2025 Hyundai Santa Fe Complaint Log

On two occasions, five months apart, the windshield cracked for no apparent reason. No foreign object hit the windshield. The replacement was NOT a generic. If was a Hyundai OEM. Two cracks, which spread over the windshield is not “normal”, in my opinion. Thank you

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving at slow speeds, the vehicle independently accelerated while the accelerator pedal was only lightly depressed. There were no warning lights illuminated. The vehicle was taken to a dealer, where the pedal sensor was adjusted. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.

P245/45/21 pirelli scorpion AS NCS sidewall on 3 tires has large bubble after 14,600 miles. Hyundai dealer advised of findings. Replaced tires at my cost. Many problems reported on this issue for the Hyundai Santa Fe 2025 Calligraphy model. No other tires options available to fix this on going problem.

The tire sidewall developed a bubble in it. The tire is only 3 months old.

While I was driving on the highway, a diagnostic trouble code (DTC) related to the blind-spot safety system appeared.

Vehicle exhibits delayed deceleration after releasing accelerator. Engine RPM remains elevated for several seconds, causing the vehicle to continue applying power unexpectedly. Issue began after recent repair and was not present before. Condition is intermittent but reproducible and affects drivability.

I am writing because my local Hyundai dealer is failing to make the repair in a timely manner consistent with what my recall notice stated, and is requiring that I make TWO trips to Hyundai in order to get this NECESSARY recall work completed. Meanwhile, if the camera fails, it could put me and others at risk. My service representative, [XXX] , and his service manager showed ZERO concern about my time or possible dangers if the rear camera fails, stating that it's Hyundai corporate that made the policy that customers must have their car inspected and photos taken of the rear camera harness assembly during this first visit, BEFORE ordering the parts under my vehicle's specific VIN number. Once they do this and submit it to Hyundai corporate, they say, the parts will be ordered and I will be contacted AGAIN to make yet ANOTHER appointment to have the parts installed. My letter from Hyundai says NOTHING about having to make two visits. It says to schedule an appointment, and the recall work will be done. I actually tried to call the 855 Hyundai number to schedule the work, and that operator said nothing about two visits; she was unable to book the appointment she'd given me, so directed me to the local Hyundai dealer, who also said NOTHING about two appointments being needed to have this recall work done. I am concerned, because i am scheduled to drive out of town in a high pedestrian and vehicle traffic area in two weeks and was doing my due diligence to get the recall work done before the trip. I feel that the two appointments are unnecessary when EVERY 2025 Hyundai Santa Fe with this feature is equipped with the same rear camera and rear camera harness assembly, such that there's no reason to have to FURTHER register it with my VIN, that this could all be done in one appointment. Requiring customers to come for 2 appointments--especially without telling them anywhere in the letter or during 2 phone calls--simply increases risk of injuries if the camera fails. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Traveling in a 55 zone on Rt 27 and my vehicle lost power and said pull over and charge vehicle with engine on. I did this once and the battery went up to half way charge then I could start to drive again. Less than a half a mile up the road climbing a good size hill by the town’s salt shed—the same issue occurred. I had to pull over again and allow battery to recharge. This is not a complete hybrid, it has a gas engine not sure why the hybrid and gas are not syncing up. Many users on the internet have reported the same issue that I have experienced. Someone needs to investigate this before major injury occurs.

This complaint goes with my issue 11727421. After I replaced my driver from in [XXX] , my passenger front blew out on XX entrance ramp from the expressway north of [XXX] . Called [XXX] and AAA took us to [XXX] . Replaced tire next day. Two tire failures on the same trip! This one was scary. Very busy highway there north of [XXX] . We were on the inside lane with little room to guardrail. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

255/45R20 We had a front driver tire get a bubble on our way to Florida. Had it replaced in [XXX] . On our trip back we had a blowout to the passenger front on XX just outside of [XXX] , in a very vulnerable area on the left side of the road. Called Hyundai SOS and they had AAA come. Got my wife out through the drivers door and over the guardrail while we waited. Called [XXX] as the traffic was flying by and the car has very little room on the berm. The tire blowing had no warning. Got a new tire the next day in [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Second row power seats will operate even when a carseat is present & installed using LATCH system, crushing occupant. Power seat button at base of second row seats are easy to inadvertently press while entering/exiting the seat (i.e when seat belt is not on), causing the seat to move forward crushing occupant. This has happened multiple times since taking ownership.

