2004 Mazda Mazda3 Complaint Log

There has been no accident- the vehicle is my mother in laws vehicle- my concern is while at work she has at times loaded our daughter into the vehicle- I inspected the vehicle one day while as an employee of Les Schwab- the driver cvc axle vibrates so bad from the boot being torn and having no lubrication- these axles power the vehicle forward and if not maintained can snap and cause damage- the wipers no longer work correctly- the tires are 2017 and old and weather cracked- potential to separate while driving or blow out on the heated pavement. upon inspection also found that the front shocks are blown out and bouncing in the mounts under the hood- causing the tires to not have the correct contact patch on the road thus decreasing traction and control- on top of all this the vehicle hasn't been registered since 2020 and has no insurance on the vehicle- again there has been no accident...yet- this is my concern- that if this vehicle continues to remain operational and on the road it not only puts the driver and occupants at risk but also other drivers- kids- teens and anyone that may be on the other end o the crash when the vehicle does snap the cvc axle or blow i out a tire

The contact owns a 2004 Mazda 3 equipped with Hankook Tires, Tire Line: Ventus S1 Noble2, Tire Size: 205/50/R17, DOT Number: N/A. The contact stated that while driving at approximately 45 MPH, a loud explosion was heard. The contact's wife alerted him that the rear driver's side tire had blown out. The contact's vehicle was then rear-ended by another vehicle, causing his vehicle to turn 360 degrees. The air bags did not deploy. The contact was not injured, but his wife suffered from neck pain. Medical attention was not received. A police report was filed. The vehicle was towed to the contact's workplace and was not deemed totaled by the insurance company. A body shop repaired the vehicle. The tire manufacturer was made aware of the failure and informed the contact to send in the faulty tire. The tire failure mileage was unknown. The vehicle failure mileage was 150,000.

This model car has a fuse box under the glove box known as a "passenger junction box" that has a faulty or defective relay soldered onto the circuit board. The relay is tied to lighting that includes the interior lights, exterior front parking lights, exterior rear tail lights, and the license plate light and is controlled by the left turn signal stalk (rotating switch). Based on my experience and many others (on the Mazda 3 forums), this relay has the tendency to fail and cause all of these lights tied to this relay to intermittently or permanently be disabled. There is no warning for this; the driver will only notice when driving at night that the interior illumination of the dashboard goes completely dark, which could cause disorientation and confusion as to whether or not the car is operable. Subsequently, the problem can be recreated by attempting to turn the lights on and off and there will be no response (and no clicking noise...it is audible when working and it switches on); the relay fails to operate and all the lights will not turn on. Driving at night without tail lights is extremely dangerous and I am surprised this has not caused serious injury from rear-ending incidents in nighttime or inclement weather situations. The serial/model number of junction box on my vehicle is BN8B-66730-C and many others on the forums have had the same issue with the same model, as well as other variations of the box. Some on the forums went as far as replacing the culprit relay (see attachment); however, at the risk of destroying the entire junction box and rendering the vehicle unusable. I finally ended up purchasing a replacement unit on eBay which corrected the issue so far and has made the lights reliable again.

THE CAR RAN GREAT FOR THE END OF 2019. I BOUGHT IT USED AT 145,000 MILES. THEN THE AUTOMATIC TRANSMISSION STARTED TO SLIP. NOW ITS STUCK IN LIMP MODE.

THE TAIL LIGHTS GO OUT INTERMITTENTLY DUE TO A DEFECTIVE PASSENGER JUNCTION BOX (FUSE BOX). TAPPING THE BOX WITH A SCREWDRIVER HANDLE WILL BRING THE TAIL LIGHTS BACK ON FOR A WHILE. THIS HAS BEEN A MAZDA 3 ISSUE OVER THE YEARS. THE SHOULD BE A RECALL ON THIS.

TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT PASSENGER SEAT MAIN MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. AN UNKNOWN DEALER WAS CONTACTED, BUT COULD NOT ASSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,680.

DRIVER SIDE FRONT SEAT WOBBLES-ENTIRE ASSEMBLY NEEDS TO BE REPLACED-DANGEROUS IF WELD HAD BROKEN WHILE ON FREEWAY-WHY ISN'T THIS A SAFETY RECALL-NUMEROUS OTHER COMPLAINTS FOR VARIOUS MODEL YEARS EVEN WHEN NEW-ARE SEATS REMOVED BY L0-JACK TECHS WHEN INSTALLING LO-JACK DEVICES?

