2002 Ford Ranger Complaint Log

Steel rim came apart while adding air to tire causing severe injuries to hands leg and foot only 20 psi in tire pressure when rim blew apart !

Extreme rusting of the entire frame and underside steel components. Attachments are rusting to the point of failure and falling off the vehicle.

The contact owns a 2002 Ford Ranger. The contact stated while driving approximately 40 MPH and attempting to switch lanes, the accelerator pedal was depressed but the vehicle failed to accelerate as needed. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The local dealer was not contacted. The vehicle was taken to three separate independent mechanics to be diagnosed. After each diagnostic test, the contact was informed that the rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 180,000.

The contact owns a 2002 Ford Ranger. The contact stated while driving 30 MPH, the air bag warning light was illuminated. Neither the dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA. The failure mileage was approximately 50,000.

Rear shake bracket rusted off

TRUCK FAILED NH SAFETY INSPECTION 4/10/2021 DUE TO BADLY RUSTED FRAME.

2002 FORD RANGER. CONSUMER WRITES IN REGARDS TO FRAME ON RANGER VEHICLE. *LD *JS

WHILE PULLING UP TO A SECURITY GATE WHEN I APPLIED THE BRAKES THE VEHICLE ACCELERATED. AND I RAN INTO THE GATE. I COULD NOT STOP. DON'T KNOW WHY THIS HAPPENED

RECENTLY MY TRUCK UNINTENTIONALLY ACCELERATED AS I WAS BACKING UP IN DRIVEWAY CAUSING AN ACCIDENT. WHEN I PICKED UP TRUCK AFTER COLLISION REPAIR, IT SUDDENLY ACCELERATED ON HIGHWAY CAUSING IT TO FISH-TAIL OUR OF CONTROL AND NEARLY CAUSING ANOTHER ACCIDENT.

THE REAR STRAP THAT HOLDS THE FUEL TANK IS HANGING DOWN. ON CLOSER INSPECTION, THE MOUNT THAT IS CONNECTED/PART OF THE FRAME HAS COMPLETELY CORRODED AND IS NOW MISSING. I ONLY NOTICED THE PROBLEM WHEN THE "CHECK FUEL CAP" AND I STARTED TO TRY AND LOCATE THE PROBLEM.

THE FRAME HAS COMPLETELY RUSTED OUT. THE SPARE TIRE RUSTED OFF WHILE DRIVING. *TR

HARD FRONT END COLLISION WITH TELEPHONE POLE. ICE ON ROAD. TOTAL DAMAGE, VEHICLE STATUS IS SCRAP. DRIVER INJURY. HEAD AND JAW. AIR BAG DID NOT DEPLOY. THIS IS SECOND FRONT COLLISION. FIRST COLLISION, VEHICLE WAS REPAIRED. STRUCK BY WRONG WAY DRIVER. $3400 DAMAGE. AIR BAG DID NOT DEPLOY. REPAIRS AT FORD DEALER, ST. LOUIS , MO.

WE ARE ORIGINAL OWNERS OF A 2002 FORD RANGER XLT NOW WITH 57,000 HIGHWAY MILES, ALWAYS GARAGED/WASHED/MAINTAINED, LITTLE DRIVING IN WINTER (MOSTLY IN SUMMER), ALWAYS FORD MAINTAINED/SERVICED AT SAME DEALERSHIP, BODY/ENGINE/TRANSMISSION IN GREAT SHAPE, WILL LIKELY FAIL INSPECTION THIS SPING BECAUSE FRAME AND FRAME COMPONENTS ARE SEVERELY RUSTED OUT. - SEVERE RUST ON THE ENTIRE FRAME INCLUDING BOTH CROSS MEMBERS (ENGINE AND TRANSMISSION), ARM BOLT POINTS AND CONTROL ARMS. - FRAME ALSO HAS SEVERE RUST DOWN BOTH SIDES TO REAR BUMPER, REAR AXLE AND DIFFERENTAL, LEAF SPRINGS AND ALL MOUNTS. - THE PASSENGER SIDE STEARING KNUCKLE IS DELAMINATING. - ALL BRAKE LINES HAVE FAILED WHILE DRIVING: FIRST THE REAR BRAKES INCLUDING ALL AXLE COUPLINGS AND DRUM COUPLINGS; SECOND THE FRONT BRAKE LINES FAILED AT THE DISK BRAKES AND RUBBER COUPLINGS. ALL BRAKE TUBES HAD TO BE REPLACED FROM THE MASTER CYLINDER TO THE WHEELS. - SERVICE MANAGER IS WORRIED ABOUT FRONT CROSS MEMBER FAILING UNDER THE ENGINE, MIDDLE CROSS MEMBER FAILING UNDER THE TRANSMISSION AND THE GAS TANK BRACKETS/STRAPS. - THE FRAME AND MEMBERS AND MOUNTS MUST BE REPLACED; THE REST OF THE VEHICLE IS MECHANICALLY SOUND. SERVICE MANAGER SAID NO REPAIR WAS POSSIBLE TO FRAME RUST IS SO BAD PICTURES CAN BE PROVIDED AND/OR VEHICAL INSPECTED BY NHTSA IF DESIRED. ALL BRAKE LINES AND COUPLINGS PERFORMED AROUND AUGUST 29, 2019.

