2007 MINI Cooper Complaint Log

TL* THE CONTACT OWNS A 2007 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000.

2007 mini cooper s airbag light with warning on navigation screen saying seat belt tensioner or belt force limiter has a problem and passenger airbag is off. Odometer is 76,000 when problem started.

PASSENGER AIRBAG LIGHT IS ERRATIC, SOMETIMES IT WORKS, MOST TIMES NOT.

THIS CAR HAS BEEN A CONSISTENT USER OF OIL. IT USES A QUART AT ABOUT 500 MILES. THIS ENGINE HAS A REPUTATION FOR PROBLEMS ON MINI COOPER S MODELS AND THE PEUGEOT MODELS WITH THAT SAME ENGINE. I'VE HEARD THAT LATER MODELS DON'T BURN OIL. I'D LIKE TO KNOW WHY BMW HAS NOT RECALLED THEM. FIRST THE TIMING CHAIN, COOLING SYSTEM AND HIGH PRESSURE FUEL PUMP., THEY PAID FOR THE TIMING CHAIN AND THE FUEL PUMP.

WE ARE A SECOND OWNER OF THIS MINI COOPER HAD IT ABOUT A YEAR. TURN THE CAR ON AND HEAR A RATTLE IN MOTOR. WORSE WHEN IT'S COLD. TOOK IT IN TO BE CHECKED IT THE TIMING TENSIONER. APPARENTLY THERE HAS BEEN AN ISSUE WITH THIS FOR SOMETIME. REPAIR COST IS AROUND $2000. CAR ONLY HAS 76,000 MILES THIS PART SHOULD BE PROVIDED UNDER WARRANTY. BUT WHEN IT BREAKS IT AFFECTS THE MOTOR AS WELL BECAUSE IT IS METAL IT TEARS THE MOTOR UP. MAKING A 10 DOLLAR PART COST THOUSANDS OF DOLLARS FOR REPAIR. I DON'T FEEL LIKE I AM LIABLE FOR THE EXPENSE THAT MINI KNEW WAS A PROBLEM AND NEVER RECALLED.

CAR STARTED OF FIRE AS I WAS DRIVING ON THE INTERSTATE. FIRE STARTED IN THE ENGINE COMPARTMENT ON THE PASSENGER SIDE. THE BRAKES FAILED AS I WAS TRYING TO STOP THE CAR. HAD TO PULL THE E-BRAKE TO STOP AND BY THIS TIME THE CAR WAS ENGULFED IN FLAMES. PASSENGER HAD TO CRAWL OUT THE DRIVERS SIDE BECAUSE OF THE FLAMES ON THAT SIDE. LUCK TO HAVE GOTTEN OUT AS THE CAR WAS COMPLETELY DESTROYED IN 10 MINS

TL* THE CONTACT OWNS A 2007 MINI COOPER S. WHILE DRIVING 20 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE FAILURE MILEAGE WAS 39,000.

ENGINE, THERMOSTAT, GASKET, RADIATOR, COOLANT TUBE, AND BATTERY WENT OUT ON THE V AT THE SAME TIME. IT WAS RUNNING ROUGH AND JUST STOP RUNNING.

WHILE DRIVING ON THE STREET WITH MY WIFE THE "PASSENGER AIR BAG OFF" LIGHT CAME ON AND WOULD NOT GO OFF IMMEDIATELY. SINCE THEN IT HAPPENS SPORADICALLY WITHOUT ANY NOTICE. I TOOK IT INTO THE DEALER AND THEY SAID IT WAS THE PASSENGER SEAT AIRBAG SENSOR AND IT WOULD COST $1300 TO REPAIR IT. I KNOW THERE WAS A RECALL FOR THE 2007 COOPER S BUT NOT FOR THE 2007 MINI COOPER. IT SEEMS TO ME THE SAME PART COULD BE HAVE BEEN USED IN THE SAME MODEL YEAR CAR.

2007 MINI COOPER S, HATCHBACK. THE PASSENGER AIRBAG (OFF) LIGHT, INDICATING THE PASSENGER AIRBAG IS DISARMED, IS ON AT ALL TIMES REGARDLESS OF PASSENGER. ADDITIONALLY, THE DASHBOARD WARNING LIGHTS FOR MY AIRBAG SYSTEM AND SEATBELT ARE ILLUMINATED AT ALL TIMES. THE CODES IDENTIFIED BY THE MINI DEALERSHIP IN HONOLULU INDICATE THE PASSENGER SEAT OCCUPANCY SENSOR HAS A FAULT. LOOKING UNDER THE SEAT, IT COULD BE A FAULTY WIRING HARNESS OR FAULTY CONNECTER AS THEY APPEAR VULNERABLE TO SEAT MOVEMENT FORWARD OR BACKWARDS. THE MINI DEALERSHIP ALSO STATED THE OBNOXIOUSLY EXPENSIVE PART WAS ON NATIONAL BACK-ORDER.

