1997 Ford Windstar Complaint Log

TL* THE CONTACT OWNS 1997 FORD WINDSTAR. THE CONTACT STATED WHILE TRAVELING 65 MPH THE REAR AXLE BEAM BECAME FRACTURED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. A PRIVATE MECHANIC STATED THAT THE REAR AXLE BEAM NEEDED TO BE REPLACED. THERE WERE NO REPAIRS MADE ON THE VEHICLE. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 1997 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE TRACK BAR DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO WOBBLE EXCESSIVELY. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT NOT TO DRIVE THE VEHICLE. THE FAILURE MILEAGE WAS 90,000. UPDATED 09/21/12*LJ THE VEHICLE WAS REPAIRED BY A LOCAL MECHANIC AT THE OWNER'S EXPENSE. THE DEALER WAS MADE AWARE OF FAILURES. UPDATED 09/26/2012 *JS

TL* THE CONTACT OWNS A 1997 FORD WINDSTAR. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE INSPECTED, HE WAS NOTIFIED THAT THE VEHICLE FAILED TO PASS THE STATE INSPECTION DUE TO THE SUB FRAME BEING COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SUB-FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

I PURCHASED A 1997 FORD WINDSTAR AND FROM WHAT I UNDERSTAND IS THAT THERE WAS A RECALL ON THE COIL SPRINGS/SUSPENSION. (RECALL#01I00700) < I BELIEVE THIS IS THE RECALL #. LONG STORY SHORT MY FRONT TIRES ARE FLAT DOUE TO THE COIL SPRINGS. NONE OF THE DEALERS I TOOK IT TO ARE WILLING TO FIX THIS. THEY SAY IT IS NOT COVERED UNDER ANY RECALL... PLEASE HELP ME BETTER UNDERSTAND WHY FORD WONT FIX THIS DEFECT. *TR

I TURNED THE AIR CONDITIONING ON IN THE VAN AND AFTER ABOUT 10 MINUTES, TURNED IT TO THE 'MAX AC' POSITION. THE HOOD STARTED STEAMING SO I TURNED THE AIR COMPLETELY OFF. AFTER LESS THAN A MINUTE, I NOTICED THE HOOD WAS SMOKING SO I PULLED TO THE SIDE OF THE ROAD IMMEDIATELY. I TURNED THE CAR OFF AND EXITED THE VAN AND SAW THAT THE PASSENGER SIDE OF THE HOOD WAS ON FIRE. I RAN TO THE PASSENGER SIDE AND OPENED THE SLIDING DOOR, AND GOT MY 18 MONTH OLD AND 4 YEAR OLD OUT OF THE VEHICLE. AFTER WE WERE ALL A SAFE DISTANCE AWAY I SAW THAT MOST OF THE HOOD OF THE VAN WAS IN FLAMES. BY THE TIME THE FIRE DEPARTMENT ARRIVED ABOUT 5 MINUTES LATER, THE ENTIRE HOOD WAS ON FIRE WITH A LOT OF BLACK SMOKE. THE ENTIRE ENGINE COMPARTMENT LOOKS CHARRED AND PARTIALLY MELTED. THE VEHICLE IS BEYOND REPAIR. I'M THANKFUL MY CHILDREN ARE SAFE BUT I AM VERY CONCERNED ABOUT THE SAFETY (FAILURE) OF THIS VEHICLE. *TR

I HAD MY 97 WINDSTAR FAN FIXED DUE TO RECALL # 09S09:SPEED CONTROL SYSTEM MODIFICATION. EVER SINCE THEN THE ABS AND PARKING LIGHTS HAVE BEEN COMING ON. WE HAVE HAD THE CODES RESET, BUT THEY KEEP APPEARING. I HAVE ALSO CALLED THE FORD DEALER WHERE THE REPAIR WAS DONE, BUT THEY SAY IT IS NOT COVERED IN THE RECALL TO CHECK THE SCDS, OR THAT IF IT WASN'T LEAKING THEN, THEY DID NOT HAVE TO REPLACE THAT PART. I AM VERY FRUSTRATED. *TR

MY WINDSTAR GL WOULDN'T START. I REPLACED THE RANGE SELECTOR SWITCH. WHEN I RESTARTED THE VEHICLE I FORGOT THE RECONNECT THE BRAKE PRESSURE SENSOR WIRING CONNECTOR AND THE ABS LIGHT CAME ON. I TRIED TO GET THE CODE CLEARED BUT NO-ONE COULD ACCESS THE CODE. I TOOK THE VAN TO THE DEALER FOR A RECALL NOTICE ON THE SPEED CONTROL SYSTEM AND HAD THEM LOOK INTO WHY THE ABS LIGHT WAS ON. I WAS TOLD THE ABS MODULE HAD QUIT AND NEEDED REPLACED. THE MODULE IS $1500.00 AND $300.00 TO INSTALL. THAT'S MORE THAN THE VAN IS WORTH. I SEARCHED ONLINE AND FOUND OUT MANY OTHER WINDSTAR OWNERS ARE HAVING THE SAME PROBLEMS. THE CRUISE CONTROL SYSTEM HAS ALSO QUIT AND THE DEALER REP. TELLS ME THAT THE CRUISE CONTROL ALSO GOES THROUGH THIS MODULE. WITH THE POSSIBILITY OF FIRE IT SEEMS RATHER IRRESPONSIBLE FOR FORD TO DO NOTHING MORE THAN INSTALL A FUSIBLE LINK AS A SAFETY MEASURE. I AM LOOKING INTO BUYING A USED MODULE TO REPAIR THE CRUISE AND ABS. THE FAILURE IS TOTAL. NEITHER THE CRUISE CONTROL OR THE ABS SYSTEM WORKS AT THIS TIME. *TR

