2022 Ford Mustang Mach-E

When starting car the instrument cluster was entirely blank. Center infotainment was functional. Due to use of digital dash in the car there were no warning lights or any information including speed available. It is unknown if any safety/driver assist systems were on or off because the display was non-functional. Issue resolved after performing 1 or more software resets documented across the internet but not documented in the manual. Steps to reset appear to be: 1) Perform a hard reset of the car (hold brake 15 sec, release brake 15 sec, press start without bake). 2) Allow car to fully reset and then turn off. 3) Move far enough away from car to trigger locks and put car into low power mode. 4) Return to car and power on. Hard reset did not provide immediate fix. Sync soft reset did not work.

Parking brake malfunction indicated. Ford CSP 22P31 covers repair of the issue for vehichles with a manufacture date before 3/15/22. My vehicle reached the US on 6/22/22. Ford has offered to cover a small part of the repair, but won't include me in the fix due to manufacture date. So Ford ended the program, NEVER FIXED THE ISSUE, and now won't offer to repair my car.

Vehicle shutdown while driving causing total power loss and hitting a parked vehicle. No alerts or notifications were present at the time.

On Tuesday, [XXX], between approximately [XXX] and [XXX] PM EST, I parked my Mustang Mach-E, powered the vehicle off, and exited the car with my wife and child. After unloading groceries and sports equipment, I retrieved the Level 2 charger from the front of my garage and plugged it into the vehicle. I waited for the blue indicator lights to turn solid and blink, confirming charging had started, which typically takes about one minute. I believe the vehicle had been parked and powered off for approximately 10 minutes when I entered the house. Shortly thereafter, I heard an unusual clicking noise and observed the charging cable strike the side of the garage door opening. The vehicle had rolled backward approximately six feet, twisting and pulling the Level 2 charging unit off the joist it was mounted to and damaging the vehicle’s front charging port as the cable stopped the vehicle from rolling into the street. This incident occurred less than one week after the vehicle was returned from service for a “Parking Brake Fault – Service Now” error that was repaired at Losco Ford in Fenton, Michigan. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car gave an error in the middle of the trip and displayed 'Stop Safely Now'. Will not start and run after this warning. The extended battery was fully charged before the trip and after 100 miles of driving it showed this message with 54% battery left.

Vehicle: 2022 Ford Mustang Mach-E Mileage at failure: ~36,800 miles Complaint Description: The left rear electronic parking brake (EPB) wiring harness/connector failed, resulting in a parking brake fault and abnormal braking behavior. This component is not a wear-and-tear item and is located in a fixed, protected area of the vehicle. It is not subject to routine maintenance or driver interaction. The failed wiring harness was inspected by an authorized Ford dealership and is available for further inspection upon request. This failure put safety at risk because the electronic parking brake is a safety-critical braking system. The fault created uncertainty regarding proper engagement and release of the parking brake, increasing the risk of unintended vehicle movement when parked and reduced confidence in braking reliability while driving. The problem was confirmed and diagnosed by a Ford dealership, which determined the wiring failure developed over time due to moisture intrusion and corrosion, not misuse, accident damage, or normal wear. The vehicle and component were inspected by an authorized Ford dealership. Ford Motor Company reviewed the repair documentation through Ford Customer Care but did not dispute the diagnosis. The component has not been inspected by police or insurance representatives. A parking brake fault warning message appeared shortly before diagnosis, accompanied by abnormal braking behavior. There were no prior accidents, vehicle modifications, or external damage related to the failure. This failure is identical to a known defect already acknowledged by Ford in Customer Satisfaction Program 22P31, which covers EPB wiring harness connector failures on other 2021–2022 Mustang Mach-E vehicles. Although my VIN was excluded, the same non-wear safety defect occurred within the same model year, indicating a broader safety concern beyond the original VIN population.

