2017 Kia Niro Complaint Log

The contact owns a 2017 Kia Niro. The contact stated that while driving 60 MPH on the highway, the vehicle jolted and shook abnormally. The electrical system warning light illuminated, and the vehicle lost partial power. The engine and hybrid warning lights were illuminated. The vehicle was coasted off the roadway to a gas station. The vehicle was towed to the local dealer, where it was diagnosed with a blown high-voltage fuse. The vehicle was repaired with a higher voltage fuse. The manufacturer was contacted and opened a case. The approximate failure mileage was 101,000. The VIN was not available.

The contact owns a 2017 Kia Niro. The contact stated that while driving approximately 60 MPH, there was smoke coming from the rear of the vehicle. The message, "Turn Off the Vehicle and Stop" was displayed, and the transmission failure warning light was illuminated. The contact pulled over and turned off the vehicle. Once the vehicle was turned off, the smoke dissipated. The vehicle was towed to the dealer, who diagnosed that there were holes in the engine, power steering, and there was an engine oil leak. The engine, transmission, and battery were replaced. However, 2 months later, the contact attempted to start the vehicle; however, the vehicle failed to start. The vehicle was scheduled to be towed to another dealer, Buster Miles Kia (1401 S Quintard Ave, Anniston, AL 36201). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure, and it was determined that the repair was not covered under warranty or recall. The failure mileage was approximately 50,500.

I previously had major issues and recall 23V534000 fixed on my 2017 Kia Niro. I had issues again and took it to the local Kia dealership in Wichita, KS. They found a leak in a seal causing fluid to leak on to the clutch actuator. The service tech indicated it is related to the recall. I have spoken with Kia customer service escalations on multiple occasions. Originally they stated it was related to the recall. When I spoke when them today, on the phone they said all the parts that are affected are what were changed out previously. When they called back, they changed the story and said it is not related and they would not pay for it to be fixed, even though they previously said it was the exact thing related to the recall. When I emailed and asked for it in writing as to why it was denied, she changed the reasoning. It was nothing the same that she had told me on the phone. This is a safety issue that should be fixed by the manufacturer and they are refusing to fix it and telling me I have to pay over $5000 to fix it. Completely unacceptable.

Power sterring went out - MDPS. Car has less than 50,000 miles. This is apparently happening to many of this model & a recall was done on a very small number of vehicles for the same issue. The recall should be expanded. This is very unsafe.

-Car was leaking or burning coolant causing engine to overheat. -Car was diagnosed with: Exhaust heat exchanger is leaking coolant and needs to be replaced. After costly repair, car continued to leak coolant and overheated. -Car was taken back to the dealership and diagnosed with: Engine Assembly - Long Block - Replace | Engine long block needs replacement due to coolant in the oil. This was at a certified Kia Dealership. No insurance reps or police were involved. An engine light has come on a couple of times over the years that was interpreted to mean replacing the gas cap. After replacing the gas cap, the engine light didn't come back on. My safety was impacted as a person living in a cold, rural state to have a sudden mechanical failure where I couldn't run the heat and had to stop the car immediately.

Failed/leaking coolant heat exchanger which is integrated into the rear catalytic converter assembly. This seems to be a well-known issue with 2017-2020 Kia Niros. Leaks cause overheating of the engine or no heat in the vehicle and potential blown head gaskets. This issue has been confirmed by an independent service center. Car itself gave no messages or warnings regarding the leak.

The contact owns a 2017 Kia Niro. The contact stated that while operating the vehicle, the message "Engine Overheated - Turn Engine Off" was displayed with white smoke coming from the exhaust system. Upon inspection, it was discovered that the coolant level was extremely low. The contact stated that coolant was added to the reservoir; however, hours later the coolant level was low again. The vehicle was towed to the local mechanic, who diagnosed the vehicle and determined that the head gasket was blown and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 112,000.

