2017 Honda Pilot Fuel System Problems

The contact owns a 2017 Honda Pilot. The contact stated that while stopped at a traffic light, the vehicle unexpectedly lunged forward with the check engine warning light illuminated, and the “Emission System” error message was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.

The contact owns a 2017 Honda Pilot. The contact stated that while driving at slower speeds, the transmission unexpectedly shifted to neutral(N) while the accelerator pedal was depressed. Several unknown warning lights were illuminated. Prior to the failure, the vehicle was taken to a local dealer for a fuel injector replacement. The vehicle was taken to a local dealer, where it was diagnosed and determined that the fuel pump and catalytic converter needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign: 23V858000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.

It has happened on multiple occasions where I’m driving at 70mph, and my engine cuts out and I can no longer accelerate on the highway. My rpm’s drop to 0. I have to pull over until it comes back on again. It’s putting my safety, my children’s safety at risk, other drivers on the road at risk when all of the sudden my car will not accelerate.. has not been inspected by manufacturer. No other symptoms, no lights come on.

While driving, the vehicle lost engine power on three separate occasions (3/6/26, 3/10/26, 3/20/26) and had to coast to a stop on the road. One of the codes that appeared was P0087; the Honda dealership replaced the fuel pump kit (part # 06161-RLV-305) due to the fuel rail pressure being too low, but the vehicle continued to stall upon replacement after being picked up from the dealership. When it was brought back to them, they could not find a problem or replicate the stalling. This is a safety risk because the car is stalling for an unknown reason and will not start back up for 10-15 minutes. This is a safety risk to the driver and others because stalling could cause an accident or fatalities if the driver is unable to safely pull over. Fuel pumps are a known problem in 2017 Pilots and this vehicle was not included in the recall (SB 24-010). I paid $1694 for the repair from the Honda dealership and the problem is still occurring. There were no warning lights prior to the failure. Honda should reimburse me for this cost, but they denied responsibility for the cost despite Service Bulletin 24-010. These vehicles are unsafe and should not be on the road at all.

I own a 2017 Honda Pilot. The vehicle has been stalling and losing power while driving. The loss of power creates a serious safety risk, especially in traffic and at highway speeds, as the vehicle hesitates and struggles to accelerate. The High-Pressure Fuel Pump was replaced at my expense after the vehicle began stalling and losing power. Despite this repair, the problem has persisted. I am now being told by Honda that the Low-Pressure Fuel Pump also needs to be replaced. I have already paid for significant repairs, including replacement of the High-Pressure Fuel Pump, water pump, timing belt, and related components. My vehicle’s VIN is not included in any fuel pump recall, although similar vehicles appear to have had related recalls. I did receive a warranty extension for the torque converter, but I have received no notification or warranty support regarding the Low-Pressure Fuel Pump. The stalling and loss of power place me and other drivers at risk, particularly in intersections and during highway driving. The issue has been diagnosed by a Honda dealer/service center. The failed components are available for inspection upon request. No consistent warning lamps appeared prior to failure. I am concerned this may be a broader safety defect affecting vehicles outside the current recall population.

The contact owns a 2017 Honda Pilot. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate while depressing the accelerator pedal. There were several unknown warning lights illuminated. The contact referenced NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 143,000.

The vehicle started to Make loud clinking sound coming from engine. Went to dealership for diagnostic and high pressure fuel pump failed. Was quote 2000 .

Turned car on and it was making a very loud sound coming from what sounded like the engine. Very loud when accelerating or stepping on the gas. Driving at lower speed was also loud. Unknown if it was safe to drive. Took to mechanic and was told it was the high pressure fuel pump. There were no warning lights or warnings.

The contact owns a 2017 Honda Pilot. While the contact’s wife was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The contact referenced an unknown recall; however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 59,000.

Noisy Fuel pump and difficulty to start the car.

2017 FWD Honda Pilot, Current miles 67k. In June 2025, Morning start, car makes whining noice when idle and gets louder while driving. Pilot then loses power, poor acceleration, starts to stall and steering wheel jerk. NO WARNING LIGHT / CHECK ENGINE ON DASHBOARD. (Common for light not to come on) Not putting my family and others at risk Pilot was taken to nearby dealer for diagnostics. I was told high pressure fuel pump needs fail / need replacement. Advisor at dealer sent out Goodwill request for replacement and was denied any repair. This is known problem on "2017-2020 Acura and Honda vehicles" Part #16790-RLV-305 - PUPM ASSY IS COVERED under Emission Warranty 84month / 70k miles. Why did Honda denied repair(?) Called American Honda Motor co., Inc. recall line Center and submit another request for repair. waiting for call back.

The car began making a grinding noise, shimmied and surged. Independent mechanic found documentation online that Honda reported that if this occurred in 2017 Honda Pilots the problem could be the Fuel Pump Direct Injection High Pressure part. To correct problem this part must be replaced. Mechanic did replace this part which corrected the problems.

