2017 Hyundai Santa Fe Complaint Log

On Saturday January 29, 2022 while getting off the 91 freeway in Corona, CA ; we heard a knocking noise coming from the engine; the oil light flashed once and went away. we arrived at our destination which was about 3-5 minutes from exit. We noticed the knocking got louder as we pressed the gas. We checked everything , we decided to check the Oil compartment due to the one flash we saw getting off the freeway, noticed the car had no oil. The vehicle NEVER notified us before this day on oil issues. According to our last oil change in September 10, 2021 we still had about 200 miles left for our next oil change. We took the vehicle to a Hyundai dealership, the car has been there since January 31, 2022. They said we need a new engine and they would file a claim with Hyundai, I've submitted my oil changes from Jiffy Lube; I have not received any information since. This is definitely a safety issue to myself, my daughters, other drivers if the engine had exploded /caught on fire due to the malfunctioning of the vehicle. I've always heard if a car ever needs oil, or it has an issue, it'll notify you. This car did not notify me, 0 messages, nothing lit up other than that flash on that day January 29, 2022, but it was obviously way too late. I had 0 oil. and now my engine is messed up. My car only has 78,620 miles on it.

On 1/29/22 I was driving on the parkway going 60 mph when my vehicle began to fail. I could not accelerate and I had to put my car in neutral to get to the side of the busy parkway. My vehicle turned off and would not turn back on. My vehicle was towed to A Hyundai dealership where ultimately I was told I needed a new engine for almost $6000. Hyundai stated they won’t pay for it due to a recall that was never taken care of in the beginning of 2019. I bought my vehicle in November 2019 from a Chevrolet dealership where nothing about a recall was ever disclosed. I can’t seem to find anything about a 2019 recall but I do see there was on listed on 2/2/22. I’m at loss for what to do. I can’t afford to pay for this and I still owe 13,000 on it. The red battery signal lit up on the dashboard when the engine started to fail. That was the only warning signal. Yes available for inspection upon request.

Car has repeatedly lost power or hesitated when making turns. Now it lost power and decelerated over 10 mph abruptly while driving on I-65. After deceleration the car would not accelerate to in a normal fashion. Took minutes to get up to speed. Upon a test drive at the dealership, Terry Lee Hyundai, I was told nothing was wrong with the car. I refused to believe that after my highway driving incident and made them test it again. It produced a dTC code of P0088. After having my car for four days they tried to return it to me again saying nothing was wrong with it. I was dumbfounded. How can I have a drastic highway incident and DTC codes emailed to me via bluelink and nothing be wrong. I feel this car is unsafe for highway driving. May cause a wreck due to the losing power while turning issue and now this highway driving issue. The car drove normal under 60 mph. The turning issue happens when the car makes quick 90 degree turns. Also the engine was replaced due to electrical interference issues at 96000 miles. Car has always had loss of power issues followed by the lack of the ability to accelerate properly. Please help!!!!

I was on the highway going about 65mph when all of the lights on my dashboard came on, including the engine light. I received a warning on the screen to get service immediately. My car started slowing down and I was able to pull over before my engine completely seized up. I was lucky that the highway was not crowded and that I was able to get over before it stopped in the middle of the highway!! I do not know why it failed! I had regular maintenance, oil changes, etc. None of the lights came on before this happened. I had no warning. I have been told by the dealership that I need a new engine. It only had 76K miles on it!

On January 11, 2021 I was on my way to work. I work for Kia. My car stalled out and my engine light began blinking perfusly. I made an illegal turn to get to my job where I was told to pull into service where it was diagnosed with a knock sensor code. It was towed to south Towne Hyundai of Newnan where it still is and has yet to be diagnosed. I have been getting lies saying I was next over 3 weeks. I have lost a job, exhausted all of my funds on rentals and my calls are being ignored. I filed a claim for reimbursement but at this time. I no longer want to deal with Hyundai. I would just like them to buy the vehicle back from my finance company as I completely am utterly disgusted by the policies, practice, and procedure that they refuse to honor. The case workers give false information but when you go read the website they have not adhered to anything they offer.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Engine failure due to "rod failing". Car lost power and RPMs. Mileage was 119325. Car always serviced at dealership. Dealership recognized the issue and referred me to customer service. Case File #1959318 was files with Hyundai Customer Service. They rejected any assistance in replacing engine citing that it was more than 10% over 100,000 miles. Replaced used engine cost $10,146.04. Thomas Cumberland Invoice 6035219 (Mar 28, 2022)