The heat exchanger (exhaust heat recovery system) on my 2017 Kia Niro has been diagnosed by an authorized Kia dealership as leaking coolant. The failed component can be available for inspection upon request. This failure poses a serious safety risk. The heat exchanger is part of the vehicle’s cooling system, and when it leaks, the engine can rapidly lose coolant while driving. This can lead to sudden overheating, reduced power, or potential engine shutdown in traffic. A driver may not receive immediate warning, and if the vehicle overheats unexpectedly at highway speeds, it can put both the occupants and surrounding drivers at risk of a collision. Coolant leaking into the exhaust system can also create steam and white smoke that may impair visibility for the driver or other vehicles. The problem has been confirmed by a Kia dealership, which inspected the vehicle and provided a repair estimate of over $3,500 for heat exchanger replacement. The vehicle has not been inspected by the police or insurance representatives. In my case, there were no warning lamps or messages prior to the diagnosis. The vehicle did not illuminate a check-engine light related to the failure or coolant warning, meaning the failure could easily occur without the driver’s knowledge until the engine overheats or loses power while on the road. This lack of warning significantly increases the safety risk. Given the number of owners reporting identical heat-exchanger failures, the high repair cost, and the potential for sudden overheating or power loss, this appears to be a widespread safety-related defect that warrants investigation.

The push buttons that lock/unlock the car in the outer front door handles fell out within two weeks of each other (passenger door and driver door). There was no sign of them being loose before falling out. There was no event that would cause them to fall out. Without the buttons, the lock circuitry is exposed. Kia dealership has seen the broken handles but unable to reinsert the buttons.

I am experiencing engine issues with my 2017 Kia Niro Touring Launch Edition at approximately 111,000 miles, including engine hesitation and lack of acceleration, along with engine code P0011. These symptoms started suddenly and have made highway driving difficult and potentially unsafe, as I was recently in the mountains unable to exceed 35 mph. This appears to be a widespread issue among 2017 Kia Niro owners, with many reporting CVVT (Continuously Variable Valve Timing) or solenoid failures around 100,000 miles shortly after the powertrain warranty expires suggesting a pattern of premature failure. My car was purchased certified preowned and is still within the 10 year timeframe. No official recall currently exists for this issue, but it should be investigated. Despite submitting service requests and making multiple attempts to contact the dealership to have these recalls addressed, I have received little to no follow up. I have not yet had the engine issue officially diagnosed by a Kia dealer due to lack of response but the pattern of failure and symptoms match what others are experiencing. There has been no crash, fire, or injury at this time, but the combination of the existing fire related recalls and the new engine malfunction creates serious concerns for long term safety and reliability.

The contact owns a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact used a personal code reader and retrieved a fault code related to the evaporative emissions. The contact replaced the gas cap. The contact stated that the failure persisted. The vehicle was then taken to an independent mechanic, who diagnosed the vehicle with internal failure. The independent mechanic provided the contact with the Manufacturer's Service Action Number: SA395. The contact was informed that the failure might be related to the evaporative emissions system. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 135,000.

Cooling system broke down at 140k miles. Water pump, EHRS failure EGR Cooler. Engine head gasket blown needs engine replacement 144k miles $9000 repair. Problems confirmed by dealership. Engine light never came on for cooling system, water pump coupling repair. Engine light did come on for head gasket and vehicle stopped working.

I am making a complaint in reference to my 2017 Kia Niro. On or about June 2025 I attempted to open my back driver side door and the handle broke off the car in my hand. We had this replaced at our cost. Since this repair, the back passenger door handle has done the same thing. I have notified KIA headquarters of this and they say they cannot help with this. I am concerned of the safety concerns with the inability to access the back seat quickly in case of emergency because this is where my grandchildren ride. I saw there was a bulletin that when one handle breaks, all door handles with the exception of the drivers door, must be replaced at the same time. I notified the Kia dealership of this and they denied it and told me they had no indication this was required and advised me to take it to my nearest Kia dealership. (3 hour drive).

