2007 MINI Cooper Complaint Log

The contact owns a 2007 Mini Cooper. The contact stated that while driving at an undisclosed speed, the engine seized. No warning lights were illuminated. The vehicle was towed to the residence. The contact, who was an independent mechanic, researched and diagnosed the failure with water damage to the junction box electronics. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall that had a similar failure description; however, the VIN was not under recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 116,000.

The contact owns a 2007 Mini Cooper S. The contact stated that water was entering the vehicle through the sunroof. The contact stated that the water was collecting inside the headliner and would overflow and leak down the driver’s and passenger’s side sun visors and into the electronics of the footwell. Additionally, the front driver’s and passenger’s seats, floorboards, and dashboard would become soaked from moisture. Due to the failure, the vehicle would fail to start or operate as needed. Upon investigation, the contact discovered NHTSA Campaign Number: 23V337000 (Electrical System); however, the VIN was not included in the recall. An independent mechanic was notified about the failure and the contact was advised to park the vehicle outside as the failure could cause the vehicle to catch on fire. The manufacturer was then notified of the failure and the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 140,000.

The airbag warning light randomly remains on. From what I understand this is a known issue as there has been previous recalls by Mini. This could potentially mean the airbag system is faulty and non-operational. Based on online searches, it seems like a lot of there problem are wiring problems though, bad connections. The previous recalls should be extended further, as there are other cars with the same problem, like mine.

On almost all r56 model mini coopers the passenger seat occupancy sensor has a major malfunction that causes it to fail and pop up an airbag sensor light even when someone is sitting in the seat, Mini USA did not issue a recall but rather a reimbursement form for owners in 2017 the last year of production for that car and did not publicly disclose this. I feel as though this should be a recall as it is common enough for bypass devices to be normal for this car

[XXX]. Mini Cooper 2007-2013: Recalls and TSB. My car is part of a recall under MINI Recall for Timing Chains. I understand now it was settled as part of a class action lawsuit that extended the warranty. I always take my car to a dealer and now after mileage they told me that they want me to pay out of my pocket. My car is a 2007 S. My mileage is 105,000K miles. The recall notice is for the year of my car and they are saying my car is too old and the mileage. This recall is for the year of my car so I am not understanding. Upon inspection by the dealer, it and needs to be replaced and cost $4,100.00. I don't have that kind of money. . My name is [XXX], [XXX]., [XXX], [XXX]. Phone #[XXX]. The dealership is Mini Cooper 1660 E.Spring Street, Long Beach Ca 90806. I never received this recall notice and knew of this only because I took my car to the dealer for something else related for the 3rd time.

The contact owns a 2007 Mini Cooper. The contact stated while operating the vehicle, the check engine, ABS, and Dynamic Stability Control (DSC) warning lights remained illuminated, and the vehicle lost motive power and stalled. The vehicle was taken to the local mechanic who diagnosed that the foot well control module was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer was notified of the failure and the contact was informed that the VIN was not included in NHTSA Campaign Number: 23V337000 (Electrical System). The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was 130,000.

My Mini Cooper was rendered unsafe to drive as most of the exterior lights (i.e., headlights, brake lights, turn signals) stopped working--all at once. A local mechanic verified that the electrical short resulted from a severely corroded Footwell Control Module, which is the subject of the recall (Recall No. 23V-337, July 2023) for which a "Remedy is Unavailable." When contacted, a case management specialist of BMW of North America could tell me only that a remedy is not yet available. Again, the car is unsafe to drive as it lacks exterior lighting. As such, I am forced to purchase another vehicle as the Mini Cooper sits unusable.

The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

I was notified in July 2023 by NHTSA of the potential failure of the Footwell Control Module and subsequent potential "thermal event which could increase the risk of a fire of injury." Apparently, a fix for this issue has not been developed yet. I am afraid to keep my car in the garage, which is attached to my house. 7 months. Does BMW engineering really not know how to replace this poorly-designed component?

