2002 MINI Cooper

The contact owns a 2002 Mini Cooper S. The contact stated that while driving approximately 45-55 MPH, the steering wheel seized. There was no warning light illuminated. The vehicle was coasted to the side of the road. The contact restarted the vehicle and continued driving normally. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V660000 (STEERING). The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 43,000.

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WAY TO RESOLVE IT. I NOW CAN'T SELL THIS VEHICLE EITHER BECAUSE IT WOULD BE MORALLY WRONG TO PASS THIS PROBLEM ON TO A NEW OWNER. I CAN'T AFFORD THIS KIND OF SAFETY AND FINANCIAL PROBLEM. I NEED HELP TO GET THIS WORK DONE AND MINI COOPER CALLED ME AFTER MY INQUIRY AND SAID I AM BASICALLY OUT OF LUCK. THEY HAVE NO RESOLUTION FOR ME OR ANY OTHER MINI COOPER OWNERS THAT LIVE IN RURAL STATES AND ARE NOT NEAR A CERTIFIED DEALERSHIP. I NEED THIS REPAIRED AND AM HOPING YOU CAN HELP ME AND ALL THE OTHER MINI COOPER OWNERS IN THIS DANGEROUS SITUATION. THE NUMBER THE MINI REPRESENTATIVE CALLED ME FROM WAS 800-831-1117.

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

THE VIN # OF MY 2002 MINI COOPER S WAS NOT INCLUDED IN THE RECALL FOR THE ELECTROHYDRAULIC STEERING FAILURE OF 2002 - 2005 MINI COOPER S BUT I AM EXPERIENCING THE EXACT ISSUE OUTLINED IN THIS RECALL. THE STEERING IS INCREDIBLY HARD TO TURN WHEN PARKED, AS WELL AS WHILE DRIVING. I NOTICED THAT THE RECALL HAD ABOUT 339 COMPLAINTS AND ROUGHLY 85,000 VEHICLES WERE RECALLED, SO MAYBE AT THE TIME NO ONE WITH A SIMILAR VIN AS ME COMPLAINED.

PURCHASED THIS CAR USED WITH LOW MILES. SHORTLY AFTER PURCHASE I NOTICED THE STEERING ON MY VEHICLE GOT A LITTLE HARDER TO STEER, DIDN'T THINK TO MUCH ABOUT IT. THEN THE RADIATOR FAN WOULD NOT TURN OFF WHEN THE VEHICLE WAS OFF. TOOK THE CAR IN TO TWO DIFFERENT MECHANICS TO FIND THE PROBLEM. FOUND OUT IT WAS THE POWER STEERING PUMP WENT OUT CAUSING THE COOLANT RESERVOIR TO GO OUT. THIS COULD CAUSE EXTREME SAFETY HAZARDS WHEN DRIVING ON THE FREEWAY AND THE STEERING FREEZES!! I CONTACTED BMW AFTER HEARING THERE WAS A RECALL FOR THIS SAME PROBLEM. I WAS TOLD WE MISSED THE RECALL TIME FRAME. I HAVE LOW MILES, 60,000. THE RECALL EXPIRED IN 2017. WELL, MY CARE WAS NOT HAVING THE ISSUES. I DON'T FEEL COMFORTABLE SELLING THE CAR AND HANDING THE PROBLEM TO ANOTHER CONSUMER. THIS RECALL SHOULD BE EXTENDED AS IT COULD BE AN UNPLEASANT RESULT.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

POWER STEERING SUDDENLY STOPPED WORKING. MAKING A WHINING NOISE WHEN TURNING THE WHEEL AND THE STEERING WHEEL ITSELF IS HARD TO TURN. NOT LEAKING ANY FLUIDS AND THE POWER STEERING FLUID IN THE RESERVOIR IS FULL.

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2002 MINI COOPER S. AFTER PLACING THE VEHICLE IN REVERSE, THE CONTACT SWITCHED GEARS INTO DRIVE. WHEN ATTEMPTING TO ACCELERATE FORWARD, THE POWER STEERING FAILED. THE CONTACT ADDED POWER STEERING FLUID AND MADE ANOTHER ATTEMPT TO STEER THE VEHICLE; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE POWER STEERING WAS NO LONGER COVERED UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

AT 140,000 MILE: + AIR BAG LIGHT CAME ON. DEALER SAID THAT THE AIRBAG COMPUTER MODULE WILL COST $1,000 TO REPLACE. I SEE ON-LINE BLOGS AND NHTSA HAVE HAD NUMEROUS COMPLAINTS ON THE AIR BAG DASH LIGHT COMING ON AND NHTSA IS STILL INVESTIGATING.

THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BAG AND ABS COST WILL BE $2,000

TL* THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) AND THE DEALER SCHEDULED A REPAIR APPOINTMENT. THE DEALER LATER CANCELED THE APPOINTMENT, STATING THAT THE PART WAS NOT AVAILABLE. THE CONTACT HAD NOT BEEN ABLE TO RECEIVE THE RECALL REPAIR REMEDY FOR MONTHS. THE MANUFACTURER WAS UNABLE TO PROVIDE A DATE THAT THE PART WOULD BE SUPPLIED TO THE DEALER. THE CONTACT WAS NOT EXPERIENCING A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. ...UPDATED 04/12/16 *BF

TL* THE CONTACT OWNS A 2002 MINI COOPER S. WHILE DRIVING AT 60 MPH AND ATTEMPTING TO AVOID HITTING AN ANIMAL, THE STEERING WHEEL SEIZED WITHOUT WARNING AND THE VEHICLE STRUCK THE ANIMAL. THE AIR BAGS DID NOT DEPLOY; HOWEVER, THE AIR BAG WARNING LIGHT ILLUMINATED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED AT 865-693-4553 AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT STATED THAT WHEN THE STEERING WHEEL WAS TURNED TO THE RIGHT, THERE WAS AN ABNORMAL NOISE AND IT WAS DIFFICULT TO MAKE THE TURN. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE DEALER WAS NOTIFIED OF THE FAILURE AND THE MANUFACTURER WHO INDICATED THAT THE CONTACT WOULD NEED TO WAIT FOR A SECOND NOTIFICATION LETTER TO DETERMINE WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT WAS WAITING FOR MONTHS AS THE FAILURE PROGRESSED AND WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS UNABLE TO PROVIDE A TIME FRAME FOR THE PARTS TO BECOME AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.