The push-button locks (the plastic button that covers the electronic components) on the exterior of the driver's door and passenger's door fell off. The problem was confirmed by the Kia dealership, and attempting to push the buttons back on did not work (the buttons promptly fell back off). There was no warning that the buttons were loose before they fell off. The dealership stated that the only solution would be to replace the entire door handle.

When I was driving, a propulsion system warning went off. Then a malfunction in the vehicle’s powertrain/propulsion system lit up on the GPS screen. Shortly afterward, the engine began smoking, and a loud popping sound occurred simultaneously. The vehicle then experienced a sudden loss of propulsion, requiring me to pull over immediately to avoid a hazardous situation. An authorized Kia dealer subsequently diagnosed a blown head gasket with internal coolant intrusion, confirming an internal powertrain failure consistent with propulsion system malfunction, and the vehicle became inoperable. The vehicle was inspected in October and the loss-of-propulsion failure occurred in December.

The contact owns a 2017 Kia Niro. The contact stated while driving at an undisclosed speed, the check hybrid system warning light illuminated, and the hybrid system seized. The vehicle was towed to the dealer where it was diagnosed with power relay assembly failure. The contact was informed that the power relay assembly needed to be replaced. The vehicle was taken to the dealer to be repaired. The contact referenced Technical Service Bulletin: SC256 as a possible fix for the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.

I had some lurching when trying to accelerate for a month before the check engine and HEV warning beeping came on. Kia Niro EGR (Gas Recirculated Cooler) failed at 105K miles. It leaked on to the engine causing it to overheat. My children and I got smoked out and my child had an asthma attack from this issue. We were also stressed, thinking the engine would catch fire. Kia says there are no recalls for my 2017, yet the 2023 has a recall on this exact item. I would like this complaint to be filed due to a part failing 5K miles after a warrenty. The problem was diagnosed by the Kia Dealer. Quote is $1875.

I received a warning indication that the engine temperature is too hot while driving the vehicle to work. I opened the hood of my vehicle and discovered the vehicle’s coolant reservoir was empty which led me to believe there was a coolant leak. I took the vehicle to be inspected and diagnosed by an independent repair shop (non-dealership) and it was explained that there was in fact a coolant leak and it’s because the exhaust heater exchanger is failing. This is a serious safety concern because if there is a coolant leak the vehicle’s engine can overheat causing further and extensive damage to the engine which could result in a fire. Based on research, there have been other cases where this particular year/model vehicle has had or is experiencing issues with the exhaust heater exchange failing. This faulty system is causing customers who own the same year/model vehicle that I drive to either bypass the exhaust heater exchange all together—which I don’t believe is safe to do—or customers are being made to pay a huge bill just to repair the faulty system. My vehicle only has 73,000 miles and this is something that I should not be experiencing especially since Kia is aware of the fault with the exhaust heater exchange on these particular year/model vehicles. Kia should be recalling these vehicles with the faulty system for diagnosis and repair as this is a major safety concern on the road not only for the driver, but also for other motorists as well.

The contact owns a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the message "Check Hybrid System" was displayed. The vehicle was towed to the dealer, where it was diagnosed, and determined that the hydraulic clutch actuator and power assembly had failed. The dealer related the failure to Kia Safety Recall Campaign Number: SC163 (Hydraulic Clutch Actuator (HCA) Inspection, Repair or Replacement). The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, where the part was replaced a second time; however, the failure persisted. The contact stated that while attempting to drive out of a parking space, the vehicle stalled and became undrivable. The vehicle was towed to Executive Kia (1164 N Colony Rd, Wallingford, CT 06492), where it was diagnosed and determined that the HCA needed to be replaced. The contact stated that the HCA failure had caused a hole in the bottom of the vehicle. The vehicle was not repaired. The contact stated that the recall repair failed to correct the failure. The manufacturer was notified of the failure, and the case was escalated to a case manager, who informed the contact that the case would fall under Goodwill assistance. The failure mileage was unknown.

