2004 Mercury Mountaineer Complaint Log

I HAD PICKED UP MY KIDS FROM DAYCARE AND I PUT MY VEHICLE IN REVERSE AND BACKED UP. WHILE BACKING UP I HEARD A LOUD POP AND I GOT OUT TO SEE BUT THERE WAS NOTHING VISIBLE. SO I PUT THE VEHICLE IN DRIVE AND AS I WAS GOING DOWN THE STREET MY VEHICLE AXLE BROKE AND MY TRUCK HIT THE STREET IN THE MIDDLE OF TRAFFIC. I TOOK IT TO THE FORD DEALERSHIP AND THEY SAID IT WAS MY AXLE AND MY DIFFERENTIAL HAD BROKEN ALSO, AM I AM LUCKY THAT I DIDN'T HAVE A BAD ACCIDENT WITH THE EXTEND OF THE DAMAGE OF THE DIFFERENTIAL. AFTER I FIXED THAT AND IT COST $2900. THAT STILL DID NOT FIX THE PROBLEM AND I HAD TO REPLACE THE TRANSFER CASE. THEN ALL THREE OF MY CADILLAC CONVERTERS HAD TO BE REPLACED. I HAVE HAD PROBLEM AFTER PROBLEM AND OH YEAH THE BACK REAR GATE HAS BEEN CRACKED LIKE THE MONTH AFTER I BOUGHT IT. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE ATTEMPTING TO CHANGE THE WHEEL DRIVE, THE VEHICLE FAILED TO UTILIZE THE FORWARD WHEEL DRIVE. IN ADDITION, THE VEHICLE BEGAN EXHIBITING SEVERAL FAILURES SIMULTANEOUSLY. THE POWER STEERING ASSIST FAILED, THE GEAR SHIFTER FAILED, AND THE TRANSMISSION WAS CAUSING THE VEHICLE TO JERK ABNORMALLY. ALSO, THE POWER WINDOWS HAD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE TRANSFER CASE AND TRANSMISSION NEEDED TO BE REPLACED. THE ADDITIONAL FAILURES WERE NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

I OPENED THE WINDOW HATCH ON THE BACK OF THE VEHICLE AND THE WINDOW HINGE BROKE AND THE WINDOW STARTED TO SLIP DOWN ALMOST BRAKING MY NOSE. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DEACTIVATED THE CRUISE CONTROL WHEN THE VEHICLE SUDDENLY STALLED. THE FAILURE ALSO RECURRED WHEN DRIVING AT SLOWER SPEEDS OR WHEN DECELERATING WITH THE CRUISE CONTROL ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THERE WAS A RECALL AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THERE WAS A MANUFACTURER'S VOLUNTARY RECALL ISSUED BUT THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 9/21/12 *CN THE CONSUMER STATED WHEN THE FAILURE OCCURRED, THERE WAS A TOTAL SHUTDOWN OF THE ONBOARD COMPUTER, BECAUSE THE POWER STEERING AND POWER BRAKES ALSO FAILED. RECOVERY REQUIRED GETTING THE VEHICLE STOPPED ON THE SHOULDER AND TURNING OFF THE IGNITION. UPDATED 10/04/12

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE SHIFTER WOULD NOT SHIFT INTO PARK DUE TO A DEFECTIVE SHIFT CABLE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE THE MECHANIC ADVISED THAT THE SHIFTER CABLE NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE SHIFTER CABLE REPLACED. THE FAILURE MILEAGE WAS 140,000.

AS I WENT TO SHUT THE BACK LIFT GATE WINDOW HATCH, THE HINGE BROKE LEAVING THE WINDOW TO FALL. LUCKILY I CAUGHT IT, BUT IT CAME DOWN HARD. THE SHEAR PIN BROKE STRAIGHT OFF. *TR