ABS AND BRAKE LIGHT ON SAME TIME. NOTICE BRAKE FLUID LEAK. REFILL BRAKE FLUID OFTEN. SPEEDOMETER NEEDLE SWAYS ERRATICALLY FOR ABOUT 2 YEARS. CRUISE CONTROL INOPERABLE FOR 2 YEARS. *TR

NOTICED THAT I WAS LEAKING SOME BRAKE FLUID FOR THE LAST COUPLE OF MONTHS ON MY 1997 FORD WINDSTAR BUT VERY LITTLE AT THAT. ABOUT THE SAME TIME THE CRUISE CONTROL QUIT WORKING. ONE DAY WHILE DRIVING I NOTICED A LOT OF SMOKE COMING FROM UNDER THE HOOD. RAISED THE HOOD BUT THE SMOKE HAD QUIT. GOT BACK HOME AND NOTICED THIS AGAIN WHEN I WAS STOPPED IN THE DRIVEWAY. CHECKED UNDER THE HOOD AGAIN AND FOUND THAT THE CRUISE CONTROL DEACTIVATION SWITCH WAS SMOKING AND VERY HOT. WENT TO THE FORD DEALER TO CHECK IF THERE WAS A RECALL ON THIS AND THERE WAS NOT . INSTALLED THE REPLACEMENT PART WITH PLUG ADAPTOR AND THIS FIXED THE PROBLEM WITH SMOKING AND THE CRUISE STARTED WORKING AGAIN. NOTICED ON THE NET THIS SAME PART THAT IS IN MY WINDSTAR IS ALSO IN OTHER VEHICLES THAT HAS BEEN RECALLED. WHY IS THIS? THIS COULD HAVE EASILY CAUGHT FIRE AND BEEN A TOTAL LOSS TO THE VAN AND IF IT HAD BEEN PARKED IN THE GARAGE THE HOUSE ALSO. *TR

TL*THE CONTACT OWNS A 1997 FORD WINDSTAR. WHILE DRIVING 20 MPH THE PASSENGER SIDE TIRE EXPLODED CAUSING THE FRONT END TO HIT THE GROUND. THE CONTACT OBSERVED THAT THE FRONT COIL SPRING WAS BROKEN. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 132,000.

TL* THE CONTACT OWNS A 1997 FORD WINDSTAR. WHILE DRIVING AT 45 MPH THE POWER STEERING FAILED. THE FRONT SPRING FAILED AND PUNCTURED THE FRONT PASSENGER TIRE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT STATED THAT RECALL #01I007000: SUSPENSION:FRONT:SPRINGS:COIL SPRINGS WAS RELATED TO THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT THAT THE RECALL EXPIRED. THE CURRENT AND FAILURE MILEAGE WAS 142,000. *AK

OUR 1997 FORD WINDSTAR MINIVAN THAT IS CURRENTLY SUBJECTED TO THE RECALL FOR THE FAULTY CRUISE CONTROL SWITCH BURNED TO THE GROUND ON FEB 21, 2007 AS THE RESULT FROM A FIRE THAT STARTED IN THE ENGINE AREA. *TR

I HAVE 1997 FORD WINDSTAR. FEB. 1, 2007 I WAS GOING ABOUT 20 MPH, ANDPASSENGER FRONT SPRING SHATTERED. I HAD TO HAVE IT TOWED. MY MECHANIC SAUD I WAS LUCKY I WAS NOT ON THE EXPRESSWAY WHEN IT HAPPENED. I HAD IT FIXED, IT COST ME $1036.00. I CALLED FORD TO TRY AND GET REIMBURSED, AND THEY TOLD ME THAT I DID NOT HAVE IT REPAIRED AT A FORD DEALER. IF I HAD KNOWN THEY WERE BAD I WOULD HAVE. I NEVER RECEIVED ANY WARNING AT ALL. THEY DID NOT EVEN HAVE ME DOWN AS THE REGISTERED OWNER. HERE IS THE RECALL # 011007000, FRONT COIL SPRING CORROSION. THEY SAID IT COVERS FROM 1995-1998 WINDSTARS. HERE IS MY VIN. #2FMDA514VBD14446. ALL I WOULD LIKE IS TO GET SOME OF MY MONEY BACK, I LIVE ON $699. A MONTH, AND FOR THEM TO ADMIT I WAS COVERED. THEY ARE BEING REALLY NASTY ABOUT THIS. I WAS TOLD TO CALL BY FOX 6 IN MILWAUKEE, KATRINA CRAVY CONSUMER REPORTER. *AK

TL*- THE CONTACT WAS SITTING IN VAN , THE VEHICLE WAS TURNED OFF. THE VAN STATED TO FILL UP WITH SMOKE. AT WHICH POINT HE LOOKED AT THE DRIVER SEAT AND NOTICED THAT THE VAN WAS ON FIRE. THE HE PUT OUT THE INITIAL FIRE. WHEN HE LOOKED UNDER THE DRIVER SEAT HE NOTICED THERE WERE MORE FLAMES. THE NEXT DAY HE SAW THAT THERE WERE WIRES UNDER THE SEAT. HE WAS ABLE TO DRIVE THE VA WITH THE SEAT IS DAMAGED DUE TO THE FIRE. CONTACT DRIVE THE VAN HOME.