I WAS INFORMED BY MY MINI SERVICE DEPARTMENT THAT THE PASSENGER SIDE AIR BAG SENSOR LOCATED UNDER THE PASSENGER SEAT WAS MALFUNCTIONING AND NEEDED TO BE REPLACED. THIS EXACT PART HAS BEEN THE CAUSE OF A RECALL FOR MINIS MADE THE SAME YEAR AS MINE, BUT MY CAR IS NOT INCLUDED IN THE RECALL. THIS IS OBVIOUSLY THE SAME PROBLEM THAT GENERATED THE RECALL. I CANNOT AFFORD TO MAKE THIS REPAIR MYSELF, AND NEITHER THE MINI DEALER NOR MINI CORPORATE HAS BEEN HELPFUL IN RESOLVING THIS ISSUE. I FEEL THAT MY CAR SHOULD BE INCLUDED IN THIS RECALL AND THEREFORE SHOULD BE REPAIRED AT NO COST TO ME. I'D LIKE TO REQUEST THAT MY CAR BE INCLUDED IN THE RECALL OFFICIALLY, SO THAT I CAN COMPLETE THESE REPAIRS. OTHERWISE, I RISK DRIVING UNSAFELY, WITHOUT THE FUNCTION OF THE PASSENGER SIDE AIRBAG.

MY 2007 MINI COOPER STARTED TO OVERHEAT, DISPLAYING BOTH THE YELLOW AND RED INDICATION LIGHT SIMULTANEOUSLY. I STOPPED, LOOKED AT THE MANUAL AND IT SUGGESTED THAT I TURN THE CAR OFF AND LET IT COOL OFF. I LET MY MINI "COOL DOWN" AND WHEN I WENT TO START MY CAR IT WOULD NOT START UP. MY CAR IMMEDIATELY SHUT OFF, I CALLED MINI COOPER WHICH IS 75 MILES AWAY AND GOT MY CAR TOWED. I WAS TOLD MY ENGINE NEEDS REPLACEMENT FOR 11K. MY MINI WAS CHECKED LESS THAN ONE MONTH AGO AND I RECEIVED NO WARNING THAT MY ENGINE WAS FAILING. MY 2007 MINI ONLY HAS 83,000 FAR FROM THE EXPECTED OVER 100,000 LIFE EXPECTANCY. I WAS TOLD MY ENGINE FAILED DUE TO LOW COMPRESSION AND THE REPLACEMENT OF A THERMOSTAT; A THERMOSTAT THAT HAVEN'T BEEN IN STOCK FOR MONTHS. AFTER GOOGLING THIS ISSUE, I FOUND HUNDREDS OF COMPLAINTS FOR THE SAME ISSUE. BMW REFUSE TO RECALL THE THERMOSTAT OR ENGINE, AND IT'S AN OUTRAGE. TO MAKE MATTERS WORST, A FAIR CONDITION, RUNNING 2007 MINI W/83,000 MILES AND PACKAGES VALUE IS LESS THAN 5K, A CLEAR SIGN OF THE WORTH OF A MINI. SUPER SAD CUSTOMER.

TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG LIGHT REMAINED ILLUMINATED. THE DEALER DIAGNOSED THAT THE FRONT PASSENGER SEAT OCCUPANT DETECTION MALFUNCTIONED AND/OR WAS FAULTY. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.

ENGINE WAS RUNNING EXTREMELY ROUGH AND VERY LOUD ENGINE NOISE RATTLE. TOOK THE CAR TO MINI COOPER SERVICE DEPARTMENT IN JACKSONVILLE FOR DIAGNOSTIC THEY NEED TO REPLACE THE TIMING CHAIN, THEY WANT TO CHARGE ME OVER 2,800. WHEN MY UNDERSTANDING THIS ISSUE WAS ADDRESSED BY A RECALL TO BE REPAIR WITHOUT CHARGE.

WHEN I START MY CAR WHILE PARKED IN MY GARAGE FROM COLD THERE IS A EXTREMELY LOUD RATTLE KNOCK NOISE IN THE ENGINE. I WAIT FOR IT TO WARM UP THEN I DRIVE IT THERE IS STILL A LOUD ENGINE NOISE THAT IT MAKE IT SOUND LIKE IF IT IS A DIESEL ENGINE. AND AFTERWARDS THE ENGINE STALLS AND IT LOOSES RPM WHEN I AM DRIVING ON THE HIGHWAY OR STREET MAKING IT HAZARDOUS AND DANGEROUS BECAUSE THE ENGINE CHOKES AND WANTS TO DIE OUT ON THE ROAD WHILE I AM DRIVING IT.