My Kia Niro 2017 began losing antifreeze back in January of 2024. Upon inspection by Folsom Lake KIA they determined that the EGR needed to be replaced. The dealership made the repair under my third-party warranty that I purchased when I bought the car preowned in 2020 (22,000 miles). In August 2024 the engine began to overheat triggering and engine light. The car had approximately 90,000 miles on it at the time. The antifreeze was gone, and I filled it up and took it to the dealership a few weeks later when they had an available appointment. They were not able to diagnose the issue during that visit. They said that I had to schedule a multiday appointment to get a diagnostic done. In the meantime, I was adding antifreeze every few days to keep the reservoir full. I took the car back to Folsom Lake KIA on October 14th and received a diagnostic on the 17th that the vehicle's heat exchange recover system was leaking the antifreeze into the exhaust which burns off as a white smoke. The recommendation was to replace the entire heat exchanger. I decided to do some research and found find out what exactly this part does. I discovered that it simply warms up the antifreeze faster using the engine exhaust and shuts off when the coolant temperature reaches a setpoint. After further research on the internet, it became clear to me that this is a systemic issue with these vehicles, but no recall has been made. My warranty claim was denied due to the part not being covered. When I took it to an independent shop, they said that the part was not available from anyone, but KIA and they said that there was no price listed, and you had to contact KIA for the part. KIA quoted 3,000.00 for the part and labor to replace the heat exchanger. All of this just seems very suspect. I believe KIA knows this is a systemic problem but refuse to recall the part. Instead, they are making a bundle replacing this part. Any help would be appreciated. Thank you.

Niro had been exhibiting increasingly frequent "crunching" noises in the steering mechanism at lower speeds, like backing up and in-town driving. Issue started in late June 2024 at about 67K miles. A few times the steering wheel grabbed on turning and I had to fight it back. I called the dealer for a diagnostic appointment and they said they couldn't see it until mid-August 2024. I then took the car in to a local mechanic two times, who said they could feel the crunching on backing up, but weren't able to reliably reproduce the condition and refused to open up the steering column in the absence of a defined problem. I continued to drive car the throughout July. On 7/20/24, the crunching noise in the steering column got markedly more frequent, was witnessed and felt by passenger, and continued intermittently throughout the day through a number of short in-town drives at low speeds on typical city roads. The next day, 7/21/24, after about 1.5 hours of continuous highway, then local driving on curvy mountain road, a series of loud crunching noises suddenly came from the steering column, the EPS warning light came on, and I experienced a total loss of power steering, making the car extremely difficult to control. The failure occurred in a triple s-curve at the top of a hill with an approaching, very steep drop-off embankment and I was very scared I would not be able to keep it on the road, even at the low speed I was driving. It took both hands and considerable effort to wrest control of the wheel and to keep the car on the road, and I managed to drive the remaining two miles home with considerable effort and both hands forcefully steering the car through turns. Definitely NOT safe to drive in this condition. The car was towed to the dealer for diagnosis. Dealer confirmed "total failure of steering mechanism"

