2002 Mercedes-Benz C-Class Complaint Log

The rear subframe rusted out and failed at the driver side trailing arm mount. It is available for inspection. My pregnant wife was driving it when it failed, luckily it failed an 1/8th mile from our house on a 25mph back road. The problem with these subframes has been well documented in later models and the subject of a class action lawsuit. Nobody has inspected it. There were no symptoms prior to the failure.

Recall ID: 24V874 on Sliding Roof Bonding was issued. Mercedes-Benz of Nashville was not able to open the Roof and asked for $219.88 to determine cause of sunroof being inoperative. Recall letter stated that: "vehicle repair will be provided at no cost to you" "If dealer for any reason is unable to remedy the situation without charge.. you may submit a complaint to the NHTSA.." Hence I am submitting this complaint that my sliding roof was not checked nor repaired.

Suddenly started driving badly on the highway. It would swerve side to side after hitting a bump. The rear sits about two inches lower than the front. My trusty independent mechanic said I should check the rear subframe and refrain from driving the car. KBB lists a safety recall for this issue, stating that the rear subframe wasn't sufficiently rustproofed. Mercedes and NHTSA do not list this recall, and my local dealer says the repair will cost around $3,000. May have to scrap the car with 81,000 miles on it.

While changing one of the lights in the headlight housing, I found the wiring's insulation rotting off all the wires, exposing the bare copper presenting a fire hazard.

Vehicle constantly smells like gas inside the cabin, it makes me dizzy and affects my head overall health inhaling vapors. At first I thought I could handle it, but it just gives me nonstop headaches and I'm afraid one spark will ignite/ explode my entire vehicle. This happens everytime I fill the gas tank. I heard their was a warranty extension but don't believe me vehicle was included which is unfortunate. Their is a check engine light informing of a EVAP Leak.

There is an old recall campaign for the Camshaft Seal, # 2009100001. This car is among those affected by this problem and should be covered for issues and repairs.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C240. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTS FAILED TO ILLUMINATE PROPERLY. THE CONTACT STATED THAT THE ODOMETER WAS INOPERABLE. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF TACOMA (1701-C ALEXANDER AVE E, FIFE, WA 98424) WHERE IT WAS DIAGNOSED HOWEVER, THE CONTACT WAS STILL AWAITING INFORMATION ON THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE APPROXIMATELY 90,000.*DT*JB*DT THE CONSUMER PROVIDED A PHOTO. *TR

RECEIVED NHTSA RECALL #19V918, MB CAMPAIGN #2020040011, AND BROUGHT VEHICLE TO MERCEDES DEALER, ALFANO, IN SAN LUIS OBISPO, CA ON 8/25/2020. WAS TOLD BY DEALER'S SERVICE MANAGER THAT VEHICLE PRODUCTION DATE WAS NOT AVAILABLE AND THAT THE VEHICLE DID NOT MATCH THE MODELS INCLUDED IN THE RECALL, SUCH PRODUCTION DATES WERE FROM 01/16/2006 TO 07/09/2006 INCLUSIVE. NO INSPECTION OF THE SUNROOF BONDING OR REPAIRS WERE ATTEMPTED ON THE VEHICLE. IMAGE OF SERVICE INVOICE ATTACHED TO THIS DOCUMENT.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C240. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V918000 (VISIBILITY). FLAGSHIP MOTORCARS OF LYNNFIELD (385 BROADWAY RTE. 1 NORTH, LYNNFIELD, MA 01940) WAS CONTACTED AND AN APPOINTMENT WAS SCHEDULED TO HAVE THE RECALL REPAIR PERFORMED. UPON LEAVING THE DEALER AFTER THE RECALL REPAIR WAS PERFORMED, THE CONTACT ATTEMPTED TO USE THE SUN ROOF HOWEVER, THE SUNROOF WOULD NOT CLOSE. THE CONTACT DROVE THE VEHICLE BACK TO THE DEALER AND EXPLAINED THE FAILURE. THE CONTACT WAS INFORMED THAT HER SUN ROOF WOULD BE RESET. THE CONTACT WAS ALSO INFORMED THAT THERE WAS AN ISSUE WITH THE MOTOR AND THAT SHE WOULD HAVE TO PAY OUT OF POCKET FOR A DIAGNOSTIC TEST TO DETERMINE THE FAILURE. THE CONTACT REFUSED THE SERVICED AND ASKED THE MECHANIC TO SEAL THE SUN ROOF AND RETURN THE SUN ROOF TO ITS ORIGINAL FORM. AFTER LEAVING THE DEALER FOR THE SECOND TIME, THE CONTACT STATED THAT THE SUN ROOF SHOOK UPON CLOSING HER FRONT DRIVER'S SIDE DOOR. THE CONTACT THEN CALLED THE DEALER BACK THE NEXT DAY AND WAS INFORMED THAT THE SUN ROOF SHAKING WAS NOT NORMAL. SHE WAS ADVISED TO TAKE THE VEHICLE BACK TO BE INSPECTED. THE CONTACT HAD YET TO TAKE THE VEHICLE TO THE DEALER. THE CONTACT ATTEMPTED TO NOTIFY THE MANUFACTURER OF THE FAILURE HOWEVER, SHE WAS UNABLE TO REACH A REPRESENTATIVE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C240. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 19V918000 (VISIBILITY). THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED MERCEDES-BENZ OF SEATTLE (2025 AIRPORT WAY S, SEATTLE, WA 98134 (206) 331-4312) WHERE IT WAS INFORMED THAT THE VEHICLE WAS FROM CANADA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DID NOT EXPERIENCE A FAILURE. THE MANUFACTURER WAS CONTACTED HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT THE BATTERY WAS DRAINED AFTER THE VEHICLE WAS PARKED AND TURNED OFF. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DRIVER'S SIDE SEAT MODULE WAS DEFECTIVE WHICH CAUSED THE BATTERY TO DRAIN. THE MODULE WAS UNPLUGGED TO PREVENT THE BATTERY FROM BEING DRAINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

