2017 Ford Fusion Complaint Log

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 77,000.

See attached document for complaint.

MY 2017 Ford FUSION 2.0 Eco COULD HAVE CAUGHT ON FIRE WITH MY 6 YEAR OLD INSIDE!! I went to start my car & it didn’t want to turn over. Turned car off. Tried again. Started up but sputtered manically..then “kind of” settled down. I was maybe 2 miles down the road && COOLANT TEMP HIGH light turned on. I pulled over immediately turned car off. Checked coolant levels….it was BELOW minimum (NO VISIBLE LEAKS) replaced coolant, car started smoother. 2 days later. I started my car it was a little rough && as I began driving I could see what looked like white smoke coming from exhaust. I looked for a safe place to quickly pull over and the COOLANT TEMP HIGH light dinged on again. I checked levels…again BELOW minimum..this is 2 days AFTER I refilled the coolant….once again there are no visible leaks on the ground. It is the weekend so have NOT made it to dealership. Myself & my 6 year old daughter were in the car && THE ENGINE COULD HAVE BLOWN or caught fire!! This is absolutely unacceptable && unsafe. This is unsafe to the people around me && on the road due to the smoke of the car, possible flames, && sudden STOP. This is BEYOND dangerous. I’m positive after researching that this is coolant intrusion in the engine. I was never informed of this possible issue by Ford. I am a single mother, with one vehicle, this should not be MY BILL especially since I’ve maintained the maintenance on this vehicle regularly. I will be taking my Fusion to the Ford Dealership Monday where I hope Ford will cover this issue. (( I can update later if needed ))

My car developed a miss in the engine that continued to get worse. It was inspected at the dealership, Key Scales Ford, in Leesburg, Florida. The check engine light was on and the car showed a code of PO303, misfire in #3 cylinder. It was determined that there was a crack in the block and coolant was entering #3 cylinder. The approximate costs to replace the engine were over $10,000 and the car had a trade-in value of approximately $9,000 so repair out of my pocket was not a smart option. Through research of my own I learned of NHTSA action which had led to a Ford Technical Service Bulletin TSB 21-2134. I contacted the Ford Customer Satisfaction Program and was told my VIN was not included under the TSB, even though it had the exact same problem. Ford refused to participate in any type of resolution despite this being a well-known problem with the 1.5-liter Ecoboost engines. This type of engine failure could lead to being stranded at any time so driving the car further was not a good idea. There was 55,912 miles on this car and the original brake pads outlived the engine. These engines are known to be defective and a problem.

The contact owns a 2017 Ford Fusion. The contact stated while accelerating from a stop, the vehicle stalled with the check engine warning light and several other unknown warning lights illuminated. The vehicle was restarted on the third attempt; however, the failure recurred. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was 156,782.

My car is experiencing the issue noted in Technical Service Bulletin 22-2229 (09-June-2022). My car leaks engine coolant into the engine/cylinders causing an excessive draining of coolant, overheating the engine, and shutting off the car. Specifically, my engine overheated and shut off, making the car undriveable. I was forced off the road on a single lane highway with speed limits of 55mph. This occurred at [XXX] on Friday, [XXX]. The area where the care came to rest was not particularly safe due to the narrow roads and high speed limit. The check engine light came on when this issue became a problem. My car was inspected by Bull Valley Ford in Woodstock, IL. They diagnosed that the issue is indeed the same issue in TSB 22-2229. The quoted price to repair is $7,000.00. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The shifter cable bushing that other cars in my year got recalled for is going out. It’s having the same problem that the recalled cars are having but my vin doesn’t fall under it for some reason.

The vehicle experienced engine failure due to engine coolant intruding into the cylinders. This was formally diagnosed by a Ford Dealership service team after the vehicle broke down on the side of the highway. This is the exact issue outlined in TSB #22-2229. The check engine light was activated indicating there was an issue. I filled up the coolant basin with a gallon of the manufacturer recommended coolant, and within 6 days, all the coolant was gone and the engine shut down when I was driving at approximately 50mph. Ford Corporate will not lend any financial assistance for the repairs, which is a complete engine replacement. This replacement costs between $7,000-$10,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 65 MPH, the vehicle was losing motive power. The contact depressed the accelerator pedal, and the RPM gauge was rising but the vehicle failed to respond as needed. The contact stated that there was no warning light illuminated. The contact pulled over and stopped the vehicle. The contact turned off and restarted the vehicle; however, the vehicle had not regained normal functionality. The vehicle was towed to a dealer to be diagnosed. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 105,000.

