2005 MINI Cooper Complaint Log

The contact owns a 2005 Mini Cooper S. The contact stated while driving 25 MPH, the steering wheel became difficult to maneuver. The contact stated that the vehicle had lost power steering assist. The vehicle was not diagnosed or repaired. The contact stated that a software update was performed on the back over prevention camera. The manufacturer was notified of the failure but offered no assistance. The contact related the failure to NHTSA Campaign Number: 15V660000 (STEERING); however, the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 175,830.

The contact owns a 2005 Mini Cooper. The contact stated while driving 35 MPH, the steering wheel was difficult to turn. The vehicle lost power steering functionality. The contact stated that the failure was related to NHTSA Campaign Number: 15V660000 (Steering). The vehicle was taken to an independent mechanic, who determined that the power steering pump needed to be replaced. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 117,300.

The contact owns a 2005 Mini Coop S Hardtop. The contact stated that while the vehicle was parked and unoccupied, the vehicle alarm activated inadvertently and the contact noticed smoke coming from underneath the hood. The contact stated that he lifted the hood open and noticed fire coming from underneath the engine. The contact extinguished the fire with a fire extinguisher. There were no injuries sustained. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

The contact owns a 2005 Mini Cooper Convertible. The contact stated that she noticed a leak coming from the vehicle. The contact took the vehicle to an independent mechanic, where it was diagnosed with a power of steering hose leak. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V660000 (Steering). The manufacturer was made aware of the failure. The failure mileage was approximately 94,000.

The vehicle experienced a loss of power steering assist. The dealer was made aware of the failure; however, the vehicle was not repaired. The dealer informed me that there was no recall associated with the VIN. The failure is NHTSA Campaign Number: 15V660000 (Steering) however, the VIN was not included in the recall.

The contact owns a 2005 Mini Cooper. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The dealer informed the contact that there was no recall associated with the VIN. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 15V660000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 167,000.

The contact owns a 2005 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact also stated that he was advised by the dealer that he had to pay out of pocket for a diagnostic test. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2005 Mini Cooper. The contact stated that there was water accumulated on the passenger's side front floorboard. The contact stated that the heater was causing some undisclosed issues. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was diagnosed, and it was determined that the sunroof drain tubes were clogged, the drain tubes were cleared, and an undisclosed reprogramming was completed. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 172,843.

The contact owns a 2005 Mini Cooper Convertible. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering). The contact stated that while her son was driving at an undisclosed speed, the power steering assist failed. The dealer was made aware of the recall but informed the contact that they do not service recall repairs. The nearest dealer that was able to service the recall repair was located 177 miles away. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unavailable.

My son drives this car and the power steering went out twice on him while driving. I need to get the pump replaced via the recall, but the nearest location is 200 miles from me. It is not safe to drive this car that far and I would have to drop it off and make another trip to pick it up. Towing that far would cost a small fortune. I called every number and was transferred to several people to help with this issue. They say they can not and won't help me till I get the car to a dealership to fix it. One person from Mini told me I might be able to go to a certified mechanic but when I asked the next person they said it had to be a dealership. I spent two days on the phone with several people from Mini and no one was willing to offer a solution. I drive this car to get the recall fixed and something happens and the car wrecks, or worse someone is killed, who would it be on then? No happy about this at all.

2005 Mini Cooper S has power steering whine, hard to steer the wheel. Very unsafe.

The transmission will cycle first through third and when it tries to go into 4th it slips and will not operate higher gears it caused me to lose my forward drive momentum as I was switching lanes and the car I was getting in front of almost ran into me.

Driving at approximately 10-15 miles an hour entering a parking lot when I noticed flames coming out of the hood scoop of my 2005 Mini Cooper S. After brief inspection from my mechanic, it is believed to have been caused by the wiring harness for ABS or possibly the power steering unit since the fire originated from the rear/right hand side of the engine and those two components. I have a claim opened with USAA but during simple research, I have found tens, if not close to a hundred issues with similar characteristics. I know I am not the first R53 Mini Cooper (2002-2006 run) with this problem and this should be considered a hazard and public safety issue. I have included the link to many of the cases captured by the North American Motoring Association (a primarily North American Mini car association) which details 24 pages of these issues. https://www.northamericanmotoring.com/forums/stock-problems-issues/73527-spontaneous-engine-bay-fires.html?ispreloading=1

