2016 Kia Sorento Complaint Log

Paint for this car has been delaminating and peeling off from regular use of the car. No accidents or scratches caused the paint to begin peeling, it just started on it's own. I am reporting this because I found it was a common issue for Kia owners with a pear white paint.

2016 Sorento 3.3L with approximately 136,000 miles on it. Did not have heat. Diagnosed with low coolant and possible head gasket leak due to loose head bolts. No warning lights. Seems to be a common manufacturing issue with these engines.

Paint delamination happening to my Kia Sorento, paint is peeling exposing primer

The contact owns a 2016 Kia Sorento. The contact stated that the engine was empty of engine oil a week after an oil change. After oil was added, the contact's husband observed that a quart of oil had been consumed in a few days. The vehicle was initially taken to an independent mechanic, and it was discovered that excessive oil sludge and hard carbon build-up was in the valve and stems. The contact was also informed that the piston rings were worn and that there was scoring on the cylinder walls. The contact also stated that while driving at 55 MPH, the engine oil warning light flashed on the instrument panel and the vehicle stalled. Due to the failure, the vehicle was towed to the dealer where it was diagnosed with piston failure and a misfire in cylinder #2. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 142,000.

On the morning of October 31st, 2022 I used my remote starter to warm the engine in my driveway for approximately 10 minutes, when I got into the car I noticed the air blowing was ice cold and when looked at the temperature gauge the needle was in the red. I allowed the engine to cool down for about an hour, checked the coolant level and found it empty. I looked all around and under the engine for signs of leaks, none were found. I purchased a gallon of coolant, topped off the system and brought the car to my local garage to check the problem. They replaced the thermostat and bled the cooling system. About a week later it started overheating again so I topped off the coolant again and took the car to the nearest Kia dealer. After keeping my car for a week they concluded that the head gaskets were leaking and the repairs would be more than the value of the car and they'd be happy to trade what's left of my car for a new Kia. I had my car towed to a reputable independent shop and ended up paying a total of $12, 274.84 for a re-manufactured engine and for labor involved in stripping down the old engine for the extended warranty who inspected the engine and denied the claim. I purchased this vehicle on 1/9/2021 with extended warranty from and authorized Kia Dealer for $20,522.78. I have since found out that this is an ongoing issue with the Kia/Huyndai V6 engines from 2016-2019. As a Mercedes-Benz employee for 30 plus years I am appalled at Kia for their unwillingness to stand by their products.

I noticed one day when filling up my wiper fluid that the engine was just slightly below the coolant low level. I topped off the coolant and tried to see if there was any leaks under the car. I couldn't see any. I started the vehicle and noticed there was bubbling in the coolant reservoir.I called my local mechanic and scheduled an appointment to bring the car in. The car wasn't driven until the day it was going in to be looked at. When driving the car in it started rough and slugish but then went back to normal. I drove it to my mechanics and on the way the car started running very rough engine shaking and the check engine light started flashing. I was only a few blocks away from the shop so I coasted in. They took the car in said it had a code for a cylinder misfire and started the car saying it was blowing white smoke out of the exhaust. They ran a test on the car and said they didn't want to take anything apart and to tow it to Kia. The car was towed to Kia in Wheat Ridge, CO. Car was inspected and the diagnosis was that the engine had overheated. The block is made of aluminum and so is the head. The headbolts that hold the two pieces together are a different type of metal. This manufacturing defect caused the threads in the aluminum block to strip or pull and loose tension on the head gasket. This allowed coolant to enter into one of the cylinders. Kia is recommending the engine be replaced for $11,910 and change. Car was regularly serviced and drove perfectly fine up until the day it went into the shop. Dealer service dept says this is very common on Kia and Hyundai 3.3L engines. Multiple cases around the same mileage.

The engine of the vehicle and other parts had a problem which had caused the vehicle to not accelerate fast enough. It also made the car shake when it was stopped. The component that is malfunctioning is available for inspection. If the car does not accelerate on the road, then it can cause a crash which can lead to injuries or even death. Especially if the car has to turn left and other cars are incoming, it can lead to serious issues if the car does not go fast enough. It can lead to injuries to the driver and the passengers. The vehicle was initially put for inspection to the manufacturer in Lou Sobh Kia, "fixed", and then was given back in a condition where the effects stated above continued to occur. We then took the vehicle back to the manufacturer where they further reviewed the car. They reviewed it again and did not tell us enough information about the issues going on with the car. Since we did not think they were reviewing the car properly, we took it Rick Case Kia where they were able to spot out the engine problem. It was also reviewed by a Korean service center and Good Year where they both told us that it was an engine and timing belt/chain problem, whereas Lou Sobh Kia weren't able to properly capture the issue. Both the engine light and oil light were on which is why we took it to Kia Lou Sobh, and they first appeared around October-November 2023.

