2023 Kia Sorento Complaint Log

Transmission went out while driving on highway. Dealership said they need to replace the entire transmission.

February 23 2026: Discoverd the rear window had imploded on its own overnight. investigated with the neighbor's Ring camera to see if there was suspicious activity overnight and found there was none. I had the glass replaced. I thought this was bizarre to have a window implode but didn't think anything else. March 17, 2026: Driving home from an errand the rear window imploded again with the most impressive sound-like a gunshot- and the window bits sprayed inside the vehicle. The sound was so loud my ears rang for approx 2 hours afterwards. I have the repair people coming out again, but am working with the local Kia Dealership to source the reason for the issue. This is no longer a one-off problem, but a particular car defect. There have been no warnings or extreme weather temperature changes that could factor into the problem. The incidents are sudden and without warning or reason. I have photographs from both incidents.

While driving on the interstate at 70 mph the front part of the panoramic sunroof exploded. There was no debris or road hazards that caused it.

What component or system failed or malfunctioned, and is it available for inspection upon request? —-The radiator How was your safety or the safety of others put at risk? ——possible fire and engine damage Has the problem been reproduced or confirmed by a dealer or independent service center? —— dealer stated rock chip damage. Contesting as manufacturer defect. They should be a plate to protect from this. Advertisement show vehicles off road so how can a normal highway driving cause this type of alleged damage. Is there No manufacturer design to prevent this flaw. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? ——no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? —— yes, warning message on 3/21/26

The contact owns a 2023 Kia Sorento. The contact stated that while driving at 40 MPH, the "Low Oil" message was displayed on the instrument panel. The contact immediately pulled over and called for assistance. A service technician arrived at the scene and added engine oil, and the vehicle was driven to an independent mechanic to be inspected. The vehicle was inspected, and the contact was informed that the bolts on the oil pan were loose, causing oil to leak from the engine. The bolts were tightened. The mechanic then informed the contact that certain Kia vehicles were under investigation for failures with the oil pan and that the vehicle was possibly affected. The contact stated that approximately 4 hours after the oil service, the "Low Oil" message returned. Due to the failure, the vehicle was towed to a dealer for inspection. The dealer was unaware of any investigations regarding the engine oil pan, and the vehicle remained with the dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.

The contact owns a 2023 Kia Sorento. The contact stated that while his wife was driving 10 MPH, after making a left turn, the sunroof shattered with the sunroof cover closed. The vehicle was steered to the side of the road and inspected, but the contact was unaware that the sunroof had exploded. The vehicle was taken to the residence, where the contact’s husband became aware that the sunroof had shattered. The contact had not sustained any injuries. The vehicle was then taken to a dealer, where it was diagnosed that the sunroof had exploded and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 39,000.

I purchased this car with approximately 22,000 miles on it. I have had to have OEM rotor resurface / replacement at the dealership approximately almost every oil change or about every 6,000 miles for about 30k miles (2 replacements, 3 resurface in an 18 month period). They sent out a Kia engineer last time it happened.

Screen not responding properly

I am writing to report a mechanical failure with my Kia vehicle that occurred on January 19, 2026. While stopped at a red light, my vehicle suddenly shut off and would not restart. Although the electrical lights came on, the engine would not turn over. Because my car was stuck in the middle of the intersection blocking traffic, I had to call 911 for assistance. When the police arrived, the officer attempted to jump-start the vehicle, but it still would not start. A tow truck was then called to remove the vehicle from the roadway. I paid $290 out of pocket to have the vehicle towed to a nearby repair shop. After diagnosing the issue, the shop determined that the starter had completely failed. I purchased the vehicle on May 15, 2023. At the time of the failure, the vehicle had just exceeded the 60,000-mile warranty, leaving me responsible for the repair. I paid approximately $500 out of pocket to replace the starter. Given the short time between purchasing the vehicle and the failure of the starter, I believe this may indicate a defective component.

Upon starting the vehicle, it flashed several warning lights that were not on the day before. Including popping codes up on the infotainment system and urging me to schedule a service with KIA. Upon looking up the codes it states HVAC issue, when calling to dealership to schedule a service for it (while it is still barely under warranty) they let me know it might not be covered. That’s when I found out there is a recall only for certain VIN #’s for the exact same issue. My car won’t even drive because the electrical system is being affected. Windshield wipers going crazy, lights not working, AC/heat not working, the emergency braking system braking out of nowhere, the lane departure pulling the wheel while driving without cause. I don’t even feel safe driving the vehicle anymore. Kia needs to have a recall on this that alerts the vehicles owners because I had no clue that there was a potential fire hazard due to faulty wiring.

