2005 MINI Cooper Complaint Log

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT OBSERVED FLUID LEAKING FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING HOSES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE POWER STEERING PUMP FAILED PREVIOUSLY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 70,000.

ABOUT A MONTH AGO VEHICLE STEERING BECAME VERY DIFFICULT. VEHICLE HAS 117,650 MILES ON IT. DRIVING IS VERY DIFFICULT AS STEERING IS VERY HEAVY. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE POWER STEERING ABILITY HAD NOT RETURNED FOR ONE MONTH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT AN ELECTRO HYDRAULIC STEERING SYSTEM WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING), BUT THE VIN WAS EXCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

POWER STEERING ISSUES: MINI COOPER CONVERTIBLE 2005. THE FIRST EVIDENCE OF MY PROBLEM WAS WHEN THE ELECTRICAL SYSTEM SEEMED TO BE FAULTY. I REPLACED THE ALTERNATOR, AND THAT FIXED THE CAR FOR ABOUT TWO WEEKS. AT THAT POINT, I NOTICED A FAN RUNNING A LOT, AND THEN FOUND THE BATTERY DEAD ON SEVERAL OCCASIONS. FINALLY, I FIGURED OUT THAT A FAN WAS CONTINUING TO RUN--AND I TRACED THE NOISE TO THE POWER STEERING PUMP. I DISCONNECTED THE BATTERY, AND THEN DROVE TO THE SHOP. THEY REPLACED THE POWER STEERING COOLING FAN. THIS SOLVED THE PROBLEM FOR ABOUT THREE MONTHS. THIS WEEKEND, I PARALLEL PARKED IN A TIGHT SPACE WITH A SLIGHT DIP. I REALIZED WHILE PARKING THAT I SUDDENLY HAD NO POWER STEERING, BUT I THOUGHT IT WAS BECAUSE OF THE WAY I PARKED. IT DID NOT GET BETTER AS I LEFT. I MUSCLED THE CAR OUT OF THE SPACE, AND DROVE IT TO MY LOCAL SHOP, WHERE THEY TOLD ME THAT THE FAN STILL WORKED, THAT THE FUSES STILL WORKED, BUT THAT THE POWER STEERING PUMP HAD FAILED. HAD ALREADY READ EXTENSIVELY ABOUT POWER STEERING PUMP FAILURE ISSUES WHEN I HEARD THE FAN RUNNING IN THE FIRST PLACE. BUT... I THOUGHT AFTER A FEW MONTHS THAT I WAS LUCKY TO AVOID THE PUMP FAILURE--IN CATCHING THE FAN FIRST-- BUT IT SEEMS THAT MANY HERE HAVE DESCRIBED. EXACTLY THE SAME TRAJECTORY. I CALLED MINIUSA AND A LOCAL DEALER, AND THEY REFUSE TO HELP, BECAUSE MY CAR'S MANUFACTURE DATE IS A LITTLE UNDER TWO MONTHS PAST THE DATE INCLUDED IN THE "EXTENDED WARRANTY NOTICE". THIS IS RIDICULOUS! IT IS EXACTLY THE SAME PROBLEM DESCRIBED IN THE RECALL, IN EVERY DETAIL, AND IT IS A SAFETY ISSUE. I AM EXTREMELY LUCKY I WAS NOT HURT BY IT. I FILED A FORMAL COMPLAINT DIRECTLY WITH MINI USA. IF I FELT IT WERE FOR LACK OF MAINTENANCE, OR NORMAL WEAR AND TEAR, I COULD ACCEPT THAT, BUT THIS CAR HAS METICULOUS MAINTENANCE, AND RECORDS TO BACK IT UP.

I HAVE HAD THE STEERING PUMP FAIL TWICE IN MY 2005 R53 MINI, THE 1ST TIME THE POWER STEERING WOULD CUT OUT AT RANDOM WHILE DRIVING AND THE PUMP WOULD CONTINUED TO RUN AFTER CAR WAS TURNED OFF (HAD TO DISCONNECT BATTERY FOR IT TO STOP). THIS WAS REPLACED IN 2013 AT A MINI DEALERSHIP UNDER AN "EXTENDED WARRANTY" AT THE EXPENSE OF MINI. NOW 3 YEARS LATER I AM HAVING THE SAME SYMPTOMS, THE POWER STEERING CUT OUT ON WHILE CHANGING LANES ON THE HIGHWAY AND THEN THE PUMP CONTINUED TO RUN WHEN I ARRIVED HOME AND TURNED THE CAR OFF (HAD TO DISCONNECT BATTERY). THE NEXT DAY THE STEERING PUMP ACTUALLY BURNT ITSELF OUT (SMOKED) WHILE THE CAR WAS IDLING IN THE DRIVEWAY. I UNDERSTAND MINI HAS ISSUED A MORE EXTENSIVE RECALL HOWEVER SINCE MINE WAS "FIXED" ALREADY I AM NOT COVERED - IT SEEMS AS THOUGH THE REPLACEMENT PARTS ARE JUST AS FAULTY AS THOSE THEY HAVE REPLACED AND WILL MOST LIKELY EXPERIENCE THE SAME DANGEROUS FAILURE. *TR