REAR HATCH BACK GLASS BODY-SIDE HINGE BROKE ON RIGHT SIDE IN NORMAL OPENING OF GLASS. HINGE IS COMPOSED OF A BLACK PLASTIC OR NYLON RETAINING CLIP WITH A METAL PIN. THE PLASTIC APPEARS TO HAVE FAILED FROM FATIGUE. RECENT HIGH HEAT (100+ DEGREES FOR SEVERAL DAYS) MAY BE A FACTOR. PLASTIC BROKE THROUGH OVER THE PIN CHANNEL, ALLOWING THE PIN TO POP OUT. THE GLASS IS HEAVY AND TORQUED BY THE REMAINING HINGE AND TWO HYDRAULIC LIFTS. NO INJURIES, BUT EASILY COULD HAVE FALLEN, BROKE OR SHATTERED ON THE OPERATOR. THE HEAVY GLASS IS A DANGER ESPECIALLY TO CHILDREN OR SMALLER ADULTS. THE OPERATOR FORTUNATELY HAD A WOOD SLAT IN THE BACK BIG ENOUGH TO PROP UP THE GLASS AND SUPPORT IT UNTIL HELP ARRIVED. EVEN WITH TWO ADULTS IT WAS HARD TO HOLD AND CONTROL THE GLASS TO CLOSE IT AND TAKE TO THE DEALER. RETENTION CLIP REALLY SHOULD HAVE EMBEDDED METAL REINFORCEMENT AROUND THE PIN.(THE LARGER EXPEDITION APPEARS TO HAVE JUST THAT IN THE EQUIVALENT PART.) READING ONLINE THERE ARE MANY CASES OF SIMILAR FAILURE THAT INCLUDED DAMAGE AND OR AT LEAST MINOR INJURIES. REPAIR WAS $270 AT A FORD DEALER. APPEARS TO BE COMMON ENOUGH FAILURE TO BE A DESIGN FLAW NOT TO BE REPEATED. ADMITTEDLY THIS APPEARED ON A HIGH MILEAGE NINE YEAR-OLD VEHICLE WHICH HAS OTHERWISE PROVIDED VERY GOOD SERVICE, BUT THE WEIGHT OF THE FALLING GLASS AND TORQUE INVOLVED WERE BOTH DANGEROUS AND COULD EASILY HAVE RESULTED IN SERIOUS INJURY. OPERATOR FELT LUCKY TO CATCH AND CONTROL IT WITHOUT BREAKING THE GLASS OR GETTING HURT. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS A POPPING NOISE FROM THE REAR OF THE VEHICLE. UPON INSPECTION, IT WAS DISCOVERED THAT THE REAR LIFT GATE WINDOW HAD SUDDENLY SHATTERED. THE CONTACT INDICATED THAT WINDOW WAS REPLACED BUT THE FAILURE REOCCURRED. AFTER REPLACING THE WINDOW A SECOND TIME THE CONTACT RECENTLY DISCOVERED THAT THE WINDOW PANEL AND GLASS HAD CRACK. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

TRANSMISSION SOLENOIDS THREE TIMES, PAINT COMING OFF, PASSENGER SEAT TRIM CAME OFF, CRACKED REAR LIFT GATE, PASSENGER FRONT AND REAR DOOR WINDOWS, AND DRIVER SIDE REAR DOOR WINDOW DO NOT WORK. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE TRAVELING 5 MPH IN REVERSE, THE CONTACT NOTICED A THUMPING SOUND COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. MOMENTS LATER, THE CONTACT NOTICED THAT THE VEHICLE WOULD NO LONGER ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE REAR DIFFERENTIAL WAS REPLACED. THE CONTACT STATED THAT THE FAILURE WAS RECURRING. THE CURRENT AND FAILURE MILEAGES WERE 143,000.

THE TRANSMISSION FAILED ON MY 2004 MOUNTAINEER THE FIRST TIME IN JULY 2009 WITH ONLY APPROX 58,000 MILES. IT WAS UNDER WARRANTY. I WAS TOLD BY THE MERCURY DEALERSHIP THAT MY TRANSMISSION WOULD HAVE TO BE REBUILT FOR THE TRANSMISSION WAS ON NATIONAL BACK ORDER FOR A BRAND NEW TRANSMISSION. I MADE AN INQUIRY AS TO WHY A TRANSMISSION WOULD BE ON NATIONAL BACK ORDER??. NOW AT APPROX 84,000 MILES THE WARRANTY REBUILT TRANSMISSION HAS FAILED AGAIN . THAT IS ONLY 24,000 MILES PUT ON THE REBUILT TRANSMISSION. MY REBUILT TRANSMISSION HAS NOT EVEN HIT THE 30,000 MILES MAJOR TRANSMISSION SERVICE TIME. MY WARRANTY EXPIRED AT 75,0000 MILES . MY DEALERSHIP HAS INFORMED ME I HAVE NO WARRANTY ON A TRANSMISSION THAT WAS REBUILT UNDER WARRANTY PAST 75,0000 MILES. *TR