DT*: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED CONSTANTLY, AND THE OVERDRIVE LIGHT LOCATED ON THE GEARSHIFT ILLUMINATED INTERMITTENTLY. THIS WAS ACCOMPANIED BY A STRONG SMELL OF SOMETHING ELECTRICAL BURNING. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE IT WAS DETERMINED THAT THE SENSOR ON THE MASTER CYLINDER HAD CAUGHT ON FIRE, AND ALSO BURNED THE WIRING HARNESS BETWEEN THE MASTER CYLINDER AND THE TRANSMISSION. THE MECHANIC REPLACED THE SENSOR ON THE MASTER CYLINDER, ON THE TRANSMISSION, AND THE WIRING HARNESS, WHICH CORRECTED THE PROBLEM. THERE WAS A NHTSA RECALL # 05V388000, WHICH PERTAINS TO THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

DT*: THE CONTACT STATED, WHILE THE VEHICLE WAS IMMOBILE WITH THE ENGINE RUNNING, SMOKE ERUPTED FROM UNDER THE HOOD. THE ENGINE WAS IMMEDIATELY TURNED OFF AND THE VEHICLE WAS VACATED. THE HOOD WAS RAISED AND FLAMES LOOKED AS IF THEY IT WAS COMING OUT OF THE ENGINE COMPARTMENT. THE FIRE WAS EXTINGUISHED AND THE VEHICLE WAS TOWED TO THE HOME OF THE CONTACT. THE MANUFACTURER WAS ALERTED. THERE IS A NHTSA RECALL #97V097000 PERTAINING TO THE POWER TRAIN:AUTOMATIC TRANSMISSION. THE VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

DT*: THE CONTACT STATED THE FUEL TANK CRACKED RESULTING IN FUEL LEAKAGE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE FUEL TANK WAS REPLACED. THE CONTACT IS THE ORIGINAL OWNER AND EXPLAINED THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT.

I OWN A 1997 FORD WINDSTAR, OVER THE COURSE OF A MONTH MY HUSBAND AND A FEW FRIENDS USED MY VAN TO GO HUNTING. OVER THE COURSE OF THAT MONTH HIS FRIEND WEIGHING IN AT 300 POUND SAT IN THE CENTER REAR SEAT. THE SEAT BELT SNAPS INTO PLACE ON THE SIDE OF THAT SEAT. DURING THAT MONTH OF GETTING IN AND OUT AND PLOPPING DOWN ON IT, IT BROKE AND NOW I HAVE TO REPLACE IT IN ORDER TO USE IT AGAIN. BUT IM AFRAID THAT IF IT COULD BRAKE BECAUSE SOMEONE SAT ON IT THEN HOW EASILY COULD IT BREAK DURING AN ACCIDENT. PLEASE TAKE THE TIME TO DO AN IN DEPTH INVESTIGATION OF IT BEFORE SOMEONE IS INVOLVED IN AN ACCIDENT AND THE SEAT BELT BREAKS AND SOMEONE IS HURT OR WORSE KILLED. *NM

TL*THE CONTACT OWNS A 1997 FORD WINDSTAR. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WAS ABNORMALLY LOW. UPON FURTHER INSPECTION, HE NOTICED THAT THE FRONT COIL SPRINGS FRACTURED DUE TO EXCESSIVE RUST. THE FAILURE CAUSED THE TIRES TO DEFLATE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 01V199000 (SUSPENSION:FRONT:SPRINGS:COIL SPRINGS); THEREFORE, THEY WOULD NOT ASSUME RESPONSIBILITY FOR ANY REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED ACCORDING TO THE RECALL. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 90,000. UPDATED 6/4/09 *CN THE EXHAUST SYSTEM WAS REPLACED AND BRAKE LINES SNAPPING. UPDATED 06/09/09.*JB

DRIVING ON INTERSTATE WITH SPEED LIMIT OF 70 MPH... WAS DRIVING ABOUT 77 MPH AT THE TIME... VEHICLE'S FACTORY INSTALLED CRUISE CONTROL WAS IN USE... SPEEDOMETER BEGAN TO FLUCTUATE WILDLY BETWEEN ABOUT 60 MPH AND MAXIMUM (OVER 120 MPH)... VEHICLE'S SPEED REMAINED CONSTANT - TROUBLE WAS JUST WITH THE SPEEDOMETER... VEHICLE HAS 90,000 MILES ON THE ODOMETER... 1997 FORD WINDSTAR... SPEEDOMETER DOESN'T FLUCTUATE WILDLY AT MOST SPEEDS OVER 30 MPH... FROM CHECKING ON WEB THIS HAS HAPPENED TO OTHER OWNERS OF FORD WINDSTARS - THIS IS A SAFETY ISSUE. *JB