NO PROBLEMS FROM CAR NO WARNING LIGHT. BIG BANG THEN ENGINE MAKING VERY LOUD KNOCKING NOISE...ON INTERSTATE... STILL CRANKS BUT NEEDS MOTOR...READ THAT LOT OF PEOPLE HAVE HAD SAME PROBLEMS

The contact owns a 2004 Mazda Mazda3. The contact stated that while starting the vehicle and driving at an undisclosed speed, the air bag warning light was illuminated. The dealer was made aware of the failure but informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall. The contact related the failure to NHTSA Campaign Number: 04V468000 (Air Bags). The failure mileage was approximately 165,000.

POWER STEERING GOES OUT INTERMITTENTLY. OFTEN STARTS WHEN TURNING THE WHEEL TO THE LEFT. THE POWER STEERING FAILURE LIGHT , OR SOMETIMES ALL WARNING LIGHTS, COME ON. THE STEERING WHEEL BECOMES EXTREMELY DIFFICULT TO TURN IN EITHER DIRECTION AND THE CAR IS DIFFICULT AND HAZARDOUS TO NAVIGATE TO A STOP. ELECTRONICS FLASH ON AND OFF (HEADLIGHTS, RADIO, ETC.). CAR SOMETIMES DIES. IF THE STEERING WHEEL IS NOT PERFECTLY STRAIGHT WHEN THE CAR DIES, IT IS LOCKED AND THE CAR CANNOT BE RESTARTED UNTIL SOMEONE CAN WRENCH THE STEERING WHEEL STRAIGHT AGAIN. THIS HAS HAPPENED OFF AND ON FOR A YEAR. SINCE IT IS INTERMITTENT, MECHANICS ARE UNABLE TO FIND THE PROBLEM.

TL* THE CONTACT OWNS A 2004 MAZDA 3. WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL LIGHT ILLUMINATED. THE STEERING WHEEL LOCKED AND WAS HARD TO TURN. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON A FEW TIMES AND SHIFTED THE STEERING WHEEL TO THE LEFT AND RIGHT, BUT THE WHEEL WOULD NOT UNLOCK. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,173.

WAS IN ACCIDENT HIT DITCH AND TREE HEAD ON AND AIRBAGS DID NOT DEPLOY, CAUSING INJURY TO FACE FROM HITTING STEERING WHEEL. WAS ON CITY STREET AND IN MOTION.

ENGINE LIGHT CAME ON WITH EVAP LEAK CODE. SMALL LEAK AT FIRST THEN INCLUDED LARGE LEAK CODE LATER. ALSO BEGAN TO NOTICE STRONG GAS SMELL OUTSIDE VEHICLE AFTER FUELING. TURNED OUT THE FUEL PUMP RING THAT HOLDS DOWN AND SEALS FUEL PUMP TO FUEL TANK HAD CRACKED. OVER TIME THE SPLIT BECAME LARGER. WHEN TANK WAS FILLED, RAW FUEL WOULD LEAK OUT AROUND PUMP ON TOP OF TANK. WHICH ALSO HAPPENS TO BE RIGHT UNDER THE REAR SEAT WHERE ME KIDS SIT. REPLACEMENT WAS EXPENSIVE BECAUSE THE RING COULD NOT BE REMOVED FROM UNDER THE SEAT. IT REQUIRED DROPPING THE TANK TO REPAIR. MECHANIC FELT IT WAS A STRESS CRACK. THE FUEL PUMP HAD NEVER BEEN WORKED ON BEFORE. THE ORIGINAL RING WAS INSTALLED AT THE FACTORY.

THERE WAS A STRONG FUEL SMELL THAT WAS OCCURRING ON BOTH THE INSIDE AND OUTSIDE OF MY CAR EVERY TIME I FILLED MY CAR UP. I TOOK TO MY THE MECHANIC AND IT WAS FOUND MY FUEL TANK WAS LEAKING IN 2 SPOTS. ONE WAS PART OF THE GAS TANK THAT VENTS THE FUMES - THAT SEAL WAS LEAKING AND THE OTHER WAS PART OF THE LOCKING RING THAT IS ON THE GAS TANK ITSELF WAS CRACKED.