TRANSMISSION FAILED AT 58,000 AND WAS REBUILT ( NOT REPLACED) UNDER WARRANTY. NOW LESS THAN 24,000 MILES AND 27 MONTHS LATER AT 84,000 MILES, TRANSMISSION HAS FAILED AGAIN. THE REBUILT TRANSMISSION HAS NOT EVEN HIT THE 30,000 MILES MAJOR TRANSMISSION SERVICE TIME. *TR

CAME OUT ONE MORNING TO DISCOVER THE REAR HATCH HAD A CRACK AROUND THE EMBLEM OF MY 2004 MERCURY MOUNTAINEER. CAR WAS PARKED IN DRIVEWAY AND WAS NOT HIT OR INVOLVED IN AN ACCIDENT. STARTED NOTICING THAT EVERY MERCURY MOUNTAINEER OF THE SAME BODY TYPE HAD SIMILAR CRACKS IN THE SAME LOCATION. CONTACTED FORD BUT DID NOT HAVE VIN #. EVENTUALLY CONTACTED FORD AGAIN WITH VIN # AND WAS TOLD THERE WAS NO RECALL AND THAT FORD WAS NOT ACCEPTING ANY RESPONSIBILITY . I TOLD FORD THAT IT IS AN OBVIOUS DEFECT TO NO AVAIL. I WILL NEVER BUY ANOTHER FORD PRODUCT IF THIS IS HOW THEY TREAT THEIR CUSTOMERS. THIS SHOULD BE A RECALL AND FORD SHOULD REPAIR THIS DEFECT. THE VALUE OF MY CAR HAS DECREASED BECAUSE OF THIS. I GOT A $500.00 ESTIMATE TO REPAIR IT BUT WAS TOLD IT WOULD PROBABLY HAPPEN AGAIN. *TR

WIFE WAS CLOSING LIFTGATE AND IT BROKE FROM THE HINGES. THE LEFT SIDE FELL AND HIT HER ON THE HEAD. WAS TRYING TO HOLD LIFT GATE SO GLASS WOULDN'T FALL AND BREAK. CALLED FORD AND THEY SAID IT WAS NOT A RECALL ISSUE. LOOKING ONLINE IT SEEMS THIS HAPPENS A LOT. *KB

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED, WITH THE REAR LIFT GATE OPENED, WHEN IT BEGAN TO ROLL BACKWARDS. WHILE ATTEMPTING TO ENTER THE MOVING VEHICLE, THE CONTACT WAS KNOCKED DOWN AND SUSTAINED INJURIES. THE VEHICLE CONTINUED TO ROLL BACKWARDS UNTIL CRASHING INTO A TREE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THERE WAS AN INVESTIGATION OPEN UNDER NHTSA ACTION NUMBER: EA09013 (STEERING POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) STEERING:COLUMN STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE) THAT MAY BE RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 82,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THE LIFT GATE GLASS HINGE DISENGAGED AND IMPACTED HER ABILITY TO DRIVE. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

2004 MERCURY MOUNTAINEER, REAR HATCH MOLDING WITH MERCURY EMBLEM. TWO WINTERS AGO THE MOLDING CRACKED AFTER A VERY COLD FREEZE. VEHICLE WAS UNDER WARRANTY AND THE ENTIRE HATCH HAD TO BE REPLACED. DEALER HAD VEHICLE 3 OR 4 DAYS AS NEW HATCH WAS SENT OUT TO A LOCAL BODY SHOP TO BE PAINTED, MATCHING THE VEHICLE COLOR. NOW, THE SAME MOLDING HAS BEGUN DE-LAMINATING FROM THE HATCH. DEALER STATES HATCH HAS TO BE REPLACED AND WILL COST $1000.00. *KB

AUTOMATIC TRANSMISSION SHIFTER COMPLETELY BROKE OFF WHEN CHANGING FROM PARK TO DRIVE ON A 2004 MERCURY MOUNTAINEER. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFTGATE WAS FRACTURED FROM THE DECAL UP TO THE MIDDLE OF THE REAR GLASS. THE VEHICLE WAS NEITHER INSPECTED NOR REPAIRED FOR THE FAILURE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGE WAS 51,029.

