2002 MINI Cooper Complaint Log

FAULTY POWER STEERING PUMP CAUSING A LOSS OF COMPLETE CONTROL OF THE VEHICLE. 80,000+ INCIDENTS REPORTED WITH THIS MAKE/MODEL OF VEHICLE WITH THE KNOWLEDGE OF VEHICLE MANUFACTURER. THE PUMP HAS SINCE BEEN RE-MANUFACTURED TO FIX THE ISSUES BUT MINI OF NORTH AMERICA REFUSES TO ISSUE A RECALL FOR THE SERIOUS SAFETY ASPECT OF THEIR FAILING PART. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT WAS DRIVING 20 MPH WHEN THE STEERING ASSIST FAILED. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE STEERING RACK, POWER STEERING PUMP AND THE FAN MIGHT HAVE TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 102,000.

POWER STEERING WENT OUT AT HIGHWAYS SPEEDS, AFTER 3+ HOURS OF DRIVING. AFTER COOLING DOWN FOR AN HOUR, POWER STEERING CAME BACK, BUT ONLY LASTED 5 MIN., AND WAS OUT FOR ANOTHER DAY. COMES AND GOES, DEPENDING ON HOW HOT THE WEATHER/ENGINE IS, BUT STAYS OUT LONGER AND ONLY WORKS FOR SHORT PERIODS OF TIME NOW. PLEASE ISSUE A RECALL/EXTENDED WARRANTY AS CANADA HAS SOON! *TR

POWER ASSIST PUMP FAILURE. *TR

I WAS TRYING TO GET ONTO AN OFF RAMP AND WHEN I WAS INTO THE TURN I ALMOST RAN INTO A CONCRETE BARRIER BECAUSE THE WHOLE STEERING WHEEL LOCKED UP. THE STEERING WHEEL ALWAYS LOCKS UP SOMETIMES IT WITH A FEW MILES AND OTHERS IT IS GOOD UNTIL IT LOCKS UP. VERY DANGEROUS. *TR

WHILE DRIVING STEERING BECAME STIFF. ALMOST UNABLE TO TURN WHEEL WHEN I SLOWED TO PARK. AFTER TURNING CAR OFF AND BACK ON, PROBLEM RESOLVED. STILL HAPPENS AT LEAST ONCE PER DAY USUALLY WHILE SLOWING OR DOWNSHIFTING. ALWAYS RESOLVES AFTER RESTARTING CAR. *TT

POWER STEERING FAILED AS I WAS DRIVING, UNABLE TO STEER CAR. AFTER SOME TIME, POWER RESUMED INTERMITTENTLY. *TR

I WAS DRIVING ALONG AND LOST THE POWER STEERING. IT WAS VERY DIFFICULT TO STEER. I GOT HOME PARKED THE CAR AND LET IT GO. THE NEXT MORNING IT WAS FINE. HOWEVER, THIS MORNING, 6/8/2012, IT HAPPENED AGAIN AS I WAS TURNING IN AN INTERSECTION. FORTUNATELY FOR ME THERE WEREN'T MANY CARS ON THE ROAD, AS IT WAS VERY DIFFICULT TO TURN. IF THIS HAD HAPPENED IN EVEN A SEMI-BUSY INTERSECTION, I WOULD HAVE BEEN IN TROUBLE. *JS

THE AIRBAG LIGHT WAS ON IN MY MINI. THERE WAS A RECALL ON THE CABLE TENSIONER, BUT ON MODELS OF 2003 AND ABOVE. I AM WANTING YOU TO RECONSIDER THE YEAR OF THIS RECALL TO INCLUDE 2002. I NEEDED TO REPLACE THE REP CABE F SEAT SIDE AIRBAG, REP CABLE BEL TENSIONER, CABLE STRAP, CABLE CONNECTOR, SHRINKING HOSE AND CABLE STRAP WITH BRACKET FOR A COST OF 800. THE AFFECT OF THIS DEFECT IN THE CAR IS FOR THE CAR TO BE UNABLE TO DETERMINE THE WEIGHT OF THE PASSENGER IN THE CAR IN ORDER TO DEPLOY THE AIRBAG PROPERLY. *TR