Battery drains after being parked overnight, 58,000 miles, dealer maintained since new. Driven by a little old lady until I bought it. Took it to the dealer and they replaced one of the seat modules. Soon afterward, the problem recurred. Took it back to the dealer and they said it was a defective fuse box and replaced it for $650. Went to pick up the car and the battery was dead again. After some complaining, they refunded the bill. They looked at it again and said the problem was somewhere in the dashboard and it would cost $2300 just to take it apart and look for a bad module. They offered $2300 trade in toward a new or CPO car, and said my car would be sent to the crusher. I took the car back and installed a remote operated battery cutoff, and have been driving it ever since. Other than disturbing the engine computer, it's been running well for three years and 20,000 miles. Lovely car otherwise.

TAKATA RECALL ESL (ELECTRIC STEERING LOCK) COMPONENTS THE MOTOR FAILS TO UNLOCK THE STEERING THE FIRST TIME, BUT WORK IN FOLLOWING ATTEMPTS. SOME TIMES IT TAKES 1 TO 4 HOURS FOR ESL TO UNLOCK. THIS HAPPENS ONLY WHEN THE VEHICLE IS PARKED WEATHER OVERNIGHT OR JUST COMING OUT OF THE STORE SHOPPING.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C240. THE CONTACT STATED THAT UPON PURCHASE OF THE VEHICLE, THE SUN ROOF RATTLED WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT THEN RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER :19V918000 (VISIBILITY) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C230. WHILE REVERSING AT 5 MPH, THE STEERING COLUMN LOCK FAILED TO ENGAGE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 163,000. ..UPDATED 09/25/17 *BF .. .UPDATED 10/04/17 *BF THE CONSUMER STATED DUE TO THE STEERING LOCK FAILURE THE STEERING WHEEL MOVES FREELY WHILE DRIVING AND PARKED. *JS

BATTERY DRAINING

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C230. WHILE DRIVING BETWEEN 15-20 MPH, THE VEHICLE FAILED TO ACCELERATE. WHILE DEPRESSING THE ACCELERATOR PEDAL, THE ABS AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRE HARNESS MELTED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.

SEATS CONTROL MODULE

STRONG ORDER OF GAS COMING FROM BEHIND THE DRIVERS SEAT. PULLED BACK SEAT OFF AND THERE IS A POOL OF GAS UNDER THERE. APPEARS ONE OF THE PLASTIC OVERS HAS CRACKS IN IT.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C240. WHILE DRIVING VARIOUS SPEEDS, THE INSTRUMENT CLUSTER LIGHTS FAILED TO OPERATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNED A 2002 MERCEDES-BENZ C320. THE CONTACT CALLED ON BEHALF OF THE DRIVER. WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER LOST CONTROL OF THE VEHICLE. THE VEHICLE SPUN AROUND SEVERAL TIMES AND CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE CAUGHT ON FIRE. THE DRIVER WAS KILLED ON IMPACT. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY THE POLICE AND DEEMED DESTROYED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS UNKNOWN. *DT*JB

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C240. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT OUT OF FIRST GEAR AND WAS LEAKING TRANSMISSION FLUID. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS LEAKING FLUID IN SIX DIFFERENT PLACES AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