MY VEHICLE CAUGHT FIRE WHILE PARKED DIRECTLY AFTER DRIVING IT SIX MILES, SAVED BY FIRE EXTINGUISHER AND FIRE DEPARTMENT. CAUSE DETERMINED TO BE FAULTY POWER STEERING MODULE.

TL* THE CONTACT OWNS A 2005 MINI COOPER CONVERTIBLE. THE CONTACT STATED THAT THE STEERING UNIT FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING FAN AND STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE FAILURE MILEAGE WAS APPROXIMATELY 145,000. ...UPDATED 01/05/17 *BF *TR

ELECTRO-HYDRAULIC POWER STEERING SYSTEM RECALL. MINI COMPANY AND DEALERSHIP REFUSE TO TOW OUR CAR FOR REPAIR. WE RECENTLY EXPERIENCED THIS ISSUE OF STEERING "FREEZING UP" - SEVERELY LIMITED, ON THE HIGHWAY, WHICH WAS SCARY AND DID NOT FEEL SAFE. ALL DEALERSHIPS REQUIRE DRIVING ON THE HIGHWAY FROM OUR HOME. DEALERSHIP STATED THAT IT WAS SAFE TO DRIVE, BUT I DO NOT AGREE, HAVING EXPERIENCED THE PROBLEM FIRST HAND. MINI REFUSES TO TOW BECAUSE IT WAS NOT PART OF THE RECALL. PLEASE NOTE: INCIDENT DATE IS AN ESTIMATE. WILL GET ACTUAL DATE ASAP. NOTE: THIS STEERING LIMITATION HAS ALSO HAPPENED LAST WINTER WHEN TRYING TO STEER THE CAR OUT OF A PARKING SPOT. I WAS NOT ABLE TO MOVE THE STEERING WHEEL (1/16). CALLED DEALERSHIP, BUT DID NOT HAVE NEW PART IN STOCK YET AND DID NOT KNOW WHEN IT WOULD BE AVAILABLE. CAR DID NOT DO IT THE NEXT TIME (FEW DAYS LATER). DEALERSHIP NEVER CONTACTED US TO ALERT THE PART WAS AVAILABLE (AS IT NOW IS).

THE POWER STEERING GOES IN AND OUT. SOMETIMES IT STEERS PROPERLY AND SOMETIMES IT IS LIKE TURNING A TRUCK. HAPPENS BOTH WHILE STATIONARY AND WHEN MOVING.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT THE POWER STEERING FAILED INTERMITTENTLY AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DIAGNOSIS. IT WAS UNKNOWN IF THE VEHICLE WAS REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

COMPLETE POWER STEERING FAILURE ON MY WAY TO WORK THIS MORNING WHILE TURNING A CORNER FROM THE HIGHWAY TO CITY STREET. I FOUND AN OPEN SAFETY RECALL DEC 2015 FOR 2005 MODEL MINI COOPER S BUT MY 2005 VIN IS NOT INCLUDED. IT SEEMS A MAJOR SAFETY CONCERN LIKE THIS WOULD BE TAKEN CARE OF BY THE OEM.

FRONT DRIVER SEAT OCCUPANT DETECTION MAT DOESN'T SEEM TO BE WORKING CORRECTLY AS IT DOESN'T DETECT SOMETIMES WHEN THERE IS AN OCCUPANT. SECOND ISSUE IS THE CVT TRANSMISSION OF THIS VEHICLE. I GET A JERKING MOTION EVERY NOW AND THEN AND FOUND A CLASS ACTION LAWSUIT LINKED WITH THESE TRANSMISSIONS. I PURCHASED THIS CAR AFTER THIS LAWSUIT BUT APPARENTLY THIS PARTICULAR VEHICLE WAS NOT TAKEN CARE OF. MY VEHICLE ONLY HAS 70,000 MILES ON IT AND FIND THIS UNACCEPTABLE.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING 35 MPH, THE VEHICLE LOST POWER STEERING ABILITY WITHOUT WARNING AND BECAME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP FAILED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 131,000. UPDATED 07/12/16*LJ UPDATED 07/14/16.*JB