[XXX] . Airbag sensor recall. My car is part of a recall under MINI Recall 23V-xxx: Footwell Module. I took my car to a dealer and they told me that they would not repair it because my car is a 2007. My mileage is 102,000K miles. The notice says Im covered but they say im not. The recall notice is for the year of my car and they are saying my car is too old. This recall is for the year of my car so I am not understanding. A light comes on that shows the passenger airbag. Upon inspection by the dealer, it is a faulty seat mat sensor and needs to be replaced and cost $2,120.56. I dont have that kind of money. This should be addressed under the recall. My name is [XXX] , [XXX] . Phone [XXX] . The dealership is Mini Cooper Downtown Los Angeles. 6333 S Almeda Los Angeles Ca 90001. I never received this recall notice and knew of this only because the light indicator came on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Restraint System Malfunction Fault in passenger-restraint system effecting airbag, belt tensioner or belt-force limiter. Having to replace passenger seat or sensor to indicate I have a passenger so the airbag will deploy. It looks like there may have been a recall for this in the past according to an article I found, but my VIN does not come up as needing this item replaced. Cost is approximately $800.

The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated the key fob failed to lock and unlock the vehicle, causing the contact to manually lock and unlock the vehicle. The contact also stated that the radio would change stations or power off independently. The vehicle had been taken to an electrician who referred the contact to the dealer. The dealer was contacted. The manufacturer was made aware of the failure. The failure mileage was 153,000. VIN tool confirms parts not available.

The contact owns a 2007 Mini Cooper S. The contact stated that while driving approximately 35-40 MPH, the parking brake engaged, and the vehicle came to a stop. The contact manually pulled the parking brake lever several times until the parking brake released. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 48,000.

The open recall for this vehicle has been open for 15 months now. Meanwhile my wife's car remains broken down with a bad footwell module due to the exact reason the recall is being issued. I contacted mini and they said I'd have to pay for repairs out of pocket and apply for reimbursement after they come up with a remedy. I have issues with this for a few reasons. First, the repair is costly. Second, it's already been over a year since the recall has been issued, and still no remedy so who knows when they'll actually have one. Third, they said that even if I pay for repairs out of pocket there's no guarantee I'd get reimbursed for them. In my opinion, for something as serious as this recall, the manufacturer should be on the clock to determine the remedy and repair customers cars. It would be nice if BMW/Mini would get some pressure to get this resolved so the my wife and the thousands of other people affected by this can enjoy the vehicles they spent their hard earned money on without worry that it might spontaneously burst into flames.

The contact owns a 2007 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the sunroof was inoperative. The contact waited for several minutes for the sunroof to return to normal operation. The "Passenger Air Bag Disabled" message was displayed on the instrument panel; however, the passenger’s seat was occupied. The infotainment system was unintentionally turned on while the vehicle was turned off. The check engine and low tire pressure warning light were intermittently illuminated. The failures occurred on several different occasions. The contact stated that there was no local dealer; a dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. Parts distribution disconnect.

The vehicle has been presenting issues with breaks, electrical issues, turning off while driving, misfires, air bags don't work, ADAS sometimes don't work, the vehicle chokes and has difficulty running at times, among other issues. There has been a recall since last year and I've tried contacting the manufacturer multiple times, but the issue has not been fixed yet. All of these problems are a great safety hazard for me and my family while on the road.

There is a warning light of airbag. But it havent reported when i purchased by a previous owner and carfax as well

