2005 Ford Five Hundred Complaint Log

THE ELECTRONIC THROTTLE BODY IS BAD IN MAJORITY OF VEHICLES IN MY CLASS YEAR. THIS COSTLY REPAIR CAUSES THE VEHICLE TO LUNGE FORWARD WHILE IN DRIVE AND LUNGE BACKWARDS WHILE IN REVERSE. IT IS WORST WHEN THE AC IS ON,,IT CAUSES THE VEHICLE TO IDLE HIGH AND LOW TO THE POINT OF ALMOST SHUTTING OFF THE VEHICLE IN TRAFFIC. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THEN VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT WAS UNABLE TO INCREASE SPEED AND EVENTUALLY, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 62,000.

I HAD THE NEED TO AVOID AN ACCIDENT BY SUDDENLY CHANGING LANES BUT WHEN I STEP ON THE GAS PEDAL MY TRANSMISSION FAILED TO SHIFT TO HIGHER SPEED. INSTEAD TWO CLUNKING SOUNDS TOOK PLACE BEFORE FINALLY SWITCHING INTO HIGHER GEAR .I WAS ABLE TO AVOID THE CAR IN FRONT OF ME , BUT NOW THE CAR BEHIND ME ALMOST REAR ENDED US. THIS WOULD HAVE CREATED A FATAL CHAIN REACTION WE COULD HAVE BEEN CRUSHED IN. I FOUND OUT THIS CARS HAVE A GREAT AMOUNT OF FAILURES ON RECORD FORD 500 2005 PLEASE HELP *JS

I HAVE AN ONGOING ISSUE WITH THE TRANSMISSION DE-ENGAGING WHEN THE TEMPERATURE OF THE TRANSMISSION WARMS UP. WHEN I ACCELERATE WHEN PASSING OR USING THE CRUISE CONTROL THE TRANSMISSION WILL DIS-ENGAGE LEAVING ME WITH NO FORWARD POWER, I MUST PUT THE CAR IN NEUTRAL AND HOPE IT ENGAGES ALL THE WHILE ALMOST BEING RUN OVER BY TWO SEMI-TRUCKS. THIS HAPPENED ALMOST A DOZEN TIMES DOWN AND BACK ON MY TRIP FROM BUFFALO TO PEAPACK NJ ON MONDAY 4/16/2012. THIS IS A KNOW PROBLEM THAT FORD IS AWARE ON THE FIVE HUNDRED MODEL, MONTEGO AND SOME FUSION MODELS. MANY START TO FAIL AT LESS THAN 30,000 MILES AND HAPPENED AT 65,000 MILES ON MY VEHICLE. I CONSIDER THIS AN EXTREMELY DANGEROUS SITUATION AND AMAZED NO ONE HAS BEEN KILLED DUE TO THESE DEFECTIVE TRANSMISSIONS. THE FORD FORUM HAS OVER 10 PAGES OF COMPLAINTS REGARDING THIS PROBLEM. FORD TOLD ME THEY WOULD NOT DO ANYTHING UNLESS THERE WAS A RECALL.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE ENTERING THE VEHICLE, HE NOTICED THAT SMOKE FILLED THE INTERIOR. THE CONTACT THEN NOTICED THAT THE TRUNK LIGHT WAS ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT WAS NOT CALLED AND NO ONE WAS INJURED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN A LOUD POP WAS HEARD AND SUDDENLY, THE SUN ROOF GLASS EXPLODED. THE GLASS SHATTERED INSIDE OF THE VEHICLE AND THE CONTACT SUFFERED INJURY TO THE EYE FROM SMALL FRAGMENTS OF GLASS ENTERING THE EYE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE REAR TRUNK AND REAR BUMPER SUSTAINED SEVERE SCRATCHES. THE WAS TAKEN TO A COLLISION CENTER FOR REPAIR. THE TECHNICIAN ALSO INFORMED THE CONTACT THAT THE FRONT DRIVER SIDE WINDOW GLASS EXHIBITED SPIDER CRACKS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 32,724.