UNKNOWN However multiple times the front end of the vehicle starts shaking when I try to break up especially on the highway. The dealership claimed to have repaired it once and shortly after it happened again. When I took it in they first looked and said the parts was ordered but nothing was done then came back and said oh yes it was done then refused to fix it without a charge so I had to pay to repair it since I feared that the brake would give out if I drive it. The other issue was the check engine light just popped up check engine while driving on the highway, when I take it in they are stating that I may have left the gas tank open which is absolutely false. They cleared it but could not or neglect to explain why it was on. All these incidents occur while on highways never in the general local areas.

Was driving on Dallas North Toll way when my vehicle lost acceleration. Had to pull over and engine started smoking and lit a flame under the hood. Car is now at Clay Cooley Kia in Irving, TX. Car has been there for over two weeks and I still have no answers or information regarding the plan to fix it. Major dealership delay and all they keep saying is “Waiting on a Kia Engineer to come out but we don't have a date.”

Incident #1: [XXX] The vehicle would not accelerate after coming to a stop at an intersection. The vehicle would not exceed 20 MPH with oncoming traffic from both the East and West as I was turning West from a North Bound Road. On coming traffic was traveling between 45 and 50 MPH. I was clearly nearly broadsided. The car displayed flashing lights on the dash as I was attempting to accelerate. Depressing the accelerator did not increase my speed. The car kept at a 20 MPH speed for the 1/2 mile I traveled to pull off the road in a safe location, causing traffic to be disrupted until I could pull off the highway I had the car towed to the Kia of Round Rock dealership November 17th. The car remained at Kia until December 3rd where they were unable to duplicate the problem. I requested the problem be referred to Kia in California. Kia of CA was totally unresponsive when the problem could not be duplicated. Incident #2 [XXX] Vehicle failed to respond to accelerate after stopping before attempting to enter a four lane highway. (No traffic was visible.) The car would not accelerate more than 20 MPR, the speed limit was 55 MPH. For the 1.5 mile trip home, I turned on my hazard lights, kept to the right and flagged traffic around me. The car never exceeded 20 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was Driving the car and the sunroof exploded out of the blue.

Automatic lift gate closed and injured child. Was placing groceries in vehicle. Closed lift gate with button on lift gate, child was next to me, but hand was behind him. Liftgate closed and would not reopen. Child was injured.

I have been calling the nearest Kia dealership to have this recall fixed since September 2025 and there has been no remedy since. We do not feel safe using the vehicle due to the recall involving a fire hazard due to HVAC wiring. We have a family that needs the vehicle and its been 3 months with no remedy and no estimated date of when remedy will be available, so remedy for recall is indefinite. We would like Kia to repurchase the vehicle or assist in auto monthly payments, as we are paying for a vehicle that we cannot use. We have kids and do not feel comfortable driving in this vehicle. We use this vehicle to help work and recall has impacted us financially. Below are details of the recall as we are trying to get Kia to help with: Manufacturer Recall Number SC351 There is no remedy for this safety recall ***REMEDY IS NOT AVAILABLE YET*** KIA AMERICA, INC. IS RECALLING CERTAIN 2021-2023 SORENTO VEHICLES. THE HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) BLOWER MOTOR WIRING HARNESS MAY BE INADEQUATE, WHICH CAN RESULT IN A FIRE. Safety Risk A FIRE INCREASES THE RISK OF INJURY.

Around 35,000 miles the vehicles fuel pump, relay assembly, and smart junction box failed and left my wife stranded. Kia took about 7 days to diagnose and repair.

The contact owns a 2023 Kia Sorento. The contact stated that while the vehicle was parked, the gear shifter was shifted into drive, the accelerator pedal was depressed; however the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to move forward. No warning lights were illuminated. The contact stated that the failure had occurred more than five times within a month. The failure occurred after a previous repair was performed by the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that previously, while the vehicle was parked on a hill, the gear shifter was shifted into reverse, and the vehicle rolled forward and crashed into a curb. The vehicle was taken to the dealer and was repaired. The contact was informed that the failures were not failures but instead the normal function of the vehicle. The contact submitted a Lemon Law claim and was advised to contact the NHTSA Hotline to report the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,700.