VEHICLE WAS STATIONARY IN MY DRIVEWAY, WAS NOT STARTED AND WAS UNATTENDED, HAD NOT BEEN STARTED IN OVER A WEEK AND KEYS WERE NOT IN THE VEHICLES. THE VEHICLE SPONTANEOUSLY BURST INTO FLAMES WHICH BURNED THE ENGINE BAY AND FRONT END OF THE CAR BEFORE THE FIRE DEPT. ARRIVED AND EXTINGUISHED THE FIRE WITH FOAM. THE CAR HAD BEEN SITTING UNSTARTED FOR OVER A WEEK. I AM UNSURE OF WHAT CAUSED THE FIRE AND BECAUSE OF THE EXTENSIVE DAMAGE TO THE ENGINE BAY I COULD NOT DETERMINE WERE THE FIRE ORIGINATED. PERHAPS A PROFESSIONAL FIRE EXAMINER COULD DETERMINE THAT. I AM BLESSED THAT THIS DID NOT HAPPEN WHILE PARKED IN MY GARAGE BUT WAS SCARY. I JUST WANT THIS INCIDENT ON RECORD SO THAT OTHERS WHICH OWN THIS PARTICULAR TYPE OF VEHICLE CAN BE WARNED ABOUT THE POTENTIAL DANGERS. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAD A COUPLE OF UPDATES DONE PER BMW SUCH AS THE TAILPIPES AND TIMING CHAIN IN THE ENGINE. I WAS NOT AWARE OF ANY ADDITIONAL RECALLS OR UPDATES BUT APPARENTLY THERE HAVE BEEN SOME INCIDENCES OF FIRES SUCH AS MINE WHICH I LEARNED ABOUT AFTER SEARCHING THE INTERNET TO SEE IF SIMILAR ISSUES HAD BEEN DOCUMENTED. I WILL ATTACH A FEW PICTURES FOR YOU TO HELP WITH YOUR ASSESSMENT. THANK YOU FOR YOUR TIME AND CONSIDERATION. I HOPE THIS INFORMATION WILL BE SOME HELP TO OTHERS IN PREVENTING A SIMILAR SITUATION. I THANK GOD NO ONE WAS INJURED OR PROPERTY DAMAGED OTHER THAN MY CAR. THE FIRE DEPARTMENT MADE A REPORT BUT IT DID NOT INCLUDE INVESTIGATING THE CAUSE JUST A RESPONSE TO A FIRE. *TR

VACUUM PUMP AND WATER PUMP NEED TO BE REPLACE

TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED WHILE AT A STANDSTILL, THE VEHICLE BEGAN TO EMIT SMOKE FROM THE ENGINE COMPARTMENT. THE CONTACT STATED CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO LOCAL DEALER SCHOMP MINI (1001 PLUM VALLEY LN, HIGHLANDS RANCH, CO 80129 (303) 872-5752) WHERE IT WAS DIAGNOSED THAT THE THERMAL HOUSING NEEDED TO BE REPLACED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 18V248000 (ENGINE AND ENGINE COOLING) HOWEVER THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 138,867.

THERMOSTAST HOUSING REPLACEMENT AND WATER PIPE. COOLING SYSTEM NEEDS TO BE FLUSH. ENGINE REBUILD DUE OVER HEATING. OXYGEN SENSOR REPLACEMENT. TIMING CHAIN REPLACEMENT. THERMOSTAST REPLACEMENT.

PASSENGER OCCUPANCY AIRBAG SENSOR FAILED, MINI HAS OFFERED A RECALL FOR SIMILAR MODELS BUT ONLY THE CONVERTIBLE AND NOT THE HARD-TOP; HOWEVER THIS IS A PROBLEM FOR THE NON CONVERTIBLES. IT'S INCREDIBLY UNSAFE FOR THE SENSOR TO GO OFF AND NOT BE RESET. I WOULD LIKE MINI TO RECALL AND REPAIR ALL MODELS WITH THAT SENSOR THAT FAILS, NOT JUST CONVERTIBLE MODELS.