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MINI COOPER. WITHOUT WARNING, THE STEERING WHEEL WAS TIGHT, EXTREMELY DIFFICULT TO TURN, AND SEIZED SEVERAL TIMES. THE CONTACT HAD TO USE EXTREME FORCE TO MANEUVER THE VEHICLE EACH TIME THE FAILURE PROGRESSED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. PARTS DISTRIBUTION DISCONNECT. UPDATED 08/03/16*LJ UPDATED 08/09/16.*JB *CN

ELECTRO/HYDRAULIC POWER STEERING UNIT FAILURE @ 87,000 MILES . UNIT WILL NOT SHUT OFF UNLESS THE BATTERY CABLE IS DISCONNECTED. MINI USA REFUSES TO COVER THE PART UNDER THE CURRENT RECALL.

THERE IS A POWER STEERING PUMP RECALL FOR THIS MODEL (NHTSA CAMPAIGN NUMBER: 15V660000) BUT THE DATE CUTOFF IS FOR CARS PRODUCED BY FEBRUARY OF THE 2005 MODEL YEAR. MY CAR (2005 MINI COOPER S WITH 86,000 MILES) HAS A PRODUCTION DATE OF JUNE 2005 AND IS NOT ELIGIBLE FOR THE RECALL. THE POWER STEERING PUMP HAS FAILED MAKING STEERING DIFFICULT AND MORE ERRATIC. STEERING NOW REQUIRES SUBSTANTIALLY MORE FORCE, SO MY WIFE IS CURRENTLY UNABLE TO DRIVE THE CAR WITHOUT CONCERNS FOR HER OWN SAFETY. IF THE MANUFACTURER FEELS THAT THE PART THEY USED AFTER FEBRUARY 2005 WAS NOT SUBJECT TO THIS "GLITCH", THEN WHY IS THE PART MALFUNCTIONING IN THE SAME MANNER AS THE ADMITTEDLY FAULTY PART?

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, IT WAS DIFFICULT TO TURN THE STEERING WHEEL. THE CONTACT STATED THAT THE POWER STEERING ASSIST FUNCTION FAILED TO OPERATE AS INTENDED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ELECTRO HYDRO POWER STEERING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

THE POWER STEERING HAS FAILED IN THIS VEHICLE. MINI COOPER HAS A RECALL ON THIS MAKE, MODEL AND YEAR BUT SAYS MY VIN IS NOT INCLUDED. MECHANIC STATED POWER STEERING UNIT NEEDS TO BE REPLACED.

TRANSMISSION WENT OUT AT 60K MILES BECAUSE OF THE WAY IT'S MADE IT HAD TO BE COMPLETELY REPLACED. MANY MANY COMPLAINTS ABOUT THIS FAULTY TRANSMISSION. BMW HAS TO PAY FOR IT.

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MINI COOPER CONVERTIBLE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR NHTSA CAMPAIGN NUMBER: 15V505000 (AIR BAGS). THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS, BUT THE AIR BAG LIGHT REMAINED ILLUMINATED. THE DEALER INDICATED THAT THE VEHICLE NEEDED TO BE TAKEN BACK FOR FURTHER DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 65 MPH, THE POWER STEERING FAILED. THE FAN FOR THE POWER STEERING PUMP WAS NOT WORKING PROPERLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

MY SON WAS DRIVING THE MINI COOPER AND THE STEERING STOPPED WORKING, HE HAD CALLED MINI WHEN HE GOT IT IN NOV 2015 ABOUT RECALLS AND THEY SAID THAT THE MINI WAS RECALLED FOR THE STEERING AND THE PASSENGER SEAT AIR BAG. WHEN WE CALLED THE LOCAL MINI DEALER THEY SAID ONLY THE AIR BAG. I JUST GOT OFF THE PHONE WITH A CASSANDRA FROM MINI AND SHE SAID THERE IS A RECALL FOR THE STEERING FOR MINIS MADE BETWEEN MARCH 2005 AND FEBRUARY 2005 AND HIS CAR WAS ON THE TAIL END OF IT AND THEY WOULD NOT WARRANTY IT TO BE FIXED. I BELIEVE THAT THESE CAR DEALERS KNOW ABOUT SAFETY PROBLEMS BUT DON'T WANT TO FIX THEM PROPERLY. MY SON COULD HAVE BEEN KILLED IF NOT FOR THE FACT THAT IT CAME BACK LONG ENOUGH FOR HIM TO GET THE CAR STOPPED. I HOPE THAT YOU CAN GET THIS RESOLVED SO THEY WILL TAKE CARE OF THIS SAFETY ISSUE

POWER STEERING PUMP WENT OUT WHILE DRIVING AND IT STAYS ON WHEN THE ENGINE IS OFF. I WAS ON A CITY STREET WHEN IT HAPPENED. I HAVE TO DISCONNECT BATTERY CABLE SO IT DOESN'T DRAIN THE BATTERY.