WHEN I START MY CAR WHILE PARKED IN MY GARAGE FROM COLD THERE IS A EXTREMELY LOUD RATTLE KNOCK NOISE IN THE ENGINE. EVEN IF I WAIT FOR IT TO WARM UP WHILE I AM DRIVING THERE IS STILL A LOUD ENGINE NOISE THAT IT MAKE IT SHOULD LIKE IF IT IS A DIESEL ENGINE. AND AFTERWARDS THE ENGINE STALLS DRIVING ON THE HIGHWAY AND IT LOOSES ITS RPM WHILE DRIVING MAKING IT HAZARDOUS AND DANGEROUS BECAUSE IT APPEARS TO DIE OUT ON THE ROAD WHILE I AM DRIVING IT.

PASSENGER AIRBAG WARNING LIGHT IS ILLUMINATED AND CANNOT BE FIXED. PAASENGER SEAT WEIGHT WIRING HARNESS IS DEFECTIVE. THE REPLACEMENT PARTS CANNOT BE PURCHASED (6 MONTH BACKLIST). THIS IS A VERY DANGEROUS DEFECT.

PASSENGER SEAT AIR BAG LIGHT STAYS ON MOST OF THE TIME. LOCAL DEALERSHIP DIAGNOSED PASSENGER SEAT SENSOR MAT DEFECTIVE AND MUST BE REPLACED. ON JANUARY 12, 2016, I PREPAID THE COST OF THE REPLACEMENT PART AT NEARLY $1,400 DOLLARS. ON JANUARY 21, 2016, THE DEALERSHIP INFORMED ME THAT THE PART IS ON NATIONAL BACK ORDER. ESTIMATED TIME OF ARRIVAL IS MAY 2016. WITH LAST YEAR'S RECALL OF 2005 AND 2006 MINI COOPER HARDTOPS AND 2005- 2008 CONVERTIBLES FOR THIS DEFECTIVE SAFETY PART, I AM SHOCKED AND DISAPPOINTED THERE IS A BACK ORDER AND SUCH A LONG WAIT TIME FOR THE REPLACEMENT PART TO ARRIVE.

FRONT PASSENGER SEAT AIR BAG INDICATOR LIGHT STAYED ON FOR LONG PERIODS AND SOMETIMES WENT OFF. YESTERDAY BMW/MINI DEALERSHIP DIAGNOSED SEAT SENSOR MAT SENDING FAULT CODE. DEALERSHIP WOULD NOT LET ME HAVE COPY OF DIAGNOSTIC REPORT AND I ASKED SEVERAL TIMES TO HAVE A COPY. PART MUST BE DEFECTIVE. MY OUT OF POCKET COST TO REPLACE DEFECTIVE SENSOR MAT IS $1,371.00 FOR THE PART WHICH I HAD TO PREPAY BEFORE DEALERSHIP WOULD ORDER IT. LABOR TO INSTALL AND PROGRAM NEW PASSENGER SEAT SENSOR MAT IS ESTIMATED AT $505.00. MILEAGE AT TIME OF FAILURE AROUND 22,000. CAR IS ON AN ISLAND WHERE YOU CANNOT DRIVE LONG DISTANCES. I MUST REPLACE THE SENSOR MAT NOW, AT MY OWN EXPENSE, IN ORDER TO PASS STATE OF HAWAII ANNUAL AUTOMOBILE SAFETY INSPECTION. MINI COOPERS MANUFACTURED IN 2005 AND 2006 WERE RECALLED LAST YEAR FOR DEFECTIVE PASSENGER SEAT SENSOR MATS. I THINK THE 2007 MINI COOPERS SHOULD ALSO BE RECALLED FOR SAME DEFECT. MINI COOPER 2007 CONVERTIBLES WERE RECALLED FOR DEFECTIVE PASSENGER SEAT MAT SENSOR. WHY OMIT 2007 MINI COOPER HARD TOPS FROM THAT RECALL? IF MY CAR IS RECALLED IN THE FUTURE FOR THIS DEFECT, WILL I BE REIMBURSED BY BMW/MINI FOR MY OUT OF POCKET EXPENSES??

OIL FEED LINE LEAKING ON TURBO

I HAVE BEEN TOLD THAT MY MINI COOPER AIRBAG SYSTEM HAS HAD A MECHANICAL FAILURE WHICH HAS CAUSED THE CAR TO DISABLE THE AIRBAG SYSTEM. THERE IS CURRENTLY A RECALL HOWEVER MY VIN NUMBER ISN'T INCLUDED- I WOULD SUGGEST PERHAPS LOOKING INTO WHERE MINE WAS PRODUCED TO SEE IF THOSE ARE ALSO AFFECTED BY THIS RECALL. AN AIRBAG SYSTEM SHOULDN'T JUST DISABLE ITSELF- THAT DEFINITELY SEEMS LIKE A MANUFACTURER DEFECT.