BOUGHT 4 NEW TIRES ON 3/23/12. THREE OF THESE TIRES DEVELOPED BUBBLES AND HAD TO BE REPLACED.

I STARTED MY CAR AND MY POWER STEERING LIGHT CAME ON MY DASH WHEN I WAS LEAVING WORK ON 4/2/2015. I HAD NO POWER STEERING AT ALL. I'VE HAD A REPAIR SHOP TELL ME IT IS MY POWER STEERING PUMP THAT HAS FAILED. THEY STATED THAT THEY CANNOT ORDER THE PART NEEDED TO REPAIR MY VEHICLE, WHICH IS THE ELECTRIC POWER STEERING PUMP. I CALLED A NEARBY DEALERSHIP AND THEY SAID I HAVE TO GO THROUGH A ZIP DEALERSHIP BECAUSE IT IS A VIN SPECIFIC PART. THEY QUOTED ME $900 FOR A POWER STEERING PUMP AND $315 TO INSTALL IT! I RESEARCHED THE ISSUE ONLINE AND HAVE NOTICED THERE IS A RECALL ON THE SAME YEAR AND MODEL VEHICLE AS MINE. BUT AFTER CHECKING WITH YOUR WEBSITE, IT STATES THERE ISN'T A RECALL ON MY VEHICLE. I WOULD LIKE TO KNOW WHY MY VEHICLE HAS BEEN EXCLUDED FROM THIS RECALL BUT IS EXPERIENCING THE SAME ISSUES AS STATED IN THE RECALL INFORMATION. THANK YOU FOR YOUR TIME AND ASSISTANCE. *TR

TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE CORROSION AND THE DOOR FRAME WAS STARTING TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT PORTIONS OF THE VEHICLE COULD BE REPAIRED; HOWEVER, THE CORROSION WAS IN AREAS THAT WERE BEYOND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V468000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

CLUTCH SLIPPING, HIGH RPMS, NOT RED LINING. TRANSMISSION EXPLODED CAUSING ENGINE FIRE AND BURNING MOTOR AND ELECTRICAL COMPONENTS.

SEAT BELT LIGHT COMES ON AND STAY FOR FEW DAYS THEN GO OFF AND BACK AGAIN

I HAD MY MECHANIC WORKING ON REPLACING A BURNT OUT LICENSE PLATE LIGHT WHEN HE DISCOVERED THAT THE TAIL LIGHTS WERE NOT WORKING. HE TURNED THE LIGHTS OFF AND BACK ON, AND THE TAIL LIGHTS STARTED WORKING AGAIN, TURNED THE LIGHTS BACK OFF AND ON AGAIN, AND THE TAIL LIGHTS WERE BACK TO NOT WORKING AGAIN. HE IDENTIFIED THE FUSE BOX TO BE THE CAUSE OF THIS ISSUE, AS WHEN THE TAIL LIGHTS WERE OUT, HE WOULD HIT THE FUSE BOX WHICH WOULD THEN CAUSE THE LIGHTS TO COME BACK ON, AND HE DEMONSTRATED THIS FOR ME. THIS IS A SERIOUS SAFETY CONCERN TO ME AND AFTER ONLY A FEW MINUTES OF INTERNET RESEARCH I FOUND OTHERS WERE HAVING THE EXACT SAME ISSUE. I FEEL VERY FORTUNATE THAT I'VE NOT BEEN HIT FROM BEHIND. I'VE CALLED MAZDA AND THEY SAID THEY WERE NOT AWARE OF A KNOWN ISSUE AND THERE WERE NO RECALLS ON THE PART, BUT I'VE ALSO LEARNED THAT THIS PART HAS BEEN REISSUED 6 TIMES. THIS MAKES ME THINK IT HAS TO BE A KNOWN ISSUE, OTHERWISE WHY KEEP MODIFYING THE PART? *TR