THE CAR PERIODICALLY LURCHED AND SURGED. FINALLY, IT WOULD NOT START. THE DEALER DETERMINED THAT THE ELECTRONIC THROTTLE BODY WAS DEFECTIVE. BASED ON INFORMATION FROM THE DEALER AND FROM THIS WEBSITE, IT APPEARS THAT THIS IS A COMMON PROBLEM ON CERTAIN FORD MODELS. IF THIS PROBLEM IS AS WIDE-SPREAD AS IT APPEARS, THERE SHOULD BE A RECALL. *TR

BEING STOPPED AT AN ATM, MY CAR BEGAN TO SMOKE. PULLED OVER INTO THE BANK PARKING LOT TO SEE IF IT WAS OVER HEATING. THE WHITE SMOKE WOULD NOT SUBSIDE AND BEGAN GETTING WORSE. DIALED 911 AND A FIRETRUCK CAME OUT OPENED THE HOOD AND EXTINGUISHED A FIRE UNDER THE HOOD. PRIOR TO THE TRUCK ARRIVING, A LOUD BANG OCCURRED UNDER THE HOOD. *TR

WHEN YOU ARE DRIVING THE VEHICLE WILL STOP ACCELERATING AND A FAIL SAFETY MODE LIGHT COMES ON, IF YOU PULL OVER AND RESTART IT, IT WILL RESTART AND HAPPENS A FEW MINUTES LATER. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO JERK VIOLENTLY AND RESPONDED AS THOUGH IT WOULD STALL. THE FAILURE OCCURRED SPORADICALLY WHEN DRIVING AT LOW AND HIGH SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSIS. THE TECHNICIAN STATED THAT THE MOTOR MOUNT WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 155,000 AND THE CURRENT MILEAGE WAS 160,000.

SINCE 2007 THE CAR INTERMITTENTLY WILL PERIODICALLY LUNG FORWARD AND IT IS ALMOST IMPOSSIBLE TO CONTROL THE CAR. THIS HAS HAPPENED SEVERAL TIMES SINCE JUNE 2007 (88,000 MILES). EVEN HARD BRAKING DOES NOT NECESSARILY STOP THE CAR...I HAVE HAD TO PUT THE CAR IN NEUTRAL THE ENGINE REVS UP AS IF I AM TOUCHING THE ACCELERATOR (AND MY FOOT IS NOT ON THE PEDAL) AND I SHUT THE CAR OFF. TURNING THE CAR BACK ON DOES NOT NECESSARILY REMEDY THE PROBLEM. IN ADDITION, THE CAR ROUTINELY GOES INTO FAIL SAFE ENGINE MODE OR CUTS OFF WHILE I AM DRIVING AT A REASONABLE RATE OF SPEED BOTH ON RURAL ROADS AND HIGHWAYS. THIS CAR IS A HAZARD TO DRIVE, MORE SO IN THE WARMER MONTHS...MY THOUGHT IS SOMETHING MUST GET OVERHEATED BUT WHAT I DO NOT KNOW. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE OIL PRESSURE AND BRAKE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE TURN SIGNALS FAILED AND THE REVERSE LIGHTS ILLUMINATED ON THEIR OWN. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE DOWN SHIFTED AND LOST ENGINE POWER. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE DEALER REPROGRAMMED THE COMPUTER, BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR A DIAGNOSTIC TEST, WHICH LOCATED THE FAILURE AT THE TRANSMISSION VALVE BODY. THE TRANSMISSION VALVE BODY WAS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 67,407.

TL* THE CONTACT OWNS A 2005 FORD FIVE-HUNDRED. THE CONTACT STATED THAT WHILE REVERSING FROM A RESIDENTIAL GARAGE, THE VEHICLE LUNGED BACKWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 70,000.

I WAS DRIVING DOWN A RESIDENTIAL STREET WHEN ALL OF THE SUDDEN THE ENGINE STALLED ON ME AND I RECEIVED A "FAILSAFE ENGINE MODE" MESSAGE IN THE MESSAGE CENTER. I STOPPED THE CAR AND SHUT OFF THE ENGINE, THEN WAITED A COUPLE OF MINUTES AND STARTED IT AGAIN AND HAD NO PROBLEMS. I WAS THEN DRIVING DOWN A RESIDENTIAL STREET AGAIN A COUPLE OF DAYS LATER AND THE SAME THING HAPPENED WHERE THE ENGINE STALLED ON ME. THE ONLY WARNING SIGNS THAT I CAN RECALL WERE THAT AT TIMES, I WOULD EXPERIENCE SLUGGISH ACCELERATION. THIS IS A HUGE ISSUE TO ME AND VERY DANGEROUS SINCE I HAVE A CHILD AND WHAT IF I WAS TRAVELING ON THE HIGHWAY AND THIS HAPPENED TO ME? *TR

DRIVING IN TOWN, AT APPROX 25MPH. CAR JERKED/LURCHED SUDDENTLY, THEN ENTERED LIMP HOME MODE. PULLED OVER, TURNED OFF CAR. RESTARTED AND CHECK ENGINE LIGHT CAME ON. TURNS OUT IT IS A THROTTLE BODY FAILURE. SHOP SAYS THIS IS A VERY DANGEROUS SITUATION - THE CAR COULD SUDDENLY ACCELERATE/DECELERATE WITHOUT NOTICE. LOOKING AT ONLINE FORUMS - IT SEEM A FAIRLY COMMON FAILURE, AND SOMETHING FORD SHOULD ISSUE A SAFETY RECALL ON. *TT