WAS DRIVING ON HIGHWAY WHEN ESP, BAS AND ABS LIGHTS SHOW UP, AND SPEEDOMETER DISPLAY STOPS WORKING - SPEED READING GOES TO ZERO, THOUGH THERE IS NO REDUCTION IN SPEED. GET TO DESTINATION. ON RETURN IT HAPPENS AGAIN. THIS TIME I GO TO REST AREA, STOP THE CAR, REMOVE THE KEY AND RESTART. THE CAR REFUSES TO MOVE OUT OF PARK. CALL ROADSIDE ASSISTANCE AND GET INSTRUCTION TO OVERRIDE PARK, DRIVE HOME WITH FLASHERS ON - VERY ROUGH RIDE QUALITY. TOW TO DEALER NEXT DAY, THEY ARE NOT SURE IF NEW PART WILL FIX IT, EVEN IF $1850 PART IS REPLACED. LOTS OF ELECTRICAL PROBLEMS OVER THE YEARS. TURN LIGHTS GO OUT ROUTINELY. CHANGED CD CHANGER. SEAT DRAINS BATTERY,HAD TO DISCONNECT IT. POOR ELECTRICAL SENSORS ALL AROUND. NOW IT ALSO HAS RUST DAMAGE, ALL OF A SUDDEN, AT THE BOTTOM OF DOORS.

TL*THE CONTACT OWNS A 2002 MERCEDES C320. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT MENTIONED THAT AFTER AN HOUR, THE VEHICLE WAS ABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 123,384.

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT THE ELECTRONIC STABILITY CONTROL LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND SMOKE STARTED TO EMIT FROM UNDER THE HOOD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT INFORMED OF THE ISSUE. THE FAILURE MILEAGE WAS 127,000.

THE SEAT CONTROL UNITS DO NOT SHUT OFF AND CONTINUALLY DRAIN THE BATTERY. THIS IS A WIDESPREAD PROBLEM FOR THIS MODEL CAR. *TR

SEAT CONTROL MODULE DRAINING THE BATTERY. CAR WILL NOT START IF NOT DRIVEN FOR 24 HOURS. 99% OF THE CARS WITH THE SEAT CONTROL MODULE PART NUMBER STARTING WITH "203" ARE BAD!! WHY WONT MERCEDES RECALL THEM AND REPLACE WITH NEW ONES FREE OF CHARGE. ITS OBVIOUS THAT ITS A DEFECTED PART AND IT WILL CAUSE OTHER THINGS TO GO BAD. WE SPEND ENOUGH HARD EARNED MONEY ON BUYING THE CAR TO HAVE TO PAY FOR THERE DEFECTIVE PARTS. THAT'S WHY THEY ARE CALLED THE STEALER NOT THE DEALER! *TR

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C240. THE CONTACT'S VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING), ALTHOUGH THE INSTRUMENT PANEL FAILURE WAS IDENTICAL. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

THIS IS A FOLLOW-UP TO COMPLAINT #10579528. SPOKE TO ROBIN, CUSTOMER SERVICE REPRESENTATIVE AT MERCEDES BENZ CORPORATE HEADQUARTERS IN THE UNITED STATES. THEY REFUSE TO ACKNOWLEDGE A DESIGN FLAW IN THE REAR SIGNAL ACTUATOR MODULE AS THE BASIS FOR THE FUEL DELIVERY FAILING WHILE DRIVING THE CAR. THE EXPLANATION THEY OFFERED IS THAT THE LIKELY CAUSE OF THE FAILURE IN FUEL DELIVERY TO THE ENGINE, WHILE DRIVING, IS THE FUEL PUMP, MERCEDES PART# 203 470 3794. HOWEVER, THEY FURTHER EXPLAINED THAT THE ONLY WAY TO REPLACE A FAULTY FUEL PUMP IS TO REPLACE THE ENTIRE FUEL TANK, FUEL DELIVERY UNIT, FUEL SENDING UNIT AND WIRING HARNESS ...THE ENTIRE FUEL STORAGE TANK AND FUEL DELIVERY SYSTEM! NO ONE I KNOW HAS EVER HEARD OF A SITUATION WHERE AN ENTIRE FUEL SYSTEM HAS TO BE REPLACED BECAUSE OF A FAILED IN-TANK FUEL PUMP. THIS POINTS TO YET ANOTHER DESIGN FLAW FOR WHICH MERCEDES BENZ, THE AUTOMOBILE MANUFACTURER,HOLD ITSELF ACCOUNTABLE. WHAT POSSIBLE ENGINEERING REASON CAN THEY OFFER OTHER THAN THE FACT THAT THE FUEL AND ELECTRICAL FUEL DELIVERY COMPONENTS SYSTEM WERE SERIOUSLY FLAWED FROM THE BEGINNING OF PRODUCTION? *JS