Motor was using way too much oil between engine oil changes. The vehicle only had 76,000 miles on it. My wife was driving to work when it stopped working. My mechanic said Hyundai was aware of poor engines. My wife was driving it and engine stopped working. Now have to replace the motor.

Back in January 2022 my car stalled, I took it to my mechanic and he said that I had no oil. My car has 33175 miles. He filled it up. Four months later it stalled again, I brought to the same mechanic again, he told me to take it to the dealer because the car is consuming oil. May 18 2022 dropped the car off at the Hyundai dealer and they told me they were keeping it. After numerous phone calls to them they allowed me to pick up my car June 22 2002 and they did nothing, they told that my car had a consumption problem and that I need to drive it for one thousand miles and have the oil checked. July 12 2022 My milage now is 33397 he added oil. I came back after 510 miles and they had to put a quart of oil in, I have everything documented. Milage was 33685. September 19 2022 Mike added 1/2 quart of oil, milage was 34109. November 25 2022 milage was 34870 they added 2 1/2 quarts of oil. On January 23 2023 I called corporate and got a case number #20630111, not satisfied dealing with the dealer anymore. All the time I was going to the dealer no one documented anything that happened with the car. On February 24 2023 I brought the car back to the dealer and the oil consumption problem has been approved they put a tamper seal for the oil filter and drain plug to start the oil consumption test. My milage was 36129. I am petrified to drive the car for fear that I am going to stall out and get hit, I am 75 years old, I work, pick up grandkids and take care of my 101 year old mother, they don’t seem to care. I drove the car 1000 miles and on May 5 2023 I brought it back for an oil check up, it was 2 1/2 quarts short. I have a paper that says “time line of the recall” it says “the TSB instructed dealers to inspect and repair if the oil consumption was over 1 quart/ 1000 miles “ Every time I went to the dealer I took a picture of the dipstick and the milage. I was hoping you would be able to see that my car is not safe on the road and that I am petrified to drive it. Please help

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving approximately 35mph when the vehicle stalled and white smoke was emitting from the tailpipes. The vehicle was unable to be restarted. The contact stated check engine malfunction indicator light warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed with needing high-pressure fuel lines replaced but was not repaired. The manufacturer was informed of failure and was awaiting a response. The failure mileage was approximately 100,000.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

My paint is peeling off in sheets.

I bought the bait vehicle 8 months ago from my dealership. My car started driving rough. While it was in phase 2 of having a oil consumption test. My car has been using more oil than necessary. I took it to the dealership service department they said that the fuel injectors were bad and now it needs a new motor. They had to replace the fuel exhaust valves Austin valves but did not solve solve the issue of the car running rough running rough when it was running it would stall.

Engine starting acting up and consuming oil. Engine light came on @ 107000 miles. I'm first owner and have warranty until 150000. Need a whole new engine and have taken care of my vehicle since day one. My father is a mechanic and has taught us since we were little you have to take care of your maintenance and car. They are saying it was not taken care of and is normal wear and tear. One cylinder just does not go out. It would be all the cylinder misfiring at once. Mistreated as a women and also military family. No loaner offer and still waiting to see what will happen to my car since middle of December. I have all oil change records and maintenance done. I keep reports.