The 2nd-row seats in the 2025 Hyundai Santa Fe Hybrid Calligraphy feature motorized recline and folding functions. My testing reveals a significant safety flaw: the motorized "Seat Slide Forward" and "Rear Cargo Fold Down" buttons do not appear to have functioning pinch sensors and do not automatically disable when a passenger or object is detected. Specific Incident: On [XXX], while my [XXX] son was entering the vehicle, the "rear access" button was accidentally triggered. The seat began folding and sliding with him in the path of travel; the motor did not sense his presence or stop automatically. Fortunately, he was not yet buckled and was able to jump out of the way before I manually reversed the action. Technical Findings: Based on further testing (see attached results), any car seat installation would be severely compromised if these buttons are pressed. While the vehicle's system is aware when a seat belt is buckled, it fails to use this logic to lockout the motorized folding functions. All motorized movement should be disabled for any seat where the buckle is engaged to prevent injury to occupants or the structural compromise of a child safety seat. This issue is similar in nature to the recent recall of the 2026 Palisade (NHTSA ID: 26V160000). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Have had two sidewall bubbles appear, one was right front tire with approximately 7000 miles, second was left front tire with 11,500 miles. Both were OEM equipment on 2025 Hyundai Santa Fe hybrid limited fwd. Tire size 255/45/R20. No blowouts. Replaced tires at great expense and inconvenience immediately upon finding bubble on sidewall.

The contact owns a 2025 Hyundai Santa Fe. The contact stated that after parking the vehicle, the button was pressed to fold the second row passenger seat while the [XXX] daughter was still seated. During the incident, the electronic folding seat began to fold down onto the daughter, causing extreme distress to the child and crushing her into the seat. The button was pressed, which stopped the seat from continuing to fold down, and the child was freed from the seat. No medical treatment was required. The vehicle was taken to the local dealer, who examined the seat and determined no failure had occurred. The contact was informed that although the incident was extremely dangerous, the electronic folding seat had operated as intended. The contact was informed that the seat belt needed to be buckled to avoid the problem in the future. The manufacturer was notified of the failure, but no assistance had yet been offered. The contact indicated that a similar incident resulting in a fatality had occurred in the Hyundai Palisade vehicle. The failure mileage was 20,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

With only 3320 miles on vehicle have a Bubble on sidewall didn't hit anything. P 255/ 45 R 20 105V Pirelli States could happen if it was a pothole.

All normal sounds completely stop working, no audio or volume at all: no turn signal, no collision warning, no GPS audio, no radio; no hands-free phone volume. Hyundai Service department advised they have never heard of this type of incident. All warning systems are completely silent.

Side view camera that displays blind spot area in dash screen cluster, screen intermittently shows just a green screen and not the blind spot.

I was driving on a 5 Lane Highway when suddenly what sounded like a gunshot or grenade going off in my right ear turned out to be my sunroof shattering. I thought someone shot at me since there were traffic on my right, but when I looked to my right I saw no evidence until I looked up, then immediately felt glass particles falling in all around.

Vehicle experienced sudden loss of power while driving. Transmission warning and ABS warning lights appeared at the same time. The vehicle would not shift properly and began skipping and dropping gears. Smoke was visibly coming from the center underside of the vehicle near the transmission area. There was a strong burning oil or rubber smell inside and outside the vehicle. This created a serious safety risk due to loss of acceleration and potential fire hazard from smoke and burning odor. The issue has been intermittent since early ownership, including jerky shifting and hard engagement. The dealer documented dual clutch transmission communication faults and ABS faults but returned the vehicle the same day stating it was a loose ground. The problem has continued after repair. Vehicle is available for inspection. The defect involves the powertrain and related electrical systems.