TIMING CHAIN REPLACED AT 32K, JUST FAILED AGAIN AT 92K WITH MOBIL ONE OIL AND FILTER CHANGES EVERY 5K MILES. CHAIN JUMPED IN GARAGE DURING SHUT DOWN OF ENGINE. WOULD NOT RESTART. I CHECKED SPARK, FUSES FOR PRIMARY FUEL PUMP AND MADE A JUDGEMENT THAT IT WAS A FAILURE OF THE HIGH PRESSURE FUEL PUMP AND TOWED IT TO THE DEALER FOR WARRANTY REPLACEMENT. GOT THE CALL THE TIMING CHAIN JUMPED A LINK AND I WOULD NEED A REPLACEMENT AGAIN. CAN'T BELIEVE IT . THIRD CHAIN WITH GOOD LUBRICATION MAINTENANCE IN UNDER 92K.

I MOVED THE PASSENGER SEAT FORWARD TO LET SOMEONE INTO THE BACK SEAT. THE PASSENGER AIR BAG SENSOR LIGHT STARTED TO GO ON AND OFF LATER THAT DAY INDICATING THAT THAT THE AIR BAG WAS NOT ON FOR THE PASSENGER SEAT. NOW THE LIGHT IS ON CONSTANTLY. I SAW ON THE INTERNET THAT OVER 90,000 OF THESE SENSORS HAVE BEEN RECALLED INCLUDING THE 2007 MINI CONVERTIBLE, BUT NOT MY HARDTOP. WHY IS MY MODEL NOT INCLUDED IN THE RECALL? THIS IS A LITTLE CAR AND I AM AFRAID TO HAVE ANYONE SIT IN THE PASSENGER SEAT WITH THE AIRBAG DISENGAGED.

2007 MINI COOPER WITH 31,000 MILES. I AM USUALLY THE ONLY ONE IN THE CAR. ON THIS DAY MY HUSBAND AND A FRIEND WERE WITH ME. WE MOVED THE PASSENGER SEAT UP TO ALLOW THE THIRD PERSON TO GET IN THE BACK SEAT. LATER IN THE DAY THE LIGHT ON THE DASH WHICH SIGNIFIES THAT THE PASSENGER AIRBAG IS TURNED OFF STARTED GOING ON AND OFF. I THOUGHT MAYBE THERE WAS A LOOSE WIRE UNDER THE SEAT, BUT WAS TOLD BY A MECHANIC THAT I NEEDED A NEW AIRBAG SENSOR. THE PART COSTS 1100.00 AND WAS ORDERED TWO MONTHS AGO. I AM STILL WAITING. THE LIGHT IS ON ALL THE TIME NOW. APPARENTLY, MINI HAS RECALLED OVER 90,000 CARS WITH THIS SAME PROBLEM. THE CARS MADE IN 2006 ARE INCLUDED IN THE RECALL AS WELL AS 2007 CONVERTIBLES. HOW MANY PEOPLE HAVE TO REPORT THIS PROBLEM FOR ALL 2007'S TO BE INCLUDED IN THE RECALL? THIS IS AN ESPECIALLY ALARMING PROBLEM BECAUSE THE MINI IS SUCH A SMALL CAR. LUCKILY, WE HAVE TWO CARS AND I DO NOT HAVE TO PUT ANYONE IN THE PASSENGER SEAT UNTIL THIS IS FIXED.

AIR BAG LIGHT CAME ON AFTER THE PASSENGER SIDE SEAT WAS MOVED FORWARD TO ALLOW ENTRY TO THE REAR SEAT. THIS PROBLEM IS WELL DOCUMENTED BY NUMEROUS OTHER OWNERS ON THE INTERNET AND BMW HAS RECALLED CARS OLDER AND NEWER THAN MY CAR AND CONVERTIBLES FROM THE SAME YEAR.

2007 MINI COOPER SOLD TO ME WITH A BAD TIMING CHAIN, TIMING TENSIONER, CAMS AND ENGINE.

TL* THE CONTACT OWNS A 2007 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING SIGNAL ILLUMINATED. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

2007 MINI COOPER HARDTOP PURCHASED MAY 7, 2015 SUFFERED MAJOR ENGINE FAILURE DUE TO MANUFACTURER DEFECTIVE TIMING CHAIN & TIMING TENSIONER ISSUES, RESULTING IN LOUD TICKING INSIDE OF THE ENGINE ON THE PASSENGER SIDE..ESTIMATES TOTALING UP TO $2400.00 IN REPAIRS.....VEHICLE AT THIS POINT IS INOPERABLE.

