2003 Mitsubishi Outlander Complaint Log

The contact owns a 2003 Mitsubishi Outlander. The contact stated while driving at approximately 25 MPH, the vehicle came to an immediate stop and did not return to normal operation. The contact noticed that the front control arm had detached. No warning light was illuminated. The contact researched and became aware of NHTSA Campaign Number: 16V458000 (Suspension). The vehicle was not drivable and was towed to the residence. A dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the VIN was included in the recall but already had been serviced under the recall; however, the failure occurred. The failure mileage was 188,000.

REAR CONTROL ARMS ARE RUSTED THROUGH, THERE WAS A RECALL FOR THE FRONT AND HAD THE REPAIRS DONE. THE FRONT CONTROL ARM RECALL WAS DUE TO POOR RUST PROOFING DURING MANUFACTURING. THE REAR HAS THE SAME PROBLEM. CANNOT REALIGN REAR WHEELS AND REAR SWAY BAR BRACKET BROKE FREE ENTIRELY. VEHICLE IS NOW STATIONARY AS IT CANNOT BE DRIVEN.

TL* THE CONTACT OWNED A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED WHILE ATTEMPTING TO AVOID COLLIDING WITH A DEER. DURING THE CRASH, THE VEHICLE HAD ROLLED OVER AND THE DRIVER WAS KNOCKED UNCONSCIOUS. THE DRIVER SUSTAINED HEAD AND NECK INJURIES, A FRACTURED LEFT SHOULDER AND AN INJURED TORSO AND WAS TRANSPORTED TO THE HOSPITAL. THE VEHICLE WAS DESTROYED AND TOWED AWAY. A POLICE REPORT WAS TAKEN AT THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 340,000. *DT *TR *BF CONSUMER STATES THAT AIRBAGS FAILED TO DEPLOY DURING THE COLLISION. CONSUMER SAYS THAT MANUFACTURER WAS AWARE AIRBAG FAILURE SINCE 2004, BUT FAILED TO INFORM CONSUMERS. *DL

CAR TAKEN TO DEALERSHIP, ANDERSON MITSUBISHI, 8162790354), JANUARY 2017, FOR NHTSA RECALL 16V458. CROSSMEMBER NOT REPLACED OR RUST TREATED. CROSSMEMBER FAILED 4-20-2019. REPAIRED AT MY EXPENSE $2161.70. MADE CLAIM FOR REIMBURSEMENT THROUGH MITSUBISHI DEALER AND MITSUBISHI OF NORTH AMERICA. HAVE A MITSUBISHI FILE NUMBER [XXX]. MITSUBISHI OF NA HAS VERBALLY AGREED TO SETTLE, BUT HAS NOT CONTACTED ME SINCE AUGUST OF 2019. I HAVE NOT BEEN ABLE TO GET MY CALLS RETURNED SINCE. THE CROSSMEMBER BROKE WHILE MY WIFE WAS DRIVING ON CITY STREETS WHICH CAUSED THE CAR TO VEER INTO ONCOMING TRAFFIC LANE, WITHOUT ACCIDENT. CAR WAS TOWED AND REPAIRED AT MY EXPENSE. I NEED HELP GETTING MY REIMBURSEMENT PAID. I AM THE ORIGINAL OWNER OF THE CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

CAR HAS BEEN OWNED FOR 10+ YEARS AND HAS BEEN MAINTAINED VERY WELL. GAS MILEAGE HAS DROPPED SINCE 2014. CAR THREW A P420 CODE IN THE YEARS AFTER. CATALYTIC CONVERTER HAS BEEN REPLACED FOUR TIMES IN A YEAR. OXYGEN SENSOR HAS BEEN REPLACED AND NEW EXHAUST HAS BEEN INSTALLED. WE HAVE NOW SEEN THE EXHAUST MANIFOLD HAS A CRACK IN IT. THIS APPEARS TO BE A MANUFACTURER ISSUE.

AIR BAGS DID NOT DELPOY DURING CRASH. THE VEHICLE WAS TOTATLED AND I NO LONGER OWN THE VEHICLE. *JS

HVAC temperature control knob is hard to turn, it broke off.