I was sent a letter in the mail asking to bring in my vehicle for a safety recall involving the rearview camera. I scheduled an appointment with Key Hyundai of Milford, CT. After waiting for an hour, I was told that the dealership did not have the part needed to perform the repair and that they would call me when the part came in. It has been three weeks and I have not received a call or been contacted in any way. I got the sense that because this was not a paid service it was a very low priority for the service department. Because of that, I feel reluctant to trust the dealership with the repair.

The driver attention warning incorrectly emits loud alarms, a coffee cup icon, and suggests the driver take a break. These warning alarms are not based on any discernable lack of attention, erratic driving, etc. They are RANDOM and ongoing, and when they begin, they repeat every few minutes. On this 2025 model - unlike prior years and models - this cannot/cannot be adjusted or turned off according to every level of Hyundai dealer staff. This has become an intolerable, frustrating, aggravating safety hazard that makes a driver irate, impatient and angry. This type of "warning" should be reserved for an imminent crash warning, or sudden lack of oil pressure. Please ensure that this safety hazard is eliminated. Thank you

I purchased a brand new 2025 Hyundai Santa Fe Calligraphy from the dealer and I saw a the tire pressure drop from a normal 36 psi to 32 psi and the vehicle would vibrate. I filled it up right away thinking due to weather. Then, it dropped again after a couple of days to 32 psi and vehicle would vibrate again. I took the vehicle to Costco to get it inspected thinking it's some sort of a slow leak and vibration could be due to 32psi pressure. When Costco tried to repair the tire, the sidewall failed on the tire. Costco said I needed a new tire. When removing another tire, the same thing happened, the second tire sidewall broke as well. I ended up getting all new set of tires, which ended up costing me $1350. They informed me that these are Pirelli's tires and is known to have vibration at high speeds and could develop buldge and shows signs of early deterioration and abnormal wear problems. I found the same thing after doing some research. I provided the Costco report to Hyundai National Consumers affairs along with the pics of the tire. They told me go to the dealer first and upon arriving at Hyundai dealer, they weren't really interested in knowing what happened since I didn't purchase a tire warranty plan. I spoke to Hyundai consumer affairs and they said there's nothing they can do either since I didn't have tire protection purchased from them. This is a brand new vehicle with factory installed tires and for them to just not take responsibility for selecting a poor supplier that is known to have these issues shows they don't care about the customers at all. I have been a long time loyal customer of Hyundai for at least 10 years. This was my 3rd Hyundai vehicle and if they don't resolve this then this will be my last Hyundai vehicle

After making right turn after being stopped at traffic light, when I attempted to accelerate the vehicle would not shift from low gear to higher gear(s). This caused very high engine RPMs for the time it took to pull the vehicle off to the side of the road and stop and turn of the vehicle . I looked at dash board for any indicator lights but didn’t see any. Restarted the vehicle accelerated back on to the road and the vehicle did change gears ok. Again looking for any dashboard indicator to be on but didn’t see any. The date of this incident was [XXX]. Made appointment on 2/10/26 for service to diagnose why this incident happened on 2/17/26 and to provide any necessary repairs at Columbia Hyundai, Cincinnati, Ohio. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting premature tire wear on OEM Goodyear Assurance 235/60R18 tires installed on my AWD 2025 Hyundai Santa Fe SEL (VIN: [XXX] ). Component/System: OEM tires; documented and can be inspected at the dealership, which serves as a neutral, third-party verifier, or via submitted records. Safety risk: AWD vehicles require uniform tires; uneven tread risks drivetrain damage and unsafe handling, endangering myself and others. Confirmation: PA state inspection (11/17/2025) at 6,172 miles: Rear 3/32”, Front 5/32”. Dealer Delaney Hyundai (RO# 494892) documented the issue. Current mileage 7,074; tread wear ~1/32” per 881 miles, estimated current depth Rear 2/32”, Front 4/32”. Inspection: Documented by dealer and PA inspection; no manufacturer inspection yet. Warning symptoms: None beyond premature tread wear. Phone attempts to manufacturer: [XXX] (10:54, 7 min, snarky, refused escalation), 11:02 – 15-min hold no answer (son’s phone 8 min hold); [XXX] (11:17, 35 min), insisted on retail Goodyear center, finally agreed to supervisor callback (24–48 business hours). Requested resolution: Corporate review and replacement of all four OEM tires, including mounting, balancing, and disposal, coordinated with dealership documentation and PA inspection. No retail Goodyear referral should be required; inspection is only for verification as part of corporate review. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I tried to drive my 2025 Hyundai Santa Fe Hybrid; the vehicle displayed a gear selection error message stating something like "gear already selected". The vehicle would not shift properly and would not power off or restart. I attempted multiple shutdown and restart attempts using the Start/Stop button with no success. The vehicle remained in this condition for about 30 minutes and would not allow normal operation or shutdown. Due to safety concerns, Hyundai roadside assistance was contacted and a tow truck was dispatched. Before the tow arrived, the vehicle spontaneously allowed shutdown without any intervention. This was a safety related failure involving the shift-by-wire system and vehicle power-down logic. The issue occurred without warning and left the vehicle inoperable. The vehicle had app 7150 miles at the time of the incident.