NEXT CARS USA IN BAKERSFIELD CALIFORNIA SOLD US A FORD WINDSTAR WHICH WAS DEFECTIVE (A LEMON). WITHIN TWO WEEK AFTER OUR PURCHASE THE VEHICLE CUT OFF JEOPARDIZING THE SAFETY OF MY CHILDREN EACH TIME WE PRESSED THE ACCELERATOR PEDAL. WE HAVE TAKEN THE VEHICLE TO NEXT CARS FOR REPAIRS AND TO DATE WE ARE NOW MOVING INTO OUR THIRD MONTH WITHOUT TRANSPORTATION. WHEN WE INQUIRED ABOUT A LOAN VEHICLE JUAN CASILLAS (MANAGER) RESPONSE WAS THAT "WE DON'T DO THAT." WE HAVE FILED A COMPLAINT WITH THE BETTER BUSINESS BUREAU AND WHEN NEXT CARS RECEIVED THE COMPLAINT ON MARCH 8, 2006 JUAN CASILLAS TOLD US THAT "WE JUST STOPPED WORKING ON THE CAR BECAUSE YOU PISSED US OFF." WE ARE AT OUR WITS END AND SO WE ARE SUBMITTING THIS COMPLAINT FOR AN INVESTIGATION. *JB

ON AUGUST 20TH, WHILE IN A REPAIR SHOP HAVING THE MOTORS REPLACED IN THE WINDOWS OF MY FORD WINDSTAR 1997, THERE WAS A FIRE UNDER THE HOOD WHILE THE CAR WAS OFF. THE MECHANIC PUT THE FIRE OUT AND I TOOK IT TO MY MECHANIC THE SAME DAY. THE CRUISE CONTROL MECHANISM WAS WHAT CAUGHT FIRE. AFTER SEEING MY MECHANIC I CALLED THE FORD HOTLINE AND ASKED ABOUT RECALL INFORMATION. THEY SAID THEY WOULD GET BACK AHOLD OF ME IN TWO DAYS, AND THEY DID NOT. TODAY, AUGUST 30TH, WHILE IN WAL-MART WITH MY CHILDREN I WAS PAGED TO THE PARKING LOT. MY CAR HAD CAUGHT FIRE AGAIN, WHILE OFF AND WITH NO KEY IN THE IGNITION. THE ENGINE WAS DESTROYED, AND LUCKILY THE FIRE DEPARTMENT ARRIVED IN TIME TO PUT THE FIRE OUT BEFORE THE INTERIOR OF THE CAR WAS DESTROYED (CAR SEATS, STROLLERS, ETC.). *NM

DT: THE CONTACT STATES HAS BEEN HAVING SEVERAL PROBLEMS WITH VEHICLE SINCE 2002. ON APRIL 28, 2004 THE SPEEDOMETER WAS NOT PROVIDING AN ACCURATE SPEED READING. ON DECEMBER 9, 2004 THE SLIDING DOOR WOULD NOT UNLOCK OR SLIDE PROPERLY. THE DEALER REPLACED THE DOOR LOCK ACTUATOR AND DETERMINED THAT THE SLIDE WHEELS WERE DRY. THE DEALERSHIP REPLACED THE DOOR LATCH, AND NOW IT NEEDED REPLACEMENT AGAIN. ON FEBRUARY 5, 2005 THE ENGINE WAS REPLACED AT 75, 172 MILES, AND ON NOVEMBER 21, 2005 THE POWER STEERING FAILED AND WAS REPLACED. ALL REPAIRS HAVE BEEN DONE AT CONTACT'S EXPENSE.*AK

DUE TO A FAULTY HEAD GASKET, ANTI FREEZE LEAKED INTO THE OIL AND RUINED THE ENGINE. *PH THE DEALER REFUSED TO REPLACE THE VEHICLES FAULTY GASKETS FREE OF CHARGE BECAUSE THE VEHICLE'S WARRANTY HAD EXPIRED. THE CONSUMER INDICATED THAT A RECALL WAS ISSUED ON THE VEHICLE BUT THE DEALER STILL REFUSED TO REPAIR THE VEHICLE. *NM *SC *JB

ABS ANTI-LOCK BRAKING ENGAGES DURING NORMAL DRY BRAKING. THIS CAUSES A LESSENING IN BRAKING JUST BEFORE A COMPLETE STOP. COULD CAUSE A COLLISION BY NOT STOPPING CAR WITHIN THE DISTANCE EXPECTED. *JB

WHILE TURNING AT LOW SPEEDS, THE DRIVER HEARD A LOUD NOISE COMING FROM THE END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE RACK AND PINION NEEDED TO BE REPLACED. *AK

FAILED HEAD GASKET LED TO A PISTON ROD SHOOTING THROUGH THE OIL PAN. VERY DANGEROUS FOR THE CARS BEHIND ME AS OIL WAS SHOOTING OVER THE HIGHWAY. SLIPPERY FOR CARS FOLLOWING, AND WENT ON OTHER CARS PAINT AND WINDSHIELDS. HEAD GASKETS WERE RECALLED IN PREVIOUS 3 YEARS OF VEHICLES 1993-96 FORD WINDSTARS, 1997 WAS NOT ON A RECALL EVEN THOUGH THE PROBLEM WAS NEVER CORRECTLY FIXED. HIGHLY DANGEROUS AND HIGHLY IRRESPONSIBLE OF THE AUTOMAKER TO NOT INCLUDE ADDITIONAL CARS IN THE RECALL EFFORT. *AK

1997 FORD WINDSTAR: SPEEDOMETER AFTER 55MPH BOUNCES AND REACHES 70MPH WITH NOISE UNDER THE DASHBOARD. I ASKED OTHER FORD OWNERS AND THEY HAD SAME PROBLEM ON DIFFERENT FORD MODEL.