The contact owns a 2017 Ford Fusion. The contact stated while starting the vehicle and shifting into drive(D), the gear shifter knob shifted back into park(p) independently. The message "Shift System Fault" was displayed. The contact stated while inspecting the vehicle, the contact noticed that the shift linkage bushing had separated. The contact manually adjusted the cable bushings in order to drive; however, the failure persisted. The dealer was contacted and informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact the NHTSA Hotline for assistance. The failure mileage was approximately 180,000.

While driving on the highway at 60MPH, the check engine light came on first, then got an overheating issue. Let car cool, then drove city streets and took car to an independent auto repair shop. They read the engine and it had error code P0304. Shop bore scoped into cylinder 4 and found engine coolant. Took to dealer to confirm, they did find that engine coolant was leaking into cylinder 4 and recommended replacing engine long block assembly for $9.25k.

Driving on a highway engine began to shake and lose power engine had no problems prior to this all oil changes were up to date. After Engine began shaking violently pulled over on side of road no check engine light was present. Had vehicle towed where even when engine was on no check engine light. After checking the codes with ob2 reader it was determined a cylinder 1 and 2 misfire was present I replaced spark plugs and coil packs and that did not resolve the issue. It was then towed to a repair shop where they confirmed there was catastrophic engine failure including metal in the enigne there were no warning signs that this could happen the dealer and ford have been 0 help except wanting 12,000 to replace the engine

Was out of town when I went to shift out of Park, and I received a SHIFT SYSTEM FAULT - SERVICE REQUIRED MESSAGE. My car was stuck in reverse and could only shift into neutral. The shift cable bushing had dry rotted and snapped. This item was recalled on previous fusions up to the 2016 model year, yet the same part was used through the 2020 model year. ALL of these items need to be recalled. They are all defective.

The contact owns a 2017 Ford Fusion. The contact stated that after starting the vehicle and shifting into drive(D), the accelerator was depressed; however, the vehicle hesitated before responding as needed. The contact stated that the vehicle only hesitated while accelerating. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 17V427000 (Power Train); however, the VIN was not included. The manufacturer was informed of the failure. The failure mileage was approximately 89,000.

The engine light came on. Brought it to have it checked. They said it was a mechanical issue. Drive it from Connecticut to South Carolina. Light came back on and went to three different mechanics. Last one said the engines on this model are defective. Brought it to Ford they said I can put in a new engine for $9,600.00. It has engine coolant leaking into the engine. Spark plug has melted into the engine and can’t be removed. The car has 65,000 miles on it. The car should have a 200,000 mile life.

The contact owns a 2017 Ford Fusion. The contact stated that occasionally the "Coolant Level Low" message was displayed and after starting the vehicle and driving at various speeds, there was thick white smoke coming from the exhaust. The contact decided to replace the head gasket and discovered that the engine block was cracked. The contact researched and became aware that the failure might be caused by coolant intrusion into the engine. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall related to the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 58,000.

#4 cylinder has fouled 3 spark plugs in the last 5 months. Car sputters at start, anti-freeze is missing bit no visible leak, blue smoke from exhaust. Took to dealer for diagnostic and was told engine rebuild/replace is needed and was quoted cost of $7465. My car is just over 91k miles and my extended warranty expired in March of this year.

The bushing that attaches the shifter cable to the transmission may degraded and detached. Similar issue that was on recall for the 2013-2016 Ford Fusion.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that coolant was leaking into the cylinder and that the engine needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 60,000.

2.0l EcoBoost engine illuminated malfunction indicator light (MIL) diagnostic trouble code indicates presence of coolant intrusion into one or more cylinders. defect causes corrosion, misfires, engine failure, and fires.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle briefly vibrated, and there was excessive white smoke coming from the exhaust. The contact stated that the message "Low Coolant Level" was displayed, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the spark plugs. The vehicle was repaired, but the failure reoccurred. The vehicle was then taken to the dealer, who diagnosed a failure with the fuel injectors. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, and the contact was informed there was a misfire in cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

Shaking of the vehicle and resistant to accelerate on so dangerous to drive especially on highways. Check engine light on. Both independent service center and Ford dealership confirmed spark plugs are damaged, leaking oil, need new engine and this is a known issue with this ford engine.