Moonroof unexpectedly shattered, like a bomb had gone off, sending thousands of pieces of glass into the interior and on the vehicle occupants (including 3 children [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While I was driving on an interstate road(with no vehicles around) the sun roof of my 2023 Kia Sorento exploded and the glass completely shattered and caused pieces of the broken glass to fly off. Thankfully I had the visor up so none of the glass fell onto me, otherwise myself and my two kids (3 year old and 6 month old) could have gotten seriously injured. With nearly 80% of the glass sunroof panel above the driver area popping off, that much glass falling onto me could have caused a serious distraction and caused me to run into another vehicle or lose control of the vehicle. At the time the sunroof shattered, there was nobody on the road or any external debris that could have caused the sunroof to shatter like that. I suddenly head a loud explosion that sounded almost like a shotgun being shot and was instantly startled, and when I realized we were all okay in the vehicle I heard the sound of glass sliding off the roof of my Sorento. I then began to see chunks of glass falling on the road behind me which posed as a risk to other vehicles that were behind me and caused other drivers to swerve to avoid being hit by the glass. Since this has happened, I have contacted Kia and taken it in to my local service department. The service manager (when he inspected the sunroof) stated the glass is tempered glass and should not explode when cracked or shattered. Other reports of this exact issue is prevalent online and poses a great risk to consumers, families, and other drivers on the road.

I was driving down the highway when the sunroof randomly exploded, there was no debris that hit the roof or damages to the roof prior.

Front panel of panoramic sunroof shattered while driving on Interstate 90 at approx 65mpg. Sunroof was fully closed. Exploded on its own with no outside influence. Conditions were clear and dry. Sounded like a gun shot and glass was flying everywhere. Fortunately shade was closed with no glass entering passenger compartment. Could have resulted in injuries or accident if glass entered the driving inside area.

Brakes and rotors needed changed at 23930, not normal

on [XXX], the check engine light came on solid. My car is just 2 years old, only has 22K miles, and is currently under warranty, as it is a leased vehicle. According to Auto Zone, it was a "speed sensor". On 7/25/25, I was able to get an appointment with Garvey Kia of Queensbury, NY and the fault code is the "input turbine shaft speed sensor B circuit range for performance". The service technician told me that it is not able to be accessed, as it is internal, and it is not serviceable. My safety and the safety of others were at risk because the car would go "limp" when accelerating, there was harsh and delayed shifting, erratic RPM readings, and no power when accelerating. This inability to accelerate causes problems in traffic and when trying to get through intersections or out of side streets when acceleration is imperative. Yes, the car has been inspected by the Kia dealership. This same exact thing happened on [XXX], in which Destination Kia of Albany had by car for over 4 weeks to replace the transmission. At that time, the car had under 10K miles and was not even a year old. At that time, they put a refurbished transmission into the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Safety concern. Vehicle suddenly could not maintain highway speed; vehicle unexpectedly decelerated. We were forced to pull over on the shoulder of the freeway. We called 911 and officers came. Officer confirmed being stopped on the shoulder of a major freeway was a very dangerous situation. We had 3 adults and two sleeping children in the car. No warning signals in the vehicle prior to the incident.

The contact owns a 2023 Kia Sorento. The contact stated that while driving 55 MPH or higher, the vehicle was vibrating abnormally. The contact stated that while depressing the brake pedal, the brakes seized with an abnormal sound coming from the brakes. The vehicle was taken to the dealer, and the contact was informed that the vehicle was included in an undisclosed recall related to rotors, and the rotors were replaced under the recall. However, approximately 2 months after the repair, the failure reoccurred. The vehicle was returned to the dealer, and the contact was informed that the rotors had failed again and needed to be resurfaced. The dealer started to resurface the rotors, but the contact decided to stop the process. The contact researched and determined that rotors needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 12,000.

The car is accelerating without anyone pressing down on the gas, not accelerating when our foot is on the gas, jerking unexplainably and the emergency brake warning is coming on when it has not been employed.