I was taking my mom to her knee appointment after her surgery, and my temperature gauge started to rise. No lights or warnings came on in the car what so ever. I pulled over before it reached the red, let it cool and checked fluids. From what I could see the oil, and coolant were fine. The heat in the car stopped working, and the car kept wanting to over heat in the lower gears. I got it to Lion Country Kia in St.College and diagnosed it as finding a cylinder head gasket. My car could no longer be driven, from St.College to my home in St.Mary’s. I had to have it towed, as well as checked here as well to find they were right with a cylinder head gasket issue. I was under the assumption I had the power train warranty as well because it’s under 10/100,000 but unknown to me I didn’t. I could’ve been in an awful accident if I wasn’t paying attention to my gauges and my car overheated and locked up while driving. If anything would’ve happened to my children and my mom in the car that day, all because of a fault in the car manufacturing, Id be knocking on doors! To see all the recalls on the years previous to this for the same issue, you would think it would’ve either been taken care of, or a recall put on this year as well. From what I’ve been reading it’s been happening all too often. Something needs done.

Vehicle is burning excessive amounts of oil. The check engine light nor low oil light has came on and vehicle was (4) quarts low (according to independent mechanic). Was told by KIA dealership that they would not repair unless the engine was completely blown up. I was told to add oil, get more frequent oil changes, trade vehicle, or come up with $8,500. The engine only has 61,000 miles on it and is a 2016 model. This is a widely known issue and KIA needs to admit the failures and fix the problem.

Does not show low oil light when the car has no oil in the engine

Car started making a knocking noise and before I could pull over the car shut off. Told now engine needs to be replaced. Kia could not look at it until November 1st and will not give us a car to use. We only have this car as a mode of transportation.

While traveling to Atlanta, GE from Ohio, I stopped for gas south of Chattanooga. Immediately after ( within 10 miles), my 2016 Kia Sorento began to lose power and acceleration. In trying increase speed, the car started shaking and acting erratically. I pulled over to try to discern the issue, but could find nothing. ENGINE LIGHT WAS NOT ON. I thought it might be bad gas but this was not the case. I drove the car the rest of the way to Atlanta as this was late Friday night and Saturday I had a gig in Atlanta with no chance to visit a garage or dealership. On the return trip to Ohio the car continued to stall and I had to shift to N in order to keep the engine running during several traffic jams… still running erratically, That next Monday, [XXX], I took the car to a local garage. They reported a misfire in cylinder 2 and no compression in this cylinder. They suspected a burnt exhaust valve and recommended rebuilding the engine. I got a 2nd opinion at the dealer 15 miles away and they recommended a new/ rebuilt engine as it would have a 3 year warranty. I ok’d the repair and spent $13,600 plus another $400 for an engine bolt after the install. The newer engine lasted a week and it was another 4 weeks for the 2nd engine re-install. So… $117.66 for the first diagnostic and $14,000 after the installed engine. I checked with Kia and there were any with this engine. The answer was no. Since then, I have read complaints on forums concerning this Kia 3.3 Lambda engine. I would like to add my name to the list of complaints. There is no reason this engine should have failed. I kept up on service, changed the oil within 3-5k miles. I bought the car in Dec 2018 with 59k miles and since then have generated another 60k miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

car has been burning oil, I'm filling it every other week and i barely drive it (less than 30 miles a week). Was driving to the dealer to have it looked at and it failed - I suddenly could not accelerate on a busy highway over 3mph! No warning lights came on at all and it is not throwing any codes. I was almost rear ended. One Kia dealership told me "just keep topping off the oil and drive it till it fails" That seems like an unsafe solution. Will Kia be responsible if I get into a collision if my car suddenly fails?

2016 Kia Sorento SX 3.3l engine failure at 87k miles. Head bolts backed out. Kia dealership verified the issue. The engine could have seized why driving which is a safety risk. No warning lights at all.

Engine stalled when merging in the freeway. Mechanic said that the engine stalled because there was not enough oil. I did an oil change a month prior, and no oil light indication came on until after the car broke down.

Steering sticking,

Oil Consumption issue in which the oil is burning in in the engine. It's a known issue KIA acknowledges however; will not recall to replace the engine. My car has gone through the oil consumption test which they acknowledged it is consuming oil but would cost 1600 to correct a 92% success rate. I don't have the money to fix. Solution from the service dealer was to wait for the engine to go so it can be replaced in its entirety. I am having to check my oil every 1000 miles to top the oil off-quart low and change the oil every 3k. So unsafe to say wait for the engine to go. I am scared to drive my car any further than in the city limits. Is there anything that can be done. Where is the accountability on their end?

Car excessively burns oil. Within 1,000 miles burned through about 4qts of oil with no type warning light. Refilled with 4 more quarts then burned within 3 weeks of average driving. Vehicle only has 90k miles wirth no sign of oil being burned or oil stains in normal parking area.