POWER STEERING PUMP STOPPED FUNCTIONING MAKING CAR UNSAFE TO DRIVE. *TR

I WAS DRIVING THE CAR IN LACEY WA. SMOKE STARTED ISSUING FROM THE CAR. I IMMEDIATELY PULLED INTO A PARKING LOT. I OPENED THE HOOD AND SMOKE WAS ISSUING FORTH. AFTER 5 MINUTES, I SPOTTED FLAMES. I HAD A SMALL FIRE EXTINGUISHER BUT IT WAS INSUFFICIENT TO PUT OUT THE FLAMES. A PASSING MOTORIST ARRIVED WITH A LARGER EXTINGUISHER AND PUT OUT THE FLAMES. AN INSURANCE ADJUSTER INFORMED ME THAT THE FIRE WAS DUE TO A FAULTY POWER STEERING PUMP. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSMISSION HESITATED IN A JERKING MOTION AND BEGAN TO DOWN-SHIFT INTO ANOTHER GEAR CONTINUOUSLY. IN ADDITION, THE ENGINE WARNING INDICATOR AND EP CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED DUE TO INTERNAL DAMAGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 56,416.

THE AIRBAG SENSOR IN THE SEAT CUSHION HAS FAILED AND A WARNING LIGHT NOW PERMANENTLY SHOWS ON THE INSTRUMENT PANEL. THE PASSENGER AIRBAG MAY NOT FUNCTION AS DESIGNED. UPDATED 11/25/15*LJ UPDATED 2/5/2016 *JS UPDATED 11/07/2017*CN

EVER SINCE BUYING THIS CAR USED IN JANUARY OF 2012, THE SRS WARNING LIGHT HAS BEEN ON. THE CAR STORE WE BOUGHT THE VEHICLE FROM DID CANCEL THE CODE WHEN WE DISCOVERED IT WAS ON AFTER PURCHASE. HOWEVER, THE CODE CAME BACK. WE BROUGHT IT TO BE FIXED, AND I BELIEVE SOMEONE ELIMINATED THE COUPLER UNDER THE PASSENGER SEAT, WIRING THE SEAT TO THE ECU DIRECTLY, BY CRIMPING WIRES TOGETHER. STILL, THE LIGHT CAME BACK ON. IT HAS BEEN ON CONSTANTLY FOR OVER A YEAR NOW. I HAVE SOLDERED THE WIRES UNDER THE PASSENGER SEAT TOGETHER, AS ONE CONNECTION SEEMED BROKEN, HOPING THIS WOULD ELIMINATE THE LIGHT. I BOUGHT A CODE READER TO RESET THE LIGHT, BUT THE CODES ONLY TEMPORARILY DISAPPEAR AND AFTER BLINKING A FEW TIMES THE LIGHT IS BACK ON. I DO NOT KNOW, NOR DO I HAVE CONFIDENCE IN KNOWING, WHETHER OR NOT THE AIR BAG WOULD DEPLOY IN CASE OF AN ACCIDENT. I HOPE NEVER TO FIND OUT, OF COURSE. BUT I DO KNOW THAT THE AIR BAG LIGHT BEING ON IS A CONSISTENT AND PERSISTENT PROBLEM WITH MINI COOPERS BUILT FROM 2002 - 2006. AND I KNOW THAT THERE HAS BEEN NO RECALL, NOR AN EXTENDED WARRANTY THAT WOULD COVER WORK THAT APPARENTLY WILL COST AROUND $2,000 AT A DEALER REPAIR SHOP. WITH THE RECENT RECALL OF AIR BAGS MADE BY JAPANESE AIR BAG MAKER TAKATA, INCLUDING THOUSANDS OF BMWS MADE IN A SIMILAR TIME FRAME AS THE AIR BAGS IN MY MINI COOPER, I AM ALSO WONDERING IF THE MINI AIR BAGS ARE MADE BY TAKATA, AND SENSIBLY WORRY ABOUT THEIR SAFETY SHOULD THE IN FACT DEPLOY AS DESIGNED. BMW HAS RECALLED SOME OF THEIR OWN CARS FOR AIR BAG LIGHT ISSUES, INVOLVING SEAT SENSORS, BUT NOT ON THE MINI, EVEN THOUGH BOTH CARS USE IDENTICAL COMPONENTS. IT IS TIME FOR BMW TO TAKE OWNERSHIP OF A SERIOUS PROBLEM THE AIR BAG SYSTEMS IN THEIR EARLY MINI COOPERS. I WOULD HOPE THAT YOU CAN FORCE THE ISSUE, AS THIS CERTAINLY IS A SAFETY ISSUE WHICH EXISTS/PERSISTS ON THOUSANDS OF VEHICLES SOLD IN THE US. *TR