MY 2 BOYS AND A FRIEND WERE IN THE CAR AND HAD RAN INTO THE BACK OF A TRUCK HARD ENOUGH TO MOVE THE MOTOR BACK, THE AIR BAGS DID NOT GO OFF, MY CHILDREN COULD HAVE BEEN SERIOUSLY INJURED. THANK GOD THEY HAD THEIR SEAT BELTS ON. WHY DO I PAY MONEY FOR SAFETY FEATURES IF THEY ARE NOT GOING TO WORK? I AM REALLY UPSET AND DISAPPOINTED AND WILL MAKE SURE ALL OF MY FRIENDS AND FAMILY KNOW THAT OUR CAR WAS DEFECTIVE. I WILL LOOK INTO AN ATTORNEY TO MAKE SURE YOU FIX THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME INOPERABLE. ALSO, THE CONTACT MENTIONED THAT THE EXTERIOR AND INTERIOR LIGHTS FAILED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

WHEN STARTING THE CAR THE AIR BAG LIGHT COMES ON AND STAYS ON FOR WEEKS THEN IT WILL TURN OFF. THIS HAS BEEN HAPPENING FOR OVER A YEAR.

THE ENGINE MOUNTS HAVE FAILED AND THE CAR'S ENGINE LURCHES APPROXIMATELY 2 INCHES IN EACH DIRECTION AND VIBRATES WHILE IDLING. THE INDEPENDENT MECHANIC INDICATES THEY HAVE SEEN A NUMBER OF THESE ENGINE MOUNTS FAIL ON THIS MODEL DUE TO POOR/FLIMSY DESIGN. *TR

WHILE DRIVING ON THE FREEWAY AT 65 MPH AT NIGHT, MY LOWER DASH (RADIO, HVAC) AND STEERING WHEEL CONTROLS LIGHTING WENT OUT FOR ABOUT TEN MINUTES, AND THEN CAME BACK ON. THIS STARTED HAPPENING INTERMITTENTLY FROM THAT POINT ON, SHUTTING OFF AND COMING BACK ON RANDOMLY, WITH THE LIGHTS BEING OUT CONTINUOUSLY ONCE FOR ABOUT 30 MINUTES WHILE DRIVING AT NIGHT IN TRAFFIC. THE SAFETY CONCERN IS THAT I JUST DISCOVERED THE TAIL LIGHTS WERE ALSO GOING OUT AT THE SAME TIME. INDICATIONS ARE THAT THE CAUSE IS A DEFECTIVE PASSENGER JUNCTION BOX (PJB). THIS IS A SERIOUS SAFETY ISSUE AND AN UNACCEPTABLE ENGINEERING FLAW WHICH APPEARS TO AFFECT OTHER DRIVERS OF THIS VEHICLE MODEL AS WELL. DUE TO PROHIBITIVE COST OF JSB REPLACEMENT AND UNCERTAINTY OF THE INTEGRITY OF THAT PART ITSELF, IT MAY BE NECESSARY TO INSTALL A FAILSAFE INDEPENDENT WIRING SOLUTION FOR THE BRAKE LIGHTS TO ENSURE REQUIRED RELIABILITY

I HAVE CAR JM1BK12F64[XXXX], MAZDA 3, 2004, 2.0L. I HAVE A PROBLEM WITH THE AXLE SHAFT OF MY CAR. I NEED TO KNOW IF THIS CAR HAS RECALLS OR WARRANTY. I BOUGHT THE CAR USED IN DEALER OF PUERTO RICO BUT IT WAS AN IMPORT FROM THE USA. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I WAS INVOLVED IN A CRASH ON I-35W JUST OUTSIDE OF DOWNTOWN MINNEAPOLIS. I WAS TRAVELING AT 60MPH AND HIT A CONCRETE WALL. MY AIRBAGS DID NOT DEPLOY. UNACCEPTABLE!!! *TR

THE LOCK RELEASE LEVER ON THE STEERING WHEEL GET LOOSE WHILE THE VEHICLE IS IN MOTION AND DOES NOT LOCKED IN PLACE. THIS CAN CAUSE AN ACCIDENT AND SERIOUS INJURIES. THERE SHOULD BE A RECALL TO GET THIS REPAIR.

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3 . THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE DRIVER'S SIDE CONSOLE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V468000 (AIR BAGS: FRONTAL: SENSOR/CONTROL MODULE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 110,000.