TL* THE CONTACT OWNED A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE HEADLIGHTS INTERMITTENTLY ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, WAITED A WHILE, AND WAS ABLE TO RESUME DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. IN ADDITION, THE CONTACT CRASHED INTO ANOTHER VEHICLE WHILE DRIVING 30 MPH. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000(SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. DORSETT AUTOMOTIVE IN TERRE HAUTE, IN REFUSED TO PERFORM THE REPAIR BECAUSE THE PASSENGER SIDE OUTER TIE ROD AND LOWER CONTROL ARM NEEDED TO BE REPAIRED BEFORE THE RECALL REPAIR COULD BE COMPLETED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT THE COMPONENTS HAD TO BE REPAIRED BEFORE THE REMEDY COULD BE PERFORMED. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE ATTEMPTING TO CHECK UNDER THE VEHICLE, THE CONTACT NOTICED THAT THE REAR FRAME WAS ROTTED. THE VEHICLE WAS TAKEN TO CHERRY HILL MITSUBISHI AT (856) 471-1057 (1805 MARLTON PIKE W, CHERRY HILL, NJ 08002) WHERE IT WAS DIAGNOSED THAT THE REAR FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING UNKNOWN SPEEDS, THE CONTROL ARM, BALL JOINT, CROSS MEMBERS, AND CV AXLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER TOWED TO SAVANNAH MITSUBISHI (8203 WHITE BLUFF RD, SAVANNAH, GA 31406, PHONE NUMBER: (912) 226-6200) WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBERS WERE CORRODED THROUGH AND CAUSED THE CV AXLE, BALL JOINT, AND CONTROL ARM TO DETACH. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD NOT REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

HEAVY SMELL OF GASOLINE WHEN FUEL TANK IS FILLED. FILL GARAGE WITH FUMES. CHECK ENGINE LIGHT IS ON. IF FILLED TO A HALF TANK OR SO, NO INDICATION OF FUEL SMELL. DOES NOT APPEAR TO BE LEAKING. I HAD AN ASE CERTIFIED MECHANIC LOOK AT IT AND THE FUEL TANK AS WELL AS FILLER NOZZLE ARE DETERIORATED. I CALLED MITSUBISHI MOTORS NORTH AMERICA AND THEY ACTED AS IF THIS WAS THE FIRST TIME THEY EVER HEARD OF THIS PROBLEM. I CALLED MULTIPLE DEALERS, AND ALL HAVE EXPERIENCED THE SAME PROBLEM WITH THEIR CUSTOMERS. THE INTER-NET IS FULL OF SIMILAR COMPLAINTS ON 2003 TO 2006 OUTLANDERS. I HAVE HAD A RECALL FOR THE FRONT END BECAUSE OF EXCESSIVE RUST MAKING IT UNSAFE TO DRIVE. I DO NOT THINK THIS IS A NORMAL WEAR AND TEAR WITH THE FUEL TANK. MITSUBISHI SHOULD ACKNOWLEDGE THIS PROBLEM AND CORRECT IT FOR THEIR CUSTOMERS. I AM THE ORIGINAL OWNER. THE CAR IS ALWAYS GARAGED WHEN NOT BEING DRIVEN.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE SEAT BELT RETRACTOR MECHANISM FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 164,241.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE REAR SUSPENSION AND CROSS MEMBER WERE CORRODED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT A TRAVEL-ARM HUBBERING WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

