2012 Ford Fusion Electrical System Problems

The contact owns a 2012 Ford Fusion. The contact stated that the A/C unit failed to operate as needed, causing the cabin of the vehicle to become hot while driving. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the evaporator temperature sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 143,000.

Brakes failed while driving. Finally stopped after multiple attempts after pressing brakes to the floor. ABS, advancetrac, and ABS lights came up on dash while this was occurring (not prior). Dealer reproduced /confirmed concern. ABS module fix of $2750. Luckily I was driving slowly and no other cars, people, or animals were in the vicinity; otherwise, this could have resulted in injury/deaths.

The contact owns a 2012 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle started to shake without warning. The contact then stated that she attempted to operate the A/C unit, when she heard an abnormal sound inside the unit. The contact also stated that the unit failed to dispense cool air. Additionally, the contact stated that after the accelerator pedal was depressed, the vehicle hesitated to respond for five seconds. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that due to an unknown electrical failure, the A/C compressor needed to be replaced. The dealer was notified of the failure and the contact was advised to bring the vehicle in for diagnostic test. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage as approximately 120,000.

The contact owns a 2012 Ford Fusion. The contact stated that on several occasions, the instrument panel warning lights randomly illuminated and then failed. The contact then stated that when the instrument panel failed, the turn signals failed to operate. The contact then stated that the air conditioning unit failed and blew out heat. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 89,544.

AC does not work, the climate control module is the problem. when you switch the AC on it only blows heat. The fix would be a new climate control module.

Started car and began to back out of parking space. There had been a few drops of rain, but it wasn't actively raining at the time. Brake went to floor when driver went to slow down. Numerous dashboard lights and messages came on, including ABS, Traction Control, Traction Control Off, and "Service ADVANCETRAC" message. Driver stopped car with handbrake and shut car off. Tried several times to restart vehicle over the next 30 minutes, but lights remained on and brake remained soft. Finally restarted car and brake was normal, but lights remained on. All lights went on and car returned to normal when put in drive gear. This has happened about five times to two different drivers over the past 18 months. All but one time in rain, and twice while driving at 35 mph or so. We will plan to scrap or trade in the vehicle. Vehicle has been checked out by both an independent mechanic and Richmond Ford West, with no issues identified when examined.

Driving down the road when my car suddenly started to decelerate. It would not allow me to go any faster when pressing the gas. I had to pull over put my hazard lights on as cars were coming up on me. I pulled over turned my car off and waiting a few seconds, turned it back on and it was fine. However, I looked up what it could be and found the electronic throttle body could be the cause. Why hasn’t mine been fixed if Ford new about this. I’ve been in an had my oil change and my air bag recall and nobody has mentioned any of that.

2012 FORD FUSION. CONSUMER WRITES IN REGARDS TO VARIOUS ELECTRICAL ISSUES WITH VEHICLE. THE CONSUMER STATED THE VEHICLE EXPERIENCED SEVERAL ELECTRONIC ISSUES. THE CONSUMER STATED THE ISSUES INCLUDED THE SOUND SYSTEM, WINDOWS, THROTTLE SYSTEM, POWER STEERING, TRACTION CONTROL. THE AIRBAG INDICATOR WOULD FLASH. THE CONSUMER EXPRESSED DISSATISFACTION WITH THE CONSOLE DASHOBOARD FEATURES AND ACCESSIBILITY OF CLOCK CONTROLS.

On October 5th, 2021 around 6:20am, the brakes on my 2012 Ford Fusion Hybrid failed to slow the car in any way. This event occurred while I was on the highway (M14) going ~65mph. Unable to conventionally stop, I was a crash hazard to those around me, and to the braking traffic in front of me. After being inspected by the Varsity Ford Dealership, I was told "the brake control unit is not actuating the valves in the hydraulic control unit" and that "there is a possibility that it will also need the hydraulic control unit as well." It has been at the dealership for the past 2 weeks and is available for inspection. There were no warning messages or signs prior to the brake failing. I received a warning sign at the point of failure, but by then I already knew the brakes did not work.