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

BATTERY DIED AND REPLACED. DROVE 2 DAYS AND BATTERY DIED AND AGAIN REPLACED. DROVE AND STEERING BECAME EXTREMELY STIFF. CHECKED FLUIDS AND NO POWER STEERING FLUID. HAPPENED AGAIN WITH BOTH BATTERY AND P/S FLUID. BECAME AWARE OF RECALL IN 04 AND 05 MINI COOPER'S AND TOOK TO DEALER. BAD POWER STEERING PUMP AND FAN AS WELL AS 2 HOSES. WAS TOLD MY CAR WAS NOT COVERED UNDER RECALL BECAUSE THE BUILD DATE IS MAY. WAS QUOTED $1300+ FOR REPAIRS.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 15 MPH, THE POWER STEERING FAILED AND CAUSED THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING PUMP WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.

ON 2/11/2016 I GOT HOME FROM WORK AND I PARKED MY 2005 MINI COOPER S (53,000 MILES) ON THE DRIVEWAY, TURN OFF CAR AND STAYED WITH MY KIDS & WIFE SINCE THEY WERE WAITING FOR ME OUTSIDE, MY WIFE NOTICE A SOUND & SMOKE COMING FROM THE CAR, THE SMOKE WERE COMING FROM THE ENGINE, I IMMEDIATELY OPEN THE HOOD & THERE WAS MORE SMOKE COMING OUT, THE HEADLIGHTS & ALL THE LIGHTS TURNED ON & STARED FLICKERING, ALSO THE WIPERS TURNED ON, COUPLE OF SECONDS LATER THE BOTOM OF THE ENGINE WAS ENGULFED IN FLAMES. MY WIFE RAN TO GET THE WATER HOSE & I WERE ABLE TO PUT THE FIRE OUT, WE WERE LUCKY THAT I DIDN'T WALK INSIDE THE HOUSE LIKE I ALWAYS DO, IT COULD HAVE BEEN A HORRIBLE TRAGEDY FOR ME, MY FAMILY AND EVEN OUR NEIGHBORS. THE NEXT DAY I HAD THE CAR TOWED TO MY MECHANIC WHO AFTER AN INSPECTION FOUND OUT IF WAS THE POWER STEERING PUMP THAT GOT ON FIRE AND DAMAGED ALL THE WIRES AROUND IT, SINCE HE IS A MINI SPECIALIST HE TOLD US ABOUT A RECALL FOR THAT SPECIFIC PART, BUT TO OUR DISAPPOINTMENT HE RAN OUR VIN # AND FOUND THAT OUR CAR IS EXCLUDED FROM THAT RECALL SINCE ITS A LATE 2005 PRODUCTION. THAT EXACTLY SAME THING HAPPEND TO US WITH THE ACTUATORS, ONE DAY WHILE MY WIFE WAS SHOPPING WITH MY KIDS, THEY JUST GOT LOCKED INSIDE THE VEHICLE WITH THE WINDOWS ROLLED UP, IT WAS A SUMMER DAY AND LUCKILY SHE WAS ABLE TO GET OUT THROUGH THE BACK TRUNK, WE CONTACTED MINI BECAUSE THERE IS ALSO A RECALL FOR THE ACTUATORS AND THEY ALSO EXCLUDED OUR CAR SAYING THAT IT WAS A LATE 2005 PRODUCTION AND WERE NOT ABLE TO GET THE RECALL. THE WAY WE SEE IT MINI IS NOT TAKING RESPONSIBILITY FOR THEIR DEFECTIVE COMPONENTS, IT IS NOT FAIR SINCE I HAVE NO WAY TO FIND OUT IF MY CAR WAS BUILD WITH NOT DEFECTIVE PARTS, OBVIOUSLY IT WAS. I AM TERRIFIED BY THE IDEA THIS COULD HAVE BEEN WORST SINCE WE R ALWAYS DRIVING WITH OUR KIDS. U NEED TO DO SOMETHING ABOUT THIS & MAKE MINI LIABLE FOR THESE SAFETY ISSUES.