I AM REFERRING TO A WELL KNOWN "STICKY HVAC MIX DOOR" ISSUE IN THE MITSUBISHI OUTLANDER AND LANCER VEHICLES IN MODEL YEAR 2003 (PERHAPS AMONG OTHER YEARS AND MODELS). THIS ISSUE CAN RESULT IN AN INABILITY TO DEFROST THE WINDSHIELD DURING COLD WEATHER DRIVING. I HAVE HAD THE "STICKY" ISSUE FOR SOME TIME, WHICH, WHILE IT WAS DIFFICULT TO TURN THE KNOB, WAS NOT A HUGE ISSUE. HOWEVER, RECENTLY WHILE DRIVING, THE DOOR WENT FROM "STICKY" TO "STUCK," ON THE "COLD" SETTING. MY WINDOWS GRADUALLY STARTED TO FOG AND I WAS UNABLE TO DEFOG THEM SINCE THE SYSTEM COULD NOT BLOW HOT AIR DUE TO THE STUCK MIX DOOR. I WAS DRIVING ON AN INTERSTATE HIGHWAY (I-39) IN CENTRAL WISCONSIN AT THE TIME, ON AUGUST 27, 2016 IN THE EVENING. IN LATE SUMMER / EARLY AUTUMN, THERE IS A WIDE TEMPERATURE SWING DURING THE DAY AND NIGHT, SO FLIPPING FROM HOT TO COLD SETTINGS IS VERY COMMON. FORTUNATELY IT WAS NOT EXTREMELY COLD SO I WAS ABLE TO TURN OFF THE HVAC AND OPEN ALL MY WINDOWS IN ORDER TO GET BY DURING MY SHORT DRIVE. HOWEVER, IN THE WINTER, I NEED TO HAVE IT SET ON "HOT" AT ALL TIMES: THEREFORE, FOR WINTER DRIVING, MY CAR WILL NOT BE DRIVABLE AT ALL DUE TO THIS ISSUE. PLEASE ISSUE A RECALL IN COLD WEATHER STATES ASAP. THIS IS A VERY WELL KNOWN ISSUE WITH THESE VEHICLES, BUT ONLY AT THIS TIME DID IT BECOME A SERIOUS CAUSE OF CONCERN: WHEN THE HVAC MIX DOOR IS STUCK ON THE COLD SETTING, THE INABILITY TO DEFOG THE WINDSHIELD IS A SERIOUS SAFETY ISSUE FOR THE DRIVER AS WELL AS FOR ANYONE ELSE SHARING THE ROAD.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN TO BE INSPECTED FOR NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION), THE TECHNICIAN INFORMED THAT THE FRONT CROSS MEMBER WAS CORRODED AND NEEDED TO BE REPLACED HOWEVER, THE PARTS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT UPON INSPECTING THE VEHICLE, IT WAS NOTICED THAT THERE HAD BEEN EXTENSIVE PREMATURE RUST AND CORROSION ON THE LOWER CONTROL ARM AND THE FRONT SUB-FRAME TO THE POINT THAT THE PART MIGHT FRACTURE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION), BUT WAS UNABLE TO DRIVE THE VEHICLE DUE TO THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE NEEDED TO BE TOWED TO THE DEALER AND WAS UNCERTAIN OF WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE CONDITION AND THEY PROVIDED NO SOLUTION TO GET THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000(SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE CONTACT STATED THAT THE RECALL SHOULD ALSO COVER THE FRAME THAT HELD THE REAR AXLE, WHICH THE CONTACT STATED WAS MORE RUSTED THAN THE FRONT FRAME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE RECALL DID NOT COVER THE REAR FRAME. THE FAILURE MILEAGE WAS 193,000. PARTS DISTRIBUTION DISCONNECT.

RECEIVED A SAFETY RECALL NOTICE IN AUGUST 2016. AS OF THIS DATE THE PART TO REPAIR THE VEHICLE IS NOT AVAILABLE. HAVE CALL MITSUBISHI SEVERAL TIMES AND THEY KEEP SAYING THE PART IS BEING PROCESSED. CONFUSION AS TO WHETHER THE PARTS ARE SENT TO A DEALER FOR REPAIR OR IF THE VEHICLE NEEDS TO BE INSPECTED FIRST AND THEN THE PART IS ORDERED BY THE DEALER. THE DEALER CLAIMS THAT THE VEHICLE NEEDS TO BE INSPECTED FIRST THEN THE PART IS ORDERED IF NECESSARY. MITSUBISHI STATES THAT THEY WILL DETERMINE HOW MANY PARTS TO SEND TO WHAT DEALERS. CONFUSION. NEAREST DEALER TO ME IS 3 TO 4 HOURS ONE WAY TRIP. IF THE VEHICLE NEEDS TO BE INSPECTED FIRST BEFORE THE PART IS ORDERED THEN IF WILL HAVE TO MAKE TWO 6 TO 8 HOUR ROUND TRIPS. HOW THE DEALER KNOWS HOW MANY PARTS TO SEND TO WHAT DEALERS DOES'T MAKE SENSE. THIS PART IS NEEDED TO PREVENT THE VEHICLE'S STEERING FROM FAILING. THE PART IS THE LOWER CONTROL ARM. PLEASE CLEAR THIS UP FOR ME.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE REAR CROSS MEMBER FRACTURED DUE TO CORROSION WHILE THE VEHICLE WAS PARKED AT THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION); HOWEVER, THE RECALL ONLY COVERED THE FRONT CROSS MEMBER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INSTRUCTED THAT THE REPAIRS WOULD NOT BE PERFORMED PER A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL SOUND WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE FRONT END OF THE VEHICLE SHOOK UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT IT NEEDED A WHEEL ALIGNMENT AND THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED INTERMITTENTLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION); HOWEVER,THE PART WAS UNAVAILABLE FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,432.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, IT WAS BROUGHT TO THE CONTACT'S ATTENTION THAT THE SUBFRAME AND REAR END WERE RUSTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,000.

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MUFFLER AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

THE CAR STEERS TO THE RIGHT ON HIGHWAY., UNABLE TO REPAIR.