POWER STEERING PUMP STOP WORKING WHILE DRIVING TURNING IN A CITY STREET

WHEN DRIVING VEHICLE TRANSMISSION SLIPS CAUSING A JERK REACTION IN THE VEHICLE AND THEN IT WILL RENEGADE CAUSING ANOTHER JERK REACTION IN THE VEHICLE AND MAKES GOING AND OR STOPPING UNPREDICTABLE. TURNING LEFT IS DANGEROUS AS THE CAR MAY NOT MOVE FORWARD AT A SPEED THAT IT SHOULD OR MAY JERK IN THE MIDDLE CAUSING THE VEHICLE TO STOP IN FRONT OF ONCOMING TRAFFIC. I HAVE HAD A MACHANIC CHANGE THE TRANSMISSION AND IT STILL DOES THE SAME THING. I HAVE CONTACTED THE MANUFACTURERS WHO INFORMED ME THAT THERE WERE NO RECALLS AND NOTHING THEY WOULD DO.

BATTERY LIGHT FLASHING, POWER STEERING CUTTING OUT INTERMITTENTLY WHILE DRIVING. ALTERNATOR AND SERPINTINE BELT REPLACED BUT PROBLEM CONTINUES. ELECTRIC POWER STEERING SEEMS TO BE DRAINING ELECTRICAL SYSTEM.

THE POWER STEERING ASSIST HAS ALL BUT STOPPED WORKING, WITH STEERING NOW DIFFICULT AT LOWER SPEED--ESPECIALLY WHEN I FIRST START THE ENGINE IN THE MORNING. THE CLUTCH DOESN'T RESPOND WELL AND THE VEHICLE NO LONGER GOES INTO SECOND GEAR. THE REAR LEFT BRAKE CALIPER SEIZED IN PLACE, NOT ALLOWING THE BRAKE PAD TO RETRACT COMPLETELY AND THEREFORE THE BRAKE PAD CONTINUOUSLY RUBBED AGAINST THE DISC, BUT WITHOUT NOISE. NOT UNTIL THE LEFT REAR BRAKE MADE NOISE BECAUSE OF THE METAL ON METAL BRAKING WAS THE SEIZED OEM CALIPER IDENTIFIED, WHEN I PUT ON A SET OF NEW BRAKE PADS. NONE OF THE OTHER THREE BRAKES HAD THE SEIZED OEM CALIPER.

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING BECAME VERY DIFFICULT TO MANEUVER. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE VEHICLE OFF. ONCE RESTARTED, THE STEERING OPERATED NORMALLY. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED APPROXIMATELY ONE AND A HALF MONTHS AND WAS GETTING WORSE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 92,500.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE VEHICLE OVERHEATED AND SMOKE BEGAN COMING FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE WATER PUMP WAS REPLACED. AFTER THE REPAIR, THE POWER STEERING CEASED WITHOUT WARNING UPON STARTING THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) AS POSSIBLE CAUSE OF THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. MINI OF DES MOINES LOCATED AT (9900 HICKMAN RD, DES MOINES, IA 50325) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

THE CAR WAS IN MOTION WHEN SUDDENLY THE STEERING WHEEL BECAME VERY HARD AND THE DRIVER LOST CONTROL, ALMOST CAUSING AN ACCIDENT. THERE HAS BEEN A RECALL FOR MINI COOPER S VEHICLES (15V-XXX SAFETY RECALL) INVOLVING THE ELECTRIC-HYDRAULIC POWER STEERING SYSTEM. THE RECALL INCLUDES 2002-2005 MODELS, AND EXTENDS THE WARRANTY UP TO 13 YEARS OR UP TO 150,000 MILES. OUR VEHICLE FALLS UNDER THOSE REQUIREMENTS, AND IS A 2005 MODEL AND HAS 69,751 MILES, YET WE WERE TOLD THAT THERE ARE NO EXISTING RECALLS FOR OUR VEHICLE, EVEN THOUGH WE SUSPECT THAT THE INCIDENT WE HAD INVOLVES THE HYDRAULIC STEERING SYSTEM.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT EXPERIENCED INTERMITTENT POWER STEERING FAILURE. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, MINI OF MARIN (5880 PARADISE DR, CORTE MADERA, CA 94925, (415) 887-2194) AND THE MANUFACTURER WERE CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

THE POWER STEERING PUMP STOPS FUNCTIONING INTERMITTENTLY WHEN STARTING A STOP.