I have a 2017 Hyundai Santa FE Sport 2.4 Liter engine. On December 16th at 3am i was on the highway and the gas would not go above 65mph after i herd a clunk, but i did not hit anything in the road. 4 miles after that it started slowing down with all the warning lights going off. 3 miles after that off the highway onto a city street and 4 miles away from home the vehicle made a sudden down shift (it seemed) started to slow down after a sound of my engine clinking and sounded as some parts fell off. A half mile away from home it slowed to a walking pace and shut down. I looked under the vehicle, oil was everywhere, i looked under the hood and seen the same thing. After a half mile tow my mechanic of 12 years who inspects the vehicle and does all the repairs and oil changes three to four times a year stated the pins and rods under the engine fell apart and blew a hole in the bottom of the engine. My mechanic T.J.Burns at Burns Automotive, CarMax mechanic and Precision Auto all in Greenville, South Carolina said the 2.4 Liter engines from this manufacturer are known for blowing out and dying after 100,000 miles regardless of proper maintenance and this IS a a manufacturer's defect in their professional opinion.

Excessive build up of sludge, even with proper maintenance.

While driving 25 mph the engine just stalled , initially it would not restart after about 30 minutes the vechile restarted but had missing sound and at this time the check engine light came on as able to drive vechile home which was 2 miles however would not go over 15-20 mph had a lot of smoke coming out of exhaust , had dealer check and stated it was engine failure and that certain 2017 Santa Fe had a recall for engine issue that was exactly like what’s wrong with this one but it isn’t included in recall is what I was told and that it would 15k to fix , I think if that make and model had a recall on the engines due to failure it should be for every 2017 3.3 l v6 engine as looking at the vechile history that is a very common issue the car had 125000 miles on that is not very many and all maintenance was maintained on this car

The contact owned a 2017 Hyundai Santa Fe. The contact stated that while driving approximately 35 mph, the traffic stopped and the brake pedal was applied but the vehicle failed to stop. As a result, the contact crashed into an unknown vehicle. There were no warning lights illuminated. The air bags deployed. A police report was filed. There was no reported fire or injuries. The vehicle was towed to an independent lot. The vehicle was deemed a total loss by the insurance company. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 33, 000.

I purchased a 2017 Hyundai Santa Fe June 2021 Upon completion of my oil change 12/1 I was told there was a oil leak and the oil wasn't going to stay in, I drove home under 20mph because my engine wouldn't allow me to go any faster. The next day it was towed to a Hyundai dealership close to home, Hyundai denied the first claim because they said it was the oil change companies fault. I then called the warranty company and the adjuster came out examined the car he found out that wasn't the case, it was internal damage cause by the manufacturer. Botls came loose that cracked something and metal chips got into my engine. My extended warranty denied covering it because it wasn't basic engine failure it was cause by the production of the vehicle and the faulty bolts that internally damage itself. I resubmitted the claim to Hyundai for repairs since we know now it wasnt outside negligence and the extended warranty company wasn't going to cover it. The advisor told me the second claim was denied as well , after speaking to the consumer affairs department myself they still denied having any part and the faulty engine. I'm in a Facebook community group and these people are going through this daily with Hyundai they are putting bad engines in cars once the original owner finds out they're trading them in and the second owner buys them in the car fails we aren't covered under the powertrain warranty because it only applies to the first owner. Hyundai is ripping people off and stealing our hard worked for money and getting away with it! They're picking and choosing who the engine failure class action lawsuit applies to even though we all have bad failed engines! I have been stuck making payments on a car for 2 months that I cannot drive and I owe $18,000 on a totaled car and they care nothing about!

I purchased a 2017 Hyundai Santa Fe June 2021 Upon completion of my oil change 12/1 I was told there was a oil leak and the oil wasn't going to stay in, I drove home under 20mph because my engine wouldn't allow me to go any faster. The next day it was towed to a Hyundai dealership close to home, Hyundai denied the first claim because they said it was the oil change companies fault. I then called the warranty company and the adjuster came out examined the car he found out that wasn't the case, it was internal damage cause by the manufacturer. Botls came loose that cracked something and metal chips got into my engine. My extended warranty denied covering it because it wasn't basic engine failure it was cause by the production of the vehicle and the faulty bolts that internally damage itself. I resubmitted the claim to Hyundai for repairs since we know now it wasnt outside negligence and the extended warranty company wasn't going to cover it. The advisor told me the second claim was denied as well , after speaking to the consumer affairs department myself they still denied having any part and the faulty engine. I'm in a Facebook community group and these people are going through this daily with Hyundai they are putting bad engines in cars once the original owner finds out they're trading them in and the second owner buys them in the car fails we aren't covered under the powertrain warranty because it only applies to the first owner. Hyundai is ripping people off and stealing our hard worked for money and getting away with it! They're picking and choosing who the engine failure class action lawsuit applies to even though we all have bad failed engines! I have been stuck making payments on a car for 3 months that I cannot drive and I owe $18,000 on a totaled car and they care nothing about goodwill and helping their customers who have spent thousands on their cars.