THE VEHICLE IS WAS PURCHASED USED WITH NO CHECK ENGINE LIGHT ON AT THE TIME OF PURCHASE. AFTER DRIVING FOR A WEEK THE LIGHT CAME ON AND THERE WAS A STRONG FUEL SMELL AFTER FILLING THE GAS TANK. A DIAGNOSIS CHECK WAS DONE AND IT WAS FOUND THERE IS AN ISSUE WITH THE FUEL TANK. IT WAS BROUGHT TO THE DEALERSHIP AND FOUND THAT THERE IS A HOLE IN THE TOP OF THE GAS TANK CAUSING FUMES TO LEAK. THE TANK CANNOT GO BELOW A QUARTER TANK OR THE ENGINE WILL SHUT OFF AS WELL. AFTER RESEARCHING THROUGH THE INTERNET IT WAS FOUND THAT THIS IS A VERY COMMON PROBLEM WITH THE VEHICLE. MITSUBISHI WAS CONTACTED TO FIND OUT IF THERE WAS A RECALL TO FIND OUT THERE WAS NOT, THEY ALSO DID NOT ASSIST IN ANY WAY TO MAKE THIS ISSUE ANY BETTER. DEALERSHIP WOULD CHARGE $1700.00 TO REPLACE TANK.

SINGLE OWNER/USER;RETIRED, GARAGE KEPT. UNDERCARRIAGE SO ERODED WHEELS BEGAN TO LIST. IMPRACTICAL TO REPAIR. BODY AND ENGINE WITHOUT PROBLEMS. NOT NOTIFIED BY DEALERSHIP AT RECENT SERVICE THERE WAS A PROBLEM. AN UNKNOWN PERSON THAT DROVE BEHIND ME MENTIONED THAT I SHOULD GET REAR WHEEL LOOKED AT. WHEN BROUGHT FOR ALIGNMENT CHECK, I WAS NOTIFIED BY THE MECHANIC TO LOOK AT THE UNDERSIDE OF THE CAR. EROSION WAS SO BAD, I DROVE THE 5 MILES TO MY HOME AND WILL NOT TAKE IT ON THE ROAD AGAIN. NO RECALLS RECEIVED. *TR

TL* THE CONTACT OWNED A 2003 MITSUBISHI OUTLANDER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED SPARKS EMITTING NEAR THE RADIO. THE CONTACT ALSO STATED THAT THERE WAS SMOKE AND SUDDENLY THE INTERIOR FRONT OF THE VEHICLE CAUGHT FIRE. A POLICE AND FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 206,000.

HVAC KNOB HAS ALWAYS BEEN HARD TO TURN FROM HEAT TO COOL, BUT IT HAS NOW COMPLETELY BROKEN. IF YOU TURN IT TO HEAT IT BOUNCES BACK TO COOL. I HAVE NO HEATER OR DEFROST! I WAS QUOTED $1,500 TO FIX THE PROBLEM BECAUSE THE HVAC CABLE AND DOOR ARE STUCK SHUT. THE DEALER KNEW MY EXACT PROBLEM AND THE PART NUMBER OFF THE TOP OFF HIS HEAD! HE SAID IT IS A VERY COMMON PROBLEM, BUT THEY DON'T RECALL IT BECAUSE IT ISN'T A SAFETY HAZARD. I DON'T SEE HOW THIS IS SO. WE WERE PLUMMETED WITH SNOW AND FREEZING TEMPERATURES THIS WEEK AND I HAD TO USE AN ICE SCRAPPER ON THE INSIDE OF MY WINDOWS WHILE STOPPED AT LIGHTS! FREEZING AND NO VIABILITY SEEMS LIKE A SAFETY CONCERN TO ME. *TR

OVER THE LAST 4-6 MONTHS I NOTICED A GASOLINE ODOR AFTER FILLING THE GAS TANK (AFFECTED PART). THE GAS ODOR HAS GOTTEN SIGNIFICANTLY STRONGER OUTSIDE AND INSIDE THE VEHICLE EACH MONTH. IF I FILL THE GAS TANK TODAY THERE IS AN EXTREME GAS ODOR/FUME THAT IS LEAKING FROM THE GAS TANK. AS THE GAS TANK EMPTIES THE ODOR DECREASES. THERE ISN'T A GAS LIQUID LEAKAGE THAT YOU WOULD SEE ON THE GROUND, BUT A FLUME LEAKAGE THAT FILLS THE PASSENGER COMPARTMENT AND SURROUNDS THE OUTSIDE REAR AREA OF THE VEHICLE. I THINK IF THERE WAS SPARK, OPEN FLAME, REAR END COLLISION, OR IF THE VEHICLE WAS PARKED IN DIRECT SUN LIGHT A COMBUSTIBLE FIRE/EXPLOSION COULD OCCUR. THIS AN EXTREMELY DANGEROUS AND UNSAFE CONDITION. I HAVE BROUGHT THIS PROBLEM TO THE ATTENTION OF THE DEALER AND THEY HAVE RECEIVED MULTIPLE COMPLAINTS FROM CUSTOMERS OWNING 2003 AND NEWER MITSUBISHI MODEL YEARS, WITH THE SAME PROBLEM. THE SOLUTION IS TO REPLACE THE GAS TANK AT AN ESTIMATED COST OF $1500. THEY SAID THERE SHOULD BE RECALL FOR SOMETHING AS DANGEROUS AND LIFE THREATENING AS THIS BUT THERE ISN'T. THE OUTCOME COULD BE SIMILAR TO THE FORD PINTO GAS TANK DEFECT THAT CAUSED THE INJURY AND DEATH OF MANY PEOPLE BEFORE A RECALL WAS ISSUED NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION. *JS