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C32 AMG. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED AFTER THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

I WOULD LIKE THE FOLLOWING ADDED TO MY ORIGINAL COMPLAINT ODI#10579532. THE FOLLOWING LETTER WAS SENT TO ME BY DAIMLER BENZ CORPORATE OFFICE IN GERMANY: [XXX] MAY 15 (1 DAY AGO) TO ME REF: [XXX] DEAR [XXX], THANK YOU FOR YOUR MOST RECENT EMAIL. WE CAN ASSURE YOU THAT ALL AUTHORIZED MERCEDES-BENZ WORKSHOPS WORLDWIDE ARE COMMITTED TO WORKING WITHIN THE GUIDELINES AND WORK INSTRUCTIONS OF THE MANUFACTURER. IN THIS CASE, MERCEDES-BENZ RECOMMENDS THAT THE MOST EFFECTIVE REPAIR IS TO REPLACE THE ENTIRE ASSEMBLY, RATHER THAN THE INDIVIDUAL AFFECTED PART. WE REGRET THAT YOU FEEL WE ARE PUSHING YOU AWAY HOWEVER, AS YOUR VEHICLE IS REGISTERED IN THE UNITED STATES OF AMERICA WE MUST INVOLVE THE RESPONSIBLE ENTITY, WHICH IS MERCEDES-BENZ USA. WE HOPE YOU CAN APPRECIATE THAT DUE TO THE VARYING LEGISLATIONS WORLDWIDE, WE MUST ENSURE THAT EACH CUSTOMER IS DEALT WITH IN ACCORDANCE WITH THE CORRECT PROCEDURES. MERCEDES-BENZ USA WILL ADDRESS THIS MATTER IN FULL FOR YOU AND SHALL INFORM US OF THE OUTCOME. THANK YOU ONCE AGAIN FOR TAKING THE TIME TO CONTACT US BUT REGRETTABLY WE ARE UNABLE TO ADD ANY FURTHER COMMENTS. YOURS SINCERELY [XXX] DAIMLER TEAM FOR THE BOARD OF MANAGEMENT / DAIMLER KUNDENBETREUUNGSTEAM FR DEN VORSTAND DAIMLER AG SITZ UND REGISTERGERICHT/DOMICILE AND COURT OF REGISTRY:STUTTGART INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THIS 2002 MERCEDES C32 IS A DEATHTRAP! THE ELECTRONIC COMPONENTS, REAR & FORWARD SAM, FUEL PUMP, ETC, FAIL AT AN UNUSUALLY HIGH RATE. THE MOST RECENT INCIDENT INVOLVED A FAULT IN THE PRIMARY FUEL PUMP. THE MERCEDES DEALER IDENTIFIED THE FAULT AS A FAULTY PLASTIC POWER CONNECTOR ON THE PUMP AND A FAILED FUEL PRESSURE SENSOR. THEY THEN PROCEEDED TO TELL ME THAT MERCEDES BENZ NORTH AMERICA WOULD NOT SELL ME A REPLACEMENT PUMP; INSTEAD, THEY INSISTED THAT I PURCHASE AN ENTIRE NEW FUEL TANK AND WIRING HARNESS FOR $3200 PARTS AND THOUSANDS OF DOLLARS MORE FRO LABOR. MERCEDES BENZ IS AWARE OF A SERIOUS DESIGN FLAW ON THIS YEAR AND MODEL, YET, REFUSES TO ACKNOWLEDGE A VOLUNTARY RECALL! MOREOVER, THE DESIGN AND PLACEMENT OF THE TANK--A SADDLE TYPE, SITUATED UNDER THE REAR SEATS--ALLOWS DIRT, SMALL PEBBLES AND OTHER DEBRIS TO ACCUMULATE IN THE AREA (A TYPE OF WELL) OF THE FUEL PUMP(S)--THERE ARE TWO. EVERY TIME I'VE HAD THE CAR SERVICED THE TECHNICIAN HAD TO VACUUM OUT ALL THE ACCUMULATED DEBRIS. (MY NEW YORK TITLE, WHERE I ORIGINALLY REGISTERED IT AFTER PURCHASING IT USED AT A NEW CAR DEALER, NEVER INDICATED IT HAD BEEN PART OF A LEMON LAW PROCESS.) I'VE NOTICED ON THIS SITE THAT OTHERS HAVE COMPLAINED ABOUT FUEL PUMP PROBLEMS, INCLUDING SERIOUS FUEL LEAKS WITH THEIR ASSOCIATED FUEL LINE FAULTS. REGARDLESS OF THE AGE OF THE VEHICLE, THESE FAILURES SHOULD NEVER TAKE PLACE!!!! MOREOVER, I AM COUNTING ON YOUR OFFICE TO INVESTIGATE THIS MATTER THOROUGHLY. IN RECENT DAYS IT HAS COME TO LIGHT THAT THE AUTO INDUSTRY HAS BEEN CRIMINALLY NEGLECTFUL WITH RESPECT TO ADDRESSING FAULTY DESIGN ISSUES. I THINK MY CIRCUMSTANCE IS YET ANOTHER EXAMPLE OF THIS PHENOMENON. MERCEDES BENZ OF NORTH AMERICA MUST BE HELD TO ACCOUNT FOR PLACING A SERIOUSLY FLAWED PRODUCT INTO THE MARKETPLACE! *JS