I HAVE A 2005 MINI COOPER S WITH LESS THAN 85K MILES IT. THE POWER STEERING HAS COMPLETELY GONE OUT. BEFORE IT WENT OUT COMPLETELY, IT WOULD STOP OCCASIONALLY WITH OUT WARNING WHILE DRIVING THE VEHICLE. THE PRIMARY IMPACT IS AS LOW SPEEDS, PARKING OR TURNING FOR EXAMPLE. THIS VEHICLE HAS RUN FLAT TIRES MAKING STEERING AN EVEN BIGGER CHALLENGE. IT IS A SAFETY HAZARD AND DUE TO THE HIGH COST TO REPLACE THIS FUNCTION AND SAFETY HAZARD IT IMPOSES,, THE CAR HAS BEEN SITTING FOR OVER A YEAR. THERE HAS BEEN A RECALL ON THIS SPECIFIC YEAR & MODEL OF VEHICLE FOR THE EXACT SAME ISSUE- HOWEVER IT DID NOT INCLUDE MY PARTICULAR VIN. I BELIEVE THIS TO BE AN ISSUE OF EPIDEMIC PROPORTIONS AND WOULD ASK THAT THIS BE LOOKED INTO IF POSSIBLE. THE MINI COOPER S IS A GREAT LITTLE CAR, HOWEVER STEERING IS A VITAL AND A REQUIRED SAFETY MEASURE THAT I FEEL MINI/BMW SHOULD GLADLY COVER IN ALL VIN'S DURING THIS TIME FRAME.

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. WHEN THE VEHICLE WAS TURNED OFF, THE CONTACT NOTICED THAT THE ELECTRIC FAN KEPT RUNNING. THE FOLLOWING DAY, THE VEHICLE FAILED TO START. THE BATTERY WAS DEAD. WHEN ROADSIDE ASSISTANCE ARRIVED, THE BATTERY WAS JUMPSTARTED AND THE FAN REMAINED ACTIVE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP AND THE POWER STEERING FAN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

MY MINI COOPER S CONV, 2005, HAS BEEN HAVING STEEERING ISSUES FOR SOME TIME NOW. IT WILL RANDOMLY LOSE WHAT SEEMS LIKE THE POWER STEERING WHILE I AM DRIVING! I HAVE FOUND THAT BY TURNING THE CAR OFF (IF I AM STOPPED AND IN AREA WITH TIME TO TURN OFF MY CAR) THAT IT WORKS AGAIN FOR 10 MINUTES TO 30 MINUTES. OTHER TIMES I CAN DRIVE FOR 45 MINUTES NO PROBLEMS AT ALL. HOWEVER, MORE OFTEN THAN NOT THE STEERING GOES OUT IS NOT WORKING AS SOON AS I TURN THE CAR ON. I K NOW THAT I HAVE TO SELECT A DATE OF WHEN THIS HAPPENED AND I AM PUTTING TODAY'S DATE SINCE IT HAPPENS DAILY. HOWEVER, I WANT IT NOTED IT IS NOT ONLY TODAY.

IN COLD WEATHER THE DRIVER SIDE PARKING BRAKE FREEZES/STICKS. ONE OF MANY EXAMPLES WAS THIS MORNING. IT WAS 27 DEGREES IN MY GARAGE AND I WAS ABLE TO DRIVE WITH NO PROBLEMS, I DROVE FOR A FEW MILES WITH THE CAR FULLY WARMED UP. I STOPPED FOR COFFEE AND LEFT THE CAR RUNNING (WIFE IN CAR) AND RETURNED NO MORE THAN 5 MINUTES LATER. WHEN I TRIED TO DRIVE THE PARKING BRAKE WAS NOT RELEASED ALL THE WAY. AFTER DRIVING A SHORT DISTANCE THE PASSENGER REAR BRAKE WAS COOL TO THE TOUCH BUT THE DRIVER SIDE WAS RADIATING HEAT AND SMELLED OF BURNING BRAKES. THIS IS AN UNACCEPTABLE FLAW AND CAN BE DANGEROUS. THE REAR CALIPERS ARE RELATIVELY NEW AND THE BRAKE FLUID IS FLUSHED EVERY TWO YEARS. I ALSO HAVE A 2006 MINI COOPER THAT DOES NOT HAVE THIS ISSUE. A QUICK INTERNET SEARCH PROVIDES NUMEROUS EXAMPLES ALL SEEM TO BE ISOLATED IN THE 2004-2005 YEARS AND IN COLD CLIMATES.