File against: Ford Motor Company Vehicle: 2022 Ford Mustang Mach-E VIN: [XXX] Safety Complaint While driving, the vehicle unexpectedly slowed down, lost power, and became inoperable, creating a serious safety hazard. I was able to pull over safely, but the sudden loss of motive power occurred during active roadway conditions. Dealer diagnosis identified a wiring harness connector failure affecting communication between vehicle control modules. After the repair, the same issue reoccurred within one to two days, again causing loss of power. The vehicle is currently back at the dealership, and the underlying defect has not yet been permanently resolved. This recurring electrical failure represents a loss-of-motive-power safety risk that may indicate a broader wiring harness defect affecting vehicle reliability and safety. Thanks and Regards INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was backing up the car and the car raced on it own at least couple of times. Luckily no-one was injured. I am worried about the safety of my family including a newborn. There was a Recall 22S29 for the mach-e but it seems to have not fixed the issue for my car.

Passenger front door stopped opening from the outside. there is no power going to the door at all. There are alert codes appearing on the dashboard "passenger door ajar" "door fault. service required" I have taken it to Ford multiple times over the last 1 year, starting Dec 2024, for a fix and they are unable to find a solution. they attempted replacing physical parts with no success. There were no warning signs before this happened. One day i went to close my front passenger door and it would not open back up. This presented as a safety risk to me when I was being followed by a stranger, with my infant with me. I got in the car and pressed the lock button, but the stranger was still able to open my door. luckily I was able to drive away fast enough. however. because the door was seen as ajar, the car will not lock. this is a major safety issue when I cannot secure my vehicle to keep me and my child safe!

I brought my car to ford stanford for recall work and they didnt do it. Tried to charge me first even thought it was under warranty. Battery recall

I have a 2022 Mustang Mach-E GT and have now experienced two (2) High Voltage Battery Junction Box (HVJB) failures. First failure was in July 2023 when the vehicle had approximately 12,000 miles. I received the stop safely now message. Vehicle codes displayed via the Ford app showed a High Voltage Battery Warning and Power train Malfunction / Reduced Power warnings. I have now received this same failure and warnings again. The car currently has 54,000 miles and I was just advised by my dealer that the HVJB has failed a second time. My concern is that the replacement voltage boxes are nothing more than a Band-aid for the problem and not a permanent solution. As I prepare to receive by 3rd HVJB, I feel this is nothing more than a temporary fix until I receive another Stop Safely Now message while operating my vehicle. Please look into the HVJB failure rate for these vehicles. I am in online two Mustang Mach-E owners groups and this issue is rampant among owners. I feel this issue requires outside attention as Ford has now had 4 years to solve this issue for early produced Mach Es. Yet the issue continues to exist. Thank you for your attention in the matter.

The contact owns a 2022 Ford Mustang Mach-E. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The messages "Stop Safely Now", "Service Advancetrac", "Overdrive Off", and "Pre-Collision Indicator Off" were displayed. The contact pulled over and parked the vehicle. The vehicle failed to restart, and the 12-volt battery was drained. The vehicle was towed to the residence. The vehicle was later towed to the dealer, who determined that the high-voltage battery contactor needed to be replaced. The dealer performed the recall repair under NHTSA Campaign Number: 22V412000 (Electrical System); however, the failure persisted. The vehicle was not repaired and remained with the dealer. The manufacturer was made aware of the failure, and two cases were filed. The failure mileage was 104,442.

My wife was driving on the parkway when her Mustang Mach-E started flashing multiple warning messages on the HUD. The vehicle suddenly died with no power. She was in a center lane of traffic in a 6-lane section. The vehicle did not let her put the car into neutral to push it out of the way. When they tried to get back into the car they found that it would not open and after she and the police officer who stopped searched Google and YouTube, they learned that there is no way to manually open the vehicle with no power. This was confirmed by the dealership.

I was waiting in a drive thru behind a line of cars at a full stop for some time, so I was using One Pedal assist/Auto Hold. My car suddenly accelerated and slammed into the car in front of me.