I OWN A 1997 FORD WINDSTAR GL WITH 53,000 ON THE ODOMETER. THE SPEEDOMETER HAS FAILED TO OPERATE PROPERLY. AT SPEEDS OF 40 MPH AND ABOVE THE SPEEDOMETER FLUCTUATES ERRATICALLY RANGING IN SHOWN SPEEDS OF 60 TO 110 MPH. I HAVE DONE MUCH RESEARCH AND HAVE BECOME AWARE OF THOUSANDS OF CONSUMER COMPLAINTS. THIS IS UNCONSCIOUS THAT FORD IS AWARE OF THIS PROBLEM AND MAKING A MINT OFF OF THE CONSUMER OUT OF POCKET EXPENSE OF REPAIR. THIS SHOULD BE AN IMMEDIATE SAFETY RECALL OR TSB. *AK

AT A ROUTINE NYS INSPECTION, THE FORD DEALER ADVISED THAT THE HEAD GASKETS NEEDED TO BE REPLACED. THE CAR IS 6 YEARS OLD WITH 36K MILES. CALLED FORD FOR ASSISTANCE, AND GOT PROFUSE APOLOGIZES, AND NO HELP WITH A $1600.00 REPAIR. THE CAR IS EXHIBITING NO SYMPTOMS OF ANY PROBLEMS, AND I DO NOT HAVE THE MONEY FOR THE REPAIR. FOR SUCH LOW MILEAGE, I THINK THAT FMC SHOULD MAKE SOME ATTEMPT TO ASSIST WITH THIS COMPLAINT. THEY ARE CERTAINLY AWARE OF THE PROBLEM WITH THE 95 & 96 WINDSTARS!!