Car got caught on fire while driving with my 5kids

this vehicle is a match box waiting to kill someone. I've been reporting these problems an nobody has follow up. on 08/20/2023 fuel pump had to be replaced after fumes coming into vents report one on 06/03/2023 issue happened again, 0n 09/04/2023 engine went out. after getting vehicle back catalytic converter and manifold was burnt out do to engine .had it inspected by a muffler shop. kia will not replace anything even if they are told it was caused on behalf of there produce

While driving car sputtered, was able to get to side of road. Turned car off, waited and then turned on again and was able to proceed, engine light on - got occasional performance issues. Kia dealer checked out and servicing, informed me of the oil was depleted issue and in need of substantial engine repair. (Provided written estimate, approx $4800). Able to continue driving but risk of stalling, told eventually timing belt will fail. Got estimates for repairing, and total engine replace to compare options. (Have not done either option as yet).

Sometimes the cruise control works. Sometimes it doesn't work. Even after vehicle is warmed up still no resolution. Engine oil disappears without notice or warning.

Engine burned oil with no warning lights. Engine failed on highway with no warning lights. Regular maintenance and oil change done to vehicle, this was not negligible.

The roller for the headliner falls when I open the sunroof and this causes me not to be able to see out of my mirrors when driving. There has not been an accident or anything to the vehicle and the vehicle has been taken care of the entire time.

The headliner in the truck does not roll back properly and just out the blue falls down when I open the sun roof.

White Pearl paint peeling significantly

I have a pearl white painted Kia (2016) and the paint has severely flaked off where no damage has caused this. I believe the paint is defective, exposing the car to rust.

At various times the headlights shut off while in "auto" mode. Since it is "auto" mode it is always at night and you suddenly cannot see the road. We have found when this happens that the system goes to the "Parking" light mode. Rotating the multi-function switch to a different position other than "auto" and back allows the headlights to come back on. We have not found a pattern in this dangerous event where we are able to repeat the failure.

The paint on the body of my vehicle just started rapidly peeling off on its own really bad from passenger door handle and spreading.

The contact owns a 2016 Kia Sorento. The contact stated that she noticed that the temperature gauge was continuously fluctuating. The contact checked the oil level and noticed that there was no oil in the vehicle; even though the engine oil had been changed two weeks prior. The contact added 3 quarts of oil in the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced, and that the failure was related to Kia Campaign Number: 2002B. The vehicle was taken to the dealer, who informed the contact that they could not replace the engine unless it had completely failed. The vehicle was not repaired. The manufacturer was notified of the failure and advised as the dealer. The failure mileage was approximately 73,000.

Was driving to work RPM's jumped up and stayed after releasing gas pedal. The engine started knocking. Pulled off the road at gas station near by. Shut car off. Had to have car towed to back to my house.

3.3 liter engine - no warning not part of recall or knock sensor per Kia - driving slow ( thank God ) just died . Towed to the dealer - hearing 3 different story’s ? Diagnosis ? Manifold or Rod Bearing issue - whole engine needs replaced over 15k cost . Doing research on this issue snd see many complaints on all makes and models / expect a recall on this vehicle in time as well - it’s only a matter of time till someone is hurt or killed due to Kias repeated negligence in regards to engine failure - the dealer and corporate are ignoring this and that is not acceptable .

While driving through a rain storm on 8/13/23 the paint on my vehicle started to peel off. I have since discovered that this is an issue with KIA, especially the Pearl White color. My vehicle looks like it has been vandalized. Pictures are available. My safety was jeopardized when chunks of paint from the hood were hitting my windshield while driving on the Interstate. On 8/14/23 I took my vehicle to a body shop and they estimated $3,336 to repair or repaint the damage. The formal estimate is available, too. I have been unable to talk to a live person at Kia customer service, but will continue to call so the incident is on the record with them. My contact information is: [XXX] Cell [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle lost.all power engine started to knock stopped in the middle of traffic in 4 lanes almost causing an accident 700 miles from home. Mechanic states engine is blown and that Kia engines don't last past 100000 it will cost me almost 11000 to get a new Kia plus had to pay for rental car motel etc to get home. Pathetic and extremely dangerous and car has to be pushed out of traffic and get a tow truck to haul it. I will never ever purchase a Kia again and will tell everyone I know not to purchase and of course the warranty was off so I have no can and lose 110000..Kia should be held responsible as it looks like this is a continuing and dangerous issue.

Car engine suddenly started to fail, no power, engine knocking, died in traffics turning into an intersection extremely dangerous

Car ran fine until we stopped for gas, went to get back on the highway when the car wouldn't accelerate >25mphs,almost got hit from this. The car was then towed to the near by Kia dealership and they found that it was a compression issue with a known issue in the engine and now we need a new engine or scrap the car. Kia is not willing to fix their horrible product and has told us to just suffer.