I was driving my car as usual and it began overheating. I took it to the mechanic and they could not find a coolant leak, even though the coolant was all gone. We added more coolant and I was on my way. A few weeks later, the same thing happened. The mechanic said to take it to the dealer because they would need to run a diagnostic. I took it to the dealer and they said there were some new recalls that needed to be repaired that could fix the issue. They did the recalls, I topped off my coolant, and I was on my way. One week later, while picking up my son from school, the engine had a catastrophic failure. This was not only dangerous to me and my kids, but to those around me. The car stopped and refused to start up again mid-driving. I had it towed to the Dealer (Kia of Carson) and they rand diagnostics. A few days later they send me a quote for $10K to replace the engine as well as the muffler system - more than the current market value of the car. The car has just over 70K miles on it, and since I bought it used from Carvana, it was not under Kia's warranty. This is NOT how things should be. They should not be allowed to put vehicles that break down like this and then charge people outrageous amounts for it with no compromise whatsoever. How can the engine be worth more than the whole car? I've talked with Kia customer service and they don't care. I've spent months trying to reason with them, but to no avail. Also, upon research online, there are tens of thousands of Kia Niro (and other kia car model) owners who've had the same problem - overheating that turns into engine failure. This is a systemic problem with a fraudulent company that is destroying the lives of their customers. This experience put my family in danger and has essentially ruined my life since it happened. I hope the NHTSA can do something about this!

I am unsure of what to say about my car. I saw a check oil light flicker and it went away. The car had oil when I checked on it so it didn't seem to be a problem. There was no sign of leakage and no sign of burning oil or fuel. Several days later, the check oil light came on permanently. Before I could get the car anywhere, the car started making a strange sound. I took it to my usual shop. They said it had sprung a spontaneous leak. They said it was a large oil pressure switch leak. They replaced the sensor and added oil. They said there was some damage but that the car was still drivable. I drove the car for a week and then when I was on the highway, the car starting roaring and shaking like I was in an earthquake. The check engine light started blinking. I could not accelerate properly and had to coast to safety on the electric. I was able to use my friends scanner and found 4 misfire codes: PO300-303. My neighbor (a mechanic) looked at the vehicle and said that was damage was internal and was going to need extensive work or a new engine. He didn't have the time to take the vehicle apart so we did not find the true cause and I am now wondering if this is a new safety issues or related to the recall. I did not receive the recall information until recently (I tend to have issues receiving my mail sometimes) and haven't even had time to get to the dealership to check on it. Everyone I have spoken to has said this is how Kia's are and they are not worth purchasing.

The Exhaust heat recovery system has a valve that can malfunction and allows coolant to leak into the exhaust and ignite it into the atmosphere. It can cause misfires in the engine, there are technical service bulletins (TSB 212 and Pitstop Tech bulletin PS709 that are attached to this report) that have more information on this issue. This can drain the coolant from the system and cause engine overheating issues. Some shops may misdiagnose it as a head gasket problem. This is a common problem for Kia Niro's 2017-2022. A new heat exchanger as of now costs $3000 brand new from the OEM and Kia is very strict about how they apply their warranty to any kind of part. Please can you help remedy this issue for Niro owners.

Coolant keeps leaking causing car to overheat. Faulty heat exchange flooding catalyic converter. This is a know issue with Kia Niros. No warning lights. Kia service department found the issue.

The contact owned a 2017 Kia Niro. The contact stated that while driving at an undisclosed speed, the temperature gauge began to indicate that the vehicle was overheating. The contact then observed smoke emanating from the engine compartment. The contact was able to pull to the shoulder of the roadway, where the vehicle soon became engulfed in flames. Local emergency services arrived and were able to extinguish the flames. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed a total loss by the contact's insurance provider. A fire report was filed. A police report was also filed, with no injuries reported. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V534000 (Engine), and the VIN was included, but the vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2017 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2017 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2017 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had experienced a strong electrical burning odor inside the cabin of the vehicle. The contact stated that the front passenger’s side wheel well had melted and collapsed. The cause of the failure was not yet determined. The local dealer was notified of the failure. The failure mileage was 91,760. VIN tool confirms parts not available.

My 2017 Kia Niro (hybrid) discharges white smoke and overheats while being driven. I brought it to a reputable mechanic immediately. After an inspection, it was discovered that coolant is leaking into the engine because the heat exchange system is not functioning correctly. There are 6 similar complaints files about the same model vehicle (NHTSA 11561701, 11550994, 11547940, 11442817, 11457565 & 11491873) and many that have not been filed on line but complaints are the same. A Kia dealership said that the part (#28601G5320) is on back order everywhere w/ no availability in sight. This is a $3000-$6000 repair and is ridiculous. No engine lights or indications of anything malfunctioning, this needs to be recalled ASAP!