POWER STEERING GOES OUT. VERY HARD TO TURN THE WHEEL. ITS LIKE HAVING NO STEERING AT ALL AT TIMES. I HAVE TWO MINI COOPERS. THIS ONE HAS NOT YET TO GET THE RECALL FOR THE STEERING PUMP. I HAVE A RECALL FOR THE OTHER MINI THAT I OWN BUT THAT ONE DOESNT HAVE A PROBLEM.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE IN PARK, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE AFTER THE VEHICLE WAS TURNED OFF. THE CONTACT HAD TO DISCONNECT THE BATTERY CABLE TO GET THE NOISE TO STOP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSIST PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000. ...UPDATED 02/19/16 *BF... UPDATED 05/03/18*JB

TRANSMISSION PREVIOUSLY REPLACED AT 48K MILES BY MANUFACTURER DUE TO NOISE. MY TRANSMISSION IS BROKEN. MY TIRES CHIRP EVERY TIME I PUSH ON THE GAS BECAUSE THE TRANSMISSION DOES NOT KNOW WHAT GEAR TO BE IN DUE TO THE BAD BODY CONTROL VALVE. THE TRANSMISSION NEEDS TO BE REPLACED BECAUSE I CANNOT VERIFY HOW MUCH MECHANICAL DAMAGE HAS TAKEN PLACE DURING THE TIME THAT THE VALVE BODY HAS BEEN BROKEN. ONCE THE VALVE BODY BREAKS DOWN, THE MECHANICAL UNIT ALSO BEGINS TO BREAK DOWN. MINI NEEDS TO ISSUE A SERVICE BULLETIN TELLING THE DEALERS TO COMMENCE SERVICING THE AISIN TRANSMISSIONS EVERY 40K BY REPLACING THE FLUID. BMW/MINI'S TRANSMISSION FLUID IS NOT LIFETIME. VOLKSWAGEN ISSUED A SIMILAR BULLETIN A FEW YEARS AGO BECAUSE IT ALSO USES THE AISIN TRANSMISSION. THE INDEPENDENT REPAIR SHOPS MAY NOT REPLACE THE FLUID RIGHT BECAUSE THE TRANSMISSION FLUID IS HARD TO DRAIN AND IN MANY CASES IF IT'S NOT DONE RIGHT, GREAT DAMAGE IS DONE THE ENGINE. THE CONSUMER STATED THE VEHICLE WAS UNDER POWERED UPON ACCELERATION. THE VEHICLE WOULD JERK, AND BUCK. THE VALVE BODY IN THE TRANSMISSION BEGAN TO BREAK DOWN BECAUSE THE SHAVINGS FROM THE TRANSMISSION GEARS BEGAN TO CLOUD THE FLUID AND INHIBIT COMMUNICATION FROM THE VALVE BODY SOLENOIDS TO THE MECHANICAL COMPONENTS. UPDATED 03/23/16.*JB

I WAS LEAVING WORK LATE AT NIGHT WHEN I TRIED TO DRIVE THE CAR OUT OF THE PARKING LOT THE STEERING DISAPPEARED. IT WAS DIFFICULT TO MANEUVER THE CAR. I HAD THE CAR AT THE MINI DEARLSHIP EARLIER IN THE WEEK TO REPLACE LIGHT BULBS SO I CALLED THE DEALERSHIP TO FIND OUT WHERE WHAT THIS COULD BE, WHERE I COULD CHECK THE POWER STEERING FLUID LEVELS. THEY WERE NOT THAT HELPFUL. THEN LATER I LOOKED ONLINE AT ALL THE STEERING COMPLAINTS AND CALLED THE DEALERSHIP BACK AND WAS TOLD THAT THERE WAS A PROBLEM AND MY CAR (VIN#) WOULD BE COVERED FOR 13 YEARS/150,000. I AM REPORTING THIS BECAUSE ALL MINI'S WITH THIS PROBLEM SHOULD BE COVERED. DEALERSHIPS SHOULD CHECK VEHICLES FOR RECALLS WHEN CUSTOMERS CALL WITH PROBLEMS. I LIKE MY DEALERSHIP BUT I AM DISAPPOINTED THAT I HAD TO RESEARCH THIS DANGEROUS PROBLEM.

POWER STEERING FAILED AT LOW SPEED WHILE TURNING AT A STOP SIGN IN A SCHOOL ZONE. STEERING EFFORT INCREASED DRAMATICALLY THEN SHORTLY AFTER THE BATTERY LIGHT, THEN ALTERNATOR LIGHT CAME ON. WAS ABLE TO JUST MAKE IT HOME. I LOOKED ONLINE AND DISCOVERED THAT THIS IS A COMMON PROBLEM AND THAT MINI IS OFFERING AN EXTENDED WARRANTY. I CALLED MINI AND GAVE THEM MY VIN. THEY TOLD ME MY 2005 COOPER S IS NOT INCLUDED IN THE EXTENDED WARRANTY AND WOULD NOT DO ANYTHING FOR ME. IT SEEMS THAT MINI IS NOT CAPTURING ALL THE VEHICLES THAT HAVE THIS PROBLEM. I NEVER RECEIVED A LETTER NOTIFYING ME OF THE ISSUE. LOT OF FORUMS ABOUT THIS ISSUE. SO GLAD THIS DID NOT HAPPEN ON THE HWY.