PROBLEM 1: CLUTCH/TRANSMISSION FAILED AT 50,000 JUST AFTER WARRANTY. UNABLE TO SHIFT ON HIGHWAY, HAD TO STAY IN LOW GEAR. TRANSMISSION WAS REPLACED. IT FAILED A SECOND TIME, WAS REPLACED AT ABOUT 80,000. I BELIEVE IT IS FAILING AGAIN AS THE CLUTCH IS SLIPPING IN 1ST AND 2ND GEARS; MINI COOPER SAYS THEY NOTE NO PROBLEM. PROBLEM 2: TIMING CHAIN. PARKED, MY CAR WOULD NOT START EASILY; STARTED ON 3RD TRY. MY CAR STALLED, STOPPED ON THE HIGHWAY AS I WAS SLOWING DOWN DUE TO TRAFFIC. RESTARTED AND CONTINUED. NO ENGINE LIGHT. DRIVING TO MINI SERVICE, CAR STALLED COMING IN; HAD TO COAST IN. FOUND TO BE TIMING CHAIN, VALVETRONIC ECCENTRIC SHAFT, PERHAPS PARTS FALLING INTO OIL PAN. $2800 IN REPAIRS. WHEN I ASKED ABOUT LAW SUITS OR RECALLS OVER THE LAST 3 YEARS BECAUSE I'VE HAD MAJOR PERFORMANCE ISSUES, MINI COOPER STATED NO KNOWN SUITS EVEN THOUGH THERE WERE. I FIND THAT THERE HAVE BEEN SUITS, AND I "MISSED THE WINDOW" FOR THE TIMING CHAIN.

PASSENGER SEAT MAT SENSOR ON 2007 MINI COOPER FAULTED. THERE WAS A RECALL ON BMW AND MINI COOPERS EXCEPT FOR THIS BASE MODEL. DEALER SAID IT WOULD BE $1800. TO FIX I WOULD THINK THE PARTS FOR THIS CAR ARE THE SAME. SHOULD BE RECALLED.

PASSENGER SEAT MAT OCCUPANCY SENSOR/PAD HAS GONE BAD AGAIN AFTER THE RECALL.*DT SAFETY RECALL REPORT XXX-XXX 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

I HAVE BEEN DRIVING MINI S 2007 FOR MORE THAN A YEAR WITH NO SERIOUS ISSUES OTHER THAN ONE CHECK ENGINE LIGHT ISSUE, WHICH WAS RESOLVED SIMPLY BY A MECHANIC CHECK AT BMW SERVICE CENTER. ON SUNDAY EVENING MAY 26, 2019, AS I WAS PLANNING TO GO OUT, I OBSERVED THE STEERING ALERT SIGN ON. I TRIED RESTARTING AND SHUTTING OFF ENGINE MULTIPLE TIMES THINKING IT MAY BE AN ELECTRONIC ABERRATION WHICH MAY BE KICKED AWAY BY BRUTE FORCE OF RESTARTING THE IGNITION. AFTER 30-45 MINUTES OF THIS FRUITLESS EXERCISE, I TURNED MY ATTENTION ONLINE WHERE I FOUND NUMEROUS AUTO BLOGS OF STARTING THE CAR WITH JUMPERS BATTERY TO REPLACING POWER STEERING FLUID. SINCE MINI SERVICE WAS CLOSED, I HAD TO SEEK HELP FROM MY INSURANCE COMPANY. THEY SENT A PERSON AFTER TWO HOURS TO USE JUMPERS, BUT THAT DID NOT HELP EITHER. WE WERE ABLE TO CHECK THE POWER STEERING FLUID , AND THAT WAS ALSO FULL TO THE MARK. ON FURTHER RESEARCH ONLINE, I DISCOVERED TO MY UTTER DISAPPOINTMENT THAT MINI COOPERS HAVE BEEN PLAGUED WITH POWER STEERING ISSUES DUE TO INHERENT FLAW OF PLACEMENT AND DESIGN OF POWER STEERING PUMP. IT IS VERY WELL DOCUMENTED ACROSS REPUTED CAR JOURNALS/MAGAZINES THAT THE POWER STEERING PUMP FAILURE WILL DEFINITELY HAPPEN IN MINI COOPERS, AND THE ONLY VARIABLE IS THE TIME. I WAS THOROUGHLY CRESTFALLEN GIVEN I HAD PLACED SO MUCH TRUST IN THE BRAND AND THE QUALITY OF MINI COOPER. THE PURPOSE OF THIS COMPLAINT IS TWO PRONGED- ONE IS OBVIOUSLY TO HIGHLIGHT THE PROBLEM ONCE AGAIN AND MAKING SURE MINI ENGINEERS SOLVE THIS PROBLEM IN THEIR ENGINEERING DESIGN PROCESSES. SECOND- IS TO REQUEST TO HAVE THE POWER STEERING ISSUE FIXED IN MY CAR BY MINI. GIVEN THAT THE ISSUE HAS BASIS IN THE INHERENT FLAW OF THE DESIGN, I BELIEVE MINI COOPER WILL WAIVE OFF THE COST OF SERVICES AND PARTS TO GET THIS ISSUE FIXED. THIS IS NOT USUAL WEAR AND TEAR WHOSE COSTS SHOULD BE BORNE BY THE CUSTOMER.