WHEN ADJUSTING THE DRIVER AND PASSENGER SEATS, THE AIRBAG LIGHT ILLUMINATED. AFTER RESEARCHING ONLINE, I CONDUCTED TROUBLESHOOTING. I VERIFIED THAT THE WIRING HARNESSES AND CONNECTORS FOR THE AIRBAG SENSORS UNDER BOTH SEATS HAD COME LOOSE, AND CERTAIN WIRES DE-PINNED. THE CAR WAS RUNNING, AND PARKED WHEN THIS OCCURRED.

POWER STEERING NO LONGER WORKS.

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT THE ELECTRIC POWER STEERING WAS FAULTY. MINI OF LOVELAND (4055 BYRD DR, LOVELAND, CO 80538, (970) 292-5020) WAS NOTIFIED OF THE FAILURE, BUT A DIAGNOSTIC APPOINTMENT WAS NOT SCHEDULED. THE DEALER INDICATED THAT THE VEHICLE WAS EXCLUDED FROM EXTENDED WARRANTY PROGRAM: SI M32 02 15 (STEERING AND WHEEL ALIGNMENT). AN INDEPENDENT MECHANIC DIAGNOSED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS ALSO NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE SERVICE ENGINE SOON WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE STEERING FAILURE WORSENED SINCE DECEMBER OF 2017. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER. AFTER TURNING THE VEHICLE OFF, THE POWER STEERING PUMP CONTINUED TO OPERATE. ALSO, WHILE OPERATING THE VEHICLE, THE POWER STEERING PUMP SOMETIMES FAILED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. ALSO, THE LOW BATTERY WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ORLANDO MINI (350 LAKE DESTINY DRIVE, ORLANDO, FL) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 172,000.

WENT TO DINNER AND CAME OUT AND STARTED MY CAR AND IT WAS SUPER HARD TO STEER

DRIVING ON INTERSTATE AND LOST POWER. I PULLED TO SHOULDER AND BLACK SMOKE CAME THRU AIR VENTS. I OPENED THE HOOD AND THERE WAS FIRE. MY CAR COMPLETELY BURNED UP. I NEVER HAD ANY MECHANICAL PROBLEMS. THE TOW TRUCK DRIVER SAID HE BELIEVED THE FIRE STARTED UNDER MY CAR.

STEERING WHEEL GOT STIFF WHEN I'M DRIVING.

2005 MINI COOPER S WAS TRAVELING 50MPH WHEN IT HIT ICY BRIDGE SPUN AROUND AND ROLLED 3 TIMES DRIVER WAS WEARING A SEATBELT AND PASSENGER WAS NOT AND GOT EJECTED AND DIED.NO AIRBAGS DEPLOYED. HWY 299.*DT *JS

THE PASSENGER SEAT OCCUPANCY MAT WAS REPLACED BY RECALL ON 10/28/2016. ON 10/2018 I NOTICED THAT WHEN THERE IS A PASSENGER IN THE SEAT WITH THEIR SEAT BELT ON THE AIR BAG WAS OFF, IN 1 WEEKS TIME THE PASSENGER SIDE SEAT BELT LIGHT WAS ON ALL THE TIME AND THE AIR BAG IS OFF ALL THE TIME WITH OR WITHOUT SOMEONE OCCUPING THE SEAT. REGUARDLESS IF THE CAR IS IDILING OR GOING DOWN THE RODE. AT LEAST BEFORE THE RECALLED MAT SENSOR WAS REPLACED THE SEAT MAT SENSOR WORKED MOST OF THE TIME. NOW IT DOES NOT WORK AT ALL. I TOOK IT TO THE DEALERSHIP AND THEY TESTED THE OC3 MAT (PASSENGER SIDE MAT SENSOR) AND SAID THERE ARE MULTIPLE CODES FOR THE OC3 MAT AND THEY FOUND INTERNAL FAULTS AND IT REQUIRES REPLACEMENT AGAIN. THEY SAID THIS RECALL IS NO LONGER UNDER WARRENTY AND I NEED TO PAY OVER 1500.00 TO HAVE IT REPLACED. IT IS UNSAFE FOR ME TO HAVE A PASSENGER IN MY CAR IF WE GOT INTO AN ACCIDENT THEIR AIRBAG WOULD NOT BE ON, THERE FOR THEY WOULD HAVE NO AIRBAGS TO DEPLOY TO TRY AND PROTECT THEM. HOW IS THIS MY FAULT? THEY REPLACED MY MAT SENSOR WITH ANOTHER FAULTY ONE THAT IS WORSE THEN THE FIRST ONE. HOW LONG ARE THE WARRENTIES FOR RECALLS AND THE PARTS REPLACED? I HAVE THE PAPERS FROM THE DEALERSHIP STATING WHAT I JUST REPORTED TO YOU.