The contact owns a 2023 Kia Sorento. The contact stated that while attempting to activate the HVAC system, there was an abnormal burning plastic odor inside the vehicle. There was no warning light illuminated. The vehicle was to an independent mechanic who diagnosed the vehicle and determined that the blower motor relay had short circuited and needed to be replaced. The vehicle was not repaired; however, the contact performed a repair based on guidance from the mechanic. The contact stated that the vehicle was repaired, but the failure with the blower motor relay reoccurred. The contact recently received notification of NHTSA Campaign Number: 25V649000 (Electrical System, Visibility). The contact related the failures to the recall. The contact called a local dealer and was advised that the remedy was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 48,000.

The car overheated while driving and my wife and daughter had to pull over to side of road. Engine Coolant was spilling everywhere. Car was towed to Raceway Kia in Freehold NJ. The dealer advised my wife that the radiator needs to be replaced and it was NOT covered under warranty. They claim that debris from the road must have damaged the radiator and therefore it was "third party damage". I searched the web for incidents and found that this ios a design problem in the Kia Sorrento. Their design causes the vulnerability to get damage to readaitor due to leaks. This should be recalled and redesigned before someone gets seriously injured as a result.

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

I am reporting a vehicle fire that occurred in June 2025 involving my Kia vehicle. On the day of the incident, I started my car and immediately noticed excessive smoke coming out of the air vents, along with a strong burning smell. I drove only a short distance and pulled into a gas station across the street to stop and check what was wrong. While stopped, my children in the back seat alerted me that there was a fire coming from the rear AC vent area. I known it was fire because I saw flames inside the AC vent located in the back seat area of the vehicle. I immediately got my children out of the car and ran inside the store to ask for help. When I walked back outside moments later, my entire vehicle was engulfed in flames. The vehicle was a total loss. At the time of the incident, there was no recall issued for my vehicle. However, in November 2025, I received a recall notice from Kia by mail that appears to be related to the cause of the fire. I purchased this vehicle from Toyota Cavender in October 2024. Since the fire, I have contacted Kia multiple times seeking assistance and resolution, but I am still waiting for a response. This fire occurred without warning and put my children and me in immediate danger.

Check engine light on. Rear defrost doesn't work. Auto stop/start not working. Cruise control not working. Vehicle shuts off sometimes at stand still and have to put in neutral or park and push Start button. Engine looses power while driving. Check rear cross traffic, check tire pressure monitoring system, check lane departure warning system, check speed limit system, check lane keeping assist, check forward safety system lights are cycling on the front screen and warning ️ signs pinging. Vehicle has been inspected 3 times at a local KIA DEALERSHIP. 1st in 4/2025, 2nd 6/2025 3rd time 10/2025. Module was replaced and 2 days later same issue so Vehicle will be going back a 4th time. No warnings before issues started. Sometimes it does it for hours and sometimes it's back to normal.

On 8 occasions, while driving on a highway, the emergency lights started to flash out of no where and the driver could not accelerate. The driver had to find a way to pull over and turn the car off and then restart the car. The car was taken in 3 times and checks were run but no codes showed up. The third time the car was brought in, the mechanic agreed to drive it until the problem could be reproduced. The car was driven for 70 miles but it could not be reproduced. The mechanics were informed that it happened every 300-500 miles and the car had not been driven enough. The mechanics said it was running as designed. Our safety and everyone on the road was put at risk if we could not get over to a shoulder.

Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem

Was driving up a hill when the 'Auto-Off' light started flashing on the driver display. Car would not accelerate above 20mph. At the top of the hill, I switched gears to neutral and the car began operating as expected; however, the same behavior occurred again at the next hill. Pulled over and restarted the car. Car worked as expected after restart. This is dangerous. I was taking my daughter to school in morning rush hour traffic. We live in a very hilly area and I'm terrified to drive the car. I dropped it off at the dealership almost 2 weeks ago and they have yet to identify the issue. I do see similar complaints on this site so I'm hoping that you are investigating.

All safety features disabled, srs light turns on, vehicle shuts off when driving, guage cluster is inop doesn’t show speed.

Engine consuming excessive oil between oil changes.

What component or system failed or malfunctioned, and is it available for inspection upon request? I was driving and the car completely shut down- I could not use my brakes or accelerate. I had to pull along the road in ongoing traffic to coast to a stop. I lost all control. How was your safety or the safety of others put at risk? I was in traffic and the cars behind me had to slow down immediately, I could not speed up or even brake to come to a stop. Others around me as well as myself were in danger. Has the problem been reproduced or confirmed by a dealer or independent service center? They reviewed and said they scanned it and did a drive test and could not find the cause. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, It was seen at the Kia dealer I bought it from. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? As soon as the vehicle lost power there was a warning sign on the dash that showed "limit" with a half circle emblem.