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE POWER SEAT MODULE WAS DRAINING THE BATTERY AND AS A RESULT, IT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 81,000.

FUEL SENDING UNIT FAILURE CAUSING GAS TANK TO LEAK. FUMES SO STRONG IN GARAGE RISK OF EXPLOSION. FUMES PERMEATING HOME. *TR

I AM NOT SURE WHY MERCEDES IS DOING THIS. I AM SURE THE AUTO MAKER IS AWARE OF THE SITUATION AND NOT DOING ANYTHING ABOUT IT. I HAVE READ NUMEROUS FORUMS REGARDING THE SAME ISSUE. ELECTRICAL COMPONENTS NOT FUNCTIONING PROPERLY. I DEMAND MERCEDES TO DO SOMETHING ABOUT THIS PROBLEM AND THEY CAN NOT GET AWAY CLEAN HANDS JUST LIKE ANY OTHER AUTO MAKERS. THIS ARE PEOPLE LIVES YOU ARE PLAYING WITH AND YOU AS A AUTOMAKER HAVE NO REMORSE FOR PEOPLE LIVES. THIS IS NOT A MOVIE WHERE YOU CAN JUST CALCULATE YOUR COLLATERAL DAMAGE AND GET AWAY. WILL NEVER BUY MERCEDES EVER AGAIN. I AM VERY DISAPPOINTED. ITS ONE ISSUES AFTER ANOTHER. MY CAR JUST STOPS ON HIGHWAY ALL OF SUDDEN LOSES POWER AND HAVE TO TURN IT OFF AND TURN IT ON AGAIN. I HAD ALMOST EVERYTHING REPLACED IN THE CAR, SPARK PLUGS, ALTERNATOR, BATTERY(THAT WENT OUT 3 TIMES). OH DON'T GET ME STARTED ON THE AIR CONDITIONER - THE PARTS ARE MADE SO CHEAP THAT THERE IS A LITTLE HOOK TYPE THING THAT REGULATES THE SPEED OF THE SPEED BREAKS SO EASILY I CANT BELIEVE IT. COUNTLESS FORUM DATA EXIST AND NHTSA DOESN'T DO ANYTHING ABOUT IT. BAN THIS AUTOMAKER OR TELL THEM TO GIVE ME A NEW CAR. NOW I AM LOOKING TO SPEND CLOSE TO ANOTHER $600-$1000 BUCKS TO DIAGNOSE AND REPLACE PARTS. THIS IS NOT A JOKE. OH THEN THERE IS THAT WHEEL BEARING ISSUE I MEAN COME ON MY DAD OWNS A HONDA ACCORD OLDER THAN MINE ALL HE HAS DONE TO THAT CAR SO FAR IS OIL CHANGE AND REGULAR MAINTENANCE. I DEMAND SOME ANSWER AND POSSIBLE COMPENSATION FROM THE AUTO MAKER. *TR

THE FOLLOWING PROBLEM(S) OCCURRED ON A 2002 MERCEDES C32 AMG: THE CAR WOULD NOT START AFTER RUNNING FINE DURING THE LAST DRIVE. I SUSPECTED THE FUEL PUMP AND PROCEEDED TO INSPECT IT. AFTER REMOVING THE WIRING FROM THE FUEL PUMP LEVEL PRESSURE SENSOR (MERCEDES P/N 2034701741) THE CAR STARTED. I THEN FILLED UP THE GAS TANK, AND GAS POURED OUT ON THE DRIVER'S SIDE. RE-INSPECTING THE FUEL PUMP LEVEL SENSOR SHOWED GAS POURING OUT OF IT. IT TURNS OUT THE WIRING HAD MELTED A SMALL HOLE IN THE PART AND THAT WAS THE SOURCE OF THE GAS LEAK. I REPLACED THE PART WITH AN OEM ONE ON 9/26/13 AND IT FAILED AGAIN FOR THE SAME REASON ON 10/15/13. I HAVE READ NUMEROUS REPORTS OF THIS SAME PROBLEM ACROSS THE MERCEDES LINE-UP AND OF A CLASS ACTION SUIT TO CORRECT IT. *TR