I WOULD LIKE TO REPORT A POWER STEERING FAILURE ON MY PREGNANT WIFE'S 2002 MINI COOPER. THE CAR ONLY HAS 61K MILES ON IT. SHE WAS DRIVING LAST NIGHT, IN THE RAIN, AND THE POWER STEERING PUMP WENT OUR AS SHE WAS ON A FREEWAY TRANSITION RAMP AT A SPEED OF 40-50 MPH. SHE ALMOST LOST CONTROL OF THE VEHICLE AND ALMOST HIT THE SIDE RAILS. FORTUNATELY SHE WAS ABLE TO AVOID CRASHING. THE POWER STEERING PUMP STARTED TO WORK INTERMITTENTLY AFTER THE CAR WAS SHUT OFF AND RESTARTED. THIS IS A HUGE SAFETY PROBLEM AND MINI/BMW NEEDS TO ADDRESS THIS PROBLEM BEFORE SOMEBODY GETS SERIOUSLY HURT OR DIES.

COMPLETE LOSS OF POWER STEERING WHILE IN ONCOMING TRAFFIC LANE DURING OVERTAKING ON TWO LANE ROAD. STEERING REQUIRED AN EXTREME AMOUNT OF EFFORT. BARELY MANAGED TO MOVE BACK TO RIGHT HAND LAND BEFORE GETTING DANGEROUSLY CLOSE TO ONCOMING TRAFFIC. POWER STEERING DID NOT RECOVER FOR ANOTHER 2.5 MINS OF DRIVING. PULLED OVER TO SIDE OF ROAD, TURNED CAR OFF, ON AGAIN, POWER STEERING RETURNED. ELECTRIC POWER STEERING PUMP NOW RUNS CONTINUOUSLY EVEN WHEN KEY IS TURNED OFF. INDICATIVE OF ELECTRIC POWER STEERING PUMP CONTROLLER FAILURE. I CONTINUE TO HAVE CONCERNS THAT POWER STEERING MAY CUT OUT AT ANY TIME AGAIN, AND THAT IF THE PUMP CONTINUES RUNNING CONSTANTLY EVEN WHEN THE KEY IS REMOVED IT MAY START A FIRE AT SOME POINT. I HAVE TO DISCONNECT THE NEGATIVE TERMINAL OF THE BATTERY TO PREVENT THE PUMP FROM RUNNING CONTINUOUSLY. *TR

POWER STEERING FAILED WHILE CAR WAS BEING DRIVEN. LUCKILY THE CAR WAS AT LOW SPEED AT THE TIME AND I WAS ABLE TO GET TO A SAFE STOP BY USING BRUTE FORCE TO STEER THE CAR. POWER STEERING THAN REAPPEARED INTERMITTENTLY OVER THE NEXT FEW DAYS, FINALLY FAILING COMPLETELY. MECHANIC SAYS POWER STEERING PUMP FAILED AND THAT IT IS A COMMON PROBLEM WITH MINIS. COST WILL BE OVER $1200 TO REPAIR. IT APPEARS THE ISSUE IS ALREADY BEING INVESTIGATED BY BMW, YET THEY HAVE TAKEN NO ACTION TO RECALL OR FIX. *TR

WHEN I LEFT MY HOME I TURNED ON THE HEATED SEATS. AS I TRAVELED APPROXIMATELY A HALF MILE I FELT LIKE BOTTOM SEAT WAS EXCEPTIONALLY HOT AND TURNED THE BOTTOM OFF . SHORTLY THEREAFTER I SMELLED SMOKE AND FOUND THAT A HOLE HAD BURNED THROUGH THE SEAT BEHIND MY BACK. THERE WAS SMOKE, A HOLE ABOUT THE SIZE OF A SILVER DOLLAR AND MY COAT HAD BEEN BURNED . MY COAT DID NOT CATCH FIRE BUT HAS A PERMANENT BLACK BURN MARK. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURER DEFECTS. THE GEAR LEVER, TRANSMISSION, BRAKE PEDAL, MOTOR, CLUTCH, FRONT AND REAR AXLES, AND THE ACCELERATOR PEDAL POSITION SENSOR WERE ALL REPLACED. THE FAILURE MILEAGE WAS 118,457.

