2003 Lincoln Navigator Suspension Problems

MY ROOF-MOUNTED DVD PLAYER HAS NEVER WORKED BUT STILL MAKES NOISES WHEN CAR IS CRUNK UP OR SWITCHED OFF, MY BATTERY ALL OF A SUDDEN WENT DEAD (CAR WOULD NOT CRANK), HEADLIGHTS HAVE SHORTS IN THEM...AFTER REPLACING $100 BULBS, I FOUND OUT IF I TURN THE LIGHTS OFF AND BACK ON, THE BULB WILL COME BACK ON, CHECK PARK ASSIST LIGHT AND ALARMS COME ON EVERY TIME THE VEHICLE IS PUT IN REVERSE, AND MY SUSPENSION WILL NOT LET THE VEHICLE UP WHEN THE WEATHER IS COLD. *TR

TOTAL AIR SUSPENSION FAILURE. *TR

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, A LOUD ROARING NOISE WAS HEARD FROM THE FRONT PASSENGER'S SIDE OF THE VEHICLE. THE CONTACT INSPECTED UNDER THE HOOD AND DETECTED THAT THE NOISE WAS COMING FROM THE AIR LIFT COMPRESSOR. THE NOISE COULD ALSO BE HEARD WHEN THE VEHICLE WAS STATIONARY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,319.

THE RIGHT SIDE FRONT AIRBAG RIDE SUSPENSION BAG EXPLODED WHILE DRIVING. *TR

THIS IS A COMMON PROBLEM THAT NEEDS TO BE FIXED IT'S ALL OVER THE INTERNET. THE SUSPENSION SYSTEM ON THESE ARE ALWAYS MESSED UP PLEASE FIX THIS. *KB

SUSPENSION PROBLEMS IN MY 2003 LINCOLN NAVIGATOR. *TR

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE AIR RISE SYSTEM ON THE VEHICLE FAILED AND WAS CAUSING THE VEHICLE TO BOUNCE ABNORMALLY WHEN DRIVING OVER ANY TYPE OF ROAD BUMP OR UNEVEN ROAD SURFACE. THE AIR RISE SYSTEM WAS REPAIRED TWICE, BUT THE FAILURE CONTINUED TO RECUR. THE DEALER ADVISED THE CONTACT THAT THE ENTIRE AIR RISE SYSTEM WOULD NEED TO BE REPLACED. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 157,000.

AIR SUSPENSION MOTOR HAD TO BE REPLACED AT AROUND 100,0000 MILES. ALSO AIR BAGS LEAK AND ARE SLOW TO AIR UP IN COLD WEATHER. MECHANIC SAID NEED TO REPLACED. *TR

A YEAR AND AHALF AGO, THE NAVIGATOR BEGAN TO MAKE STRANGE GROWLING NOISES WHEN IT WAS PARKED UNDER THE GARAGE. SOME DAYS WHEN I WOULD TRY TO GET INTO THE CAR, IT WAS HIGH OFF THE GROUND, OTHER DAYS IT WOULD BE EXTREMELY LOW. THE ENTIRE SUSPENSION WENT OUT ON OUR 2003 NAVIGATOR. IT COST ME OVER $700 TO HAVE IT REPAIRED. THIS IS MY ONLY TRANSPORTATION, SO I HAD TO BORROW A CAR FOR A WEEK TO GET TO WORK. NOW, IT IS OUT AGAIN! BECAUSE OF THE LAST EXPERIENCE, I HAD BEEN DOING A SYSTEM CHECK PERIODICALLY. THE CHECK ALWAYS SAID, "SUSPENSION OK". WELL, TWO WEEKS AGO, I BEGAN TO NOTICE THE CAR SEEMED TO LEAN TO THE RIGHT OR LEAN FORWARD WHEN PARKED. FINALLY, LAST WEEK MY HUSBAND SAID, THE CAR WAS RIDING LIKE A BOUNCING BUGGY - THE SUSPENSION IS GONE AGAIN! THIS IS THE SECOND TIME AND I CANNOT AFFORD TO HAVE IT REPAIRED. IT IS THE ONLY TRANSPORTATION WE HAVE FOR GETTING TO WORK. AND I'M STILL PAYING ON A CAR THAT I CANNOT RIDE. *TR

