NHTSA Campaign Number
10V252000
ELECTRICAL SYSTEM:WIRING
Reported to NHTSA: October 6, 2010
Defect Description
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.
Safety Consequence
THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.
Remedy
VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
What This Recall Page Shows
This page summarizes a single NHTSA recall campaign, including the defect description, safety consequence, and manufacturer's remedy. The affected vehicles listed below are the make/model/year combinations tracked in our database — this is not a VIN-specific result. To check whether your individual vehicle is covered by this recall, enter your 17-digit VIN at nhtsa.gov/recalls. Click any vehicle below to view its full safety profile.
Affected Vehicles (1)
| Year | Make | Model |
|---|---|---|
| 2009 | Volkswagen | Routan |
Browse Affected Vehicles
Affected Models
Affected Years
This recall information is from NHTSA campaign 10V252000. This site is not affiliated with NHTSA. Contact your dealer or call NHTSA's Vehicle Safety Hotline at 1-888-327-4236 for more information.