2024 Kia EV9 Electrical System Problems

BPM warning in the KIA app. Apparently, ICCU and battery failures are t known issues with the KIA EV9s.

My vehicle popped up a red vehicle warning to check the electric vehicle system. It would no longer charge, was taken to the dealership where the emergency notification was sent :suspected condition with your EV9's Battery Management System has been detected and charging has been limited. A full system check is recommended. Please schedule an appointment with your local Kia dealership as soon as possible. And another CRITICAL EV WARNING your EV battery has a critical issue contact roadside assistance. This is a 2024 and has a total battery failure.

I would also like to highlight the serious safety concern due to cell deviation (imbalance) along with SOC (State of Charge) mismatch as per my car's BMS (Battery management system) which is present in my vehicle and shared with Kia corporate. In an electric vehicle, the high-voltage battery cells, the Battery Management System, and the battery coolant system function as a single integrated safety-critical system. When battery cells are imbalanced and there is a significant mismatch between the state of charge displayed to the driver and the lower usable energy calculated by the Battery Management System, the weakest cell can reach its safe operating limit under normal driving load even though the dashboard indicates sufficient charge. If this condition is combined with a battery coolant system fault, such as low coolant level or air in the cooling circuit, battery temperatures can rise unevenly and further reduce safe operating margins. To protect the battery and prevent thermal or electrical damage, the system must immediately limit propulsion or enter a reduced-power (“turtle”) mode without driver input. Because these protective actions can occur suddenly and without advance warning, they can restrict acceleration or vehicle speed during ordinary driving conditions such as merging or maintaining highway speed, creating an unexpected loss-of-propulsion safety risk rather than a mere inconvenience. This is equivalent to a faulty fuel gauge for a gasoline car but with more immediate and severe consequences Sudden Power Cutoffs: If a single battery cell's voltage drops below a safe threshold, the Battery Management System (BMS) will shut down the entire pack to prevent permanent damage. This can happen even if the dashboard shows 25% or more remaining, potentially leaving you without power while driving. Loss of Vehicle Control: A sudden shutdown can lead to a loss of power steering and braking assistance, which is hazardous in high-speed or heavytraffic situatio

The DC charger plug won’t release after charge was completed. Waiting 3.5 for the tech to forcefully unplug and broke the charger pins. This is a known issue with Kia vehicles and costly repairs.

Battery Management System - Critical EV Battery Warning This vehicle has been back to the dealership for repairs multiple times. Including needing to swap battery cells and wires around.

Received the following warning on 8/16 with 6987 miles on the car: Critical EV Battery Warning Your EV Battery has a critical issue. Contact Roadside Assistance as soon as possible. Car has been in the dealership for a week with "no estimated repair timeline" due to the battery cells failing. Car will not fully charge and is at risk of suddenly losing power and stopping, per the dealer.

While driving, the vehicle suddenly lost power and could not accelerate normally. The speed dropped and got stuck around 12–25 mph even when pressing the accelerator. This happened multiple times, usually during hot daytime conditions. It created a serious safety risk, and one time another car almost hit me from behind because my vehicle slowed down so suddenly. The dealer has inspected the car several times but said they could not reproduce the problem. Warning messages such as “Power Limited” appeared on the dashboard when the failure occurred. I also recorded multiple videos of the problem when it happened.

The instrument display panel goes black and you can’t see speedometer or hear turn signals etc.

I was driving and the car suddenly gave a number of error messages, and I could not drive above 40 miles an hour on the freeway. This was very unsafe. I had it towed to the dealership and they replaced the ICCU Unit, which appears to be a very common problem with Hyundai/Kia electric vehicles. The ICCU unit does not power the car. It should not have affected the car's performance.

I was driving around 60-65 mph on the highway when suddenly a warning alarm went off and the warning light read “stop vehicle and check brake system”. I took my foot off the accelerator and car continued to maintain speed. The power brakes did not work. I put the car into neutral hoping that would slow it down, but it continued to maintain speed. I went into the right lane and put on my hazards. When I had the opportunity to pull into the breakdown lane, I did so and was able to push the brake pedal manually and get the car to stop, and turn it off. When I turned the car back on again, I got the same warnings and alarms. After 5-10 minutes, when I turned the car on, everything seemed to have cleared. I still had the car towed to KIA to investigate the issue.