I have a 2017 ford fusion with a 2.0 ecoboost engine. First, I received service engine soon message on my car which was diagnosed as a misfire. Following that, a few days later, my car overheated on the way to my work. I checked the coolant which was low and added more. There had been no signs of leaking under the car at any time. I was able to drive the car home but by the time I got home the coolant was again very low. I had it towed to a Ford dealership where I was given the catastrophic news that it was due to coolant intrusion and I need a whole new engine that will cost 9,000.00 after folloeing the TSB. I have approximately 60,000 miles on it and Ford has refused to help in any way. I have had the oil changed as recommended since I bought the car used from a Ford dealership as certified pre-owned with approximately 14,000 on it and was never made aware of any coolant intrusion problems. Researching this issue, I find that this is a common and very serious problem. If the engine were to overheat it could cause loss of power and more concerning, an engine fire. If the engine caught fire I worry if I could get 2 toddlers out of their car seats in the back in time. This is a serious safety issue. If I lost power on the freeway due to overheating would we be rear ended endangering all of our lives? Ford has acknowledged this engine has a design flaw and have recalled the 1.5L engines and certain other 2.0 for the exact problem. This sets a precedent, and all these engines with this problem should be recalled and the engine replaced. The symptoms and end result are all the same. My car is still sitting at the dealership since I do not have any way to come up with 9,000. Nor can I drive it.

The contact owns a 2017 Ford Fusion. The contact stated while the vehicle was parked, the contact connected the battery to the charger and the dead cell warning light illuminated. In addition, the contact stated that the battery failed to charge. The contact stated that even though the vehicle was not started, the gear shifter independently switched from park and reverse. The contact stated when the vehicle started, the vehicle rolled backwards several feet. The contact stated that the failure almost caused him to be pinned up against the wall of the garage, where the vehicle was parked. The contact stated that he used the parking brake to stop the vehicle from moving. The vehicle was towed to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 33,500.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at approximately 35 MPH, the check engine warning light was illuminated. The contact drove the vehicle to a local dealer who diagnosed the vehicle and determined that coolant had leaked into the cylinders. The dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to Technical Service Bulletin: 19-2346 Coolant Intrusion into the Cylinders (Engine and Engine Cooling). The failure mileage was approximately 70,000.

The contact owns a 2017 Ford Fusion. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that unknown gaskets had malfunctioned, causing fluids to leak into the engine. The engine was currently being replaced. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 75,000.

My 2017 Ford Fusion started with a grumble, saw white smoke exhaust. Drove about 6 miles turned off car, restarted the car and the engine light came on. Brought the car a week later to Dons Ford, they diagnosed a coil issue caused the engine light being on. Roughly a $700.00 repair. Few days later engine light came back on. Took it back to the dealer, they said they probably didn't reset the computer, so the computer thinks it still has a problem. They checked and rechecked my issue. This car has been a gem, 69,000 miles. Bought the car because I buy American made, my son worked in Detroit for Ford. Engine light came back on about 5 days later. Diagnoses, you need a new engine. $9,000. They say my car can catch on fire, but the dealer said I can drive it. There is more I could say but that's for a different agency.

Engine coolant leaks into the cylinder block due to a manufacturing defect. Car needs a new engine.

COOLANT ISSUE CAUSED ENGINE OVERHEAT WHICH LEAD TO CYLINDER MISFIRE AND ENGINE FAILURE

Transmission went out , 2017 fusion had recall with something with transmission never got notice from

The coolant leaked into the engine. The dealership said it needs a new engine. I had no problems with the car until all of a sudden the overheat light came on. Regular maintenance has been done. The car is in great condition. Less than 72,000 miles.

The contact owns a 2017 Ford Fusion. The contact stated that while cold starting the vehicle, the vehicle was shaking, vibrating, and idling roughly. The contact turned off and restarted the vehicle to reset the computer. The contact stated that the failure was intermittent but had become a recurring failure. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was coolant intrusion into the cylinders and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 61,000.