WHILE ON A SHORT VACATION OUT OF TOWN, CLOSE TO 230 MILES FROM MY HOME, MY COOPER S' POWER STEERING FAILED AND ALMOST CAUSE ME AN ACCIDENT. I IMMEDIATELY CHECKED THE FLUID AND SAW THAT THERE WERE NO VISIBLE LEAKS PRESENT. AFTER MAKING ARRANGEMENTS FOR A RENTAL VEHICLE, I NOTICED THAT THE POWER STEERING STARTED WORKING CORRECTLY AGAIN. BECAUSE OF THAT I PROCEEDED TO RETURN HOME AND THE STEERING DID NOT FAIL FOR THE REMAINDER OF THE TRIP. DURING MARCH OF 2012, THE POWER STEERING FAILED AGAIN, DURING A COMMUTE HOME FROM WORK ON FRIDAY, MAY 3RD. TO THIS DAY, I HAVE NO BEEN ABLE TO AFFORD ADDITIONAL REPAIRS OR DIAGNOSTICS, BECAUSE OF THE MONTHLY PAYMENTS, INSURANCE, FUEL AND PREVIOUS ISSUES OF REPAIRS UNDER 75,000 MILES INCLUDING THE HEAD GASKET, AND HEATER CORE. REGARDLESS OF THE POLICIES THAT BMW/MINI AND THE NHTSA HAVE CONCERNING USED VEHICLES, AND WARRANTIES, ABSOLUTELY NO VEHICLE PRODUCED BY AN INTERNATIONALLY KNOWN COMPANY OR BUSINESS SHOULD BE PRODUCING SUCH UNRELIABLE, UNSAFE AND POTENTIALLY DANGEROUS MOTOR VEHICLES AND NOT TAKE IMMEDIATE RESPONSIBILITY TO ISOLATE AND TERMINATE THE ISSUE RATHER THAN IGNORE AND DENY RESPONSIBILITY FOR POORLY MANUFACTURED PRODUCTS. *TR

POWER STEERING FAILURE--THE POWER STEERING IN MY MINI COOPER S 2002 BEGAN "CUTTING OUT" AND BECAME MORE FREQUENT OVER A FEW DAYS. THE "CUTTING OUT" HAPPENS WITHOUT WARNING AND IS POTENTIALLY QUITE DANGEROUS AS THE VEHICLE BECOMES ALMOST UNMANAGEABLE WHEN MAKING A TURN. THIS MAKES DRIVING THE VEHICLE VERY UNSAFE. UPON RESEARCHING THIS PROBLEM, THIS IS A VERY COMMON PROBLEM WHICH WILL EVENTUALLY OCCUR WITH MOST MINI COOPERS EVEN THROUGH FAIRLY RECENT YEARS OF MANUFACTURE AND OFTEN AT FAIRLY LOW MILEAGE ACCUMULATION. *TR

LOSS OF POWER WHEN GOING 60 MPH IN THE HIGH SPEED LEFT LANE OF FOUR LANE HIGHWAY. CAR WENT INTO "LIMP MODE" AND UNABLE TO ACCELERATE. CAR WOULD ONLY GO 5 TO 10 MPH WITH LARGE TRUCK BEHIND AND BEARING DOWN ON ME. EML AND SERVICE ENGINE LIGHTS ON DASH. WAS ABLE TO PULL INTO A CONSTRUCTION LANE THAT HAPPENED TO BE RIGHT THERE. OTHERWISE WOULD HAVE BEEN UNABLE TO GET CAR OUT OF THE WAY. CAR NEEDED TO BE TOWED. FAULT CODES LIST THROTTLE BODY AND WIRING HARNESS AS PROBLEMS AND RECOMMENDATION IS TO REPLACE BOTH. FROM MY RESEARCH, THE PROBLEM IS WELL KNOWN AND RELATES TO POOR CONNECTOR BETWEEN THROTTLE BODY AND WIRING HARNESS. MINI HAS SINCE REDESIGNED THE ANGLE OF THIS CONNECTOR TO FIX THIS PROBLEM. SUCH A LOSS OF POWER WHILE DRIVING IS EXTREMELY DANGEROUS. SHOULD BE RECALL ITEM. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE POWER STEERING PUMP CONTINUED TO RUN WHILE THE ENGINE WAS TURNED OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 49,000.

TL* THE CONTACT OWNED A 2002 MINI COOPER S. WHILE DRIVING 30 MPH, THE POWER STEERING FAILED AND CAUSED EXTRA EFFORT TO TURN THE STEERING WHEEL. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ELECTRO-HYDRAULIC POWER STEERING SYSTEM AND WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,548.