WHEN DRIVING DOWN THE HIGHWAY AT 60 MPH, THE ENGINE LOST POWER AND HAD A HARD TIME GETTING IT TO THE NEAREST EXIT FOR SAFETY. WHEN I STOPPED THE CAR I ATTEMPTED TO CHECK THE FLUID LEVELS BUT THE CAR WAS TOO HOT TO CHECK AND I WAITED FOR ABOUT AN HOUR TO COOL. WHEN I WAS ABLE TO CHECK ALL LEVELS DOWN, INCLUDING THE OIL, WHICH I JUST HAD A CHANGE IN LESS THAN A WEEK PREVIOUS TO THIS INDENT. THE OIL LEVEL WAS DOWN 2 1/2 QUARTS AND THE WATER LEVEL WAS BELOW THE SAFETY LEVEL. WHEN I TOOK IT TO MY INDEPENDENT CERTIFIED BMW MECHANIC, HE ADVISED THAT THE TIMING BELT NEEDED TO BE REPLACED. I CALLED BMW AND MINI CORPORATE OFFICES AND THEY BOTH STATED THAT I SHOULD TAKE IT TO THE DEALERSHIP AND THEY MAY BE ABLE TO FIX AT A REDUCE COST. UPON FURTHER QUESTIONING, AND THEM STATING THAT THEY MAY NOT ASSIST DUE TO AGE, I CAME TO THE CONCLUSION THAT THE LIKELIHOOD OF THEM ASSISTING WAS ZERO. THEY STATE THAT THE WARRANTY WAS NO LONGER COVERING AND THAT THE CAR HAD TOO MANY MILES, 85K. I PREVIOUSLY HAD THE THERMOSTAT REPLACED, THE AIR INTAKE VALVE REPLACED, THE OIL PUMP REPLACED, AND NOW THE TIMING BELT TO THE SUM OF $4300 IN THE PAST YEAR AND HALF. WILL NEVER PURCHASE ANOTHER AND WILL NEVER ENCOURAGE ANYONE ELSE TO PURCHASE A BMW OR MINI PRODUCT. I WILL PAY AND CONTINUE TO DRIVE, BUT WILL PUT A MESSAGE ON IT TO NOT ASK ME OR COMMENT ON THE "CUTENESS" OF THE CAR BECAUSE IT IS A PIECE OF JUNK! I WOULD HAVE EXPECTED TO GET AT LEAST 200K OUT OF IT BEFORE THESE MAJOR REPAIRS SHOULD HAVE EVER OCCURRED! VERY FRUSTRATED, NOT TO MENTION DISAPPOINTED IN THIS HIGH PERFORMANCE VEHICLE THAT SELLS ITSELF WITH A SIMPLE DRIVE, BUT MECHANICALLY IS NOT SUPPORTED BY ITS MANUFACTURER.

AIR BAG LIGHT TURNED ON. PERFORMED A FAULT SURVEY AND FOUND THERE IS 1 RELATED FAULT CODE IN THE MRS CONTROL UNIT. PASSENGER SEAT OCCUPANCY SENSOR, NOT CURRENTLY PRESENT, OCCURRED 12 TIMES. NEED TO REPLACE THE SEAT OCCUPANCY SENSOR AND RE PROGRAM THE MRS CONTROL UNIT. TOTAL REPLACEMENT COST: $1,164.47 CALLED MINI HEADQUARTERS AND WAS TOLD THERE WAS NO WARRANTY OR RECALL FOR MY SPECIFIC CAR. HOWEVER, THEY TOLD ME THAT THE 2005, 2006 MINI COOPER HAD A RECALL FOR THE SEAT SENSOR. THIS IS A MAJOR PROBLEM AND SHOULD BE RECALLED FOR THE 2007 MODEL AS WELL.

MY 2007 MINI COOPER HAS 117K MILES AND WAS WORKING WELL UNTIL THE LAST MONTH WHEN IT STARTED BURNING OIL AND BLOWING BLACK SMOKE. THEN THE CHECK ENGINE LIGHT STARTED COMING ON BRIEFLY SO GOT MY MECHANIC TO CHECK IT OUT TODAY. THE ERROR CODE INDICATES THE TIMING CHAIN NEEDS REPLACING. COSTLY REPAIR AT $2,000 AND 2 WEEKS OUT OF COMMISSION. IN GOOGLING ONLINE THIS IS A REPORTED ISSUE WITH MY MODEL MINI FOR THOUSANDS OF FOLKS YET BMW /MINI HASN'T ISSUED A RECALL NOTICE.

THE PASSENGER AIRBAG LIGHT IS LIT AND CANNOT BE TURNED OFF, THIS IS THE SAME ISSUE OTHERS HAVE HAD. ALSO THE SAME PROBLEM THAT HAS HAPPENED TO THE CONVIRTIBLE 2007 MINIS THAT HAVE A OPEN RECALL TO GET THE SENSOR FIXED.

HAVING EXACT SAME SYMPTOMS AS DETAILED IN A SIMILAR RECALL (NHTSA CAMPAIGN NUMBER: 15V205000 -- FRONT PASSENGER SEAT OCCUPANT DETECTION MAT), IN ADDITION TO HAVING GOT A 93C3 FAULT CODE (SEAT-OCCUPANCY DETECTOR, PASSENGER). SEEMS OBVIOUS THAT THE DEFECT IS THE SAME DESPITE THE SUB-MODEL NOT BEING THE SAME (MINE IS A 2007 R56 MINI CLUBMAN, CLOSEST RECALLED MODEL IS 2007 R52 MINI CONVERTIBLE).

