2018 Kia Niro

Everything is falling off the bottom of this vehicle

The contact owns a 2018 Kia Niro. The contact stated that when the vehicle was shifted into reverse(R), the vehicle failed to respond. The vehicle was turned off and restarted to reset the transmission, but the vehicle failed to respond while in reverse(R). The vehicle was shifted to drive(D) but failed to respond. The vehicle was shifted into park(P). The vehicle was towed to a local dealer. The dealer diagnosed the vehicle and determined that the transmission fuse and the hydraulic clutch actuator had failed and that the transmission needed to be replaced. The contact researched online and related the failure to NHTSA Campaign Number: 23V534000 (Power Train). The manufacturer was contacted and the contact was informed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 175,000.

I am reporting a safety issue involving my 2018 Kia Niro hybrid related to the Hydraulic Clutch Actuator (HCA), which is currently subject to a recall addressing fire risk. My vehicle has already had the recall remedy performed, which consisted of inspection and installation of a lower-amperage fuse. The dealer confirmed that the actuator is leaking fluid but did not replace it because there was no evidence of PCB contamination, which is the condition required under the recall. However, the vehicle is now experiencing significant drivability issues that create a safety hazard: Intermittent hesitation when accelerating from a stop Failure to properly engage the transmission, especially on inclines Engine revving without corresponding vehicle movement Delayed or inconsistent clutch engagement In one recent instance, the vehicle would not properly engage while attempting to move from a stopped position on an uphill incline, creating a hazardous situation where the vehicle could not reliably move when needed. This condition appears to be caused by loss of hydraulic pressure due to the leaking actuator, even though it has not yet reached the stage of PCB contamination described in the recall. The current recall remedy does not address this failure mode. Instead, it allows a known defective component to remain in service until it reaches a condition that presents a fire risk. In the meantime, the vehicle can experience loss of propulsion under normal driving conditions. I believe this represents a separate safety defect or an incomplete remedy, as loss of propulsion, especially during acceleration from a stop or on an incline, can significantly increase the risk of a crash. I am requesting that NHTSA investigate whether the current recall adequately addresses all safety risks associated with the defective Hydraulic Clutch Actuator, including drivability and loss-of-propulsion conditions that occur prior to PCB contamination.

Driver heated seat shorted out and caused burn to leg. System has not been repaired, will wait to hear from Kia Customer Affairs prior to decision to repair. I was injured by this and have concerns about the safety of the vehicle, will this happen again if a new grid is installed. Kia dealership confirmed that the grid showed high resistivity but also claimed since nothing is melted I couldn't have been burned. The vehicle has only been inspected by the dealership currently. there were and are no indicators, warning lights or messages about the failure available. Kia dealerships claims there no way to tell with the electrical systems.

The contact owns a 2018 Kia Niro. The contact stated that occasionally driving at various speeds, the vehicle hesitated to stop as intended while the brake pedal was depressed, and the brake pedal was depressed to the floorboard. The message "Stop - Regenerative Braking Failure" was displayed. The contact restarted the vehicle as a temporary repair; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed, and a 91400 fuse Kit was installed, and various repairs were performed. The vehicle was repaired out-of-pocket; however, approximately one month later, the failure reoccurred. The vehicle was taken back to the same local dealer where it was diagnosed; however, the cause of the failure was not determined. The vehicle was not repaired. The contact stated that the vehicle was taken back to the same local dealer, where it remained. Upon further investigation, the contact related the failure to NHTSA Campaign: 23V534000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure, and a case was filed; however, was the claim was denied. The failure mileage was approximately 150,000.