THE AIRBAG WARNING LIGHT CAME ON IN MY 2002 MINI COOPER S. THE MINI DEALER SERVICE DEPARTMENT SAID THAT THE AIRBAG CONTROL UNIT WAS FAULTY...THAT THE "MRS CONTROL UNIT SHORTED". SINCE THIS IS A PIECE OF SAFETY EQUIPMENT, AND SINCE IT IS NOT A MECHANICAL DEVICE THAT WOULD BE SUBJECT TO WEAR, I BELIEVE THE DEALER SHOULD HAVE REPLACED THIS UNIT AT NO CHARGE...AND/OR AN ALERT SHOULD GO TO OTHER MINI OWNERS. I HAVE SINCE HAD THE CONTROL UNIT REPLACED (AT CONSIDERABLE EXPENSE) BECAUSE I FELT UNSAFE DRIVING WITHOUT AIRBAGS. *TR

BOUGHT THIS CAR IN 2008 AND HAVE HAD VERY FEW ISSUES. THIS MONTH (NOVEMBER 2011) THE CVT (AUTOMATIC TRANSMISSION) WENT OUT. ONLY REPAIR APPARENTLY IS "REPLACEMENT" - RECEIVING QUOTES BETWEEN 7K AND 9K FROM THE DEALER AND AAMCO. NOW FINDING OUT THIS IS A VERY COMMON PROBLEM WITH ALL MINI COOPER CVT'S. THIS IS UNACCEPTABLE. REPAIR COST NOW EXCEEDS CAR'S VALUE. WON'T DO IT. FOOL ME ONCE... SHAME ON YOU. *TR

THE POWER STEERING FAILED WHEN DRIVING. IT BECAME IMPOSSIBLE TO STEER. IT WAS AS THOUGH THE CAR STEERING BECAME LOCKED. I WAS VERY LUCKY TO HAVE A POLICE CAR STOP TO ASSIST ME TO MOVE ME TO A SAFE SPOT ON THE STREET. *TR

THIS CAR GOES INTO LIMP MODE AT VERY IN OPPORTUNE TIMES, BEFORE THIS LATEST TIME (AGAIN TO THE SHOP) IT NEARLY GOT ME T-BONED IN AN INTERSECTION, THIS CAR HAS BEEN IN THE SHOP NUMEROUS TIMES FOR ENGINE ELECTRICAL PROBLEM, THIS IS A KNOW DEFECT WITH THE WIRING HARNESS-I BELIEVE THIS SHOULD BE COVERED IN A RECALL FOR A VERY UNSAFE SITUATION. *TR

I BOUGHT A 2002 MINI COOPER S ALMOST A MONTH AGO AND LOST THE POWER TO STEER MY CAR IN A TURN AT ALMOST 50 MPH. IF TOYOTA WOULD HAVE HAD THIS PROBLEM I'M SURE SOME ONE WOULD BE IN JAIL OR MAYBE YOU WOULD HERE IT ON THE NEWS. THIS IS MY THIRD MINI IN 6 YEARS AND I NEVER HEARD A PEEP ABOUT THIS SCAREY PROBLEM. I WOULD LIKE TO THANK ARE GOVERNMENT FOR MAKING THE ROADS SO SAFE. AT LEAST THEY ARE TAKING THE EFFORT TO STOP THOSE PESKY KIDS AND THERE TEXTING. THANKS AGAIN! *TT

I WAS EXITING THE FREEWAY WHEN MY BATTERY INDICATOR LIGHT WENT ON; I LOST POWER STEERING AND SAW A LARGE AMOUNT OF SMOKE COMING FROM UNDER THE HOOD. THE MINI DEALERSHIP HAS DETERMINED THAT THE POWER STEERING MODULE FAILED, AND SUBSEQUENTLY BURNED THE WIRING HARNESS. THERE HAVE BEEN SEVERAL REPORTS OF FAULTY MANUFACTURING IN REGARD TO THIS PART FROM BBC IN UK, AS WELL AS ON MANY FORUMS, IN PARTICULAR NORTH AMERICAN MOTORING. *TR

HEARD OF POWERSTEERING ISSUE BUT STILL PURCHASED CAR. DRIVING TO WORK SMELLED BURNING AND LOST POWERSTEERING, IF THIS HAPPENS TO A WOMAN DRIVING AROUND A ROTARY AND KILLS SOMEONE WILL YOU WAIT FOR 50 PEOPLE TO GET KILLED BEFORE SOMETHING IS DONE. THIS IS COMPLETE INADEQUATE RESEARCH ON YOUR PART FORD RECALLS DUE TO ELECTRICALSHORT OF THE IDLE AIR CONTROL VALVE AND CRUISE CONTROL CUT PRESSURE SWITCH HAD TO BURN DOWN HOUSES WHEN THEY HAD THE CRUISE CONTROL ISSUE WHICH NO RECALL TILL MONTHS AFTER THEY KNEW IT WAS A FAULT. BY THE WAY I AM A MECHANIC ASE CERTIFIED OWN A SHOP IN WAKEFIELD [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER AN APPARENT SHORT OUT OF THE ANTI-LOCK BRAKING SYSTEM A FIRE OCCURRED SHORTLY AFTER TWO TO FIVE MINUTE LATER THE CAR WAS COMPLETELY ENGULFED IN FLAMES. FIFTEEN MINUTES LATER THE CAR WAS COMPLETELY GONE, CALIFORNIA HIGHWAY PATROL AS WELL AS KEYS CITY FIRE DEPARTMENT BOTH GAVE THEIR CONCLUSION OF THE CAR BEING ABSOLUTELY TOTALED. LUCKILY I WAS ABLE TO GET THE CAR STOPPED AND OFF TO THE SIDE OF THE HIGHWAY AND WAS ABLE TO EVACUATE THE VEHICLE. *TR