THE CAR SUDDEN SURGES FORWARD OR BACK WHEN MOVING OUT OF PARK. IF YOUR FOOT IS NOT FIRMLY ON THE BRAKE IT WILL GO MOVE SIGNIFICANTLY. UPON RESEARCH ONLINE AND TALKING TO FORD DIRECTLY THIS IS KNOWN PROBLEM THAT IS NOT UNDER RE-CALL YET BUT SHOULD BE. OUR LOCAL FORD DEALER CARRIES THE THROTTLE BOTTLE IN STOCK BECAUSE THEY SELL SO MANY OF THEM. THEY AVERAGE 10 A YEAR. A SIMPLE RESEARCH OF THE PROBLEM SHOWS UP. IT IS EXTREMELY DANGEROUS. ALSO IF THERE IS QUICK STOP IT WILL GO TO A FAIL SAFE MODE AND BASICALLY SHUT OFF THE CAR COMPLETELY. THE CAR HAS TO BE SHUT OFF AND RESTARTED IN ORDER TO MOVE THE VEHICLE AGAIN. THE THROTTLE BOTTLE MUST BE REPLACED IN ORDER FOR IT TO BE SAFE AS A PARTS COST OF ALMOST $600.00. *TR

2005 FORD FIVE HUNDRED. CONSUMER WRITES IN REGARDS TO HARD SHIFTING AND TWO INSTRUMENT PANEL LIGHTS ILLUMINATING. *TGW THE CONSUMER ALSO STATED THE RPM'S WOULD RACE AT TIMES. THE CONSUMER WENT TO HER LOCAL DEALER AND A DIAGNOSTIC'S TEST REVEALED A PROBLEM WITH THE PCV VALVE. THE PCV WAS REPLACED AT A COST OF $ 112.95. HOWEVER, IT DID NOT RESOLVE THE PROBLEM. THE CONSUMER WENT BACK TO THE DEALER FOR A TRANSMISSION DIAGNOSTIC TEST, BUT THE DEALER WAS UNABLE TO GIVE A DEFINITIVE ANSWER AS TOW HAT THE PROBLEM WAS. FORD CUSTOMER SERVICE WAS THEN CONTACTED AND THEY INFORMED THE DEALER TO REPLACE THE TRANSMISSION AT A COST OF $5000. THERE WAS ALSO ANOTHER INTERMITTENT PROBLEM WHERE THE VEHICLE WOULD REV WHILE STOPPED AT A STOP SIGN, OR RED LIGHT ETC. AFTER GETTING OTHER OPINIONS, THE CONSUMER WAS INFORMED, THE PROBLEM WAS NOT WITH THE TRANSMISSION. AFTER DOING SOME RESEARCH ONLINE, THE CONSUMER DISCOVERED IT WAS A VERY COMMON OCCURRENCE WITH HER PARTICULAR MAKE, WHICH SEEMED TO BE A MANUFACTURING DEFECT.