The car battery cells are defective and would not charge above 60%. After faulting on electrical vehicle alarm instrument panel sometimes may show false battery state of charge.

Battery keeps dying despite full charge and multiple jumps. Battery has already been replaced and continues to die even after jumping and leaving on. Car just dies despite it running after a jump.

1. Repair History and Days Out of Service The vehicle has been at CMA Colonial Kia dealership since [insert drop-off date], totaling 49 days (and counting) out of service as of 05/13/2025. The sole but critical issue is a failed high-voltage battery, which the dealership and Kia confirmed must be fully replaced. This is the first repair attempt, but the car has remained unusable for over a month. 2. Substantial Impairment to Use, Value, and Safety The failure of the high-voltage battery in an electric vehicle renders it completely inoperable, with no capability to drive, charge, or function. This significantly impairs the use, safety, and value of the vehicle: Use: The car cannot be driven at all. Safety: Battery failure in an EV represents a major system defect with fire and high-voltage risks. Value: A brand-new EV with major battery failure has diminished resale value and buyer confidence. 3. Eligibility Under Virginia Lemon Law Under the Virginia Motor Vehicle Warranty Enforcement Act (Lemon Law): A vehicle qualifies if it is out of service for 30 or more calendar days for warranty repairs within the first 18 months or 18,000 miles. My EV9 has been out of service for 49+ days, meets mileage and time limits, and involves a major system failure. Therefore, my vehicle qualifies for relief under the statute. 4. Issues for the Arbitrator to Address The vehicle meets Virginia Lemon Law criteria due to prolonged inoperability for a substantial defect. Kia has not provided a comparable loaner or timely resolution. The vehicle poses safety concerns due to failed propulsion battery. 5. Desired Resolution I am requesting a full repurchase (buyback) of the vehicle, including: Full reimbursement of the purchase price (down payment, monthly payments made, taxes, fees). Any towing or rental expenses incurred. Cancellation of the finance agreement if applicable.

The windshield wipers could not complete full return to starting position due to wet snow. This caused a shuddering noise as the mechanism driving the wipers continued to try to complete its motion. Then an electrical burning smell emanated through the car.

All of a sudden the EV battery management system warning light is on and it suggest I do not drive it until fixed. This was after my entire screen went out, where I could not see the speed I was going or use turn signals. Very unsafe

My car started to not charge for more than 10mn at a time. It also showed an error message about the electrical system. I have dropped off my car at the dealership on march 3rd. No information since

Battery cell in electric vehicle failed after 6 months of ownership.

The dashboard and control panel of my vehicle have repeatedly blacked out since shortly after purchase. These blackouts cause the entire instrument cluster and control systems, including critical safety features, to become non-functional or obstructed intermittently while driving. This creates a dangerous situation where I lose access to important information such as speed, warning indicators, and climate controls, severely compromising my ability to operate the vehicle safely. The issue has occurred multiple times, including once while driving on a highway, which put me and other drivers at significant risk. The problem has been reported to authorized dealerships, where the vehicle was inspected and software updates were attempted, but the issue persists. Despite multiple repair attempts, the blackouts continue to happen unpredictably. There have been no specific warning lamps or messages prior to the blackouts; the system simply fails without notice. The malfunction affects the vehicle’s safety system by obstructing the driver’s view of critical controls and information, increasing the risk of accidents. Customer service from the dealerships has been unsatisfactory, with long wait times for repairs, lack of loaner vehicles, and repeated failure to resolve the problem. This ongoing safety concern remains unresolved despite numerous visits and repair attempts.

The blank screen software recall has not fixed the screen that goes blank. It is still happening. This was after a dealership visit to address the recalls.

Vehicles battery has somehow malfunctioned and will charge to 100% but only has ~40 miles of range. This lead to my family being almost stranded in the middle of the night without range to get home with the un expected decrease. Vehicle is currently still at the dealership and has been there for over a month. They believe they have identified a problem with the battery pack but have to send out a specialist to look at it and have been waiting for that person for over three weeks and there is still no one assigned