I WAS FILLING MY GAS TANK UP AND NOTICED FUEL LEAKING ON THE GROUND.DROPED CAR OFF FOR REPAIR. GARAGE DID SMOKE TEST OF FUEL TANK AND IDENTIFIED THAT THE PLASTIC RING ON FUEL PUMP WAS CRACKED, THE GARAGE HAD TO REMOVE THE FUEL TANK AND REPLACE THE PLASTIC RING AND SEAL. MY WARRANTY DID NOT COVER THIS REPAIR AND IT COST ME OUT OF POCKET $399.96 MY REQUEST IS THIS COVERED UNDER ANY REGULATIONS OR RECALLS ON THIS MAKE AND MODEL OF VEHICLE? *TR

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING FAILED TO OPERATE NORMALLY AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE MECHANIC STATED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 114,000. THE VIN WAS NOT AVAILABLE.

WHEN DRIVING OVER BUMPY ROADS, MY POWER STEERING LIGHT COMES ON, SOMETIMES LOSING POWER STEERING MAKING IT VERY DIFFICULT TO DRIVE THE CAR. IT HAS NEVER HAPPENED ON THE HIGHWAY, BUT THERE'S NO RHYME OR REASON FOR WHEN IT WILL COME BACK ON OR WHY THE STEERING GOES OUT OR NOT. TWO MECHANICS I'VE TAKEN IT TO CAN'T SEEM TO FIND ANYTHING WRONG AND ONE THINKS IT COULD BE THE POWER STEERING PUMP. *TR

THE INTERIOR LIGHTS AROUND THE AIR CONDITIONER CONTROLS WERE NOT ON, THOUGHT IT WAS A SHORT OR A BLOWN FUSE, PLANNED ON CHECKING ONCE RETURNING HOME THAT NIGHT. HOWEVER WAS PULLED OVER BY LOCAL POLICE DEPT AND TOLD I DIDN'T HAVE ANY TAIL LIGHTS. CHECKED ALL FUSES RIGHT THEN, ALL FUSES WERE GOOD. DROVE HOME WITH EMERGENCY FLASHERS ON TO AVOID BEING HIT. TOOK THE CAR TO THE MECHANIC THE NEXT DAY THEY CHECKED ALL FUSES AND FOUND THE FUSES WERE GOOD BUT FOUND THE REAR TAIL LIGHTS HAD BLOWN. TWO WEEKS LATER THE SAME THING, NO LIGHTS AROUND AIR CONDITIONER CONTROLS SO I IMMEDIATELY GOT OUT OF THE CAR AND DISCOVERED NO TAIL LIGHTS. TOOK CAR BACK TO SAME MECHANIC AND UPON RESEARCHING HE FOUND THAT THIS MODEL HAS PROBLEMS WITH THE PASSENGER JUNCTION BOX (FUSE BOX) HAVING SHORTS. WILL HAVE TO REPLACE THE ENTIRE JUNCTION BOX AND THE REPLACEMENT BOX IS APPROXIMATELY $800. WITH THIS BEING A KNOWN PROBLEM THERE SHOULD BE A RECALL TO REPLACE ALL PASSENGER JUNCTION BOXES! I COULD HAVE HAD AN ACCIDENT FROM NOT HAVING TAIL LIGHTS AND NOT KNOWING IT!!!!! *JS