NHTSA Complaint Summary Vehicle: 2025 Hyundai Santa Fe Issue: Airbag non‑deployment in a 40‑mph side‑impact collision On January 20, 2026, my 2025 Hyundai Santa Fe was struck by another motorist directly along the driver side awaiting to make a left turn. The other motorist crossed the centerline at an estimated impact speed of approximately 40 mph, according to the police report. The collision caused significant damage along the front and entire driver side of the vehicle. Despite the severity and direct nature of the impact, neither the side curtain airbags nor the front airbags deployed. The impact was so much that the other motorist ended up behind my husband in the left turning lane once he stopped. My husband, who was driving, suffered a head abrasion and a concussion from the force of the impact. Since the crash, he has continued to experience persistent headaches and intermittent dizziness when standing, which began immediately after the collision and have not resolved. The lack of airbag deployment in a high‑energy side‑impact crash raises concerns about a potential malfunction in the airbag sensors or side‑impact detection system. This incident presents a significant safety risk, and I am reporting it so NHTSA can evaluate because as I've researched there have been other incidences of similar non‑deployment issues are with 2025 Hyundai Santa Fe vehicles. I can provide photos, the police report, medical documentation, and repair estimates upon request.

Front wipers of the vehicle stopped working with snow buildup. This was solved once by tightening a bolt but happened again while driving