WHILE DRIVING TO GET ON THE FREEWAY FROM ON RAMP, MISS JUDGE AND LOST CONTROL OF THE STEERING WHEEL, VEHICLE FLIP FROM FRONT TO BACK ON THE DITCH SIDE OF THE ROAD, DRIVER WAS WEARING A SEAT BELT BUT GOT THROWN OUT DUE TO SEATBELT MALFUNCTION. FRONT AIRBAG ON STEERING AND PASSENGER SIDE DID NOT DEPLOYED, DRIVER SUSTAINED BROKEN SPINAL (NECK), TRAUMA BRAIN INJURY, BROKEN COLLAR BONES, BRUISED LUNGS, TWO BROKEN ARMS TWO BROKEN LEGS. *TR

DRIVING FROM SAN FRANCISCO (SEA LEVEL) AND EVENTUALLY DESCENDING FROM ECHO PASS AT 7200 FEET ELEV TO LAKE TAHOE (6200 FEET ELEV) ON HIWAY 50, ALL OF A SUDDEN, THE VEHICLE DISPLAY SHOWED AN ESP WARNING LIGHT WHILE SIMULTANEOUSLY THE ENGINE WENT INTO 'IDLE' MODE (ENGINE WAS STILL RUNNING) AND THE ACCELERATOR PEDAL COULD SUMMON NO POWER. PULLED OVER AND TURNED CAR OFF COMPLETELY TO PONDER. TURNED CAR BACK ON AND THE ESP WARNING LIGHT WAS GONE. THERE WAS FULL ACCELERATOR POWER AGAIN. CONTINUING THE DRIVE INTO SOUTH LAKE TAHOE, WE EXPERIENCED THE SAME EXACT THING AGAIN TWO MORE TIMES IN ONLY ABOUT 15 MILES HAVING TO DO THE SAME RESTARTING & CLEARING THE ESP WARNING TO GET TO OUR DESTINATION. IT CONTINUED TO OCCUR SEVERAL MORE TIMES IN THE 2 DAYS WE WERE AT TAHOE. WE WERE WORRIED ABOUT MAKING IT BACK TO SF. WE DECIDED TO TRY IT AND WE LEFT ECHO LAKE (7200 FEET) AND DESCENDED TO SF (SEA LEVEL) BUT THE ESP WARNING DID NOT COME ON AGAIN AT ALL FOR THE NEXT THREE WEEKS. ONLY LAST WEEKEND, WE HEADED BACK UP TO THE EXACT SAME LOCATION AT ECHO LAKE AND BEHOLD, THE ESP WARNING CAME BACK ON. BY RESTARTING THE CAR AND TURNING THE STEERING WHEEL SEVERAL TIMES ALL THE WAY LEFT TO RIGHT OVER AND OVER, DID THE ESP FINALLY GO OUT AND WE THEN DROVE ALL TYHE WAY HOME AGAIN TO SF. THE ESP WARNING HAS SINCE NOT COME BACK ON, NOR HAS THE CAR STOPPED OR SWITCHED INTO AN 'IDLE' MODE. IT IS A NUISANCE AND CLEARLY ELECTRONIC......FAULTY SWITCHES/SENSORS ?

THERE HAVE BEEN TWO WARNING LIGHTS FOR REAR LIGHTS AND AFTER DRIVING FOR 4 HOURS, A WARNING CAME ON FOR ELECTRICAL STABILITY AND MY CAR QUIT WORKING COMPLETELY. THERE WAS A BURNING SMELL AND I HAD TO RESTART IT. I AM VERY CONCERNED ABOUT THIS. *TR