THERE HAVE BEEN THREE INSTANCES WHEN MY POWER STEERING WENT OUT ON ME...I COULD HAVE HAD AN ACCIDENT HAD I NOT BEEN IN A RESIDENTIAL AREA DURING THOSE TIMES. *TR

POWER STEERING FAILED WHILE GOING DOWN A MULTI-STORY PARKING LOT. VERY SCARY. CAR CORRECTED ITSELF. LATER THAT DAY IT HAPPENED AGAIN. CALLED MY MECHANIC (A MINI MECHANIC) AND WAS TOLD THIS HAPPENS ALL THE TIME WITH 2002-2005 MINI COOPERS. WILL NEED TO REPLACE PUMP AND FAN WHICH WILL COST ME $1200 INC. LABOR. THIS IS A PROBLEM THAT MINI USA IS VERY AWARE OF. THEY RELEASED A CAR WITH KNOWN PROBLEMS (INC. CVT TRANSMISSION ISSUES) HOW CAN THEY DO THIS? SO FAR O ONE HAS BEEN KILLED (THAT WE KNOW OF) BUT I KNOW IT WILL HAPPEN ONE DAY. THIS IS A VERY DANGEROUS ISSUE. *TR

DRIVING TO WORK 4 MILE TRIP POWER STEERING RANDOMLY STOPS WORKING ALMOST LOCKING UP THE STEERING WHEEL. TRIED TO PULL OVER TO THE SIDE OF THE ROAD A FULL GROWN MAN STRUGGLES TO BE ABLE TO TURN THE WHEEL ABOUT A QUARTER OF A TURN. SHUT OFF CAR WAIT TO START BACK UP. POWER STEERING STILL DEAD CALL TOW TRUCK AND HAVE IT HAULED TO REPAIR SHOP. TOLD POWER STEERING PUMP HAS DIED AND NEEDS REPLACED ALONG WITH POWER STEERING PUMP FAN. *KB

ON 13 JUNE 2011 A POWER STEERING FAN SHORTED ON MY DAUHTERS 2002 MINI COOPER S CAUSING THE RADIATOR FAN TO STOP. THIS CAUSED THE CAR TO OVERHEAT. ON 14 JUNE 2011 CAR WAS REPAIRED BY A MINI COOPER DEALER AFTER BEING TOWED. PARTS REPLACED ARE FAN HOUSING WITH FAN, FAN WITH PROTECTING GRILLE, WIRING SET FOR POWER SUPPLY, CABLE STRAP. POWER STEERING FAN SEIZED CAUSING COOLING FANS NOT TO WORK. DEALER REPLACED WIRING HARNESS (UPDATED) TO KEEP POWER STEERING FAN AND COOLING FANS SEPERATE (AS TOLD BY SERVICE REP). OLD PARTS WHERE NOT KEPT. THIS HAPPENED ONCE. *TT

AIR BAG WARNING LIGHT STAYS ILLUMINATED AFTER PASSENGER SEAT WAS MOVED. LIGHT WILL NOT TURN OFF. *TR

TL*THE CONTACT OWNS A 2002 BMW MINI COOPER. THE CONTACT STATED THE STEERING FAILED WHILE DRIVING AT A LOW SPEED AND HAD TO BE HELD WITH FORCE WITH BOTH HANDS IN ORDER TO TURN IT, OR KEEP THE VEHICLE UNDER CONTROL. THERE WERE NO WARNING LIGHTS BEFORE OR AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC TEST THAT LOCATED THE FAILURE IN THE POWER STEERING PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THE FAILURE WAS NOT RECALLED, AND THEY WOULD NOT ASSIST WITH THE REPAIR. THE FAILURE AND THE CURRENT MILES WERE 114,000. UPDATED 07/20/11*LJ THE CONSUMER STATED THE VEHICLE THEN BEGAN TO MAKE A HUMMING SOUND IN WHICH THE POWER STEERING PUMP WAS RUNNING WHEN THE VEHICLE WAS OFF, WHICH CAUSED THE BATTERY TO DIE. UPDATED 08/01/11