DRIVING FROM SJ TO LA, CALIF. 200 MILES INTO MY JOURNEY WITH WIFE AND 3 KIDS, PULLED OFF HIGHWAY FOR GAS. SLOWED DOWN AND NOTICED THE WRENCH AND CHECK ENGINE LIGHTS ON AND CAR WOULD ONLY GO 10 TO 15 MILES PER HOUR AND REVVED AT MORE THAN 3000 RPMS. THE CAR CLUNKED HARD WHEN PUT INTO DRIVE OR REVERSE. TURNED OFF THE ENGINE, SEVERAL TIMES AND RESTARTED. SOMETIMES FIXED PROBLEM, OTHER TIMES DID NOT. I HAD CAR TOWED TO HANFORD, CALIFORNIA, AND THEN AGAIN TO LOS ANGELES-ANOTHER 198 MILES TO FORD DEALERSHIP. I HAD TO RENT A CAR AND DRIVE THE REST OF THE WAY TO LA AND DRIVE BACK - 198 MILES-TO HANFORD-TO RETURN THE RENTAL CAR. I TESTED THE CAR A FEW TIMES IN HANFORD AND WHEN IT WAS AT THE FORD DEALER. FROM A COLD START, THE CAR WORKED FINE. DROVE AND SHIFTED WELL WITH NO PROBLEMS. BUT ONCE THE CAR WARMED UP, IT WENT BACK INTO LIMP-MODE, CLUNKED HARD WHEN YOU SHIFTED INTO DRIVE OR REVERSE, AND WOULD GO ONLY 10-15 MPH AT 3000 OR MORE RPMS. THE DEALER TEST DROVE IT AND HAD THE SAME RESULT. THE DEALER GOT CODES P0701, P0871, AND P0961 AND SAID THAT MEANT THE TRANSMISSION HAD INTERNAL PROBLEMS. THEY SAID THEY CALLED FORD ENGINEERS WHO TOLD THEM THE LIKELY PROBLEM WAS WHEN THE TRANSMISSION FLUID WARMS UP, IT IS NOT PROPERLY CIRCULATING DUE TO LEAKS IN WHAT THEY CALLED TWO VARIATORS INSIDE THE TRANSMISSION. THEY QUOTED THE COST TO REPLACE THE VARIATORS AS $3600 FOR PARTS AND LABOR OF $1200 FOR A TOTAL OF $4800 AND THAT IS MORE THAN THE COST TO REPLACE THE TRANSMISSION FOR WHICH THEY QUOTED $4500. SO THEY REPLACED THE TRANSMISSION. AFTER STARTING, THEY FOUND A BROKEN TRANSMISSION MOUNT SO THEY REPLACED THAT FOR ANOTHER $250 (PART ONLY - NO LABOR CHARGE). I TEST DROVE THE NEW TRANSMISSION YESTERDAY. THE CAR NO LONGER GOES INTO LIMP MODE AND DRIVES NICELY EXCEPT AFTER IT WARMS UP IT CLUNKS HARD INTO DRIVE AND REVERSE AND WINES IN REVERSE GEAR. NOT TAKING CAR TILL FIXED PROPERLY. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE DRIVER'S DOOR WAS NOT ABLE TO SHUT COMPLETELY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE TRANSMISSION FAILED. UPON SHIFTING INTO GEAR, THE VEHICLE ACCELERATED ON ITS OWN EVEN WITH THE BRAKES APPLIED. THE VEHICLE WOULD THEN ENTER INTO FAIL SAFE MODE AND STALL. THE FAILURE WOULD RECUR UPON RESTART. THERE WERE NO LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION AND THEY STATED THAT THE FAILURE WAS DUE TO A THROTTLE BODY FAILURE. THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR WOULD NOT LATCH PROPERLY AFTER INCLEMENT WEATHER SUCH AS ICE, SNOW OR RAIN. THE CONTACT WOULD HOLD OPEN THE DOOR HANDLE AND SHOVE IT A FEW TIMES IN ORDER TO ENTER ON THE PASSENGER SIDE TO ENSURE THAT THE DOOR WOULD REMAIN SHUT WHILE OPERATING THE VEHICLE. THE DEALER ADVISED THE CONTACT THAT HER VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 74,000 AND THE FAILURE MILEAGE WAS 71,000.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT FAILED AND ALL OF THE GAUGES WERE INOPERABLE. IN ADDITION, THE REAR BACK UP SENSORS WERE BUZZING HAPHAZARDLY. THE CONTACT CHECKED ALL OF THE FUSES AND WAS UNABLE TO LOCATE A CAUSE FOR THE FAILURE. THE VEHICLE WAS NOT INSPECTED BY THE DEALER OR A MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 1/27/12 *CN UPDATED 02/01/12

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHENEVER IT WOULD RAIN OR SNOW, WATER PENETRATED THE REAR DOOR DRIVER'S SIDE CAUSING ELECTRICAL AND STRUCTURAL FAILURES. THE VEHICLE WAS TAKEN O A LOCAL MECHANIC WHO INSPECTED THE VEHICLE AND WAS UNABLE TO LOCATE THE AREA WHERE THE WATER WAS PENETRATING THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE 112,000.

CARS ENTERS INTO FAILSAFE MODE AND ENGINE CUTS OUT. I HAVE BEEN ALMOST REAR- ENDED THREE TIMES SINCE FIRST OCCURRENCE AND ONE TIME ALMOST T-BONED. SLUGGISH ACCELERATION WHEN TAKING OFF MAY OCCUR ALSO. I HAVE NOTICED THIS HAS BEEN A COMMON PROBLEM WITH THIS MODEL AND THE FAULTY THROTTLE BODY HAS SINCE BEEN REDESIGNED BY FORD. THEY SHOULD RECALL THIS AS IT IS A SAFETY HAZARD. I KNOW THAT I WAS LUCKY TO HAVE NOT BEEN INJURED IN AN ACCIDENT DUE TO THIS FAULTY PART, BUT I AM SURE SOME HAVE NOT BEEN SO LUCKY. *TR