My name is [XXX] I live at [XXX] my phone number is [XXX] my social security is [XXX] . I own a 2025 Hyundai Santa Fe that is subject to Safety Recall 25V-808 involving the rearview camera system. On [XXX] at 12:30pm while operating my vehicle, the rearview camera malfunctioned (the image was [blank / inoperative]). Due to the loss of rear visibility, I was involved in a minor accident while backing up. At the time of the incident, I had not yet received the recall repair. The malfunction experienced is consistent with the defect described in the recall notice regarding the rearview camera harness. This incident caused [minor vehicle damage / property damage. I am reporting this to document a safety-related incident connected to an acknowledged manufacturing defect.I am requesting that this incident be reviewed as a recall-related accident and that Hyundai advise on reimbursement or compensation options. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a serious safety concern with my 2025 Hyundai Santa Fe Hybrid Calligraphy (VIN: [XXX] ). While my child was seated in the second row, the folding seat button was accidentally triggered and the seat continued folding while my child was still in the seat. My child screamed in distress, and I am concerned this created a pinching or crushing hazard. This appears to be a dangerous condition because the seat continued moving even though a child occupant was present. The button may also be too easy to trigger during child entry or exit. I believe this issue should be investigated before a more serious injury occurs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dear NHTSA Team, My car was in a minor accident Last. After that, the repair shop replaced my bumper and front camera. Don Franklin Somerset Hyundai performed a calibration on my new radar. They calibrated it six times, but there are still many issues with the HDA driving system. 1. False Dual-Side Warning When a vehicle is present only on the right side, the vehicle camera system incorrectly detects vehicles on both the left and right sides. In reality, there is no vehicle on the left side. In this scenario, both the radar warning and the camera detection are incorrect. 2. Wrong-Side Warning In some cases, when a vehicle approaches from the left rear, no warning is issued on the left side, while a warning is incorrectly displayed on the right side. In this scenario, both the radar warning and the camera detection are incorrect. 3. False Warning During Smart Driving While driving on the highway using the smart driving function, when the vehicle is required to turn left or right, the system may generate a false dual-side warning. As a result, the vehicle aborts the intended left or right turn and continues driving in the center of the lane. In this scenario, both the radar warning and the camera detection are incorrect. 4. while driving manually (without HDA engaged) or parking, the vehicle shows left-side or right-side collision warnings without clear cause. I reported these issues to Hyundai USA approximately three weeks ago. I was instructed to bring the vehicle to the dealership for inspection. However, during my recent visit, the dealership representative only reviewed the videos I provided and concluded that no issues were present, without conducting a physical inspection or test drive of the vehicle. Given the ongoing safety concerns and lack of proper diagnosis or resolution, I am submitting this complaint for your review and assistance. Thank you for your attention to this matter. Thanks, Best Regards, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle intermittently fails to reverse properly, hesitates, jerks, and at times locks despite no obstruction present. This occurs during normal use and creates a serious safety concern, particularly when backing out of parking spaces or into traffic. In addition, the vehicle exhibits ongoing electrical issues, including intermittent warning lights, rearview camera distortion or failure, inconsistent system operation, intermittent inability to unlock using the key fob or door handle, and the vehicle fan or air system continuing to run for extended periods after the vehicle has been turned off. These issues occur without consistent warning and have not been resolved despite multiple service visits. The vehicle is also subject to an active safety recall (NHTSA Recall 26V218000, Manufacturer Recall 298) involving the front seatbelt anchor. The recall remains unrepaired, with no remedy currently available. I have personally experienced the seatbelt becoming stuck and not releasing properly, which presents an additional safety risk. The vehicle also experienced a battery failure. I was initially informed that the battery could not be replaced without cost; however, it was later replaced. Despite repeated concerns, the hybrid battery system was not tested or evaluated, and this remains an unresolved issue affecting vehicle reliability and safety. Additionally, the vehicle has experienced tire tread separation and peeling requiring replacement. This is not consistent with normal wear and may indicate alignment, suspension, or other underlying vehicle-related defects. The vehicle has been inspected by the dealership multiple times; however, the issues were not reproduced and no corrective repairs were performed. These problems are intermittent and occur during regular day-to-day operation. Collectively, these unresolved issues present an ongoing safety risk to the driver and others.

This car was in a BBB binding Arbitration and Hyundai was told to fix: speed control malfunction, speed linit not posting to hub arbitrary fan engagement. The Dealership ALM West had the car 2 weeks and the car sat on their lot. They said we are unable to duplicate the problem. Now in addition I showed them the cracked windshield and they were not responsible. I had an insurance complaint I took it to Safelite and replaced the windshield yesterday and I got it back with a new windshield and it also had a Crack in the replacement windshield. I think Hyundai knows there's a problem with the glass which is also part of the safety system of the car.

My 2025 Hyundai Santa Fe Hybrid has recurring powertrain communication failures starting at only 67 miles and continuing at 5,300 and 6,200 miles. Diagnostic trouble codes include U010100 (lost communication with engine control module) and multiple U100xxx codes related to transmission and CAN bus communication failures. These indicate loss of communication between critical control modules. The issue has happened multiple times and remains unresolved. I am concerned this could cause drivability problems, warning lights, or sudden loss of power. This appears to be a system-level defect in the vehicle’s communication network.