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFT GATE WAS FRACTURED AROUND THE EMBLEM UP TO THE MIDDLE OF THE REAR WINDOW. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WAS NO RECALL AND TO CONTACT NHTSA. THE FAILURE MILEAGE WAS 63,725. UPDATED 03/01/13*LJ

SHUT OFF WHILE DRIVING LOST POWER STEERING ETC. *TR

PREMATURE RUSTING AND PAINT BUBBLING ON REAR QUARTER PANEL UNDER FUELING DOOR (CONTINUES TO GET WORSE.) I HAVE OBSERVED SEVERAL OTHER LINCOLN/MERCURY VEHICLES WITH SAME PROBLEM. *TR...UPDATED 12/09/15 *BF

I WAS DRIVING ON THE HIGHWAY AT ABOUT 55MPH IN A 2004 MERCURY MOUNTAINEER AND SUDDENLY BOTH SIDE CURTAIN AIRBAG DEPLOYED. THERE WAS NO ACCIDENT, NO IMPACT, NO POTHOLES, NO VEERING OR RUNNING OFF THE ROAD; JUST DRIVING AND IT HAPPENED. SCARED ME HALF TO DEATH. I WAS ABLE TO COMPOSE MYSELF WELL ENOUGH TO NOT WRECK. FURTHERMORE, THERE WAS NO WARNING FROM THE DASH FOR THE AIRBAG TO INFORM ME OF ANY MALFUNCTIONS OR PROBLEM WITH THE AIRBAG SENSOR OR MODULE. *TR

TL*THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE HAVING THE VEHICLE SERVICED FOR ROUTINE MAINTENANCE AT AN AUTHORIZED DEALER THE CONTACT COULD SMELL A BURNING ODOR. THE CONTACT WAS TOLD THE ENGINE MANIFOLD WAS CRACKED AND LEAKING. THE VEHICLE WAS REPAIRED. A FEW DAYS LATER THE VEHICLE BEGAN SHAKING WHILE STOPPED. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZE DEALER WHERE THE CONTACT WAS TOLD THE ENGINE COILS AND SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 46,845. UPDATED 03/24/11*LJ UPDATED 1/4/11 *CN

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THERE WAS A FRACTURE IN THE PANEL OF THE REAR LIFTGATE FROM THE BOTTOM OF THE WINDOW TO THE BASE OF THE LIFTGATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE CONTACT STATED THAT THE REAR LIFTGATE WAS INOPERABLE. THE FAILURE AND CURRENT MILEAGE WAS 70,000.

REAR DOOR PANEL CRACKED, VISUAL, THEN FOUND SEVERAL MORE 2004 MOUNTAINEERS WITH THE SAME CRACK, NOW A LAWSUIT HAS BEEN FILED AS CLASS ACTION, I HEAR A NOISE MECHANICAL GRIND FROM REAR OF VEHICLE, STOP BY A FORD DEALER TO GET A TRADE IN PRICE, AND SEE IF ANYTHING IS MENTIONED, THEY TELL ME TO GET MY CAR FIXED, !! NO MENTION THEY KNEW OF THE PROBLEMS, NOW I READ TRANSMISSION PROBLEMS, GLASS VISIBILITY PROBLEMS, CRUISE CONTROL FIRE, PROBLEMS MY CAR'S CRUISE QUIT WORKING, ON AND ON IT GOES, LISTS OF LISTS OF PROBLEMS, I KNOW CARS WEAR OUT BUT TO KNOW THERE ARE PROBLEMS AND HIDE THEM, NEEDS ACTION. *TR

TRANSFER CASE DEFECT CAUSES STEERING DIFFICULTY ON SLOW TURNS. TRANSMISSION ISSUE REPORTED TO FORD IN 2005 AT 38,000 MILES. AGAIN AT 51,000. I OPTED FOR AN AAMCO TRANSMISSION WHEN FORD REFUSED TO COVER. NOW TRANSFER CASE IS MAKING DRIVING DANGEROUS. TURNING ABILITY GREATLY REDUCED. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE CENTER PIECE EMBLEM OF THE HATCH BACK STARTED TO FRACTURE. THE VEHICLE WAS PREVIOUSLY REPAIRED WITH A NEW HATCH BACK DOOR APPROXIMATELY TWO YEARS PRIOR TO THE RECENT FAILURE. THE VEHICLE HAD NOT BEEN INSPECTED SINCE THE RECURRENCE OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 04/26/12 *BF UPDATED 05/10/12

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED THAT THERE WAS A LARGE CRACK ON THE REAR LIFT-GATE DOOR PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000. THE CURRENT MILEAGE WAS 98,000. THE VIN WAS UNAVAILABLE.