THE TURBOCHARGER HAD TO BE REPLACED, NEW TURBO GOT HOT AND MELTED THE VALVE COVER. THEN THE TURBOCHARGER CAUGHT FIRE WHILE IN MOTION IN A RURAL NEIGHBORHOOD. ALL WITHIN 6 MONTHS.

TO THE RIGHT OF MY GAS PEDAL IN MY CAR GETS SUPER HOT! IT REACHES OVER 207 FAHRENHEIT DEGREES. IT GETS WORSE WHEN I USE MY AC. WHEN I WEAR MY FLIP FLOPS IT BURNS MY TOES.

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A CATASTROPHIC ENGINE FAILURE WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BRAMAN MINI OF PALM BEACH (2815 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409, (561) 257-4774). THE DEALER INDICATED THAT THE MANUFACTURER SERVICE CAMPAIGN WAS ONLY TO ADDRESS REPLACING THE TIMING CHAIN AND THAT THE REPLACEMENT OF THE ENGINE ASSEMBLY WAS NOT INCLUDED IN THE MANUFACTURER'S GUIDELINES OF THE SERVICE CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THEY COULD APPROVE THE DEALER REPLACING THE TIMING CHAIN AND THE ENGINE ASSEMBLY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY VEHICLE IS CURRENTLY @ BRAMAN BMW WPB (5612423210) FOR A TIMING CHAIN PROBLEM WHICH WAS UNDER RECALL. THE SERVICE ADVISOR CALLED ME AND NOTIFIED ME THAT THE TIMING CHAIN BROKE INSIDE THE ENGINE & COMPLETELY DESTROYED THE MOTOR. TE TIMING CHAIN JOB ALONE ESTIMATE IS $3800, BUT THEYVE NOTIFIED ME THAT THE ENGINE IS UNREPAIRABLE & MUST BE REPLACED! THEY ALSO FAILED TO ACKNOWLEDGE THAT THIS HAPPEN WHILST DRIVING ON AN INTERSTATE, ALMOST CAUSING A HUGE ACCIDENT!! PLEASE HELP!! MINI APPARENTLY CARES MORE ABOUT MONEY THAN LIVES!!

TIMING CHAIN TENSIONER BROKE AND MESSED UP THE ENGINE

TAKATA RECALL, I HAVE A 2007 MINI COOPER THAT ONLY HAS 84000 MILES AND HAVE HAD TO HAVE THE TIME CHAIN REPLACE 4 TIMES. THE REPAIR GARAGE IS TELLING ME THAT MINI KEEPS UPDATING THE KITS FOR EVERY REPAIR. THE TIME CHAIN WAS REPLACED IN 2009, 2012,2016,2018. ONCE THING THEY DID TELL ME THAT I DON'T KEEP ENOUGH OIL IN THE CAR, BUT IF THE OIL LIGHT DOESN'T COME ON HOW AM I TO KNOW THIS. I DON'T HAVE $2000.00 TO $2500.00 EVERY COUPLE OF YEARS TO KEEP GETTING THE CAR REPAIRED. SO I'M THINKING ABOUT GETTING READ OF THE CAR. HAS ANYONE ELSE HAD THIS PROBLEM.