AIRBAG LIGHT ILLUMINATED AT ALL TIMES. DEALERSHIP REPORTS $1200 TO REPLACE SENSOR FOR PASSENGER SEAT AND MAY IMPACT ALL AIRBAGS IF NOT FIXED.

BEFORE I BOUGHT THE CAR IT WAS REAR-ENDED FROM LOSING SPEED BECAUSE THE TRANSMISSION WAS SLIPPING. THIS IS IN THE DESIGN OF THIS YEAR OF MINI COOPER AS I AM FINDING THAT IT IS ON THE INTERNET AS JUST A BAD DESIGN. I CAN'T GET ANYONE TO WORK ON IT FOR A REASONABLE PRICE. I'M HOPING THERE'S SOME HELP OUT THERE FOR UNSUSPECTING INNOCENT PEOPLE LIKE ME WHO THOUGHT THEY WERE GETTING A GOOD CAR AND NOW IT IS JUST UNSAFE AS I HAVE HAD TO TOW IT 3 TIMES NOW AND I'VE ONLY HAD IT SINCE MAY OF THIS YEAR 2018.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE CONTACT TOOK THE VEHICLE TO THE DEALER (IRVINE MINI, 9829 RESEARCH DR, IRVINE, CA 92618, (888) 238-7585), BUT THEY REFUSED TO REPAIR THE POWER STEERING DUE TO A DISCREPANCY IN THE PART NUMBERS. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD CALL THE CONTACT BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000. PARTS DISTRIBUTION DISCONNECT.

I GOT HOME FROM WORK PARKED CAR AND HEARD A WHINING NOISE UNDER HOOD I COULD SEE SMOKE AND BURING SMELL COMING FROM STEERING COOLING FAN THE FAN STAYED ON AND WENT INTO EXTREME HIGH SPEED AND CONTINUED TO SMOKE AND WIRING BURNING ,I WAS FORTUNATE ENOUGH TO BE ABLE TO DISCONNECT BATTERY WHICH STOPPED FAN AND ELECTRICAL BURNING I HAVE CAR PARKED IN DRIVE WAY AND CONTACTED MY INSURANCE TO FILE A CLAIM ,I AM AFRAID TO START CAR AND NEED TO HAVE CAR REPAIRED

THE CAR STOPPED STEERING CORRECTLY. IT IS VERY DIFFICULT TO TURN THE WHEELS. THE POWER STEERING IS GONE. I STARTED NOTICING THE DIFFERENCE IN THE STEERING AND THEN THE STEERING PROGRESSIVELY GOT WORSE. I CALLED THE SERVICE DEPARTMENT OF THE DEALERSHIP TO ASK IF THERE SHOULD BE A CONCERN BECAUSE THE STEERING STARTED AFTER I HAD THE RECALL SERVICE ON THE SEAT WARMMER.

POWER STEERING PUMP FAILED WHILE CAR WAS BEING DRIVEN. VEHICLE ONLY HAS 90K AND FOR SOME REASON WAS NOT COVERED UNDER THE RECALL PER MINI USA. MINI NEEDS TO REVIEW THE RECALL AND CORRECT ALL 2005 MINI COOPER'S WITH THIS DEFECT.

WHILE DRIVING CAR MY STEERING WHEEL BECAME VERY HEAVY AND HARD TO STEER.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING 15 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. MAG MINI DUBLIN IN COLUMBUS (5825 VENTURE DR, DUBLIN, OH 43017, (614) 389-6854) WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

STEERING IS DIFFICULT AND REQUIRES EXERTION WHEN I TURN THE WHEEL. I BELIEVE MY CAR SHOULD BE INCLUDED IN THE RECALL RECALL 15V-XXX: ELECTRO-HYDRAULIC POWER STEERING (EHPS) SYSTEM M32 02 15 IT IS NOT INCLUDED IN THIS RECALL BUT BECAUSE MY CAR EXHIBITS THE SAME ISSUE THAT IS RECALLED ON CARS MADE IN THAT YEAR, I FEEL THAT THE LIMITS SHOULD BE EXPANDED TO INCLUDE MY CAR AND OTHER CARS MANUFACTURED WHEN MINE WAS.