AT ANY GIVEN SPEED OR CONDITION THE PASSENGER SIDE AIRBAG WARNING LIGHT ILLUMINATES, MEANING THAT THE AIRBAG MAY NOT DEPLOY IN A CRASH . IN SOME INSTANCES THE LIGHTS WILL DISAPPEAR, BUT AT OTHER TIMES THE LIGHTS ARE ILLUMINATED CONTINUOUSLY. IT IS OF GREAT CONCERN THAT THIS PART HAS BEEN RECALLED AS A DEFECTIVE PART, BUT BECAUSE MY PRODUCTION DATE IS MERELY ONE MONTH OFF THERE IS NO RELIEF . IT SEEMS CONCERNING THAT THERE MAY BE A NUMBER OF THESE UNSAFE VEHICLES ON THE ROAD, BUT GIVEN THE DELAY TO INCLUDE THEM IN THE RECALL, MANY LIVES MAY UNKNOWINGLY BE AT RISK.

DRIVING PA TURNPIKE WHEN MY 2007 MINICOOPER TEMP LIGHT CAME ON, IMMEDIATELY FOLLOWED THE OIL AND ENGINE LIGHT. AS THE LIGHTS APPEARED, THE CAR WAS LOSING POWER. IT LOST POWER AS I WAS PULLING OFF THE ROAD. 3 MINUTES TOTAL. SMOKE POURED OUT. I OPENED THE HOLD TO SEE A 3 INCH HOLE MELTED AWAY. I CLOSED THE LID. CONTACTED MINI ROADSIDE SERVICE WHO WOULD NOT HONOR THE TOW. CALLED AAA WHO DID. CALLED MINI OF PITTSBURGH, JASON THOMPSON, WHO ONLY SERVICED MY MINI FOR 4 YEARS AND 35,000 MILES WHEN HE FIRST DIAGNOSED NEEDING A NEW ENGINE. I ASKED MANAGER CHRIS LASKO ABOUT ANY RECALLS? COULD IT BE A LEMON? NO THIS IS UNUSUAL FOR A MINI, WAS THE ANSWER. BEFORE AUTHORIZING REPAIRS I ASKED ABOUT THE ELECTRICAL SYSTEM AND THE EFFECTS OF OVERHEATING. NO ELECTRICAL ISSUES WHERE FOUND. THEY FELT CONFIDENT RECOMMENDING REPLACING A NEW ENGINE & PARTS. I OKAYED TO PUT IN ALL NEW STARTER, STARTER CORE, ENGINE, ENGINE CORE, ENGINE HARNESS, COLLAR SCREW, PING SENSOR, INTAKE MANIFOLD, CORE RETURN GASKET, IGNITION COILS, COLLAR SCREW, SCREW WITH WASHER, CORE RETURN WITH HEAT PR, SRP BELT, AND COOLANT, A WATER PUMP PULLEY, AND FEW OTHER 20 SOME PARTS TO GET IT BACK ON THE ROAD. A MONTH LATER, I RECEIVED A LETTER REVEALING A POTENTIAL PROBLEM WITH THE DURABILITY OF A VAPOR RECOVERY DIAGNOSTIC PUMP ON 07. FEDERAL EMISSIONS DEFECT WARRANTY COVERS 10YEAR OR 120K MILES. I CALLED THE DEALER, THEY SAID THAT IT DID NOT PERTAIN TO MY VEHICLE. 2015 DEJA VU AT 64K MILES. I WAS DRIVING, COMMUTING WHEN THE ENGINE LIGHT CAME ON AGAIN. I DROVE 2 MILES TO MY MINI DEALER. THEY SAID THEY COULD FIX IT BY PUTTING IN A NEW ENGINE. I HAD IT TOWED HOME. I HAVE CALLED & LEFT EMAIL'S WITH BMW/MINI CUSTOMER SERVICE. I HAVE HAD ZERO REPLY FROM THEN. THEY CLAIM TO BE THE ULTIMATE DRIVING MACHINE. AS AN ADVERTISING ASSOCIATE CREATIVE DIRECTOR, I THINK THE MORE HONEST AND REAL CLAIM WOULD BE THE ULTIMATE FARSE MACHINE.

INITIALLY THERE WAS AN INTERMITTENT INDICATION THAT THE PASSENGER SIDE AIR BAG WAS DEACTIVATED. PROBLEM IS GETTING TO BE MORE FREQUENT. OBDII FAULT CODE "93C3 SEAT-OCCUPANCY DETECTOR" IS SET. I AM TOLD THIS IS THE SAME FAULT CODE THAT RESULTED IN A RECALL OF THE 2006 MODEL YEAR MINI COOPER.