THE POWER STEERING SYSTEM ON DIFFERENT OCCASIONS HAS STOPPED WORKING COMPLETELY, OTHER TIMES IT JUST TAKES MORE OF AN EFFORT TO TURN THE WHEEL EACH OCCURANCE CAN LAST FROM A FEW SECONDS OR MUCH LONGER PERIODS OF TIME AND DOESN'T MATTER IF ITS LOW OR HIGH SPEEDS. ALSO WHEN STARTING THE VEHICLE A LOW BATTERY LIGHT IS SOMTIMES ILUMINATED. THE LOSS OF POWER STEERING ASSISTANCE IS COMPLETE UNPREDICTABLE.

I RECEIVED A NOTICE FROM MINI COOPER IMPORTANT SAFETY RECALL NOTICE BY MAIL AND CALLED TO TRY AND SCHEDULE A REPLACEMENT OF THE SEAT SENSOR. I WAS TOLD THAT A DIAGNOSTIC TEST MIGHT BE CHARGED FOR THIS AND IT WOULD BE $150.00 FOR THE REPLACEMENT. THIS IS FREAKING RIDICULOUS, THIS IS THE SECOND TIME THEY TRY TO CASH OUT AT MY EXPENSE... NHTSA RECALL NUMBER: OPENS NEW WINDOW TAKES AWAY FROM VIN LOOKUP SECTION> 15V205 RECALL DATE: APRIL 3, 2015 MANUFACTURER RECALL NUMBER: NA

THE WRITTEN "SAFETY RECALL NOTICE" THAT I RECEIVED IN THE MAIL YESTERDAY, OCTOBER 14, 2015, OF WHICH BMW/MINI LIKELY PROVIDED NHTSA A COPY IS BOTH FALSE AND MISLEADING. FOUR MONTHS AFTER BMW/MINI NOTIFIED ME NOT TO ALLOW AN ADULT-SIZE PERSON TO RIDE IN THE FRONT PASSENGER SEAT OF THIS FOUR-SEAT, TWO-DOOR AUTOMOBILE, THE CURRENT WRITTEN NOTICE INDICATES THAT BMW'S MINI DEALERS "ARE NOW READY" AND I SHOULD "SCHEDULE AN APPOINTMENT FOR RECALL REPAIR SERVICE AS SOON AS POSSIBLE." IN USING THE WEBSITE PROVIDED IN THE NOTICE TO LOCATE THE NEAREST DEALER, I WAS UNABLE TO SCHEDULE AN APPOINTMENT. THE DEALER HAD NO PARTS AND WOULD NOT EVEN SCHEDULE AN APPOINTMENT TO OCCUR IN THE FUTURE. A CALL TO THE BMW/MINI TOLL-FREE NUMBER INCLUDED IN THE NOTICE CAUSED THE BMW/MINI "CUSTOMER RELATIONS AND SERVICES" REPRESENTATIVE TO ADMIT THAT THE NOTICE WAS FALSE AND THAT MANY DEALERS ARE NOT READY TO SCHEDULE APPOINTMENTS FOR THIS SERVICE. THE NOTICE FOR RECALL CAMPAIGN NO. 15V-205 INDICATES THAT IT WAS SENT TO ME "IN ACCORDANCE WITH THE NATIONAL TRAFFIC AND MOTOR VEHICLE SAFETY ACT." DOES NHTSA REALLY CONDONE FALSE AND MISLEADING WRITTEN NOTICES PURPORTED TO BE IN ACCORDANCE WITH FEDERAL SAFETY LAW?

OVER THE PAST 9 MONTHS MY POWER STEERING WILL STOP WORKING, I WILL USUALLY NOTICE THIS WHEN I START MY CAR AND GO TO MOVE I AM ABLE TO DRIVE MY CAR BUT IT IS VERY DIFFICULT TO STEER, IF I TURN OFF MY CAR AND TURN IT BACK ON OCCASIONALLY IT WILL START MY POWER STEERING BACK UP THIS IS NOT A CONSTANT THING BUT IS HAPPENING MORE FREQUENTLY. I HAVE FOUND THAT THERE IS A RECALL ON THE POWER STEERING FOR THE MINI COOPER BUT MY VIN NUMBER ISNT INCLUDED IN THIS RECALL I AM VERY CONCERNED THAT I HAVE THE SAME PROBLEM I NEED HELP PLEASE

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 60 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED AND CAUSED THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MOTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE FAILURE OF THE POWER STEERING PUMP CAUSED METAL FRAGMENTS TO ENTER THE RACK AND PINION, WHICH CAUSED A FAILURE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED THAT BECAUSE OF THE TREAD ACT, THE MANUFACTURER WAS ONLY OBLIGATED TO REPAIR THE POWER STEERING PUMP UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,155.