2005 FORD FIVE HUNDRED SEL 3.0L V6 AUTOMATIC 6 SPEED TRANSMISSION ACCELERATING ON INTERSTATE CAR SEVERELY HARD SHIFTED AND THEN RPMS FLARED LET OFF GAS AND CAR SLAMMED INTO A LOWER GEAR NOW CAR HARD SHIFTS IN DOWN GEARS AND RPMS GO UP CAR DOESN'T MOVE SOMETIMES WHILE ACCELERATING VERY SPORADIC AND DANGEROUS. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT ALL OF THE GAUGES ON THE INSTRUMENT PANEL FAILED TO FUNCTION AND THE REVERSE LIGHT WAS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WERE NO RECALLS FOR THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 109,102.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHT FAILED. THE CONTACT WAS UNABLE TO SEE THE MILES DRIVEN OR ANY OF THE OTHER COMPONENTS ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE INSTRUMENT PANEL DIGITAL SYSTEM. THE VEHICLE WAS REPAIRED. THE DEALER REPLACED THE ELECTRICAL INSTRUMENT PANEL DIGITAL SYSTEM. THE FAILURE AND THE CURRENT MILEAGE WAS 59,090.

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE WRENCH WARNING INDICATOR ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THE VACUUM OPERATIVE VALVE BEHIND THE THROTTLE BODY WAS REPLACED. THE FAILURE RECURRED AFTER THE REPAIRS. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 121,000.

FRONT DRIVER SIDE WHEEL STUDS SNAP. MECHANICS NOTE- FAULTY PARTS HE COULD NOT FIND ANY SIGNS OF OVER TIGHTENING FROM THE TIRE COMPANY WHICH REPLACED ALL FOUR TIRES OVER 1 YEAR AGO. *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THE TIRE JACK THAT CAME EQUIPPED WITH THE VEHICLE FAILED. THE JACK COLLAPSED WHILE IN USE, CAUSING THE VEHICLE TO FALL. THERE WAS NO PERSONAL INJURY. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

SIMILAR ISSUE AS IN PE07058. INSTRUMENT CLUSTER FAILS FOR EXTENDED PERIODS. IN THIS TIME I HAVE NO INSTRUMENTATION AVAILABLE, SPEED, RPM, FUEL, ETC. MULTIPLE WARNING LIGHTS ILLUMINATE, INCLUDING AIRBAG. ALL INTERIOR LIGHTING DIMS SIGNIFICANTLY. REVERSE LIGHTS ILLUMINATE EVEN WHILE IN PARK, OR DRIVING FORWARD. *TR

I UNFORTUNATELY OWN A 05 FORD FIVE HUNDRED WITH 95,784 MILES ON IT. THE PROBLEM STARTED HAPPENING ABOUT A YEAR AGO AND AT FIRST I THOUGHT THAT IT WAS MY FOOT HITTING THE GAS WHEN I PUT MY FOOT ON THE BRAKE. THEN I NOTICED WHEN I WOULD BUT IT IN GEAR IT WOULD TRY TO TAKE OFF ON IT'S OWN. I FINALLY HAD ENOUGH JUST LAST NIGHT I WAS IN A DRIVE THRU LINE AND I PUT IT IN DRIVE FROM NEUTRAL AND I CAME INCHES FROM REAR ENDED THE PERSON IN FRONT OF ME. TODAY I'M TAKING IT TO THE DEALERSHIP TO GET FIXED HOPEFULLY. NOT LOOKING FORWARD TO PAYING A $1000 DOLLARS FOR A COMMON PROBLEM. WELL FORD YOU LOST ME AS A BUYER. *TR

VEHICLE GOES INTO FAIL SAFE MODE AND LURCHES VIOLENTLY IN FORWARD AND REVERSE WITHOUT TOUCHING THE GAS PEDAL. STARTED AT 45,000 MILES INFREQUENTLY AND NOW OCCURS ABOUT 3 TIME A MONTH. I AM GOING TO REPLACE THE THROTTLE BODY TO SEE IF IT CORRECTS THE PROBLEM. *TR