The Adaptive Cruise Control indicated speed lags when user changes speed. The lag will fluctuate from non-existent to 4-5sec at times. It occurs at different speeds and for different changes (e.g., speeding up to 45mph or speeding down to 25mph.) It also occurs when changing speeds in different increments (e.g., one click up for 1mph increase or hold down for 5mph decrease.) The lag is only in the display and not the actual drivetrain, meaning that the selected speed in the Adaptive Control indicator is not relaying the selected speed even though the car itself is changing speed. This is a safety issue as you don't know whether the car has registered a speed increase or decrease for several seconds (which at higher speeds is certainly not safe.) There was an OTA related to the Instrument Control Panel sent earlier this summer that was successfully installed, IPC-25.7.46, however this may be a coincidence. After calling multiple times to Ford, including their OTA update team, their EV Technology Team, and a generic Customer Experience team, I was told to bring it into a dealership AND submit a complaint to NHTSA. The dealership identified modules that required updating but that did not fix the issue. Ford has NOT been helpful and their Customer Experience reps have been dismissive of the seriousness of this issue.

I was driving my car when all of a sudden it lost all acceleration and power, I was lucky that I wasn't on the highway anymore and was able to pull over safely on a side street while car was rolling still. Dealer said 12V battery fused, and I have been reading forums where this is a common issue.. In a normal ICE car when 12V battery dies while driving, car can still drive, in this case, it just stops and pops up a dozen errors about everything being broken.

Vehicle Information: •Make: Ford •Model: Mach-E •Model Year: 2022 •Vehicle Type: Electric SUV •VIN: [XXX] •Mileage at time of incident: 31114 •Purchased in: California Incident Date: [XXX] Location: Laguna Niguel, CA Injury: Yes Crash: Yes Fire: No Airbags Deployed: No Police Report Filed: Yes Description of Complaint: On or around [XXX], I was driving my 2022 Ford Mach-E when the steering wheel suddenly locked and the braking system failed completely. I lost all control of the vehicle and was unable to slow or steer the car, leading to a crash. Despite the severity of the incident, the airbags did not deploy. At the time, I did not have obvious injuries, but shortly afterward, I began to experience severe pain and physical impairment, including an inability to stand or walk without difficulty. These symptoms have worsened and are now impacting my daily life. The vehicle is now completely inoperable and appears to have suffered a critical system malfunction, possibly involving its electric or software control systems. There were no warning lights or indicators before the failure. I believe this is a serious safety defect in the Ford Mach-E and could pose a danger to other drivers. I am requesting that the NHTSA investigate whether this is part of a broader pattern of defects affecting Ford’s EV line and take action to prevent further injuries or fatalities. Contact Information: •Name: [XXX] •Phone: [XXX] •Email: [XXX] •Preferred contact method: email INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ford Mustang Mach E. The contact received notification of NHTSA Campaign Number: 25V404000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and advised the contact that the part to do the recall might be available by the end of 2025. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The recall has no estimated repair date: the initial notification was June 16th. This has passed a reasonable amount of time, with no repair but a "we think we might fix it around the 3rd quarter of 2025" - definitely not satisfying the law. Tesla already had one death from entrapment post accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2022 Ford Mustang Mach-E has experienced a complete failure of the front passenger door latch. The electronic latch (e-latch) button does not light up or respond, and the door remains fully open and cannot be latched or secured. This occurred without any damage or external cause. I’ve been informed that this issue requires full latch replacement at my expense, totaling over $760. I’m also aware of a pending recall (25S65) related to 12V discharge and door latch functionality, but I’ve been told my vehicle is not currently covered — even though the symptoms appear directly related. This is a safety-critical failure because the door cannot be secured while driving, creating a serious risk of passenger ejection in motion. This issue appears to be common among early Mach-E models and should be formally investigated.