The contact owns a 2017 Ford Fusion. The contact stated that the check engine warning light was illuminated intermittently while driving. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders. The dealer determined that the long block engine assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving 60 MPH, he noticed white smoke coming from the rear of the vehicle. The check engine and coolant warning lights illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed that coolant was leaking into cylinder #3 and that the engine would need to be inspected. The vehicle was not repaired. The manufacturer was notified and provided the contact with the recall number, and opened a case. The contact was relating to the failure of Technical Service Bulletin: 22-2134 (Low Coolant, White Exhaust Smoke And/or Illuminated); however, the VIN was not included in the bulletin. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 122,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated to respond and made an abnormally loud sound. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed; however, the failure persisted while driving. The contact stated that the following day, she noticed that oil was leaking from the vehicle onto the ground. The vehicle was taken to the dealer, where it was confirmed that the oil change was performed correctly. The dealer diagnosed that oil was leaking from the transmission. The dealer informed the contact that the transmission needed to be taken apart to determine the source of the leak. The dealer advised the contact to trade the vehicle in due to the significant cost of labor. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 175,000.

The engine on this vehicle needs to be replaced due to coolant intrusion into the cylinders. On my engine diagnosis I get Error Code #P0302 which indicates Cylinder 2 misfire detected. My vehicle overheats quickly, runs rough and the coolant reservoir is dry. The vehicle's exhaust blows out a lot of white-ish smoke with a sickening odor. I took my vehicle to my local Auto Nation Ford of Bellevue, WA service department. They told me it is what they have seen on a lot of Ford Eco-Boost engines and there was a recall on these for engine replacement but my 2017 vehicle falls out of the recall. They told me I need a new engine replaced in this vehicle to the cost of about $10,000. Auto Nation Ford Bellevue, WA's service department referenced service bulletin #22-2229 (Some 2015-2018 Edge and 2017-2019 Fusion/MKZ/Escape/MKC vehicles equipped with a 2.0L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or a runs rough condition with or without an illuminated malfunction indicator lamp (MIL). Diagnostic trouble codes (DTCs) may include P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into the cylinder. To correct the condition, follow the Service Procedure to replace the long block engine assembly.). There were no warnings or dashboard lights except when my coolant gauge rose suddenly while driving on the road. I have dutifully maintained my vehicle with regular checkups so I don't believe I am at fault for this problem. I believe the Ford Motor Company should have informed me of this chronic problem but they didn't. I also believe my 2017 Fusion should be repaired with the cost going to the Ford Motor Company for a known defect. What do I do now please?

I drove through a strip mall shopping center on 8/13/2024, without warning, my 2017 Ford Fusion's engine shut down and I could not re-start the engine. There was no "Check Engine" light. The shutdown later proved to be caused by the failed Mas Air Flow (MAF) sensor, Ford Part #Part #: AFLS195 (8V2Z12B579A). My understanding is that the MAF sensor sends data to the Powertrain Control Module (PCM) to deliver the specific amount of fuel that’s proportional to the airflow and without that information, the engine just stops. I read, the MAF sensor failure shutdown occurs in vehicles of many makes. I was in a shopping center when the engine shut down, leaving me stranded in the traffic, but minutes before I was in 45 MPH speed limit traffic on a main multi-lane thoroughfare. Had the engine shut down had occurred then. I may have been in a dangerous situation. In fact, an Auto Zone general information article on MAF failure stated, "These issues can create dangerous situations causing accidents and injury." There needs to be a fail safe that, when the sensor fails, like for example that causes the PCM to default value that does not cause a shutdown while activating the "check engine light."

The contact owns a 2017 Ford Fusion. The contact stated while shifting from park(P) to drive(D), the vehicle failed to respond. The contact stated that the vehicle responded as needed after the second attempt. The power train warning light was illuminated. The contact stated that the failure recurred while shifting to drive(D) and to reverse(R) in a drive-thru. The contact stated that the vehicle was undrivable. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the transmission shifter cable bushing had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to an unknown recall. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 98,500.

My brakes are faulty sometimes I’m not able to stop like I should. I also have transmission problems. When I put the car into reverse or drive I hear a loud boom. It is getting worse by the day. I see that the transmission is on a recall as well.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle started running abnormally rough, after which the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the spark plugs and ignition coils, resulting in an engine misfire. The vehicle was repaired; however, the failure reoccurred. The contact stated that later, while driving at an undisclosed speed, the engine started overheating, after which there was a burning odor inside the interior of the vehicle, prompting the contact to pull over to the shoulder of the roadway to turn the vehicle off. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed with head gasket failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 19-2375. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 85,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal sound and vibrated. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with a coolant leak into the engine, and it was determined that the short block needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 98,526.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer where the vehicle was diagnosed and determined that there was coolant leaking into the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 125,000.