WE BOUGHT MY CAR IN JULY 2011, ITS WAS GARAGED BY THE 1ST OWNER SO IT WAS LIKE BRAND NEW!! LOW MILES JUST 12,850 , START WHAT NOW SEEMS TO BE THE ENDLESS DRIVES IN A RENTAL CAR AND WITH EMPTY WALLETS TOTALING NOW APPROX; CLOSE TO AN ADDITIONAL $3,500 NOW IN REPAIRS FROM THE BATTERY IN AUG 2011 TO NOW TO HAVING THE THROTTLE BEING REPLACE ALONG WITH A SET IF TIRES AND THE 2ND SET OF BOTH REAR AND FRONT BRAKES IN LESS THEN A YEAR , ALL DUE TO THE CONSENT STOPPING AND GOING OF THE CAR BY HITTING THE BRAKES TOO MUCH AND HAVING TO ACCELERATE, BECAUSE THE CAR WOULD WHILE TEMPTING TO PULL OUT OF MY GARAGE AT WHAT SHOULD OF BEEN A MERE 3MILES PER HOUR; RESULTED IN FLYING BACKWARDS SUDDENLY WHILE FOOT WAS APPLYING PRESSURE ON THE BRAKES TO KEEP FROM MOWING DOWN MY TEENAGE SON AT 15 MILES A HOUR ON ITS OWN WITH THE MP RISING RAPIDLY , WAS THE SCARE OF MY LIFE!!!! PLEASE SOMEONE RECALL THIS CAR , BEFORE SOMEONE REALLY DOES GET KILLED OR HURT!!! AS OF TODAY THE TOTAL THIS TIME TO REPAIR MY CAR IS AT A TOTAL IF$ 1,585.00; TO REPLACE THE THROTTLE AND TIRES & BRAKES AGAIN, AND FORD WOULDN'T EVEN COMP, US A RENTAL CAR THIS TIME ON OUR 5 TRIP DOWN TO THE SERVICE DEPT OF FORD!!!! *TR

WHILE STOPPED AT A RED LIGHT, THE CAR STARTED TO JERK AND THE MOTOR RACED/IDLED UP HIGH. *TR

I OWN A 2005 FORD 500. THE CAR HAS STARTED LURCHING FORWARD ON ITS OWN. I HAVE BEEN READING FORUMS AND HUNDREDS OF OTHER PEOPLE ARE HAVING THE SAME PROBLEMS. THEY SAY IT IS THE THROTTLE BODY. FORD SHOULD HAVE A RECALL ON THE 500 .THE FORD FREESTYLE IS HAVING THE SAME PROBLEM. DO PEOPLE HAVE TO DIE OR BE RUN OVER BEFORE SOMETHING IS DONE. IT IS EXTREMELY SCARY WHEN MY CAR LURCHES FORWARD ON ITS OWN. HELP, PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT PANEL WOULD SHUT ON AND OFF INTERMITTENTLY WITHOUT WARNING. IN ADDITION, THE CHECK ENGINE AND AIR BAG WARNING LIGHTS WERE ILLUMINATED SPORADICALLY. SHE BELIEVED THAT THE ENTIRE ELECTRICAL SYSTEM WAS FAULTY SINCE A RECENT FAILURE OF THE ODOMETER READING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT MILEAGE WAS 42,000 AND THE FAILURE MILEAGE WAS 41,500.

ON 7/27/11 CAR LUNGED FORWARD AND ACCELERATED PAST NORMAL DRIVING SPEED. CAR HAS BEEN DOING THIS (LUNGING) SINCE I PURCHASED THE VEHICLE BACK IN 2008, BUT HAS BEEN ACCELERATING ON ITS OWN FOR THE PAST 2 MONTHS. I HAVE HAD THE CAR LOOKED AT BY A MECHANIC AND IT WAS DIAGNOSED WITH A THROTTLE BODY DEFECT. *TR

THE VEHICLE HAS RPM SURGES AT LOW SPEEDS EITHER IN REVERSE OR FORWARD. I NEARLY HAD 3-4 ACCIDENTS IN 2 DAYS BECAUSE OF THE ISSUE. THE VEHICLE WILL ACTUALLY INCREASE UP TO 1000 RPMS BY ITSELF WHILE I HAVE MY FOOT ON THE BRAKE. AS SOON AS I BEGIN TO RELEASE PRESSURE OFF THE BRAKE WHILE TRYING TO PARK OR NEGOTIATE THE VEHICLE AT VERY LOW SPEEDS THE ENGINE WILL JUST TAKE OFF. THE FIRST TIME I NOTICED IT I WAS BACKING OUT OF A PARKING SPACE AND THE VEHICLE TOOK OFF BACKWARD CAUSING ME TO HAVE TO SLAM THE BRAKES ON. I ALMOST HIT A WOMAN WHO WAS PASSING ON THE OTHER SIDE OF THE LANE. *KB