I AM A PROUD OWNER OF A 2005 MINI COOPER S WITH 108K MILES. RECENTLY I EXPERIENCED THE INFAMOUS EHPS PUMP FAILURE THAT THE PUMP WILL CONTINUE RUNNING AFTER SHUTTING OFF THE CAR. IT DRAINS THE BATTERY COMPLETELY SO I HOOKED UP MY BATTERY CHARGER TO IT OVERNIGHT. AFTER PERFORMING SOME GOOGLE RESEARCHING ON THIS SUBJECT MATTER, I REALIZED MINI HAD ISSUED AN EXTENDED WARRANTY ON THE EHPS SYSTEM IN 2013 AND LATER SUPERSEDED BY THE RECALL 15V-660. UNFORTUNATELY MY PRODUCTION DATE (AUGUST OF 05) DOES NOT FALL IN THE RANGE OF THE RECALL. THE RECALL COVERS PRODUCTION BETWEEN SEPTEMBER 2001 TO FEBRUARY 2005. FURTHER READING ON THIS ISSUE, MANY OWNERS EXPRESSED THAT THEY HAVE SUCCESS ON CLEANING THE DUST INSIDE THE PUMP TO SOLVE THE SHORTING ISSUE WITHIN THE PUMP. SO I DISCONNECT THE BATTERY, REMOVED THE PUMP FROM THE CAR AND START TAKING THE PUMP APART. AFTER REMOVING THE COVER, I REALIZED THE SHORT HAD ALREADY MELTED DOWN ONE OF THE BRUSH (THE GOLD COLOR PIECE IN IMG_9730) AND SOME OTHER COMPONENTS INSIDE THE PUMP. MY RESEARCH SHOWED THAT THIS PUMP IS THE EXACT SAME ONE THAT WAS USED AS THE RECALL ONE, BMW PART NUMBER 6769961-02 (IMG_9733). LATER ON THE PART NUMBER CHANGED TO 6769961-03. SO I WONDERED WHY MY CAR ISN'T PART OF THE US RECALL. I ALSO FOUND THAT THE TRANSPORT CANADA RECALL #2012029 DOES PROVIDE EXTENDED WARRANTY (12 YEARS / 200K KM) ON THE PUMP AND PUMP COOLING FAN FOR ALL 2002-2005 COOPER AND COOPER S IN CANADA. I HOPE SOMEONE CAN FURTHER INVESTIGATE THIS POTENTIAL FIRE HAZARD ISSUE FOR ALL AFFECTED PRODUCTION UNITS THAT IS OUTSIDE OF THE RECALL. IT IS DEFINITELY A SAFETY CONCERN FOR ALL MINI OWNERS AND PASSENGERS THAT UTILIZE THIS EHPS PUMP.

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING 45 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT IT WAS DIFFICULT TO MANEUVER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE IN HAVING THE VEHICLE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

THE POWER STEERING PUMP ON MY 2005 MINI COOPER S IS ACTING UP/ FAULTY, MAKING A GROAN NOISE AND STEERING IS HARD AT TIMES.

ELECTRIC POWER STEERING PUMP HAS LOUD WHINE OR MOANING SOUND WITH ONLY 42,000 MILES ON IT. FLUID LEVEL IS GOOD AND SO FAR THE POWER STEERING IS STILL WORKING. IT DOES GET LOUDER WHILE TURNING BUT ALSO ANNOYING WHEN JUST IDLING.

TL* THE CONTACT OWNED A 2005 MINI COOPER CONVERTIBLE. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH AFTER EXITING HIS DRIVEWAY, HE SUDDENLY LOST POWER STEERING WITHOUT WARNING. AS A RESULT OF THE FAILURE, THE CONTACT LOST COMPLETE CONTROL OF THE VEHICLE AS THE VEHICLE VEERED OFF THE ROAD AND INTO A UTILITY POLE. THE CONTACT WAS UNAWARE IF THE AIR BAGS DEPLOYED UPON IMPACT. THE CONTACT STATED THAT HE EXITED THE VEHICLE, WALKED BACK TO HIS HOME AND TOOK A NAP. AN HOUR LATER, THE CONTACT STATED THAT HE WAS AWOKEN BY A SHERIFF'S DEPUTY WHO ASKED HIM QUESTIONS ABOUT THE INCIDENT WITH HIS VEHICLE. A POLICE REPORT FILED AND THE CONTACT LATER WENT TO A DOCTOR WHERE HE WAS TREATED FOR INJURIES FOR HIS LOWER BACK WHICH INCLUDING A SLIPPED DISC AND A BRUISED VERTEBRAE. DUE TO THE FAILURE, THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DESTROYED. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V660000 ( STEERING) WHICH HE LINKED TO HIS VEHICLE FAILURE. THE CONTACT REACHED OUT THE MANUFACTURER WHERE HE WAS ASKED QUESTIONS ABOUT HIS VEHICLE FAILURE; HOWEVER, THE CONTACT REFUSED TO ANSWER ANY QUESTIONS AND DECIDED TO SEEK LEGAL ADVICE. THE VEHICLE WAS DEEMED DESTROYED. THE FAILURE MILEAGE WAS UNKNOWN.