I OWN A 1997 FORD WINDSTAR MINIVAN (VIN# [XXX]) THAT CONTAINS A 3.8 V6. AT 82,000 MILES, THE HEAD GASKET HAS BLOWN. THE DEALER TELLS ME THAT IT WILL COST BETWEEN $2000 AND $4000 TO REPAIR. AFTER DOING EXTENSIVE RESEARCH ON THE WEB, IT APPEARS THAT THE 1995 AND 1996 MODELS ALSO HAD HEAD GASKET PROBLEMS DUE TO AN ADMITTED DESIGN FLAW. FORD CLAIMS TO HAVE CORRECTED THE PROBLEM-BUT THERE ARE INCREASING NUMBERS OF OWNERS OF 1997 MODELS THAT ARE EXPERIENCING THE SAME PROBLEM. REPEATED VISITS TO THE DEALERSHIP-AS WELL AS NUMEROUS CALLS TO FORD-HAVE RESULTED IN DEAD ENDS. I GET RESPONSES SUCH AS: THE WARRANTY HAS EXPIRED, THERE ARE NO RECALLS ON YOUR VEHICLE AT THIS TIME, ETC. BUT SINCE THIS IS CLEARLY DUE TO A DESIGN FLAW IN THE ENGINE, THEN SHOULDN'T THIS STILL BE COVERED AND CORRECTED? FORD OFFERED A BRIEF PROGRAM TO REPAIR THE EARLIER MODELS-SO WHY HASN'T THIS BEEN OFFERED ON THE LATER YEARS? FORD CLAIMS THAT THEY HAVE FIXED THE PROBLEM-WHICH THEY CLEARLY HAVE NOT-YET THEY EXPECT PEOPLE TO SIMPLY PAY FOR THE REPAIRS. I BELIEVE THAT FORD NEEDS TO BE HELD ACCOUNTABLE FOR THIS, AND THAT THEY SHOULD OFFER TO PERFORM THE WORK AT EITHER A DISCOUNTED RATE, OR FOR FREE SINCE THIS IS DUE TO THEIR ENGINE DESIGN. EVEN THE MANUAL CLAIMS THE HEAD GASKET IS EXPECTED TO LAST FOR AT LEAST 120,000 MILES, AND I WAS TOLD THAT THIS WAS THE CASE WITH THIS VEHICLE. HAD I KNOWN OF THE PROBLEMS OTHER OWNERS WERE HAVING, I WOULD HAVE RECONSIDERED MY DECISION TO PURCHASE THIS VAN. TO THAT END, I FEEL THAT I WAS MISLED SOMEWHAT. IT IS MY HOPE TO HAVE FORD ADMIT TO THE PROBLEM AND OFFER TO REPAIR MY VEHICLE AT NO CHARGE. GIVEN THE CIRCUMSTANCES-AND THE AMOUNT OF EVIDENCE SUPPORTING THE CLAIM OF NEGLIGENCE ON THE BEHALF OF FORD-THIS SHOULD NOT BE AN UNREASONABLE REQUEST. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I OWN A 1997 FORD WINDSTAR MINIVAN (VIN# [XXX]) THAT CONTAINS A 3.8 V6. AT 82,000 MILES, THE HEAD GASKET HAS BLOWN. THE DEALER TELLS ME THAT IT WILL COST BETWEEN $2000 AND $4000 TO REPAIR. AFTER DOING EXTENSIVE RESEARCH ON THE WEB, IT APPEARS THAT THE 1995 AND 1996 MODELS ALSO HAD HEAD GASKET PROBLEMS DUE TO AN ADMITTED DESIGN FLAW. FORD CLAIMS TO HAVE CORRECTED THE PROBLEM-BUT THERE ARE INCREASING NUMBERS OF OWNERS OF 1997 MODELS THAT ARE EXPERIENCING THE SAME PROBLEM. REPEATED VISITS TO THE DEALERSHIP-AS WELL AS NUMEROUS CALLS TO FORD-HAVE RESULTED IN DEAD ENDS. I GET RESPONSES SUCH AS: "THE WARRANTY HAS EXPIRED", "THERE ARE NO RECALLS ON YOUR VEHICLE AT THIS TIME", ETC. BUT SINCE THIS IS CLEARLY DUE TO A DESIGN FLAW IN THE ENGINE, THEN SHOULDN'T THIS STILL BE COVERED AND CORRECTED? FORD OFFERED A BRIEF PROGRAM TO REPAIR THE EARLIER MODELS-SO WHY HASN'T THIS BEEN OFFERED ON THE LATER YEARS? FORD CLAIMS THAT THEY HAVE FIXED THE PROBLEM-WHICH THEY CLEARLY HAVE NOT-YET THEY EXPECT PEOPLE TO SIMPLY PAY FOR THE REPAIRS. I BELIEVE THAT FORD NEEDS TO BE HELD ACCOUNTABLE FOR THIS, AND THAT THEY SHOULD OFFER TO PERFORM THE WORK AT EITHER A DISCOUNTED RATE, OR FOR FREE SINCE THIS IS DUE TO THEIR ENGINE DESIGN. EVEN THE MANUAL CLAIMS THE HEAD GASKET "IS EXPECTED TO LAST FOR AT LEAST 120,000 MILES", AND I WAS TOLD THAT THIS WAS THE CASE WITH THIS VEHICLE. HAD I KNOWN OF THE PROBLEMS OTHER OWNERS WERE HAVING, I WOULD HAVE RECONSIDERED MY DECISION TO PURCHASE THIS VAN. TO THAT END, I FEEL THAT I WAS MISLED SOMEWHAT. IT IS MY HOPE TO HAVE FORD ADMIT TO THE PROBLEM AND OFFER TO REPAIR MY VEHICLE AT NO CHARGE. GIVEN THE CIRCUMSTANCES-AND THE AMOUNT OF EVIDENCE SUPPORTING THE CLAIM OF NEGLIGENCE ON THE BEHALF OF FORD-THIS SHOULD NOT BE AN UNREASONABLE REQUEST. *LA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE SUBFRAME ASSEMBLY ON MY 1997 FORD WINDSTAR HAS BROKEN/CRACKED IN TWO DIFFERENT LOCATIONS * ON TWO SEPARATE OCCASIONS. THE FIRST REPAIR WAS IN SEPTEMBER OF 2002. THE MOST RECENT REPAIR WAS SEPTEMBER 2003. THE SERVICE MANAGER AT DENNISON FORD (STEVE BOWNS) SAID THAT IF IT HAPPENS AGAIN, THE SUBFRAME PROBABLY WILL NEED TO BE REPLACED. MY IMPRESSION IS THAT THIS IS A COMMON PROBLEM WITH WINDSTARS. WHEN I CALLED TO SET UP AN APPOINTMENT THE SECOND TIME AND STARTED DESCRIBING THE PROBLEM, THE SERVICE REP SAID THEY USUALLY BROKE AT THE STRUT. WHEN SEARHING THE INTERNET, I HAVE FOUND OTHER WINDSTAR OWNERS WITH THIS PROBLEM. IN A DISCUSSION WITH SHELDON (#2052) AT (1 - 800 392 FORD) WHEN ASKED IF THIS WAS A SAFETY ISSUE, HIS RESPONSE WAS "I AM NOT IN A POSITION TO COMMENT IF THIS IS A SAFETY ISSUE." WHEN ASKED IF HE CHECKED WITH THE SERVICE MANGER IF THIS WAS A SAFETY ISSUE HE RESPONDED. "I DID NOT ASK HIM SPECIFICALLY IF IT WAS A SAFETY ISSUE. IF YOU WANT TO KNOW IF IT IS A SAFETY ISSUE, YOU WILL NEED TO TALLK TO THE PERSON THAT IS WORKING ON YOUR CAR." I INDICATED TO SHELDON THAT I WANTED TO TALK WITH A FORD REPRESENTATIVE THAT COULD TELL ME WHETHER OR NOT A SUBFRAME BREAKING WHILE DRIVING WAS A SAFETY ISSUE. HE INDICATED ONLY THE PERSON WORKING ON MY CAR COULD DO THIS. SHELEDON INDICATED THAT HE (SHELDON) WAS NOT QUALIFIED TO DO THIS. IS THIS A SAFETY ISSUE? * THE SERVICE TECH SAID SEVERAL TIMES THAT IT WAS A DIFFERENT LOCATION. WHEN SHELDON CALLED THE DENNISON FORD SERVICE MANAGER, STEVE BOWNS, THE SERVICE MANGER INDICATED THAT IT WAS THE SAME LOCATION ACCORDING TO SHELDON.