CAR HAS A PROBLEM WITH THROTTLEBODY THAT CAUSES SAFETY CONCERNS WITH STOPPING THE CAR. CAR LUNGES FORWARD CAUSING NEAR ACCIDENTS AS A RESULT OF THIS COMMON ISSUE. THIS PROBLEM IS REFERENCED BY MANY PEOPLE AT THE FOLLOWING LOCATION WHICH EXPLAINS FURTHER THE ISSUE AND WHY THIS NEEDS TO BE A RECALL: HTTP://WWW.FORDTAURUS.NET/FORUMS/VIEWTOPIC.PHP?F=5&T=9366. *TR

I HAVE THE WRENCH LIGHT UP ON THE DASH BOARD AND IT SAID ENGINE FAILSAFE MODE IN THE MESSAGE CENTRE? THIS STARTED HAPPENING TO ME A FEW WEEKS AGO FROM TIME TO TIME. NO WARNING, I JUST ACCELERATE FROM A RED LIGHT AND I NOTICE I HAVE NO POWER, I LOOK DOWN AND SURE ENOUGH - WRENCH IS LIT AND ENGINE FAILSAFE MODE. I PULL OVER, TURN THE CAR OFF FOR A FEW MINUTES AND THEN THE PROBLEM IS GONE WHEN I START AGAIN. I COULDN'T FIND ANY SPECIFIC INFO ON WHAT IS CAUSING THIS AROUND THE 'NET - AND EVEN THE MANUAL SAYS, IF IT IS PERSISTS, TAKE IT TO THE DEALER. IT HAPPENED A FEW MORE TIMES, BUT THIS TIME IT SEEMED THE RPM'S WERE REVVING WITHOUT MY FOOT ON THE ACCELERATOR. I HAD MY FOOT ON THE BRAKE SO NOTHING HAPPENED, BUT DID IT A FEW TIMES, SO I BROUGHT IT TO THE DEALER LAST WEEK. THEY RAN SOME DIAGNOSTICS AND ULTIMATELY SAID THEY REPAIRED A VACUUM HOSE AT MY AIRBOX. OK, SURE, WHATEVER. NEXT TWO DAYS, NO PROBLEM. THE THIRD DAY, HAPPENED AGAIN. THIS TIME, I WAS GOING INTO AN UNDERGROUND PARKING SPOT AND IT STARTED REVVING AND I ENDED UP (VERY LIGHTLY) HITTING THE WALL AS IT LURCHED FORWARD. WHEN I WENT TO LEAVE THE SPOT - IN REVERSE - HAPPENED AGAIN - ALMOST HIT THE PARKED CAR BEHIND, AS IT LURCHED. SO TOOK IT TO THE DEALER THIS MORNING - AND THE SERVICE ADVISOR MENTIONED HE SUSPECTS THE THROTTLEBODY AS HE HAS HAD SOME OTHER 500'S IN FOR THE SAME THING. NO IDEA WHY, BUT THE COMPUTER DIDN'T HAVE A CODE FOR THE THROTTLEBODY PROBLEM LAST TIME - BUT IT DID THIS TIME, SO AS I WRITE THIS, THEY ARE PUTTING THE NEW ONE ON AND I'LL BE THERE IN AN HOUR TO PICK IT UP. *TR

WE HAVE A 2005 FORD FIVE HUNDRED. TWO DAYS AGO, THE CAR FAILED TO RESPOND WHEN THE ACCELERATOR WAS PRESSED, EVEN AS IT WAS PRESSED TO THE FLOOR. THE WRENCH LIGHT CAME ON AND THE CAR STARTED LUNGING AND HESITATING IN ADDITION TO NOT ACCELERATING PROPERLY. THIS OCCURRED WHILE DRIVING THROUGH A VERY BUSY INTERSECTION; THANKFULLY, I WAS ABLE TO MOVE THE CAR WITH MY TWO SMALL CHILDREN OUT OF TRAFFIC. A DIAGNOSTIC COMPUTER PROVIDED TWO CODES - P2106 AND P061B. THIS IS NOT THE FIRST TIME THE CAR HAS LUNGED; IT HAS BEEN DOING THIS FOR APPROXIMATELY 1.5 YEARS. IT HAS REPEATED THIS SEVERAL TIMES IN BOTH DRIVE AND REVERSE. IN MOST INSTANCES, THE AIR CONDITIONER WAS RUNNING AT THE SAME TIME; HOWEVER, THE CAR HAS LUNGED WHEN THE A/C WAS NOT ON. THE LUNGING OCCURS WHEN THE CAR IS BEING DRIVEN OR SITTING IDLE (I.E., STOP LIGHTS, PREPARING TO MERGE INTO TRAFFIC). I HAVE BEEN ABLE TO AVOID ACCIDENTS BY KEEPING MY FOOT FIRMLY ON THE BRAKE AND BY CREATING A LARGE STOPPING DISTANCE CUSHION. WE CONTACTED THE DEALER AND WERE TOLD THE ENTIRE THROTTLE BODY WOULD NEED REPLACED, AT A COST OF OVER $530.00. WE ARE NOW REVIEWING OUR OPTIONS. *TR