AIRBAG LIGHT WILL NOT GO OUT, ALL THESE [XXX] MINI COOPERS HAVE PROBLEMS WITH AIRBAGS, THIS IS PRETTY IMPORTANT...MINI WANTS $1500 TO REPAIR A KNOWN ISSUE...HOW MANY PEOPLE NEED TO DIE BEFORE MINI IS FORCED TO DO THE RIGHT THING AND REPAIR THESE [XXX] CARS????????????????? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE PASSENGER SIDE AIR BAG MAY NOT DEPLOY IN CASE OF A CRASH; HOWEVER, THE TECHNICIAN WAS UNABLE TO PROVIDE A REASON FOR THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 73,000.

THE PASSENGER SIDE AIRBAG PAD COMPONENT WAS FOUND TO BE DEFECTIVE BY MY SERVICE CENTER. THE PASSENGER SIDE AIRBAG WILL NOT DEPLOY IN A CRASH. IT IS APPROXIMATELY AN $1100 PART TO REPLACE PLUS LABOR. REPORTS ON VARIED NEWS MEDIA HAVE THIS AS A RECALL. I FIND NO INSTANCE OF A RECALL FROM BMW/MINI

OIL FEED LINE GOING INTO TURBO IS LEAKING OIL DIRECTLY ONTO TURBO. MINI USES A RUBBER O RING THAT IS CONNECTED TO A VERY HOT TURBO AND O RING WILL FAIL ON ALL MINI COOPERS WITH A TURBO. WHEN THIS RUBBER O RING FAILS IT WILL LEAK OIL DIRECTLY ONTO HOT TURBO AND CAUSE A FIRE. I THINK IT'S IN THE SAFETY OF ALL THAT THIS BE LOOKED INTO AND RECALLED. I BELIEVE MINI COOPER IS VERY AWARE OF THE PROBLEM AND IS COVERING UP THE ISSUE BY INSTALLING A CHEAP HEAT SHIELD ON OIL LINE BUT THIS IS A BANDAID FIX AT BEST. *TR

ENGINE FAILURE OCCURRED WHEN DRIVING ON MAJOR FREEWAY AT POSTED SPEED LIMITED OF 75 MPH. PULLING OFF ON SLIP ROAD DUE TO ENGINE STOPPING. ONLY AFTER FULL STOP DID ENGINE WARNING LIGHTS COME ON. CHECKED UNDER HOOD AND FOUND COOLANT HAD EVACUATED THE SYSTEM. ENGINE WOULD NOT RESTART. TOWED TO MECHANIC AND FOUND THAT THE GEAR SHIFTER HAD WORN THROUGH COOLANT HOSE DUE TO ENGINEERING DEFECT.

I JUST PURCHASED A 2007 MINI COOPER S AND FOUND OUT THE TIMING CHAIN NEEDS TO BE REPLACED FOR THE SECOND TIME. I UNDERSTAND THIS IS A VERY COMMON FAULT WITH THIS CAR AND A CLASS ACTION LAWSUIT IS ONGOING. I ALSO AM TRYING TO FIND OUT IF MY CAR HAS ACTUALLY HAD ALL RECALLED ITEMS REPAIRED. PLEASE LET ME KNOW HOW TO ASCERTAIN THIS INFORMATION. *TR

I WAS GETTING ON INTERSTATE STILL ON THE ON RAMP WHEN MY MINI DIED AND STARTED SMOKING WITH NO WARNING. HAD TO HAVE IT TOWED. INSURANCE STATED IT WAS AN ELECTRICAL WIRE FIRE SO IT ISN'T COVERED UNDER INSURANCE. CAN MINI PAY TO HAVE IT FIXED? THE MANUFACTURER SHOULD BE HELD LIABLE. I ALREADY HAD TO GET A NEW WATER PUMP LAST YEAR THAT WASN'T COVERED EITHER. THESE AREN'T CHEAP VEHICLES YET THEY EXPECT US TO PAY FOR THE MISTAKE THAT WE DID NOT CAUSE! PAID $18K FOR THIS CAR AND HAVE PUT OVER $3K FOR REPAIRS WITH LESS THE 80K MILES. COME ON MINI COOPER THIS IS TERRIBLE BUSINESS! IN MY PROFESSION IF I WERE TO SELL A DEFECTIVE PART FOR AN OIL RIG, I WOULD HAVE TO REPLACE IT EVEN YEARS LATER. THIS GOES FOR ANY PROFESSION! *TR

TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

THE PASSENGER SEAT AIR BAG LIGHT IS ILLUMINATED AND CANNOT BE RESET DUE TO A FAULTY OCCUPATION SENSOR. ACCORDING TO THE SERVICE TECHNICIAN THIS WILL CAUSE THE AIR BAG TO MALFUNCTION IF AN ACCIDENT WERE TO OCCUR. THIS IS A COMMON PROBLEM WITH THESE CARS AND COSTS OVER $1000 TO REPAIR AND IS NOT COVERED BY THE MANUFACTURER.