LOST POWER STEARING, HEAT AND AIR ALL AT THE SAME TIME.

WHILE BACKING MY CAR OUT OF MY PARKING SPACE THIS MORNING I WENT TO TURN THE WHEEL AND IT SEEMED STUCK I THEN REALIZED I HAD NO POWER STEERING. I HAD PARKED THE CAR THE NIGHT BEFORE AND HAD NO INDICATION THAT THERE WAS A PROBLEM WITH THE STEERING. AS I BACKED THE CAR OUT WITHOUT POWER STEERING I ALMOST HIT TWO CARS TRYING TO CONTROL THE VEHICLE, I WAS ABLE TO PARK THE CAR WITHOUT INCIDENT. THERE HAS SO FAR BEEN NO RECALL ON THE STEERING AND APPARENTLY I'M NOT THE FIRST PERSON THIS HAPPENED TO.

AFTER AN HOURS DRIVE, I WAS STANDING OUTSIDE OF THE VEHICLE TALKING W/ THE CAR OFF. ALL OF SUDDEN SMOKE STARTS POURING OUT FROM UNDER THE HOOD. I QUICKLY OPENED THE HOOD TO HEAR SOME TYPE OF ELECTRICAL FAN/PUMP SOUND & SMOKE COMING FROM THE BOTTOM/REAR SIDE OF THE MOTOR. I WAS ABLE TO PULL THE BATTERY TERMINAL & THE NOISE/SMOKE STOPPED. I THEN SEARCHED ONLINE & FOUND THE KNOWN ISSUES OF THE ELECTRICAL ASSISTED POWER STEERING. I FOUND THE FUSE FOR THE CIRCUIT, A 100 AMP FUSE HIDDEN ON THE BOTTOM SIDE OF THE FUSE BOX THAT HAD NOT POPPED EVEN THOUGH THE PUMP WAS BURNING ITSELF UP. I HAD ENOUGH TOOLS W/ ME TO PULL THE FUSE, GET THE CAR STARTED & MAKE MY WAY HOME W/O THE POWER STEERING ASSIST.

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

IN THE MONTHS OF MAY AND JUNE OF 2015, MY POWER STEERING WOULD INTERMITTENTLY STOP PROVIDING POWER ASSIST. IT HAS COMPLETELY STOPPED WORKING NOW. MAKES IT CHALLENGING TO MAKE EMERGENCY MANEUVERS.

POWER STEERING FAILED. EXTREMELY DIFFICULT TO STEER WITHOUT IT. AFTER THE CAR AS TURNED OFF AND THEN COOLED: 30 MINUTES LATER THE POWER STEERING WORKED AGAIN. THIS HAS NOW HAPPENED ON 3 OCCASIONS OVER THE LAST 2 WEEKS: ALL ON DAYS WITH THE TEMPERATURE IN THE 90S. I CALLED THE MINI SERVICE BUT THEY SAID THAT THEY WON'T FIX IT UNDER THE EXTENDED WARRANTY ON THE POWER STEERING PUMPS (150K MILES, 13 YEARS) UNLESS ITS FAILED WHILE THEY HAVE IT. VERY DANGEROUS TO DRIVE THIS WAY WITH UNEXPECTED FAILURES: ESPECIALLY FOR MY WIFE WHO WOULD NOT BE ABLE TO FORCE IT THROUGH TURNS WITHOUT POWER STEERING. I DON'T UNDERSTAND WHY THERE HAS NOT BEEN A RECALL ON THIS POWER STEERING SYSTEM.

2005 MINI COOPER. CONSUMER WRITES IN REGARDS TO ENGINE ELECTRONIC FAILURE. CONSUMER HAS ANOTHER VEHICLE COMPLAINT LISTED IN ARTEMIS. *SMD THE CONSUMER STATED THE PROBLEM HE EXPERIENCED WITH HIS VEHICLE WAS A COMPUTER TEST CALLED COMPREHENSIVE COMPONENT KEPT READING INCOMPLETE. THE DEALER FOUND AN INTERNAL SHORT INSIDE THE ENGINE BASIC CONTROL COMPUTER. THE CONSUMER STATED THE COST TO REPLACE THE ELECTRONIC HARDWARE WAS $1968 WHICH WAS EXCESSIVE. *JB