENTLY AND AGGRESSIVELY IN WHAT EVER DIRECTION YOU ARE TRAVELING, SOMETIMES SO AGGRESSIVELY IT WILL STALL THE VEHICLE OUT AND THEN GO INTO A FAILSAFE MODE. THIS IS VERY DANGEROUS AS YOU COULD UNEXPECTEDLY HIT SOMEONE WALKING AROUND THE CAR AT A STOP SIGN OR CROSSWALK. I HAVE ALSO FOUND NUMEROUS OTHER COMPLAINTS ON VARIOUS BLOGS, FORUMS, AND OTHER SITES. EVERYONE BASICALLY STATING THE DEALER GIVES THEM THE RUN AROUND. AND AS LONG AS IT IS A HOT DAY I CAN DUPLICATE THE RESULTS CONTINUOUSLY, AND WOULD BE MORE THAN WILLING TO SHOW THIS TO SOMEONE ELSE IF POSSIBLE. I AM TYPICALLY NOT ONE TO COMPLAIN, BUT I FEEL VERY STRONGLY ABOUT THE SAFETY OF THIS VEHICLE, ESPECIALLY SINCE I HAVE A 3YR OLD DAUGHTER. *TR

WE WERE DRIVING DOWN A HIGHWAY AND WENT TO GET BACK TO SPEED AFTER PASSING THROUGH A SPEED ZONE. I NOTICED A DECREASE IN POWER AND LOOKED AT THE INFORMATION SCREEN. THE FAIL SAFE MODE AND THE "WRENCH" ICON WAS ON. I PULLED THE CAR OVER AND TURNED IT OFF. I THEN TURNED IT ON AND THE CAR ACTED NORMAL. IT HAS HAPPENED TWICE SINCE THE FIRST INCIDENT. MY WIFE TOOK IT TO THE DEALERSHIP AND FORD CANNOT DUPLICATE THE PROBLEM AND THE ISSUE DOES NOT THROW A CHECK ENGINE CODE OR LEAVES ANY TYPE OF ELECTRONIC HISTORY OF THE ISSUE. I CANNOT ALLOW MY WIFE TO DRIVE THIS CAR BECAUSE SHE IS SEVEN MONTH PREGNANT AND CANNOT HAVE HER DRIVE IT IF THE CAR BREAKS DOWN DUE TO THIS ISSUE. *TR

ONE DAY IN JUNE I WAS PULLING UP TO A STORE PARKING SPACE ROLLING ROUGHLY 5MPH. I HAD MY FOOT ON THE BRAKE, I WAS ABOUT TO STOP. WITHOUT TOUCHING THE GAS MY 2005 FORD FIVE HUNDRED LUNGED AT THE BUILDING AS IF THE THROTTLE WAS STUCK WIDE OPEN! I HAD TO PUSH THE BREAK AS HARD AS I COULD TO KEEP IT FROM CRASHING INTO THE STORE! FORD SHOULD HAVE A RECALL ON THIS ISSUE! IT IS EXTREMELY DANGEROUS! THIS HAS HAPPENED TO MANY FORD FIVE HUNDRED OWNERS! LAST MONTH IN JANUARY MY FIVE HUNDRED HAD OTHER ISSUES. I WAS DRIVING 35MPH AND ALL OF A SUDDEN MY CAR HAD NO POWER, I GAVE IT GAS AND IT WOULD GROWL BUT NO POWER. I HAD TO PULL OVER AND SHUT THE CAR OFF. ONE RESTARTED IT RETURNED TO NORMAL BUT THE WRENCH ICON LIGHT WAS ON THE DASH. I HAVE ALSO HAD AN IDLING PROBLEM. WHILE AT IDLE MY CAR WOULD SPUTTER. THE RPM'S WERE LOW AND IT WOULD IDLE ROUGH AND SURGE FROM LOW TO HIGH, I TRIED HITTING THE GAS PEDAL AND THE CAR STALLED! AGAIN OTHER FORD FIVE HUNDRED OWNERS ALSO EXPERIENCED THESE ISSUES! FORD ITS TIME TO STEP UP AND DO A RECALL!!!! *TR

DURING HOT ( 95 DEGREES) AFTERNOON, WITH A/C ON HIGH, VEHICLE REVS AND LURCHES WHILE VEHICLE IS IN GEAR. HARD PRESSURE ON THE BREAK WILL STOP THE VEHICLE, BUT ENGINE REVS STILL CONTINUE. ENGINE THEN DIES AND ' ENGINE FAIL SAFE MODE ' APPEARS. TURNING THE VEHICLE OFF AND WAITING TO RESTART RESETS THE FAIL SAFE MODE. ALLOWING VEHICLE TO COOL DOWN CLEARS THE SHORT TERM PROBLEM. REPORTED TO LOCAL FORD DEALER WHO CLAIMS TO HAVE NOT HEARD OF THE PROBLEM. *TR