At times, when I attempt to accelerate, the fuel pump malfunctions, causing the vehicle to stall. This has almost caused accidents in the middle of intersections on multiple locations. When I attempt to cross intersections with other cars, my car is almost hit when it suddenly stops. The car has been inspected by a Mossy Honda of Lemon Grove and the fuel pump problem has been confirmed. There are no warnings or indications that this will happen. It doesn't happen all the time but it does happen every day. I am available at any time for an inspection.

My 2017 pilot 6speeds gave a really bas gas smell then my it started to sound like an exhaust leak but after going my regular mechanic it was confirmed that my high pressure fuel pump was bad. I cant afford the cost and labor so now im hoping my car would also come included with the fuel pump warranty. I keep up with regular maintenance and currently only has 72k miles on it. Plss get it resolved as i see alot of ppl on honda pioneers threads talking about the same exact issue.

To whom it may concern, I own a 2017 Honda Pilot which recently stalled while I was driving on the highway, forcing me to pull over. There was no indication that anything was wrong with the vehicle at the time - no check engine lights, no warning indicators, no alerts - this happened suddenly and unexpectedly. My car felt like it lost power, the steering wheel became jerky, and I was concerned for my safety. All the warning lights on the dashboard then lit up, and I believe the car entered limp mode. Had I not been on an empty highway, I believe that it could have easily led to an accident. Fortunately, I was able to slowly drive towards a Honda Service Center nearby, who ran diagnostics and told me that the fuel pump had failed. The error code that their diagnostics reported was p0087: fuel rail pressure too low. Upon looking online, it appears Honda released a statement recalling 2017-2020 Honda and Acura vehicles in the US to replace the fuel pumps: [XXX] . This appears to be associated with NHTSA recall no. 23V-858. Based on the description in the notice, where an inoperative fuel pump can cause the engine to not start or stall while driving, I believe that my car experienced the exact same issue. My 2017 Honda Pilot appears that it would be included in this recall; however, when I check my VIN on the Honda Recall Lookup website, it claimed that my car has no active recalls. I believe this is a serious safety concern, and Honda should be expanding the recall to include the production batch when my 2017 Honda Pilot was manufactured. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Honda Pilot. The contact stated that on three occasions while driving at various speeds, the messages "Emissions System failure", "Stabili-trak Assist Failure", "Hill Start Assist Failure", “Vehicle Stability Assist Failure", and "Power Steering System Failure" were displayed. Additionally, the power steering and check engine warning lights were illuminated. The vehicle then stalled each time. The vehicle was restarted after approximately four attempts. The contact stated that after the first and second failures, DTC code: P0087; was retrieved on a handheld diagnostic scanner. The contact associated the failure with NHTSA Campaign Number: 21V215000 (Fuel System, Gasoline). The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 179,831.

We are going through gas at a very accelerated rate. We were told in September that there was a recall for a fuel related part. We were told this by AutoFair Honda in Manchester, New Hampshire, where we purchased the vehicle. We were then told that appointments for the recall repairs would be made in November. Upon calling today, They are claiming there's never been such a recall. I was told by three different representatives over the course of the past two months that they're still awaiting appointment times because they don't have the parts in to do the recall repair. It's a 17.5 gallon tank and we have to fill it twice a week and don't do a lot of driving- enough is enough.

To Whom It May Concern, I am writing to formally file a complaint regarding Honda's refusal to address a known issue with my 2017 Honda Pilot Touring AWD, despite the existence of a service bulletin. My vehicle has been consistently experiencing error code P0430, which pertains to the catalytic converter and emissions system. This error happens while driving several times. Honda has issued a service bulletin (NHTSA ID: 10187006) to address this very issue, accessible in the attachement. I scheduled an appoitnment at Honda to request the repair outlined in the bulletin. Unfortunately, they have refused to perform the necessary repairs due to my vehicle having a salvage title. I want to emphasize that although my vehicle has a salvage title, there has never been any engine or mechanical damage that would affect the emissions system or components causing this error code. Additionally, I am not alone in experiencing this issue. Many members of the Honda Pilot community have reported the same problem, and there is a large Facebook group where numerous owners are discussing their frustrations with the P0430 error code. This widespread issue further demonstrates that Honda needs to address the defect, regardless of a vehicle's title status, particularly since it is unrelated to any previous damage or title condition. It is disappointing that Honda is using the salvage title as a reason to deny what should be a covered repair, as the service bulletin explicitly addresses this mechanical defect. Given the direct impact this has on emissions compliance and potentially broader safety and environmental concerns, I am seeking NHTSA’s assistance in urging Honda to comply with their own service bulletin and perform the necessary repairs. Thank you for your attention to this matter. I hope for a swift and fair resolution to ensure my vehicle is properly repaired according to the service bulletin.

The contact owns a 2017 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. The VIN was not available.

High pressure fuel pump failed at 57,500 miles.