HAVE A LITTLE OVER 67,000 MILES ON VEHICLE. DRIVING AT HIGHWAY SPEED TRANSMISSION INDICATOR CAME ON, O/D INDICATOR FLASHES AND SERVICE ENGINE INDICATOR CAME ON. TRANSMISSION SHIFTS ROUGHLY FROM 1ST GEAR TO 2ND, AND DOES NOT HAVE OVERDRIVE. SERVICE STATION RAN DIAGNOSTIC WHICH RESULTED IN 4 SERVICE CODES: PO732, PO735, PO775, AND PO1744. THESE CODES WERE ALSO CONFIRMED BY AAMCO TRANSMISSION. THE RESULT APPEARS TO BE TRANSMISSION SOLENOID PACK, ALONG WITH REBUILD OF THE TRANSMISSION. *TR

2004 MERCURY MOUNTAINEER V8, 47,000 MILES. TRANSMISSION IS SHOT. IT SLIPPED IN AND OUT OR REVERSE (CREATING A VERY DANGEROUS SITUATION SINCE I COULD NOT CONTROL THE VEHICLE WHEN IT WAS IN REVERSE) AND IT STRUGGLED TO SHIFT GEARS IN DRIVE. NO WARNING LIGHT BEFORE THE PROBLEMS BEGAN. THE VEHICLE AGED OUT OF WARRANTY IN JULY 2010. FORD WILL NOT PAY FOR ANYTHING (ALTHOUGH THE DEALER IS CUTTING ME A BREAK ON THE SERVICE COSTS). *TR

JUST PURCHASED A 2004 MERCURY MOUNTAINEER TODAY. DRIVING HOME, USING CRUISE/SPEED CONTROL AT AROUND 30MPH AND DRIVING ON A SLIGHT DECLINE, THE VEHICLE SHUT DOWN. ALL INDICATOR LIGHTS WENT ON, AND I HAD TO COAST TO THE SIDE OF THE ROAD. I PUT VEHICLE IN PARK AND RESTARTED IT WITHOUT PROBLEM. THERE WERE NO INDICATOR LIGHTS (CHECK-ENGINE, ETC.) LIT UP. IMMEDIATELY WENT TO LOCAL FORD DEALERSHIP AND THEY HAD NO CLUE, ESPECIALLY SINCE THE COMPUTER DID NOT HAVE ANY CODES INDICATING A PROBLEM.. I'M CANCELING THE CHECK AND RETURNING THE VEHICLE TOMORROW. *TR

I OWN A 2004 MERCURY MOUNTAINEER. ABOUT A WEEK AGO I NOTICED A CRACK IN THE REAR LIFTGATE PANEL OF MY VEHICLE. THE CRACK CURVES AROUND THE MERCURY LOGO LOCATED ON THE REAR PANEL. I CONTACTED THE DEALER AND HE SAID FORD IS VERY AWARE OF THIS PROBLEM AND HE REPAIRS MANY CRACKED LIFTGATES ON FORD/MERCURY SUV'S, ESPECIALLY IN THE WINTER DUE TO EXPANDING AND CONTRACTING OF PLASTIC. IT IS ALMOST HALFWAY DOWN THE BACK AND AM AFRAID THAT THE WINDOW WILL POP OUT WHILE DRIVING AND CAUSE AN ACCIDENT OR INJURE SOMEONE. IT IS A SAFETY HAZARD. FORD NEEDS TO RECALL THESE VEHICLES AND FIX THIS PROBLEM. IT SHOULD NOT BE THE RESPONSIBILITY OF THE CONSUMER, SINCE IT IS A DEFECT OF THE SUV. *TR

THE REAR PANEL IS CRACKED AROUND THE LOGO OF MY MERCURY MOUNTAINEER. I SEE THIS ON MOST OTHER MOUNTAINEERS AND EXPLORERS FROM THIS GENERATION AND FORD HAS DONE NOTHING TO REMEDY IT. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THERE WAS A HAIRLINE FRACTURE BELOW THE REAR WINDOW NEAR THE REAR LIFTGATE LATCH. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE DEFECT. THE FAILURE MILEAGE WAS 55,000. THE VIN WAS UNAVAILABLE.