THERE WAS A RECALL FOR THE TIMING CHAIN, SO I HAD IT REPLACED IN THE RECALL PROGRAM THAT WAS OFFERED THROUGH MINI COOPER. LESS THEN 2 YEARS LATER, MY TIMING CHAIN BROKE AGAIN, AND HAS DAMAGED THE MOTOR OF MY CAR. IT WOULD NOT START

TRANSMISSION ISSUE: WHEN INDICATOR DISPLAY OF TRANSMISSION STATUS IS NOT THE SAME AS SELECTED ON THE STICK. THEREFORE, CAR ALWAYS STUCK WHEN EVER TRANSMISSION IS PUT ON PARK MODE. SAFETY ISSUE IS MOST PEOPLE LAND THE TRANSMISSION ON NEUTRAL MODE TO AVOID LOCKING WHEN PARKING. THIS ISSUE CAN EFFECT SAFETY WHEN PARKED ON UP OR DOWN HILL CAUSE IT'S NOT ON PARKED MODE.

POWER STEERING FAILURE AT 71,000 MILES. ONE DAY THE POWER STEERING WAS FINE AND THE NEXT DAY WHEN STARTED, THE POWER STEERING FAILURE LIGHT WENT ON AND THERE WAS NO POWER STEERING.

THE PASSENGER SIDE SEAT SENSOR GOES ON AND OFF WHEN A PASSENGER IS SEATED. LIGHT INDICATORS AND ALARMS SOUND INTERMITTENTLY. PASSENGER AIR BAGS ARE TURNED OFF WHEN PASSENGER IS SEATED AND CAR IS MOVING. IF THERE IS NO PASSENGER THIS DOES NOT OCCUR.

MY CAR IS LITTLE OVER 102,000 MILES. IT SUDDENLY STOPPED, NEAR MY HOUSE AND I WAS NOT ABLE TO START AGAIN. REPLACED BATTERY, HOWEVER FOUND OUT THAT HIGH PRESSURE FUEL PUMP FAILED. WARRANTY REPORTED BY MINI EXPIRED EARLIER THIS YEAR. THIS COULD BE SAFETY ISSUE, IF CAR STOPS IN MIDDLE OF HIGHWAY.

PASSENGER SEAT GOT WET WINDOW LEFT OPEN WHILE PARKO

TIMING CHAIN MAKING LOUD NOISE WHEN STARTED

TAKATA RECALL. AIRBAG LIGHT CAME ON WHEN I SAT IN MY CAR ONE DAY AND WHEN I TOOK IT TO THE MINI COOPER DEALERSHIP A COUPLE OF DAYS LATER, IT WAS FOUND THAT THE DRIVER HEAD AIRBAG HAS FAILED FOR NO APPARENT REASON. THE AIRBAG HAS NEVER BEEN USED. HAVING THE AIRBAG FAIL ON A RANDOM DAY IS VERY DANGEROUS, CONSIDERING THE FACT THAT AN ACCIDENT COULD HAVE OCCURRED THAT DAY AND THE AIRBAG WOULD HAVE NEVER PROTECTED THE DRIVER. THIS IS VERY DISAPPOINTING AND INCREDIBLY STRANGE FOR AN AIRBAG TO FAIL.