WHEN I BOUGHT MY CAR SOME TIME LAST YEAR EVERYTHING SEEMED FINE BUT AFTER A FEW MONTHS THINGS STARTED TO GO WRONG ON THE CAR. IT BEGAN WITH ME CONSTANTLY HAVING TO GET THE OIL CHANGED THE TIRES WERE BAD THE CAR STARTED MAKING NOISES THAT I COULDN'T EXPLAIN AND THE TIRES IN THE TIRES IN THE BACK WERE CONSTANTLY BUSTING. THE ENGINE IS NOW GOING BAD AND I HAVE BOUGHT AT LEAST 10 SETS OF TIRES FOR THE BACK IN THIS YEAR ALONE. I DON'T HAVE THE MONEY TO KEEP PUTTING IN THIS CAR AND CONTINUE TO PAY THE LEASE OFF FOR IT AS WELL. ITS GETTING ABSOLUTELY RIDICULOUS. *TR

RECENTLY BOUGHT A USED 2003 MITSUBISHI OUTLANDER AND THE HEADLIGHT LENS ON BOTH SIDES ARE CRACKED, EXTREMELY CRAZED AND THE WHOLE THING IS MILKY, WHICH DULLS THE HEADLIGHT AT NIGHT, I HAVE RESEARCHED AND MITSUBISHI WILL NOT REPLACE AFTER WARRANTY, IT WOULD COST ABOUT $1000 TO REPLACE THE ENTIRE HEADLIGHT ASSEMBLIES. WITH ALL THE COMPLAINTS ON THIS ISSUE, MITSUBISHI SHOULD DO SOMETHING ABOUT IT. *TR

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE SEAT BELT FAILED TO UNLOCK. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. *TR

I PURCHASED MY 2003 MITSUBISHI OUTLANDER IN FEBRUARY, 2013 WITH 104,000 MILES ON IT. AT FIRST EVERYTHING SEEMED FINE, BUT AFTER 2 WEEKS THE BACK END OF THE CAR ON THE PASSENGER SIDE SQUEAKS AND MAKES LOTS OF NOISE. AT FIRST IT WOULD ONLY DO IT A LITTLE BUT IT GOT WORSE AND WORSE WITHIN A COUPLE WEEKS IT CONSTANTLY MAKES NOISE, WHICH IS VERY ANNOYING. I THINK THE DEALERSHIP MUST HAVE DONE A QUICK CHEAP FIX ON IT SO WHEN I TEST DROVE IT, IT WOULD NOT DO IT UNTIL IT WAS PURCHASED. I ALSO HAVE WATER SEEPING IN IN THE FLOOR NEXT TO THE DOOR ON THE DRIVER SIDE AND WATER COMING THROUGH THE DASH AREA ON THE PASSENGER SIDE WHEN IT RAINS OR IN A CAR WASH. I READ ONLINE THAT THAT CAN CAUSE ELECTRICAL PROBLEMS WHICH WORRY'S ME. MY HEAD LIGHTS ALSO HAVE CRACKS AND FOGGED UP AND MAKES IT HARD TO SEE AT NIGHT, WHICH I'VE SEEN TO BE A COMMON PROBLEM WITH THIS CAR. I DON'T UNDERSTAND WHY THIS CAR WAS NEVER RECALLED FOR ALL THE PROBLEMS IT HAS, THIS IS RIDICULOUS! *TR

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TEMPERATURE KNOB BROKE OFF AFTER GETTING STUCK. SOUNDS LIKE THIS HAPPENS QUITE FREQUENTLY. I GOT AN ESTIMATE TO FIX IT FROM THE DEALER. OVER $2000. MAJOR ISSUE IN THE WINTER FOR DEFROST/HEAT. *TR