AS I WAS DRIVING HOME FOR EASTER, ALL OF THE SUDDEN A LIGHT CAME ON. I PULLED TO THE SIDE OF THE ROAD AND THE ELECTRICITY WENT OUT IN MY CAR. I WAS STRANDED IN THE MIDDLE OF NOWHERE. THE TIMING CHAIN IN MY CAR BROKE AND CAUSED CATASTROPHIC ENGINE FAILURE. *TR

THE PASSENGER SEAT HAS A PRESSURE MAT BUILT INTO THAT HAS FAILED AND IT IS CAUSING THE SRS/AIRBAG LIGHT TO STAY LIT. THIS IS TURNING OFF THE PASSENGER SIDE AIRBAG OFF WHICH CAUSES THE PASSENGER TO NOT HAVE AIRBAG PROTECTION. THIS IS A VERY COMMON PROBLEM ON ALL 2005 UP MINI COOPERS. *TR

MY VEHICLE IS A 2007 MINI COOPER S. THE YELLOW "PASSENGER AIRBAG OFF" LIGHT ON THE OVERHEAD CONSOLE IS ALWAYS ON. THE AIRBAG LIGHT AND THE BUCKLE LIGHT ARE ALWAYS ON. THESE LIGHTS ARE ON REGARDLESS WHETHER THERE IS A FRONT PASSENGER. THE CAR WAS NEVER IN ANY KIND OF ACCIDENTS AND THE AIRBAGS WERE NEVER DEPLOYED. I BOUGHT THE CAR USED IN NOV 2013 AND THE LIGHTS CAME ON PERMANENTLY DURING EARLY 2015. AS I FOUND OUT RECENTLY, A FAULTY AIRBAG SENSOR IS A VERY SERIOUS SAFETY ISSUE. THESE DAYS AND THE PAST YEAR, WITHOUT KNOWING THE DANGER OF A FAULTY AIRBAG SENSOR, I HAVE BEEN DRIVING MY WIFE AND SOMETIME MY MOTHER AROUND. I CAN NOT IMAGINE INVOLVING IN AN ACCIDENT WITH SOMEONE SITTING ON THE PASSENGER SEAT. I HOPE BMW/MINI CAN ADDRESS THIS ISSUE ASAP.

I BOUGHT A CAR FROM NEW COUNTRY MINI IN HARTFORD ON JANUARY 2, 2015. AT FIRST THE CAR WORKED GREAT, HOWEVER THE FRICTION POINT OF THE CLUTCH WAS PRETTY FAR TOWARDS THE END RANGE. BECAUSE IT'S A HYDRAULIC CLUTCH, I THOUGHT THIS WAS ADJUSTABLE. HOWEVER I STARTED NOTICING THE NEXT DAY THAT THERE WAS A GRINDING NOISE COMING OUT OF FIRST AND IN REVERSE. I EMAILED THE PERSON AT NEW COUNTRY MINI FROM WHOM I BOUGHT IT FROM EXPLAINING WHAT I WAS HEARING/FEELING AND WAS CONCERNED ABOUT THE CLUTCH GOING. HE REPLIED THAT IT PROBABLY JUST NEEDED TO BE OILED AND IT WOULD BE FINE. HE DID NOT ASK ANY OTHER QUALIFYING QUESTIONS, OR OFFER TO LOOK AT IT. AS OF JANUARY 5, THE CLUTCH HAS BECOME EXPONENTIALLY WORSE. THE CAR NOW SHUTTERS WHILE ENGAGING THE CLUTCH, AND CONTINUES TO SHUTTER AFTER THE CLUTCH HAS BEEN ENGAGED. ADDITIONALLY THERE IS A BURNING SMELL COMING FROM THE CAR. ALSO, THIS IS NOT MY FIRST CAR I'VE HAD THAT WAS A MANUAL TRANSMISSION. I LEARNED HOW TO DRIVE ONE WHEN I WAS 16, SO I DON'T BELIEVE THIS IS DRIVER ERROR; ESPECIALLY HOW QUICK THE CLUTCH DIMINISHED. I AM INCLINED TO THINK THAT NEW COUNTRY MINI NEW ABOUT THE PROBLEM PRIOR TO SELLING IT, BUT DIDN'T DO ANYTHING ABOUT IT. MOREOVER, THERE IS A CLUNK THAT HAPPENS WHEN ACCELERATING FROM 2ND GEAR TO 3RD GEAR. ANY AND ALL HELP WOULD BE GREATLY APPRECIATED. *TR

TL* THE CONTACT OWNS A 2007 MINI COOPER S. WHEN THE IGNITION SWITCH WAS TURNED TO THE RUN POSITION, THE PASSENGER SIDE AIR BAG DID NOT ILLUMINATE WHEN THE SEAT WAS OCCUPIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.