My car slowed, smelled hot, and then transmission overheat light came on approximately 130 miles from my home. I had it towed to nearest Kia service due to my warranty, Lehighton Kia dealer by AAA (Kia roadside wanted $293). Dealer claimed it was Clutch Actuator (said nothing about recall) and claim to be attempting to confirm warranty with Zurich for days with no success, I had no issue calling Zurich to confirm warranty would cover it. They said parts were unavailable in US, some in Korea, no guarantee where they would be distributed to and could not be ordered yet, so timeline of at least a month that I would be without a car. They could not offer me a loaner or rental. Last night I received Recall notice SC276 for the exact issue I am dealing with. In 4 calls to Lehighton Kia this recall was never mentioned. I bought my car in March with 31,000 with the best extended warranty I could buy to protect myself as a recent widow with a daughter in college. My car now has 52,000 and is not usable indefinitely, I cannot afford a rental and I work 35 miles away and feel that the Lehighton Kia has been less than helpful in dealing with this issue.

The contact's daughter owns a 2017 Kia Niro. The contact stated that while her daughter was driving at an undisclosed speed, the Check Hybrid System, Turn Off Engine message displayed, and the HEV warning light illuminated. The vehicle then stalled. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine and battery needed to be replaced. The vehicle was then towed to an independent mechanic, who determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 120,787.

The contact owns a 2017 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the HEV warning light was illuminated. Additionally, the contact stated while driving 35-40 MPH and depressing the accelerator pedal, the vehicle failed to respond and lost motive power. The contact was able to veer to the side of the road. The contact was able to restart the vehicle, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the dealer, where it was diagnosed, and the dealer determined that the failure was related to the recall. The dealer informed the contact that the recall repair part was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 134,000. Parts distribution disconnect.

Car gives digital signal of overheating, white smoke pours out of exhaust but there is no code that allows dealership to diagnose and remedy. This has occurred twice in the last 6 weeks and the car has sat at the dealership for weeks. This problem and inability to repair without a $1,200 exhaust system replacement is well documented on-line [XXX] ] and the dealership is unhelpful. It appears there's a design flaw that allows this to occur and should be remediated by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Steering malfunction. Very difficult to turn right or left, steering wheel refuses to turn. Rattling noise of metal hitting metal when turning right or left

Few days ago, the check engine light turned on in the dashboard of the Kia Niro 2017 The car was taken to an authorized Kia dealership for diagnostic. The dealership informed that the "Fuel air filter kit & NVLD" needed to be changed at the expenses of the owner. The same issue was described in the "Kia technical service bulletin ... SA395" in the NHTSA website. This bulletin explains that the dealership has to repair this issue under warranty, even if the warranty is expired. The dealership said that this car VIN number is not covered by this bulletin; however, the issue is exactly the same as described in the mentioned document. The car mileage is under 54,000 miles. I would appreciate if NHTSA reviews the list of VIN numbers in order to cover all the cars that present this problem.

I was driving and the car was stuttering. Then after I stopped for a bit it resumed normal operations. Then the warning light came on, then it went off again. This happened for a couple of weeks until finally, while on a road trip at the end of July 2023, the car seemed to just lose power in 4th gear and I would have to really rev the engine just to keep it moving, that happened while on a road trip. I called the dealership several times during the trip and they said I’d already had the computer recall reset so they didn’t think it made any sense. I took it to my neighborhood repair shop when I got back and they said two spark plugs are shot, they replaced them and it ran fine. But now it’s stuttering again, just a few months later. I called the dealership again and they said I could bring it it for a diagnostic (not free) and then I got a letter about a recall. Not sure if it’s related to my issue because the dealer said probably not and said they’d call me when they knew more and my car had the computer issue not this one. No one has called and the car is still stuttering. I took it to the mechanic again and he said spark plugs look fine, but again, it is losing power in 4th gear, just around 45 mph only when I’ve been driving for more than two hours. I would just like the dealership to take a look and fix it.