Was driving 55 mph and engine went into limp mode on busy road almost creating a tear end collision with multiple vehicles traveling at high rate of speed. Cam shaft bolt har sheared off cracking the fuel cover resulting in loss of engine oil. Told this was not covered under warranty but fixable. So fixed that along with front and rear brakes for a total bill of over 3k. Less than 500 miles Later my 21 year old son was driving - engine started clanking loudly the he lost acceleration while traveling a proximate ally 49 mph in heavy traffic. Car needed to be towed and am not being told the engine is blown.

The owner had just left the driveway and was driving up the neighborhood block at low speed in the vehicle when another driver motioned that there was a problem with the car, pointing at the driver's side wheel well. The owner immediately pulled to the curb, exited the vehicle, and saw smoke pouring from the vehicle. Grabbed purse and moved a safe distance away. Spontaneously the car caught fire under the engine before the fire truck arrived 8 minutes later. Huge flames shooting from under the hood were captured on both video and photos. The car is a total loss. Had been well maintained.

My Santa Fe’s verified oil consumption by the dealership is 5 qts every 3148 miles. I was told the oil consumption rate is within specification. I’ve had 3 oil consumption tests done, had pistons soaked and cleaned over 24 hour period, injectors cleaned, and had the engine cleaned with BG engine cleaner. There is black soot coming out the tailpipe, and no power when accelerating. I’m concerned the vehicle will fail while I’m driving and cause an accident. I have contacted Hyundai Customer Service and have a case number. I’m unable to get Hyundai to repair or replace this engine. Thank you for your assistance.

Engine is burning oil. Up to 1/2 quart + every 1,000 miles. No leaks observed.

Vehicle had excessive oil consumption causing catastrophic engine failure. No check engine light came on. Engine stalled on interstate.

The Oil has been burning black for years, the oil has been burning up in between scheduled oil changes, there has been a knocking sound for years, we have advised the Hyundai dealerships and they always said it was the fuel pump or gas cap or spark plugs, these were the only items they advised they fixed and the problem persisted. Independent repair shops advised it was either the seal of the piston rings or engine issue. Hyundai dealers refused to advise if it was an issue with the engine, they also refused to perform a compression test unless it was first authorized by Hyundai corp. The engine finally died and now the car will not run, an independent shop advised there was no compression on Cylinder 2. We opened a case 18967436 with Hyundai Motor Corp since Nov 11, 2021 and to date nothing has been done.

Driving started to smoke pulled over check oil full stick had a mechanic check the car said the engine has locked up

Car loses power when taking off and turning either direction, like when you are getting out into traffic. Very dangerous. Just when you need to accelerate it looses power for a few seconds. Traction control light comes on each time, very briefly. Happens at random times, so it is hard to duplicate and trouble shoot. Service Dept says even if it is a known problem, Hyundai will not fix (still in warranty) unless they can duplicate problem ON MY CAR! And they will charge $150 if it doesn't happen for them.