I'm 59 years old never have an accident or had to slam breaks on the guy in front of me slammed his breaks on so I did the same time the brake pedal was to the floor the car didn't even slowed down and not even skid marks hit him then air bags deployed the car was totaled no one got hurt thank God I do t know if any other kia cars had this problem I got real lucky

An alert to "check regenerative brakes" popped up on the dashboard screen. My younger sister who is borrowing our car, told me it now takes her much longer to come to a stop when braking. She's having to brake really early to stop on time but traffic and animals will not always allow for that. From what I am reading online, this is a common issue due to faulty 12v battery or a loose ground from said battery. The only way to fully engaged the conventional brakes (without the regenerative brakes) is to switch the car into neutral and then brake. This is a major safety issue that Kia should address. Maybe they need to address the battery issue, but they definitely should address the fact that you have to shift into neutral to brake properly when the regenerative brakes arent working right. Seems like a common sense plan to have it default to conventional brakes when the others are having issues or at least provide a way to turn off regenerative brakes.

Known issues with wiring cause check engine light to come on and also now the door open sensors to stay on. Just paid $800 for a known issue to the wiring that a Kia technical bulletin wss issued for, however the cost was left to the customer.

Hydraulic Clutch Actuator recall was previously done and only a fuse was changed as the inspection only determined the actuator itself did not have an active code. 4 months has gone by and now the actuator has now failed.

Internal combustion engine coolant leaking out exhaust. The heat exchanger located in the catalytic converter system is leaking, leading to the ICE coolant draining. This leads to the engine overheating, and damage. Signs of the issue started with the coolant level lowering quickly, then the car heater stopped working. This confirmed by an independent mechanic.

Just before Hurricane Helene, I brought my 2018 Kia Niro Hybrid to Asheville Kia (NC) after noticing coolant loss and white smoke coming from the exhaust. The dealership charged me $1,400 for a repair involving new gaskets and the EGR cooler. Within a month, the same symptoms returned. I returned to the dealership and explained I believed the original issue had not been resolved. I had done research and found reports of similar problems in other Niro Hybrids. I specifically mentioned the coolant heat exchanger as a possible source, but they dismissed my input and pushed a $3,500 muffler system replacement. I asked for diagnostic proof, and they initially showed a photo of the muffler with no visible leak. Later, they claimed a "small leak" was found during a pressure test — but the symptoms didn’t align. I then took the vehicle to John’s Kwik Lube in Spruce Pine, NC, where they confirmed the coolant heat exchanger was faulty — exactly what I had originally suspected. They repaired it with a simple workaround for under $200, and I’ve had no issues since. The faulty component (coolant heat exchanger) is not available for inspection, but I retained diagnostic records, pressure test results, and screenshots of the dealership’s estimate. I also documented that Kia’s quote system does not allow access to past service quotes, so I had to screenshot everything manually. The only symptoms were coolant loss and white smoke from the tailpipe, beginning shortly before the storm in September 2018, and recurring until the final repair later that year. The problem was confirmed by an independent mechanic, and partially acknowledged (though misdiagnosed) by the Kia dealership. No police or insurance inspection was involved. This situation posed a safety risk due to reduced visibility, potential engine overheating, and exposure to coolant vapors, especially during uphill driving. The issue is known among Kia owners and appears to be a recurring design flaw in the Niro.

The contact owns a 2018 Kia Niro. The contact stated that while operating the vehicle, the vehicle failed to shift out of neutral while shifting the gear shift lever. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed and the DTC code: P090B:73 error was retrieved. In addition, the contact stated that an unknown message was displayed. The local dealer was contacted and informed the contact that the failure was related to an unidentified recall; however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 136,663.

hybrid battery warning paid out of pocket for towing, car still at the dealership, loss of income and wages, been treated with awful customer services, and paying out of pocket. Car went in on June 25

The contact owns a 2018 Kia Niro. The contact stated that upon starting the vehicle, the vehicle was shuddering and failed to start. The battery charge was low. The HEV warning light was illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The dealer informed the contact that a field expert would be determining the cause of the failure. The manufacturer was not contacted. The failure mileage was 140,000.

Coolant leak within the heat exchanger of the catalytic converter. Increases likelihood of overheating and engine damage. Especially when driving long distances, or within heavy traffic. Increases emissions as burning off coolant within exhaust.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.