DEFECTIVE HEADLAMP ASSEMBLIES ON 2003 MITSUBISHI OUTLANDER.. THE HEADLAMP LENSES ON THIS VEHICLE HAVE TOTALLY FAILED. THEY ARE MILKY IN COLOR, NOT THE CLEAR THEY SHOULD BE, AND THE LENSES THEMSELVES ARE CRACKED AND CRAZED, BUT SHOW NO IMPACT DAMAGE, OR DAMAGE OF ANY OTHER KIND OTHER THAN DETERIORATION OF THE PLASTIC ITSELF. THE VEHICLE IS VERY UNSAFE TO DRIVE AT NIGHT AND I WOULD ESTIMATE THE LIGHT OUTPUT AT MUCH LESS THAN 50% OF WHAT IT SHOULD BE. MY LOCAL DEALER WILL REPLACE THEM FOR A GRAND TOTAL OF $1,251.10 INCLUDING TAX AND LABOR BUT IT IS MY CONTENTION THAT THESE ITEMS ARE DEFINITELY SAFETY RELATED, AND ARE DEFINITELY SAFETY HAZARD. THEY SHOULD LAST THE LIFE OF THE VEHICLE, OR AT LEAST MUCH LONGER THAN THEY HAVE. I HAVE PHOTOGRAPHS OF THESE AVAILABLE TO EMAIL AND THERE IS AN INTERNET SITE IN THE MITSUBISHI FORUMS THAT REPORTS NUMEROUS OTHER COMPLAINTS DESCRIBED ALMOST IDENTICALLY. *TR

I OWN A MITSUBISHI 2003 OUTLANDER - THE HEATING COOLING KNOB IS VERY HARD TO TURN AND EVENTUALLY BROKE OFF - I SPENT OVER $300 TO FIX IT - THEY INSTALLED A $150.00 PART BUT SAID I WOULD NEED A MORE EXTENSIVE FIX TO GET THE KNOB TO TURN FROM HEATING TO COOLING. THAT WOULD COST OVER $1500 ALSO TO TURN IT I HAVE TO GET DOWN ON THE FLOOR AND PUSH ON A PART UNDER THE HEATING SYSTEM - THIS IS DANGEROUS WITH A RISK OF BURNS BECAUSE IT GETS HOT DOWN THERE. I FEEL THAT THE COMPANY SHOULD RECALL THESE CARS - NOT REALISTIC TO HAVE SUCH AN EXPENSIVEFIX FOR WHAT SHOULD BE A SIMPLE PROBLEM WITH A TIGHT CABLE . THEY KNOW ABOUT IT - OTHERS HAVE COMPLAINED . *TR

I HAVE A 2003 MITSUBISHI OUTLANDER WHICH I PURCHASED NEW. IT HAS NEVER BEEN IN AN ACCIDENT AND HAS BEEN KEPT IN A GARAGE WHEN PARKED. BOTH OF MY HEADLIGHTS HAVE SEVERE CRACKS AND NOW I HAVE MOISTURE INSIDE THE LIGHTS. *TR

MY MITSUBISHI OUTLANDER HEADLIGHTS ARE CRACKED AND HAZED, THIS IS NOT FROM NORMAL USE, THIS IS DEFECT IN THE MANUFACTURING OF THE HEADLIGHT ASSY. THEY HAVE CAUSED ME TO SLAM ON MY BRAKES 3 TIMES DUE TO POOR ILLUMINATION OF THE ROAD. I BELIEVE THAT MITSUBISHI SHOULD OFFER TO FIX THE HEADLIGHTS, OR OFFER A DISCOUNT, NOT $300 HUNDRED DOLLARS A PIECE TO REPLACE!!!!! *TR

THIS PERTAINS TO MY 2003 MITSUBISHI OUTLANDER (CURRENT MILEAGE 44732) AND WAS OUR FIRST ENCOUNTER WITH THIS POTENTIALLY DANGEROUS PROBLEM. MY WIFE WENT TO THE POST OFFICE IN TOWN TO MAIL A PACKAGE. AFTER STOPPING IN THE PARKING SPOT, THE CAR SURGED (ACCELERATED) BEFORE SHE COULD SHIFT INTO PARK AND STRUCK THE LANDSCAPING WALL AT THE POST OFFICE. FORTUNATELY, NO ONE WAS WALKING ON THE SIDEWALK BETWEEN THE FRONT OF THE CAR AND A HEDGE IN FRONT OF THE WALL. ALSO, FORTUNATELY, ONLY DAMAGE WAS DONE TO THE CAR. AN INCIDENT REPORT HAS BEEN FILED WITH THE LOCAL POLICE, MITSUBISHI, AND 21ST CENTURY INSURANCE. THE CAR IS CURRENTLY IN MY GARAGE. *TR