On Oct. 25, 2021 my family and I were returning from a day trip. I stopped to re-fuel my car and when I got out the engine was making a horrible noise. No lights came on, nothing indicated any kind of issue. I asked my husband and he said it is the engine and told me to turn the car off. We pushed the car to a safe space and took an Uber home. The following day I had the vehicle towed to the local Hyundai dealership. Within a few days I was told the vehicle failed a rod bearing test and that it was being submitted to Hyundai for review and hopeful assistance with replacement because the engine was done. It was indicated that because I had the larger engine and there were no recalls on that one it wasn't likely Hyundai would help but it was worth a shot to try. It took several weeks but Hyundai finally responded and said they would not assist. I was advised by the dealership to file my own claim and argue so I did. It took over a month to get a response from Hyundai despite multiple calls from me and Hyundai basically told me I was on my own. So, I have a blown engine in a vehicle I owe over $16,000 on that only has 103,000 miles. I have taken appropriate care of the vehicle and it has NEVER run low on oil. This is a catastrophic failure with no recourse. Hyundai does not make the engine any longer (gee I wonder why? ) and a remanufactured engine with a 1 year warranty will cost me between $8,000 and $11,000. I have been told by every junk yard within a 200 mile radius that the engine I am looking for is hard to find because they are generally purchased as they come in the door because of such a high need for replacement engines.

I was driving on the interstate with my 2 kids in the car and my car started losing power. I was able to coast off the exit and the car died. No warning lights, no smoke, no noises, nothing. The engine seized up. We provided maintenance records but Hyundai is denying its their fault or a faulty engine. They quoted us $18,000 for new engine

2017 Santa Fe Ultimate with 70,000 miles experienced known oil consumption problem which we monitored and topped off regularly. While driving at approx. 35 MPH, car went into limp mode. Towed (flat bed) to local garage where they confirmed metal shavings in the oil and suggested repairs based on computer diagnostic. Replaced timing chain and some other engine parts. Car driven approx. 100 miles after repairs when engine completely seized (again at low speed in neighborhood). Towed to local dealership for diagnostic on Oct 26, 2021. Dealer confirm engine was seized and needed to be replaced. They also indicated possible AWD differential damage but not able to confirm as car is not currently drivable. 10yr/100,000 powertrain warranty not honored as we were not the original owners. Hyundai offered to cover 65% of engine cost (good will offer), but we are required to pay at least $8,100 of the engine repairs (dealer verbal quote) plus any cost related to differential repairs needed. Est 3 months to complete engine replacement and stated zero warranty on the replacement engine. As of Jan 29, 2022 still no update from dealership as to when car will be available.

Oil consumption excessively after every few hundred miles; caused engine to stall. Engine knock heard. Caused engine to fail.

I was driving on the highway and my car started losing power, I navigated off the exit ramp and the car shut off and would not turn back on. There was no warning whatsoever. No lights, no smoke, no noises, etc. Our engine has to be replaced at 77,000 miles. The dealership is putting the cost on us for replacement. I have seen reports that Hyundai engines are notorious for failure. I read an article that said many recalls involved manufacturing defects that stopped oil from flowing through the engine block. This needs to be investigated. This is absolutley ridiculous. I had my 2 kids in the car and this was very scary and dangerous.

While driving the vehicle on a major city street at approximately 40 mph the stopped running not allowing me to move out of the roadway and almost rear ended by another vehicle. The vehicle was moved out of the road way and towed to my residence. It was found that the check engine light showed code P0014 and P0024 crank shaft issues which caused the vehicle engine to lose power. Vehicle was taken to dealer ship and manufacture was contacted. Note that there had been a prior recall for engine and crank shaft issues. Manufacture advised that the vehicle was out of warranty and that the VIN number was not part of the recall. Manufacture was not willing to take any other action to resolve the problem with the engine issues.

my car feels like it is going to stall when i am sitting at a stop light. the tack drops like the motor is dying out and then picks back up. it has been doing this for awhile. i have an appointment with my local dealer 2/17/22 to take my car in

Engine started using excessive oil. Monitored and refilled as needed. On Sept 15, 2021, Engine completely seized while driving. Took over a month to get appointment at local Hyundai dealership. Towed to dealership and confirmed engine needed to be replaced and possible AWD system damage (can’t confirm until engine is replaced). At dealer since Oct 25, 2021 (now May 2022). Hyundai refused warranty coverage as we are second owners. Dealer advised delay to repairs due to numerous similar engine failures and lack of parts.