THE POWER STEERING IN MY MINI COOPER 2005 HAS BEEN INTERMITTENT. THE STEERING WHEEL BECOMES VERY HARD TO TURN ALL OF A SUDDEN, PARTICULARLY AT LOW SPEEDS WHEN IT IS NEEDED THE MOST TO MAKE TURNS OR TO PARK. THERE ARE NO FAULT INDICATORS FOR THIS ISSUE ON THE DASHBOARD EITHER. THE VERY FIRST TIME THIS HAPPENED IN MARCH 2011 WHEN MY CAR HAD LESS THAN 80,000 MILES ON IT. THE POWER STEERING BECAME COMPLETELY INOPERABLE. AT THAT TIME THE DEALER INFORMED ME THAT THE POWER STEERING PUMP FAILURE WAS A KNOWN PROBLEM IN MINI COOPER AND THAT THE PUMP HAD TO BE REPLACED. THE REPLACEMENT COST WAS TOO HIGH THOUGH, HENCE I CHOSE TO THINK ABOUT IT BEFORE HAVING IT REPLACED. LUCKILY, THE POWER STEERING STARTED WORKING AGAIN AND EVEN THOUGH STEERING BECAME A LITTLE HARD AT TIMES I GOT USED TO IT. BUT SINCE END OF APRIL 2017 THE PROBLEM HAS BEEN GETTING WORSE. STEERING GETS TOO HARD AT TIMES AND REQUIRES A LOT OF FORCE TO TURN THE STEERING WHEEL AT LOW SPEEDS. GETTING IN AND OUT A COMPACT PARKING SPOT IS EXCEPTIONALLY HARD. MAKING LEFT, RIGHT AND U TURNS ARE ALSO VERY HARD. EVEN THOUGH THERE IS A RECALL ON THIS ISSUE, I HAVE NOT RECEIVED A RECALL NOTICE IN THE MAIL. I DON'T UNDERSTAND WHY MY CAR WAS NOT INCLUDED IN THE RECALL. OR IF THE RECALL IS ONGOING, WHY SHOULD IT TAKE SO LONG SINCE THIS IS A SAFETY ISSUE.

PROBLEM WITH THE TRANSMISSION. TRANSMISSION DOES NOT SHIFT PROPERLY DOWNSHIFTS AT HIGH SPEEDS CAUSING THE ENGINE TO REV REALLY HIGH. JOLTS A LOT ON THE SPEED CHANGES. HAVING SIGNS INDICATIVE OF TRANSMISSION FAILURE.

I REPORTED A FEW MONTHS AGO THAT MY POWER STEERING HAD FAILED. IT IS A 2005 MINI COOPER, AND SOME 2002-2005 MINI COOPERS WERE EFFECTED, BUT SUPPOSEDLY NOT MY MINI WITH MY VIN NUMBER. THE RECALL HAD ENDED IN FEBRUARY 2005 AND MY CAR WAS MANUFACTURED IN APRIL 2005. HOWEVER I BELIEVE THAT BMW (MAKERS OF MINI COOPER) WERE USING FAULTY POWER STEERING UNITS AFTER FEBRUARY 2005. MY CAR HAS LOW MILES, I AM THE ORIGINAL OWNER AND I TAKE PRISTINE CARE OF MY MINI. AS A RESULT, I HIT A CURB AND HAD TO HAVE THE FRONT LEFT TIRE CHANGED. THE WEATHER WAS CLEAR, NO RAIN AND MY TIRES ARE ALL JUST ABOUT BRAND NEW RUN FLAT TIRES. THE RANGE OF MINI COOPERS AFFECTED NEEDS TO INCREASED. THIS IS OBVIOUSLY A PROBLEM AND BMW (MAKERS OF MINI COOPER) SEEM TO NOT TAKE IT SERIOUSLY. MY POWER STEERING IS A MAJOR SAFETY ISSUE AND NEEDS TO BE ADDRESSED ASAP

TRANSMISSION UPSHIFTS AND DOWNSHIFTS ERRATICALLY AND/OR SHIFTS INTO NEUTRAL WITHOUT DRIVER INPUT WHILE IN MOTION.