ISSUE: ALL ELECTRICAL COMPONENTS ALONG WITH POWER STEERING SHUTTING OFF INTERMITTENTLY WHILE DRIVING. THE FIRST INSTANCE OF THIS ISSUE HAPPENED WHILE TURNING INTO A PARKING LOT. AS I WAS MAKING A RIGHT TURN ALL THE ELECTRICAL COMPONENTS IN MY VEHICLE SHUT OFF, ALONG WITH THE POWER STEERING. ABOUT A SECOND LATER EVERYTHING CAME BACK ON AND OPERATING NORMALLY. THIS SAME ISSUE WOULD HAPPEN INTERMITTENTLY, USUALLY WHEN MAKING RIGHT TURNS. THERE WAS NEVER ENOUGH OF A PATTERN TO SAY THAT IT WAS HAPPENING EVERY WEEK OR MONTH, ETC. I TOOK VEHICLE TO MAZDA DEALERSHIP AND THEY DIAGNOSED IT AS BATTERY CABLES NEEDING TO BE REPLACED, AFTER IT STARTED HAPPENING MORE FREQUENTLY A FEW MONTHS LATER. THE ISSUE STOPPED FOR A COUPLE MONTHS, BUT THEN BEGAN AGAIN. THIS TIME IT STARTED HAPPENING JUST BY TAPPING ON THE BRAKES AS WELL AS MAKING A TURN. ALL THE ELECTRICAL ON THE VEHICLE WOULD SHUT OFF, ALONG WITH THE POWER STEERING AGAIN; AND THEN IT WOULD COME BACK AFTER A SECOND BEING OFF. THIS TIME IT BEGAN HAPPENING MUCH MORE FREQUENTLY, AT LEAST A COUPLE OF TIMES A WEEK; MOST RECENTLY IT HAPPENED AGAIN AND THIS TIME MY POWER STEERING WAS OFF FOR MY ENTIRE 30 MILE DRIVE HOME FROM WORK. I TOOK IT AGAIN TO A DIFFERENT MAZDA DEALERSHIP TO HAVE IT DIAGNOSED, AND THIS TIME I WAS TOLD THEY NEEDED TO CHANGE THE BATTERY, ALTERNATOR AND POWER STEERING PUMP FOR STARTERS; BUT WAS NOT GUARANTEED THAT WOULD RESOLVE THE ISSUE AS THE TECHS HAD NEVER SEEN THIS ISSUE BEFORE AT THEIR SITE; THEY SAY THEY CALLED THEIR CORPORATE TECH LINE AND WERE ADVISED TO REPLACE THOSE ITEMS FIRST. I EVEN SHOWED THEM A VIDEO I HAD TAKEN OF THIS HAPPENING IN MY CAR ONE NIGHT AS I DROVE AROUND MY BLOCK IN ORDER TO DOCUMENT THE ISSUE. THERE IS NO PATTERN WITH REGARDS TO SPEED OF VEHICLE, OR WHETHER THE ENGINE IS COLD OR HAS BEEN RUNNING FOR A WHILE, AS THE ISSUE CAN HAPPEN REGARDLESS OF ANY OF THESE CONDITIONS. *TR

2004 MAZDA 3. PURCHASED CAR USED IN MARCH 2007. PER OWNER SERVICE RECORDS, MOTOR MOUNT #3 FAILED AND IN 11/2006, PER SERVICE BULLETIN, AND WARRANTY, LOCAL DEALER PERFORMED PARTIAL ENGINE REPLACEMENT, INCLUDING RUBBER ON MOUNT #3. NO PROBLEMS WITH CAR LEADING UP TO INCIDENT, REGULAR MAINTENANCE PERFORMED DURING OWNERSHIP 2007 - CURRENT. CAR USED PRIMARILY TO AND FROM WORK, APPROX. 12K PER YEAR DRIVEN. ON 8/29, CAR JUST STOPPED, MOTOR AND TRANSMISSION FELL OUT OF CASING, CAR CRASHED ON HWY 9. TOWED TO MAZDA DEALERSHIP. INITIAL ESTIMATE OF REPAIR $990 APPROX. ESTIMATE REVISED TO $3500 APPROX. TRANSMISSION BRACKET SHEARED/BROKEN AT METAL. MOTOR MOUNT #4 & TRANSMISSION MOUNT SCREW COMPLETELY DISLODGED. RECOMMENDED REPAIR INCLUDES COMPLETELY NEW TRANSMISSION CASE AND MOUNTS. NOT SURE IF ANY DAMAGE DONE TO TRANSMISSION ITSELF. FAILURE REPORTED TO DSM AND MAZDA CORPORATE. DUE TO CAR OUT OF WARRANTY AND MILEAGE ON CAR $100K, DENIED ANY RECOURSE FROM MAZDA FOR STRUCTURAL FAILURE. *TR

FRONT WHEEL BEARING FAILS PREMATURELY. MY RIGHT FRONT WHEEL BEARING FAILED AT 58K MILES AND NEEDED TO BE REPLACED. MY LEFT FRONT WHEEL BEARING IS FAILING AT 68K MILES AND NEEDS REPLACING. MY MECHANIC STATED THAT THESE PARTS SHOULD LAST MUCH LONGER, AND THAT CONTINUED DRIVING WITH A BAD BEARING COULD LEAD TO WHEEL LOCKUP AND AN ACCIDENT. MANY OTHERS ARE COMPLAINING OF SIMILAR FAILURE ON INTERNET FORUMS. MAZDA WON'T REPAIR THIS FREE OF CHARGE SINCE VEHICLE IS OUT OF WARRANTY. *TR