DRIVING APPROXIMATELY 25 MPH AND VEHICLE LOST POWER STEERING....MADE IT HOME...CHECKED ALL FLUID LEVELS...ALL OKAY....GOT BACK IN THE VEHICLE THE NEXT MORNING TO TAKE TO SERVICE STATION AND POWER STEERING WAS WORKING AGAIN...GARAGE COULD NOT FIND PROBLEM...SCARED TO DRIVE IT NOW FOR FEAR OF LOSS OF STEERING AGAIN! *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH A SUDDEN LOSS OF POWER STEERING OCCURRED WITHOUT PRIOR WARNING. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD WITH DIFFICULTY IN TURNING THE STEERING WHEEL. THE CONTACT RESTARTED THE ENGINE AND WAS ABLE TO RESUME NORMALLY. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE POWER STEERING PUMP WOULD BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000. UPDATED 07/08/11 *BF THE CONSUMER STATED THE POWER STEERING GOES OUT INTERMITTENTLY AT RANDOM TIMES. UPDATED 07/18/11

I WAS DRIVING FROM EAST LOS ANGELES TO WEST LOS ANGELES (PLAYA DEL RAY) ON THE 105 WEST HGWY WHEN THE CARS TRANSMISSION WENT OUT. THIS HAPPENED IN THE MIDDLE OF THE FREEWAY IN LA DURING RUSH HOUR. I HAD TO SLOWLY MOVE OVER TO THE RIGHT HAND SIDE OF THE HIGHWAY UNTIL I COULD FIND AN AREA WITH A SHOULDER. I BARELY MADE IT TO THE SHOULDER AND COULD HAVE DIED FROM ONE OF THE CARS SPEEDING PAST ME. LUCKILY I MADE IT. I CALLED AAA AND THEY BROUGHT A TOW TRUCK WHICH TOWED THE CAR INTO A SHOP WHICH STATED THAT THEY WOULD NOT BE ABLE TO REBUILD THE TRANSMISSION. THEY SAID I WOULD HAVE TO REPLACE THE WHOLE THING WHICH WOULD COST $7,000 MINIMUM. I CALLED MULTIPLE OTHER DEALERS AND SHOPS, WHOM ALL GAVE THE SAME ESTIMATE. I DONATED IT TO MY LOCAL NPR STATION BECAUSE I DID NOT WANT TO PAY THAT AMOUNT OF MONEY TO REPLACE A FAULTY TRANSMISSION, WITH ANOTHER FAULTY TRANSMISSION. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPERS. THE CONTACT WAS DRIVING 40 MPH WHEN THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO A MECHANIC SHOP WHERE THEY INFORMED HIM THAT THE FUSE THAT CONTROLLED THE POWER STEERING CHARGING SYSTEM HAD BLOWN. THE COMPONENT WAS REPLACED AT A THE CONTACTS EXPENSE. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 36,000. UPDAT ED 06/03/11 *BF UPDATED 08/08/11

POWER STEERING PUMP IN 2002 MINI COOPER FAILED WHILE MAKING A RIGHT HAND RUN, CAUSED ME TO DRIFT INTO THE ONCOMING LANE, ALMOST HITTING THE ONCOMING TRAFFIC. *TR

POWER SYSTEM ON MY 2002 MINI COOPER WENT OUT. THIS SEEMS TO BE A COMMON OCCURRENCE. AND VERY DANGEROUS AND COSTLY. BMW HAD BETTER DO SOMETHING ABOUT THIS BECAUSE I ALMOST CREAMED A COP... *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO MAKE A LEFT OR RIGHT TURN THE STEERING WHEEL WAS DIFFICULT TO TURN. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND THE CURRENT MILEAGE WAS 82,426. UPDATED 05/03/11*LJ UPDATED 05/16/11

