2022 Kia Telluride Visibility & Wipers Problems

Windshield cracks so easily, slightest road debris creates a chip then crack

We were driving in the left hand lane on i75 south about 15 miles south of [XXX] and about 10 miles from [XXX] . We were traveling about 75 mph with air conditioning on low. We heard a loud bang and pulled off at exit 328 to investigate. We pulled over at Myers carpet on dug gap road. We looked at the sunroof and it looked like it had exploded upward. 1/3 of the glass was gone and a cone like upward shattering appears in the edges of the blowout area. We had to go to the nearby tractor supply to find duct tape and plastic sheeting to tape over the whole sunroof to drive home to [XXX] . It just happened on 3/15/2026 at approximately 4pm. We have not yet been to a Kia dealer or called consumer affairs at Kia corporate yet. I am filing a ticket with Kia now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The windshield cracked for no apparent reason. The crack was on the driver's side, about 16 inches long, starting near the top and curving around the driver's view to the middle of the windshield.

I had noticed a 1" wide crack had formed in the center of the windshield after first night of cold weather (~10°F). There was no prior damage to the windshield before the crack formed. I'm concerned that the crack will continue to spread as we progress into the winter in the upper Midwest, ultimately shattering while I'm driving.

Windshield cracked for no reason. Developed a crack from the edge to the center of the windshield about 2 ft long.

My windshield had a light crack and it ran pretty easily. It should not have done this so quickly. The crack should have been isolated and given me time to get it repaired before I have to replace the whole windshield. I can feel the break. I wouldn't think with a laminated windshield that all US cars are required to have, that I could actually feel the sharpness of the broken glass.

We are replacing a second windshield in less than 2 years. Small pebbles start a chip, and the window companies try to fill the chip, but it cracks anyway. In both instances, the crack spanned from one side toward the top and affected my line of sight. The glass companies say they fix a lot of these cars. I'm afraid to go through the car wash with the high speed dryers for fear that the windshields strength is compromised and something can happen. Kind of makes my car wash membership useless...... That's over $2000 for 2 windshields and even then I have no guarantee that it will last. I'm seriously thinking of selling it as soon as I get it fixed. I'll definitely check the newer models to see if they are still having a problem. Maybe they can do us a favor and at least manufacture a better quality window for our next installation?

I was driving my 2022 Kia Telluride and my windshield crack, on the road and the crackline still running across my windshield. I think is dangerous to drive, but I don't if Kia will replace or do I need to pay my self

My Wife was driving 37mph in town at 1:40pm on a 31* afternoon. When she hears an apparent "gunshot", it was not a gunshot. Her forward sunroof had exploded. She had the sunshade closed thankfully so she did not get hit with any glass. Her vehicle was not hit by anything. The glass looks like it was forced from the inside, blowing the glass outwards. We took her vehicle to our local dealership. They vacuumed up the glass shards, and then taped the remaining glass on both sides, and also covered the roof until repairs can be made. Dealership is filing for warranty, but awaiting approval.

The contact owns a 2022 Kia Telluride. The contact stated that while driving at an undisclosed speed, the rear windshield inadvertently shattered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who was unable to diagnose the failure. The contact was informed that the manufacturer was aware of the issue. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 37,000.

Description of the Problem: I noticed a crack suddenly appearing on my car’s windshield without any external impact, such as a rock or debris. The crack seems to have formed spontaneously, starting from the bottom edge and growing through the center of the glass, and there are no visible signs of external damage or impact points. This raises concerns about the quality or structural integrity of the windshield. It started early in the morning at about 6 inches but now has more than 12 inches and two ramifications. The car was parked in front of our garage and there were no extreme temperature changes. Concerns: I am worried that the windshield may have a manufacturing defect or material issue that could compromise the safety of the vehicle. This could pose a risk if the crack spreads or the windshield fails under stress.

A small rock hit my windshield on my way to work but did not initially appear to cause damage. Upon arriving at work I made no notice of any visible cracks or damage. Went in to the office, worked 8 hours, proceeding to get in my Telluride, removed my sunshade and noticed about an 18" to 24" long crack in my winshield running right down the middle. It was mindblowing how bad the crack was after a day that was not extremely hot or cold.

Windshield cracked under normal driving conditions. The crack was not caused by a strike or impact of any kind.

Windshield crack developed from the lower left driver side, up and across to the middle of the glass right in the field of view of the driver. There was no chip, no strike of any kind. Simply pulled the car out of the garage where it is kept daily and went 1 mile to the mail box. The crack appeared on my return and is getting larger. Did my research and found out about the class action lawsuit. I've seen where it is very much a known issue. I will contact KIA customer care next and then the dealership.

My windshield has cracked spontaneously and now I have a crack that is the length of a quarter of the windshield.

In preparation for winter driving operations that include clearing the windshield of snow and ice, "before entering the vehicle"; both windshield wiper arm assemblies are not able to be lifted away or disentangled from the windshield glass due to the specific design interference of the hood. ************* Without properly clearing the wiper arms, wiper blades and windshield of ice and snow, operating the vehicle is not safe. *************

Windshield had a small chip and then spidered next day across entire windshield. Dealer said, “So sorry, but can’t help or repair.” The 2020 Telluride had a recall and they fixed my first one after repeated calls.

Our windshield spontaneously cracked despite striking nothing.

Saturday July 8 2023 heard crackling sounds like static coming from approximately 3/4 across the front console. Turned off radio, disconnected phone. Sounds continued, with no connection to road conditions or speed. Sunday July 9 2023 sounds continued intermittently. Monday July 10 2023 crackling sounds continued until a loud pop was heard. Windshield cracked at approximately 3/4 across the front and center of vertical (mid passenger vision). Very small center dot with three lines - looks like a bowtie or cat whiskers - intersecting at the dot, with a horizontal and two diagonal lines. Crackling sounds have since ceased. No impact to the windshield was detected prior to the crackling sound beginning.

Driver side wiper gets stuck and won’t wipe in intermittent mode. Sporadically stops in auto mode.