During first recall 18V-666, Kia stated that I received a new PRA in September 2019 per recall instructions. July 2023, my car would not turn on and was sent to same Kia dealership. Recall 22V-836 applies to my car, and my PRA shows sign of thermal damage yet again. Both main relays that were replaced in 2019 were of Panasonic, yet, the PRA was melted to the point that the wire harness also needs replacing. This is 2 fire incidences in my 2017 Kia Niro in less than 3.5 years, on the same part.

Car stalled, overheated due to coolant leaking into car parts which is causing catyllac converter to not work correctly. The issue is not with the catillac converter but the faulty piece that causes coolant leaking. This is a known issue amongst Niro Users. KIA is illegally forcing customers to purchase the most expensive part instead of bypassing so that the heat exchange system doesn’t leak into converter. The same issue affects the EV model which KIA has recalled but they refuse to add the hybrid to the recall list. Please help. The repair is $3,000 and customers that have paid to fix only end up in the same position moths later with the same issue. I reported the issue to KIA and my claim was denied.

Hybrid System Failure due to overheating Overheating due to coolant leak into resorvoir My car started having white smoke come from exhaust during driving Took to the repair shop, repaired the coolant reservoir next day, same issue took back to the service tech stated they couldn't find the leak, but the reservoir was empty. Took the car for a second opinion, the service people had my car all day, after picking up, was told by the repairman that it was the engine and KIA is aware of it. Stated he is unable to help and I should take the car to a KIA dealer For weeks the car was still blowing smoke Took the car to KIA of Stamford Had the car for a few hours, tech said coolant leak and I will need to replace the part which is 3000, advised there is a bypass method on the internet for NIRO owners with the same issue online, and I was told they will not do the bypass due to emission laws. Advised my car should be covered under Emissions warranty, and was told it does not cover the part. Advised the service man this should be covered under my 100,000 warranty with KIA, which is what I was sold, and was told this is not the case, and I wasn't covered. Advised KIA I have an extended warranty with WIZ autos where i purchased the car. Spoke to the warranty department and was told it wasn't covered under their warranty either. May 2023 While driving I saw white smoke, my car began to overheat and I tried to pull over, when I pulled over the car would not drive. HYBRID System Malfunction The car has been with Wiz autos and they are now telling me the repairs will cost $5,800 There are many people online suffering because of this defect. There are reports online that once fixed, the issue returns months later. Wiz autos is asking me to pay 6000 for a repair and 3 month warranty on the part. Issue: Coolant leak is causing issues that affect the safety of drivers, as well as destroys their vehicles and KIA Motors has been the worst to work with.