2004 MERCURY MOUNTAINEER - HARMONIC BALANCER FAILED. IT WAS NOTICED WHEN A SQUEAKY NOISE WAS COMING FROM THE ENGINE. ALTHOUGH IS WAS CAUGHT BEFORE ANY SERIOUS INJURY OCCURRED, THIS FAILURE MAY HAVE LED TO ONE. IF THE BALANCER HAD COMPLETELY FAILED, IT COULD HAVE RESULTED IN LOSS OF STEERING AND AT HIGHWAY SPEEDS WOULD HAVE BEEN CATASTROPHIC. STEERING IS LOST BECAUSE DRIVE BELT WOULD HAVE COME LOSE. UNIT WAS REPLACED AT A COST OF $475. OLD PART WAS SAVED FOR INSPECTION. *TR

TL*THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT NOTICED THAT WHEN DRIVING, THE TRANSMISSION WAS UNABLE TO BE SHIFTED INTO SECOND OR FIFTH GEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO INFORMED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHO TOOK A COMPLAINT BUT OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 131,000.

2004 MERCURY MOUNTAINEER. TRANSMISSION FAILING 69,469 MILES ON VEHICLE. TAILGATE CRACKED ALSO. NOT SURE IF WORTH REPAIRING. *TR

I OWN A 2004 MERCURY MOUNTAINEER HAS FOUR THOUSAND MILES. THE VEHICLE WAS STORAGE IN GARAGE FOR FOUR AND HALF YEARS. I STARTED TO USE THE VEHICLE ON LAST FALL OF 2009. ON SEPTEMBER I SEE THE TAILGATE DEVELOPED A CRACK AROUND THE EMBLEM AND THE REAR GLASS. THE HEATER IS NOT WORKING ALSO. THIS IS OBVIOUS MANUFACTURE DEFECTS! *TR

TL*THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE PARKED HE NOTICED THERE WAS A CRACK BELOW THE MERCURY EMBLEM ON THE REAR LIFT GATE. THE VEHICLE WAS NOT TAKEN TO BE EXAMINED FOR THE CAUSE OF FAILURE AND WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 79,000. THE VIN WAS UNAVAILABLE.

2004 MERCURY MOUNTAINEER WITH 40K MILES HAD DRIVER SIDE UPPER AND LOWER BALL JOINT FAILURE. THIS WAS UNCOVER DURING A NORMAL STATE INSPECTION. REPLACEMENT OF BOTH JOINTS WAS REQUIRED TO SAFELY DRIVE THIS CAR. *TR