This is a Santa Fe Ultimate AWD with the 3.3 l engine. We were driving home and in our neighborhood when the car suddenly stopped with no warning. We had it towed to a local shop and were told the engine had completely seized and needs to be replaced. It was not low on oil and has been regularly maintained. Only 60,000 miles.

Even though my check engine light wasn’t on my vehicle began to stall while I was merging on a major highway. A mile later the car began to smoke from behind made a weird noise and it completely stopped. Me and my 7 yr old stayed stranded on the shoulder of a highway while semis whizzed by at 80 mph. Called roadside assistance but no longer covered so couldn’t be helped while me and my families life was in danger. Case manager at the national office rude unsympathetic and hung up on me. My car is still with the dealer even though it is under warranty and has been with the dealer since September 8,2021 every time I call they give me the run around as I pay $1200 for a rental because they refuse to provide me with one.

Our Santa Fe is losing oil rapidly. This started around 73,000 miles. They have done an oil consumption test and then a combustion chamber cleaning, neither worked. It showed that our vehicle is consuming 1 quart of oil every 647 miles. This will cause the engine to dry out and eventuay fail. They told us we need an engine replacement, but Hyundai will not cover it. They told our local dealer to reach out to our extended warranty. They may not cover it. They need more tests run, but at our expense. After researching online, I found out this is a known problem with these engines. Others have complained and they even state that this problem occurs at about 74,500 miles. I cannot believe that Hyundai is not being he'd responsible for these repairs. This is a potential hazard, especially if someone doesn't realize they are losing oil. Most people don't regularly check their oil between changes, this is a huge hazard. We do check ours and found the problem. Hyundai is installing faulty engines and they should have to repair them, not the consumer.

The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving 50 MPH, the vehicle loss power. The vehicle was towed to an independent mechanic where it was diagnosed that the engine had seized. The vehicle was towed to the dealer where they confirmed the diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.

Starting in September we have been documenting my engine burning, not leaking, oil at an alarming rate. I am currently losing 2-3 quarts of oil every 2 weeks. I have submitted a claim through Hyundai Corporate through the CDI engine recall program and they are denying my claim because "I'm out of warranty." The recall is supposed to extend the warranty for these issues but they are refusing to honor the terms of the recall. My car smells like burning oil and I've been told not to park inside my garage or near my home as the car is a fire hazard. I have attempted resolution by contacting the entire chain of command at Hyundai including Omar Rivera (Director of Quality and Service Engineering), Barry Ratzlaff (VP, Customer Satisfaction), and Jose Munoz (CEO and President).

The engine in our 2017 Hyundai Santa Fe SE 3.3L V6 has always had problems with lag/ hesitation when accelerating from a stop from the very beginning of ownership (first owner). This was always dismissed by Hyundai's mechanics as not actually existing, although it did lag constantly. I know many other have reported similar issues so, I include this only that it could potentially be an early sign of a manufacturers defect leading to larger problems later? Now, we regularly change the oil in our Santa Fe and have never seen a single warning light outside of tire pressure warnings. But on 7/29/21, with our vehicle just out of warranty at 112k miles, while accelerating to freeway speed from an on ramp at 60 mph multiple warning lights came and at the same time there was a very large bang from the engine and a large amount of smoke came from under the hood, enough to seriously affect the vision of drivers behind me. There was a very rapid lose of speed and I also observed things falling from the vehicle in the rearview. I luckily managed the vehicle to the shoulder and quickly got out. I thought vehicle was on fire, it may have been, the smoke kept up for 5-10 minutes. At this point the car would not start or run and a large pool of oil and or coolant formed underneath. It was towed to a Hyundai dealer and the prognosis was a broken connecting rod that had blew a large maybe 5" diameter hole through the bottom of the engine. And now, despite providing proof of recent oil changes, Hyundai has dismissed any manufacturing issues from causing the issue and sighting the problem was from lack of maintenance because of sludge in the engine. Although to my understanding sludge can also be produced rapidly when contaminants, like coolant, from bad valves or head gaskets, enter the oil. When I asked about this the technician literally just didn't answer. So, now we currently owe $7k on a vehicle needing repairs at the quoted price of $8-$14k and Hyundai has closed our case.