TRANSMISSION STUCK IN 4X4 LOW

DRIVING TO WORK REAR END LOCKED UP AND EXPLODED WHILE DRIVING. MY HEAD HIT THE STEERING WHEEL. THERE WAS A RECALL ON 2002 FORD RANGER FX2 AXLE BUT ONLY FOR MANUAL TRANSMISSION WHEN RESEARCH SHOWS IT DOES IT ON AUTOMATIC ONES TO. LOOKED UP RECALL DOCUMENTS AND SYMPTOMS AND EVERYTHING WAS THE EXACT SAME! I DO HAVE RECALL NUMBER 02S32. HAD TO BE TOWED HOME...

TL* THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING APPROXIMATELY 10-15 MPH, THE REAR DIFFERENTIAL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. EBY FORD LINCOLN (LOCATED AT 2714 ELKHART RD, GOSHEN, IN 46526, (574) 534-3673) WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V035000 (POWER TRAIN). THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. *TT CONSUMER STATED REAR END LOCKED UP AND BLEW HOLES THROUGH THE COVER AND DESTROYED IT. *JB

AT THE ANNUAL SAFETY INSPECTION IT WAS DETERMINED THAT THE REAR FRAME HAS BEEN PERFORATED BY RUST. I WAS INFORMED THAT THIS IS A COMMON PROBLEM DUE TO HOW THE FRAME IS SHAPED WHERE THE SPARE TIRE ATTACHES. AN OTHERWISE MECHANICALLY SOUND AND SOLID VEHICLE IS NO LONGER DRIVEABLE.

THE SEAT BELT ON THE DRIVER SIDE DOES NOT LOCK, AND AS A RESULT IT'S CAUSING THE AIRBAG LIGHT TO GO OFF AND IT FLASHES CODE NUMBER 46 AS FOR THE SEAT BELT TENSIONER.

REAR BUMPER AND SPARE TIRE HOLDER ROTTED OFF .. REAR SHACKLES ON BOTH SIDES.. GAS TANK STRAPS AND CROSSMEMBER THAT HOLDS IT UP... NOW THE FRAME HAS ROTTED IN HALF RIGHT IN MIDDLE OF TRUCK... SPARE TIRE FELL OFF WHILE DRIVING

THE VEHICLE OCCASIONALLY ROLLS AFTER BEING PUT IN PARK. TOLD THAT THE PARKING PAWL MAY BE DEFECTIVE CREATING A SAFETY HAZARD DUE TO THE VEHICLE ROLLING IN PARK.

FRONT FRAME SPRING POCKETS ARE CRACKED.MAIN FRAME NEAR TRANSMISSION MOUNT BRACKET CRACKING,BACK REAR FRAME SPARE TIRE MOUNT GONE..MATEL MISSING NO BACK BUMMER.BOTH MAIN FRAME UNDER CAB ARE RUSTED STARTING TO CRUMBLE .

FRAME IS RUSTING AWAY. FRONT COIL SPRING POCKETS CRACKING.FRAME NEAR FRONT CONTROL ARMS ARE RUSTED,AND CRACKING.BACK FRAME SPEAR TIRE BRACKET ARE GONE.FRAME RUSTED BACK LEAF SPRING SHACKELS NO MATEL FRAME FOR BACK BUMPER MOUNT.