I CALLED MBUSA 2 WEEKS AGO REGARDING MY 2002 C320 WAGON WHICH WAS SMELLING OF PURE GASOLINE WHICH THE ODOR WAS SO STRONG IT WAS COMING INTO THE HOUSE FROM THE GARAGE GIVING US HEADACHES. I CHECKED ONLINE WITH MBUSA CLUB MEMBERS AND FOUND OUT THIS COULD BE A DANGEROUS SITUATION AND TO CALL IT IN. I CALLED MBUSA AND WAS TOLD THERE WERE NO RECALLS OR BULLETINS PERTAINING TO THIS ISSUE AND WE WERE OUT OF WARRANTY TO CONTACT THE DEALER. I CALLED THE DEALER WHO SEEMED VERY FAMILIAR WITH THIS ISSUE AND JUST FOR PARTS IT WAS OVER $800 AND THEY WERE NOT AWARE OF ANY WARRANTY, RECALL ISSUES. THIS IS OUR FAMILY CAR WE USE THIS WAGON TO TRAVEL DAILY WITH THE KIDS OR OTHER LITTLE FAMILY MEMBERS SO WE DID NOT WANT TO TAKE ANY CHANCES. WE CALLED OUR INDEPENDENT MERCEDES BENZ CERTIFIED MECHANIC AND HE KNEW WHAT IS WAS JUST FROM OUR CONVERSATION. HE HAD US BRING IT IN RIGHT AWAY AND HE LIFTED UP THE REAR SEAT WHERE OUR CHILDREN SIT AND SHOWED MY HUSBAND AND MYSELF A POOL OF GASOLINE COMING FROM THE FUEL PUMP SITTING RIGHT UNDER THE SEAT!! I WAS DISGUSTED TO KNOW THAT MBUSA DISMISSED THIS SO QUICKLY AND COULD HAVE POTENTIALLY PUT OUR CHILDREN AT RISK. PLEASE NOTE THIS VEHICLE HAS BEEN WELL TAKEN CARE HAD AN EXTENDED WARRANTY AND HAS VISITED THE MB DEALER MORE TIMES THAN ANY CAR SHOULD EVER NEED. THIS SEEMS TO BE A COMMON PROBLEM EVEN THE PARTS DEPARTMENT AT THE DEALER TOLD US THEY SEE ALOT OF THESE NEEDING REPLACED AND ALTHOUGH MB HAS UPDATED THE FAULTY PART THEY HAVE NOT NOTIFIED OWNERS OF THE POSSIBLE SAFETY ISSUE. *TR

DRIVERS POWER SEAT CONTROL MODULE DRAINS BATTERY WHEN AUTO IS PARKED. *TR

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ C320. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE INSTRUMENT PANEL FAILED TO FUNCTION. AS A RESULT, THE CONTACT WAS UNABLE TO READ THE GAUGES AND THE INDICATORS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 06V028000 (INTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 102,000.

TL* THE CONTACT OWNS A 2002 MERCEDES C320. THE CONTACT STATED HE HAD TO REPLACE THE BATTERY IN THE VEHICLE SEVERAL TIMES. THE DEALER STATED THE SEAT CONTROLS FOR THE PASSENGER SEAT DRAINED THE BATTERY AND THE SEAT CONTROL MODULE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE 90,904. *TR

I AM CORROBORATING WHAT WAS SUBMITTED ON CLAIM 10632020. THE FRONT POWER SEATS ON BOTH SIDES OF MY CAR HAVE FAILED. WHEN THEY FAIL THERE IS A CONSTANT BATTERY DRAIN WHILE THE CAR IS OFF THAT DRAINS THE BATTERY COMPLETELY, CAUSING IT TO BE DEAD WITHIN 8 HOURS. FIRST MY DRIVERS SIDE FAILED, THEN WITHIN THE SAME YEAR THE PASSENGER SEAT FAILED. I BOUGHT TWO NEW BATTERIES AND HAD TO ARGUE WITH THE SALESMEN ABOUT WHETHER THE BATTERIES WERE GOOD OR BAD BEFORE I REALIZED THE PROBLEM WAS IN THE SEAT CONTROLS. MB WANTED MULTIPLE THOUSANDS OF DOLLARS TO REPLACE 1 SEAT CONTROLLER. OVERALL THE ELECTRONICS ON MY CAR ARE ITS WEAKEST LINK, AND UNFORTUNATELY WHEN SOMETHING BREAKS THERE IS NO FIXING IT OTHER THAN TO REPLACE THE ASSEMBLY. MB SHOULD COVER THIS ON A RECALL BECAUSE IF SOMEONE'S MOTHER OR WIFE IS OUT ON THE ROAD AND THEY FIND THEIR BATTERY DEAD IN THE DARK OF THE NIGHT THERE IS A SAFETY ISSUE. *TR

THERE IS VERY LIMITED VISIBILITY FROM THE DRIVER'S SIDE MIRROR BECAUSE THE MIRROR IS COMPROMISED IN SOME WAY. THIS OBVIOUSLY IS A SAFETY HAZARD. ADDITIONALLY, FLUID FROM THE MIRROR LEAKED ONTO THE DOOR OF THE CAR AND I UNDERSTAND THAT IT HAS ALMOST DEFINITELY AFFECTED THE PAINT. APPARENTLY, THIS HAS BEEN A COMMON PROBLEM IN MERCEDES CARS. I WAS AMAZED TO DISCOVER THE REPLACEMENT COST OF THE MIRROR, WHICH EXCEEDS $600. *TR