FRONT AIR SUSPENSION ON THE PASSENGER SIDE DOES NOT WORK IN COLD WEATHER, AND ONLY WORKS HALF OF THE TIME IN WARM WEATHER. TRUCK IS VERY WELL TAKEN CARE THRU THE DEALERSHIP AND HAS ONLY 76,000 MILES AND BEEN TO THE DEALER SEVERAL TIMES FOR THE SUSPENSION AND RIGHT RUNNING BOARD. SEE ALL OVER THE INTERNET NUMEROUS COMPLAINTS ABOUT THE SAME THING, THIS IS CLEARLY A COMMON PROBLEM WITH THE MODEL (2003 LINCOLN NAVIGATOR). THE TRUCK HAS NOT BEEN DRIVEN IN 2 MONTHS BECAUSE OF THE EXPENSE AT THE DEALER TO REPAIR. *TR

2003 LINCOLN NAVIGATOR TRAVELING 65 MILES AN HOUR AND SUSPENSION WENT OUT REAR ONE THIS TIME TRUCK BOUNCED SO HARD HIT MY HEAD AND TRUCK WAS UNCONTROLLABLE WE NEED TO SUE LINCOLN. BOUGHT MINE IN STATEN ISLAND DANA MOTORS WAS IN SHOP 21 TIMES FOR THE SUSPENSION THEY FIXED AND 3 MONTHS LATER OUT AGAIN LAST TIME OCTOBER COST ME 1100 DOLLARS . VERY BAD TRUCK STUCK WITH PAYMENT OF A DEATH TRAP! *TR

SUSPENSION RELAY FAILS THEN COMPRESSOR FAILS NOW IT STILL WILL NOT FILL AND HOLD AS IT SHOULD RIGHT FRONT DIPS DANGEROUSLY LOW NO REAL FIX OR RELIEF IN SIGHT. *TR

THE SUSPENSION IN MY 2003 LINCOLN NAVIGATOR HAS GONE COMPLETELY OUT. THE ESTIMATE TO GET IT FIXED IS OVER $1000, BUT CANNOT REPAIR BECAUSE I HAVE BEEN LAID OFF FOR OVER A YEAR. BEING AS HOW THIS DEFECT IS SO WIDELY AFFECTS THIS MAKE AND MODEL VEHICLE, IT SHOULD BE INVESTIGATED AS A POSSIBLE RECALL. A TYPICAL CAR DRIVER SHOULD NOT HAVE TO BE EXPECTED TO PAY FOR AN OBVIOUS ENGINEERING DEFECT. WE'RE TALKING ABOUT THE ENTIRE SUSPENSION SYSTEM FAILING WITH ONE COMPONENT GOING OUT. *TR

I HAVE A 2003 LINCOLN NAVIGATOR .I BOUGHT IT IN STATEN ISLAND NY DANA MOTORS 2 YEARS AGO I HAVE HAD IT IN THERE SHOP FOR SUSPENSION CENSORS AND BAGS OVER 10 TIMES MY WARRANTY EXPIRED 30 DAYS AGO AND GUESS WHAT MY REAR SUSPENSION WENT OUT .I CONTACTED FORD OVER 10 TIMES AND I WANT TO SAY THAT THIS HAS TO BE THE WORST TRUCK AND COMPANY I HAVE EVER HAD TO DEAL WITH FORD FOUND ON ROAD DEAD GO GM. *TR

AIR SUSPENSION SENSOR WILL NOT STAY ATTACHED AND CAR HEIGHT ADJUSTMENT RANDOMLY GOES UP TOO HIGH OR DOWN TOO LOW. IF THIS OCCURS WHILE IN MOTION IT COULD BE VERY DANGEROUS AS THE TIRE CAN COME IN CONTACT WITH THE WHEEL WELL. CAR WAS TAKEN TO DEALER AND WE WERE TOLD THAT IT WOULD BE $2000 TO REPAIR. FOR NOW THE SENSOR WAS CLIPPED BACK ON AND EVERYTHING WAS WORKING FINE. A WEEK LATER SENSOR CAME OFF AGAIN AND WE HAVE FIGURED OUT HOW TO PUT IT BACK ON OURSELVES. AFTER DOING SOME RESEARCH IT SEEMS THAT THIS IS A COMMON PROBLEMS WITH THIS MAKE AND MODEL AND YEAR OF VEHICLE. THOUGH LINCOLN DID CORRECT THE ISSUE WITH THE NEWER MODELS NO ATTEMPT HAS BEEN MADE ON THE OLDER MODELS TO MAKE A MORE LASTING REPAIR. ON LINE THERE ARE TONS OF REPORTS OF PEOPLE THAT HAVE HAD THE PARTS REPLACED TO ONLY FIND THAT THIS DID NOT REMEDY THE ISSUE AT HAND AND MORE MONEY NEEDED TO BE SPENT TO ATTEMPT TO CORRECT IT. THERE ARE COMPANIES THAT HAVE COME UP WITH SYSTEMS TO REPLACE THE AIR SUSPENSION WITH TRADITIONAL SUSPENSION SO THAT MULTIPLE REPAIRS CAN BE AVOIDED IN THE FUTURE. THIS IS EVIDENCE TO ME THAT A DEFECT IS KNOWN INDUSTRY WIDE. *TR