TL* THE CONTACT OWNS A 2002 FORD RANGER. ON SEVERAL OCCASIONS, WHILE MAKING A TURN, THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE ALSO LOST POWER STEERING FUNCTIONALITY AND BRAKING ABILITY. USING AN OBD DIAGNOSTIC TOOL, THE CONTACT WAS UNABLE TO RETRIEVE A FAULT CODE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO ALLAN VIGIL FORD OF FAYETTEVILLE, INC (LOCATED AT 275 GLYNN ST N, FAYETTEVILLE, GA 30214, (770) 461-1151) WHERE IT WAS DIAGNOSED THAT THE PCM NEEDED TO BE FLASHED. THE VEHICLE WAS SERVICED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

REAR TIRE FELL OUT ONTO ROAD, ROTTED CARRIER , FRAME ROTTED AT AXLE, CRACKED IN HALF WHILE DRIVING ON HIGHWAY, REAR END SHIFTED, CAN KNOW LONGER DRIVE VEHICLE SAFELY, HAD TO BUY NEW TRUCK DAYS LATER! BODY IN GOOD SHAPE, FRAME TOTALLY ROTTED! SO MANY OTHER COMPLAINTS ABOUT SAME THING ON GOOGLE SEARCH. TOYOTA TOYOTA HAD SAME THING, WE CALLED ALL THEIR TRUCKS AND REPLACED ALL TRUCK F WE CALLED ALL THEIR TRUCKS AND REPLACED ALL TRUCK FRAMES FRAMES, STILL TO THIS DAY FORD HAS NOT RECOGNIZED A MAJOR PROBLEM WITH THEIR FRAMES!!! THESE VEHICLES ARE A MAJOR SAFETY HAZARD ON THE ROAD AND A RECALL NEEDS TO HAPPEN !!

CV JOINT PROBLEMS

FRAME HAS EXTENSIVE ROT RESULTING IN AN UNSTABLE HANDLING FEEL TO THE TRUCK WHILE DRIVING. ALSO THE LEAF SPRING MOUNTS ARE RUSTED THROUGH AND ABOUT TO FALL APART, I FEEL THE TRUCK IS NO LONGER SAFE TO DRIVE.

REAR SPRING HANGERS ROTTED AND FAILED AND BOTH SIDES OF FRAME RUSTED BAD..SPARE TIRE HOLDER RUSTED ROTTED AND BROKE LETTING SPARE TIRE AND REAR BUMPER TO DROP DOWN. I CAUGHT IT BEFORE IT MADE IT TO THE ROAD.WE WERE ON THE ROAD WHEN THE RIGHT HAND SIDE CAME DOWN.LEFT SIDE HAPPENED A YEAR BEFORE THE RIGHT SIDE[ESTIMATE].

EXCESSIVE RUST UNDERNEATH. LEAF SPRING HANGERS FAILED AT 11 YEARS/120K MILES. SPARE TIRE WINCH SEPARATED FROM TRUCK AT 14 YEARS/155K MILES. . AN EXHAUST MOUNT HAS RUSTED AWAY LEAVING THE EXHAUST SYSTEM MARGINALLY SUPPORTED - UNCERTAIN OF WHEN THIS HAPPENED. LOGGING THIS COMPLAINT DUE TO THE GAS TANK STRAP FAILURE. ONE GAS TANK STRAP SEPARATED FROM UNDERNEATH THE TRUCK BED APPROXIMATELY ONE MONTH AGO - AGE 14.5 YEARS, ~160K MILES. WITH THE SPARE TIRE, I NOTICED IT HANGING LOW (3 OF 4 FASTENERS HAD PULLED AWAY FROM THEIR MOUNTS), AND WITH LITTLE EFFORT, WAS ABLE TO HAVE IT FALL OFF. HAD THE REMAINING FASTENER FAILED ON THE HIGHWAY, OBVIOUSLY BAD THINGS COULD HAVE HAPPENED. WITH THE GAS TANK STRAP, LUCKILY IT SEPARATED FROM UNDERNEATH THE BED RATHER THAN FROM THE FRAME, AND I COULD HEAR IT RUBBING AGAINST THE DRIVE SHAFT. THE OTHER STRAP WAS ABLE TO CARRY THE ENTIRE WEIGHT UNTIL I WAS ABLE TO SECURE THE GAS TANK.