TAIL LIGHT SOCKET MELTED AND BURNED. NOTICED BLINKER AND PASSENGER SIDE BRAKE LIGHT WERE NOT WORKING. PULLED OUT OF HOUSING AND SAW THE SOCKET WAS BURNT AND THE BULB WAS MELTED IN THE SOCKET.

DEFROST/AC/VENTS BLOW OUT HOT AIR REGARDLESS OF SETTINGS...FOUND THIS TO BE A VERY COMMON ISSUE ONLINE AND AN EXPENSIVE PERMANENT FIX...VENTS/DEFROST/AC MAY BE TRICKED INTO WORKING IF LIGHTS ARE TURNED ON BEFORE STARTING (THINKS IT'S NIGHTTIME OR COVER UP LIGHT SENSOR ON DASH)

THE AIR CONDITIONER FAN BLOWER MOTOR FREEZES UP UNTIL IT EVENTUALLY STOPS WORKING. IT IS DOING IT AGAIN FOR THE 6TH TIME. I HAVE HAD TO REPLACE IT EVERY 1-2 YEARS.

I WAS GETTING GAS AND I CUT MY CAR OFF WHEN I GOT BACK INTO MY CAR IT DID NOT START. I CONTINUED TO START IT. CAR WOULD NOT START. I POPPED THE HOOD AND TOUCHED THE BATTERY SOME AND TRIED STARTING THE CAR THE CAR STARTED THEN ABOUT 5 MINUTES AFTER DRIVING IT SUDDENLY CUTS OFF. THIS IS A ONGOING ISSUE. CAR SUDDENLY STOPS IN THE MIDDLE OF STREET ALMOST CAUSING ACCIDENTS THAT CAN NEARLY KILL SOMEONE!!! VERY UNSAFE AND EXTREMELY DANGEROUS. THIS HAPPENED ON HIGHWAY AND STREET. AND ITS SO RANDOM NO SIGNS JUST CUTS OFF AT ANY SPEED.

MY DRIVER'S SIDE ELECTRIC DOOR LOCK AND INSIDE HANDLE WILL NOT OPEN DOOR. MUST PUT WINDOW DOWN AND REACH OUT SIDE TO OPEN DOOR. VERY APPREHENSIVE BECAUSE SOMETIMES I HAVE TO REPEAT THE UNLOCKING PROCESS BEFORE I CAN LET MYSELF OUT OF THE CAR. AT THE TIME OF THE INCIDENT, I HAD BEEN DRIVING AND THEN PARKED AT A BUSINESS PLACE. WHEN I ATTEMPTED TO UNLOCK THE DOOR AND TO OUT, I HEARD A CLICK BUT THE HANDLE WOULD NOT RELEASE.

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WAS DIFFICULT TO START. THE VEHICLE WAS TOWED TO FRANKLIN FORD (175 E CENTRAL ST, FRANKLIN, MA 02038 508-570-4022) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WIRING UNDER THE DASHBOARD HAD A CORRODED SOLDER POINT. THE CONTACT STATED THAT THERE WAS A SHORT CIRCUIT IN THE WIRING HARNESS. THE CONTACT STATED THAT SEVERAL REPAIRS WERE PERFORMED AT A COST OF $3,000 HOWEVER, FAILED TO FIX THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

DRIVING LIKE NORMAL UNDER NORMAL CONDITIONS. THE RADIO SHUTS OFF, CHIMES DING LIKE IT DOES ON START UP, TURN SIGNALS DO NOT WORK, HORN DOES NOT WORK, AND CLIMATE CONTROLS DO NOT WORK. CAR IS STILL UNDER POWER, AND IT LASTS ANYWHERE FROM A FEW SECONDS TO ABOUT A MINUTE, THEN COMES BACK ON. IT DOES NOT MATTER IF I'M IN CITY TRAFFIC OR ON THE INTERSTATE, WET OR DRY, HOT OR COLD, OR SMOOTH OR BUMPY ROAD SURFACE.