GASKETS HAVE COMPLETELY FAILED. *AK

I BOUGHT THIS 1997 FORD WINDSTAR IN MARCH OF 2003. THE VERY NEXT DAY I RETURNED TO THE INDEPENDENT CAR DEALER DUE TO THE CHECK ENGINE LIGHT WAS ON. THEY SAID NOTHING WAS WRONG AND THEY RESET THE LIGHT. WITHIN A WEEK IT WAS ON AGAIN AND THIS TIME THEY SAID IT WAS A FLUXATION IN THE ELECTRICAL CURRENT AND IT WAS MAKING THE LIGHT COME ON. THEY RESET IT. ABOUT 2 WEEKS LATER IT IS LOSING COOLANT SOMEWHERE AND RUNNING ROUGH, THEY CHECK IT AND NOW IT NEEDS 2 OUT OF 4 OXYGEN SENSORS REPLACED IM TOLD. THEY PAY FOR IT IF THEY TRULY FIXED IT BECAUSE ABOUT 2-3 WEEKS LATER I AM HAVINT THE SAME PROBLEMS SO THEY REPLACE THE OTHER 2 OXYGEN SENSORS, BUT CANNOT EXPLAIN THE COOLANT LOSS. EVER SINCE I HAVE HAD NOTHING BUT PROBLEMS SO I DECIDED TO GO TO THE LOCAL FORD DEALER EVEN THOUGH I TRY TO AVOID DEALERS BECAUSE OF PRICES AND THEY CHARGE ME $58 TO TELL ME I NEED A HEAD GASKET, MY ABS SYSTEM IS NOT WORKING, TIMING COVER IS LEAKING, BALL BEARING IS SHOT AND MY ANTIFREEZE LOOKS LIKE MUD. THIS IS ALL WROTE ON A SERVICE ESTIMATE I ASKED THEM FOR. IT WOULD COST ABOUT $1700 + TAX FOR THEM TO FIX. I HAVE READ THAT FORD KNEW THEY HAD A PROBLEM WITH THE 95 WINDSTARS AND THE HEAD GASKETS AND OFFERED AN EXTENDED WARRANTY OR MONEY TOWARDS A NEW CAR SO I FEEL THEY KNOW ALL WINDSTARS WITH THIS 3.8L ENGINE ARE FAULTY NOT JUST THE 95'S. I CALLED FORD AND THEY TOLD ME TOUGH LUCK BASICALLY. I HAVE READ ON THE INTERNET NUMEROUS COMPLAINTS ABOUT THE HEAD GASKETS IN ALL 3.8L WINDSTARS AND I WANT MY VAN FIXED.

BEHIND IN PAYMENTS. FORD MOTOR CREDIT ISSUED WRITE OF SUMMONS ON 7/3/03, TRIAL SCHEDULED FOR 9/22/03. ON 7/29/03, WHILE AT WORK, VEHICLE CAUGHT ON FIRE, DAMAGING 2 OTHER VEHICLES PARKED ON EITHER SIDE OF ME. FIRE MARSHALL INVESTIGATED THE INCIDENT AND FOUND TO BE AN ELECTRICAL PROBLEM. INSURANCE INVESTIGATED AND VEHICLE WAS TOTAL LOSS. INSURANCE PAID FORD MOTOR CREDIT $5,689.25 (CLAIM [XXX]). FORD MOTOR CREDIT OBTAINED JUDGMENT AND WAGES ARE CURRENTLY BEING GARNISHED ON A VEHICLE THAT WAS CLAIMED A TOTAL LOSS DUE TO AN ELECTRICAL PROBLEM. *JB UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

CONSUMER STATED THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING TRANSMISSION FAILED, CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED.*AK

HEAD GASKET LEAKED, TIMING COVER CRACKED. $3,000.00 + REPAIR BILL.*AK

TIE RODS WERE WORN OUT. DEALER NOTIFIED. *AK

THE CONSUMER NOTICED TWO CRACKED RIMS IN 2001. THE PARTS WERE REPLACED WITH FORD ORIGINAL PART# F58Z1015A. LATER THE CONSUMER NOTICED THREE CRACKED WHEELS WHICH WERE ALSO REPLACED. *AK *SC

WHEN I EXCEED 50 MPH MY SPEEDOMETER FAILS TO KEEP ACCURATE SPEED AND IT "WAVES" WILDLY FROM 20 - 110 MPH. WHEN I CONTACTED MY FORD DEALERSHIP THEY "HAD NEVER HEARD OF THAT BEFORE", BUT WHEN I DID A LITTLE MORE RESEARCH I FOUND AT LEAST 50 MORE COMPLAINTS. I CONTACTED THE FORD MOTOR COMPANY DIRECTLY TO SEE WHY THERE HAD NOT BEEN A RECALL ON WHAT APPEARS TO BE A MANUFACTURING DEFECT BECAUSE ALL PROBLEMS OF THIS NATURE INVOLVED ONLY THE 96-98 FORD WINDSTAR MODELS. THEY INFORMED ME THEY KNEW OF THE PROBLEM BUT ONLY THE NHTSA COULD INITIATE A RECALL. I HAD NEVER HEARD OF THIS AND I DOUBT OTHER OWNERS OF THESE VEHICLES DO, EITHER OR THERE WOULD BE MORE COMPLAINTS. THIS IS A SERIOUS PROBLEM.*JB

I BOUGHT MY 1997 WINDSTAR USED 6 MONTHS AGO WITH 87,000 ON IT, I HAVE DRIVEN ONLY 3,000 MILES AND MY ENGINE BLEW WITH NO WARNING. THIS WAS THE MOST EXPENSIVE USED CAR I HAD EVER OWNED AND WE DID EVERYTHING WE COULD BEFORE WE BOUGHT IT..WE CHECKED THE VIN REPORT ON CARFAX...WE HAD THE VEHICLE CHECKED OUT BY OUR OWN MECHANIC. I THOUGHT I HAD FOUND A GREAT (DREAM FOR ME)VEHICLE. BEN SATCHER FORD IN SC SAID THERE WAS NO RECALL ON THIS CAR ONLY THE 95 MODEL AND THAT PROBLEM HAD BEEN SINCE FIXED. SO I'M STUCK WITH PAYING $3000 FOR A NEW ENGINE WHILE I STILL OWE $6000 ON MY VEHICLE. THIS VEHICLE IS THE ONLY WAY I CAN TRANSPORT MY 3 CHILDREN AROUND TOGETHER, OUR OTHER VEHICLE IS A PICK-UP WITH ONLY FRONT SEATS...SO WERE STRANDED.