TRUCK EXHIBITED A 'CLUNK' NOISE FROM LEFT REAR WHEN TRAVERSING A BUMP IN THE ROAD. I TOOK IT TO THE DEALERSHIP WHERE I BOUGHT IT NEW AND HAVE HAD ALL MAINTENANCE AND REPAIR WORK DONE. SERVICE MANAGER SAID NO REPAIR WAS POSSIBLE'FRAME RUST WAS SO BAD A NEW LEAF SPRING, ETC. COULD NOT BE ATTACHED AND IT WAS UNSAFE TO DRIVE. SEE ATTACHED INVOICE. I HAD THE TRUCK TOWED TO MY HOME AND IT HAS NOT BEEN DRIVEN SINCE. (DATE OF OCCURRENCE IS APPROXIMATE. IT BECAME WORSE AS TIME WENT ON AND OCCURS AT ANY SPEED.)

I BOUGHT MY RANGER NEW, IT CURRENTLY HAS 232,000 MILES. FRAME RUST IS SO BAD IT IS UNSAFE TO DRIVE. REAR SPRING SHACKLE MOUNTS RUSTED AWAY, BED IS RESTING ON SPRINGS. RUST RAINS FROM UNDERNEATH WHEN HOOD IS ALLOWED TO CLOSE. BRAKE LINE MOUNTS ARE NEARLY GONE, AS IS GAS TANK STRAPS. I HAVE NEVER SEEN FRAME ROT THIS BAD, EVEN IN NORTHERN STATES WHERE ROAD SALT IS USED.

THE AIRBAGS FAILED TO DEPLOY IN A HEAD ON COLLISION TRAVELING 50 MPH

WAS PULLING INTO FRIENDS DRIVEWAY WHEN I HEARD A CRACKING NOISE WHEN I CHECKED THE LEFT REAR SPRING HANGER PULLED OUT OF THE RUSTED FRAME. I PULLED OFF THE BED OF THE TRUCK AND FOUND SEVERAL AREAS WHICH WERE SEVERELY RUSTED INCLUDING THE SPARE TIRE CARRIER AND THE STRAPS WHICH HOLD UP THE GAS TANK. I AM THE ORIGINAL OWNER OF THE VEHICLE AND HAVE LIVED IN PENNSYLVANIA THE WHOLE TIME.

MY WIFE AND I WERE DRIVING ON HWY 79FROM PALISTINE TX TO JACKSONVILLE TX THURSDAY 7/11/2016 WHEN WE NOTICED SMOKE COMING OUT FROM UNDER THE TRUCK WE PULLED OVER AND NOTICED FIRE UNDER THE HOOD I TRIED TO POOR WATER ON IT ALL IT DID WAS JUST GET WORSE AND OUR TRUCK ALL MY WORK TOOLS MY LIVELY HOOD BLEW UP.

TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,546.

THE TRUCK FRAME HAS MULTIPLE SPOTS OF SEVERE RUST THAT CAUSED IT TO SNAP IN 2 MAKING THE TRUCK UNSAFE TO DRIVE. ONE OF THE AREAS IS NEXT TO THE GAS TANK (WHERE IT SNAPPED) AND THE RUST DOES NOT AFFECT ANY OTHER SPOT AROUND THE FRAME IN THIS AREA. I WAS MAKING A WIDE RIGHT HAND TURN ON A HIGHWAY ON RAMP AND IT SNAPPED.

ENGINE ERROR CODE P303 DISPLAYED AND ENGINE MISSING ON THAT CYLINDER. FORD TSB 05-26-3 STATES HEAD REPLACEMENT NECESSARY TO CORRECT. THIS APPEARS TO BE A GENERIC ISSUE WITH THE 3.0 LITER VULCAN ENGINES,. CAR WILL NOT PASS EMISSIONS INSPECTION UNTIL THIS IS REPAIRED.

FRAME IS RUSTED OUT. JUST NOTICED DURING SERVICING VEHICLE.

WHILE SLOWLY BACKING UP THE THROTTLE UNEXPECTEDLY WENT TO WIDE OPEN THROWING GRAVEL, DIGGING HOLES AND LEAVING RUBBER BURN PATCHES. I WAS ABLE TO PUT IN NEUTRAL BEFORE HITTING A PARKED CAMPING TRAILER. LATER THE SAME DAY WHILE BACKING OUT OF A PARKING PLACE AT A BANK THE SAME THING OCCURRED BUT MY FOOT WAS ALREADY ON THE BRAKE AND I WAS ABLE TO STOP IT. WHEN I GOT HOME AND WAS PARKING IT HAPPENED AGAIN, IN REVERSE, ALMOST RAMMING THE GARAGE. I HAVE NOT DRIVEN IT SINCE THIS HAPPENED . FORD 2002 RANGER 4X4 AUTOMATIC TRANS.W