THE AIR BAG/SEAT BELT SYSTEM INDICATOR LAMPS ON THE DASH (BEHIND THE STEERING WHEEL) AND IN THE SPEEDOMETER CLUSTER (CENTER OF DASHBOARD) ARE ON WHILE DRIVING THE CAR WITH THE SEAT BELTS PROPERLY FASTENED. THIS BEGAN ON ABOUT 12/21/2014 WITH AN ODOMETER READING OF 81,190 MILES. SHORTLY AFTER THAT I CONTACTED THE MOTORWERKS MINI, BLOOMINGTON, MN, AND WAS TOLD THERE WAS NO RECALL ON THIS ISSUE AND IT WAS NOT COVERED BY WARRANTY. I ALSO CONTACTED MINI CUSTOMER RELATIONS AND CHECKED THE NHTSA.GOV SITE TO CONFIRM THIS. I KEPT WATCHING THE TAKATA RECALLS, BUT MY CAR WAS NEVER INCLUDED. I ALSO CALLED THE DEALERSHIP AND MINI CUSTOMER RELATIONS SEVERAL MORE TIME, BUT GOT THE SAME ANSWER. THEN ON 5/11/17, WE RECEIVED A LIMITED EXTENDED WARRANTY LETTER FROM MINI THAT COVERED THE SEAT OCCUPANCY MAT. THE PROBLEM WAS THAT MINI'S "POLICY" WAS TO FIRST HAVE THE PROBLEM DIAGNOSED AT A MINI DEALER 'AT OUR COST'. WE WENT AHEAD AND DID THAT, PAID ALMOST $148.50, ONLY TO BE TOLD THE ISSUE WAS WITH THE COMPUTER, OR POSSIBLY THE WIRING HARNESS AND NEITHER OF THOSE ISSUES ARE COVERED BY THE LIMITED WARRANTY EXTENSION. THE ESTIMATED REPAIR COST RANGED FROM ABOUT $1,300-$4,000. I HAVE THE DEALERSHIP INVOICE (#1MCS838674), DATED 5/19/17 (ODOMETER 97,852) IF NEEDED. AS OF TODAY, JUNE 8, 2017, THE LIGHTS ARE STILL ON AND THE ODOMETER READS 98,069 MILES (SEE ATTACHED PHOTOS). I AM REQUESTING THAT THE NHTSA REVIEW THIS ISSUE TO DETERMINE IF IS SYSTEMIC AND MIGHT WARRANT A FURTHER INVESTIGATION OR A MANDATED RECALL. IF MORE INFORMATION IS NEEDED, PLEASE LET ME KNOW. THANKS'''''..

CAR CRASH MAY 30, 2017, DRIVER'S AIR BAG DID NOT DEPLOY CAUSING GREAT BODILY INJURY TO DRIVER.. DRIVER WAS TRAVELING 25 MPH IN TOWN AT AROUND 10:30 A.M.. DRIVER HAD A STROKE, PASSED OUT, CROSSED OVER TO OPPOSITE SIDE OF ROAD AND HIT AN UNOCCUPIED PARKED CAR. THAT CAR HIT ANOTHER PARKED VEHICLE AND CHAIN REACTION LEFT FOUR CARS IN THE ACCIDENT. STATE FARM OR GENE'S AUTO BODY SHOP HAVE PHOTOS.

PASSENGER DOOR SEAL FAILED RESULTING IN FLOODING OF THE ENTIRE PASSENGER SIDE. MOISTURE CAUSED THE STARTING SENSOR TO FAIL AND THE VEHICLE NOT TO START. THERE WAS ALSO RAPID GROWTH OF MOLD IN THE VEHICLE FROM THIS MOISTURE. THE ONLY RESOLUTION WAS TO REMOVE THE ENTIRE INTERIOR, SHAMPOO THE CARPET, AND DRY EVERYTHING OUT. ON-LINE RESEARCH (AFTER THE FACT) REVEALED THAT APPARENTLY THIS IS A KNOWN ISSUE BUT THERE DOESN'T SEEM TO BE A RECALL ISSUED.

TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED THAT THE SEAT BELT INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MINI OF NASHVILLE (LOCATED AT 1572 MEMORY LANE NASHVILLE, TN 37027 615-340-7098) WHERE IT WAS DIAGNOSED THAT THE SEAT MAT SENSOR NEEDED TO BE REPLACED; HOWEVER, THE PART WAS ON BACKORDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 46,000.