HAVE A 97 FORD WINDSTAR ALL OF A SUDDEN I HAD A TIRE BLOW COMPLETELY HERE TO FIND OUT THAT THE COIL SPRING ON DRIVERS FRONT BROKE AND WENT INTO TIRE, THEN TO FIND OUT THERE WAS A RECALL 2 YEARS AGO ON IT BUT WAS NEVER NOTIFIED OF IT AND ALSO A FEW WEEKS AGO, VAN ALL OF A SUDDEN KEPT GETTING REAL HOT WITH ROLLING WHITE SMOKE JUST TO FIND OUT THAT THERE WAS PROBLEMS WITH THE HEAD GASKETS ON THESE WINDSTARS BUT YET STILL WAS NEVER NOTIFIED, THIS IS NOT RIGHT, I FEEL WE WERE CHEATED, NOW HAVE A VAN THAT SITS AND STILL OWE $10,000 ON BECAUSE I'M A FAMILY MAN OF SIX AND CANNOT AFFORD THE COST OF THESE MAJOR REPAIRS, I'M AFRAID OF WHAT MIGHT OF HAPPENED IF THIS WOULD OF BLEW WITH ALL MY FAMILY IN IT ON A HIGHWAY, IS THIS HOW THE FORD COMPANY TREATS THEIR CONSUMERS BY LYING AND DECIEVING THEM.

THE HEAD GASKET LEAKED.*JB

DEFECTIVE SPEEDOMETER UNITS IN 1997 FORD WINDSTARS.I HAVE HAD MY SPEEDOMETER REPLACED 3 TIMES AND IS IN NEED OF ANOTHER. THE DEALER TOLD ME THIS HAS BEEN A PROBLEM WITH THE WINDSTARS AND THE TAURUS.YOU CAN NOT JUDGE HOW FAST YOU ARE GOING WHICH IS A SAFETY ISSUE.ESPECIALLY WHEN YOU REPLACE THE UNIT AND IT KEEPS NEEDING TO BE REPLACED.CAN IT BE RECALLED?

THE ENGINE OVER HEATED.*JB

SUDDEN CATASTROPHIC FAILURE OF THE TRANSMISSION ON MY 1996 WINDSTAR, 86,000 MI. PROPER MAINTENENCE HAD BEEN DONE. I SEE THERE ARE MANY COMPLAINTS HERE WITH THE SAME PROBLEM. NHTSA IT IS TIME TO STEP UP AND FORCE A RECALL. HOW LONG DO THE CONSUMERS HAVE TO BEAR THE BRUNT OF THIS OBVIOUS DEFECT. WE DON'T HAVE THE $3000 THEY WANT FOR REPAIRS. WHAT HAPPENED TO COMSUMER RIGHTS? THE WAY IT STANDS NOW I WILL NEVER BUY ANOTHER AMERCIAN CAR. IS THAT WHAT YOU WANT FOR THE ECONOMY. YOU HAVE TO HOLD CORPORATE AMERICA RESPONSIBLETOPUT OUT QUALITY VEHICLES. YOU HAVE THE POWER. DO WHAT YOU ARE THERE TO DO, PROTECT THE CONSUMER, NOT THE CORPORATE MONEY.

SPEEDOMETER UNIT IN 1997 WINDSTARS ARE DEFECTIVE. I HAVE HAD MINE REPLACED 4 TIMES WITHIN THE PAST 4 YEARS AND IT NEEDS TO BE REPLACED AGAIN. THE SPEEDOMETER DOES NOT WORK, JUST SWINGS WILDLY. IT IS UNSAFE AS THE DRIVER DOESN'T KNOW HOW FAST THEY ARE DRIVING. MY FORD DEALER TELLS ME THIS HAS BEEN A PROBLEM WITH WINDSTARS AND TAURUS BUT NEVER RECALLED. *JB

ADOLESCENT WAS CAUGHT IN SEAT BELT. IT CONTINUED TO LOCK TIGHTER AND WOULD NOT RELEASE. PARENT HAD TO STOP CAR AND CUT CHILD FREE OF BELT TO AVOID INTERNAL INJURIES. CHILD WENT INTO SHOCK AND WAS DRIVEN TO NEAREST FOR EVALUATION. NO PERMENANT INJURIES WERE NOTED AT THIS TIME. DT

BLOWN HEAD GASKET ON 3.8 ENGINE ON 1997 FORD WINDSTAR, WITH ONLY 77,000 MILES. FORD WITH NOT OFFER ANY HELP. AFTER OWNING A FORD FOR PAST 28 YEARS, THIS IS THE LAST FORD PRODUCT THAT MY FAMILY WILL EVER OWN. EVER! TS