2002 FORD RANGER XLT, FAILED INSPECTION BECAUSE OF SEVERE RUST THAT DEVELOPED ON THE FRONT LEFT SUB FRAME, A ARM BOLT POINTS AND CONTROL ARM POINTS. THE EXTENT OF RUST IS SO SEVERE THAT THE MECHANIC DOESN'T BELIEVE THE VEHICLE CAN BE SALVAGED, BECAUSE THERE IS A NOTHING SOLID ENOUGH LEFT TO WELD A PATCH OR REPLACEMENT PIECE TO. THE TRUCK BODY IS IN PERFECT SHAPE NO OTHER RUST EXCEPT THE FRAME. THE DAMAGE WAS ONLY VISIBLE WHEN THE FACTORY FRONT SKID PLATE WAS REMOVED BY THE INSPECTING MECHANIC. THE TRUCKS FACTORY WARRANTY AT THE TIME OF DISCOVERY EXCEEDED THE TEN YEAR TIME LIMIT, BUT WAS STILL UNDER THE MILEAGE PORTION.

REAR LEAF SHACKLES REPLACED, ROTTED FROM FRAME, LAST AUG 2014 TO PASS INSPECTION. THIS WINTER 2014-2015, THE SPARE TIRE CARRIER FRAME ROTTED AND FELL FROM THE VEHICLE, INCLUDING THE SPARE TIRE. NOW, UPON INSPECTION OF THE BED APPEARING CROOKED, THE DRIVERS SIDE FRAME IN FRONT OF THE DRIVERS SIDE FRONT LEAF SPRING MOUNT IS TOTALLY ROTTED. THIS HAS CAUSED THE GAS TANK MOUNTS TO THE FRAME TO BREAK. IT HAS ALSO CAUSED THE BED TO TWIST AND THE ENTIRE REAR END OF THIS VEHICLE IS NOW ONLY SUPPORTED BY THE PASSENGER SIDE FRAME.

THE TIRE IS BF GOODRICH P245/75 R16 109S. I WAS UNABLE TO SELECT THE CORRECT TIRE ON DROP DOWN BOX. REPORT AS FOLLOWS. WHILE DRIVING ON I-74 I FELT A BIT OF A BUMP, AS IF I HAD RUN OVER SOMETHING. THE STEERING WHEEL SHIFTED IN MY HANDS THEN WENT SHARPLY INTO THE RIGHT LANE. THE TRUCK WAS OUT OF CONTROL. AS THE TRUCK WAS FLIPPING I SAW THE GUARDRAIL THROUGH A SIDE WINDOW, THE AIRBAGS HAD BEEN DEPLOYED BY THEN. THE TRUCK KEPT FLIPPING. THE TRUCK THEN LANDED ON THE DRIVERS SIDE DOOR AND SPUN SEVERAL TIMES, THEN FINALLY STOPPED. I WAS ABLE TO REMOVE MY SEAT BELT THEN STAND IN THE TRUCK. I WAS ABLE TO OPEN THE PASSENGER DOOR THAT WAS IN THE AIR, ABOUT 10 INCHES, ENOUGH TO LOOK OUT, SCREAM FOR HELP AND WAVE MY ARM. A MAN THEN PRIED THE DOOR OPEN ENOUGH FOR ME TO CLIMB THE TRUCK SEATS AND CONSOLE LIKE A LADDER THEN SQUEEZE OUT OF THE DOOR AND JUMP DOWN. AFTER EVALUATING THE TRUCK, THE TIRE TREAD HAD COME OFF OF THE TIRE, WHICH IS STILL ON THE TRUCK AND INFLATED.

TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE HAD NOT PASSED INSPECTION DUE TO RUSTING ON THE AXLE AND THE SUBFRAME ON THE FRONT DRIVER SIDE. THE CONTACT STATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT FRAME WAS UNABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. THE VIN WAS NOT AVAILABLE.

DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, LESS THAN 30 MPH AND MOSTLY WHEN GOING AROUND TURNS. STARTED ALMOST A YEAR AGO.