THE GEAR SHIFT LIGHT ON THE DASH BOARD STAYS ON AND IT'S MAKING MY CAR GO DEAD. I HAVE TO KEEP GETTING A JUMP EVERYDAY. IT IN PARK NO KEY IN THE IGNITION AND DOORS LOCKED.ITS MAKING A LOUD NOISE

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE FUSE RELAY ASSEMBLY AND WIRING HARNESS FAILED AND NEEDED REPLACEMENT. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED ONE OTHER TIME. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,422.

I OWN A 2012 FORD FUSION SE 6 CYLINDER THIS VEHICLE HAS A MAJOR SAFETY HAZARD. MY PASSENGER SIDE RTAIL LIGHT CONTINUES TO BLOW AND THE MOST RECENT INCIDENT OCCURRED LAST WEEK WHEN I NOTICED A BURNING SMELL. I HAVE BEEN REPLACING THIS TAIL LIGHT EVERY SIX MONTHS FOR THE PAST TWO YEARS AND IT HAS CAUSED MELTING AROUND THE LIGHT SOCKET AND THE BULB IS CLEARLY BURNT. AFTER GOOGLING THIS ISSUE I HAVE SEEN NUMEROUS COMPLAINTS ABOUT THE SAME ISSUE WITH THE 2012 FORD FUSION AND A RECALL NEEDS TO BE ISSUED IMMEDIATELY OR I AM GOING TO THE PUBLIC. THIS CAN KILL SOMEONE AND START A FIRE ESPECIALLY IF THE BLAZE GETS OUT OF HAND AND CHILDREN ARE IN THE BACKSEAT STRAPPED IN. PLEASE EMAIL ME [XXX] REGARDING IF YOU ARE HAVING A SIMILAR CONCERN SO I CAN COMPILE THIS AND GO PUBLIC BECAUSE THEY HAVE RECEIVED SEVERAL COMPLAINTS AND NOT DONE ANYTHING TO REMEDY THIS ISSUE. THIS IS CLEARLY AN ELECTRICAL ISSUE AND FORD AND THE NTHSA NEED TO STEP IT UP AND SAVE LIVES BEFORE IT'S TOO LATE. HERE ARE LINKS TO SIMILAR ISSUES HTTP://WWW.FIXYA.COM/CARS/T16277316-2012_FORD_FUSION_REAR_TURN_SIGNAL_STILL HTTP://M.CARCOMPLAINTS.COM/FORD/FUSION/2012/LIGHTS/EXTERIOR_LIGHTING.SHTML HTTP://WWW.CARPROBLEMZOO.COM/FORD/FUSION/TAIL-LIGHT-SWITCH-PROBLEMS.PHP INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

I HAVE BEEN HAVING ELECTRICAL PROBLEMS SINCE I PURCHASED THE CAR IN 2012. CURRENTLY, MY HORN DOES NOT WORK AS WELL AS OTHER ELECTRICAL COMPONENTS OF MY CAR. ANOTHER EXAMPLE, WOULD BE MY SEAT BELT, WHICH HAS BEEN AN ONGOING ISSUE.THE SERVICE PROVIDER AT FORD TOLD ME TO LET MY CAR RUN A LITTLE,. AND THEN IT WOULD WORK. SO FAR, STILL HAVING THE SAME ISSUE. AT THIS TIME, WITH MY HORN NOT WORKING, IT IS A SAFETY ISSUE, AS I HAVE ALMOST GOTTEN INTO 3 ACCIDENTS THUS FAR, I HAVE CONTACTED THE FORD CEO AND KAREN JOHNSON, ANOTHER EXECUTIVE OF FORD AND HAVE NOT HEARD ANYTHING FROM EITHER ONE OF THEM. I NEED MY CAR FIXED AS ALL THESE ISSUES ARE SAFETY RELATED AND EACH DAY THAT I DRIVE WITH THE CONCERNS, PUT MYSELF AND MY FAMILY IN DANGER.