DURING WARM WEATHER WITH THE A/C OPERATING, THE RPMS SURGE AND THE VEHICLE LUNGES IN THE DIRECTION OF THE TRANSMISSION LEVER SELECTION (FORWARD OR REVERSE) WHEN MOVING THE SHIFT LEVER FROM PARK TO DRIVE OR FROM PARK TO REVERSE WITH DRIVER'S FOOT ON THE BRAKE. ENGINE RPMS SURGE UP TO APPROX. 1,500 FROM IDLE AT A DEAD STOP WITHOUT INPUT FROM ACCELERATOR PEDAL. DIFFERENT INDICATOR LIGHTS COME ON AND OFTEN THE ENGINE DIES AFTER THE SURGE. IF DRIVER DOES NOT KEEP APPROPRIATE PRESSURE ON BREAK PEDAL WHILE SHIFTING FROM PARK, THE VEHICLE WILL ACCELERATE WITHOUT INPUT FROM GAS PEDAL. THIS SURGE ALSO HAPPENS WHEN DECELERATING TO A STOP. VEHICLE SLOWS DOWN AND RPMS DECREASE TO APPROX 600 (IDLE), AND WITH PRESSURE APPLIED TO BRAKE PEDAL, ENGINE RPMS WILL INCREASE, WITHOUT INPUT FROM ACCELERATOR PEDAL, FORCING THE DRIVER TO INCREASE PRESSURE ON BRAKE PEDAL OR RISK UNCONTROLLED FORWARD MOVEMENT. INITIAL REPORTS INDICATE A FAULTY THROTTLE BODY AS REFERENCED IN NHTSA INVESTIGATION # PE110818. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED LTD. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STARTED TO LUNGE FORWARD AND BACKWARD BEFORE STALLING. THE CONTACT MERGED THE VEHICLE TO THE SHOULDER, TURNED THE ENGINE ON AND OFF AND THE VEHICLE STARTED IMMEDIATELY. THE FAIL SAFE MODE WARNING LIGHT STARTED TO ILLUMINATE. THE DEALER WAS NOTIFIED OF THE ISSUE BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000. THE CONSUMER STATED BEFORE SHE STARTED DRIVING ON THE ROAD, SHE BACKED OUT OF A PARKING SPACE. SHE HAD HER FOOT ON THE BRAKE SLIGHTLY AS SHE WAS BACKING UP, WHEN THE VEHICLE TRIED TO LUNGE FORWARD THEN BACKWARD. SHE APPLIED THE BRAKE ALL THE WAY, STOPPED THE VEHICLE, BUT DID NOT TURN IT OFF AND THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED. SHE TRIED TO BACK UP AGAIN, BUT IT STILL WASN'T RUNNING CORRECTLY, BUT SHE MANAGED TO FINISH BACKING OUT AND STRAIGHTENED OUT THE VEHICLE. THE FAIL SAFE MODE LIGHT STAYED ON. SHE SAT FOR A MINUTE AND BEGAN TO EXIT THE PARKING LOT. SHE ONLY DROVE 500 FEET, WHEN THE INCIDENT HAPPENED AGAIN. UPDATED 10/01/12

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE LIGHT BEGAN TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE VEHICLE WOULD NEED A NEW THROTTLE BODY. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 101,934.

THROTTLE BODY MALFUNCTION. ENGINE REVES UP WHILE PLACING THE CAR IN DRIVE OR REVERSE WITHOUT TOUCHING THE GAS PEDAL, UP TO 1.5 ON THE RPM'S ON THE SPEEDOMETER. THIS IS VERY SCARY, A CHILD CROSSED IN FRONT OF ME WHILE I WAS WAITING AT A STOP SIGN. FOOT WAS ON THE BRAKE BUT ALL OF A SUDDEN IT JUST REVED UP. IT LUNGED FORWARD AND I HD TO REALLY PUT THAT BREAK ON. SCARED ME AND THE CHILD TO. I BOUGHT THE CAR NEW AND HAD ALL SERVICE DONE FROM THE FORD DEALER IN THE SERVICE PERSON THERE TOLD MY HUSBAND THAT THIS PART "THROTTLE BODY" WAS MADE BY THE SAME MANUFACTURER THAT MADE THE TOYOTA PARTS THAT WENT BAD "STICKING GAS PEDALS" ? AND THAT TOYOTA RECALLED THIS DANGEROUS ISSUE AND FIXED IT. UNLESS MY HUSBAND MISUNDERSTOOD THIS GENTLEMAN, WHICH I DON'T THINK HE DID. I SPOKE TO FORD AND PLACED A COMPLAINT AND THEY TOLD ME THAT THERE HAD BEEN COMPLAINTS, BUT THERE WAS NO RECALL ISSUED AS YET, BUT HOLD ONTO MY RECEIPT IN CASE THERE IS A RECALL ISSUED IN THE FUTURE. THIS WILL COST $850.00, "WHICH I FEEL SHOULD BE PICKED UP BY FORD". PRESSING NORMALLY ON THE BREAKS IS NOT GOOD ENOUGH, YOU HAVE TO ALMOST PUT IT TO THE FLOOR SO THAT YOU DO NOT MOVE AND PRAY THAT IT DOESN'T LUNGE FORWARD IN THE TRANSITION FROM BREAK TO GAS PEDAL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT

WHILE CHANGING A TIRE THE JACK COLLAPSED UNDER MY VEHICLE. FORTUNATELY I WAS NOT UNDER THE CAR AND THE WHEEL WAS STILL ON THE CAR. IT APPEARS THAT THE FEMALE THREADS ON THE JACK STRIPPED AWAY. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FAIL SAFE MODE ACTIVATED, CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS MERGED TO THE SHOULDER, TURNED OFF AND THEN RESTARTED AFTER SEVERAL MINUTES, AS IT RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING A FULL DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 126,000.