CANT COTROL CAR WANT TO LUNGE FORWARD OR STALL HARD TO DRIVE LIKE THIS I AM TOLD IT IS THE (ETB) ALSO DOOR WILL NOT STOP CHIMING

BRACKET FOR SPARE TIRE ROTTED, TIRE DROPPED OFF, NO CAR IN BACK OF ME, DIDN'T KNOW WHAT HAPPEN AT THE TIME, THAT HAPPENED 6 MONTH AFTER I BOUGHT IT, THE OTHER DAY THE FRAME CRACKED IN HALF. CAR DEALER SHIP SOLD TRUCK TO ME ROUGHLY 15 MONTH AGO TRUCK IS TOTALED. INSURANCE ADJUSTER SAID WHOLE FRAME AND UNDER CARRIAGE IS ROTTED? HELP. EXTERIOR OF TRUCK LOOKS BRAND NEW? HELP *TR

ENGINE EJECTED SPARK PLUG FROM CYLINDER NUMBER THREE. MECHANIC SAID IT IS A COMMON PROBLEM WITH FORD VEHICLES MANUFACTURED WITH AN ALUMINUM HEAD. I AM FORTUNATE THAT THIS OCCURRED WHILE ACCELERATING FROM A STOP SIGN AT ONLY 20MPH. AT HIGHER SPEEDS, THE MECHANIC SAID THE SPARK PLUG MAY HAVE EJECTED ITSELF STRAIGHT THROUGH THE HOOD AFTER WHICH, THE ENGINE OFTEN CATCHES FIRE BECAUSE OF THE GASOLINE SPURTING OUT OF THE CYLINDER. REPAIR INCLUDED A HELICOIL TAP KIT AND NEW SPARK PLUGS. THIS IS A VERY DANGEROUS DEFECT AND SHOULD BE ADDRESSED BY FORD AND ALL GOVERNMENT SAFETY AGENCIES. THIS TRUCK HAS VERY LOW MILEAGE FOR IT'S AGE AND HAS BEEN TAKEN VERY GOOD CARE OF. THERE IS NO REASON WHY THIS SHOULD HAVE HAPPENED OTHER THAN FAULTY DESIGN AND USE OF AN ALUMINUM HEAD. *TR

TL* THE CONTACT OWNS A 2002 FORD RANGER. WHILE DRIVING AT 35 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING AND THEN HESITATED TO REDUCE SPEED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 192,000.

I BOUGHT THIS TRUCK FROM A DEALERSHIP IN JAN 2010. TRUCK WAS IN GOOD SHAPE, HAD FRAME CHECK OUT BEFORE I BOUGHT IT AND LOOKED VERY GOOD. TRUCK HAD ONLY 48000 MILES ON IT. IN JAN OF 2015 THE TRUCK BED SAT A LITTLE CROOKED CHECK FRAME AND SEEN A CRACK ON FRAME 3' LONG BY FRONT SHACKLE. AT THAT TIME TRUCK ONLY HAS 94000 MILES ON IT. TOOK BED OFF AND FOUND MORE AREAS THAT WOULD NEED ADRESSING SOON. I TRIED TO KEEP TRUCK UNDER SIDE CLEAN DURING THE WINTER, I GUESS THE STUFF THE STATE USES ON THE ROAD WAS TO MUCH FOR THE TRUCK.

I RECENTLY CHECK THE UNDERSIDE OF THE VEHICLE AND FOUND OUT A MISSING SPARETIRE AND ALSO A VERY LOOSE REAR BUMPER AND THE CAUSE OF IT IS RUST, VERY BAD RUSTING ON THE FRAME, MOSTLY ON THE REAR END. *TR

MY SON WAS DRIVING HIS FORD RANGER XL 2002 WHEN DUE TO A PEDESTRIAN, THE CAR IN FRONT OF HIM SLAMMED ON THEIR BRAKES CAUSING MY SON TO REAR END THEM. SNOWY WEATHER WAS A FACTOR. THE BRAKES DIDN'T CATCH AS THEY SHOULD HAVE. HIS AIRBAGS BLEW UP, NOT DEPLOY- BLEW UP AND CAUGHT FIRE! THE STEERING WHEEL BLEW UP! EXTENSIVE DAMAGE OCCURRED TO THE STEERING COLUMN STEERING WHEEL AND DASHBOARD COMPONENTS. THE STARTER WENT OUT AND THE TRUCK WOULD NOT START. INSURANCE DEEMED THE TRUCK TOTALED. OBVIOUSLY THE AIRBAGS WERE DEFECTIVE!! WAS THERE A RECALL CONCERNING ANY OF THESE COMPONENTS THAT WE WERE NEVER INFORMED OF? WHAT COMPENSATION IS AVAILABLE TO US FOR THIS OBVIOUS MANUFACTURERS DEFECT?...UPDATED 02-03-15 *BF