THERE HAVE BEEN NO REPAIR ISSUES WITH THIS 2003 OUTLANDER. THERE HAVE BEEN NO COOLANT OR ANY FLUID LEAKS WITH THIS CAR. THE CAR SUDDENLY FILLED WITH SMOKE ON THE PASSENGER'S SIDE; SMOKE POURED FROM THE ENGINE; PRIOR TO THAT - FIVE MINUTES EARLIER THE CHECK ENGINE LIGHT WENT ON AND ACCELERATION WAS DIFFICULT; THERE WAS AN ODD ODOR AS WELL AS A METAL ON METAL TYPE SOUND. 911 WAS CALLED AS THE SMOKE WAS HEAVY. THE DEALERSHIP WAS ASKED BY MITSUBISHI CORP. TO PULL THE ENGINE TO DETERMINE IF IT WAS THE ENGINE - WARRANTIED OR OUR FAULT- A RADIATOR ISSUE. THIS WAS A 400$ COST TO US UNLESS THEY FOUND IN OUR FAVOR..THIS WAS IN ADDITION TO THE 80$ DIAGNOSTIC FEE TO BEGIN THE PROCESS. THEY ARE SAYING THAT THERE IS A CRACK IN THE RADIATOR WHERE THE ENGINE CONNECTS BY A HOSE TO THE RADIATOR AND THAT IT IS "NORMAL" WEAR. THERE IS NOTHING NORMAL ABOUT THIS. IT WAS IMMEDIATE AND CATASTROPHIC. THEY WANT TO CHARGE US $3600 TO REPLACE THE ENGINE. I AM ARGUING THAT THIS IS OBVIOUSLY A DEFECT - WE HAVE 100,000/7 YEAR WARRANTY ON THE DRIVETRAIN. MY CAR ONLY HAS 57,000 MILES AND HAS RUN PERFECTLY FINE UP TO LAST WEEK. I HAVE ASKED MITSUBISHI TO RECONSIDER AND HAVE BEEN PROMISED AN ANSWER BY A CASE MANAGER BY CLOSE OF BUSINESS TOMORROW -6/25. I HOLD LITTLE HOPE THAT THEY WILL COVER THE COST OF AN ENGINE YET I FEEL THAT THE WAY IN WHICH THE ENGINE OVERHEATED AND THEN DIED IS NOT ALL NORMAL FOR A CAR WITH SUCH LOW MILEAGE AND ONE WHICH HAS NO HISTORY OF REPAIRS. WE NEVER RECEIVED A RECALL NOTICE ON A RADIATOR FAN CONTROL PART AND WONDER IF THAT IS WHAT CAUSED THIS SERIES OF EVENTS TO OCCUR. IF SO, ARE THEY NOT RESPONSIBLE FOR THE REPAIR? I CURRENTLY HAVE ONLY FOUR PAYMENTS LEFT ON THE CAR FOR A TOTAL OF A BIT UNDER 2000$. THE DEALERSHIP TOLD ME THAT WITHOUT REPLACING THE ENGINE, THEY COULD ONLY GIVE ME 500$ TOWARD A TRADE! I WOULD APPRECIATE YOUR INTERVENTION AND HELP. *TR

TL*THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. ONE YEAR AFTER PURCHASING THE VEHICLE SHE HAD TO REPLACE THE ENGINE, RADIATOR, GASKETS, AND WATER PUMP. SHE IS CURRENTLY UNABLE TO DRIVE THE VEHICLE. THE MANUFACTURER ADVISED HER THAT THE COOLANT FAN WAS REPLACED TWICE PER THE RECALL WITH THE PREVIOUS OWNER. THEY ALSO STATED THAT SINCE THE WARRANTY EXPIRED SHE COULD NOT RECEIVE A FREE REMEDY. NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 67,500.

WHEN SLOWING DOWN AND THEN ACCELERATING AT ABOUT 35MPH, THE TRANSMISSION DOWNSHIFTS HARD, JERKING THE CAR FORWARD HARD AND CAUSING ONE OF THE REAR CV JOINTS TO POP. THE DEALER SAID THERE WASN'T ENOUGH OCCURRENCES OF IT HAPPENING TO WARRANT ANY INSPECTION OR REPAIR. THEY CALLED IN A MITSUBISHI REP AND HE CLAIMED TO NEVER FEEL OR HEAR THE PROBLEM EVEN THOUGH THE SERVICE TECH DID. *TR