Immediately following routine maintenance performed at an authorized Hyundai dealership, my 2025 Hyundai Hybrid Santa Fe Calligraphy experienced a complete loss of engine oil, which resulted in the engine shutting down while driving on a highway. While traveling at highway speed with my minor daughter, the oil pressure and engine warning lights illuminated, followed by multiple error messages. The vehicle rapidly lost power, and I struggled to safely maneuver it onto the shoulder while high-speed traffic was passing. This created an immediate and life-threatening safety situation, with a real risk of being struck by other vehicles. We were stranded on the roadside for over three hours awaiting a tow, exposed to ongoing traffic danger. The dealership later advised that the incident was caused by a faulty Hyundai-supplied part, not driver error, misuse, or lack of maintenance. The vehicle had only approximately 4,000 miles at the time of failure. A sudden engine shutdown due to oil loss at highway speeds presents a severe risk of collision, injury, or death, especially when it occurs without warning. Given that a Hyundai component is implicated, I am concerned this may represent a broader safety defect affecting other vehicles. This incident caused extreme distress and endangered both myself and my child. I am submitting this complaint so that NHTSA may evaluate whether this issue warrants regulatory review or further investigation.

I was driving at on the highway no other cars around going 80mph and the sunroof spontaneously shattered without impact. Distracting me with a loud bang and glass flying I had my wife and two kids in the car it’s a major safety issue. I’ll repeat the sunroof spontaneously shattered without impact of rock or debris. And I was traveling at a speed of 80mph on a clear highway. Distracting me with the loud bang and glass flying in and over my roof of the car

Within a month of purchasing the vehicle [March of 2025] I was having a windshield replaced due to a crack. After I had that one installed, it needed to be replaced due to scratches on the windshield [safelite warrantied it under faulty glass]. Now within 2 weeks I have had 2 small impacts and 2 chip/cracks filled. I have never had issues with windshields in my driving career thus far like this. I understand windshields can pick up rocks and what not but searching online it doesn't seem to be an isolated incident at all. I think Hyundai may be using cheap glass or something. This is very frustrating because im constantly looking anytime I hear an impact on the windshield. Also, I do not want to be constantly calling safelite for chip repairs

While driving on a service road at approximately 45 mph, the corner side glass on my 2025 Hyundai Santa Fe shattered suddenly and without warning. There was no impact from a rock or object, and no other vehicles were present that could have caused debris. We had just entered the service road, and road conditions were normal. My [XXX] was seated in the front passenger seat at the time of the incident. The glass shattered inward, and the only thing preventing glass from entering the cabin was the window tint holding the shattered pieces together. This presented a serious safety hazard, as occupants could have been injured if the tint had not contained the glass. Once parked in my garage, I took pictures and tried to examine the damage but the window was still crackling and popping. My husband was able to inspected the window immediately after he returned home and confirmed there is no visible rock chip or point of external impact. The fracture pattern appears to originate from inside the glass or along the edge, consistent with a stress fracture or defect rather than road damage. This failure occurred under normal driving conditions with no accident, no debris strike, and no extreme temperature change. The sudden shattering while driving posed a significant risk to driver control and passenger safety, especially with multiple children in the vehicle. I am also aware of other owner complaints involving unexplained glass cracking or shattering on Hyundai Santa Fe vehicles, which raises concern that this may represent a broader defect rather than an isolated incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle has two display panels, molded into a single frame. There is an infotainment panel on the right that handles music, maps, and phone interaction. There is an instrument panel on the left. The infotainment panel has not issues. The instrument panel blanks out for 3 - 5 seconds every few minutes, and then reappears. Occasionally the words "No SIgnal" in big red letters will appear. Occasionally the gear selection letter will remain on the otherwise blank screen. The screen also shudders / tears occasionally before blanking. It does this whether the vehicle is moving or parked. I purchased the vehicle used, Jan 2 2026. I noticed the problem a couple of days later. It has continued. It is not getting any worse or any better.

My car was locked and battery had died. I was able to get in car with key from fob. I had to put car charger on battery in order to start car. This car is a year old with 18,531 miles

There is a terrible squeaking noise coming from the steering column. It feels like the car is unsafe to drive

Car had an unintended acceleration. I had been stopped prior to entering my garage. I had started to slowly accelerate when the car accelerated hard. It took a lot of effort to stop the car.