While driving my Ford Fusion on the highway at a constant speed of 65 mph, a service light appeared on the dashboard, and the car suddenly lost power to the wheels even though the engine was still running. Fortunately, I was able to pull over to the side of the road safely since there wasn't much traffic at the time. However, had this been a busy road, it could have caused a major accident. I turned off the car and restarted it. However, the problem still persisted, and the car would not shift gears (it has an automatic transmission with a center console shifter dial). I had my car towed to my Ford dealer, and they determined that the transmission had failed. The Ford service manager stated that the transmissions on this particular era Ford Fusion were poorly designed and that many of their customers needed to replace their transmissions on this model as well as several models of the Ford Explorer from the same time period. The vehicle ran perfectly fine for many years previously. Just before the transmission failed (perhaps about 20-50 miles worth of driving before it failed), I had experience several instances of the car having trouble shift out of neutral into drive and reverse, often with a delay in shifting and a slight jolt, which was barely noticeable, when it did shift. I had brought the car to the dealer, and they weren't able to find any problems and said that it worked fine. There were no error codes generated to indicate that there was a problem either. My vehicle is only a little over 5000 miles beyond its 60,000 mile warranty, and the service manager stated that he tells owners that owners "are lucky if they their car makes it to 70,000 miles before the transmission fails". Given that there were few symptoms (which I believe would go unnoticed by most drivers) of a potential failure, the sudden loss of power to the wheels, and that this is a known common issue by Ford, this is major safety issue that must be addressed.

2017 Ford Fusion (87,000 miles): Check engine light was illuminated. Visited independent garage next day. approx $700 repairs did not fix the issue. Light came on a second time the following week. Took back to independent garage and was told it was a historical alert and not an active alert. Alert cleared. several days later the light came on again. Called to make dealer appointment. While waiting for the appointment, the overheating warning message came on. Stopped at the dealer who topped off coolant. 3 days later with almost no driving in between, dealer diagnosed Coolant Leak, misfire cylinder #2 - similar to information available online - coolant almost empty. All vehicle maintenance and 4 previous recalls properly maintained for vehicle. No known recall notice related to the Ford Fusion Coolant Leak known issues. Cost of repair quoted at $9,000 to replace engine. car not drivable and will take a month to repair. vehicle not repaired yet. I don't understand why my vehicle wasn't recalled if it's a known issue for this model.

Coolant was leaking into the Engine. This is a known issue with this make and model of the Ford Fusion, yet not all the engines were recalled. Ford told us this was a known issue, but we received no notification of this being a potential issue. We have taken our vehicle to Ford since we bought it new in 2017, and nothing was ever said. Now that the engine has the issue that is part of the recall, Ford would not take any responsibility for it and refused to help pay for the repairs. If the engine is doing exactly what the recall was for, then Ford should be held responsible for the repairs.

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact had taken the vehicle to an auto parts store where it was diagnosed and determined that the spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was driven to an independent mechanic who diagnosed the vehicle and determined that there was coolant intrusion into the engine block, and that the engine needed to be replaced. The contact had the vehicle towed to another independent mechanic who confirmed that the engine needed to be replaced. The mechanic advised the contact that the failure was related to Customer Satisfaction Program: 21N12 Coolant Intrusion Into the Short Block (Engine and Engine Cooling). The contact was advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 82,000.

The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was parked on several occasions, the check engine warning light illuminated. Additionally, the contact stated that while driving at various speeds, the check engine warning light illuminated intermittently. The vehicle was taken to the dealer where it was diagnosed and determined that the engine needed to be replaced due to a coolant intrusion into cylinder #1. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 76,000.

My car has been diagnosed with the known engine coolant leak issue with the 2.0L engines in the 2013-2018 Ford Fusions. It just now today, 8/1/2024, threw up a check engine light and I went to an ASE certified technician and they diagnosed it to be the same problem Ford has covered in their own technical service bulletins.

The contact owns a 2017 Ford Fusion. The contact stated while driving 50 MPH and making a left turn, the power steering failed to function as intended. The contact stated that the steering wheel had seized and became difficult to maneuver. The vehicle was taken to the dealer where it was diagnosed with rack and pinon failure. The contact was informed that the rack and pinion needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 69,236.

Coolant consumption through the engine due to faulty long block assembly. TSB has been issued but no recall. Ford motor company has known of this issue since at least December 19th 2019. TSB 19-2346