MINI COOPER S - NUMEROUS ISSUES FOUND HAVING PURCHASED A USED 2007 MINI COOPER S FROM A SMALL DEALER IN TALLAHASSEE, FLORIDA, WE DID OUR RESEARCH UP-FRONT WITH A 'CARFAX REPORT' WHICH SHOWED NO ISSUES, WE ALSO DID A VIN DATABASE SEARCH FOR RECALLS AND FOUND NO OPEN RECALLS AND ASSUMED THAT IT WAS SAFE TO PURCHASE WHICH WE DID FOR JUST OVER $5,000. NOW THAT WE ARE NEARING A YEAR INTO OUR 4-YEAR PAYMENT PLAN, ON JANUARY 17, 2016, MY WIFE WAS DRIVING NORTH ON I-75 IN GEORGIA AND AT APPROX. MILE MARKER 211, THE ENGINE SEIZED AND SHE REQUIRED A TOW OFF THE INTERSTATE. LUCKILY, THERE WAS NO ACCIDENT OR INJURY- BUT IT SEEMS THAT WOULD HAVE HELPED OUR CASE' UPON ATTEMPTING REPAIRS, WE FIND NUMEROUS ISSUES WITH THE ENGINE (2007 R56/N16 4 CYLINDER TURBOCHARGED) INCLUDING TIMING CHAIN, WATER PUMP, VACUUM PUMP, ETC' BELOW ARE PHOTOS OF REMOVED PARTS FROM THE ENGINE ' THE VACUUM PUMP SEIZED AND BENT THE METAL COMPONENTS ' SINCE THIS IS CONNECTED TO THE 'EXHAUST CAMSHAFT', WHEN IT SEIZED IT SEIZED THE EXHAUST CAMSHAFT ' ON THE OPPOSITE END OF THIS CAMSHAFT IS A SPROCKET WHICH CONNECTS THE TIMING CHAIN (ANOTHER KNOWN ISSUE WITH THIS VEHICLE) ' THE BOLT AND SPROCKET DROPPED INTO THE ENGINE AND TIMING CHAIN AREA, CREATING A CATASTROPHIC FAILURE WHICH IT APPEARS WE ARE GOING TO BE 'LEFT HOLDING THE BAG' FOR

THE "PASS AIR BAG OFF" WITH SEAT ICON/2 LIGHT (LOCATED ON THE DRIVER'S SIDE ABOVE THE REAR VIEW MIRROR) BEGAN TO COME ON INTERMITTENTLY WITH OR WITHOUT A PASSENGER IN THE FRONT PASSENGER SEAT WHEN THE ODOMETER READ ABOUT 50,000 MILES. THE LIGHT CAME ON PERMANENTLY AT AROUND 70,000 MILES. THE DEALERSHIP CHECKED, DID NOT FIND A LOOSE CONNECTION, AND SAID THE SENSOR NEEDED TO BE REPLACED. WE CONTACTED THE MINI CORPORATION BUT WERE INFORMED THAT ALTHOUGH THERE WAS A RECALL FOR OTHER 2007 MINI COOPER PASSENGER SEAT SENSORS FOR THE AIR BAG SYSTEM, THERE WAS NO RECALL FOR THE TWO-DOOR HARDTOP. WE REPLACED THE PASSENGER SEAT OCCUPANCY SENSOR FOR THE AIR BAG SYSTEM AT OUR OWN EXPENSE.

On 2014 a Class Action Lawsuit was filed against BMW OF NORTH AMERICA for claims regarding MINI COOPER models. Answering your questions as follows: -The failing component was the timing chain tensioner -Yes, engine stalled at any speed -No, dealer did not acknowledge the real problem -No, dealer did not told me about the Class Action Lawsuit, did not advice me of any preventive repair or to install a new timing chain tensioner, when the component failed dealer told me that the problem was a jumping timing chain ; the same excuse as in the lawsuit. -There was only an engine light, not any other warning light There were two repairs, the first for $ 2,629.10 on 6/18/2016 the second for $ 3,354.93 on 1/13/2017 dealer had a two years parts and labor warranty that didn't honor and in 2016 the lawsuit was active and not of my knowledge. My question is: if the production numbers engraved on the timing chain tensioner cylinder face match or are part of the production batch from the factory for which the class action lawsuit took place ? Numbers top line: 7565868 80-02 Lower line: IV/ IS GERMANY 3 1 0 This is looks like half cero All components (parts) and the vehicle are available for inspection. Once engine is out of timing pistons will hit the valves (interference engine), in my engine broke at least one valve seat, pieces fell into combustion chamber getting stuck between pistons and cylinder walls scratching these, result lost of compression, engine die. Engine was beyond any repair, and still was charged for. Lawsuit for vehicles manufactured goes to April 2007 mine was February 2007 Neither the MINI COOPER dealer or BMW North America corporate offices paid any attention to my complaint.