Transmission Warning Indicator appears on Dashboard Cluster and vehicle bucks and stalls and won't shift properly. Dealership found Transmission was never filled properly and below specifications according to Kia Service and was verified the fluid level was extremely low and not filled to specification from factory. The dealership filled transmission to proper level and test drove vehicle. Issue seamed to be fixed. But now a month later same transmission is is happening with Transmission warning Indicator and vehicle bucking and not shifting properly causing erratic vehicle behavior and safety issues.

When I start driving, there’s a lot of hesitation like it’s going to stall and it also does this going up hills or mountains? I was on the interstate and there was a line of cars behind me and my car started to hesitate and almost stall, causing all cars behind me to break to not cause a domino effect accident I have reported this to the Kia dealer and knowing that there’s a lot of DCT problems that are posted all over the Internet they are saying there is no problem with the car upon doing research again there is a lot of DCT reporting of Kia’s not just my Sorrento please do some research on this and help me. We just bought this car. There is 13,000 miles on it. It should not be doing this and again I’m going to a different Kia to see if they say the same thing. Below you ask for a date that this happened there is too many dates to enter, but I will try to enter the very first one that we experienced.

While driving vehicle looses throttle power, goes into limb mode. Does not throw any codes. Turn the car off then back on and drives fine for a little bit. Has happened numerous times. Multiple trips to the dealership but since no codes pop up nothing can be fixed. Major safety issue!!!!

I had just entered the highway and reached highway speed of 70 mph. Without any warning, the engine died, all of the dashboard lights came on, and I was unable to accelerate. Thankfully I was in the right-hand lane and there was an exit ramp a short distance ahead. The car decelerated as it had no power, and cars behind me were honking. I was able to exit the highway and coast into a parking lot just off the frontage road. Had I not been able to get off the highway, the vehicle would have been stalled in fast-moving traffic, and a pile-up could have easily occurred. I turned the car off using the push button start/stop, waited several minutes, and restarted the car. The check engine light was on and the car diagnostics system reported an issue with the "engine management system." Upon clicking the details link, the diagnostics system further stated "A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealership to schedule an appointment." I took the car to a local Kia dealership, and they stated they could not recreate the problem. They reported they "inspected the vehicle for DTC's and found code PO65312 in history." They cleared the code and reported, in writing, that "no issues found during test drive, vehicle currently operating properly, no further action taken" and gave the car back to me without fixing anything. They stated it may need to be diagnosed for longer ext diag time. The vehicle is available for inspection, and I would appreciate any help I can get as I got no help at the dealership.

Mounting bracket for the backup camera failed and caused the camera to dangle from the car. This caused me to not be able to use the camera to view objects and surroundings directly behind the vehicle. A dealer said they fixed the part back when it was originally recalled, but the new bracket broke and the dealer is refusing to fix the issue. They said the initial recall was completed and the part is now out of warranty and therefore they will not fix it, even though the exact part that was recalled originally has now failed again.

Car is a huge safety issue. Seems to be DCT transmission issue. Car gets stuck in first or second gear and revs all the way up. Happened multiple times getting on highway or at intersections. This has almost caused multiple accidents for me. You can push the pedal to the floor and it won’t do anything. The only temp fix is turning car off and back on.

The vehicle was purchased new. From day one, there were issues. When it was delivered from the factory, it was discovered to be partly unpainted. This raised quality concerns. So far, the most serious has been that the motor blower failed at approximately 29,700 miles. This resulted in the vehicle filling with noxious fumes. It then had to be abandoned on the side of the highway. This led to a fire dispatch and later urgent care visits. Prior to towing, it was discovered that the AC was not working and the engine coolant reservoir was at ~ 1/4 of the minimum line. Ultimately, the vehicle was towed to King KIA. They held the vehicle for 2 weeks. They drove the vehicle 16 miles. However, they did not diagnose the problem. The only action that they took was to refill the engine coolant reservoir. Prior to pick-up, we notified the KIA Customer Service Escalation Case Manager in writing that the vehicle had not been fixed and continued to represent a safety risk to our family. They took no further action. After pick-up, the vehicle was driven approximately 35 miles before the smoke started to fill the engine cabin. It was taken to two independent mechanics along the side of the highway. One was Vienna Auto Care and the other was Jiffy Lube Auto Care. Both identified that the motor blower resistor had likely failed. The JLAC manager also identified white material on the engine manifold believed to be engine coolant. All was documented in writing. The vehicle was towed back to King KIA. Prior to towing, the JLAC manager told us that melted motor blower casing was highly toxic. (Later, the KIA Case Manager informed us that he would admit that our family was put at risk by being told to pick-up the unfixed vehicle.) He also told us that if the motor blower failed then it likely was not an isolated case. This time, the motor blower failure was reproduced. However, the engine coolant issue has yet to be resolved. We are now being instructed to pick-up the car again.