BACKING OUT OF THE DRIVEWAY IN A 2005 FORD 500 AWD, CAR STUMBLES THEN LAUNCHED BACKWARD VIOLENTLY. LUCKILY I HAD MY FOOT ON THE BRAKE OR THE CAR WOULD HAVE KEPT GOING. "FAILSAFE ENGINE MODE" APPEARS ON THE DASHBOARD. THIS HAS HAPPENED SEVERAL TIMES BEFORE. SHOULD BE A RECALL ON THIS CAR. *KB

THIS HAS HAPPENED MULTIPLE TIMES (MEANING MORE THAN 5 TIMES) DURING THE SUMMER OF 2011. DRIVING ON HIGHWAY AT POSTED SPEED LIMITS AND CAR SUDDENLY LURCHES THEN DROPS INTO FAILSAFE MODE (AS INDENTIFIED BY ALERT POSTED ON THE DASH). PULL OVER, READ OWNER'S MANUAL. FOLLOW DIRECTIONS HOW TO CLEAR FAILSAFE AND IMPLEMENT THEM. A FEW TIMES IT WORKED FOR SHORT PERIODS OF TIME. OTHER TIMES, IT WOULD NOT WORK AT ALL. TWICE THE CAR WAS RUNNING AT APPROXIMATELY 65 MPH AND SUDDENLY GO INTO FAILSAFE MODE THEN STALL OUT. ESPECIALLY DURING STREET/CITY DRIVING, CAR SUDDENLY KICKS FORWARD THEN FAILSAFE AND WILL SOMETIMES STALL OUT IN MIDDLE OF STREET. UNABLE TO RESTART. LAST TIME THIS OCCURRED CAR REQUIRED TOWING TO LOCAL FORD DEALER. INITIALLY SAID IT WAS THE THROTTLE SENOR FOR A COST OF $300. WHEN I OK'D THAT REPAIR, THE DEALERSHIP CALLED BACK LATER AND STATED IT WAS THE ENTIRE THROTTLE BODY AND REPAIR WOULD COME AT A COST OF $1000. THE CAR NOW SITS IN MY DRIVEWAY WHERE IT WAS TOWED TO AND SITS FOR SAFETY REASONS. AFTER RESEARCHING THE INTERNET, I HAVE COME TO FIND THAT THIS IS A COMMON OCCURRENCE WITH FORD AND AN ANNOUNCED RECALL SHOULD BE IMPLEMENTED IMMEDIATELY. *KB

THROTTLE BODY BAD ALL MOST HAD WRECK CAR WOULD NOT GO JUST IDLED. *KB

THE VEHICLE IN QUESTION WAS IDLING IN PARK. VEHICLE WAS SHIFTED INTO REVERSE WITH THE FOOT ON THE BRAKE. ONCE FOOT WAS RELEASED FROM THE BRAKE THE CAR LUNGED BACKWARD, THE TACHOMETER READ ABOUT 3000 RPM, WITH NO PRESSURE ON THE GAS PEDAL. JUST AS QUICKLY PRESSURE WAS APPLIED TO THE BRAKE AND THE CAR ENTERED "ENGINE FAILSAFE MODE" AND SHUT DOWN. TURNING THE VEHICLE OFF AND RESTARTING WOULD CLEAR THE PROBLEM. THIS HAS HAPPENED 4 MORE TIMES SINCE THE REPORTED INCIDENT DATE, ALL WITH THE SAME CIRCUMSTANCES. THE VEHICLE HAD THE A/C ON AND WAS IDLING IN APPROXIMATELY 90 DEGREE FAHRENHEIT TEMPERATURES WITH +50% RELATIVE HUMIDITY. *KB

FAILSAFE ENGINE LIGHT WENT ON, I PULLED OVER AND CAR BEGAN ACCELERATION ON IT'S OWN WHILE IN STOP POSITION... *TR

2005 FORD 500 , AC COMPRESSOR STOPPED WORKING AT 63,000 MILES , NEEDS TO BE REPLACED , LOOKING ONLINE AND LOT OF FORD 500 OWNERS HAVE THE SAME PROBLEM WITH LOW MILES. *TR