A FIRE WAS CAUSED BY THE FAILURE OF THE POWER STEERING COOLING FAN. AT SOME POINT THE DAY OF THE INCIDENT THE FAN SEIZED AND THE RESULTING ELECTRICAL RESISTANCE IN THE MAIN WIRING HARNESS CAUSED THE WIRING HARNESS TO HEAT TO A POINT OF MELTING SOME OF THE PLASTIC WIRE INSULATION ALLOWING FOR DIRECT WIRE TO WIRE CONTACT AND RESULTED IN AN ELECTRICAL FIRE BETWEEN THE ENGINE AND THE PASSENGER COMPARTMENT. THE RESULTING FIRE COMPLETELY DISABLED THE VEHICLE'S ELECTRICAL SYSTEM AND REQUIRES AT MINIMUM THE REPLACEMENT OF THE ENTIRE MAIN WIRING HARNESS. EVENT DESCRIPTION AFTER A SHORT DRIVE (LESS THAN 2 MILES ON A COLD ENGINE) THE VEHICLE WAS PARKED. AFTER THE ENGINE WAS TURNED OFF SMOKE WAS SEEN RISING FROM THE VEHICLE ENGINE COMPARTMENT. UPON RAISING THE HOOD, FLAMES WERE SEEN BETWEEN THE ENGINE AND THE PASSENGER COMPARTMENT REFLECTING OFF BOTH FIRE WALLS. 2 FIRE EXTINGUISHERS WERE REQUIRED TO PUT OUT THE FLAMES AFTER THE BATTERY WAS DISCONNECTED. TOTAL LOSS OF THE VEHICLE TO FIRE WAS PREVENTED BY THE OWNERS ACTIONS.

AFTER PICKING MY SISTER UP FROM THE TRAIN STATION I NOTICED A LOSS OF POWER STEERING. STEERING IS NOW VERY DIFFICULT AROUND CORNERS AND IN CITY DRIVING. NO REPAIRS MADE YET. *TR

POWER STEERING FAILURE. THIS OCCURS INTERMITTENTLY. MOST RECENTLY, LAST WEEK, IT WAS OUT FOR 3 DAYS AND THEN IT STARTED WORKING AGAIN. *TR

I BOUGHT A 2002 MINI COOPER AND WHILE DRIVING THE POWER STERERING QUIT WORKING. I CONTACTED A MINI REPAIR SHOP AND FOUND THAT THE POWER STEERING PUMP IS ELECTRIC AND IT'S RELAY OR OR ONE FOR IT'S COOLING FAN MIGHT HAVE FAILED. THEY TOLD ME THAT IT IS VERY COMMON AND WOULD COST OVER $1000. TO FIX IT. HAD I BEEN IN THE WRONG MODE OF DRIVING THIS FAILURE COULD HAVE KILLED ME. *TR

THE CAR HAS GONE BACK TO A MINI DEALER 4 TIMES SINCE WE'VE OWNED THE CAR BECAUSE OF THE AIR BAG LIGHT ON. LITTLE DID WE REALIZE WHEN WE TOOK IT ON A TRIP TO FLORIDA, THE WHOLE SYSTEM WAS SHUT DOWN. TOOK IT TO A MINI DEALER IN FLA. ON FEB. 15, 2012.....$2126.04 LATER. DROVE IT HOME TO HAVE THE LIGHT GO ON AGAIN , TOOK IT TO MINI OF BEDFORD, NH ON 5/28/13, PICKED IT UP ON 6/4/2013.....$1527.09 LATER. DROVE IT HOME ON 6/4/2013, ONLY TO HAVE THE LIGHT GO BACK ON APPROX 6/10/2013. AAA HAD TO USE A RAMP TRUCK TO BRING IT BACK TO BEDFORD, NH.....BECAUSE THE DRIVERS SEAT TIPPED OVER BACKWARDS WHILE DRIVING & ALMOST CAUSED A SERIOUS COLLISION. ALSO THERE IS A NEW PROBLEM WITH STEERING WHEEL. BOTH LATER ISSUES OCCURRED AFTER THEY HAD TORN IT APART IN DEALERSHIP & KEPT IT FOR A WEEK "FIXING THE PROBLEM". NOW IT SITS AT MINI OF BEDFORD..& THEY ARE TELLING US ANOTHER AIRBAG SENSOR HAS TO BE REPLACED...IT NEED A NEW SEAT....AND THEY'RE NOT SURE ABOUT THE STEERING WHEEL, BECAUSE THEY CAN'T TEST UNTIL THEY PUT IN A NEW SEAT. EVERYTHING IS ON HOLD AT THE MOMENT...#1 WE CAN'T KEEP PAYING FOR SHODDY WORKMANSHIP...#2 WE ARE VERY CONCERNED ABOUT THE SAFETY OF THIS CAR. HAVE BEEN READING SOME WEBSITES & SEE STORIES SIMILAR TO THIS AIR BAG PROBLEM. *TR