Pirella extra load radial tubeless R85133 255/45 R20 105v MS I have had two tires from this same line that has sidewalk bubbles and two tires that have completely been blown out all within one year... four tires in one year with problems.

I am reporting a safety hazard with the Driver Monitoring/Driver Assistance system in my 2025 Hyundai Santa Fe SEL (VIN: [XXX] ). The system frequently misinterprets my normal driving behavior as inattentiveness and triggers constant, loud beeping while I am driving. In many cases, it also disables assistance functions mid‑drive, which is dangerous and unexpected. The false alerts appear to be caused by the system misreading my eyes due to their natural shape and size. This issue does not occur with my wife, who has larger eyes, which indicates the system is biased toward certain physiologies and does not reliably detect all drivers. I have tested this repeatedly: if I strain my eyes unnaturally wide, the alerts stop, but this is extremely uncomfortable and only sustainable for a few seconds. The system is effectively pressuring the driver to adopt unsafe, unnatural behavior to avoid constant alarms. Environmental conditions such as sun glare, rain, and darkness make the false alerts even more frequent. The sudden loud beeping is startling and forces me to divert attention from the road. The unexpected loss of assistance features during driving further increases the risk of an accident. This system is not functioning as an assistive feature. Instead, it creates distraction, encourages unsafe compensatory behavior, and fails to accommodate normal variations in driver physiology. I request that NHTSA investigate whether Hyundai’s driver monitoring system meets safety and reliability standards and require corrective action if necessary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

As I was driving I heard a pop the front driver side tire popped from side wall And the back driver side tire has a big bubble in it and I did not hit any pot holes 2 tires on the same side failed on me and my car only has around 1500 miles one pop and one has a big bubble on a new car

Driving in light rain at 65 mph , drivers side wiper failed after using AUTO feature. Occurrd 12/23/20125. Wiper was fixed by dealership under warranty on 12/26/2025. 3 weeks later on 1/12/2026 very same situation occurred and exact same malfunction happened yet again. Drivers side wiper total non-operational again. Taken back to the dealership for repair and the Dealership said with 100% certainty issue was caused both times from ice and and snow buildup ans will not submit under warranty. Vehicle is garage kept ( heated) and had absolutely no ice or snow on the vehicle upon operation. Weather was 40+ degrees both days when malfunction occurred. Safety issue was serious due to my wife now unable to see through the window potentially causing an accident during adverse weather conditions.

Windshield has crack starting in lower left corner cracking upward to the right. 2nd cracked sine May 2025. Reported 1 crack previously

I am submitting this complaint to formally report ongoing and unresolved vehicle safety defects involving a leased 2025 Hyundai Santa Fe. These defects include persistent toxic or chemical odors inside the passenger cabin, electrical and body control system malfunctions, and unintended vehicle operations that present serious risks to occupant health, vehicle security, and public safety. Despite multiple service visits and repeated requests, Hyundai dealerships have refused or failed to conduct comprehensive diagnostic testing, leaving the vehicle in an unsafe and unreliable condition.

The adaptive cruise control does not allow the use of sunglasses to be worn while the cruise control is engaged. The cruise control will immediately shut off when sunglasses, and some prescription glasses are worn. This is a safety issue as you are not allowed to wear sunglasses on a sunny day or when the sun is low in the sky and it is below the car's sun visor. The same camera that is looking at the drivers eyes also controls other safety features and disables them when the driver is wearing their sunglasses, and some prescription glasses as well

I was trying to merge with 70 mph traffic and could not accelerate last 35 mph. Apparently a speed limiting feature came on that has never came on before decided to engage. My daughter and I were terrified and pulled over and googled what the heck had happened. We went into the settings and this feature was not selected at all so I have no idea why it decided to engage itself.

My 2025 Hyundai Santa Fe Hybrid with 1724 miles was unresponsive in the garage. Not able to get in the car because the 12v battery was completely drained. Hyundai dispatched a tow truck to take it to the local Hyundai dealership. A service provider did call me to let me know the car was there. He also told me that apparently this problem I had was a known issue with the 2025 Santa Fe Hybrids. I had no advance warning of any imminent problems with the battery.