Car shutters and stalls and metal shavings in the oil pan

I was driving, pulled over to the side of the street, put the car on park. When I was getting ready to leave, my car would not shift back from park to drive. Shift linkage was detached and was stuck in park.

My engine failed with no warning, my car shut down on the hwy. It was a safety issue because the car shut down while driving on the hwy and could have resulted in a traffic accident. This problen is all over the internet. There were no warning lights. Car ran fine up until it stalled and lost power and shut down. When towed to the repair shop, I was told it was completely out of oil, metal shavings were in the oil filter. The shop replaced oil and the car ran for a bit with knocking noise. On the way to the kia dealership, after learning this was an issue with my type of vehicle, the car shut down again and had to be towed to the dealership. My request for engine replacement was denied even though it is well within 100.000 miles and or 10yrs. It has 84,000 miles. I feel this is KIA's responsibilty to replace my engine. At this time, they are charging me $10,600 to replace my engine.

"Auto" mode on headlights sometimes causes the headlights to turn off while in use in dark conditions. Auto mode also sometimes causes the lights not to turn on automatically or turn on randomly, even when the car is not in use and key is not in the ignition. Lights can turn on randomly when not occupied or being driven.

while driving engine suddenly got hot and blew radiator hose causing overheating to engine cylinder head and leaking coolant. No warning light or gauge indicating coolant overheating. Car was towed to dealership and they indicated no safety recalls on this engine exists despite known common problems of head gasket failures and head bolts coming undone.

Pearl white paint on hood is peeling

I purchased this car in august of this year 2023. Since purchasing it has spent about half of the time I’ve had it at the dealership being repaired (all listed in carfax) Things that have been fixed are thermostat, car has been pressure tested multiple times due to hidden coolant leaks, Oring replaced, thermal module where coolant pipe connects & now it is having oil consumption issues & im in the process of testing. This car only has 60k miles and I’ve only put about 3500 of them on it. It has a good carfax showing it has been maintained properly. The dealership has told me that they are unsure if approval would be given for oil consumption. However this hadn’t been happening before all the coolant issues occured which leads me to believe this is somehow related. & now it is a huge concern to me as the idea that my engine could blow or catch on fire with two little kids in the car is extremely scary. Also there was no engine light on when car started having oil loss, luckily I was just checking fluids regularly and noticed & when we started this process the dealership had to put 3 qts of oil in.

AUG. 5, 2023: CA Steering wheel locked when trying to change lanes. Managed to turn left but went over the curb. It drove well when going straight but could not turn steering wheel. Glad I didn't go on the Freeway. Managed to stop but didn't turn off car due to too hot outside. Called towing, then a family member told me to turn car off, hesitant due to weather, too hot. It worked. TowTrk driver checked under hood and saw no problem. I then drove to dealership and left it there to diagnose. It is till in shop 6wks. It is the steering wheel wiring I am told. Now waiting for a part. Maybe this week. Love the KIA but it did me wrong. Cannot trust it anymore. That is too bad it is an awesome vehicle to me except for the problem. warning came on as incident happened. Manufacturer personnel inspected. Happy no accident just fear of not being able to manage steering easily. I drive a curvy and high altitude road. That really scares me n for any passangers.

I have paint peeling from the hood of my car, the pearl white paint is bubbling up and peeling all by itself. KIA says the it's past the 3 year warranty period so I am responsible for the repair. I have never had paint peel from a car for no reason.

The contact owns a 2016 Kia Sorento. The contact stated that while his wife was driving 50 MPH, the vehicle started overheating and then inadvertently lost motive power. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a general engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 90,000.

We are the second owners of a 2016 Kia Sorento, which we purchased at a KIA Dealership when it was under warranty. The car worked well and we maintained it with regular oil changes and tune ups, until one day the engine began making a loud sound and begin stalling. The car doesn't feel safe to drive, as we know the engine could shut down at any moment. I had two mechanics check the car and they both said that we need a new engine. I reached out to the KIA dealership, but they said they cannot do anything about it. It seems like a manufacturing problem, which may God forbid could put families in danger.

I have the Pearl White paint on my 2016 Sorrento and the top front ,hood and pillars are all delaminating. I have tried to touch up paint some areas but it has gotten too bad to keep up. The paint is peelin g now all over the car.

My kia Sorento 2016 uses excessive amount of oil resulting in engine failure. At the moment my car need an engine replacement. I took my car to get a diagnostic at the auto shop, I was informed that my car engine was dying. I did some searching online, and I find out that Kia Sorento are known to have engine issues and unusual excessive consumption of oil.

Replaced engine 6 months ago only to have the same problem again engine is locked won't start cut off while driving excessive oil consumption