1) DRIVING AT 60 MPH ON HIGHWAY, AT 4TH GEAR. 2) TRANSMISSION FAILED TO PUT POWER INTO THE WHEELS, CAUSING THE CAR TO DECELERATE RAPIDLY EVEN THOUGH RPM RISES WHEN THROTTLE IS PRESSED. ONLY 1ST AND 2ND GEARS ARE ABLE TO TRANSFER POWER FROM ENGINE TO WHEELS. 3) DEALER REFUSE TO REPLACE TRANSMISSION, EVEN THOUGH MALFUNCTIONING OF THIS PARTICULAR PART ARE APPARENT TO MANY OF THE OWNERS OF THIS VEHICLE. *TR

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3. THE CONTACT NOTICED THAT THERE WAS AN OIL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THE VEHICLE WITH AN OIL FILTER HOUSING CRACK. THE DEALER ALSO OFFERED TO ASSIST WITH THE REPAIR EXPENSES. THE ENGINE WAS REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 51,000.

TL*THE CONTACT OWNS A 2004 MAZDA3. THE CONTACT STATED THAT WHILE DRIVING, THE POWER STEERING FAILED AND THE POWER STEERING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE STEERING PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 82,000.

2004 MAZDA 3 AUTOMATIC TRANSMISSION FAILURES. 1ST OFFENSE, IT REQUIRED A PCM VALVE/SOLENOID REPLACED., 2ND OFFENSE: TRANSMISSION LOST 4TH GEAR AND WONT SHIFT INTO 4TH GEAR. CAR IS IN A SHOP FOR DIAGNOSIS. ONLY GOES UP TO 35 MPH IF SHIFT MANUALLY AND IN 3RD GEAR, OTHERWISE IT REVS, JERKS, STALLS, ETC . *TR

TL* THE CONTACT OWNS A 2004 MAZDA MAZDA3. WHILE DRIVING APPROXIMATELY 45-50 MPH, THE CONTACT NOTICED THAT BOTH AIR BAG WARNING LIGHTS WERE ILLUMINATED ON THE DASHBOARD AND THE SHIFTING CONSOLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE AIR BAG SENSOR NEEDED TO BE REPLACED AT A COST OF APPROXIMATELY $778.00. THE CONTACT REFERENCED A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V468000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE) AND STATED THAT THE RECALL REPAIR WAS PERFORMED ON THE VEHICLE JANUARY 7, 2007. THE DEALER REPLACED A SUPPLEMENTAL RESTRAINT SYSTEM UNIT, THE PASSENGER SEAT FRAME AND INSTALLED AN AIR BAG SENSOR. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 106,850. UPDATED 05/04/11 *BF UPDATED 2/1/12 *CN

I BOUGHT A CAR RECENTLY, AND IT HAD SOME RUST ON BOTH REAR WHEEL WELLS IN THE SAME EXACT SPOTS. I HAVE A 2004 MAZDA 3I AND I TOOK IT TO ABOUT 4 BODY SHOPS TO HAVE IT WORKED ON. I GOT PRICES RANGING FROM 1000.00 DOLLARS TO 2500.00 DOLLARS TO FIX THE RUST. ALL OF THESE BODY SHOPS SAID THEY HAVE HAD AT LEAST ONE OTHER PERSON WITH THE SAME CAR AND THE SAME COMPLAINT AS I DID. MAZDA NEEDS TO FIGURE OUT WHAT THE PROBLEM IS. I CAN NOT AFFORD TO PAY 1000 DOLLARS TO GET MY CAR FIXED. MAZDA NEEDS TO TAKE RESPONSIBILITY AND FIX IT. *TR