TO FORD MOTOR COMPANY (FMC) VIA WEBSITE: YOUR INQUIRY: HAS ANY MECHANIC EVERY CAME ACROSS A SITUATION SIMILAR TO MY 2004 MOUNTAINEER CRUISE CONTROL PROBLEM AS FOLLOWS: EVERY TIME I SET THE CRUISE CONTROL BETWEEN 27-45MPH AND DESCEND A HILL, THE ENGINE SHUTS DOWN! THAT'S RIGHT; NO POWER STEERING, NO POWER BRAKES, NO ENGINE RUNNING! THIS IS DEFINITELY A SAFETY/WARRANTY ISSUE TO ME? THE MERCURY SERVICE MANAGER SAID THAT HE NEVER HEARD OF SUCH A PROBLEM AND IT'S GOING TO COST ME AT LEAST $70.00, JUST FOR HIM TO FIGURE OUT WHAT'S WRONG! FROM FMC: THANK YOU FOR CONTACTING THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER REGARDING THE CRUISE CONTROL CONCERN ON YOUR 2004 MERCURY MOUNTAINEER. I SINCERELY UNDERSTAND THE FRUSTRATION THAT THIS EXPERIENCE HAS BROUGHT YOU. PLEASE BE ADVISED THAT COMPLETE VEHICLE SERVICE RECORDS ARE MAINTAINED AT THE SERVICING DEALERSHIP ONLY. AS DEALERSHIPS ARE INDEPENDENTLY OWNED AND OPERATED, WE DO NOT HAVE ACCESS TO OTHER VEHICLES' SERVICE RECORDS; THUS, CANNOT DETERMINE IF THIS IS CONSIDERED TO BE A COMMON OCCURRENCE. MOREOVER, OUR DEALERS DETERMINE HOW THE DIAGNOSTIC FEE WILL BE APPLIED WHEN ASSIGNING TECHNICIANS TO SERVICE VEHICLES. IN THIS INSTANCE, THE $70 DIAGNOSTIC FEE THAT WAS QUOTED TO YOU AND THE MANNER IN WHICH IT WOULD APPLY, IS A STANDARD PRACTICE FOR THIS DEALERSHIP. I INVITE YOU TO SPEAK WITH THE CUSTOMER RELATIONS MANAGER OR THE SERVICE MANAGER, AS HE/SHE WOULD BE IN THE BEST POSITION TO ADDRESS YOUR DIAGNOSTIC FEE. AT THIS TIME, I RECOMMEND THAT YOUR VEHICLE BE INSPECTED BY A LINCOLN-MERCURY DEALERSHIP TO DETERMINE THE CAUSE OF ANY SYMPTOMS YOUR VEHICLE MAY BE EXPERIENCING. THEY HAVE FACTORY-TRAINED TECHNICIANS, THE MOST CURRENT ENGINEERING SERVICE INFORMATION, AND THE SPECIALIZED EQUIPMENT REQUIRED TO RESOLVE YOUR VEHICLE CONCERNS. IF THERE IS NO COVERAGE UNDER APPLICABLE WARRANTIES, RECALLS OR EXTENDED SERVICE PLANS, REPAIRS AND SERVICES WOULD BE YOUR RESPONSIBILITY. MAKE AN APPOINTMENT WITH FMC DEALER. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE THE VEHICLE WAS PARKED, THE CONTACT MANUALLY CLOSED THE REAR HATCHBACK AND THE WINDOW GLASS SHATTERED UNEXPECTEDLY ONTO HER ARM. THE SMALL PIECES OF GLASS SCATTERED INSIDE AND OUTSIDE OF THE VEHICLE. THERE WAS NO PERSONAL INJURY. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN INFORMED THAT THE CAUSE OF FAILURE WAS CONTRIBUTED TO THE HATCHBACK DEFECTIVE LATCH. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS UNKNOWN.

REAR GLASS HINGE FAILURE ON 2004 MERCURY MOUNTAINEER. HINGE PIN FAILED ON MY REAR GLASS HINGE. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE VEHICLE BEGAN TO EXPERIENCE A VERY HARD SHIFT WHEN CHANGING GEARS AND DRIVING ANY SPEED. THE VEHICLE WOULD ALSO SURGE FORWARD SLIGHTLY DURING THE HARD SHIFTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT ALSO STATED THAT THE GEAR SHIFT LEVER FELT ABNORMALLY LOOSE WHENEVER OPERATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 3/7/11 *CN UPDATED 03/14/11