AFTER PLACING THE VEHICLE IN PARK, I PULLED THE STEERING WHEEL LEVER LOCK, (RED WARNING LIGHT CAME ON), AND ADJUSTED THE HEIGHT AND DEPTH OF THE STEERING WHEEL. I THEN PUSHED THE STEERING WHEEL LEVER LOCK BACK IN (RED WARNING LIGHT DISAPPEARED). I STARTED DRIVING AND WHILE I WAS MAKING A RIGHT ON A CURVE THE STEERING WHEEL SLIPPED OUT OF PLACE AND ALMOST CAUSED ME TO SWERVE INTO ANOTHER LANE. I PULLED OVER ATTEMPTED TO REENGAGE THE STEERING WHEEL LOCK IN SEVERAL DIFFERENT POSITIONS, BUT IT WOULD NOT STAY LOCKED. THE RED WARNING LIGHT ONLY COMES ON WHEN THE STEERING WHEEL LOCK LEVER IS PULLED OUT, BUT IT DOES NOT SHOW THAT THE STEERING WHEEL IS DISENGAGED WHEN THE LEVER IS PUSHED IN EVEN THOUGH THE LOCKING MECHANISM DOES NOT FUNCTION. I LOOKED ONLINE AND FOUND A FORUM WITH SEVERAL OTHER PEOPLE HAVING THE SAME PROBLEM ON A VARIETY OF DIFFERENT VEHICLES OF DIFFERENT YEARS. I FEEL IT IS DANGEROUS TO OPERATE MY VEHICLE. *TR

I HAVE A 2002 MERCEDES C320. MY BATTERY IS DEAD AFTER SEATING OVERNIGHT. TOOK THE CAR TO THE AUSTIN MB DEALERSHIP TO DIAGNOSE THE PROBLEM. I WAS TOLD THAT THE POWER SEAT MOTOR IS DRAINING MY BATTERY. BOTH SEATS. COME TO FIND OUT THAT MANY OTHER PEOPLE HAVE EXPERIENCED THE SAME PROBLEM. I CALLED MERCEDES USA AND THEY SAID THAT SINCE THE CAR IS OUT OF WARRANTY, THERE IS NOT MUCH THEY CAN DO. THAT IS BULL!! OBVIOUSLY SINCE SO MANY PEOPLE WITH THIS CAR MODEL HAVE THE SAME PROBLEM, IT HAS TO BE A MANUFACTURER FAULT. I WAS WONDERING HOW MANY PEOPLE NEED TO EXPERIENCE THIS PROBLEM BEFORE MERCEDES WILL ADMIT THAT THEY HAVE A BAD COMPONENT ON THIS MODEL. I FIGURED,IF ENOUGH PEOPLE CALL AND TELL MB THAT THEY HAVE THIS SAME PROBLEM, THEY WILL REALIZE THAT THIS IS A DEFECTIVE PART AND THEY WILL ISSUE A RECALL AND PAY FOR NECESSARY REPAIRS. PLEASE CALL MERCEDES USA AND REPORT THIS PROBLEM. 1-800-FOR-MERCEDES (1-800-367-6372) OR 201-476-6200. *TR

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C240. THE CONTACT STATED THAT BOTH THE DRIVER AND PASSENGER SEAT REGULATORS WERE DEFECTIVE. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 84,000.

BOTH FRONT POWER SEAT MODULES DRAIN BATTERY WHEN CAR IS OFF. *TR

THIS IS A C230 KOMPRESSOR COUPE. THE REAR DIFFERENTIAL MADE A LOUD NOISE AND THEN LOCKED UP AFTER BEING DRIVEN SLOWLY TO A SHOP. IT WAS LATER LEARNED THAT THIS IS A VERY COMMON OCCURRENCE WITH THE EARLY 2002 C CLASS CARS BUT AS USUAL, THERE IS NO RECALL. I CONTACTED MBUSA AND THEY OFFERED NO ASSISTANCE. THIS CAR HAS ALSO RECENTLY SHOWN EVIDENCE OF RUSTING. I CONTACTED MBUSA ABOUT THAT AND LEARNED THAT THE MB CORROSION PROTECTION IN THE U.S. IS MERELY FOUR YEARS. I ALSO FOUND THAT MOST OF THE OTHER GERMAN LUXURY AUTOMAKERS HAVE USED GALVINIZED STEEL FOR DECADES, UNLIKE THE MANUFACTURING PRACTICES OF MB. OVERALL, BETWEEN BUILT-IN MECHANICAL FAILURES AND THE RUST, AND THE FACT THAT MBUSA DOES NOT STAND BEHIND THEIR VEHICLES, I WILL CERTAINLY STEER CLEAR OF MERCEDES IN THE FUTURE. *TR