WHEN BACK UP THE CAR ACCELERATES LIKE YOU ARE ON THE GAS BUT THE GAS PEDAL IS NOT TOUCH. WHEN THE CAR COMES TO A STOP AND THE FOOT IS ON THE BRAKE, ONCE YOU TAKE THE FOOT OFF THE BRAKE THE CAR ACCELERATES WITHOUT WARNING. THIS HAS HAPPEN IF STOP AT A LIGHT, BACKING OUT OR EVEN WHILE IN PARK THE CAR WILL JUST ACCELERATE WITHOUT WARNING! MY DAUGHTER ALMOST HIT A COUPLE OF PEOPLE WALKING IN THE CROSS WALK AND ALL SHE DID WAS RELEASE THE BRAKE TO MOVE UP AFTER A CAR TURN AND ACCELERATED WITHOUT WARNING. I HAVE HAD THE CAR ACCELERATE AFTER JUST BEING STOP AT A LIGHT OR MOVING AT SLOW SPEED WITHOUT TOUCHING THE GAS, BUT IT DOES NOT HAPPEN ALL THE TIME. LAST OIL CHANGE AT FORD DEALERSHIP THERE WAS NOTHING WRONG WITH TRANSMISSION FLUID AND THERE WERE NO LEAKS...... *TR

MY FORD FIVE HUNDRED HAS BEEN UNEXPECTEDLY SURGING WHEN RELEASING THE BRAKE PEDAL WHEN GOING FORWARD AND REVERSE. IT HAS ALMOST CAUSED ME TO HIT OTHER VEHICLES IN A PARKING LOT ON SEVERAL OCCASIONS AND MAKES IT EXTREMELY DIFFICULT TO CONTROL THE SPEED OF THE VEHICLE WHEN STARTING TO ACCELERATE. SOMETHING NEEDS TO BE DONE ABOUT THIS ISSUE. I AM NOT THE ONLY PERSON WHO IS EXPERIENCING THIS. THERE ARE MANY MORE PEOPLE WHO HAVE POSTED THE SAME ISSUE ON BLOGS AND WEBSITES I HAVE READ. PLEASE LOOK INTO THIS ISSUE. *TR

WHILE PARKING, WITH FOOT ON BRAKE THE CAR SURGED FORWARD. THE A/C WAS ON AS WELL. IT HAS NOW HAPPENED 7 MORE TIMES ALL WHILE THE A/C IS ON EITHER PARKING OR REVERSING FROM A PARKING SPOT. *JS

THE HEADLIGHT SOCKET ON BOTH HEADLIGHTS ARE OVER HEATING AND MELTING CAUSING THE BULB NOT TO OPERATE. I'M JUST NERVOUS THAT THIS WILL CAUSE A FIRE AS ALL THE PARTS ARE PLASTIC. I ALSO NOTED ON LINE THAT IT IS A VERY REAL PROBLEM AND I'M NOT THE ONLY ONE EXPERIENCING THIS. *TR

MY WIFE, SON AND I WERE DRIVING. THE VEHICLE HAD RANDOM ACCELERATION WHILE AT FULL STOPPED. ABOUT 10 MINUTES LATER AFTER A FULL STOP THE VEHICLE HAD ANOTHER ACCELERATION WHILE FOOT ON BRAKE AND THE VEHICLE STALLED OUT. ONCE STALLED OUT THE COMPUTER DISPLAYED THE FOLLOWING ERROR "FAIL SAFE ENGINE". AFTER DOING AN ONLINE REVIEW I NOTICED THAT MANY OTHER FORD FIVE HUNDRED OWNERS HAVING THE SAME ISSUE AND SEEMS TO BE CAUSED BY "THROTTLE BODY". PLEASE NOTE THAT WHENEVER THE VEHICLE IS ON PARK AND PUT INTO REVERSE, THE HIGHER ACCELERATION TAKES PLACE. I ALWAYS HAVE TO BE EXTRA CAREFUL. I HAVE TO BE EXTRA CAREFUL WHILE DRIVING AS I AM AFRAID FOR ACCELERATION AND STALLING OUT IN THE MIDDLE OF THE ROAD. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TRANSMISSION FAILED AND THE SPEED DROPPED TO 30 MPH. THE CONTACT MOVED THE VEHICLE OFF THE ROADWAY AND ALLOWED THE VEHICLE TO COOL DOWN. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE WAS LATER TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 200,000. THE VIN WAS UNAVAILABLE.