TL*THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. WHILE DRIVING AT AN UNKNOWN SPEED, SMALL STONES FELL OFF OF ANOTHER VEHICLE AND STRUCK THE SUNROOF OF THE CONTACT'S VEHICLE. AS A RESULT, DEBRIS AND GLASS SHATTERED INSIDE OF HER VEHICLE. TWO PASSENGERS WERE MODERATELY INJURED. IN ADDITION, WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ROLLED OVER WITHOUT AN IMPACT OR CRASH OCCURRING. THE VEHICLE WAS TOWED TO THE DEALER, BUT THEY COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 100,000. UPDATED 6/18/09 *CN THE CONSUMER STATED THE SUN ROOF WAS NOT TEMPERED. UPDATED 06/22/09. *JB

TL* THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT WHILE PARKED THE CONTACT NOTICED THE TEMPERATURE CONTROL KNOB WAS DIFFICULT TO TURN. THE COTACT MENTIONED THAT AFTER SOME TIME THE KNOB DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

I AM HIGHLY UPSET ABOUT OUR 2003 MITSUBISHI OUTLANDER. WE TAKE VERY GOOD CARE OF OUR CAR. THE HEATER KNOB WAS HARD TO TURN FROM HOT TO COLD AND EVENTUALLY BROKE. I WENT IN TO VIVA MITSUBISHI AND THE INFORMED ME THAT THERE WAS A DEFECT ON THE OUTLANDERS AND LANCERS. THEY HAVE NOT RECALLED THE CARS TO FIX THIS PROBLEM. THEY ALSO INFORMED THAT IT WOULD COST $1300 TO FIX IT. WE DON'T HAVE THE MONEY TO FIX IT. I HAVE TO LITTLE BOYS AND IT GETS COLD HERE AND MY BOYS HAVE TO FREEZE. ALSO, WHEN WE NEED TO DEFROST THE WINDOWS, WE CAN'T CHANGE THE TEMP AND IT DOESN'T WORK. THIS IS A HUGE SAFETY HAZARD FOR US. I CAN'T BELIEVE MITSUBISHI IS WILLING TO PUT OUR LIVES, EVEN CHILDREN'S LIVES, IN DANGER ALL BECAUSE THEY WON'T RECALL THIS PART. *TR

THE TEMPERATURE KNOB ON THE MITSUBISHI OUTLANDER 2003 IS VERY DIFFICULT TO TURN ON FOR HEAT. SOMETIMES I CAN'T GET IT TO MOVE AT ALL, AND I HAVE TO DRIVE IN THE COLD. I SUFFER FROM ARTHRITIS, AND THIS MAKES IT VERY DIFFICULT FOR ME TO DRIVE AS MY FINGERS FREEZE-UP IN THE COLD WEATHER. *TR

TL*THE CONTACT OWNS A 2003 MITSUBISHI OUTLANDER. ON TWO DIFFERENT OCCASIONS, THE TIRES FLATTENED DUE TO THE VALVE STEMS. THREE OF THE VALVE STEMS WERE REPAIRED AT $20 EACH, AND THE FIRST VALVE STEM WAS FREE. NHTSA CAMPAIGN ID NUMBER 08T018000 (TIRES:VALVE) WAS REFERENCED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

I OWN A 2003 DIAMANTE WITH ABOUT 60,000 MILES ON IT. MY WINDOWS CONTINUALLY FOG UP WHILE DRIVING OR PARKED AND THE DEFROSTER/VENTS DOES NOT ELIMINATE THE FOG AT ALL, MAKING DRIVING VERY DIFFICULT AND DANGEROUS ESPECIALLY IN RAINY WEATHER AND DURING THE NIGHTTIME. THE SMELL OF ANTIFREEZE IS EXTREMELY STRONG INSIDE THE VEHICLE. I HAD A PROBLEM WITH MY TRANSMISSION SHIFTING AND THE LIGHT AROUND THE "N" ON THE INSTRUMENT PANEL WAS FLASHING. THE MECHANIC SAID MY HEATER CORE WAS LEAKING COOLANT ONTO THE TRANSMISSION CONTROL MODULE CAUSING IT TO MALFUNCTION. I WAS TOLD THAT EVEN THOUGH I PAID FOR AND HAVE AN EXTENDED WARRANTY ON THIS VEHICLE IT WOULD NOT BE COVERED BECAUSE THE HEATER CORE LEAKING IS WHAT CAUSED THE TRANSMISSION CONTROL MODULE TO FAIL. THE HEATER CORE WAS REPLACED ALONG WITH THE CONTROL MODULE AND THE RELAY WITH A COST OF OVER 2,500 DOLLARS. IT SEEMS LIKE A PROBLEM LIKE THIS THAT IS EXTREMELY COMMON IS THESE VEHICLES, CREATES SAFETY AND HEALTH HAZARDS, AND VERY EXPENSIVE TO FIX SHOULD BE RECALLED AND COVERED UNDER WARRANTY. *TR