This was an alarming situation. I was taking my wife for a cancer treatment in our 2023 KIA Sorrento with 2600 miles on it. The instrument panel showed a A with a circle around it, blinking continuously. I was going up a grade in a town and the car would not accelerate. All of a sudden the engine SURGED the brakes would not stop the car, I put it into neutral and went into a parking lot. If there would have ben a car in front of me or no place to pull over there would have been a serious accident. I called the KIA dealership and took it in for a diagnostic test. Nothing wrong with car was their answer. In the mean time I am afraid to drive the car. I am [XXX] and reflexes are not as good as they were [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On the morning of July 14, 2024 I noticed a crack on the driver side on the window. The crack appeared on the bottom of the window and travel upwards where it ended. This morning July 15, 2024, the crack spread across towards the passenger side of the vehicle. Nothing hit the window for it to develop a crack as my car was parked in the driveway and there were no markings on the window. I do put on the window sun visor to keep the excessive heat out of the car.

When attempting to start the car, the engine will not start and every alert system and dashboard light turns on. The car is undriveable when it does this. It takes 5-10 minutes of turning the car on and off before it stops and is drivable again. It does not happen every time and seems to be random. This has happened 5 times. An additional 6th time this same issue happened while I was driving - all of the dashboard lights went on, and every alert / warning turned on (forward collision, lane warning, etc). The steering wheel also became stiff and extremely difficult to turn. I have been attempting to work with 2 different Kia service departments and their corporate escalations department without luck. They are unable to replicate the issue and are planning to give the car back to us. After seeing so many similar or same issues reported on various forums I am filing a NHTSA claim. (One forum example here: [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

6/22/24-Initial start of dashboard light "miscommunication"-Codes could not be duplicated at Evans Kia dealership 7/11/24-Miscommunication occurs again-Codes pulled for diagnostics 7/22/24-Car brought in for scheduled appointment to dealership to "fix" communication errors: I was told "There was an issue with the system not updating but I should be good to go now" 2/17/25-Communication errors reappear on dash-Car taken back to dealership; Tech line case opened; Dashboard Cluster Replaced; Car given back to customer 3/20/25-Lemon Law Case filed: Determined past mileage window-Given $3000 settlement for my trouble 6/23/25-Miscommunication reappears on dash: Car taken back to dealership; Tech line case opened; Replaced Steering Column Assembly-Car given back to customer Customer files complaint with Kia Customer Affairs 6/30/25-Miscommunication reappears on dash: Car taken back to dealership; Numerous codes read from diagnostic-Tech line case opened-Front windshield camera is ready "overheating"-Tech line advises for the the camera to be replaced; Car not given back to customer and tech authorized to test drive 7/07/25-Customer informed miscommunication reappeared on dash; Tech line contacted and additional repairs pending their advice 7/15/25-Field Tech scheduled to come to Evans Kia dealership 7/24/25 "The safety of both myself and my children has been repeatedly compromised. No representative within Kia's organization has been able to provide assurance that, when all dashboard warning lights illuminate, the vehicle will not experience a complete malfunction. As a result, I no longer feel safe operating the vehicle. In July 2025, I formally requested that Kia Corporate initiate a buyback of the vehicle, rather than returning it to me following another attempted repair."

THIS IS THE SECOND REPORT I AM MAKING. As in my last report this involves the driver’s seat and changing profiles on the infotainment system. - The driver’s seat/profile will keep my settings for a few weeks or months and then it randomly forgets and resets to the factory settings. - On June 18, 2024 the infotainment profile was set for my husband. I switched to my profile and was backing out of my garage and the seat switched to factory settings while the car was actively in reverse. I am short and could not reach the break or gas pedal! - The dealer has not had any other complaints like this.