POWER STEERING FAILURE, ENGINE MOUNT FAILURE. *TR

POWER STEERING FAILS WHILE DRIVING. MAKES IT VERY DIFFICULT FOR OUR 16 YEAR OLD DAUGHTER TO STEER THE VEHICLE. *TR

I OWN A 2004 MAZDA 3 HATCHBACK THAT I PURCHASED NEW. THE CAR HAS 74,000 MILES ON IT AND HAS BEEN MAINTAINED FAITHFULLY BY MAZDA TECHNICIANS. DRIVING HOME FROM WORK, THE CAR CAUGHT FIRE. TO REITERATE, THE CAR CAUGHT FIRE. HAD MY WIFE NOT NOTICED, AND HAD WE PARKED THE CAR IN THE GARAGE, IT WOULD HAVE BURNED DOWN THE HOUSE WITH US IN IT. WE MANAGED TO PUT THE CAR OUT AND TOOK IT TO THE MAZDA DEALERSHIP. THE TECHNICIAN TOLD US THE AIR CONDITIONING COMPRESSOR FROZE AND THE BELT CAUGHT FIRE FROM THE FRICTION; THIS THEN IGNITED PLASTIC SPLASH GUARDS UNDER THE VEHICLE. ALL TOTAL - $1500 IN DAMAGE. THE TECHNICIAN STATED THE COMPRESSOR SHOULD NOT HAVE CAUSED A FIRE, AND IN FACT THIS WAS THE FIRST TIME HE HAD SEEN ANYTHING LIKE IT. I CONTACTED MAZDA AND ASKED THEM TO RECOMPENSE THE DAMAGE FROM THE FAILED COMPRESSOR AND THE FIRE, AND THEY REFUSE TO ASSIST ME (OR EVEN ACKNOWLEDGE THAT ONE OF THEIR PRODUCTS' SPONTANEOUS COMBUSTION IS A PROBLEM), OR COMPENSATE ME. I AM LESS CONCERNED ABOUT COMPENSATION THAN I AM CONCERNED THAT THERE ARE THOUSANDS OF THESE CARS ON THE ROADS, BEING DRIVEN BY FAMILIES, WAITING TO CATCH FIRE AND BURN. THIS NEEDS TO BE ADDRESSED AND ADDRESSED QUICKLY BEFORE SOMEONE LOSES THEIR LIFE. THERE HAVE BEEN NO RECALLS OR EVEN WARNINGS FROM MAZDA THAT THIS IS A POTENTIAL PROBLEM. PLEASE, I AM ASKING THAT THE NHTSA ASSIST IN DOING SOMETHING BEFORE THIS POTENTIALLY FATAL MANUFACTURER DEFECT COSTS SOMEONE THEIR LIFE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2004 MAZDA 3 WITH 2.3 LITER ENGINE AND MANUAL TRANSMISSION MAZDA HAS A POOR DESIGN ENGINE OIL FILTER HOUSING. THE END IS MADE OF PLASTIC. THESE END CAPS TEND TO FATIGUE AND CRACK WITH AGE. THIS PART IS EXPOSED TO HIGH HEAT, VIBRATIONS, AND TORQUE. WHEN IT CRACKS AND LEAKS IT LEADS TO CATASTROPHIC ENGINE FAILURE. *TR

I LOVE MY 04 MAZDA 3, HOWEVER IN THE LAST FEW MONTHS WHEN MAKING LEFT TURNS I LOSE THE POWER STEERING. THE WHEEL ALMOST COMPLETELY LOCKS. IN 2 INSTANCES THE GAUGES HAVE GONE UP AND DOWN. I TURN THE CAR OFF THEN BACK ON AND IT SEEMS TO HELP. I'M AFRAID TO DRIVE IT NOW, HELP! *TR

2004 MAZDA 3 HAS FREQUENT LOSS OF POWER STEERING. WHILE IN MOTION POWER STEERING SUDDENLY STOPS WORKING. TURNING OFF CAR FOR SEVERAL MINUTES THEN RESTARTING SEEMS TO CLEAR PROBLEM. INCIDENT OCCURS EVERY 3 - 4 DAYS. *TR

WHEN DRIVING ON THE HIGHWAY, THE TRANSMISSION OF MY 2004 MAZDA 3 WITH ONLY 84,000KM DIED AS IT LOST THE ABILITY TO REACH 3RD AND 4TH GEAR. THIS INCIDENT NEARLY COST ME MY LIFE YET MAZDA CANADA WOULD DO NOTHING ABOUT IT. WHAT KIND OF COMPANY CAN NOT STAND BEHIND THEIR PRODUCT AFTER SUCH A NEAR-FATAL INCIDENT. SUFFICE TO SAY THAT MAZDA WILL NEVER GET MY BUSINESS AGAIN. $3,200 LATER, I'M STILL ALIVE NO THANKS TO MAZDA. *TR