I HAVE A USED 2004 MERCURY MOUNTAINEER I PURCHASED IN 12/2008 IT HAD 53,000 MILES. I HAVE DONE ALL OF THE REQUIRED MAINTENANCE OIL CHANGES,BRAKE PADS,FLUID CHANGES, AND 60,000-MILE SERVICE PACKAGE. I HAVE NOTHING BUT PROBLEMS WITH THE VEHICLE. THE FAILURES I HAVE ARE AS FOLLOWS: 1. FRONT/REAR BRAKE PADS,FRONT/REAR ROTORS,SPARK PLUGS,-DEFECTED PARTS 2. BATTERY 3. TIRES-CONSTANT FLATS 4. LUG TORQUE-DRIVER FRONT/REAR 5. HOOD SHOCKS,TIRE PRESSURE SENSOR LIGHT 6. TRANSMISSION FLUID LEAK/ FRONT PUMP SEAL LEAK 7. NOISE AT HARMONIC BALANCER 8. ROAR NOISE AND SHAKES AT ALL SPEEDS 9. HUB ASSEMBLIES MAKING NOISE FRONT LEFT/RIGHT SIDE; UNLESS REPLACED VEHICLE UNSAFE TO DRIVE PER FORD DEALERSHIP 10. BRAKE PADS- FRONT/REAR NEED TO BE REPLACED GOING BAD (SECOND TIME NEEDING TO BE REPLACED) 11. NEEDS FRONT ALIGNMENT-PULLS TO THE RIGHT SIDE 12. FUEL FILTER 13. NEEDS ALL NEW TIRES 14. IGNITION COIL -DEFECTIVE NEEDS TO BE REPLACED 15. VEHICLE GEAR SHIFTER IS STUCK WHILE DRIVING WON'T SHIFT AT ALL SOMETIMES STAYS STUCK AT CERTAIN SPEED WON'T MOVE 16.UNIVERSAL JOINTS 17. AXLE HOUSING GASKET REPAIRS AND CORRECTIONS DONE ON VEHICLE: 1.NEW BRAKE PADS ON FRONT/REAR,REPLACED SPARK PLUGS, RESURFACED FRONT/REAR ROTORS.- 8/2009 2.BATTERY REPLACED- 4/2010 3.TIRES-FLATS REPAIRED/PATCHED -8/2010,11/2010,2/2011 4.HAVE NOT REPAIRED/REPLACED 5.HAVE NOT REPAIRED/REPLACED 6.REPLACED SEAL, TRANSMISSION FILTER AND FLUID CHANGED,REPLACED SEAL-OIL-6/2011 7.HAVE NOT REPAIRED/REPLACED 8. VEHICLE IS SHAKING AND LOUD ROAR NOISE HASN'T BEEN FIXED-6/2011 9.HUB ASSEMBLIES FRONT LEFT/RIGHT SIDE REPLACED -6/2011 10.HAVE NOT REPLACED/REPAIRED 11.HAVE NOT REPLACED/REPAIRED 12.FUEL FILTER REPLACED-6/2011 13. BOUGHT BRAND NEW SET OF TIRES -6/2011 14.IGNITION COIL REPLACED-10/2009 15. HAVE NOT REPAIRED/REPLACED 16. HAVE NOT REPAIRED/REPLACED 17. AXLE HOUSING GASKET REPLACED-04/2011. *TR

GLASS LIFT GATE STRUT FROZE WHEN IT WAS OPENED WHEN I TRIED TO CLOSE IT, THE FORCE BROKE THE HINGE AT THE TOP. IF I HAD NOT IMMEDIATELY SUPPORTED THE LIFT GATE IT WOULD HAVE FALLEN. THE HINGE ON THE OTHER SIDE WAS CRACKED AND BENT AND ABOUT TO GIVE. THE EMBLEM ON THE GATE HAS ALSO BEEN CRACKED FOR QUITE AWHILE. I DID HAVE THE TRANSMISSION FLUID ISSUE ADDRESSED WHEN THE VEHICLE WAS STILL UNDER WARRANTY, BUT STILL EXPERIENCE TRANSMISSION SLAMMING INTO GEAR IN REVERSE AT VARIOUS TIMES. *TR

I DROVE A 2004 MERCURY MOUNTAINEER SUV AND AS I WAS TURNING INTO THE APARTMENT COMPLEX FROM A COMPLETE STOP, THE GAS PEDAL CLAMPED DOWN & I COULDN'T GET THE BRAKE TO WORK. MY SUV WAS TOTALED & I RAN INTO A FULL-SIZED PICK-UP TRUCK, WHICH WAS TOTALED TOO. I REPORTED THE PROBLEM TO THE POLICE & MY INSURANCE COMPANY. THE INSURANCE COMPANY TOLD ME NOT TO TELL ANYONE ELSE ABOUT IT. IT WAS LATE EVENING, SO NO KIDS WERE OUT, BUT BEING UNABLE TO CONTROL MY VEHICLE, WHICH TOTALED TWO FULL-SIZED TRUCKS IS SCARY! *TR

BRAKE LIGHT SAFETY SWITCH FAILED TWICE

TRANSMISSION REBUILD AT 100,000 MILES, 6 YRS OLD. FEEL LIKE IT IS TOO SOON TO HAVE THIS KIND OF PROBLEM. I UNDERSTAND THIS HAS BEEN A QUITE A COMMON PROBLEM TOO. THE BODY PANEL UNDER THE BACK GLASS IS ALSO CRACKED. *TR