- my car started releasing white smoke - i took it to repair shop, stated it was fixed, white smoke continued -car started overheating -Took it to KIA dealership and was told i was responsible for fuel leaking into engine, was told my car was not covered under warranty, I also have an extended warranty at the dealership which they wouldn't honor stating it was not covered -Recently while driving the car flashed Hybrid system Failure and shut off -I was unable to move the car -I had the car towed to the original dealer (wiz autos) and it has been there since May 2023, it is now 4 months and the car still does not work -Wiz autos informed me the car had a "lock on it" and will need to be released by KIA its been 4 months with no answers from KIA, I have been having an issue with the coolant leaking into the engine since 11/22 and although this is a common problem in these cars(manufacturers defect) KIA will not fix, or replace. I believe the coolant leaking into the engine, is causing the cars to malfunction**** Please take a look at these forums: [XXX] [XXX] Although my car is not listed in this lawsuit by KIA, i believe more cars are affected: A federal court has granted final approval of a class action lawsuit known as In re: Hyundai and Kia Engine Litigation , No. 8:17‑cv‑00838‑JLS‑JDE and Flaherty v. Hyundai Motor Company, et al. , No. 18‑cv‑02223 (C.D. Cal.) allege that 2011–2018 and certain 2019 Kia Optima, 2012–2018 and certain 2019 Kia Sorento, and 2011–2018 and certain 2019 Kia Sportage vehicles suffer from a defect that can cause engine seizure, stalling, engine failure, and engine fire, that engine seizure or stalling can be dangerous if experienced, and that some owners and lessees have been improperly denied repairs under the vehicle’s warranty. Neither KMC nor KUS have been found liable for any of the INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I called my local Dealer Nationwide Kia in Timonium Maryland to get an appointment for the required recall. They have so far have been unresponsive, so I called Kia in California. I got a case # of [XXX] after waiting 1:30 mins on the phone. Called back the next week and they said they called the dealer and got no answer but left a message and they sent an email. Called back the next week and they said the dealer never responded and they sent another email. Called back today and sat on the phone with Kia California for another hour and they never answered. I'm very upset that i can't seem to get an appointment for a safety recall, what good does a recall do if the dealer won't answer me and the Kia Zone office can't force them into action. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

EHRS fails, causing coolant leaks & cracked cylinders

On Friday, December 9, 2022, the heating element in the driver side seat burned through the cushion, burned a hole in my coat, and burned my right leg. Yes, it is available for inspection upon request. Thursday, January 5, 2023, the service department at Kia confirmed the heated seat element had gotten too hot and burned through the seat. Service personnel said the part that needed to be replaced was not under warranty and quoted prices ranging from $600-$1,700 to have it repaired. Other than the service department at Lithia Kia of Anchorage, no other inspection has been done. There were no warning lights or messages prior to the failure. In fact the car had been in the shop the week prior and had a courtesy vehicle inspection.

Back seat got warm & later that morning car engine would not start but lights in vehicle came on. Appt made w/dealer who after a week hadn't done diagnostics nor checked battery & main hybrid fuse as I had requested. I towed to a service garage who upon starting to open the box covering battery, found battery had kindof exploded & bulged. I searched online for recalls on 12/7/22 and found a recall 11/10/22 -22V836000 (KIAs # is SC256) which is "Main Relay within Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance, which can overheat the rear seats." "This recall supersedes NHTSA recall number 18V-666. Vehicles already repaired under the previous recall will need to have the new remedy completed" I have receipt showing I had did the 1st recall but the recall is not showing up when I search my VIN#. Kia has found some dealers lied & never replaced the part they said they did. My car will be towed tomorrow to a KIA dealer who will look into this issue & what my battery looks like. No warning lights came on prior to the engine not starting. I called KIA cust service for recalls this morning 12/7 and they were no help to me at all seeing the recall isnt showing under my VIN number.

The contact owns a 2017 Kia Niro. The contact stated that while her son was driving at an undisclosed speed, he noticed white smoke coming from the exhaust. The contact stated that her son pulled over to input more coolant however, upon starting the vehicle, the coolant immediately drained from the reservoir. Additionally, the contact stated that a burning odor could be detected throughout the vehicle. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that a hole was in the exhaust and needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000. The VIN was not available.

While pulling into a parking space my car accelerated, flew over the curb and landed on another parked car. It was very sudden and going very fast

Car caught on fire while in motion on the highway due to safety recall issue

Intermittent failure of multifunction switch in steering column that controls lights, leading to loss of left-hand turn signal. Dealer checked bulb, socket, and wiring harness and could not reproduce the issue. This is a safety issue as it occurs without warning, lasts for days, and could cause an accident through inability to signal lane change or turn at intersection.

Active Air flap system error message and check engine light. Error message and check engine light come on and off randomly kind of annoying since I've only had it just over a month and already have to have it go to get repaired