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED WHILE DRIVING 35 MPH THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT HAD TAKEN THE VEHICLE TO THE DEALER REGARDING THE ELECTRICAL SYSTEM AND THEY STATED THE ENTIRE FUSE BOX NEEDED TO BE REPLACED. THE CONTACT STATED THE SUSPENSION WAS ALSO DEFECTIVE AND THE AIR BAGS WERE DEFLATING. THE DEALER STATED THE AIR BAG FOR THE SUSPENSION NEEDS TO BE REPLACED. THE FAILURE MILEAGE WAS 76,000.

I BOUGHT MY USED 2003 LINCOLN NAVIGATOR IN 2008. A YEAR LATER, AIR SUSPENSION FAILURE HAPPENED SEVERAL TIMES. BOTH IN CITY AND ON HIGHWAY - VARIOUS SPEEDS - BUT THE SCARIEST AND MOST DANGEROUS WAS WHEN IT HAPPENED ON THE HIGHWAYS. CAUSED VEHICLE TO LOSE ALL SUSPENSION AND DROP EXTREMELY LOW. THE NAVI BOUNCED DANGEROUSLY AND VIOLENTLY EVEN AT VERY REDUCED SPEEDS. IT ALSO CAUSED THE NAVI TO SCRAPE THE GROUND ON A FEW OCCASIONS. HAD IT REPAIRED THREE TIMES @ $500+ AND WAS FINALLY TOLD THAT I NEEDED TO REPLACE ALL FOUR @ APPX $2000+!! I WAS ALSO TOLD THAT THIS IS A KNOWN PROBLEM WITH NAVI'S. IN ORDER TO SAVE MY TIME, MONEY AND SANITY, I OPTED FOR SPRING-SUSPENSIONS AT A THIRD OF THE COST AND HAVE NOT HAD ANY PROBLEMS WITH THOSE IN OVER 4 YEARS! I HIGHLY RECOMMEND THE SPRING-SUSPENSIONS AND STOP THE INSANITY. *TR

TL* THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THE AIR SUSPENSION SYSTEM DISENGAGED AND THE VEHICLE BEGAN TO SHAKE VIOLENTLY WHENEVER HE DROVE OVER A BUMP IN THE ROAD. THE FAILURE OCCURRED WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT NOTICED THAT THE SUSPENSION SYSTEM WAS DISENGAGED WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AT LEAST TEN TIMES TO BE REPAIRED. THE FAILURE CONTINUED TO OCCUR. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED MORE FREQUENTLY DURING COLD WEATHER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

CAN YOU CHECK OUT 03 LINCOLN NAVIGATOR AIR SUSPENSION BECAUSE MY KEEPS FAILING COMPRESSOR AND HEIGHT SENSOR CAUSING ROUGH RIDES CHECKED ONLINE SEEMS LIKE ALOT OF PEOPLE HAVE SAME PROBLEM LIKE ME TOO. *TR

TL*THE CONTACT OWNS A 2003 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH THE FRONT AND REAR SUSPENSION FAILED AND CAUSED THE VEHICLE TO BOUNCE ABNORMALLY. WHILE TURNING THE STEERING WHEEL HE COULD FEEL THE BODY OF THE TRUCK TOUCH THE TIRE. THE ABS LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL PRIOR TO THE FAILURE. THE VEHICLE WAS INSPECTED AND REPAIRED IN APRIL 2008 AND HAD NOT BEEN INSPECTED FOR THE CURRENT FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. UPDATED 5/9/11 *CN