As I was driving on the freeway, I heard something that sounded like a bomb go off overhead. I safely pulled over and discovered that my panoramic sunroof had exploded. There were no other vehicles nearby that could have kicked up anything, especially because it was directly overhead. Thankfully I had the interior closed, but if it had been opened myself along with my 4 passengers (three who are young children) would have been covered in glass shards not to mention I could have ran into the wall or something else. Upon investigation, this is a known issue with Hyundai sunroofs. I have not yet been able to have anyone inspect it since it is Sunday. There were no warnings at all that this was going to happen.

Took 2017 Sante Fe to dealer for a oil change and to look into an intermittent hard shift from a stop. During test drive dealer stated car engine warning light came on and vehicle stalled, mechanic was able to steer vehicle to side of road, vehicle would not restart, after several hours they informed me that engine had seized and would need to be replaced.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while operating the vehicle, a knocking noise was present coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the engine bearings had failed, and metal particles were discovered in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was included in NHTSA Campaign Number: 17V578000 (Engine and Engine Cooling). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 74,400.

Dealership suspects "Rod Bearing Failure" due to knocking, loss of power and metal flakes in oil. Just 400 miles before oil was changed at dealership with no mention of issue. Technician claimed it just didn't happen, its been going on for some time. There is no mention in any service history of 4 years between the 2 dealers that it was happening. Total engine failure will happen (engine will seize). It matches the recall done in November 2017, #168 by Hyundai on a "certain" Santa Fe with the 3.3L engines. If the engine seized while driving, it could have caused an accident. Hyundai Corporate said I was the 2nd owner, warranty ended at 60,000 miles... I am owed nothing. No warning light or knocking happened until the afternoon of 8/9/21. Then the dealership took possession at 1st available date 2 days later and inspected it.

The engine had a catastrophic failure due to bearing failure with no advanced warning lights. The issue occurred while accelerating to merge into highway traffic. The engine had an immediate drop in power and produced a searing grinding noise. The drop in power forced my speed from 55 to 35 mph in a matter of secondS. I had to negotiate across 3 lanes of traffic in order to exit the highway to find a safe stop to contact roadside assistance. Some smoke was coming from the engine but no fire. Prior to the incident, the vehicle had been driven <3 miles in local stop/go traffic from a cold start. Roadside assistance towed to local Grayson Hyundai Dealer who inspected the engine and determined the bearing failure within two days. The check engine light came on at the same instance as the engine failure. There was no advanced warning even though Hyundai performed a recall that updated software to specifically detect and alert to potential failure. Car is still awaiting warranty repairs by dealer. Dealer will not provide any written details to me or provide any cost or timeline estimates for the repair. While the failure occurred within the manufacturer’s 5 year/60K mile warranty, the warranty has now expired in the 5 months it has been waiting to be repaired.

The engine lite came on, there was a lost of acceleration, the vehicle stalled when slowing down for a stop light or stop sign, There was a ping noise evident with the engine. I didnt trust the vehicle had it towed to the mechanic. The mechanic noted you have only two quarts of oil in the engine. This mechanic performed all routine maintenance, rotations, oil changes, checking fluids etc. There were no signs of oil leaks and or burning of oil with the exhaust. I then sent the car to the dealership for their own review. They confirmed the engine failure and the ping noise was the rod due to lack of oil. The dealership files a claim with Hyundai #PA102790, the claim was denied and still has not provided a reason for the oil loss which was the reason for the failure of the engine. There were no indicator lights noting low oil pressure or the engine is overheating, the engine lite came on in the morning and just like in A MANNER OF COUPLE OF HRS the engine started the symptoms noted above. The dealer ship gave Hyundai's complaint line, but after reading the problems associated with the Engines with the sante fe what is the point to call them?

When making a sharp right turn and accelerating the car hesitates then catches and accelerates suddenly. It can be very scary when trying to turn onto a busy road. The issue is repeatable.

Unknown